Sony RDRGXD-500 Service manual

RDR-GXD500

RMT-D211P

SERVICE MANUAL

SPECIFICATIONS

System

Laser: Semiconductor laser Transmission standards: DVB-T Channel coverage:

UHF channels B21 - B69

Aerial out: 75-ohm asymmetrical aerial socket Video recording format: MPEG Video Audio recording format/applicable bit rate:

Dolby Digital/2 ch, 256 kbps

When you play PCM sound tracks with a 96 kHz sampling frequency, the output signals from the DIGITAL OUT (OPTICAL or COAXIAL) jack are converted to 48 kHz sampling frequency.

Inputs and outputs

LINE 2 OUT (AUDIO): Phono jack/2 Vrms/10 kilohms (VIDEO): Phono jack/1.0 Vp-p (S VIDEO): 4-pin mini DIN/Y:1.0 Vp-p, C: 0.3

Vp-p (PAL)

LINE 2 IN/LINE 4 IN (AUDIO): Phono jack/2 Vrms/more than 22

kilohms

(VIDEO): Phono jack/1.0 Vp-p (S VIDEO): 4-pin mini DIN/Y:1.0 Vp-p, C: 0.3

Vp-p (PAL)

LINE 1 -TV: 21-pin

CVBS IN/OUT S-Video/RGB OUT (upstream)

LINE 3: 21-pin

CVBS IN/OUT S-Video/RGB IN S-Video OUT (downstream) Decoder

DIGITAL OUT (OPTICAL): Optical output

jack/–18 dBm (wave length: 660 nm)

DIGITAL OUT (COAXIAL): Phono jack/0.5

Vp-p/75 ohms

COMPONENT VIDEO OUT

B/CB

R/CR

, PR/CR):

: 0.7 Vp-p

(Y, P

Phono jack/Y: 1.0 Vp-p, P P

B/CB

: 0.7 Vp-p,

UK Model

General

Power requirements: 220-240 V AC, 50/60 Hz Power consumption: 41W Dimensions (approx.): 430 × 85 × 346 mm

(width/height/depth) incl. projecting parts

Mass (approx.): 4.9 kg Operating temperature: 5 ºC to 35 ºC Operating humidity: 25 % to 80 % Supplied accessories:

Audio/video cord (1) Mains lead (1) Aerial cable (1) Remote commander (remote) (1) R6 (size AA) batteries (2)

Specifications and design are subject to change without notice.

Compatible colour systems

This recorder is designed to record using the PAL colour system and play back using the PAL or NTSC colour systems.

DVD RECORDER

WARNING!!

WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 25 cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK.

CAUTION:

The use of optical instrument with this product will increase eye hazard.

CAUTION

Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

Unleaded solder

Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead. (Caution: Some printed circuit boards may not come printed with the lead free mark due to their particular size.)

: LEAD FREE MARK

Unleaded solder has the following characteristics.

• Unleaded solder melts at a temperature about 40°C higher than

ordinary solder. Ordinary soldering irons can be used but the iron tip has to be applied to the solder joint for a slightly longer time. Soldering irons using a temperature regulator should be set to about 350°C. Caution: The printed pattern (copper foil) may peel away if the heated tip is applied for too long, so be careful!

• Strong viscosity Unleaded solder is more viscous (sticky, less prone to flow) than ordinary solder so use caution not to let solder bridges occur such as on IC pins, etc.

• Usable with ordinary solder It is best to use only unleaded solder but unleaded solder may also be added to ordinary solder.

SAFETY CHECK-OUT

After correcting the original service problem, perform the following

safety checks before releasing the set to the customer.

1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder splashes and bridges.

2. Check the interboard wiring to ensure that no wires are "pinched" or contact high-wattage resistors.

3. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair . Point them out to the customer and recommend their replacement.

4. Look for parts which, through functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement.

5. Check the B+ voltage to see it is at the values specified.

6. Flexible Circuit Board Repairing

• Keep the temperature of the soldering iron around 270˚C during repairing.

• Do not touch the soldering iron on the same conductor of the circuit board (within 3 times).

• Be careful not to apply force on the conductor when soldering or unsoldering.

— 2 —

TABLE OF CONTENTS

SERVICE NOTE

1. DISK REMOVAL PROCEDURE IF THE TRAY CANNOT BE EJECTED (FORCED EJECTION) ············ 5

3. BLOCK DIAGRAMS

3-1. OVERALL BLOCK DIAGRAM (1/3) ···························3-1 3-2. OVERALL BLOCK DIAGRAM (2/3) ···························3-3 3-3. OVERALL BLOCK DIAGRAM (3/3) ···························3-5 3-4. POWER BLOCK DIAGRAM (1/3)································3-7 3-5. POWER BLOCK DIAGRAM (2/3)································3-9 3-6. POWER BLOCK DIAGRAM (3/3)······························3-11

4. SCHEMATIC DIAGRAMS

4-1. FRAME SCHEMATIC DIAGRAM································4-1 4-2. SCHEMATIC DIAGRAMS ············································4-3

WAVEFORMS ································································4-4

• A-003 (1/3) (EMMA2L) SCHEMATIC DIAGRAM ······························4-7

• A-003 (2/3) (DDR SDRAM, NAND FLASH) SCHEMATIC DIAGRAM ······························4-9

• A-003 (3/3) (RESET, VIDEO BUFFER) SCHEMATIC DIAGRAM ····························4-11

• AV-091 (1/9) (POWER SUPPLY) SCHEMATIC DIAGRAM ····························4-13

• AV-091 (2/9) (AUDIO A/D CONV.) SCHEMATIC DIAGRAM ····························4-15

• AV-091 (3/9) (AUDIO OUT) SCHEMATIC DIAGRAM ····························4-17

• AV-091 (4/9) (TUNER, A/D CONVERTER) SCHEMATIC DIAGRAM ····························4-19

• AV-091 (5/9) (SYSTEM CONTROL) SCHEMATIC DIAGRAM ····························4-21

• AV-091 (6/9) (VIDEO IN SELECT) SCHEMATIC DIAGRAM ····························4-23

• AV-091 (7/9) (VIDEO SELECT) SCHEMATIC DIAGRAM ····························4-25

• AV-091 (8/9) (VIDEO BUFFER) SCHEMATIC DIAGRAM ····························4-27

• AV-091 (9/9) (CONNECTOR) SCHEMATIC DIAGRAM ····························4-29

• CN-199 (RELAY) SCHEMATIC DIAGRAM ····························4-31

• ER-035 (ER AV IN/OUT) SCHEMATIC DIAGRAM ····························4-33

• FL-141 (DV/LINE 2 IN, FL DRIVER) SCHEMATIC DIAGRAM ····························4-35

• FR-216 (LED DRIVE, FUNCTION KEY) SCHEMATIC DIAGRAM ····························4-37

• RD-050 (1/19) (CONNECTOR) SCHEMATIC DIAGRAM ····························4-39

• RD-050 (2/19) (VIDEO DECODER) SCHEMATIC DIAGRAM ····························4-41

• RD-050 (3/19) (AV GLUE) SCHEMATIC DIAGRAM ····························4-43

• RD-050 (4/19) (AV ENCODER) SCHEMATIC DIAGRAM ····························4-45

• RD-050 (5/19) (MR PROCESS) SCHEMATIC DIAGRAM ····························4-47

• RD-050 (6/19) (AV DECODER) SCHEMATIC DIAGRAM ····························4-49

• RD-050 (7/19) (SDRAM) SCHEMATIC DIAGRAM ····························4-51

• RD-050 (8/19) (NAZCA) SCHEMATIC DIAGRAM ····························4-53

• RD-050 (9/19) (SDRAM) SCHEMATIC DIAGRAM ····························4-55

• RD-050 (10/19) (AUDY,DAC) SCHEMATIC DIAGRAM ····························4-57

• RD-050 (11/19) (JTAG) SCHEMATIC DIAGRAM ····························4-59

• RD-050 (12/19) (SH) SCHEMATIC DIAGRAM ····························4-61

• RD-050 (13/19) (SDRAM,NAND FLASH) SCHEMATIC DIAGRAM ····························4-63

• RD-050 (14/19) (SWA/UNSW BUFFER-1) SCHEMATIC DIAGRAM ····························4-65

• RD-050 (15/19) (SWA/UNSW BUFFER-2) SCHEMATIC DIAGRAM ····························4-67

• RD-050 (16/19) (FLASH ROM) SCHEMATIC DIAGRAM ····························4-69

• RD-050 (17/19) (GPS3 (HOST GLUE)) SCHEMATIC DIAGRAM ····························4-71

• RD-050 (18/19) (PLL) SCHEMATIC DIAGRAM ····························4-73

• RD-050 (19/19) (POWER) SCHEMATIC DIAGRAM ····························4-75

5. IC PIN FUNCTION DESCRIPTION

5-1. IT CONTROL IC (IC603: N603H2MC-511FPUO (AV-84

BOARD)) ········································································5-1

6. SERVICE MODE

6-1. Checking Item ·································································6-1 6-2. Screen Transition in the Service Mode···························· 6-2 6-3. Service Mode Menu Items and Description ····················6-3 6-4. Device Check Menu (1/2) ···············································6-3 6-5. Device Check Menu (2/2) ···············································6-3 6-6. Path Check Menu (1/2)····················································6-4 6-7. Path Check Menu (2/2)····················································6-4 6-8. Hard Disk Check Menu ···················································6-4 6-9. Device AUTO Check Screen Transition··························6-5 6-10. Device Individual Check, Screen Transition ···················6-5 6-11. Path Individual Check (Pasted Screen Check (visual check)

and data check (digital video data auto-check) ) Screen Transition·····························································6-6

6-12. Path Individual Check (Audio output Confirmation)

Screen Transition·····························································6-6

7. ADJUSTMENT

1. Videl Levl Adjustment (RD-046 Board) ·························7-1

2. Component Video Output Level Adjustment ··················7-1

3. S-Video Output S-Y Check ·············································7-1

4. S-Video Output S-C Level Check ···································7-2

5. Component Video Output Y Check ·································7-2

6. Component Video Output B-Y Chec·······························7-2

7. Component Video Output R-Y Check·····························7-2

8. REPAIR PARTS LIST

8-1. EXPLODED VIEWS 8-1-1.OVERALL SECTION·····················································8-1 8-1-2.D VD DRIVE ··································································· 8-2 8-1-3.CHASSIS BLOCK ··························································8-3 8-2. ELECTRICAL PARTS LIST ··········································8-4

— 3 —

— 4 —

SERVICE NOTE

1. DISK REMOVAL PROCEDURE IF THE TRAY CANNOT BE EJECTED (FORCED EJECTION)

1. Remove the upper case.

2. Remove the RD-50 board, RD bracket.

3. Insert the stiff wire in the hole and eject the tray.

Tr ay

The hole

Fig. 1

The stiff wire

Fig. 2

NOTES DURING THE FORCED EJECTION

1. If the forced ejection is executed while a blank disc media (DVD±RW, ±R) exists on the tray

• Insert a DVD-ROM (DVD test disc, DVD software available on the market, or the like) in the tray and then close the tray.

Note1: If you close the tray while it is empty, ejection of the tray becomes impossible. Note2: If you close the tray with a CD disc inserted in it, the CD can be ejected. However, if you close the tray while it is empty, there can be a case that

ejection of the tray becomes impossible.

Note3: Even if you replace the DVD drive unit while the tray remains under the state as described above, the situation cannot be improved.

2. If the tray cannot be ejected while the disc is not inserted

• Execute the forced ejection.

• Insert a DVD-ROM (DVD test disc, DVD software available on the market, or the like) on the tray and try to close the tray.

(There are cases that it recovers the trouble.)

3. Contents of forcedly ejected blank disc media (DVD±RW , ±R) can be damaged. (There can be a case that initialization is also impossible.)

— 5 —

MEMO

— 6 —

BLOCK DIAGRAMS

3-1. OVERALL BLOCK DIAGRAM (1/4)

CN902

15

7

13

9

11

19 21 23 25

1

TU450

CN801

2

L2 Y/C

4

S2SW

1

L2CVBSIN

V2 IN

6 8

FA IN L/R

10

L3CVBSIN0 V3

J101

LINE 2 IN

S VIDEO

VIDEO

AUDIO L AUDIO R

CY

ER-035 BOARD

AERIAL IN

FL-141 BOARD (1/3)

J803

LINE 4 IN

S VIDEO

VIDEO

AUDIO L

AUDIO R

CN2002

CN105

VY_AD

EUAUINR3 EUAUINL3 EUAUINR1 EUAUINL1TO

AVLINK

OUT

2 4 1 6 8

10

L3RC

L3G L3B

FSW

Y2 IN,C2 IN

L2 IN,R2 IN

CY

SECTION 3

AV-091 BOARD (1/3)

IC452

RF A/D CONV.

