State GTS-110-PE User Manual

O N - D E M A N D

R E S I D E N T I A L G A S

ON-DEMAND RESIDENTIAL GAS MOD EL S

GTS-110-NI GTS-110-PI

Fully modulating, gas fired, tankless, on demand water heater with sealed combustion (optional) and powervented flue. Indoor and outdoor models available for residential applications. Supplies hot water to domestic hot water systems (directly or indirectly using water storage tanks), recirculation systems, hydronic heating systems, radiant floor heating systems, and/or combined domestic & heating applications.

FEATURES

Continuous Maximum Flow Rates up to 6.6 GPM

ENERGY STAR®Qualified

Qualifies for up to $1500 Tax Credit (must be installed by December 31, 2010)

Available in Natural Gas or Propane (LP)

SAFETY FEATURES

• Built in Freeze Protection

• Manual Reset Hi Limit (Set at 194°F)

• Overheat Cutoff Fuse

• Inlet, Outlet & Mixing Thermistors for Constant Temperature Monitoring

• Flue Backdraft Pressure Switch

• GFI Power Supply Connection

• Flame Sensor

Venting and Combustion

• 4” Category III Stainless Steel

• Vertical or Horizontal Installation

• 50’ Max Length, 5 elbows max (90° elbows = 5’ equivalent length)

• Power Vent

• Electronic Ignition - No Pilot Light

• 3” Combustion Air Intake (with optional kit)

Optional Accessories

• RemoteTemperature Controller

• Complete line of Stainless Steel Venting

• Recess Box (outdoor)

• Pipe Cover

• Direct Vent Conversion Kit (indoor)

• Isolation Valve Kits

Low NOx Emissions

GTS-110-NE GTS-110-PE

ANSI Z21.10.3

CSA 4.3

For more information on Residential Gas On-Demand units, contact:

State Water Heaters 500 Tennessee Waltz Parkway Ashland City, TN 37015

1-877-737-2840 Toll-free USA www.statewaterheaters.com

Complies with Lead Plumbing Law

Warranty

• 12-year limited warranty on heat exchanger in residential applications

• 5-year warranty on all parts

SRGSS03310

O N - D E M A N D

!*! #*! %*! '*! )*!

"!!

"#!

110 Indoor/Outdoor Pressure Loss

Head

Feet

Pressure

Loss (psi)

13-3/4" (350mm)

10" (254mm)

2-1/4" (56mm)

21-3/8" (544mm)

20-1/4" (520mm)

1-3/4" (45mm)1-3/4" (45mm)

1-7/8" (47mm)

COLD 3-1/8" (79mm) HOT 5-1/4" (133mm)

120V 1-3/8" (36mm) GAS 4-7/8" (124mm)

Ø 3-9/8" (101 mm)

2-1/4" (56 mm) COLD 3-7/8" (98mm) GAS

4-7/8" (124mm) HOT

1" (26mm)

4" (102mm)

4-7/8" (123mm) 120V

7-3/4" (196mm)

2-1/4" (57mm)

13-3/4" (350mm)

10" (254mm)

21-3/8" (544mm)

20-1/4" (520mm)

1-3/4" (45mm)1-3/4" (45mm)

1-7/8" (47mm)

COLD 3-1/8" (79mm) HOT 5-1/4" (133mm)

120V 1-3/8" (36mm) GAS 4-7/8" (124mm)

7-7/8" (203mm)

1-5/8" (43mm)

2-1/4" (56 mm) COLD

3-7/8" (98mm) GAS

4-7/8" (124mm) HOT

1" (26mm)

4-7/8" (123mm) 120V

7-3/4" (196mm)

0 20 40 60 80 100 120 140

Flow Rate (GPM)

Temperature Rise (°F)

Comparison of Flow Rates vs. Temperature Rise

R E S I D E N T I A L G A S

ON-DEMAND RESIDENTIAL GAS MODELS

GAS

MODEL

NUMBER

FUEL TYPE

CONSUMPTION

INPUT

MIN.

BTU/H

MAX.

BTU/H

ENERGY FACTOR

(EF)

INLET GAS PRESSURE

MIN.

W.C.

MAX.

W.C.

MAX

GPM**

DIMENSIONS

IN INCHES

HEIGHT WIDTH DEPTH

VOLT AMP FLUE*

INTAKE

(OPTIONAL)

HOT/

COLD/

GAS

CONN.

GTS-110-NI Natural 19,500 140,000 0.82 5.0 10.5 6.6 20.5 13.8 6.7 120 0.51 4” O.D. 3.0” O.D. 3/4” NPT 38

GTS-110-PI Propane 19,500 140,000

GTS-110-NE Natural 19,500 140,000

GTS-110-PE Propane 19,500 140,000

All dimensions in inches. 15-150 psi water pressure. 40 psi or above recommended for maximum flow. *Category III required **Current numbers based on factory testing, 0.4 GPM required for continuous fire after initial ignition. Pressure only relief valve requires (Min. 200,000 BTUs. 150 PSI). Min 50 PSI or above recommended for maximum flow.

0.83 8.0 14.0 6.6 20.5 13.8 6.7 120 0.51 4” O.D. 3.0” O.D. 3/4” NPT 38

0.82 5.0 10.5 6.6 20.5 13.8 6.7 120 0.51 4” O.D. 3.0” O.D. 3/4” NPT 38

0.82 8.0 14.0 6.6 20.5 13.8 6.7 120 0.51 4” O.D. 3.0” O.D. 3/4” NPT 38

APPROX.

SHIPPING

WEIGHT

(LBS)

CLEARANCES: Top 12”, Bottom 12”, Front 24”, Back 0.5”, Sides 2”

110 INDOOR DIMENSIONS

For complete information on limited warranties, consult written warranty or contact technical support at 1-877-737-2840.

For more information on Residential Gas On-Demand units, contact:

State Water Heaters 500 Tennessee Waltz Parkway Ashland City, TN 37015

1-877-737-2840 Toll-free USA www.statewaterheaters.com

State Industries, Inc., reserves the right to make product changes or improvements without prior notice.

CLEARANCES: Top 36”, Bottom 12”, Front 24”, Back 0.5”, Sides 2”

110 OUTDOOR DIMENSIONS