Blodgett COS-201 Parts List

COS-201
NON SELF FLUSHING COMBI OVEN
REPLACEMENT PARTS LIST
EFFECTIVE APRIL 20, 2012
The Company reserves the right to make substitution in the event that items specied are not available.
ERRORS: Descriptive and/or typographic errors are subject to correction.
44 Lakeside Avenue, Burlington, Vermont 05401 USA Telephone: (802) 658-6600 Fax: (802) 860-3732
BLODGETT OVEN COMPANY
www.blodgett.com
P/N 55190 Rev B
TABLE OF CONTENTS
CONTROL PANEL .....................................................................3
CONTROL PANEL - MEAT PROBE ......................................................4
DOOR COMPONENTS .................................................................5
ELECTRICAL COMPONENTS ..........................................................8
MOTOR COMPONENTS ............................................................. 10
INTERIOR COMPONENTS ............................................................11
STEAM GENERATOR COMPONENTS ................................................ 12
PLUMBING COMPONENTS .......................................................... 13
OVENS WITH SERIAL NUMBERS BEGINNING WITH:
201
HL
TO OBTAIN LITERATURE:
Email: literature@blodgett.com
or visit
www.blodgett.com
APRIL 20, 2012 2 COS-201
CONTROL PANEL
Ref. Part No. No. Description
3 * R0135 Socket, control lamp (For use on very early models) R0226 Indicator light, clear R1318 Indicator light, green 5 R0069 Mode Switch, 4 position, S2 6 R0364 Knob, mode switch w/ring 9 R0116 Knob, Thermostat 10 R1178 Thermostat, hot air w/knob & screws P5 12 R0115 Knob, Timer 13 R1182 Timer, 100 minutes w/knob & screws
APRIL 20, 2012 3 COS-201
CONTROL PANEL WITH MEAT PROBE
Ref. Part No. No. Description
4 R0364 Knob assy, on/off switch (Pre 1986) 5 R4622 Switch, on/off meat probe S5 (Pre 1986) R5686 Switch, on/off meat probe (After 1986) R0149 Thermostat, meat probe 240V (Pre 1986)
R6746 Retrot kit, meat probe controller (Pre 1986)
R5242 Controller only, meat probe (After 1986)
1 R5317 Retrot kit, sensor spiral to plug in type
R5315 Sensor, meat probe plug in type (After 1986) R5219 Panel jack, sensor plug in 15 R0038 Suppressor, arc meat probe C1
APRIL 20, 2012 4 COS-201
DOOR COMPONENTS
Ref. Part No. No. Description
1 R0015 Screw, socket countersunk 2 R0274 Catch, door (w/hardware) 3 R1009 Insert, plastic door catch
5 R1079 Washer, door handle, at (Pre 120198)
6 R1080 Spring disc, door handle (Pre 120198) 7 R0271 Washer, door handle (Pre 120198) 8 R0269 Nut, door handle hex (Pre120198) 9 R6899 Base mounting, door handle (Pre120198) 10 R1082 Cam door handle (Pre 120198) 11 R1083 Washer, door handle plastic (Pre 120198)
R0278 Retrot kit, door handle (After 120198)
R8150 Handle assy, door (After 120198) 13 R0042 Washer, door catch
Ref. Part No. No. Description
15 R0016 Screw, hex socket head cap, door catch 16 R0922 Roller catch, female (on oven) 17 R0923 Roller catch, male (on door)
18 R0280 Gasket, door 19 R2105 Gasket, door glass (per foot) 27 R0432 Gasket, transport cart seal (per foot)