17 18

16

11 12

SDA1 SCL1

L3 Y/C

AU3 L/R

AINN

53 54

AINP

57

IF AGC

59

QSDA

58

QSCLK

62

SDA

63

SCL

X450

RESETN

TSCLK

TSVALID

TSSYNC

RDR-GXD500

IC701

VIDEO IN SELECT

CVBS IN5

3

TU VIDEO

CVBS IN1

40 12

C IN3

L2 Y/C

22

Y IN3 Y IN2

20

Y IN5

26 14

C IN4

L3 Y/C

24

Y IN4

V2

CVBS IN3

44

CVBS IN2

42

V3

CVBS IN4

DTT R/L

FA INL/R

1 6 8 18

1

44

9

36

5

40

7

38

3

42

109 113

5 72 17

102

4 27

76 57

58

CB IN C IN1 Y IN1

L/R IN5

L/R IN1

L/R IN3

L/R IN2

L/R IN4

SYNCIN CVIN1 CSYNC H DET SYNC V

FSW AV LINK IN AV LINK OUT

S2SW

TU SCL TU SDA

IC201

AUDIO AMP/ADC

IC603

SYSTEM CONTROL

DTT CB DTT CR DTT Y

11 18

4 5 6 7

SLICEV

V2

FSW

AV LINK

Q610-612,614

SWITCH

Q615

BUFFER

ER SCL,SDA

IC604

UNSW6V

2

RESET OUT

1

RESET

11

IC607

FSC IN

X603 1MHz

1

VCO 3Y

115

2

CVBSOUT

Y OUT

C OUT

CSYNC OUT VSYNC OUT

V DET OUT

COMPONENT H

YOUT_SEL

INSEL1 INSEL3

SDT0

LRCK

MLCK

SMUTE

SEL 0 SEL 2

TI SIN

IT REQ

TI SOUT

IT CLK

ITXRST

ONDO X OUT

XCIN

XCOUT

YC SEP ON

INSEL C

SIRCS

KEY 1 KEY 2 KEY 3 KEY 4

FLD DATA

FLD CLK LED STB

FLD XRESET

FLD CS

38

29

31

34 36 43

21

22

BICK

23 24

PDN

25

27

INSEL 1/2/TU

39 18 38 40 56 96

12

X IN

14

9

10 88

INSEL 1/2/TU

90 75

107

2

97 98 99

100

42 44 47 49 50

IC602

59

EEP ROM

5 7

EEP SDA EEP SCL

61

EEP WP

5

X601

10MHz

X602

32.768KHz

Q705

Q703

Q704

Q601,602

INSEL C

SLICE V

REC Y

REC C

CN501(2/2)

AADDATA

AADBCK AADLRCK PL2256L1

XAADRST

ADSMUTE

CN502(1/2)

RECCB

15

RECY

19

RECCR

23

17

B

21

G

25

R FSW

27

TO RD-050 BOARD

AI SDT

3

5 1 9

2

9

10 12 14 16 18 19

AI BCK AI LRCK 256 FS

AADXRST

SMUTE

IT XRST IT SCLK IT SIN IT SOUT IT REQ TEMP

CN1904,CN1905

RD-050 BOARD

CN1904,CN1905

NZCSIL

0-7

NZCSILCK

TO

EPG SCL EPG SDA

IC061

CN603

12

5

11

7 9 4 6

8 10 16

CN001

IR

6

KEY1 KEY1

13

KEY2

7

KEY3

11

KEY4

9

FLD CS LED RST LED STB

LED CK

LED DT

FUNCTION

2

8 10 12 14

S041

KEY

FLCS

LED RST

FLD CS LED CK LED DT

COMMANDER

1

IC062

REMOTE

RECIEVER

S036,037

FUNCTION

LED

DRIVER

EN030

2

S012-017

FUNCTION

S021-027

KEY

FUNCTION

D001,002 TIMER REC SYNCRO REC

FR-216 BOARD

3

6 20 23

1

8

7

UNSW5V

KEY

CN502(2/2)

CN002

IC550

11 18

IC551

4

5 8

TSSYNC TSVALID TS CLK RESETN

Q755,756

DTT Y

Q750,752

DTT CB

Q753,754

DTT CR

DTT L DTT R

BUFFER

A1

2

Y8 Y1

9

A8

1

10E1

Y

24

A

1

10E

Q501

BUFFER

S101

POWER

6

LED RST

FLD CS LED CK

5

LED DT

2

CN102

FL-141 BOARD(2/3)

89

FE DATA 0-7

89

FE

89

PACKET SYNC

91

FE VALID

93

FE CLK

95

FE RESET

97

SDA1

99

SCL1

68

Y

72

Cb

70

Cr

78

DAC L DAC R

76

CN1000(1/2)

59 66

656CK

55

SCL 0

51

SDA 0

53

DTT 656 D(0-7) 656 D0-D7

DTT 656 CK

IC101

FLD

DRIVER

ND101

FLOORESCENT

INDICATOR

TUBE

3-1 3-2

RDR-GXD500

3-2. OVERALL BLOCK DIAGRAM (2/4)

RD-050 BOARD

AV-091 BOARD

CN502(2/2)

TO AV-091 BOARD CN502

TO

CN501

TO

AADXRST

NZCSIL 0-7

NZCSILCK

EPG SDA EPG SCL

RECCB

RECY

RECCR

AISDT AIBCK

AILRCK

SMUTE IT XRST IT SCLK

IT SIN

IT SOUT

IT REQ

TEMP

CHECK

CN1904(1/2)

15 19 23 17

B

21

G

25

R

27FSW

3 117 ADDATI 5

• 1

PLL256FS

9256FS

XSWGBRST2

2

3

6 20 23

1

CN1906(1/2)

XSWGBRST2 CN1906 (2/2)

9

10

•

12

•

14

•

16

•

18

TH1901

19

7 8

CN103

DIAG

1

SH RXD2

3

SH TXD2

4

ADDATI ADBCKI, ADLRCKI

PLL256LI(IC1704)

ADSMUTE

IC104 IC112

IC111

EEPROM

VI 1A

80

VI 4A

23

VI 2A

7

VI 3A

16

VI 1B

1

VI 2B

8

VI 3B

17

35

3

SYSTEM CONTROL

IC702

DATACLK

IC103

Y2

|

Y9 HD VD

SCL

SDA INTREQ RESETB

SHHD 0

SHHD 31

SHHA 0

SHHA 25

43-47 50-52

HD VD

72

•

SILCK

73

•

40 28

•

4

29

•

30

•

34

|

X102

33MHz

IC402

256Mbit

NAND

FLASH

MEMORY

IC401

COMA

IC302 IC309

SYSTEM CONTROL SIGNAL

9

IC106

CLOCK BUFFER

1Y0 1Y3

CLKIN

1

1Y1 1Y2

3

• 7

2

• 5

IC108 IC109

256Mbit SDRAM

106

|

113 101

•

103

•

104

118

•

119

59,60 62-67

55

SHHA 0-25

SHHD 0-31

IC803

VIDDT0

|

VIDDT7 VIDCK

VIDVD VIDHD

ADBCKI ADLRCKI

NZCCK

RST

115

(1/2)

161

CILENCV 0

|

CILENCV 7

ENCDATO IABD ENCBCKO

ENCLRCKO

SILENCCK

SILENCVD

SILENCHD

SILENCFD

SWAHD 0-7 SWAHA 0-5

IC303 IC304

IC301 IC305

IC1402

BUFFER

RST

IC307 IC310

IC306 IC308

256Fs 512Fs

45

|

53 36 37

•

38

SYNC

40

4

|

43

IC901

AV ENCODER

16

IVIN 0

|

23

IVIN 7

9 33MHz

IALACK

7

• IABCK

8

IVFLD

11

• IVHSYNC

12

• IVVSYNC

14

• IVCLK

25

CD0-7

56-59

OS 0

61

|

63-65

OS 7

AMCLK

34

STCLK

28

CA0-5

SWAHD 0-31(DATA)

SWAHA 0-25(ADDRESS)

256Fs2

27MHz

IC902 IC903

64Mbit

SDRAM

84,86,91 90,92,97

96,102

CLK33

33

CLK27

13

HST D0-D15 HST A0-A15

ENC DT 0

|

ENC DT 7

IC1101

MR

ATP D0

ATP D15

ATP A0 ATP A4

CN-199 BOARD

CN1802 CN1801CN1101

56-59

61

|

63-65

170,208

|

185,228

206

182-184

205

224-226

INTRQ XDIOW IORDY

DMARQ XDMAC XRESET

XDIOR

23-38

6,8,5

3,4

12,14 16,18 20,40

10

24-38

6,8,5

3,4

10 12,14 16,18

IDE INT,DACK,IORDY

20,40

IDE D0-D15

IDE A0-A4

IDE R.W.DREQ.RST

3-18

35,33 36,37

38

1,21 23,25 27,29

31

DVD

DRIVER

IC1202

SWAHD0

UNHD 0-31

UNHA 0-25

SWAHD15

SWAHA0

SWAHA21

512Fs

22

33MHz

156 CRPCLKI 158

27MHz

•

160

IC1203

SWAHA 0-25(ADDRESS)

IC201 IC204

128Mbit

NOR FLASH

MEMORY

IC501

GPS3

DT0I

|

DT7I

|

ACLK

CDIN2I CDIN1I

CDBCKI

CLKI

CDLRCKI

SCLKI

TDO,TDI

TCK,TMS

TRST

DVO 0

|

DVO 7

LRCKO

BCKO

ACD120

64Mbit

SDRAM

SWAHD 0-31(DATA)

SHCKIO

7

CPUCK66

37-40 42-45

97-99

84-87 89-92

DO

IC1206

47 51

31 32 34 35

101 102

28 29 30 24

95

512fs

|

•

CLOCK GENERATOR

DEC DT0

38,60,18 61,39,19

40,42

DEC DT7

72

DEC CLK

•

78

DEC XREQ

•

79

DEC XRDY

•

64

DEC XERR

• DEC XSTRT

73 17

BCLK

•

36

SPDIF

•

59

LRCK

• DADTA

37

TDO

180

201-203

TCK,TDI

222

TRST,TMS

DEC DT 0

30,29 27-22

DEC DT 7

20

DECLRCKI

•

19

DECBCKI

•

16

DECSPDI

• DECDATI

18

95-98

TRST,TCK

102

TMS,TDI TDO

32

DECCLK DABCKO

DALRCKO

PLL1FSEL-PLL3FSEL

IC1701-1704

PLL

X1701

27MHz

|

IC803

SILNZCVB 0 SILNZCVB 7

SPDO

159156,157

SELEEHD

SELEEVD

(2/2)

SILNZCVA 0

|

SILNZCVA 7

|

SILPBCK SILPBFD SILPBHD SILPBVD SELEECK SELEEFD

DADATO

155

5

512Fs

PLL27MA PLL27M1-PLL27M3 PLL33M1-PLL33M2 PLL256L1-PLL256L3 PLL512L1-PLL512L5

128

|

135

145-148 150-153

122

124-126

139

141-143

66 57 59

•

60 51

|

55

FLFRI SPDIFI LRCKI BCKI TRST,TMS

TCK,TDI TDO

IC1102

256Mbit SDRAM

IC1501

U26

SWAHA2 SWAHA7

FLFRO

SPDIFO

IC1502

16Mbit SDRAM

DI1D0 DI1D7

DI2D0 DI2D7

SILPBCK SILPBFD SILPBHD SILPBVD SELEECK SELEEFD SELEEHD SELEEVD

SYSCK

|

64Mbit SDRAM

|

SWAHD0 SWAHD7

47

49

IC1304 IC1305

IC1301

|

TDO

TDI TCK TMS

TRST

51-55

3 7

•

8

XAMUTE

PO RR

SDTI CCLK

CDTI

512Fs

PO RB

PO Y

VO Y

VO C

VO YC

C26

D26

E26

A21

A20

A19

XVMUTE

IC1601

2CH DAC

AOUTL

AOUTR

AV-091 BOARD (2/3)

IC603

(2/2)

SYSTEM

CONTROL

80

ERINT

XNENTMUTE

62

SW5V

95

WIDE

IC802

Y IN

C IN

VIDEO IN

VIDEOOUT

MUTE1 MUTE2

Q311

Q306,308

YOUT

YOUT COUT

Q815,816

24

22CBOUT

20CROUT

29 31

33

7

1

Q305,307

Q312

Q309 Q310

XVMUTE

VIDEO SELECT

17

16

5 6 3 2

Q1303

CN1903

CR/R

25

Q1302

Q1301

Q1305

Q1306

Q1304

11

•

12

9

•

10 15

16

23

21

19

17

15

24

11

10

9

• 3

• 5

4

1

CR/B

Y/G

LCH+/-

RCH+/-

LMUTE RMUTE

SPDIFO

Q814

25

Q813

23 15

Q812

21 12

Q811

Y

19 8

Q810

C

17 6

V

Q809

15 3

24 7

9

AOUT L +/-

•

11

3

AOUT R +/-

• 5

IC302

AUDIO AMP

UNSW12V

UNSW5V

10

4

1

CN503

ER SDA

ER SCL

Q313

CN901

18

ERC

16

ERV ERY

12 10

ERB

8

ERR

6

ERG

4

XVMUTE 3 2

INT 1

SCL

23

EUAUOUTL

21

EUAUOUTR

J301

1

TO ER-035 BOARD CN2001

Y

PB/CB COMPONENT VIDEO OUT

PR/CR

YC

S VIDEO

VIDEO

LINE 2 OUT

AUDIO L

AUDIO R

COAXIAL

OPTICAL

DIGITAL OUT

PCM/DTS/MPEG/

DOLBY DIGITAL

J802

J804

3-3 3-4

3-3. OVERALL BLOCK DIAGRAM (3/4)

Q2002

Q2003

Q2004

Q2005

Q2006

Q2007

TO AV-84 BOARD CN901

XVMUTE

EUAUOUTR EUAUOUTL

ERV

8

ERY

12

ERC

6

ERR

16

ERG

18

ERB

14 20 21

SDA

22

INT

23

SCL

3 1

CN2001

48

2

4

6

8

10 41 47 45 46 52 22 20 18 12 14

3

5 15 17 21 23

ENC_CVBS

ENC_Y

ENC_C

ENC_R

ENC_G

ENC_B ALL_MUTE SDA INT SCL FSW B G R/C TU_CVBS CVBS/Y_OUT FS_AUX FSL1 ASW4 ASW3 ASW2 ASW1

IC2002

SCART

AUX_CVBS/Y

AUX_G C_OUT

PARALLEL4

CVBS/Y_OUT

AUX_R/C

CVBS_Y_OUT

L1_FB_OUT

R/C_OUT

G_OUT B_OUT

PARALLEL3

L1_CVBS

PARALLEL1

RDR-GXD500

38 42 34

43

36 40

FB

51

FS2

31

32 50 30 29 28

13

24

7

Q2010

20 11

7

CN2003 21P

LINE3/

19 15 16

8 1 2 3 6

DECODER

TO AV-84 BOARD CN902

VY-AD

AVLINK

EUAUINL1

EUAUINR1

EUAUINL3

EUAUINR3

1

2

6

7 10 12

8

9

4

5

ASW1 ASW2 ASW3 ASW4 FS_LI_IN FS_AUX_IN DA_R_IN DA_L_IN TU_R_IN TU_L_IN

IC2003

AUDIO OUT SW

14

15

10

14

15

10

11

AUX_R_OUT

AUX_R_IN

AUX_L_OUT

AUX_L_IN

FS_L1_OUT

L1_L_OUT L1_R_OUT

L1_L_IN L1_R_IN

12 13

2 1

12 13

2 1

14 15 16 17

24 22 20 23 21

IC2004

IC2005

SWITCH

19 16 15 11

7

20

8 3 1 6 2

10

CN2004 21P

LINE-1 TV

CN2002

1

FSW

3

L3B

5

L3G

7

L3RC

TUDV(NOT)

9 11

TURO(NOT)

23

TULO(NOT)

21 25 15 17 13 19

ER-035 BOARD

3-5 3-6

RDR-GXD500

DQ 0-15

DQ[0-15]

RDADT[0-7]

DADD[0-12]

DADD 0-12

EMMA2L

IC100

80

19

3

1 8

5

105,107, 114,125, 127,138,

149,151

60,158, 159,167, 168,175,

176,184

5-9 26-30 46-48

254,216, 177,235,

87,137

AV-091 BOARD (3/3)

VDO 0-7

VCK

Q304

15-18 35-38 54-57 73-76

10-13 31-33 49-53

72

22,41,

43,193,

195,214,

234,253

29-32 41-44

7-9

16-18

113

171

STPCLK

PPORT30

256

RXD1B

236

TXD1B

201

PMSDIO

212

PMSINS

220

PMSSCLK

221

PMSPON

241

PMSBS

111

CLK27IN

257

PWMOUT

27MAIN

X1 X2

126 STPEN 162 STPSTRT 183 PPORT11 263 SDA1 264 SCL1

244 SCL0 223 SDA0

270

218

VAG

Q311

272 VAB

Q312

227 VAR

ADO

DATA

LO

AUDIO D/A CONV.

