State GS6-100 URRT User Manual

R E S I D E N T I A L

SELECT

ULTRA-LOW NOX

HIGH RECOVERY TANK TYPE WATER HEATERS

FEATURES

The GS6-100 is an Ultra-Low NOx atmospheric vent commercial gas water heater which meets the thermal efﬁciency and standby loss requirements of the U. S. Department of Energy and Current Edition ASHRAE/IESNA 90.1.

Fully Automatic Controls with Safety Shutoff

• Accurate, dependable control system requires no electric connections

• Fixed automatic gas shutoff device for added safety

• Not recommended for 180°F sanitizing

Heavy Gauge Steel Jacket

• Finished with baked enamel over bonderized undercoat

Easy to Install

• Completely factory-assembled

• Only gas, water and vent connections need to be made

• All connections are located in front and top of heaters for ease of installation and service

Draft Diverter

• Low proﬁle diverter furnished as standard equipment

Maximum Working Pressure

• 150 psi

Maximum Gas Inlet Pressure

• 14” W.C.

Anodic Protection

Image shows model

GS6 100

Glasslined Tank

• Maximizes tank life

Foam Insulation

• Saves fuel, helps reduce standby heat loss

Ultra-Low NOx Emissions

• Complies with SCAQMD Rule 1146.2 and other Air Quality Management Districts with similar requirements of 14 ng/j or 20 ppm

CSA Certified and ASME Rated T&P Relief Valve

Six Year Limited Tank Warranty

• For complete warranty information, consult written warranty

For more information on Ultra-Low NOx, contact:

State Water Heaters 500 Tennessee Waltz Parkway Ashland City, TN 37015

800-365-0024 Toll-free USA www.statewaterheaters.com

SRGSS05112

R E S I D E N T I A L

HOT WATER

OUTLET

DRAIN VALVE

HOT

COLD

TOP VIEW

GAS INLET

DRAIN VALVE

COLD WATER

INLET

TEMPERATU RE AND PRESSURE RELIEF VALVE

Model

Gallon

Capacity

BTU

Input

Per Hour

Natural

BTU

Output

Per Hour

Natural

Recovery

90°F Rise

Gallons

Per Hour

Dimensions in Inches

A B C D E F G H J K L M

GS6-100 URRT 100 75,100 60,080 81 70-1/2 66-1/2 30-15/16 27-3/4 15-3/16 4 15-3/4 16 1-1/4 1-1/4 1/2 11-15/16 350

Water heater(s) shall be Model ________________ as manufactured by State or an approved equal. Water heater(s) shall be of glasslined design, and gas-fired, equipped to burn __________ gas and design certified by UL and shall be approved by the National Sanitation Foundation (with optional leg kit). Heaters must meet all applicable energy codes and comply with ultra-low NOx emissions of 14 ng/j or 20 ppm. Heaters shall have an input rating of _____ BTU/H and a recovery capacity of _____ GPH at a temperature rise of 90°F with a storage capacity of _____ gallons. Heater shall have a working pressure of 150 psi. Heater(s) shall be provided with an automatic gas shutoff device and safety shutoff in event pilot flame is extinguished; a gas pressure regulator set for the type of gas supplied; an approved draft diverter, and extruded anode rod rigidly supported for cathodic protection. A CSA Certified and ASME Rated T&P Relief Valve shall be furnished and installed by the manufacturer. The tank shall be foam insulated. The outer jacket shall have a baked enamel finish over a bonderized undercoating. Fully illustrated instruction manual. All internal surfaces of the heater(s) exposed to water shall be glasslined with an alkaline borosilicate composition that has been fused-to-steel by firing at a temperature range of 1400° to 1600°F. Heater tank shall have a six year limited warranty against corrosion and tank failure due to sediment build-up as outlined in the written warranty. Heater(s) shall be design certified by UL for operation of the heater in a closed system where thermal expansion has not been compensated for with a properly sized expansion tank will void the warranty.

SAMPLE SPECIFICATION

For complete information on limited warranties, consult written warranty or contact the State Customer Care Center at 1-800-365-0024.

State Industries, Inc., reserves the right to make product changes or improvements without prior notice.

For more information on Ultra-Low NOx, contact:

State Water Heaters 500 Tennessee Waltz Parkway Ashland City, TN 37015

800-365-0024 Toll-free USA www.statewaterheaters.com

Approximate

Shipping

Weight

(LBS)