Alpine CDA-9855-R Service manual
SERVICE MANUAL
TO ALPINE Home Page
RDS MP3/WMA CD Receiver
CDA-9855R
3 / 05-A
68E38380S01
Contents
- 3 -
CDA-9855R
Packing Assembly Parts List
Packing Method View
Specifications
5 , 6
Extension Cable
Adjustment Procedures
8 to 11
Block Diagram
Parts Layout on P.W.Boards and Wiring Diagram
Schematic Diagram
Terminal Voltage of IC/TR
Description of IC Terminal
Exploded View (Cabinet)
13 to 17
18 to 26
27 to 40
41 to 46
47 , 48
4
4
7
12
Exploded View (CD Deck Mechanism) (DP23S8DA)
NOTE : Due to continuing product improvement, specifications and designs are subject to
change without notice.
49
Packing Assembly Parts List
TO CONTENTS
- 4 -
CDA-9855R
Symbol SymbolDescription
Part No. Part No.
No. No.
101 15D00529K02 CASE,INNER 103-4 03A60836Y01 SCR,CUS 5X7 ZN A
102 15D01798K03 CARRYING,CASE
103-1 03S60820Y16 SCR,MCH 5X8 ZN A 104 09-02252Z01 ASSY,ANIC-0007-01A
103-2 03S60824Y01 SCR,WEV 1.7X4 ZN A 105 68-02278Z08 O/M AOEU AODL
103-3 36A02449K01 CAP,RUBBER(A) 106 97-02291Z01 ASSY,SBPF00001A
103-5
60T55630W01 BAT,MGN R03(NB)UM-4
Packing Method View
106
102
105
Description
101
BO
TTOM
Side
104
103
103
103
103
104
X1
103
103
-2
X1
-4
X1
X1
-1
X4
-3
-5
X1
106
X1
Specifications
< FM RADIO >
Intermediate Frequency ........................................................................................................................ 10.7±0.1MHz
Frequency Range ........................................................................................................................... 87.5 to 108.0MHz
Usable Sensitivity (30dB S/N, Mono, at 98.1MHz) ......................................................................................... 20.2dBf
-3dB Limiting Sensitivity (at 98.1MHz) ........................................................................................................... 20.2dBf
Residual Noise (Ref. 400Hz (narrow), at 98.1MHz) ...................................................................................... 30±10dB
S/N Ratio (at 98.1MHz) ......................................................................................................................... Stereo : 50dB
Mono : 55dB
Image Rejection (at 106.1MHz) .......................................................................................................................... 40dB
IF Rejection (at 90.1MHz) .................................................................................................................................. 60dB
Distortion (Input 60dBu, at 98.1MHz) ................................................................................................................. 1.0%
Frequency Response (Ref. 400Hz, at 98.1MHz) ................................................................................ 100Hz : 0±3dB
10kHz : -10±3dB
Stereo Separation (1kHz, at 98.1MHz) .............................................................................................................. 20dB
PS Sensitivity (at 98.1MHz) ............................................................................................................................ 36.2dBf
< MW RADIO >
Intermediate Frequency ....................................................................................................................... 1st : 10.7MHz
2nd : 450kHz
Frequency Range ............................................................................................................................. 531 to 1,602kHz
Usable Sensitivity (20dB S/N, at 999kHz) .......................................................................................................... 36dB
S/N Ratio (at 999kHz) ........................................................................................................................................ 44dB
Image Rejection (at 1,404kHz) .............................................................................................................. 2nd IF : 50dB
IF Rejection (at 603kHz) ........................................................................................................................ 2nd IF : 60dB
Distortion (at 999kHz) ......................................................................................................................................... 1.5%
Frequency Response (Ref. 400Hz, at 999kHz) .................................................................................. 100Hz : -3±4dB
2.5kHz : -5 +3/-5dB
< LW RADIO >
Intermediate Frequency ....................................................................................................................... 1st : 10.7MHz
2nd : 450kHz
Frequency Range ................................................................................................................................. 153 to 281kHz
Usable Sensitivity (20dB S/N, at 216kHz) .......................................................................................................... 42dB