R6979 Guard, door gasket 28 R1472 Rivets, 1/8” for window frame 29 R0225 Switch, door R1109 Grommet, door switch R0937 Pin, actuator on door
APRIL 20, 2012 5 COS-201
Retrofit Kit
R0278
DOOR HANDLE ASSEMLBY
MANUFACTURED AFTER 12/01/98
1
2
3
4
6
5
8
10
7
Ref. Part No. No. Description
1 R7889 Support, door handle 2 R1083 Washer, acetal 1.625 ID x 2.040 OD 3 R1082 Cam, door handle 4 R6899 Base, mounting 5 R1080 Spring, disc .8 ID x 1.6 OD
6 R1079 Washer, at .8 ID x 1.5 OD s/s
7 R7942 Screw, socket head 3/8-16 x 2-1/2” 8 R7867 Washer, nickle plated brass, .392 ID x 1 OD 9 R8149 Screw, set 3/8-16
10 R2292 Washer, at 3/8
11 R7888 Handle
11
9
Orientation of spring washer
APRIL 20, 2012 6 COS-201
Door Handle
Assembly
R8150
7
DOOR HANDLE ASSEMLBY
MANUFACTURED BEFORE 12/01/98
1
2
4
11
9
8
6
12
3
13
10
5
13
Ref. Part No. No. Description
1 R7889 Support, door handle 2 R1083 Washer, acetal 1.625 ID x 2.040 OD 3 R1082 Cam, door handle 4 R7944 Plate, latch mount 5 R1080 Spring, disc .8 ID x 1.6 OD 6 R7867 Washer, nickle plated brass, .392 ID x 1 OD 7 R7942 Screw, socket head cap 3/8-16 x 2-1/2”
8 R1079 Washer, at .8 ID x 1.5 OD s/s
9 3136 Bolt, hex head 1/4-20 x 3/4”
11 R0733 Washer, at 1/4 12 R8216 Nut, serrated ange hex 1/4-20
13 R7888 Handle
Orientation of spring washer
APRIL 20, 2012 7 COS-201
ELECTRICAL COMPONENTS
Ref. Part No. No. Description
R0046 Holder, fuse 1 amp R1581 Holder, fuse 2 amp R1581 Holder, fuse 3 amp push in type R0029 Holder, fuse 6 amp
6 R0293 Fuse, .5 amp ne wire
R5773 Fuse, 1 amp 600V FNQR1 R5774 Fuse, 2 amp 600V R0032 Fuse, 3 amp 300V SC3 R0043 Fuse, 3 amp KTKR3 R0030 Fuse, 6 amp KTNR6 8 R2506 Relay, time delay (Motor Start Delay) K7 9 R7652 Relay, time delay (Blinker) K6 10 R2506 Relay, time delay (Low Water) K4 11 R2506 Relay, time delay (Generator Fill) K5 R0143 Contactor, mechanical, air or steam, 240V, K2 K3, 60 amp
Ref. Part No. No. Description
R0154 Contactor, mechanical, air or steam, 240V, K2 K3, 30 amp R1571 Contactor, mercury, hot air or steam 14 R1586 Terminal block, grey power 15 R6988 Suppressor, contactor coil, C1 16 R0022 Sensor, temperature, steam P2 17 R1443 Controller, solid state steam P2 18 R9498 Buzzer T1 21 51692 Contactor, motor 208V, K1 51693 Contactor, motor 240V, K1 R5833 Protector, motor PKAM w/Manual Reset F3 23084 Cooling fan, axial M0572 Plug/cord, cooling fan
APRIL 20, 2012 8 COS-201
ELECTRICAL COMPONENTS
Ref. Part No. No. Description
1 R1573 Thermostat, Cooking Compartment F4 2 R0121 Thermostat, Too Hot To Steam, P1 3 R0118 Thermostat, Pre Heat Priority, P3 4 R0122 Thermostat, Quench, P4 13 R1586 Terminal Block, Power 14 R1586 Terminal Block, Power 17 R1178 Thermostat, hot air P5
APRIL 20, 2012 9 COS-201
MOTOR COMPONENTS
Ref. Part No. No. Description
1 R0092 Motor, 208/240V, 3ph R0079 Motor, 240V, 1ph R0081 Motor, 480V, 3ph R3025 Heat slinger, motor 3 R0037 Nut, hex motor mounting 4 R0039 Washer, toothed lock 5 R0231 Washer 6 R2328 Packing, motor shaft 8 R0232 Washer, blower wheel 9 R0233 Washer, toothed lock, blower wheel 10 R0034 Screw, hex, blower wheel 13 R1028 Blower wheel