IC300

NAND FLASH

MEMORY

IC206

27MHz CLOCK GEN.

Q309,310

3.3V

IC201

DDR SDRAM

IC202

8

RO

7

1

238

ABCK

BCKI

2

237

ALRCK

LRCI

3

258

AMCK

CLK

4

10

•

12

•

14

•

16

•

18

FE CLK

FE VALID

FE PACKET SYNC

FE RESET

CN402(1/2)

80 87

93

656 CLK

656 D0-D7

FE DATA 0-7

72

68

55 51 53

70

78

76

SCLO SDAO

Y

Cb

Cr

DAC L

DAC R

SDA1 SCL1

91 89 95 97 99

59 66

16 15 14

25 26 27 24

28

TIG MODE

RX TX

PMSINS

PMSSCLK

PMSPON

PMSBS

PMSDIO

X200

27MHz

2 3

226

CDOUT

RESET

IC302

16 15 14

25 26 27 24

28

3 4

2

5

6

Q1001

3.3V

Q1000

CN1001

CN1002

CN1000(2/2)CN402(2/2)

VCC

PMS BS

PMS SCLK

PMS INS

PMS SDIO

TX

RX

JIG MODE

4

5

3

A-003 BOARD

3-4. OVERALL BLOCK DIAGRAM (4/4)

3-7 3-8

3-5. POWER BLOCK DIAGRAM (1/3)

AV-091 BOARD

CN101

UNSW 3.3V

2

SW 3.3V

4 5

UNSW 6V

6

SW 12V

8

UNSW 12V

10

UNSW -8V

12

XP-FAIL

13

IC101

4 2

OUT

ADJ

5 1

Q101

9V REG

FAN_HI

FAN DET

IN

TL

FAN ON

SW 3.3V

Q304

Q302

Q301

XP_FAIL

6 4

FAN

J301

DIGITAL

OUT

TO POWER BLOCK

CN102

FUN OUT

3 2

VCC

2

IC401

FE 5V

4 5

IC102

4 5

IC103

6 4

Q303

VIN VOUT

IC750

5V REG

Q801

REG

5V REG

SW 5V

UNSW

RDR-GXD500

TU450

5V

87 9

FB451 FB452

Q415

5 1

VIN SW

Q414

VCC OUT

8 1

Q151

INH

3

IC151

DTT 3.3V REG

SW 5V

REG

3

UN SW 5V

SWA 5V

1 3

REG

IC301

-8V

Q702

5V

Q701

IC801

Q802

2 3

-5V REG

-5V

UNSW 5V

UNSW 12V

SWA 5V

FB151

Q603,604

IC201

AUDIO AMP/

ADC

32V

FB450 FB455

Q607

IC701

IC802

IC451

FE 32V REG

D701

VIDEO IN

SELECT

VIDEO

BUFFER

TU_PCONT

IC550

IC603

SYSTEM CONTROL

BUFFER

IC153

DTT 2.5V REG

FB550

IC602

VIN VOUT

6 4

IC551

EEPROM

CONT

1

BUFFER

FB551

1

IC450

FE 1.8V REG

VIN

IC150

VO

IC607

VCO

IC604

RESET

DTT 5V REG

1

IC452

RF D/A CONV.

3 6

ER-035 BOARD

6 4

5V REG

Q002

Q001

Q2002-Q2007

D001,002,

TIMER REC

SYNCHRO REC

BUFFER

IC2004

AUDIO SW

CN002

IC2002

SCART

IC2003

AUDIO OUT SW

IC2005

AUDIO SW

SW -8V

1

UNSW 5V

3

KEY1

4

SWITCHING

9 7 6

Q101,102

CN102

T101

D/D CONV.

Q103

ND101

IC101

ND DRIVE

S101

POWER

FL-141 BOARD

IC302

AUDIO AMP

SWA 5V

UNSW 6V

SW -8V UNSW 6V UNSW 5V

DIMMER

UN 5V

CN901

CN503

CN501

CN603

CN601

IC2001

Q2001

-5V REG

13

UNSW 6V

14

UNSW 12V

17

UNSW -8V

19

8

TO RD-050 BOARD

12 13

SW -8V

1

UN 6V

14

UNSW 5V

15

LED_DIM

13

KEY1

5

2

10 11

7 5

CN2001

CN001

17

4 3 5

13

IC062

LED DRIVE

IC061

REMOTE

COMMANDER

RECIEVER

FR-216 BOARD

IC300

AUDIO D/A CONV.

CN402

3.3V

8 9

3

VOVIN

6

33 39 40

8 9

5V

33 39

2.5V 40

IC302

RESET

IC152

DTT 1.5V REG

1

6

3

VOVIN

CN1000

42 45

42

1.5V 45

IC100

EMMA2L

IC201

27MHz CLOCK

A-003 BOARD

3-9 3-10

GEN.

IC202

DDR SDRAM

IC206

NAND FLASH

MEMORY

RDR-GXD500

3-6. POWER BLOCK DIAGRAM (2/3)

TO POWER BLOCK

AV-091 BOARD

10

11 12

14

12 13

1

4

5 6 9

8

CN1801

UNSW 6V

UNSW 3.3V

SW 2.5V

SW 3.3V

P_CCONT

CN1904

CN1903

A5V

UNSW 6V

FL

UNSW 5V

CN103

7

NOT USE

6

IC1804

4 5

REG

3

FL

IC103

SH

IC104

BUFFER

IC111

EEP ROM

IC112

BUFFER

IC106

CLOCK

SH 3.3V

IC108 IC109

256Mbit SDRAM

SW 5V

IC1803

3

UNSW 1.5V

1

REG

FL

UNSW 1.5V

6

IC201 IC204

128Mbit

FLASH MEMORY

IC301 IC305

SWA BUFFER

IC306 IC310

UNSW BUFFER

IC401

SWITCH

IC402

256Mbit NAND

FLASH MEMORY

IC1802

3

SW 1.8V

FL

1

REG

2

SW 1.8V

6

IC703

5 4

1.5V REG

IC501

GPS3(HOST GLUE)

IC803

AV GLUE

IC901

AV ENCODER

IC902 IC903

SDRAM

IC1101

MR PROCESS

IC1102

256Mbit SDRAM

IC701

5 4

3.3V REG 1

IC702

VIDEO DECODER

IC1201

5 4

1.8V REG

IC1202

AV DECODER 64Mbit SDRAM 512 FS

IC1203 IC1206

IC1601

2CH DAC

RD-050 BOARD

IC1306

V REF

5 4

REG

SW 3.3V

IC1301

NAZCA

IC1304 IC1305

SDRAM

IC1402 IC1501 IC1502

BUFFER AUDY 16Mbit SDRAM

IC1702

PLL

IC1701

27MHz BUFFER

IC1703 IC1704

512 FS 256 FS

3-11 3-12

3-7. POWER BLOCK DIAGRAM (3/3)

SWITCHING REGULATOR(POWER BLOCK)

F101

AC IN

1

2

L

N

CN101

AC INLET

T3.15A/250V

L101,102

IC101

SWITCHING

D101-104

6

1 4

5 7

PC101(2/2)

PHOTO COUPLER

L103

T101

POWER

TRANSFORMER

D301

D501

D601

D401

D451

L301

L501

PC101(1/2)

PHOTO

COUPLER

IC401

SHUNT REG

IC501

SHUNT REG

Q501

IC301

SHUNT REG

SW 3.3V

REG

UNSW 3.3V

REG

Q303

12V REG

L401

VR401

IC502

UNSW3.3V REG

VR501

IC402

5V REG

1 2

4

Q451

SWITCH

IC503

SW2.5V REG

L601

Q301

SW 12V REG

Q302

P401 2A

P501 2.5A

1

VIN

4

P601 1A

P301 1A

VOUT

RDR-GXD500

CN4

1 4

CN3

8

10

5 6

13

4 2

12

1

2

5 6 4

9 12 14

CN2

SW12V SW5V

SW12V UNSW12V

UNSW6.0V

XP_FILE

SW3.3V UNSW3.3V USW-8V

UNSW12V

SW2.5V

UNSW3.3V

SW3.3V

P-CCONT

TO DVD

TO AV-094 BOARD

TO RD-50 BOARD

3-13 3-14

RDR-GXD500

MEMO

3-15E

SCHEMATIC DIAGRAMS

4-1. FRAME SCHEMATIC DIAGRAM

SECTION 4

RDR-GXD500

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

1

CN2003

LINE 3/DECODER

CN2004

LINE 1/TV

9P

CN102

IT_GND

SW-8V

UNSW5V

9

8

FLAT CABLE

123456789

SW-8V

UNSW5V

IT_GND

9P

CN002

FR-216 BOARD

21P

A(R)OUT 1

A(R)IN 2

A(L)OUT 3

GND(A) 4 GND(E) 5 A(L)IN 6

FUNCTION_SW_IN 8

GND(E) 9 AVLINK 10

GND(E) 13 GND(E) 14

BLANKING_IN 16

GND(E) 17 GND(E) 18

V/Y_OUT 19

GND(E) 21

21P

A(R)OUT 1

A(R)IN 2

A(L)OUT 3

GND(A) 4 GND(E) 5 A(L)IN 6

FUNCTION_SW_OUT 8

GND(E) 9 AVLINK 10

GND(E) 13 GND(E) 14

R/C_OUT 15

BLANKING_OUT 16

GND(E) 17 GND(E) 18

V/Y_OUT 19

GND(E) 21

FLD_CS

LED_RST

KEY1

FLD_CS

LED_RST

BI/CO 7

G_IN 11 N.C. 12

R_IN 15

V_IN 20

BO/CI 7

G_OUT 11

N.C. 12

V_IN 20

ER-035 BOARD

LED_DT

LED_CK

3

4 16

LINE 2 IN

VIDEO

AUDIO L

AUDIO R

5 12 211917

S VIDEO IN

YC

G

J101

FL-141 BOARD

11P

L2 IN8

C2 IN4

V2 IN6

IT_GND FLD-CS UNSW5V UN6V LED_DIM IR KEY2 LED_RST KEY4 LED_STB KEY3 LED_CK KEY1 LED_DT IT_GND IT_GND SW-8V

FSW GND L3B GND L3G GND L3RC GND TUDV GND VY_AD ADGND EUAUINL3 ADGND EUAUINL1 ADGND EUAUINR1 ADGND EUAUINR3 ADGND ADGND ADGND ADGND GND AVLINK

R2 IN10

AU GND11

CN105

AU GND 11

11P

CN801

17P

CN603

23PCN901

25PCN902

AN GND5

AN GND7

AU GND9

C2 IN 4

V2 IN 6

L2 IN 8

R2 IN 10

AN GND 5

AN GND 7

AU GND 9

CN502

IT_GND

1234567

IT_GND

CN2001

CN2002

CN001

17P

1

IT_GND

2

FLD_CS

3

UNSW5V

4

UN6V

5

LED_DIM

6

IR

7

KEY2

8

LED_RST

9

KEY4

10

LED_STB

11

KEY3

12

LED_CK

13

KEY1

14

LED_DT

15

IT_GND

16

IT_GND

SW-8V

17

23P

1EUAUOUTL 2AUGND 3EUAUOUTR 4AUGND 5UNSW-8V 6ERC 7UNSW12V 8ERV

9GND 10UNSW6V 11UNSW6V 12ERY 13GND 14ERB 15GND 16ERR 17GND 18ERG 19GND 20XVMUTE 21SDA 22INT 23SCL

25P

1FSW

2GND

3L3B

4GND

5L3G

6GND

7L3RC

8GND

9TUDV 10GND 11VY_AD 12ADGND 13EUAUINL3 14ADGND 15EUAUINL1 16ADGND 17EUAUINR1 18ADGND 19EUAUINR3 20ADGND 21TULO 22ADGND 23TURO 24GND 25AVLINK

17 16 15 14 13 12 11 10

9 8 7

FLAT CABLE

6 5 4 3 2 1

23 EUAUOUTL 22 AUGND 21 EUAUOUTR 20 AUGND 19 UNSW-8V 18 ERC 17 UNSW12V 16 ERV 15 GND 14 UNSW6V 13 UNSW6V 12 ERY 11 GND 10 ERB

