Whirlpool HB 520 WF, HB 520 AN INSTRUCTION FOR USE

DÅTID HGA4K HOB INSTRUCTIONS Destination

DE AT

1. Removable panstand grids 2-3. Medium burners

4. Large burner

5. Small burner

6. Medium burner control knob

7. Medium burner control knob

8. Large burner control knob

9. Small burner control knob

10. Electric ignition button

Symbols

Shaded circle Tap closed

Large flame Maximum opening/delivery

Small flame

HOB DIMENSIONS (mm)

Operation of burners with safety device and electric ignition

To light one of the burners:

• Press the relative knob and turn it anti-clockwise to the large flame setting .

• At the same time, press the button with the star . The spark plug gives out a spark that causes the burner to ignite.

• Once the burner is lit, keep the knob pressed for about 10 seconds.

• Release the knob.

If the burner does not ignite, repeat the operation.

Note:

- Should particular local conditions of the delivered gas

make the ignition of the burner difficult, it is advisable to repeat the operation with the knob turned to the small flame setting .

The burner safety system serves to prevent the emission of gas if the flame should be extinguished accidentally (draughts, interruptions in gas supply, dousing with liquids, etc.).

Minimum opening or reduced delivery

INJECTORS TABLE II2H3B/P (AT) II2ELL3B/P (DE)

Type of gas used Type of

NATURAL GAS (Methane) G20

* NATURAL GAS (Methane) G25

LIQUID PETROLEUM GAS (Butane) G30 (Propane) G31

Type of gas used Appliance model Total rated heat

G20 20 mbar 4 gas 7.30 695 l/h 9.52 * G25 20 mbar 4 gas 7.30 809 g/h 8.187 G30/G31 50 mbar 4 gas 7.30 531 g/h 30.94

burner

large medium small

Injector marking

Y 115

H2 98

X 72

F3 134

Y 98

F1 77

S 75

M 57

H2 45

Rated heat capacity kW

3.00

1.65

1.00

3.00

1.65

1.00

3.00

1.65

1.00

capacity kW

Rated consumption

286 l/h 157 l/h

95 l/h

332 g/h 183 g/h 111 g/h

218 g/h 120 g/h

73 g/h

Total rated consumption

Reduced heat capacity kW

0.60

0.35

0.30

0.60

0.35

0.30

0.80

0.50

0.40

Gas pressure (mbar)

min. nom. max.

17 20 25

18 20 25

42.5 50 57.5

Air necessary (m combustion of 1 m

) for the

of gas

* NOT FORESEEN FOR AUSTRIA ELECTRIC SUPPLY: 230V ~ 50Hz

BEFORE USING THE COOKTOP

These instructions are only valid for above mentioned Country destinations and also on the appliance.

• Keep the packaging material (plastic bags, polystyrene

parts, etc.) out of the reach of children, as they are potentially dangerous.

• Use a proprietary detergent to clean the stainless steel hob

and remove any grease and food deposits. Before using the hob, be sure to remove any adhesive labels.

• Check whether the cooktop has been damaged during

transport.

• Ensure that the installation and gas/electrical

connections are performed by a qualified technician, following the manufacturer's instructions and in compliance with current local safety regulations.

NOTES: In case of installation of a hood above the cooktop, please refer to the hood instructions for

the correct distance.

5019 619 01119/B

To get full satisfaction from the hob, please read these instructions carefully and keep them for future consultation.

SUGGESTIONS FOR ENVIRONMENT PROTECTION

Packing

The packaging material is 100% recyclable and marked with the recycling symbol ( ).

Products

This appliance is marked according to the European directive 2002/96/EC on Waste Electrical and Electronic Equipment (WEEE). By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health.

The symbol on the appliance or accompanying documentation indicates that this product should not be disposed of as unsorted municipal waste but must be taken to

a collection point for the treatment of WEEE. Dispose of in accordance with local standards governing waste disposal.

For further information on the treatment, recovery and recycling of this appliance, contact your competent local authority, the collection service for household waste or the shop where you purchased the appliance.

HB 520

PRECAUTIONS AND GENERAL ADVICE

CARE AND MAINTENANCE

• Before any cleaning or maintenance operation,

disconnect the cooktop from mains power supply.

• The use of a gas appliance produces heat and

humidity in the room. Ensure that the room is well ventilated, or install an extractor hood with exhaust duct.

• In case of prolonged use, additional ventilation may be

needed (opening a window or increasing the extraction force of the hood).

• Keep children away from the cooktop when it is in

use and when its has just been switched off.

