Welch Allyn Kreativ Klean Air II User manual

Klean Air® II

Kreativ Menu

Manuals

Instructions for Use

Please read this manual thoroughly

prior to first use

Copyright Notice:

reproduced without written permission from Kreativ, Inc.

Manufactured by

Kreativ, Inc. (USA) 7420 Carroll Road San Diego, CA 92121-2334

European Regulatory Manager

Welch Allyn LTD.

Navan, Co. Meath

Republic of Ireland

Ph: 353-46-79060

990070 Rev. C

1. Introduction and General Information

1

Introduction

The Kreativ Model Klean Air II is a highly efficient, compact, state-of-the-art instrument designed for air filtration. It is designed to be used with the dental office high velocity evacuation (HVE) to eliminate overspray from air abrasion procedures.

Purpose of this Manual

This manual should be thoroughly studied before using the equipment. Please call your nearest authorized Welch Allyn / Kreativ service representative if you need additional information regarding installation, operation, or service of the unit.

Chapter

Information essential to the installation, operation, and routine maintenance of the Klean Air II device manufactured by Kreativ, Inc., is included in this manual.

General Information and Features

A combination pre/charcoal filter serves two distinct purposes. The pre-filter captures aluminum oxide particles, old composites and other large particles. The charcoal removes most dental office odors and gasses.

A third-stage filter eliminates the biological aerosol created by a high speed drill. This HEPA filter, similar to the type used in a hospital operating room, removes

99.97% of airborne biological contaminants down to 0.3 microns in size.

Features

• High Power Operation

• Low Power Operation

• Easy to read LED Display

• Visual Filter status indicator

• Quick detachable hose for easy access

• Doors for easy filter replacement

• Convenient handle

• Mobility

Page 3 990070 Rev. C

Specifications

• Power Requirements: 100-127 volt, ~, 60 Hz., 1.75A

220-240 volt, ~, 50 Hz., 650 mA

IEC 320 socket with removable cord is located at back; verify unit has correct

• Air Flow: 80 cfm (low) or 120 cfm (high)

• Approximate Size:13” x 13” x 27” (33 x 33 x 68.6 cm)

• Approximate Weight: 45 lbs. (20.4 kg)

• Control Panel: located on door of instrument for easy viewing

• Filters: HEPA DOP 99.97% / 99.99% and activated carbon

• Filter Replacement: user access through door

• Hose: 3” dia. (7.6 cm), 3’ (91 cm). length with expanded

• Power Switch: located adjacent to power inlet

voltage before use

(2.26 or 3.39 m3/min)

pre-filter

intake

• Environment Limitations: Operational Requirements: Temperature: 50° to 95° F (+10° to 35° C)

Humidity: 30 % to 75 % Pressure range: 10.15 to15.37 psia (70 to 106 kPa)

Transport and Storage Requirements:

Temperature: 14° to 122° F (-10° to 50° C) Humidity: 10 % to 90 % Pressure range: 7.25 to 15.37 psia (50 to 106 kPa)

• Equipment Classification: the Kreativ Model Klean Air II system is an EC Class I device requiring an electrical earth ground. This device is classified as ordinary with regard to protection against water ingress.

• Electrical Fuses: Littelfuse, SlowBlow

Model Fuse Mfr. Mfr. P/N Kreativ P/N Fuse Rating

Klean Air II

Littelfuse Type 218-02.5 600109 2.5A, 250Vac Domestic Klean Air II

Littelfuse Type 218-01.6 600096 1.6A, 250Vac European

Page 4 990070 Rev. C

• UL Canadian Classification Marking:

Oral Vacuum, Model 8000-XX

(where XX can be any alphanumeric character)

WITH RESPECT TO ELECTRIC SHOCK, FIRE, MECHANICAL

AND OTHER SPECIFIED HAZARDS ONLY

IN ACCORDANCE WITH CAN/CSA C22.2 NO. 601.1

21ZJ

Page 5 990070 Rev. C

2. Safety

2

Warnings

Make sure that the Kreativ Klean Air II is connected to a properly grounded electrical outlet.

Use protective rubber gloves when changing the filters and properly dispose of them when you are finished.

Be sure to wipe down the patient end of the hose with disinfectant and replace the Intake Liner prior to each patient use.

Chapter

Always replace fuses with fuses of the proper rating as indicated in the Specifications section of the previous chapter.

Cautions

Do not attempt to service the unit beyond those items described in the mainten-ance section. Call your nearest authorized Welch Allyn / Kreativ service representative for instructions.

Do not substitute non-Kreativ, Inc., materials or accessories. Use of materials or accessories supplied by other manufacturers may result in damage to the unit and will void the factory warranty.

Sound clinical judgment and good common sense are essential to the successful use of the unit in order to provide safe and efficient patient care.

Always follow “standard of care” protocols in performing dental operative procedures.

Page 6 990070 Rev. C