9 GND

FLAT CABLEFLAT CABLE

8 ERR 7 GND 6 ERG 5 GND 4 XVMUTE 3 SDA 2 INT 1 SCL

25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10

9 8 7 6 5 4 3 2 1

71 3

8 15

9

DVD DRIVE

IDE_D15

GND

IDE_A4(CS1)

N.C

IDE_A4(CS0)

IDE_A2

IDE_A0

IDE_A1

IDE_HD16

IDE_INT

DASP

GND

40

40PCN1801

IDE_R

IDE_DACK

GND

IDE_IORDY

IDE_W

GND

IDE_D0

IDE_DREQ

GND

IDE_D1

GND

IDE_D14

N.C

IDE_D13

151617

18

192021222324252627282930313233343536373839

CN-199 BOARD

23P

AN GND3

AN GND 3

NZCSILCK

NZCSIL5 NZCSIL3 NZCSIL6 NZCSIL7 EPG_SDA EPG_SCL ADSMUTE

IT_XRST

IT_SCLK

IT_SOUT

NZCSIL1 NZCSIL4 NZCSIL0 NZCSIL2

IT_SIN

IT_REQ

1 2 3 4 5 6 7 8

9 10 11 12 13 14

FLAT CABLE

15 16 17 18 19 20 21 22 23

NZCSILCK DGND NZCSIL5 NZCSIL3 NZCSIL6 NZCSIL7 EPG_SDA EPG_SCL ADSMUTE IT_XRST DGND IT_SCLK DGND IT_SIN DGND IT_SOUT DGND IT_REQ TEMP NZCSIL1 NZCSIL4 NZCSIL0 NZCSIL2

CN1906

6P

CN104

CN2201

TPB-2

TPA-4

TPB+3

TPA+5

DGND1

DGND6

1GND

2TPB-

3TPB+

4TPA-

5TPA+

6GND

23P

27P

CN1904

AI_LRCK 123456789

123456789

AI_LRCK

27P

CN501

Y2 IN2

S2 SW1

S2 SW 1

Y2 IN 2

1

DGND

2 3 4 5 6 7 8 9

10

DGND

11 12

DGND

13 14

DGND

15 16

DGND

17 18

TEMP

19 20 21 22 23

AADXRST

AI_SDT

40P

CN1802

GND 12345

DASP

IDE_A4(CS0)

IDE_A4(CS1)

IDE_A1

N.C

IDE_INT

IDE_HD16

IDE_A0

IDE_A2

GND

7

8

6

9

10111213141516171819202122

IDE_DACK

IDE_IORDY

N.C

IDE_DREQ

GND

IDE_R

GND

IDE_D15

IDE_W

GND

N.C

23242526272829303132333435

IDE_D0

IDE_D14

IDE_D1

IDE_D13

FLAT CABLE

1GND

2DASP

3IDE_A3(CS1)

4

5IDE_A2

6IDE_A0

7NC

8IDE_A1

9IDE_HD16

10IDE_INT

11GND

12IDE_DACK

13NC

14IDE_IORDY

15GND

16IDE_R

17GND

18IDE_W

19GND

20IDE_DREQ

21NC

22GND

23IDE_D15

24IDE_D0

25IDE_14

26IDE_D1

27IDE_D13

40PCN1101

IDE_A4(CS0)

RD-050 BOARD

25P

G

AGND

RECY

G

AGNDCbAGND

RECY

AGND

RECC

AGND

RECC

DGND

AI_BCK

DGND

256FS

1011121314151617181920212223242526

DGND

AI_BCK

DGND

256FS

DGND

AGND

UNSW6V

Cb

AGND

B

UNSW6V

AGND

DGND

B

AGND

DGND

AGND

UNSW6V

CN1903

AGND

R

FSW

27

R

FSW

AGND

Rch+

DGNDCRch-

SPDIFO

RMUTE

123456789

DGND

Rch+

RMUTE

SPDIFO

25P

CN503

AV-091 BOARD

4

5

VCC 2

D IN 1

CN301

DIGITAL OUT PCM/DTS/MPEG/ DULBY DIGITAL

GND 3

OPTICAL

COAXIAL

J802

COMPONENT VIDEO OUT

Y-PB/CB-PR/CR

LINE 2 OUT

G

VLR

V

YC

J804

S VIDEO

VIDEO

AUDIO L

AUDIO R

14

10111213141516171819202122232425262728293031323334353637383940

IDE_D6

IDE_D4

IDE_D5

IDE_D2

28IDE_D2

Rch-

IDE_D12

29IDE_D12

AUGND

IDE_D9

IDE_D10

IDE_D3

IDE_D11

1011121314

IDE_D6

IDE_D4

IDE_D3

IDE_D9

IDE_D11

IDE_D5

IDE_D10

36

30IDE_D3

31IDE_D11

32IDE_D4

33IDE_D10

34IDE_D5

35IDE_D9

36IDE_D6

LMUTE

DGND

Lch+

A5V

DGND

Lch-

AUGND

101112131415161718192021222324

FLAT CABLEFLAT CABLE

101112131415161718192021222324

A5V

Lch-

DGND

Lch+

DGND

LMUTE

AUGND

G

J803

LINE 4 IN

IDE_D8

IDE_D7

IDE_D8

373839

37IDE_D8

38IDE_D7

DGND

V

AGND

S VIDEO

123456789

IDE_RST

GND

123456789

GND

IDE_RST

40

39GND

40IDE_RST

DGND

C

DGND

G

YC

18

112V 2GND 3GND 45V

HARNESS

AC IN

1SW12V

2GND

3GND

4SW5V

CN4

CN1801

XVMUTE

Y

DGND

CB/B

DGND

Y/G

DGND

Y

Y/G

DGND

CB/B

DGND

XVMUTE

HARNESS

1UNSW6V 2AGND 3AGND 4UNSW3.3V 5SW2.5V 6SW2.5V 7DGND 8DGND

9SW3.3V 10SW3.3V 11SW3.3V 12SW3.3V 13DGND 14P_CONT 15DGND

CR/R

25

CR/R

CN2 1 UNSW6V 2 AGND 3 AGND 4 UNSW3.3V 5 SW2.5V 6 SW2.5V 7 DGND 8 DGND 9 SW3.3V

10 SW3.3V 11 SW3.3V 12 SW3.3V 13 DGND 14 P_CONT 15 UNSWPCONT/DGND

CN3

CN101 13P

CN102

3P

UNSW6V

SW3.3V

UNSW3.3V

GND

123456789

GND

SW3.3V

UNSW6V

UNSW3.3V

1GND 2FAN SENS 3FAN OUT

CN2101

SWITCHING REGULATOR

UNSW6V

SW12V

GND

B to B

GND

SW12V

UNSW6V

DC FAN

1L

UNSW12V

GND

101112

GND

UNSW12V

2N

XP_FAIL

UNSW-8V

13

XP_FAIL

UNSW-8V

TU401 TUNER

IN OUT

20 23112 10

CN1000

100P

GND

1

GND

2

GND

3

GND

4

GND

5

GND

6

GND

7

3.3V

8

3.3V

9

10

GND GND

11

GND

12

GND

13

TX

14

RX

15

JIG MODE

16

NC

17

NC

18

NC

19

GND

20 21

GND

22

GND GND

23

PMSBS

24 25

PMSINS

26

PMSSCLK

PMSPON

27 28

PMSDIO

29

GND

30

GND

31

GND

32

GND

33

5V

34

GND GND

35

GND

36 37

RESET

GND

38 39

2.5V 40

2.5V 41

GND

42

1.5V 43

1.5V 44

1.5V

45 46

GND

GPIO_1

47 48

GPIO_2

49

GPIO_3

50

GPIO_4

51

SCL0

52

GND

53

SDA0

54

GND

55

656_CLK

56

GND

656_EN

57

GND

58

656_D6

59 60

656_D7

61

656_D5

62

656_D3

63

656_D4

64

656_D2

65

656_D1

66

656_D0

GND

67 68

Y

69

GND

70

Cr

71

GND

Cb

72 73

GND

74

CVBS

75

GND

76

DAC_R

77

GND

78

DAC_L

79

GND

80

FE_DATA7 FE_DATA6

81 82

FE_DATA5

83

FE_DATA4

84

FE_DATA3 FE_DATA2

85 86

FE_DATA1

87

FE_DATA0

88

GND

89

FE_PACKETSYNC

GND

90 91

FE_VALID

92

GND

93

FE_CLK

94

GND

FE_RESET

95 96

GND

97

SDA1

98

GND

99

SCL1

100

GND

B to B

226

100PCN402

GND

1

GND

2

GND

3

GND

4

GND

5

GND

6

GND

7

3.3V

8

3.3V

9

GND

10

GND

11

GND

12

GND

13

TX

14

RX

15

JIG MODE

16

NC

17

NC

18

NC

19

GND

20

GND

21

GND

22

GND

23

PMSBS

24

PMSINS

25

PMSSCLK

26

PMSPON

27

PMSDIO

28

GND

29

GND

30

GND

31

GND

32

5V

33

GND

34

GND

35

GND

36

RESET

37

GND

38

2.5V

39

2.5V

40

GND

41

1.5V

42

1.5V

43

1.5V

44

1.5V

45

GND

46

GPIO_1

47

GPIO_2

48

GPIO_3

49

GPIO_4

50

SCL0

51

GND

52

SDA0

53

GND

54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99

100

656_CLK GND 656_EN GND 656_D6 656_D7 656_D5 656_D3 656_D4 656_D2 656_D1 656_D0 GND Y GND Cr GND Cb GND CVBS GND DAC_R GND DAC_L GND FE_DATA7 FE_DATA6 FE_DATA5 FE_DATA4 FE_DATA3 FE_DATA2 FE_DATA1 FE_DATA0 GND FE_PACKETSYNC GND FE_VALID GND FE_CLK GND FE_RESET GND SDA1 GND SCL1 GND

A-003 BOARD

AERIAL

RLV

VIDEO

AUDIO L

AUDIO R

4-1 4-2

FRAME SCHEMATIC DIAGRAM

RDR-GXD500

4-2. SCHEMATIC DIAGRAMS WAVEFORMS

THIS NOTE IS COMMON FOR SCHEMATIC DIAGRAMS (In addition to this, the necessary note is printed in each block)

(For schematic diagrams)

• All capacitors are in µF unless otherwise noted. pF : µµF.

50V or less are not indicated except for electrolytics and tantalums.

• All resistors are in ohms, 1/4 W (Chip resistors : 1 /10 W) un-less otherwise specified. kΩ=1000Ω, MΩ=1000kΩ.

• Caution when replacing chip parts. New parts must be attached after removal of chip. Be careful not to heat the minus side of tantalum capacitor, because it is damaged by the heat.

• All variable and adjustable resistors have characteristic curve B, unless otherwise noted.

• 2 : non flammable resistor

• 5 : fusible resistor

• C : panel designation

• f : internal component.

• C : adjustment for repair.

• U : B+ Line

• V : B– Line

• Circled numbers refer to waveforms.

• Voltages are dc between measurement point.

• Readings are taken with a color-bar signals on DVD reference disc.

• Readings are taken with a digital multimeter (DC 10MW).

• Voltage variations may be noted due to normal production tolerances.

AV-091

1

IC452 wh

54.3 ns

2

IC603 0

30.4 us

3

IC603 qs

BOARD

4.2 Vp-p

3.1 Vp-p

6

7

8

IC802 w;

H

IC802 ws

H

IC802 wf

1.0 Vp-p

qa

IC802 ed

1.0 Vp-p

H

Note : The components identified by mark 0 or dotted

line with mark 0 are critical for safety. Replace only with part number specified.

When indicating parts by reference number, please include the board name.

4

5

100 ns

IC607 2

225.5 ns

IC607 7

225.5 ns

5.2 Vp-p

1.0 Vp-p

5.5 Vp-p

9

IC802 wl

0

IC802 ea

H

2.0 Vp-p

2.1 Vp-p

H

1.3 Vp-p

H

WAVEFORMS

AV-091

4-44-3

RDR-GXD500

ER-035

BOARD

1 IC2002 ef (S-VIDEO)

H

2 IC2002 eh

(S-VIDEO)

H

(VIDEO)

700m Vp-p

2.0 Vp-p

RD-050

1 IC103

30.3 ns

2 IC702 7

H

3 IC702 qh

BOARD

A2

(JL127)

(S-VIDEO)

2.0 Vp-p

1.0 Vp-p

7 Q1301 E

H

8 Q1302 E

H

9 Q1303 E

780 mVp-p

390 mVp-p

qd

IC1702 34

29.5 ns

qf

IC1702 78

37.0 ns

qg

IC1702 qs

4.5 Vp-p

4.4 Vp-p

ql

IC2105 2 (JL2127)

50.2 us

w;

IC2106 0

55.5 ns

wa

IC2202 wa

3.3 Vp-p

4.5 Vp-p

H

2.0 Vp-p

H

4 IC702 wd

H

(VIDEO)

5 IC702 ug

69.8 ns

6 IC1202 og

570m Vp-p

1.0 Vp-p

2.0 Vp-p

H

0 Q1304 E

H

qa Q1305 E

H

qs Q1306 E

390 mVp-p

780 mVp-p

qh

IC1702 qg

qj

IC1702 qk

qk

IC1702 w;

77.0 ns

40.7 ns

44.3 ns

3.9 Vp-p

4.4 Vp-p

40.8 ns

3.8 Vp-p

4.4 Vp-p

37.0 ns

3.9 Vp-p

500 mVp-p

H

81.4 ns

4-5 4-6

WAVEFORMS

ER-035/RD-050

RDR-GXD500

EMMA2L

A-003 (1/3)

A

B

C

D

E

F

G

H

I

J

K

L

M

N

O

P

1

A-003 BOARD(1/3)

EMMA2L

-REF.NO.:50000 SERIES-

GP_JIG_MODE

1

TO(3/3)

PMSDIO PMSINS

PMSPON

PMSSCLK

2

TO(3/3)

3

TO(2/3)

NAND_ALE

NAND_CLE

NAND_R/BB

4

EMMA_RESET

TO(2/3,3/3)

5

TO(3/3)

6

TO(3/3)

GP_FE_RESET

7

TO(3/3)

RDATA[0] RDATA[1] RDATA[2] RDATA[3] RDATA[4] RDATA[5]

TO(2/3)

RDATA[6] RDATA[7] RDATA[8]

RDATA[9] RDATA[10] RDATA[11] RDATA[12] RDATA[13] RDATA[14] RDATA[15]

8

PMSBS

GPIO_2 GPIO_1 GPIO_3 GPIO_4

TXD1B RXD1B

VID_CR

VID_CB

4 17 21

5

6

7 2013102

8

9

11 19143 1612

15

18

NO MARK:REC/PB MODE :Voltage measurement of the CSP IC

and the Transistors with mark,is not possible.

