SERVICE
Model AWZ 220/1
Version 8575 220 65010 Page
Whirlpool Europe
Customer Services
AWZ 220/1
Service Manual
Tumble dryer
Air Vent
AWZ 220/1
Technical data 2 - 3
Spare part list 4
Exploded view 5 - 6
Wiring diagram 7
Circuit diagram 8
Program diagram 9
This documentation is only intended for qualified technicians who are aware of the respective safety regulations.
Date: 21.05.2001 Subject to modification
Document-No.: 4812 713 12379
21.05.2001 / Page 2 AWZ 220/1 Whirlpool Europe
Doc. No: 4812 713 12379 8575 220 65010 Customer Service
Technical data
SERVICE
Dimensions
Height 85 cm
Width 59.5 cm
Depth 56 cm
Weight
Gross weight 33 kg
Net weight 31 kg
Surroundings temperature
Room temperature
maximun 35 ˚C
Room temperature
minimun 5 ˚C
Humidity
Relative humidity
maximum 95 %
Power connection
Electrical components
Heating
Type Aluminium mass
heating
Nominal voltage 230 +10%/ -15% V
Nominal power 2500 ± 5%W
Heating resistances:
Connecting points 19.5 - 23 Ω
Thermostats
Caution:
☞ If one of the thermostats (TL, TH1.2)
is defective, the whole heating
element has to be changed for safety
reason !
☞ Therefore, the thermostats are not
available as separate spare parts !
Voltage 230 V
Frequency 50 Hz
Connected load 2.8 kW
Fuse 16 A
Drum data
Volume 104 l
Drum speed 56 ± 3 rpm
Airflow 120-160 m3 /h
Capacity of laundry
Cotton max. 5 kg
Easy care max. 2.5 kg
Exhaust hose
Inner diameter 10 cm
Maxi.allowable length
(with 2 bows) 4 m
Safety thermostat (in heater) TL
Switch off temperature 298 - 10 ˚C
Heat resistance of slolder 260 ˚C
Fluff thermostat (in heater) TH 1.2
Switch off temperature 220 ± 7.5 ˚C
Exhausting thermostat (in bottom) TH 1.1
Switch on temperature 38 ± 5˚C
Switch off temperature 53 ± 4˚C
Timer
Type Electromechanical
Timer
Eaton EC 4605
Nominal voltage 230 +10%/-15% V
Frequency 50 Hz
Number of steps 60
Stop 01
Heating (138 min.) 02 - 53
Cool down (6 min.) 54 - 55
Anticreasing(12 min.) 56 - 59
Stop 60
Reversing cycle 2’- 6’- 2’- 80’
Ambient temperature 5 to 70 ˚C
Storage temperature up to 85 ˚C
Whirlpool Europe AWZ 220/1 21.05.2001 / Page 3
SERVICE
Customer Service 8575 220 65010 Doc. No: 4812 713 12379
Technical data
Main- and blower motor
Type 1 phase asynchronous
Nominal voltage 230 +10% / -15% V
Frequency 50 Hz
Power consumption 295 ± 7% W
Resistances of coils:
Main coil (2-3) 24.7± 7% Ω
Auxiliary coil (2-1) 25.6± 7% Ω
Rated speed with 5 kg laundry
and 100% rest humidity 2730 rpm
Capacitor 10± 7% µ F
Radio interference filter
Type ISKRA KPB 7325
Voltage max. 275 V
Capacity 100 nFX1 + 2x 22nF Y2 +1MΩ
Start / door switch
Start switch SST
Nominal voltage 230 +10% / -15% V
Nominal current 16 A
Door switch SD
Nominal voltage 230 +10% / -15% V
Nominal current 16 A
Buzzer
type Eichhoff E 2778
Nominal voltage 230 +10% / -15% V
Resistance of coil 7 ± 15 % kΩ
Push buttons
Gentle switch SG
Nominal voltage 230 +10% / -15% V
Nominal current 16 A
21.05.2001 / Page 4 AWZ 220/1 Whirlpool Europe
Doc. No: 4812 713 12379 8575 220 65010 Customer Service
Spare part list
Model AWZ 220/1
Service No. 857522065010
Version 857522065010
SERVICE
Pos. No. 12NC Code Description
004 0 4812 530 48144 Bottom
011 0 4812 500 18054 Foot adjustable
012 0 4812 528 78033 Roll
012 1 4812 528 98003 Shaft Front
012 2 4812 520 28068 Shaft rear
021 0 4812 440 19387 Front,panel
022 0 4812 440 19445 Panel,side
024 0 4812 440 19467 Panel, rear from 98/34
030 0 4812 440 19779 Table top R0 VBL
033 0 4812 310 18582 Kit Push in cover
100 0 4812 416 18182 Door R0 WH VBL
131 1 4812 271 38362 Door lock
133 0 4812 417 28049 Pin Door
191 0 4812 466 68539 Gasket, door
220 0 4812 418 18177 Drum CPL.