S/N Ratio (at 216kHz) ........................................................................................................................................ 44dB
Image Rejection (at 270kHz) ................................................................................................................. 2nd IF : 50dB
IF Rejection (at 162kHz) ........................................................................................................................ 2nd IF : 50dB
Distortion (at 216kHz) ......................................................................................................................................... 1.5%
Frequency Response (Ref. 400Hz, at 216kHz) .................................................................................. 100Hz : -3±4dB
2.5kHz : -5 +3/-5dB
< CD SECTION >
System ....................................................................................................................... Optical (Compact Disc System)
Channel Balance (1kHz) ........................................................................................................ CD : TCD-782 : 0±3dB
MP3 : SCD-5100 (FOLDER4-128kbps) : 0±3dB
WMA : SCD-5100 (FOLDER10-128kbps) : 0±3dB
Distortion (1kHz) ........................................................................................................................ CD : TCD-782 : 0.1%
MP3 : SCD-5100 (FOLDER4-128kbps) : 0.1%
WMA : SCD-5100 (FOLDER10-128kbps) : 0.1%
CDA-9855R
TO CONTENTS
- 5 -
Frequency Response (Ref. 1kHz, 0dB) ....................................................................... CD : TCD-782 : 17Hz : 0±3dB
127Hz : 0±2dB
10.007kHz : 0±2dB
19.997kHz : -2±4dB
MP3 : SCD-5100 (FOLDER4-128kbps) : 17Hz : 0±3dB
127Hz : 0±2dB
10.007kHz : 0±2dB
19.997kHz : -2±4dB
WMA : SCD-5100 (FOLDER10-128kbps) : 17Hz : 0±3dB
127Hz : 0±2dB
10.007kHz : 0±2dB
19.997kHz : -2±4dB
S/N Ratio .................................................................................................................................. CD : TCD-782 : 85dB
MP3 : SCD-5100 (FOLDER4-128kbps) : 85dB
WMA : SCD-5100 (FOLDER10-128kbps) : 85dB
Separation (1kHz) .................................................................................................................... CD : TCD-782 : 55dB
MP3 : SCD-5100 (FOLDER4-128kbps) : 55dB
WMA : SCD-5100 (FOLDER10-128kbps) : 55dB
De-Emphasis (Ref. 1kHz, 0dB) ................................................................................ CD : TCD-782 : 4kHz : -20±3dB
16kHz : -20±3dB
< CD Deck Mechanism >
Test Disc ....................................................................................................................................................... TCD-782
RF Waveform Amplitude .......................................................................................................................... 1.2±0.5Vp-p
Quantity of Jitter ............................................................................................................................. Less than 30nsec
Measurement Angle Range ............................................................................................... Front and Rear : -15°~75°
Right and Left : ±45°
Laser Current ................................................................................................................................. Initial value ±5mA
(The initial value of laser current is indicated on the Flexible Cable.)
< Pickup >
Wave Length .................................................................................................................................................... 795nm
Laser Power .................................................................................................................................................. CLASS I
< GENERAL >
Power Supply ............................................................................................................................................... DC14.4V
Power Output (TCD-782 (1kHz, 0dB), T.H.D. 10%) / Impedance .................................................... 17W / ch / 4 ohm
Pre Output (at Vol. Max, TCD-782 (1kHz, 0dB), T.H.D. 1% or less) / Impedance ................ 4V±2dBV / ch / 10k ohm
Back Up Current (ACC-OFF After 1 minute) ....................................................................................................... 5mA
Dimensions (W x H x D) ................................................................................................ Chassis : 178 x 50 x 160mm
Nose : 188 x 58 x 24.6mm
Weight ................................................................................................................................................................ 1.6kg
NOTE : Due to Continuing product improvement, specifications and designs are subject to change without notice.