TXD1B RXD1B PMSBS

PMSDIO PMSINS

PMSPON

PMSSCLK

C136

0.1u 16V

TMODE2

B+B+

B+

VDD1

B

C127

0.1u B

16V

C128

0.1u B

16V

C129

0.1u B

16V

R108

100

R102 100

JL101

JL100

TMODE0

R149

10k

TMODE1

C132 470p

CH 50V

R113

100

CL101

R151

10k

C130

0.1u 16V

CL100

R105

47

R193 4700

R194 4700

R150

JL104

10k

C131

CL104

0.1u 16V

B+

RB100

10kX4

R192

10k

JL409

205

GND

206

GND

207

CBPC

208

CBPD

209

CBPE

210

AGND4

211

DSR1B/PMSINS

212

RDATA11/HSD3

213

RDATA5

214

RDATA12/HSD4

215

NAND_ALE

216

ATX

217

ADO

218

PPORT2

219

PPORT5/PMSSCLK

220

DCD1B/PMSPON

221

TEST

222

SDA0

223

JTDI

224

JTRST

225

RSTSWB

226

VAR

227

AVDD1

228

AGND2

229

AVDD3

230

AVDD4

231

AVDD5

232

OFF0

233

RDATA4

234

NAND_CLE

235

JL126

TXD1B

236

ALRCK

237

ABCK

238

PPORT1

239

PPORT4

240

RI1B/PMSBS

241

TMODE2

242

EDINT

243

SCL0

244

JTDO

245

NMI

246

EIVHS

247

AGND1

248

CBPB

249

AVDD0

250

B

VACOMP

251

AVDD2

252

RDATA3

253

NAND_R/BB

254

GCSB1

255

RXD1B

256

PWMOUT

257

AMCK

258

PPORT0

259

PPORT3

260

TMODE0

261

TMODE1

262

R196

100

SDA1

263

R197 100

SCL1

264

JTMS

265

RSTOUT

266

EIVVS

267

CBPA

268

AGND0

269

VAG

270

AGND3

271

VAB

272

+3V3

C106

C115

16V

B+

+2V5

C101

10u 16V

B+

+1V5

GND

FCS1B FWEB

FOEB

SPDIF

AMCK ABCK

ADO

ALRCK

VID_Y

SDA0 SCL0

SDA1 SCL1

RDATA[0] RDATA[1] RDATA[2] RDATA[3] RDATA[4] RDATA[5] RDATA[6] RDATA[7] RDATA[8]

RDATA[9] RDATA[10] RDATA[11] RDATA[12] RDATA[13] RDATA[14] RDATA[15]

C102

10u

16V

FCS1B

FWEB

FOEB

RB103 47X4

16V

10V

C107

C104

0.1u

4.7u B

F

16V

10V

C108

C113

C105

0.1u

4.7u B

B

F

16V

10V

RB404

R400

10kX4

10k

JEDINT

RB106

47X4

DADD[0] DADD[1] DADD[2] DADD[3] DADD[4] DADD[5] DADD[6]

9

TO(2/3)

DADD[7] DADD[8]

DADD[9] DADD[10] DADD[11] DADD[12]

C111

C103

C100

0.1u

4.7u

10u

B

F

C123

C119

0.1u

B

16V

C112

C120

C116

0.1u

B

16V

C117

C121

C125

0.1u

B

16V

JTCL

RST_OUT

JTDO

JTDI

DADD[0] DADD[1] DADD[2] DADD[3] DADD[4] DADD[5] DADD[6] DADD[7] DADD[8]

DADD[9] DADD[10] DADD[11] DADD[12]

C122

0.1u B

16V

C118

0.1u B

16V

C124

0.1u B

16V

C126

0.1u B

16V

PMSINS RDATA[11] RDATA[5] RDATA[12]

PMSSCLK PMSPON

RDATA[4]

PMSBS

JL130

RDATA[3]

C134

0.1u B

16V

C135

0.1u B

16V

CL130

TEST

PMSDIO

201

202

203

204

JTCK

VDD3

VDD1

DTR1B/PMSDIO

PPORT242PPORT343RXD2B4PPORT495DADD46DADD57DADD78DADD89DADD1110DRASB11DCLK12DQM013DQS114VDD215DQ916DQ1117DQ1318DQ1519GND220PPORT4621RDATA9/HSD122RDATA223RDATA10/HSD224TXD3B25TXD0B26DADD227DADD628DADD1029DADD930DADD1231DCASB32DQM133DVREF34VDD235DQ836DQ10

1

200

DADD[4]

RDATA[7]

RDATA[6]

RDATA[14]

RDATA[13]

CL116

CL109

JL109

197

198

199

GND

NAND_SEB

DADD[5]

DADD[7]

DADD[8]

196

RDATA14/HSD6

DADD[11]

195

DRASB

194

RDATA7

DCLK

JL116

192

193

RDATA6

RDATA13/HSD5

DQM0

DQS1

PPORT12

C133

0.1u B

16V

190

191

CBPF

AGND5

DQ[9]

VDO_D[1]

RDATA[15]

CL105

R198

47

JL105

JL125

R103

47

183

184

185

186

187

188

189

VAY

VDO1

GCSB0

RADD10

PPORT26

PPORT11

RDATA15/HSD7

DQ[11]

DQ[13]

DQ[15]

RDATA[2]

RDATA[9]

182

VAC

RDATA[10]

FOEB

VDO_D[4]

CL106

CL110

JL110

JL106

176

177

178

179

180

181

GND

FOEB

VDD1

VDO4

RADD11

SMDAT0

DADD[2]

DADD[6]

DADD[10]

DADD[9]

VDO_D[0]

CL113

R130

JL124

JL113

47

172

173

174

175

VDD3

VDO0

PPORT10

UPD61120AF1-100-JN1-A

CSP(CHIP SIZE PACKAGE)IC

DADD[12]

DCASB

DQM1

171

VDD3

IC100

DVREF

PPORT30

EMMA2L

IC100

170

RADD[9]

DQ[8]

RADD9

VDO_D[6]

VDO_D[2]

CL107

JL107

JL122

JL123

165

166

167

168

169

VDD3

VDO2

VDO6

PPORT29

MMOFFHOOK

PPORT45

GND2

DQ14

DQ12

40

39

38

37

JL108

CL108

DQ[10]

DQ[12]

DQ[14]

164

41

RDATA[0]

GND

RDATA0

163

42

RDATA[8]

FE_PACKET_SYNC

161

162

RADD13

RADD17/STPSTRT

RDATA1

RDATA8/HSD0

44

43

RDATA[1]

RADD8

TXD2B

VDO_D[5]

VDO_D[3]

CL115

JL115

155

156

157

158

159

160

GND

VDD1

VDO3

VDO5

ACLKIN

DBA0

DBA1

DADD0

DADD1

DADD3

PPORT50

50

49

48

47

46

45

JL118

DADD[3]

DADD[1]

DADD[0]

DBA1

DBA0

FE_DATA[1]

150

151

152

153

154

GND

VDD1

RADD19/STPDAT1

DCLKB

DCSB

DQS054DQ655DQ456DQ257DQ058PPORT4459RXD0B60VDO7

53

52

51

DCSB

DCLKB

DQS0

DQ[6]

DQ[4]

FE_DATA[0]

149

RADD14

DQ[2]

147

148

AVDD1_18

AGND1_18

RADD18/STPDAT0

DQ[0]

144

145

146

GND

VDD1

61

VDO_D[7]

143

GND

RADD162PPORT36/HSDE63RADD064PKTSTRT65RXD3B66VDD3

VDO_EN

FWEB

FE_DATA[2]

CL111

JL111

B+

137

138

139

140

141

142

GND

VDD3

FEWB

PPORT23

AGND1_16 AVDD1_16

AVSYSCLKIN

RADD16/STPEN

SYSCLKIN

AVDD1_162

AGND1_162

CLK27IN

AVDD1_266

AGND1_266

AGND1_6

PPORT28

VRCLKIN

AVDD1_6

PPORT31 PPORT35

PPORT43 PPORT33

PPORT32

STPERRB PPORT42

RADD12

RADD7

MCLKIN

RADD5

RADD6

GRDYB RADD4

RADD2

RADD3

VFIELD

136

135

134

GND

133

GND

132

GND

131

GND

130

GND

129

VDD1

128

127

126

125

EVCK

124

123

122

VDD1

121

VDD1

120

VDD1

119

VDD1

118

VDD2

117

VDD1

116

115

114

113

112

111

110

VDD3

109

FCSB0

108

107

106

105

104

103

102

GND

101

VDD3

100 99

98

97

96

95

CL140

94

VVS

93

VDD1

92

GND

91

90

89

88

87

FCSB1

CL141

86

VHS

85

JL120

84

83

JL121

82

81

80

VCK

79

78

CL142

77

76

DQ1

75

DQ3

74

DQ5

73

DQ7

72

DWEB

71

GND2

70

VDD2

69

GND2

B+

FE_DATA[4]

FE_VALID

FE_DATA[3]

FE_DATA[5]

FE_CLK

R107

47

FE_DATA[7]

FE_DATA[6]

RADD[5]

RADD[6]

RADD[4]

R115

47

FCS1B

JL114

VDO_CLK

R148

10k

DQ[1] DQ[3] DQ[5] DQ[7]

DWEB

R238

10k

C208

0.1u 16V

B+

STPDAT2/RADD20

RADD22/STPDAT4

RADD21/STPDAT3

RADD23/STPDAT5

RADD15/STPCLK

RADD25/STPDAT7

RADD24/STPDAT6

GND268VDD2

67

JL119

FE_CLK FE_DATA[0] FE_DATA[1] FE_DATA[2] FE_DATA[3] FE_DATA[4] FE_DATA[5] FE_DATA[6] FE_DATA[7] FE_PACKET_SYNC FE_VALID

VDO_D[1] VDO_D[4] VDO_D[0]

VDO_D[6] VDO_D[2] VDO_D[5] VDO_D[3]

VDO_CLK VDO_EN VDO_D[7]

C202

1p CK

50V

C203

1p

CK

50V

B

DQ[0] DQ[1] DQ[2] DQ[3] DQ[4] DQ[5] DQ[6] DQ[7] DQ[8] DQ[9] DQ[10] DQ[11] DQ[12] DQ[13] DQ[14] DQ[15]

RB110

68x4

RB111

68x4

R152

68

R153

68

R154

68

RB105 10kx4

JL117

CL117

JL112

CL112

IC201

X200

27MHz

C207

0.001u B

50V

DQ[0] DQ[1] DQ[2] DQ[3] DQ[4] DQ[5] DQ[6] DQ[7] DQ[8] DQ[9] DQ[10] DQ[11] DQ[12] DQ[13] DQ[14] DQ[15]

27MHz CLOCK GEN.

IC201

KA5SDKASO1TSL

1.7 1

X1

3.3 2

VCC

3

AIN

1.7 4

GND

C205

0.1u B

16V

B+

11

TO(2/3)

DTT_656_D[1] DTT_656_D[4] DTT_656_D[0]

DTT_656_D[6] DTT_656_D[2] DTT_656_D[5] DTT_656_D[3]

DTT_656_CLK

DTT_656_EN

DTT_656_D[7]

FE_CLK FE_DATA[0] FE_DATA[1] FE_DATA[2] FE_DATA[3] FE_DATA[4] FE_DATA[5] FE_DATA[6] FE_DATA[7] FE_PACKET_SYNC FE_VALID

10

DBA0 DBA1 DCASB DCLK DCLKB DCSB DQM0 DQM1 DQS0 DQS1 DRASB DVREF DWEB

TO(3/3)

C206

0.1u B

16V

R237

47

12

TO(2/3)

DTT_656_D[1] DTT_656_D[4] DTT_656_D[0]

DTT_656_D[6] DTT_656_D[2] DTT_656_D[5] DTT_656_D[3]

DTT_656_CLK DTT_656_EN DTT_656_D[7]

1.7

8

X2

7

GND

3.3

6

VCC

1.7

5

27M

1

DBA0 DBA1 DCASB DCLK DCLKB DCSB DQM0 DQM1 DQS0 DQS1 DRASB DVREF DWEB

SIGNAL PATH

VIDEO SIGNAL

YCHROMA

RB113

JL133

JL135

JL136

JL127

10kX4

B+

JL403

RXD1B

RB102

47X4

JL131

JL132

JL402

TXD1B

CL131

CL132

REC

PB

AUDIO

SIGNALY/CHROMA

4-84-7

RDR-GXD500

1

A-003 BOARD(2/3)

DDR SDRAM,NAND FLASH

A

-REF.NO.:50000 SERIESNO MARK:REC/PB MODE

B

C

D

E

F

3

C209

0.1u

C211

0.1u

C217

0.1u 16V

C213

0.1u

B

16V

B

16V

B

16V

1 2 3 4 5 6 7 8 9

10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33

IC202

C215

4.7u 10V

F

DDR SDRAM

RB200

68X4

RB201

68X4

RB202

68X4

RB203 100X4

RB204 100X4

RB205 100X4

C216

4.7u 10V

F

DQ[0] DQ[1] DQ[2] DQ[3] DQ[4] DQ[5] DQ[6]

11

TO(1/3)

9

TO(1/3)

13

TO(3/3)