223 0 4812 418 88027 Drum lifter
271 0 4812 358 18162 Belt 1965-H7 EH81
273 0 4812 358 18055 Pulley jokey
275 0 4812 492 68129 Spring
291 0 4812 466 68563 Gasket Drum front
291 1 4812 466 68541 Gasket Fluff Filter
291 2 4812 466 68562 Gasket Drum rear
301 0 4812 452 10469 Control panel AWZ 220
331 0 4812 414 58103 Knob WH AV TS
332 0 4812 276 18311 Push button
Pos. No. 12NC Code Description
910 8 4812 502 48348 Screw ST 4,2X 11
912 3 4812 502 18369 Screw A2F M4x6
912 4 4812 502 48015 Screw 4,0x16-TORX
922 0 4812 532 58005 Ring,circlip Triring
922 1 4812 532 58007 Ring,circlip
962 0 4812 466 38012 Protector Motor
993 0 4812 263 78014 Adapter
993 1 4812 310 18413 Accessory hose kit AMH 577
339 0 4812 413 48305 Adapter f. button
344 0 4812 464 48116 Holder
351 0 4812 134 48227 Pilot lamp
355 0 4812 280 18023 Buzzer
401 0 4812 361 18247 Motor
401 1 4812 401 18421 Clamp Motor
420 0 4812 121 18144 Capacitor 10 µ F
421 0 4812 121 18158 Interf.filter
443 0 4812 361 18248 Blower Wheel
456 0 4812 259 28674 Heating element 2500W
490 0 4812 321 18087 Cable,mains
490 1 4812 321 28367 Strain relief
492 1 4812 401 18195 Clip
500 0 4812 282 18457 Timer EC4605.01 TRA
551 3 4812 271 28369 Thermostat
621 0 4812 278 18003 Switch start reset
621 2 4812 276 18278 Switch Gentle
633 0 4812 276 18248 Switch Start
633 1 4812 276 18271 Pin Start Reset
653 1 4812 047 28001 Guide,light WH VBL
743 0 4812 530 48145 Air guide
743 1 4812 530 18011 Heating chamber
743 2 4812 466 68538 Seal for blower
761 0 4812 480 58077 Filter
794 0 4812 466 28107 Gasket
900 1 4812 290 88053 Clip
900 5 4812 532 28915 Clamp
902 1 4812 256 38002 Bracket Roller
903 0 4812 532 28028 Clip,fix
910 5 4819 502 38265 Screw VAB 4,5x20
SERVICE
Exploded view
Whirlpool Europe AWZ 220/1 21.05.2001 / Page 5
Customer Service 8575 220 65010 Doc. No: 4812 713 12379
21.05.2001 / Page 6 AWZ 220/1 Whirlpool Europe
Doc. No: 4812 713 12379 8575 220 65010 Customer Service
Exploded view
SERVICE
SERVICE
Wiring diagram
Whirlpool Europe AWZ 220/1 21.05.2001 / Page 7
Customer Service 8575 220 65010 Doc. No: 4812 713 12379
21.05.2001 / Page 8 AWZ 220/1 Whirlpool Europe
Doc. No: 4812 713 12379 8575 220 65010 Customer Service
Circuit diagram
SERVICE
SERVICE
Program diagram
Whirlpool Europe AWZ 220/1 21.05.2001 / Page 9
Customer Service 8575 220 65010 Doc. No: 4812 713 12379
Loading...