CDA-9855R
TO CONTENTS
- 6 -
Extension Cable
TO CONTENTS
- 7 -
*Always connect the Extension Cable when making checks of voltage and repair.
DVD Deck Mechanism
DP23S8DA
MAIN P.W.Board
1
0
1
B
C
CDA-9855R
CB104
(1)
CB501
(2)
CH4001
FRONT P.W.Board
(1) 01E29616S01
(2) 01V37775S01
CDA-9855R
TO CONTENTS
- 8 -
(3) Control Settings
TO CONTENTS
- 9 -
Power Switch .............................................. ON Band Switch .............................. FM/MW/LW
Fader Control ........................... Center Position T-CORR ...................................... Non Effect
Balance Control ....................... Center Position EQ ....................................................... FLAT
Treble Control .......................... Center Position DEMO ................................................... OFF
Bass Contro ............................. Center Position Others ................................................... OFF
MX ................................................... Non Effect
(4) Adjustment Procedures
Step Description
Signal Meter
Auto
1
Adjustment
(FM)
Connection
3
Figure
Signal Generator
87.5MHz,
(1)
(2)
(3)
(4)
26dBµ
(Mod. OFF)
87.5MHz,
26dBµ
(Mod. OFF)
87.5MHz,
21~23dBµ
(Mod. OFF)
87.5MHz,
26dBµ
(Mod. OFF)
Control
Dial
87.5MHz
87.5MHz
87.5MHz
87.5MHz
Test Point /
P.W.Board
Coordinates
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
Adjustment
Auto Adjustment:
After setting up of Signal Genarator,
short GND and TP501 (Pull-Down)
for 2~3 seconds.
Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.5±0.1V OK
(SPEC) TP002 : others 1.5±0.1V NG
NOTE : NG : Proceed same Auto
Adjustment of step (1)
under step (3).
Proceed same Auto Adjustment of step
(1) under step (3).
Proceed same Auto Adjustment of step
(1) under step (4).
CDA-9855R
Det Out-DC
OFFSET
2
Adjustment
(FM)
Signal Meter
Auto
3
Adjustment
(MW)
Figure
Figure 4
87.5MHz,
(1)
3
(2)
(3)
(1)
(2)
(3)
26dBµ
(Mod. OFF)
87.5MHz,
-20dB26 µ
(Mod. OFF)
87.5MHz,
-20dBµ
(Mod. OFF)
999kHz,
34dBµ
(Mod. OFF)
999kHz,
34dBµ
(Mod. OFF)
999kHz,
29~31dBµ
(Mod. OFF)
87.5MHz
87.5MHz
87.5MHz
999kHz
999kHz
999kHz
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
" DC OFFSET " displays after finishing
S-METER (FM) adjustment.
The SIGNAL GENERATOR output of
26dBu is lowered to -20dBu within
10 seconds.
When adjustment is finished,the
" DC OFFSET " display disappears.
Auto Adjustment:
After setting up of Signal Genarator,
short GND and TP501 (Pull-Down)
for 2~3 seconds.
Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.0±0.1V OK
(SPEC) TP002 : others 1.0±0.1V NG
:
NOTE NG : Proceed same Auto
Adjustment of step (1)
under step (3).
Proceed same Auto Adjustment of step
(1) under step (3).
(4)
999kHz,
µ
34dB
(Mod. OFF)
999kHz
TP002
(3-F)
TP501
(3-F)
Proceed same Auto Adjustment of step
(1) under step (4).