DQ[7] DQ[8]

DQ[9] DQ[10] DQ[11] DQ[12] DQ[13] DQ[14] DQ[15]

DADD[0] DADD[1] DADD[2] DADD[3] DADD[4] DADD[5] DADD[6] DADD[7] DADD[8]

DADD[9] DADD[10] DADD[11] DADD[12]

+2V5

GND

+3V3

DQ[0] DQ[1] DQ[2] DQ[3] DQ[4] DQ[5] DQ[6] DQ[7] DQ[8]

DQ[9] DQ[10] DQ[11] DQ[12] DQ[13] DQ[14] DQ[15]

DADD[0] DADD[1] DADD[2] DADD[3] DADD[4] DADD[5] DADD[6] DADD[7] DADD[8]

DADD[9] DADD[10] DADD[11] DADD[12]

B+

B+ B+

DQ[0]

DQ[1] DQ[2]

DQ[3] DQ[4]

DQ[5] DQ[6]

DQ[7]

DQM0 DQM1

DQS0

DWEB DCASB DRASB DCSB

DBA0 DBA1

DADD[10] DADD[0] DADD[1] DADD[2] DADD[3]

IC202

MT46V16M16P-75-T16

VDD DQ0 VDDQ DQ1 DQ2 VSSQ DQ3 DQ4 VDDQ DQ5 DQ6 VSSQ DQ7 NC VDDQ LDQS NC VDD (DNU) LDM WE CAS RAS CS NC BA0 BA1 A10/AP A0 A1 A2 A3 VDD

VSS DQ15 VSSQ DQ14 DQ13

VDDQ

DQ12 DQ11 VSSQ DQ10

DQ9

VDDQ

DQ8

NC

VSSQ

UDQS (DNU)

VREF

VSS

UDM

CK CK

CKE

NC A12 A11

A9 A8 A7 A6 A5 A4

VSS

7

66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34

C210

0.1u 16V

C212

0.1u 16V

C218

0.1u

RB206

68X4

B

RB207

68X4

B

68R214

100R245

R246

100

B

16V

RB208

100X4

RB209

100X4

DQ[15]

DQ[14] DQ[13]

DQ[12] DQ[11]

DQ[10]

DQ[9]

DQ[8]

DQS1

DVREF

DCLKB

DCLK

DADD[12] DADD[11]

DADD[9] DADD[8] DADD[7] DADD[6] DADD[5] DADD[4]

R243

100

±0.5%

R244

100

±0.5%

DBA0 DBA1 DCASB DCLK DCLKB DCSB DQM0 DQM1 DQS0 DQS1 DRASB DVREF DWEB

9

C222

C221

0.1u

4.7u F

B

16V

10V

DBA0 DBA1 DCASB DCLK DCLKB DCSB DQM0 DQM1 DQS0 DQS1 DRASB DVREF DWEB

B+

10845

RDATA[0] RDATA[1] RDATA[2] RDATA[3] RDATA[4]

12

TO(1/3)

B+

RDATA[5] RDATA[6] RDATA[7] RDATA[8] RDATA[9] RDATA[10] RDATA[11] RDATA[12] RDATA[13] RDATA[14] RDATA[15]

1162

RDATA[0] RDATA[1] RDATA[2] RDATA[3] RDATA[4] RDATA[5] RDATA[6] RDATA[7] RDATA[8] RDATA[9] RDATA[10] RDATA[11] RDATA[12] RDATA[13] RDATA[14] RDATA[15]

8

TO(1/3)

SPDIF

IC206

K9F6408U0C-FIB0T

IC206

G

3

TO(1/3)

NAND_R/BB

FOEB

FCS1B

H

NAND_CLE NAND_ALE

FWEB

NAND FLASH MEMORY

R219

10k

R218

1k

CL202

JL202

C201

0.1u 16V

B

JL200 JL201

I

4

TO(1/3,3/3)

EMMA_RESET

1

NC

2

NC

3

DNU

4

NC

5

NC

6

NC

3.3

7

R/B

3.3

8

RE

3.3

9

CE DNU

10

NC

11

3.3 VCC

12

VSS

13

NC

14

DNU

15

0

CLE

16

0

ALE

17

3.3 WE

18

3.3 WP

19

NC

20

NC

21

DNU

22

NC

23

NC

24

DNU

NC

48

NC

47 46

NC

45

3.3

I/O7

44

0

I/O6

43

0

I/O5

42

3.3

I/O4

41

NC

40 39

NC

38

3.3

VCC

37

VSS

36

NC

35 34

NC

33

0

I/O3

32

3.3

I/O2

31

0

I/O1

30

3.3

I/O0

29

NC

28 27

NC

26

NC

25

C200

0.1u 16V

B

RDATA[7] RDATA[6] RDATA[5] RDATA[4]

RDATA[3] RDATA[2] RDATA[1] RDATA[0]

C220

4.7u 10V

F

RDATA[15] RDATA[14] RDATA[13] RDATA[12] RDATA[11] RDATA[6] RDATA[5] RDATA[4] RDATA[10] RDATA[9] RDATA[8] RDATA[7] RDATA[3] RDATA[2] RDATA[1] RDATA[0]

R224

RB210

1kX4

RB211

1kX4

RB212

1kX4

RB213

1kX4

1k

DDR SDRAM, NAND FLASH

4-9 4-10

A-003 (2/3)

RDR-GXD500

1

23

456

7

A-003 BOARD(3/3)

TO(1/3)

4

RESET,VIDEO BUFFER

-REF.NO.:50000 SERIESNO MARK:REC/PB MODE

DTT_656_D[0] DTT_656_D[1] DTT_656_D[2] DTT_656_D[3] DTT_656_D[4] DTT_656_D[5] DTT_656_D[6] DTT_656_D[7]

DTT_656_CLK

DTT_656_EN

FE_CLK FE_DATA[0] FE_DATA[1] FE_DATA[2] FE_DATA[3] FE_DATA[4] FE_DATA[5] FE_DATA[6] FE_DATA[7]

FE_PACKET_SYNC

FE_VALID

EMMA_RESET

JL308

VID_Y

VID_CR

DTT_656_D[0] DTT_656_D[1] DTT_656_D[2] DTT_656_D[3] DTT_656_D[4] DTT_656_D[5] DTT_656_D[6] DTT_656_D[7]

DTT_656_CLK

DTT_656_EN

FE_PACKET_SYNC

B+

R320

1k

3.3

3.3 3 .3

C305

0.1u B

16V

B+

FE_CLK FE_DATA[0] FE_DATA[1] FE_DATA[2] FE_DATA[3] FE_DATA[4] FE_DATA[5] FE_DATA[6] FE_DATA[7]

FE_VALID

1

VCC

2

OUT

R304

100

R343

100

DAN202K-T-146

IC302

PST575IMT-T1

IC302

RESET

1.5

D300

GND

CD

R311

1k

JL304

2SA1037AK-T146-R

R341

1k

JL311

2.2

2SA1037AK-T146-R

TXD1B

RXD1B

GP_JIG_MODE

1

TO(1/3)

PMSBS

PMSINS

PMSSCLK

PMSPON

PMSDIO

GND

GPIO_1

GPIO_2

GPIO_3

GPIO_4

+3V3 +2V5 +1V5

+3V3 +2V5

GND

SCL0

SDA0

3

TO(3/3)

R322

39k

±0.5%

C306

0.1u B

16V

4 3

CL304

Q304

BUFFER

CL311

Q312

BUFFER

Q309

DTC144EKA-T146

SWITCH

3.3

C307

4.7u F

10V

C301

0.1u B

16V

R350

R332

10k

13

Q310

SWITCH

TO(2/3)

2.8

6

TO(1/3)

C324

4.7u F

10V

0

DTC144EKA-T146

L301 12uH

C300

10u 16V

A

B

C

10

D

E

F

TO(1/3,2/3)

G

H

I

J

5

TO(1/3)

VID_CB

R342

K

1

DATA

2

BCKI

3

LRCI

4

CLK

B

50V

AUDIO D/A CONVERTER

L

ALRCK

AMCK

ADO

ABCK

C304

2200p

M

100

0

SM5883AS-G-E2

IC300

R340

1k

JL310

2.2

2SA1037AK-T146-R

BUFFER

LO VDD VSS

RO

CL310

Q311

L302

12uH

8 7 6 5

C320

0.1u B

16V

C317

10u 16V

C323

4.7u F

10V

7

TO(1/3)

GP_FE_RESET

SDA1

SCL1

CL450

CL454

811

B+

DTT_656_CLK

DTT_656_EN

DTT_656_D[6] DTT_656_D[7] DTT_656_D[5] DTT_656_D[3] DTT_656_D[4] DTT_656_D[2] DTT_656_D[1] DTT_656_D[0]

FE_DATA[7] FE_DATA[6] FE_DATA[5] FE_DATA[4] FE_DATA[3] FE_DATA[2] FE_DATA[1] FE_DATA[0]

B+

FE_PACKET_SYNC

FE_VALID

FE_CLK

JL450

JL451

JL452

JL453

CL414

CL413

CL435 CL433

CL419

CL415

JL305

JL414

JL435 JL433 JL430 JL431 JL434

JL413

JL412

JL415

CL462

CL463

CL305

JL427 JL426 JL425 JL424 JL423 JL422 JL421 JL420

JL417

JL418

JL419

JL454

9

1 2 3 4 5 6 7 8

9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64

65 66 67

68 69 70 71 72 73 74 75 76 77 78

79 80 81

82 83 84 85 86 87 88 89 90 91 92

93 94 95

96 97 98 99

100

100PCN402 GND GND GND GND GND GND GND

3.3V

3.3V GND GND GND GND TX RX JIG MODE NC NC NC GND GND GND GND PMSBS PMSINS PMSSCLK PMSPON PMSDIO GND GND GND GND 5V GND GND GND RESET GND

2.5V

2.5V GND

1.5V

1.5V GND GPIO_1 GPIO_2 GPIO_3 GPIO_4 SCL0 GND SDA0 GND 656_CLK GND 656_EN GND 656_D6 656_D7 656_D5 656_D3 656_D4 656_D2 656_D1 656_D0 GND Y GND Cr GND Cb GND CVBS GND DAC_R GND DAC_L GND FE_DATA7 FE_DATA6 FE_DATA5 FE_DATA4 FE_DATA3 FE_DATA2 FE_DATA1 FE_DATA0 GND FE_PACKETSYNC GND FE_VALID GND FE_CLK GND FE_RESET GND SDA1 GND SCL1

GND

10

B TO B

TO AV-091 BOARD(9/9) CN1000

(SEE PAGE 4-29)

SIGNAL PATH

REC

PB

CHROMA

VIDEO SIGNAL

Y

Y/CHROMA

AUDIO

SIGNAL

RESET, VIDEO BUFFER

A-003 (3/3)

4-11 4-12

RDR-GXD500

A

B

(SEE PAGE 4-XX)

D

E

F

G

H

I

J

K

1

AV-091 BOARD(1/9)

POWER SUPPLY

-REF.NO.:10000 SERIES-

TO SWITCHING REGULATOR CN3

DC FAN

2

TO(6/9)

3

TO(4/9)

23

NO MARK:REC/PB MODE

CN101 13P

B TO B

GND

UNSW3.3V

GND

SW3.3V UNSW6V UNSW6V

GND

SW12V

GND

UNSW12V

GND

UNSW-8V

XP_FAIL

CN102 3P

XP_FAIL FAN_ON

1

TO(5/9)

FAN_HI

FAN_DET

TU_PCONT

FE_PCONT

JL101

1

JL102

2 3

JL103

4

JL104

5 6 7

JL105

8 9

JL106

10 11

JL107

12

JL108

13

JL115

3FAN OUT

JL116

2FAN SENS 1GND

JL150

JL117

R1756

R152

C158

1u

16V

IC152

1.5

6

VO

VIN2VC3VO4NC5GND

1

2.5

1.5

R163

1k

0.33u

IC153

2.5

6

VO

3.3

VIN2VC3VO4NC5GND

1

3.3

2.5

R165

1k

117

IC150

DTT5V REG

C164 10V

C165

0.33u 10V

C166

C167

C159

FB150

0uH

47u 16V

C161 16V

JL154

0.1u

IC152

DTT1.5V REG

D154

RB160L-40TE25

JL156

R167

0

JL157

C170

C168

0.1u 16V

C169

47u

16V

47u

16V

0.1u 16V

IC153

DTT2.5V REG

C171

0.1u 16V

JL158

JL159

R168

0R107

0

R175

0

R176

R174

0

R173

0

0R172

R106

0

JL155

JL114

C163

9

C152

0.1u 16V

C154

0.1u 16V

D151

RD3.9FM-T1

D155

PTZ-TE25-3.9B

56 12C138

IC101

SI-3010KM-TL

Q101

0

C104

0.1u

D150

C103

0.1u B

B

C155

220p 50V

STPS2L25U

JL112

R105

0.4

0

10uH

L150

IC102

IC103

L151

PQ1MX55M2SPQ

TK11250CMCL-G

MUN2213T1

JL109

JL113

R108

R177

0

Q151

MUN2213T1

3.3

R156

R178

0

10k

0

C151 180u

16V

100

0

JL151

6

GND

TL2IN3GND4OUT5ADJ

1

6.0

CL150

5.0

C105

0.1u

6.03.3

B

4

VIN

6.0

6

1

3.4

1.0

12.2

5.1

5

VOUT

1.2 ADJ2GND3CONT

1

±0.5%

JL152

5.0

4

5

VIN

GND

1.3

CONT2GND3NR

1

OUT

2

SYNC

0

3

INH

4

COMP

C156

0.022u 25V

R157 4700

R137 330k

R138

120k

±0.5%

VOUT

7.4

1.0

100k

R109

±0.5%

R110

10k

R111 5600

±0.5%

C116

0.01u B

IC151

DTT3.3V REG

IC151

R139

47k

±0.5%

9

R118

L5973ADTR

PAD

IC101

FAN POWER REG

C112

0.01u B

JL110

IC102

C108

1u B

JL111

C117

1u

B

IC103

UNSW5V REG

VCC GND

VREF

FB

10k

SW5V REG

C113

47u 16V

FB151

0uH

1.2

8 7 6 5

R158

5600

±0.5%

1.2

JL153

R159

6200

±0.5%

R160 6800

±0.5%

C160 25V

C162

10u

470u

6.3V

IC150

TK11250CMCL-G

10

12.1

5

6

VIN

GND

CONT2GND3NR

1

3.3

EC10DA40-TE12

D152

EC10DA40-TE12

5.0

4

1.3

D153

VOUT

C157

0.01u 25V

PQ015EZ01ZPH

PQ025EZ01ZPH

14

SW3.3V

UNSW6V

SW3.3V UNSW12V

UNSW-8V UNSW5V GND

UNSW6V IT_GND DTT3.3V

UNSW6V UNSW-8V UNSW5V IT_GND

SW3.3V SW12V

UNSW5V VIN_GND

SW5V SW3.3V UNSW-8V VOUT_GND IT_GND

DTT3.3V VOUT_GND

DTT3.3V UNSW6V UNSW12V UNSW-8V DTT5V DTT1.5V DTT2.5V VIN_GND

VOUT_GND IT_GND

154

4

TO(2/9)

5

TO(3/9)

6

TO(4/9)

7

TO(5/9)

8

TO(6/9)

9

TO(7/9)

10

TO(8/9)

11

TO(9/9)

4-13 4-14

POWER SUPPLY

AV-091 (1/9)

RDR-GXD500

762

C209

16V

543

50V

C217

10u

1u

16V

BP

47u

C210

47u 16V

C214

1

AV-091 BOARD(2/9)

AUDIO A/D CONV.

