Page 1
1
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
SERVICE MANUAL
S5004SE52ZPSF
SHARP CORPORATION
TABLE OF CONTENTS
page
CAUTION AND INFORMATION ...................................................................................................................... 2
SPECIFICATIONS ........................................................................................................................................... 3
DESIGNATION OF VARIOUS PARTS............................................................................................................. 4
LIST OF ELECTRICAL PARTS........................................................................................................................ 5
WIRING DIAGRAM .......................................................................................................................................... 6
FUNCTIONS .................................................................................................................................................... 8
ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS .............................................................11
MODIFICATION PROCEDURE OF THE DOOR OPEN SIDE .......................................................................19
COOLING UNIT ............................................................................................................................................. 22
REPLACEMENT PARTS LIST....................................................................................................................... 24
Refrigerant; HFC-134a
Refer to "HFC-134a COOLING UNIT" Service Manual for handling this refrigerant.
DESTINATION ......................... F
In the interests of user-safety (Required by safety regulations in some
countries) the set should be restored to its original condition and only
parts identical to those specified should be used.
MODELS
REFRIGERATOR-FREEZER
SJ-58L-A2G/A2B/A2L
SJ-63L-A2G/A2B/A2L
SJ-68L-A2G/A2B/A2L
SJ-68L-R2G
Page 2
2
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
Some household cleaning chemicals may affect the internal
food liner and plastic parts resulting in splitting or cracks
occurring.
When cleaning all plastic parts inside this refrigerator, only
use diluted dishwashing liquid(soapy water). Make sure that
all plastic parts are thoroughly rinsed with water after cleaning.
CAUTIONS AND INFORMATIONS
1. Some foods freezed in the refrigerator compartment.
2. Some plastic parts were cracked or splitted.
Cracking or crunching sound;
Sound produced by expansion and contraction of inner walls and internal parts during cooling.
Squeaking sound;
Sound produced by expansion and contraction of internal parts.
Sound of flowing fluid (gurgling sound, fizzing sound);
Sound of refrigerant flowing in pipes (sound may become louder from time to time).
3. IT IS NORMAL for the refrigerator to produce the following sounds.
Do not place food directly in front of
cold air outlet.
This may lead to the food freezing.
IN
OUT
cold air flow
In case of following troubles, the cause is not related with the failure of refrigerator.
Please mention the correct way to the customer for the use of refrigerator when the repairing.
Page 3
3
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
SPECIFICATIONS
Items SJ-58L-A2 SJ-63L-A2 SJ-68L-A2/R2
Type 2-Door 2-Door 2-Door
Outer dimensions Height 1620mm(63.8") 1720mm(67.7") 1820mm(71.6")
(Including spacer) Width 760mm(29.9") 760mm(29.9") 760mm(29.9")
Depth 740mm(29.1") 740mm(29.1") 740mm(29.1")
Rated storage volume 492 liter (17.4 cu.ft) 535 liter (18.9 cu.ft) 577 liter (20.4 cu.ft)
F: 151 liter (5.3 cu.ft) F: 151 liter (5.3 cu.ft) F: 151 liter (5.3 cu.ft)
R: 341 liter(12.1 cu.ft) R: 384 liter(13.6 cu.ft) R: 426 liter
(15.1 cu.ft)
Defrosting System Heater system
Start Automatic
Finish Automatic
Temperature control Automatic (Adjustable)
No-frost freezer Yes
Interior lamp 2
Caster 4
Evaporating pan 1
Refrigerator R glass shelf ass'y 1 2 3
Compartment V glass shelf ass'y 1
Vegetable case 1
Fruit case 1
R door pocket 1 2
Egg tray 2
Bottle pocket 2
Utility case pocket 1
Chilled case 1
Tube stand 2
Freezer Freezer shelf ass'y 1
Compartment Ice cube maker Twin ice cube maker
Ice storage box 1
F door pocket 2
Deodorizing system Yes
RATING
Items SJ-58L-A2 SJ-63L-A2 SJ-68L-A2/R2
Rated voltage (V~) 110
Rated frequency (Hz) 60
Climate class ST
Rated input (W) 150
Rated input of heating elements (W) 166
Refrigerant (Charging quantity) HFC-134a(120g) HFC-134a(125g) HFC-134a(130g)
Net Weight (kg) 81 83 88
Power comsumption
(kWh/month) 65 67 69
Energy factor
(L/kWh/month) 9.4 9.7 10.1
Plug cord 2pin
Plug type A-1
COLOR
Items -A2G/R2G -A2B -A2L
Outside color Gray Blue Green
Inside color White
OPTIONAL ITEM
SJ-L838LD (REFRIGERATOR HINGE KITS). For changing the door to left side opening.