Step Description Connection Signal Generator Dial Control
TO CONTENTS
- 10 -
Test Point /
P.W.Board
Coordinates
CDA-9855R
Adjustment
4
Signal Meter
Auto
Adjustment
(LW)
Figure 4
(1)
(2)
(3)
(4)
(1)
216kHz,
34dBµ
(Mod. OFF)
216kHz,
34dBµ
(Mod. OFF)
216kHz,
29~31dBµ
(Mod. OFF)
216kHz,
34dBµ
(Mod. OFF)
216kHz
216kHz
216kHz
216kHz
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
TP002
(3-F)
TP501
(3-F)
Auto Adjustment :
After setting up of Signal Genarator,
short GND and TP501 (Pull-Down)
for 2~3 seconds.
Proceed same Auto Adjustment of step
(1) under step (2).
(SPEC) TP002 : 1.0±0.1V OK
(SPEC) TP002 : others 1.0±0.1V NG
NOTE : NG : Proceed same Auto
Adjustment of step (1)
under step (3).
Proceed same Auto Adjustment of step
(1) under step (3).
Proceed same Auto Adjustment of step
(1) under step (4).
Set up of Adjustment Mode :
Push KeyPOWER
at the same time.
+
FM ST
Separation
5
(Roll OFF)
Adjustment
Stereo Blend
6
Adjustment
(Lch)
Figure 5
Figure 5
98.1MHz, 72dBµ
(Mod. 400Hz,
(2)
Dev. 40kHz,
Stereo, 1kHz,
Lch only)
(3)
(1)
98.1MHz, 46dB
(Mod. 400Hz,
(2)
Dev. 40kHz,
Stereo, 1kHz,
Lch only)
(3)
(1)
µ
98.1MHz
98.1MHz
Audio Output
(RCA)
Audio Output
(RCA)
Push Key, andand
observe value of separation.
Select of maximum
separation.
(SPEC) : separation : more than 20dB.
Cancel Adjustment Mode :
Push
at the same time.
Set up of Adjustment Mode :
Push KeyBAND
at the same time.
Push
observe value of blend.
(SPEC) : Blend : 8±6dB.
Cancel Adjustment Mode :
Push
at the same time.
Set up of Adjustment Mode
Push
at the same time.
Keyand
+
KeyPOWER
+
Key, andand
+
KeyBAND
:
+
KeyBAND
7
Limitting
Adjustment
Figure 6
98.1MHz, 24dBµ
(2)
(Mod. 400Hz,
Dev. 40kHz)
(3)
98.1MHz
Audio Output
(RCA)
Push
observe value of limitting.
(SPEC) : Limitting : 3dB.
Cancel Adjustment Mode :
Push
at the same time.
Key, andand
+
KeyBAND
Step Description Connection Signal Generator Dial Control
TO CONTENTS
- 11 -
Test Point /
P.W.Board
Coordinates
CDA-9855R
Adjustment
8
Noise Level
Adjustment
Figure 6
(1)
(2)
(3)
98.1MHz,
72 --> -20dBµ
(Mod. OFF)
98.1MHz
Audio Output
(RCA)
Set up of Adjustment Mode
Push
at the same time.
Rotary encoder is turned and noise level
is adjustment.
(SPEC) : Noise Level : 30 10dB.
Cancel Adjustment Mode :
Push
at the same time.