A

-REF.NO.:10000 SERIES-

12

TO(7/9)

FA_INR

AU3INR

AU3INL

FA_INL

NO MARK:REC/PB MODE

C207

50V

1u

109

118

12

B

R219

37

TO(7/9,9/9)

C

13

TO(9/9)

D

E

F

G

14

TO(3/9)

4

TO(1/9)

ADGND

DTT_R

DTT_L EUAUINR3 EUAUINL3 EUAUINR1 EUAUINL1

SWA5V

SW3.3V

UNSW6V

CL250 CL251

B+ B+

B+

C201

50V

C202

47u 16V

C203

47u 16V

C204

50V

C205

16V

R218

13k

±0.5%

R213

47k

±0.5%

R214

47k

±0.5%

R215

47k

±0.5%

R216

47k

±0.5%

R217

27k

±0.5%

C206

4.7u 50V

2.5

1u

10u

BP

±0.5%

1

LIN5

2

WTM1

3

LIN4

4

WTMO

5

LIN3

6

ZELMN

7

LIN2

8

FS

9

LIN1

LOPIN

10

LOUT

11

R220

47k

±0.5%

2.5

44

RIN5

IPGAL13IPGAR14ROUT15ROPIN16AVDD17AVSS18VCOM19DVSS20DVDD21SDTO22BICK

12

2.5

C208

4.7u 50V

L201 47uH

43

2.5

47k

TEST8

42

2.5

RIN4

R222

47k

±0.5%

41

2.5

R221

13k

±0.5%

C211

0.01u C212

16V

TEST7

B

47u

R223

±0.5%

2.5

39

40

RIN3

IC201

AUDIO A/D CONV.

IC201

AK5365VQ

5.0

SIGNAL PATH

H

REC

PB

47k

TEST6

C213

0.1u

C215

2.2u 50V

2.5

38

RIN2

2.5

B

CHROMA

R224

27k

±0.5%

37

TEST5

2.5

36

3.3

JL215

JL216

35

34

5.0

M/S

RIN1

C218

C216

0.01u

47u 16V

CTRL

1.3

1.6

B

VIDEO SIGNAL

CNS/CAD1

CCLK/SCL

CDTI/SDA

SMUTE

MLCK

LRCK

SEL2

SEL1

SEL0

ALC

PDN

Y/CHROMA

JL217

3.3

33

JL218

32

JL219

31

0

30

3.4

29

3.4

28

0

27

3.3

26

3.3

25

1.6

24

1.7

23

JL220

JL221

JL222

JL223

AUDIO

SIGNALY

R228

R230

22k

22kR229

22k

R242

R234

R235

R236

R237

R238

C219

0.01u

10k

10kR243

10kR244

100

560

22

10

22

B

TO(5/9,9/9)

10k

R505

TO(6/9)

TO(9/9)

INSEL_TU

INSEL_2

INSEL_1

ADSMUTE

17

18

19

VIN_GND

REC_CB

REC_Y

REC_CR

L3RC

15

TO(5/9,6/9)

16

TO(8/9)

L3B L3G

FSW

R508

JL501 JL502 JL503

10k

B+

JL504

JL523

JL505

JL506

JL550

JL524

JL507

JL525

27PCN501

1

AI_LRCK

2

AADXRST

3

AI_SDT

4

DGND

5

AI_BCK

6

DGND

7

DGND

8

DGND

9

256FS

10

DGND

11

DGND

12

UNSW6V

13

UNSW6V

14

AGND

15

RECCb

16

AGND

17

B

18

AGND

19

RECY

20

AGND

21

G

22

AGND

23

RECCr

24

AGND

25

R

26

AGND

27

FSW

TO RD-050 BOARD(1/19) CN1904

(SEE PAGE 4-39)

AUDIO A/D CONV.

AV-091 (2/9)

4-15 4-16

RDR-GXD500

1

2 91143 10

67

8

125

AV-091 BOARD(3/9)

A

AUDIO OUT

-REF.NO.:10000 SERIES-

AOUTR-

AOUTR+

B

20

C

TO(8/9)

AUGND

D

AOUTL+

AOUTL-

E

14

TO(2/9)

SWA5V

UNSW12V

F

5

TO(1/9)

UNSW-8V

SW3.3V

G

GND

UNSW5V

B+ B+

B-

B+

Q301-304 POWER SWITCH

2SD1781K-T146-QR

MUN2111T1

H

NO MARK:REC/PB MODE

C302

47u 16V

Q302

-9.1

C301

47u 16V

R305

10k

JL303

R306

3.33.3 10k

Q301

Q303

MSD601-RT1

-9.1

-8.4

2SB1561T100Q

R307

10k

R309 5600

-8.4

R308 100k

R304

220k

Q304

11.5

-8.9

-9.1

R310 4700

±0.5%

R311 4700

±0.5%

R314 5600

±0.5%

C310 150p

IC302

AUDIO AMP

C311 150p

R312 4700

±0.5%

R313 4700

±0.5%

R315 5600

±0.5%

R316

2200

C312 560p

B-

JL302

12.112.2

IC301

JL301

C304

47u 16V

C306

47u

16V

R370

0

+5V REG

IC301

NJM78M05DL1A-TE1

IN2GND3OUT

1

5.0

12.1

C307

C308

0.01u

B

C309

47u 16V

B+

R302

R303

470

1k

C313

560p

R317 2200

-9.0

1.3

BA4558F-HTE2

IC302

5678

1.3

R318 2200

D301

M1MA152WK-T1

2 1

R324

R325

R320

2200

1.3

0

C315 180p

R321

5600

±0.5%

3

0

C318 220u

16V

C314 180p

0

1234

12.1

R323

5600

±0.5%

C316

47u

R326

16V

470

B-

Q310

2SD1938(F)-T(TX).SO

0

C319

R330

0.1u 47k

B

C320

R331

0.1u

47k

B

B+

2.8

C317

47u 16V

R328

XX

Q306

MUN2213T1

R327

470

Q305,307,311 L MUTE SW

R332

10k

MUN2213T1

R333

Q309

C321

1u

50V

0.1

Q305

C322

1u

50V

10k

0.1

AUDIO R MUTE

-9.0

0

AUDIO L MUTE

2SD1938(F)-T(TX).SO

Q311

MSB709-RT1

R334

10k

R338

10k

R335

47k

9.6 -9.0

R336

10k

R339

10k

R337

47k

-9.09.6

9.6

R342 4700

R340 4700

Q307

DTC124TKA-T146

Q312

MSB709-RT1

Q308

DTC124TKA-T146

R344 100k

R343

100k

Q306,308,312 R MUTE SW

C333

0.1u

R345

B

1k

R356

0

R351

0

R355

470

R353

470

B+

R346

1k

R347

5.0

2.5

1.8

1k

SIGNAL PATH

REC

PB

C327 100p

C326 100p

Q313

MSD601-RT1

BUFFER

R350

68

R348

220

C328

47u 16V

AUDIO

SIGNAL

C324

47u 16V

EUAUOUTR

21

COAXIAL

OPTICAL

TO(9/9)

22

TO(7/9)

DIGITAL OUT PCM/DTS/MPEG DOLBY DIGITAL

23

TO(8/9)

J301

EUAUOUTL

AUGND

AUOUTR2

AUGND

AUOUTL2

SPD_GND

5 4

B+

3 GND 2 VCC 1 D IN

SPD_GND

SPDIFO

XLMUTE

XRMUTE

4-17 4-18

AUDIO OUT

AV-091 (3/9)

RDR-GXD500

For Schematic Diagram

• Refer to page 4-4 for waveforms.

12

3 127

56 1716

9

10

114 14

138

15

AV-091 BOARD(4/9)

A

B

C

6

TO(1/9)

D

3

TO(1/9)

E

F

G

H

TUNER,A/D CONVERTER

-REF.NO.:10000 SERIESNO MARK:REC/PB MODE

UNSW6V

DTT3.3V

IT_GND

FE_PCONT

B+

R414

0

C403

0.1u

B+

IC401

PQ1MX55M2SPQ

R407

1k

C405

0.1u

AERIAL

IN OUT

5V(SP)

RF AGC

TU450

BTP-DU601

ANALOG IF

IF AGC

IC401

FE 5V REG

4

VIN

5.2

5V

32V

SDA

SCL

AS NC

IF IF

C455

47u

L451

47uH

16V

Q415

2SB1561T100Q

10k

C446

0.1u 16V

C447

0.1u 16V

C449

33u 50V

UDZS-TE17-33B 100 100

JL415

R450

FE 5V SW

JL416

5.2

5.1 C459

C424

4.5

0.1u

R440

1k

0.1

3.3

0

C450

47u

16V

C451

47u 16V

R456

470k

D450

R458

10k

R455

10k

47u

16V

Q414

MNU2211T1

POWER SW

R457

470

C460

22p

50V

L450 10uH

R459

47k

FB450

JL407

R436

C408

47u

C440

C441

0.1u

47u

16V

FB451

0uH

C442

0.01u 16V

FB452

0uH

C443

0.01u 16V

0uH

C445

C444

0.01u

50V

R453 R454

C448

0.01u 16V

5.91.2

B+

5

VOUT

ADJ2GND3CONT

1

R412

R413

5.9

220k

100k

±0.5%

R411

C404

100k

1u

±0.5%

FL450

0uH

B+

JL450

7

JL451

8

JL452

9 10

JL453

11

JL454

12

JL455

13 14 15

JL456

16

JL457

17

JL458

18

IC451

L452

FE 32V REG

22uH

IC451

LM2733XMFX/NOPB

5.1

5

VIN

R462

51k

C456

2.2u 10V

FL451

0uH

GND

5.1

B+

1

SW

2 3

FB4SHDN

IC450

FE 1.8V REG

JL461

FB453

0uH

FB454

0uH

D451

MBR0540T1

5.1

1.2

PQ018EZ01ZP

N VI

1

3.3 1.8

C454

0.33u 10V

C452

0.1u 16V

C453

0.1u 16V

B+

C495

0.01u 50V

1.8

6

IC450

ON/OFF3VOUT4NC5GND

2

JL462

JL463

R463

680k

±0.5%

R464

±0.5%

FB455

JL465

0uH

R465

C461

680k

82p

±0.5%

50V

R466

27k

±0.5%

B+

C457

C458

47u

0.1u

16V

C463

0.001u 50V

L453

0.47uH

C464

0.001u 50V

C465

C462

0.1u

1u

50V

JL464

FE_CLK

FE_VALID

FE_RESET

47

R481

C478

0.01u

1k

R487

R486

R480

10k

16V

3.3

3.000.5

3

4

INTRPTN

5

RESETN

TSCLK

6

TSVALID

0.5

A/D CONVERTER

1

2

DVSS

DVDD

1uH

L454

B+

L455

0.1uH

R470

R467

4700

C468

C467

22p

50V

R468

C472

1k

C471

0.001u

C469

0.1u 16V

50V

R469 2200

82p 50V

C470

0.001u 50V

C466

82p 50V

L458

1uH

FB458 FB459

C473 100p

C476

50V

0.01u

R471 2200

B+

R477

JL466

10k

0

A0

64

0uH 0uH

16V

C474

0.01u C475

0.01u

3.2

R478

47

R479

47

16V 16V

SCL

63

3.1 SDA

62

TESTMODE

61

RF AGC/GPO

60

3.3 QSDA

59

3.3 QSCLK

58

3.3 IF AGC

57

CVSS

56

1.8 CVDD

55

0

AINN

54

0

AINP

53

AVSS

52

3.3 AVDD

51

3.3 AVDD

50

AVSS

49

FE_PACKETSYNC

47

R488

7

8

9

TSERR

TSSYNC

IC452

CXD1976R-T6

FE_DATA[0]

FE_DATA[1]

FE_DATA[2]

47

47R491

47R489

R490

C485

0.01u 16V

1.800.5

0.5

10

11

CVSS

CVDD

TSDATA012TSDATA113TSDATA214TSDATA315TSDATA416TSDATA5

FE_DATA[3]

47R492

0.5

FE_DATA[4]

FE_DATA[5]

47R494

47

R493

0.5

FB460

0uH

FB461

0uH

FE_DATA[6]

FE_DATA[7]

47

47R496

R495

DVDD DVSS CVDD

CVDD

XTALI

XTALO

CVDD

CVSS

0.5

17

0.5

18

3.3

19 20

1.8

21 22

1.8

23 24

1.6

25

1.6

26 27

1.8

28 29

1.8

30 31

1.8

32

C487

0.01u 16V

C488

0.01u

16V C489

0.01u

16V JL467 JL468

C490

0.01u

16V

C491

0.01u

16V C492

0.01u 16V

X450

R497

1M

R498 100

C494

TSDATA6 TSDATA7

1

DTT_SDA1 DTT_SCL1 FE_VALID FE_RESET FE_CLK FE_PACKETSYNC FE_DATA[0] FE_DATA[1] FE_DATA[2] FE_DATA[3] FE_DATA[4] FE_DATA[5] FE_DATA[6] FE_DATA[7]

C493

27p

50V

24

TO(9/9)

I

J

TUNER, A/D CONVERTER

AV-091 (4/9)

VCM44DAREFP

DAREFN46REXT47AVSS48AVDD

43

SIGNAL PATH

REC

PB

VIDEO SIGNAL

YCHROMA

Y/CHROMA

AUDIO

SIGNAL

C477

0.01u 16V

L456

B+

1uH

L457

1uH

R482

47k

±0.5%

3.3

R483 1500

±0.5%

R484

±0.5%

45

1.3

1.4

1.9

1.6

1.0

1.8

16V

C482

16V

C480

16V

0.01u

C484

0.01u

C481

0.01u

16V

C483

0.01u

47k

4-19 4-20

C486

0.01u

DVSS34DVDD35TDO36TDI37TMS38TCK39TRSTN40CVSS41CVDD42REF1VIN

33

3.3

B+

16V

For Schematic Diagram

• Refer to page 4-4 for waveforms.