Page 4
4
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
DESIGNATION OF VARIOUS PARTS
The names are the denominations used in the
REPLACEMENT PARTS LIST.
1. Freezer Lamp
2. Freezer fan
3. F shelf ass'y
4. Ice cube maker
5. Ice storage box
6. Freezer temp. control box
7. Chilled case
8. Refrigerator temp. control knob
9. Refrigerator fan
10. Refrigerator lamp
11. R glass shelf ass'y
(
SJ-58L
type 1,
SJ-63L
type 2,
SJ-68L
type 3)
12. V glass shelf ass'y
13. Fruit case
14. Vegetable case
15. Evaporating pan & cover
16. Caster
17. Adjustable leg ass'y
18. Fan & light switch(for freezer)
19. Fan & light switch(for refrigerator)
20. F door pocket
21. Water cup
22. Door packing
23. Utility case pocket
24. Egg tray
25. R door pocket
(
SJ-58L/63L
type 1,
SJ-68L
type 2)
26. Bottle pocket
27. Tube stand
1
18
19
20
21
22
23
24
25
26
27
3
2
4
5
6
7
8
9
10
11
12
13
14
17
15
16
22
Figure D-1. External Description
Upper hinge cover
Hot pipe
Freezer temp. control knob
Hot pipe
Ventilating grille
Evaporating pan
Adjustable leg ass’y
Fan motor
Freezer fan
Defrost thermostat
Evaporator
Defrost heater
Damper thermostat
Refrigerator temp. control knob
Drain pipe
Vegetable case
Compressor
Starting relay, Overload relay(Protector)
Caster
Sub condenser
Freezer
compartment
Refrigerator
compartment
Fruit case
Mark: Cold air flow
Timer, R-fan themo. ass’y
Refrigerator fan
This figure shows SJ-63L .
Figure D-2. Constructions
Page 5
5
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
LIST OF ELECTRICAL PARTS
ITEMS TYPE NAME RATING SPECIFICATIONS
Thermostat MM1-8123 125V 6A (At normal notch)
250V 3A ON/OFF : -19/-24˚C
Defrost thermostat US-602S 250V 8A Open/Close : 10/1˚C
Thermo. fuse SF70E 250V 10A Working temp. : 70˚C
F-fan motor 3R00044A 100V 50/60Hz Working with ø100 fan
110V 60Hz
R-fan motor 3R00122B 100V 50/60Hz Working with ø80 fan
127V 50/60Hz
(R-fan fuse) 123 250V 2A Cut OFF 130˚C
Defrost heater MM6-4199D 105V 150W With deodorizer
Door switch DSD-5 125V 0.5A 4 terminals push-button type
Damper thermostat MM1-6170 — Open/Close : 3.0/-2.0˚C
Defrost timer TMDFX04FB2 110-127V Integration type
50/60Hz Cycle time : 12/10 hours(50/60Hz)
Delay time : 4.8/4.0 min.(50/60Hz)
Lamp socket (F/R) — 250V 1A E-12(Hard plastic body type)
F-lamp — 110V 10W E-12
R-lamp — 110V 15W E-12
R-fan thermo. R-fan thermo.
S101 125V 15A Open/ Close : 7/ 15 ˚C
ass'y
R-fan thermo.heater
RSS2 2W (1.2W 110V) 10kΩ
Compressor FGI85HAK 115V/60Hz Cooling capacity : 209kcal/h(60Hz)
Main coil : 1.78Ω
Aux. coil : 6.8Ω
(at 25˚C)
Starting relay RTH7M4R7MC1 — 4.7Ω 20% 180V
Overload relay(Protector) 4TM771RFBZZ — Open/ Close : 130/61˚C
+
Common
Main coil
Aux. coil
Page 6
6
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
WIRING DIAGRAM
Be sure to replace the electrical parts with specified ones for maintaining the safety and performance of the set.
Figure W-1. Wiring Diagram
F-THERMOSTAT
(R)
DEFROST
TIMER
TM
THERMO.