+
+
:
KeyBAND
±
KeyBAND
Block Diagram
TO CONTENTS
- 12 -
Tuner unit
RF IF
AM
PLL
RDS Decoder
TUNER+B
(MP3 CD MECH)
Tuner on
OEM
Steering
DP23S8DA
Remote
MOTOR-DRIVER
Selector
SWD+3.3V
CD
VDD
Vol.1
I²C BUS
Main CPU
Tre/Bass
A-Mute
Nose DET
E-VOL
DSP
AI-NET
8V DET SW
Vol.2
DSP+5V
I/F
RESET
Nose PWR SW
4V AMP-8.5V
MUTE
DRIVER
Delay Circuit
Power cont
SYSTEM POWER IC
Batt-Det / VDD
PWR-ON / CD SERVO
TUNER ON / DSP+5V
MOTOR-DRIVER
ACC DET
MOTOR-DRIVE
CD-SERVO
Buffe
Buffer
Buffe
Buffer
Buffe
Buffer
PWR ON
Pre IN/OUT Selector
Slide SW
MUTE
MUTE
MUTE
Power IC
IN INT
DIMMER
PWR ANT
Rem SW
CDA-9855R
OEM SUB
DISPLAY
READY I/F
Front
Rear
BATT
IN-INT
DIMMER
ACC
P.ANT
O.REM
Ai-Net
DIN
Pre-OUT
Sub Woofer
Pre-OUT
Front
Pre-OUT
Rear
POWER CONNECTOR
OELD
Controller
External
Memory
OELD
FRONT u-COM
Key
Matrix
Vhh+B
Rotary
Encoder
Nose
Lamp
Remote
Control
Nose
LED
AUDIO +B
LAMP +B
Vhh+B
FAN Control
FAN
Parts Layout on P.W.Boards and Wiring Diagram(1/5)
TO CONTENTS
- 13 -
CDA-9855R
1
2
MOTOR,F2510CT-12UCV
(FAN MOTOR/12V-40mA)
3
To FRONT P.W.Board
4
15
ASSY,UNIZON CONN 93R
5
ANT001
ASSY,ANT CABLE 9851R
BLK
WHT
(ANT)
To TUNER Chassis
M802
RED BLK
M
(CH401)
214
A
CH501
(Top Side View)
SHIELD
115
1
To TUNER Chassis
YEL
2 1
To CB802
15 1
MAIN P.W.Board (Component Side View)
2
B
E
B
E
C827
C239
C823
R825
Q801
Q387
R852
IC306
C306
IC305
E804
R803
R804
R835
C308
C240
IC204
E387
Q388
51
ZD805
R373
C349
C352
E227
R218
C227
R581
CB501
15
14
23
CB802
12
Q818
EB
C357
R360
R363
R217
C236
C235
C225
R577
R575
R388
E328
E319
E327
C233
C232
C231
C229
C228
E806
IC307
R305
C318 C315
R210
R209
1
R330 R327
C210
C208
R331
E205
E204
E215
L502
E315
E323
IC301
E203
E213
R600
Z501
R598
R588
To CB502
-4
E202
E206
E218
IC507
L503
2
R381
6
R370
C047
L007
Q815
R824
To CB501
C831
8
31
Q302
ANT001
L006
C046
C045
20
1
TU001
C015
C016
C019
1
5
32
R847
E811
R382
R371
R369 R368
SA001
L001
B
E
6
R385
644
R378
VT001
E005
R848
Q304
L002
IC002
ZD803
1
JK301
R386
R380
R379
E001
E002
L003
Q814
R383
R372
R023
E501
C366
E
Q003
B
E004
E805
R022
34
7
3113
Q303
46
C367
R015
C012
E003
E502
R384
R377
R376R375 R374
C371
C370
B
E
R220
XL001
1235
ZD504
C510
5
C368
E
Q004
B
Q005
Z001
C237
R219
Q201
B
E229
Q501
R555
EB
Q502
R556
C513
1
IC803
2
Q805
C816
C815
R826
C804
C801
C825
R832
R831
C369
B
Q389
E
E388
R367
C355
E325
R347
C337
E326
R366
C354
E320
E228
E
EB
Q503
R557
R827
ZD802
R391
C305
C307
1463
R337
R333
E503
IC503
CB502
C363
C362
E316
SW601
C325
