Toyota Prius EH5, Prius 00016-47210-01, Prius 00016-47210-04, Prius 00016-47210-11, Prius 2011 Installation Manual

Toyota Prius 2011 - Dual Player Headrest Video

Southeast Toyota Distributors, LLC

Part Number: 00016-47210-01; 04; 11
Code : EH5

ATTENTION: SECURITY COVERS ARE NO LONGER INCLUDED IN THE HEADREST KITS AS OF 01/17/2011

Conflicts

Kit Contents

Item # Quantity Reqd. Description

1 2 Headrest Assembly
2
3 2 Ca
4 1 Power Cord #9
5 1 Bag with Storage Straps
6
7 1 Owner's Manual

9

0 8 AAA Batteries

1
11 1 Co
12 1 Hardware Bag
13 1 Fm Antenna
14 4 Cable Clamps

Hardware Bag Contents

Item # Quantity Reqd. Description

1 2 Red T-taps
2 2 10" Wire Ties
3 12 6" Wire Ties
4 1 4" x 8" Foam Tape
5 1 3"x1/2

2 Remote Control

bles #3

1 Metal Wire Puller

2 IR Headphones

ntrol Box

" Two Side Tape

Color Applicability/Trim Level

oloC r

Vehicle Trim Color

Dark Gray

Misty Gray

Bisque

General Applicability

P riu s

euqsiB

yarG kraD

yrosseccA

11-01274-61000

yarG ytsiM

10-01274-61000

40-01274-61000

X

X

X

Recommended Tools

Safety Tools

Seat/Floor Covers Blankets

Installation Tools

10mm Box end wrench Pliers
Ny

lon Removal Tool Wire Cutters
10mm
12mm Socket

Special Tools

Torque Wrench 48in/lbs

Special Chemicals

Socket Ratchet

Nylon Removal Tool NRT

Page 1 of 15

TOYOTA /PRIUS DUAL PLAYER HEADREST VIDEO

Southeast Toyota Distributors, LLC

A. Pre-installation Precaution

1. Use Seat and Floor Protectors to avoid

damage to surfaces.

2. If the vehicle is equipped with an Anti-theft
radio, the radio code must be written down prior
to disconnecting the battery cable. The code
must be re-entered when the negative battery
cable is reinstalled. Disconnecting the battery
may cause certain vehicle settings to be lost.
Manufacture’s recommendations for the battery
removal should be followed. Disconnecting the
battery is recommended.

B. Battery disconnect

1. Open rear deck lid.

2. Unlock rear cargo compartment cover locks

by twisting. (Figure B2)

Figure
B2

Figure
B3

Figure
B4

3. Lift out compartment cover. (Figure B3)

4. Lift out storage tray from handle at rear.

(Figure B4)

5. Unsnap rear right hand side cover with
hands. (Figure B5)

6. Lift out cover and remove from vehicle.
(Figure B6)

Figure
B5

Figure
B6

Page 2 of 15

TOYOTA /PRIUS DUAL PLAYER HEADREST VIDEO

Southeast Toyota Distributors, LLC

7. Loosen negative battery cable with a 10mm

Figure

B7
box end wrench and remove cable. Remove
bolt from clamp and re-install from opposite

side. (Figure B7)

C. Vehicle disassembly

1. Remove the forward inside kick panel from

each side of the center console. (Figure C1)

2. Use a NRT to pry the power point bezel from
inside the forward center console. Access

backside. (Figure C2a,C2b)

3. Lift cup holder from center console box.
(Figure C3)

Figure

C1

Figure

C2a

Figure

C2b

Figure

C3

Page 3 of 15

TOYOTA /PRIUS DUAL PLAYER HEADREST VIDEO

Southeast Toyota Distributors, LLC

4. Lift carpet from center console box.
(Figure C4)

5. Use a NRT to pry the upper console panel

from the center console box. (Figure C5)

6. Remove 5 bolts from the center console box

using 10mm socket. (Figure C6)

7. Slide the console box back away from the
forward console. (Figure C7)

8. Disconnect the electrical connector from the
console box. (Figure C8)

Figure

C4

Figure

C5

Figure

C6

Figure

C7

Figure

C8

Page 4 of 15

TOYOTA /PRIUS DUAL PLAYER HEADREST VIDEO

Southeast Toyota Distributors, LLC

9. Remove console box from vehicle.
(Figure C9)

10. Remove head rest from each front seat.
Press the release button on the left side post
while lifting up on the head rest. (Figure C10)

11. On each front seat, unzip the rear side
zippers and release the elastic strap from the
bottom. (Figure C11)

12. Vehicles with OE XM Satellite

Remove the two 12mm bolts that secure the
satellite module in place below the front side of
the driver seat. Rotate the module and bracket
toward the back of the car slightly.

(Figure C12a, C12b)

Figure

C9

Figure

C10

Figure

C11

Figure

C12a

Figure

C12b

Page 5 of 15