FUSE
FMFM
DEFROST
HEATER
DEFROST
THERMOSTAT
STARTING RELAY
C
M
A
COMPRESSOR
PROTECTOR
(B)
DOOR SWITCH
SOURCE CORD
1
2
4
(S-B)
R-FAN THERMO.
HEATER
R-FAN
THERMO.
L
L
3
(O)
(BR)
(W)
(Y)
(G)
4
12
3
CONNECTED IN TERMINAL BOX
CONNECTOR
G
Br
O
Y
R
P
B
Bk
S-B
G-Y
W
: GRAY
: BROWN
: ORANGE
: YELLOW
: RED
: PINK
: BLUE
: BLACK
: SKY-BLUE
: GREEN-YELLOW
: WHITE
R
R
F
F
(BK)
Page 7
7
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
Figure W-2. Electric Accessories Layout
F LAMP BOX ASS’Y
F-LAMP(10W)
L
LAMP SOCKET
CABINET ASS’Y
E. V. COVER ASS’Y
LEAD EV-COVER ASS’Y
F-FAN MOTOR
F-THERMOSTAT
DEF. THERMO. ASS’Y
FUSE ASS’Y
FM
DEF. HEATER ASS’Y
DOOR SWITCH
3 (PUSH CLOSE)
1 (NEUTRAL)
4 (PUSH OPEN)
2 (PUSH OPEN)
TM
FM
R CONTROL COV. ASS’Y
DEFROST TIMER
(R-FAN
THERMO. HEATER)
R FAN THERMO.
R LAMP BOX ASS’Y
L
R-FAN MOTOR
R-LAMP (15W)
LAMP SOCKET
BROWN BLUE
GRAY
SKY-BLUE
SOURCE CORD
TERMINAL COVER
COMPRESSOR
STARTING RELAY
PROTECTOR
1
2
3
4
3
1
4
2
5
7
6
8
1
2
121
2
121
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
1
2
3
4
5
7
6
8
99
GY-1
(OR-1)
BL-2
SB-1
SB-2
SB-3
BR-3
BR-4
OR-3
OR-2
(OR-2)
(W-2)
OR-1
OR-3
R-1
BR-2
Y-1
(R-1)
(BK-1)
GY-2
(Y-1)
(Y-2)
BL-1
BK-1
W-1
BR-1
W-2
(W-1)
Y-2
TERMINAL BOX
C
M
A
G
Br
O
Y
R
P
B
Bk
S-B
G-Y
W
: GRAY
: BROWN
: ORANGE
: YELLOW
: RED
: PINK
: BLUE
: BLACK
: SKY-BLUE
: GREEN-YELLOW
: WHITE
Page 8
8
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
FUNCTIONS
1. ADJUSTABLE TEMPERATURE CONTROL
(1) Temperature control of freezer
Thermostat (senses freezer temperature) operates on ON/OFF switchover to control the compressor and
cool air circulating fan (F-fan motor) , and allows the freezer temperature to keep at a suitable temperature.
However adjust the freezer temp. control knob as follows depending upon the storing condition of foods.
KNOB
SETTING
MAX
(Coldest)
MIN
PURPOSE
For making ice rapidly or fast freezing.
For storing frozen food for a short period (up to one month).
When frozen food or ice cream is not stored.
For normal freezing.
MED
When restocking with fresh food.
MIN
MAX
MED
1
2
3
4
5
6
7
Coldest
FREEZER TEMP. CONTROL
KNOB
SETTING
MED
CHILLED
ZONE
(Coldest)
MIN
PURPOSE
For keeping freshness of food longer.
For normal operation.
When the refrigerator provides excessive cooling.
When the refrigerator does not provide sufficient cooling.
MIN
MED
1
2
3
4
5
6
7 Coldest
CHILLED
ZONE
REFRIGERATOR TEMP. CONTROL
The values shown above refer to the measurement carried out center area and 1/3 of overall height from the bottom
at each of the refrigerator and the freezer after machine has been operated at an ambient temperature of 30˚C with no
food stored and the door closed until the temperature is stabilized.
The values vary depending upon frequency of opening and closing the door, ambient temperature, amount of stored
foods and manner of storing foods.
SETTING OF
REFRIGERATOR TEMP.
CONTROL KNOB
Refrigerator
temperature
Chilled room
temperature
CHILLED
ZONE
(Coldest)
MED MIN
Approx.