C321
E208
E209
E219
C526
21
21
C364
C365
E318
6
E324
C213 C212
C214
E211
R511
R512
R502
R506
R507
R513
B
E
BLU(VHH+ B)
SHIELD
E317
E207
C242
C215
E504
Q601
24
25
D395
D393
E390 E389
712
1
E220
XL201
C211
C209
IC202
C219
C221
C220
E212
R528
R527
IC501
1
3
GRY
C389
R541
R542
XL501
D392
SW301
C218
R529
R530
IC502
Z205
E217
R212
R500
R546
E814
D391
C222
C224
R548
R566
R565
16
8
D809
C845
D802
R801
C837
E812
TH501
IC201
E214
E201
E105
R508
Q816
1
5
VT120
ZD502
C223
R629
R643
E221
R630
R644
R631
R645
R632
R646
R304
R633
R647
R201
1
3
E225
D105
E103
D104
E102
E101
R559
R547
R558
R560
D505
R561
R519
R570
R569
1
54
IC508
C525
3
C512
C511
R601
From DP-S MAIN P.W.Board (CB104)
LD602 LD601
9
C522
ZD503
L501
ZD501
C517
ZD804
32
To CB101
CB803
1
D806
CB102
Q817
B
R850
E
C834
IC510
R637
EB
Q810
EB
Q811
CB201
C809
CB101
E104
R849
R860
R635
R636
CB801
3
2
R101
R102
R103
R104
R105
R107
C103
21
C802
15
Q101
IC505
5431
RA503
R834
R833
ZD806
122
JK501
IC102
E602
XL502
ZD801
1
2
DIN801
3
B
Q509
D501
E
F801
E606
Q515
D502
Z101
Q516
D503
C518
R614
E603
R607
R617
IC604
D504
E604
R610
E601
E605
R606 R605
BZ801
R509
R844
ZD807
EB
Q813
Q812
C828
BE
C835
C811
E801
IC802
C807
C810
C808
To CB801
21
ASSY,WIRE 2P 9835
BRN
WHT
MOTOR,LOAD FF-050SK
M
(NOSE MOTOR/7V-370mA)
R532
R536
3512
R609
Q826
3641
R504 R503
Q517
B
R612
C604
IC602
1345
IC601
E
R811
R810
R809
R808
R807
R806
R604
87
R537
R545
R573
R572
E
R613
R619 R618
R616
Z601
5431
B
Q827
R603
SW602
3512
SW603
CH801
M801
R620
Q602
3
4
Z602
61
R621
R622
R623
ASSY,AMP LINK55A
ET601
SHIELD
PNK
SHIELD
-1
(12C CLOCK)
91
To CB601
CB601
-3
71
SHIELD
WHT(-9V)
To CB201
RED(+9V)
BLK
YEL
RED
(AMP DATA)
(AMP POWER GND)
ORG
(1 2C D ATA)
SHIELD
YEL(VHH ON+B)
GRN(DVCC)
ORG(AUDIO +B)
GRY(1)
GRY(2)
BOX P.W.Board
(Component Side View)
E911
E903
E904
L903
BLU(VHH+ B)
GRN(DVCC)
GRY(2)
GRN
Q910
C904
L902
SHIELD
SHIELD
YEL(VHH ON+B)
E905
WHT
(H/U GND)
BLK
GRN
(H/U CLOCK)
(H/U DATA)
GRN
L910
C911
E910
CB901
E901
L901
C901
To CB901
1 9
-2
SHIELD
WHT(-9V)
RED(+9V)
GRY(1)
ORG(AUDIO +B)
ET601
ASSY,AMP LINK55A
E
B
L911
C902
A
Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern
FGEDCB
Parts Layout on P.W.Boards and Wiring Diagram(2/5)
TO CONTENTS
- 14 -
CDA-9855R
1
2
4
5
3
R534
R574
C602
R553
R533
R582
D602
IC605
C605
D601
Q514
C601
R552
IC506
R611
R840
C520
R615
R854
R535
R550
R608
R839
C521
R589
D808
R549
2253
135
R856
R857
R599
R114
Q803
R590
R112
B
E
R591
C603
C516
C508
C519