• This appliance is not intended for use by persons

(including children) with reduced physical, sensory or mental capabilities or lack of experience and knowledge unless they have been given initial supervision or instruction concerning use of the appliance by a person responsible for their safety.

• After use, ensure that the knobs are in position

(off), and close the main gas delivery valve or the gas cylinder valve.

• Caution: the lid (where present) might break if

overheated. Before closing it, make sure that all the burners are off.

ENERGY SAVING TIPS

• The cooktop is equipped with burners and/or a hotplate

with different diameters. Use pots and pans whose bottom diameter is equal to that of the burners and hotplate, or slightly larger.

• Only use flat-bottomed pots and pans.

• The pots and pans must not overlap the control panel.

Burner Diameter of container

• Warning: The protective rubber feet on the panstand

grids represent a choking hazard for young children. After cleaning the panstand grids, please ensure that all the rubber feet are correctly fitted.

Declaration of conformity

• This cooktop has been designed, constructed and

marketed in compliance with:

- safety requirements of EEC Directive “Gas” 90/396;

- safety objectives of the “Low Voltage” Directive 2006/95/CE (which replaces 73/23/CEE and subsequent amendments).

- protection requirements of EEC Directive “EMC” 89/336;

- requirements of EEC Directive 93/68.

• This cooktop is suitable for contact with foodstuffs

and complies with EEC (CE) Regulation n. 1935/2004.

• This cooktop (Class 3) has been designed to be used

only for cooking. Any other use (such as heating a room) is improper and dangerous.

• If possible, keep the container covered when cooking.

• Cook vegetables, potatoes, etc. with a small amount of

water in order to cut down cooking time.

• A pressure cooker allows you to save even more energy

and time.

NO!

Cleaning the cooktop surface, panstand grids and control panel

• Before cleaning the cooktop, disconnect it from

mains power supply and wait until it has cooled down.

• Wipe with a cloth moistened with hot water and soap or

diluted liquid detergent.

• Do not use abrasive or corrosive products, chlorine

products or steel wool.

• Do not use vapour cleaning appliances.

• Do not use flammable products.

• Do not leave acid or alkaline substances, such as vinegar,

salt or lemon juice, etc., on the cooktop.

Stainless steel surface

• Clean with a specific commercial product.

Note: if the cooktop is used continuously, the high temperatures produced by the flames may alter the colour of the surface near the burners.

Cleaning the burners

1. Raise the cap and remove it.

2. Extract the burner from its housing by pulling it up.

3. Soak the burner and the cap in hot water and liquid

detergent. (Do not wash into a dishwasher).

4. Rinse out and dry carefully.

5. Ensure that none of its openings is clogged.

6. Reposition the burner and cap.

TROUBLESHOOTING GUIDE

1. The burner fails to ignite:

• Is the main gas delivery valve open?

• Has the delivery of the town gas (methane) been suspended?

• Is the gas cylinder (liquid gas) empty?

• Are the openings of the burner clogged?

• Have the cap and burner been positioned correctly after

cleaning? (See paragraph “Care and Maintenance”.)

Note: to avoid damaging the electric ignition device, do not use it when the burners are not in their housing.

Cleaning the electric hotplate

The electric hotplate must be cleaned when it is lukewarm.

Wipe with a cloth moistened with water and salt, and polish with a cloth moistened with oil.

2. The burner fails to remain lit:

• Repeat the ignition operation, turning the knob to the

position with the small flame symbol .

3. The electric ignition device does not work:

• Is there a power failure?

Large (9,1 cm) Medium (6,4 cm) Small (4,5 cm) Triple crown (12 cm) Fish kettle (23 cm x 4,5 cm)

24 to 26 cm 16 to 22 cm 8 to 14 cm 24 to 26 cm 16 to 35 cm

AFTER SALES SERVICE

Before you call the After Sales Service:

1. Check the “Troubleshooting guide” above to see if you

can eliminate the trouble yourself.

2. Re-start the cooktop, to check whether correct operation

has been restored.

3. If the malfunction persists, call the After Sales Service.

Give the following information:

•type of malfunction;

•model of cooktop;

•service number (i.e., the number that follows the word

SERVICE on the rating plate under the cooktop and on the guarantee paper);

•your complete address;

•your telephone number and area code.

If any repairs are required, please contact an authorised After-Sales Service, as indicated in the warranty.

In the unlikely event that an operation or repair is carried out by an unauthorised technician, always request a certification of the job carried out and insist on the use of

original spare parts. Failure to comply with these instructions may

compromise the safety and quality of the product.

IKEA of Sweden AB SE - 343 81 Älmhult

+ 2 hidden pages