0˚c
Approx.
-3˚c
Approx.
3˚c
Approx.
1˚c
Approx.
6˚c
Approx.
4˚c
The values shown above refer to the case where the
freezer temp. control knob is set at "MED".
Figure F-2.
When the temperature of the refrigerator is higher, R-fan thermo. senses the temperature and the
refrigerator is cooled efficiently by running of R-fan motor.
R-fan thermo. heater energizes when the door is opened intend to promote to running of R-fan motor.
NOTE: The refrigerator temperature is affected also by the freezer temperature. If the freezer temp.
control knob is set at the position "MAX", the temperature tends to be lower than the following
values, and if set at near the position "MIN", temperature tends to be higher.
If the refrigerator is operated for a long time with the freezer temperature control sets the "MAX"
position, foods stored in the refrigerator compartment may also freeze.
When refrigerator temperature control sets to the "CHILLED ZONE", some foods stored may
freeze.
In this case adjust control set back to the "MED" position.
When refrigerator temperature control sets to the "CHILLED ZONE", some foods stored in chilled
case may also become frozen.
(3) Reference value of temperature
SETTING OF
FREEZER TEMP.
CONTROL KNOB
Freezer
temperature
MAX
(Coldest)
MED MIN
Approx.
-21˚C
Approx.
-18˚C
Approx.
-15˚C
Figure F-1.
(2) Temperature control of refrigerator
Damper-thermostat senses temperature of the refrigerator and changes the opening angle of the damper
automatically.
However, as the Damper-thermostat has no function to switch on or off the compressor and F-fan motor,
the freezer temperature control causes temperature in the refrigerator to vary to some extent.
However, adjust the refrigerator temp. control knob as follows depending upon the cooling condition.
Page 9
9
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(2) Where is melted frost brought
1. Melted frost is brought into the evaporating
pan at the bottom of the set and is evaporated
here by the heat of sub condenser.
2. Be sure that the evaporating pan is inserted
correctly and is level.
2. DEFROSTING
(1) No defrosting operation is necessary
No defrosting operation is necessary.
As this machine is so designed that a built-in
evaporator cools air and a fan circulates cooled
air, neither the freezer nor the refrigerator is
frosted, though the evaporator is frosted.
The frosted evaporator is defrosted automatically
due to the function of defrosting timer and heater,
requiring no defrosting operation.
(3) The following circuit diagrams in the table show automatic defrosting function of the refrigerator with
timer and defrost thermostat.
Operation Electric diagram Description
1. Cooling
(Normal)
2. Defrosting
(Time 20 to 30 min.)
3. Drain
(Time approx. 5 min.)
4. Restart
(Time approx. 5 min.)
The integration timer integrates running
time of the compressor. When it reaches
cycle time of defrost timer, the timer
contact is changed to start defrosting.
When the defrost thermostat becomes
OFF, the timer motor starts running.
During the operation time (delay time
of defrost time)
defrosted water is
drained outside the refrigerator.
Timer contact is changed to cooling
operation and the compressor starts
running and the timer motor stops.
Defrost thermostat contact becomes ON
when it’s cooled. And the timer motor
starts running. (Figure F-3.)
Figure F-3.
Figure F-4 .
Figure F-5.
Figure F-6.
TM COMP
Defrost thermostat ON Compressor running
Timer motor running
Timer contact
Defrost
thermostat (ON)
Defrost heater
Thermo. fuse
Compressor
Timer motor
SOURCE
TM COMP
Defrost thermostat OFF Compressor running
Timer motor stops
Thermostat Timer contact
Defrost
thermostat (OFF)
Defrost heater
Thermo. fuse
Compressor
Timer motor
SOURCE
TM COMP
Defrost thermostat OFF Compressor stops
Timer motor running
Thermostat Timer contact
Defrost
thermostat (OFF)
Defrost heater
Thermo. fuse
Compressor
Timer motor
SOURCE
TM COMP
Defrost thermostat ON Compressor stops
Timer motor stops
Thermostat Timer contact
Defrost
thermostat (ON)
Defrost heater
Thermo. fuse
Compressor
Timer motor
SOURCE
Thermostat
The timer contact is changed to start
defrosting, the timer motor stops, and
power is supplied to the defrost heater.
It takes about 20 to 30 min. to defrost.