C507
R829
1
R584
R595
E
B
C506
R830
C824
L101
Q807
R837
Q821
R855
R596
Q508
C102
E
B
TP515
R585
2
Q822
135
Q102
D807
Q809
R841
D803
R116
R842
C839
R828
IC804
R586
R845
253
1
2
135
MAIN P.W.Board (Foil Side View)
C836
D389
R221
Z203
C243
R520
1
Q504
253
TP507
TP513
TP512
R544
C504
Z202
R521
R592
C503
R392
C217
R526
R522
R524
R525
R213R211
R523
R587
C216
R583
TP509
D388
TP501
TP503
R514
TP510
C502
R518
R516
R517
R515
R624
C523
TP511
R593
R501
R551
R602
C205
Z201
R505
TP502
Z204
R510
R005
C826
C803
Q824
Q825
C843
C105
R838
R862
TP104
TP105
C844
TP103
TP106
3
R108
R111
R113
C101
IC101
1
TP102
R109
TP101
C841
C838
C840
R843
C847
R563
R543
C387
R303
R562
TP504
C388
R540
TP506
R594
TP508
R539
TP505
D394
D390
R320
R332
C330
R554
R335
C515
C505
R329
IC302
R323
R564
R642
R307
TP514
C514
C524
R576
R580
R324
R208
C821
C817
2
135
R314
R306
C238
R203
R204
R202
IC509
C822
Q819
R851
C201
R538
C202
C203
C207
C230
R206
R578
R641
R640
R531
C805
C820
R387
D387
R389
R205
R579
R802
C833
R321
R357
R216
C206
C226
C846
C818
2153
R836
R362
R352
R350
R358
R215
R567
R390
Q823
C302
C204
Q806
C301
C234
R571
R805
R322
1
D804
R349
R341
R339
R345
C241
IC504
R628
R568
D805
R365
D303
C003
IC001
B
Q002
E
C002
R008
1
3
R026
C009
R017
R027
C026
R028
R025
C023
C832
C014
45
C001
Q001
C006
R014
R002
R024
C020
C842
D301
TP001
R001
C027
C004
TP002
C008
R003
R004
C017
R861
C007
R007
C018
C022
C028
C030
C032
C036
D001
C029
R006
C031
C005
C033
C034
C035
TP002
TP501
BOX P.W.Board
(Foil Side View)
C913
R918
D900
D910
S
C905
4
IC910
C903
13
5
IC901
C910
E
SD901
R914
R913
R912
R911
ZD901
E
B
Q912
B
Q911
R910
R915
C912
R909
R908
R917
TH910
R916
R919
D801
B
Q808
D302
E
R325
3512
Q802
C806
R016
C013
C010
R029
C024
C025
R030
C509
3
A
Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern
FGEDCB
Parts Layout on P.W.Boards and Wiring Diagram(3/5)
TO CONTENTS
- 15 -
CDA-9855R
1
2
4
5
3
SW4006
SW4009
SW4010
Q4027
R4206
R4051
SW4011
LD4009
LD4003
TP4003
R4217
R4171
C4019
C4017
R4219
R4238
R4044
R4247
LD4008
LD4002
R4150
R4191
R4050
LD4025
LD4051
LD4027LD4028
E
B
R4052
R4251
R4218
R4097
R4053
SW4007
R4153
LD4026
R4152
R4154
E
R4074 R4205
SW4008
E
B
Q4021
LD4024
LD4023
R4222
IC4005
LD4001
R4049
R4070
B
Q4009
Q4008
B
E
R4023
R4237
R4221
R4226
SW4005
LD4010
R4046R4047R4048
R4146
LD4015
LD4019LD4020
R4062
LD4022
LD4018 LD4017
SW4012
LD4052
TP4002
C4027
C4018
R4224
R4223
R4184
R4188
IC4004
From OELD P.W.Board (CB4504)
SW4014
SW4027
CB4008