APRIL 20, 2012 10 COS-201
INTERIOR COMPONENTS
Ref. Part No. No. Description
R0131 Interior lamp, complete 1 R1497 Gasket, lamp lens 2 R0133 Bulb, heat-resistant 3 R1496 Lens, lamp R1498 Lens assy, w/gasket R2212 Tool, new style light lens
Ref. Part No. No. Description
4 R0132 Socket, lamp 5 R3649 Element, hot air 208V R3650 Element, hot air 240V R3651 Element, hot air 480V 6 R0098 Washer, copper 7 R0099 Washer, toothed lock 8 R0100 Nut, hex
APRIL 20, 2012 11 COS-201
STEAM GENERATOR COMPONENTS
Ref. Part No. No. Description
R0207 Valve assy, decalcier inlet
1 R2768 Element Assy, Steam 208V 3kw R2771 Element Assy, Steam 240V 3kw R2770 Element Assy, Steam 480V 3kw 2 R0035 Nut, hex switch plate
4 R0733 Washer, at strap
5 R2814 Hose, steam outlet 1-3/8” ID (per foot) 6 R0082 Clamp, hose 7 R0118 Thermostat, Pre Heat Priority P3 R1480 Thermostat, high limit (snap disc) R2630 Thermostat, high limit (capillary bulb) 8 R0082 Clamp, hose 9 R2814 Hose, 1-3/8” ID (per foot) 10 R0207 Screw, hex socket head 11 R0207 Washer, spring
Ref. Part No. No. Description
12 R0207 Washer 13 R0207 Guide bar 14 R0207 Cover, plate aluminum 15 R0207 Handle, plastic, safety valve 16 R0207 Gasket 17 R0207 Thread insert 18 R0207 Cone, safety valve 19 R0207 Gasket 20 R0207 Valve body, safety
R8397 Level Switch Assy Retrot R0920 Plate, oat switch
15882 Nut, hex 1/4-20 level switch plate 22 1265 Washer 23 R0071 Nut, hex switch plate
24 R1491 Gasket, oat switch
APRIL 20, 2012 12 COS-201
PLUMBING COMPONENTS
Ref. Part No. No. Description
1 R1086 Elbow, tting
2 R1085 Washer, elbow 3 R0080 Clamp, hose 5 R5071 Fitting, hose 3/8” 9 R0068 Gasket 11 R3755 Gasket 12 R0062 Nozzle, quench R0061 Nozzle, quench 16 R0082 Clamp, hose 17 R0022 Sensor, steam controller P2 18 R2814 Hose, silicon 42mm (per foot) 22 R1672 Gasket, drain
APRIL 20, 2012 13 COS-201
PLUMBING COMPONENTS
Ref. Part No. No. Description
8 R0080 Clamp, hose
9 R1085 Elbow, tting 3/4” 10 R1086 Seal ring, elbow tting
11 R2812 Hose, 10mm (per foot) 12 R2812 Hose, 10mm (per foot) 13 R2812 Hose, 10mm (per foot) 15 R2812 Hose, 10mm (per foot) 17 R0068 Gasket 19 R3755 Gasket 20 R0062 Nozzle, quench R0061 Nozzle, quench 21 R2812 Hose, 10mm (per foot) 22 R2812 Hose, 10mm (per foot) 26 R0070 Foot, adjustable
APRIL 20, 2012 14 COS-201
PLUMBING COMPONENTS
Ref. Part No. No. Description
1 R1086 Sealing ring, elbow tting 2 R1085 Elbow tting
3 R0080 Clamp, hose 5 R1918 Nipple, 1/2” x 3/4” 7 R1918 Double nipple, 1/2” 8 R0075 Ball Valve 9 R2812 Hose, 10mm (per foot)
10 R1918 Holder, T-tting
Ref. Part No. No. Description
14 R0076 Elbow, generator drain valve 17 R2812 Hose, 10mm (per foot) 23 R2812 Hose, 10mm (per foot) R2522 Solenoid Valve, dual R2997 Solenoid Valve, Conversion kit single to double 27 R2567 Holder, double solenoid valve R2202 Boot, drain manifold connecting 2” R2207 Clamps, drain boot R11210 Pressure regulator
APRIL 20, 2012 15 COS-201
Loading...