When little frosted, the defrosting takes
little time. When much frosted, the defrosting takes much time.
Page 10
10
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(4) As a reference to determine the causes of trouble, malfunction and phenomena are described below.
Refer to the following when repairing.
1. Disconnection of defrost heater
As off-cycle defrosting is performed, the defrosting time is extremely prolonged. Each time defrosting is
started, the freezer temperature rises and a portion of ice and stored foods are melted.
2. Melted thermo. fuse or opened-circuit due to the defect of defrost thermostat.
When the above mentioned trouble occurs in cooling operation, the timer motor does not run, defrosting
will not take place, and consequently freezing is caused. In the above mentioned condition, when the timer
shaft is turned by hand to defrost, the timer motor runs during the operation time. However, the motor stops
from the time when the contact is changed, and freezing causes.
NOTE:
As the thermo. fuse assembly is intended to prevent dangers, do not use it under shorted condition even
for a short period.
3. DEW PREVENTION
The hot pipe, namely D.P.-condenser, is arranged around the flange part of
cabinet and the C-partition plate, preventing dew from being generated on
the cabinet.
NOTE:
D.P.-condenser pipe may be felt hot if touched by hand while the
compressor is in operation.
If you are asked about this, please explain that the hot pipe serve to
prevent the dew generation.
Figure F-7
4. INSPECTION OF INITIAL STARTING
(1) Inspection of cooling unit
1. Set the temperature control knob to "MAX" and check that the compressor starts to operate.
2. Depress the door switch to run the fan and check that cool air is blown out of the cold air outlet of the
freezer and the refrigerator.
3. When the compressor does not work, check that the timer is not set to "defrost" position.
4 It takes about an hour and a half or two hours to put food in the refrigerator after starting operation.
NOTE:
After return the temperature control knob to "MED" position.
When the refrigerator is operated initially after installed, the compressor may vibrate excessively for 1 to 2
min. However, vibration becomes normal if it is continuously operated.
(2) Inspection of defrost device
Operate the refrigerator for 20 to 30 min. and then check the defrost device in the following procedures :
Allow 5 min. to restart the compressor since immediate starting after stopping will cause unsmooth operation.
1. Turn the timer shaft clockwise with a screw driver.
At this time, make certains the timer clinks and the compressor stops.
2. After more than 5 min., turn the shaft further to operate.
Make certain cooling operation is started again.
Hot pipe
Page 11
11
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
ASSEMBLING PROCEDURES OF MAIN PARTS AND CAUTIONS
CAUTION: DISCONNECT THE UNIT FROM THE POWER SUPPLY BEFORE ANY REPAIRING.
1. R-CONTROL COV. ASSEMBLY
R-temp. control knob
Nylon band
Fan cover
R-C box cover
RA sealer B
RA sealer C
Dial sealer
RA sealer D
R air guider A
RA sealer A
Damper thermo.
A sealer thermo. cap.
Defrost timer
R fan thermo. ass’y
Figure A-1
After forming, fix it to the refrigerator.
Figure A-2
(1) Forming sensor of Damper thermo.
Stick thermo.
cap. sealer
Less than 130 mm
Damper
thermostat
3
1
mm
5
1
mm
Less than 12 mm
25 2 mm
NOTE
Minimum bending radius is R5mm.
There should be no gas leak by reforming of sensor tube.
+
++
Page 12
12
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(2) Sticking of sealers to R air guider A.
RA sealer A
RA sealer A
RA sealer A
RA sealer CRA sealer B
A sealer
thermo. cap.
A sealer
thermo. cap.
RA sealer D
RA sealer A
RA sealer ARA sealer A
[Front side]
[Back side]
[Bottom side]
Dial sealer
OVERLAP 15mm
OVERLAP 15mm
Figure A-4
10 5mm
+
Cut
R-C box cover
Nylon band
R fan thermo ass’y
Fan cover
Defrost timer
R fan thermo.
ass’y
Nylon band
SEC. G-G
G
G
(3) Fixing of Defrost timer, R fan thermo. ass'y cover to R-C box cover.
Figure A-3
Page 13
13
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
2. R LAMP BOX ASSEMBLY
Lamp socket (with lead wires for R-fan motor)
Lamp 15W
Warning label
R lamp box
Propeller fan 80
R-fan motor
R fan motor holder A
Fan clamp
R fan motor holder B
Figure A-5
(1) Fixing of Lamp and Lamp socket.