To CB4008
Z4004
R4172
Z4003
R4240
R4187
R4185
R4169
R4228
R4020
To CB4001
LD4016
LD4021
81
R4174
C4022
FRONT P.W.Board (Component Side View)
4
IC4002
1
R4151
R4055
R4149
R4056
LD4013
LD4006
R4042
8
1
3
2
C4002
LD4005
LD4012
R4060
SW4015SW4017
LD4029
SW4028
B
R4307
E
B
Q4002
R4001
B
E
Q4004
R4192
R4087
R4235
R4015
R4104
R4086
R4085
R4100
R4236
R4173
R4081
R4212
R4014
C4012
LD4030
R4099
R4103
R4102
R4101
RA4027
R4255
RA4006
R4256
R4249
ASSY,SMK010001B (Top Side View)
SW4004
LD4011
LD4004
FRONT P.W.Board (Foil Side View)
R4301
R4302
CB4001
R4229
R4267
C4025
R4181
R4178
R4179
IC4008
R4177
R4180
R4182
Z4002
R4306
TP4005
R4183
C4030
R4215
R4214
L4003
RA4007
130
R4303
R4304
R4305
TP4006
TP4004
R4225
R4211
C4032
R4310
TP4009
IC4011
L4002
RA4023
XL4001
RA4003
R4227
C4015
C4010
R4019
R4017
RA4022
TP4007
R4244
R4246
C4031
C4039
R4245
R4018
RA4020
RA4002
TP4001
C4035
R4005
R4003
Z4001
Q4001
TP4010
B
C4005
C4004
R4109
R4108
Q4019
E
B
R4112
R4113
R4114
Q4015
E
B
E
C4038
R4002
B
Q4017
E
C4016
C4036
54
B
E
Q4003
R4006
R4105
C4037
IC4012
31
D4005
R4243
45
R4242
31
C4040
L4001
D4002
C4029
R4004
R4094
R4266
R4021
C4001
R4170
C4033
R4193
R4199
D4012
D4017
RA4026
RA4009
R4250
IC4001
R4130
R4131
R4132
R4198
R4254
R4253
R4252
R4257
R4259
R4258
R4265
LD4031LD4032
R4264
SW4029 SW4030
R4054
C4011
C4041
13
C4044
C4042
R4106
R4107
E
Q4020
B
D4018
45
IC4010
E
B
R4209
R4090
C4043
Q4018
D4011
D4001
R4110
R4111
R4013
R4012
R4011
R4009
CH4001
R4059
D4003
R4010
C4003
R4008
R4007
D4004
Q4028
13
Q4029
54
To CH4001
1 8
159
To ASSY, UNIZON CONN 93R
Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern
R4118
R4079
R4093
R4239
R4035
R4028
R4129
R4194
D4013
R4197
R4204
D4016
RA4008
R4092
R4034
R4200
D4015
RA4024
RA4025
R4220
R4022
R4309
R4263
R4196
D4014
R4308
R4043
R4202 R4203
RA4014
LD4007
R4071
Q4016
B
E
R4201
R4195
SW4013
LD4014
R4025
A
FGEDCB
Parts Layout on P.W.Boards and Wiring Diagram(4/5)
TO CONTENTS
- 16 -
1
OELD P.W.Board
(Component Side View)
53
2
3
D
R4510
R4508
R4509
C4506
R4512
R4532
C4510
C4504
C4514
C
R4501
C4513
R4533
R4529
R4516
ZC4501
R4514
R4515
C4512
R4534
C4511
R4502
R4503
R4504
C4503
R4505
R4506
R4535
R4536
CB4504
C4505
C4509
R4511
R4531
DC
To
35
341
To
C
35 53
D
ZC4501
ASSY, UEL101
(Bottom Side View)
CDA-9855R
4
5
A
To CB4504
30 1
From FRONT P.W.Board (CB4001)
C4507
C4501
C4502
C4508
C4515
134
Orange Color Pattern:Component Side Pattern
Blue Color Pattern:Foil Side Pattern
FGEDCB
Loading...