24

TO(2/9,9/9)

FSW

UNSW-8V

AV-091 BOARD(5/9)

SYSTEM CONTROL

A

-REF.NO.:10000 SERIES-

1

19

B

C

UNSW5V

TO(1/9)

UNSW6V

IT_GND

D

7

E

F

TO(5/9)

SLICE_V

26

G

H

I

J

K

L

FOR CHECK TERMINAL

25

TO(8/9)

CEVISDO5

CEVISDI5

CEVISCK5

ITREQ5

XITRST5

IT_GND

XIT_RST

CNVSS

SH_TXD2 SH_RXD2 CEVISCK5

OND0

CN601 8P

UN5V

M2

1 2 3 4 5 6 7 8

M

3 12

611 2010 14

7

8

9

NO MARK:REC/PB MODE

-8.2 -8.9

R623

R637

0

10k

Q603,604,607 POWER SW

0

Q603

MUN2211T1

4.9

R1696

L602

0

47uH

0

C607

C606

R610

47u

2.2 16V

Q601,602 BUFFER

R613

R611

470

39k

C602

2.7

47u 16V

2.1

R612

22k

R1695

Q601

0

MSB709-RT1

OND0

CEVISDO5

CEVISDI5

CEVISCK5

ITREQ5

XITRST5

JL633 JL631 JL632 JL615 JL616 JL634 JL635 JL630

CEVISDI5

CEVISDO5

CEVISCK5

B+

D602

0.1u

EC10DA40-TE12

B

16V

B+

R618

0

R1683

6800

±0.5%

1.6

R1684

2200

±0.5%

C603

47u 16V

D613

MMDL914T1

R625

C666

47u 16V

5.0

Q602

MSD601-RT1

1.9

R621

0

R615

10k

R674

47k

R677 470k

C634

0.01u B

25V

4.8

5.0

IC604

R3112N281A-TR

1

OUT

2

VDD

3

GND

IC604

RESET DET

5

CD

4

NC

Q607

2SD1781K-T146-QR

8.2

C659

4

IC607

VCC

X602

32.768KHz

X601

10MHz

R1678

27p CH 50V

C620

27p CH

50V

JL610

R1642

47k

100

R653 R654

0

R628

R661

10k

0R668

C617

100R639

0R669

10k

R657

R619

R1701

R1702

R665

0R1677 0

R1693

5600

IC607

R671

X603

C618

0.01u B

TC7WU04F(TE12R)

1M

2.5

1

2.4

2

3

4

B+

R1750

10k

10kR1676

10k

100R604

B

16V0.047u

R667

25V

C622 100u

10k

470R662

10k 100R640

10k

R648

10k

10kR1658

10k

16V

R622 4700

R624 4700

JL611

1A

3Y

2A

GND52Y

B+

JL1634

JL617 JL605

JL1635

JL622

JL624 JL625

JL626

JL1636

JL628 JL629

B+

VCC

1Y

3A

B+

L601 47uH

R673

510

C623

0.01u B

25V

5.0

8

2.6

7

2.6

6

5.0

1

ANEX0(TU_S/B_Dt)

5.0

2

TB4IN(SIRCSt)

0

3

TB3IN(JUST_CLK)/P93

5.0

4

TB2IN(AV_LINK_INt)

4.4

5

TB1IN(CSYNCt)

0

6

P90(FAN_DETt)

0

7

BYTE

0

8

CNVSS

1.4

9

_XCIN

1.5 XCOUT

10

4.8 _RESET

11

2.4 XOUT

12

VSS

13

2.1 XIN

14

5.0 VCC

15

5.0 _NMI

16

4.9 _INT2(SYNC_Vt)

17

0

_INT1(IT_REQt)

18

0.3 _INT0(SLICEON_INt)

19

0

P81(N.C.T)

20

5.0 TA4OUT(DIMMERT)

21

5.0 P77(AREA1t)

22

0

TA3OUT(BUZZERT)

23

0

P75(NC)

24

0

TA2OUT(STB_CNT)

25

0

P73(AREA0t)

26

0

TA1OUT(AV_LINK_OUTT)/CLK2

27

5.0 P71/RXD2/SCL(TXT_SCL)

28

5.0 TA0OUT/TXD2/SDA(TXT_SDA)

29

FB601

0uH

R1689

2200

C626

47p CH

50V

C637

0.01u

R1751

25V

R1700

B

2200

10k

R1688

R1699

10k

8200

±0.5%

C621

0.01u R1687

B

3300

25V

±0.5%

R679

470

C635 560p

CH 50V

B

25V

JL1615

5.0

2.3

115

116

ANEX1

(TU_AFTT)

JL1610

C632

0.01u

1.9

5.001.9

109

110

111

112

113

114

VSS1

VSS3

VDD3

FSCIN

CVIN1

SVREF

2 3

VSS231LP232LP333LP434VDD235M236M137SLICEON38TXD1(IT_SOUTT)39RXD1(IT_SINt)40CLK1(IT_CLKT)41P64(H/Bt)42TXD0(FLD_DATAT)43RXD0(FLD_INt)44CLK0(FLD_CLKT)45EPG_SW146EPG_SW247P56(LED_STBT)48P55(FL_PCONTT)49P54(FLD_XRESETT)50P53(FLD_CST)51P52(TXT_ENT)52P51(SYNC_C_SWT)53P50(SYNC_S/V_SWT)54P47(TU_FMONOT)55P46(RESET5VT)56P45(IT_XRSTT)57P44(TU_SCL)58P43(TU_SDA)

30

000

5.0

JL623

2200

R676

100

R605

C664

C663

C630

47p

0.1u

0.1u B

50V

B

16V

R678

C631

C668

0.01u

47p

B

10k

CH

R631

50V

R634

R635

2700

5.0

Q604

MUN2111T1

5.0

JL607 JL608 JL609

SIRCS

CSYNC FAN_DET

C612

22p 50V

C613

18p

C604

0.001u CH

25V

3.2

50V

C614

10p 50V

C615

10p 50V

VSYNC ITREQ5

DIMMER

B+

10k

C636

0.01u

SYNCIN

R680

B

25V

5.005.0

108

0.104.9

JL606

100

CEVISDI5

INSEL_C

C638

0.01u B

25V

JL1607

5.0

105

106

107

AVCC

VDD1

P97(INSEL_Ct)

0000000

JL613

JL618

100

470

R686

R685

CEVISCK5

CEVISDO5

0

R687

C619

0.01u B

10k

R1752

5.000

103

104

VREF

AVSS

AN0(TU_G_MAXT)

IC603

SYSTEM CONTROL

IC603

M306H2MC-526FPU0

JL642

100

R692

R689

10k

R1682

R602

FLD_DATA

JL1640

102

100

FLD_CLK

RDR-GXD500

XP_MUTE

S2SW

YCSEPON

HDET

EEPROM

IC602

33k

Q615

MSD601-RT1

BUFFER

D610

1SS355TE-17

4.7

1713 15 18

B+

5.0

8

VCC

5.0

7

WP

5.0

6

SCL

5.0

5

SDA

R1755

C650

0.01u 25V

C610

0.01u B

25V

B+

0

B

JL636

JL637

FLD_DATA

JL649

KEY1

JL650

FLD_CLK

JL669

KEY3

JL671

LED_STB

JL696

KEY4

JL697

FLD_RST

JL698

KEY2

JL699

SIRCS

JL1601

DIMMER

JL1603 JL1605 JL1606

FLD_CS

JL1608

FAN_ON

FAN_HI

FAN_DET

FAN_DET XP_FAIL

INSEL_1

INSEL_2

INSEL_TU

YCSEPON

HDET

CSYNC

VSYNC

XNENTMUTE

S2SW

WIDE

INSEL_C

SIGNAL PATH

CHROMA Y

REC

PB

ER_INT

R1685

0

ER_SCL

R1686

0

ER_SDA AVLINK

19

SW-8V

1

IT_GND

2

IT_GND

3

LED_DT

4

KEY1

5

LED_CK

6

KEY3

7

LED_STB

8

KEY4

9

LED_RST

10

KEY2

11

IR

12

LED_DIM

13

UN6V

14

UNSW5V

15

FLD-CS

16

IT_GND

17

1

15

27

28

29

VIDEO SIGNAL

30

17PCN603

TO(1/9)

TO(2/9,6/9)

TO(6/9)

TO(7/9)

TO(6/9,8/9)

TO(9/9)

Y/CHROMA

TO FR-216 BOARD CN001

(SEE PAGE 4-37)

165

WIDE

FAN_HI

FAN_ON

INSEL_2

10k

P02(NC)94P01(NC)

JL654

10k

5.000

91

92

P03(FAN_ONOFFt)

JL1639

10k

R1758

R1759

INSEL_1

INSEL_TU

5.0

0

88

90

P07(INSEL1t)89P06(INSEL2t)

P05(INSEL_TUt)

P10(TU_V_DETT)

P04(FAN_SPEEDt)

P11(TU_PCONTt)

P12(TA_MUTEt)

P13(AUTO_PRESETt)

P14(SAP_DETt)

P15(P_FAILT)

INT5(ERINTT)

P20(MAIN/SAPt)

P21(XP_MUTEt)

P22(SYNCHRO_DETT)

P23(S2SWT) P24(YC_SEP_ONt) P25(SYNC_POWt)

P26(DSELt)

P27(H_DETT)

P30(BS_BST_CONTt)

P31(BS_CONV_CONTt)

P32(BS_VOL_DETT)

P33(BS_C_DETT)

P34(BS_DEC_SWt)

P35(BS_BIT_SWT)

P37(XNENTMUTEt)

P40(EEP_SDA) P41(EEP_SCL)

P42(EEP_WPt)

5.0

JL619

JL620

JL621

0

R1626

R1630

R1628

10k

4700

R1631

R1632

XITRST5

5.0

INT4(NC)

P36(NC)

JL612

B+

R616

0

R1753

10k

5.0

87

0

86

0

JL1641

85

0

JL1642

84

0

83

0

JL1645

82

0

JL681

81

0.3

JL680

80

0

JL1644

79

5.0

JL1617

78

0

JL1618

77

0

JL1619

76

0

JL1620

75

5.0

JL1621

74

0

JL1622

73

4.9

JL1623

72

VSS

71

0

JL1624

70

0

VCC

69

0

JL1625

68

0

JL1626

67

0

JL1627

66

0

JL1628

65

0

JL1629

64

0

JL1630

63

0

JL1631

62

0

JL661

61

5.0

JL627

60

0

59

R1671

Q610-612,614 SWITCH

Q611

2SA1162-YG-TE85L

5.0

R1603

R695

10k

0

2.5

Q610

UN2213-TX

0

R1610

R1604

10k

10kR1763 10kR1762 10kR1761

R1764

22k

R607

100

R1647

10k

R1654

R1665 R1666

R1660 R1691

R1760

R642

R1656 R1657

R1659

R1662

R1663 R1664

R1668

C652

0.01u

220k

100

10k 0

10kR1655

10k

100R1644

0

10kR1661

0

10k

B 25V

10k

10k 10kR1667

10kR1674

100 100R1669

0R1670

R1672

SYNC_POW

R1673

2200

2200 XNENTMUTE

IC602

Q612

MSD601-RT1

4.4

R1621

10k

JL614

S-24C04BFJ-TB

1

NC

2

NC

3

NC

4

VSS

R1643

R1634

150k

5.0

4.9

Q614

MSD601-RT1

0

R1637

R1638

22k

10k

0

C653

0.22

5.5V

4.4

KEY2

KEY1

KEY3

KEY4

OND0

R1640

10k

R1636

10k

R1635

100

R1601

100

R1605

B

25V

C646

C647

0.01u

5.00000

97

5.0

100

R1602

R1606

FLD_RST

10k

R1633

10k

R1698

15k

±0.5%

0

R1611

R1607

10k

R1617

R1614

B

25V

C640

C648

0.01u

JL1632

JL1633

93

95

96

P00(WIDEt)

AN6(KEY1T)98AN5(KEY2T)99AN4(KEY3T)

AN7(ONDOT)

0

4.7

5.005.0

JL1637

JL1638

100

R1608

10k

R1703

R1757

R1704

FLD_CS

R638

0

10k

100

R601

100

R698

R696

B

25V

C645

0.01u

5.005.0

100

101

AN1(FSWT)

AN3(KEY4T)

AN2(KEY5T)

JL645

JL646

100

R699

10k

R1645

R1646

LED_STB

4-21 4-22

SYSTEM CONTROL

AV-091 (5/9)