(1)-1 Screw Lamp 15W into Lamp socket.
(1)-2 Fix Lamp socket on R lamp box by tapping
screws.
Tapping screw
Lamp socket
Lamp 15W
R lamp box
ALMINUM TAPE
Figure A-6
(1)-3 Insert the terminal of Lamp socket to R-fan motor.
Figure A-7
Fan motor
Lamp socket
DOUBLE CLAMPING WIRES
Page 14
14
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(2) Fixing of R-fan motor and Fan
(2)-1 Set R-fan motor holder A to R lamp box by
tapping screw.
(2)-2 Set R-fan motor to R fan motor holder A by
machine screw.
(2)-3 Set R fan motor holder B to A.
Propeller fan 80
R fan motor holder A
R-fan motor
R fan motor holder B
Fan clamp
Propeller fan 80
F
Shaft
2.3 0.5mm
+
Fan clamp
Slit
Slit of each Fan clamp and Propeller fan
should not be at same position.
Detail of F
(2)-4 Set Fan clamp to Propeller fan 80 and insert it
to the shaft of R-fan motor.
Figure A-9
(3) Sticking Warning label.
Figure A-8
Lamp 15W
Figure A-10
Page 15
15
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
3. E.V COVER ASSEMBLY
Defrost thermo. ass’y
E.V cover
E.V cover
sealer D
(2 pieces)
F-thermostat
L-band C
E.V cover sealer A
Fuse ass’y
E.V cover sealer B
E.V cover sealer C
Lead E.V-cover
ass’y
Fan motor
holder A
Fan motor
holder B
Propeller Fan 100
Fan clamp
Motor
cushion
U-sealer
handle
Fan motor
Figure A-11
Figure A-12
(1) Sticking of Sealers to E.V cover
E.V cover sealer B
E.V cover sealer D (b)
E.V cover sealer D (a)
E.V cover sealer A
E.V cover
Sticking start (b)
Sticking start (a)
Sticking start
Overlap 10mm(min)
[Front side] [Back side]
Sticking start
Page 16
16
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(2) Fixing of Fan motor and Fan
(2)-1 Stick U-sealer handle to Fan motor holder A.
Fan motor holder A
U-sealer handle
U-sealer handle
7 2mm
+
+
0 1mm
C
C
SEC. C-C
Figure A-15
Figure A-13
(2)-4 Set Fan clamp to Propeller fan 100 and insert
it to the shaft of Fan motor.
Fan clamp
Propeller
fan 100
Fan clamp
Slit
Slit of each Fan clamp
and Propeller fan
should not be at same position.
Shaft
4 0.5mm
+
Detail of D
D
(2)-2 Insert the terminals of Lead EV-cover ass'y to
R-fan motor.
(2)-3 Fix two Motor cushions to R-fan motor, and set it
at Fan motor holder A and B.
Then fix with Tapping screw.
Fan motor
holder A
Fan motor
holder B
Motor cushion
Tapping
screw
Fan motor
Lead EV-cover ass’y
RED
BROWN
Figure A-14
Page 17
17
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(3) Setting of Fan motor ass'y , Defrost thermo. ass'y and Fuse ass'y
After inserting, fix with vinyl tape.
60mm
Vinyl tape
(4) Inserting of pins
Alminum
tape
Alminum
tape
Turn up is lead wire
ATTENTION
cut
10 5mm
+
Tapping screw
Tapping
screw
E.V cover
E.V cover
sealer C
E
E
L-band C
L-band C
Defrost
thermo. ass’y
Defrost
thermo. ass’y
Set metal side below
F
F
Fuse ass’y
E.V
cover
Fuse
ass’y
Lead E.Vcover ass’y
Sec. F-F
Sec. E-E
Not come out of claw
Take out lead wire from
square hole to front, and
seal with E.V cover sealer C.
[FRONT SIDE]
more than
3.5mm
more than
3.5mm
Figure A-16
Figure A-18
123
456
789
F-thermostat 3
F-thermostat 4
Fuse 8
Fuse 7
Fan motor 1 , 2
Fan motor 9
(RED, inserted)
(BROWN, inserted)
(WHITE)
Defrost thermo. 5
Defrost thermo. 6
(PINK)
(BLUE)
(BLACK)
WIRE COLOR FOR FAN MOTOR
100-110V : WHITE
127V : YELLOW
220-240V : BLUE
Note Pins should be inserted surely,
and check by pulling it.
Figure A-17
Page 18
18
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
(5) Setting of F-thermostat
(5)-1 Form capillary tube of F-thermostat.
42mm13mm
20mm
20mm
230mm
R10mm
R10mm
Note
• Bending radius of
capillary tube should be
R5mm to R10mm.
Figure A-19
F
F
SEC. F-F
(5)-3 Set to E.V cover.
Figure A-21
(5)-2 Insert terminal of Lead EV-cover ass'y.
RED
BROWN
(front side)
(back side)
Figure A-20
Page 19
19
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
MODIFICATION PROCEDURE OF THE DOOR OPEN SIDE
It is possible to change the door to left side opening.
To modify the door to left side opening, REFRIGERATOR HINGE KITS (for left side opening) SJ-L838LD (optional item )is necessary.
by SJ-L838LD OPERATION MANUAL
These kits are used to change the refrigerator doors from right to left opening.
if you wish to change the door to left opening for some reason, such as restricted installation
space, ask your authorized service agent for this modification.
Tools required
Parts list
Phillips and slotted screwdrivers
Drill bit ( 3.8 mm)
Socket wrench or spanner (8 mm) :The socket wrench or spanner is used to detach and attach hinges.
Always disconnect the power plug from the wall outlet before performing work.
Caution should be taken when handling the doors.
These are heavy and could cause personal injury if mishandled.
Always tighten screws securely. May cause personal injury if door becomes unlatched and falls.
Reattach doors paying careful attention to the door alignment. Failure to fit the door
correctly might cause the cool air to leak out and lower the cooling performance.
Caution
Fitting Instruction
AB
C
D
E
F
G
HJ
Stopper spring L
(for upper door)
Stopper spring L
(for lower door)
Bottom hinge L
Door cap cover
(for upper door)
Door cap cover
(for lower door)
Door hole cover
Screw and Cover
Silicon grease
Preparation/Removing Doors
1
1. Remove Evaporating pan cover, Upper hinge cover, and Top cover.
(Carefully remove Upper hinge cover using a screwdriver, making sure that the door is not damaged.)
2. Remove Upper hinge and Spacer, and detach Upper door by lifting off the center hinge.
3. Remove Center hinge and detach Lower door by lifting off the bottom hinge. Remove the 2 Hole caps, replace them on
the screw holes of the removed center hinge, then screw in G (screw and cover) in the center hole.
4. Remove Bottom hinge. Remove the 3 screws on the left side, then install them in the screw holes of Bottom hinge.
1
Select the same color as the refrigerator exterior.
G
4
4
3
3
1
1
2
3
1
2
3
G
Screw cap for handle
(Spare)
Figure M-1
Page 20
20
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
1. Remove Screw caps and Screws on each door handle, then remove the handles.
Flatten the surface of the screw holes using the handle of a screwdriver, etc., then mount 3 units of F (Door hole covers)
on each door.
2. Remove the Nylon bearings, Door stopper(Lower door only), Stopper springs on the right side of each door and the cap
on the left side of the Upper door. Furthermore, open the hidden holes on the bottom of the door using a screwdriver,
then remove a screw (Lower door only).
3. Remove Screw caps and Screws on the right side of each door, then remove the Door cap covers and mount D and E
(Door cap covers) on the left side.
4. Replace Nylon bearings to the left side of each door, then mount the Upper door cap on the right side. Furthermore,
mount Door stopper and B and C(Stopper springs) on the left side as well. Screw in a screw in the screw hole on the
lower right of the Lower door.
5. Fix upper portion of Upper handle using one screw on the right side of Lower door, then temporarily fix the handle to the
door using tape.
6. To open screw holes, first make marks on the doorplate surface through the 3 holes of the handle, then temporarily
remove the handle (make sure that the dimensions of the markings are as shown in the diagram).
7. Lightly dent the center of each marking, then open holes using a 3.8 mm drill bit.
Use a drill guide, etc., to prevent the drill bit from entering more than 5 mm.
Make sure to open the hole straight. Opening the hole in an angle will cause the handle to clatter.
The door will be unusable if the hole are too large or too deep or if the screws are tightened too much.
8. Mount the handle using the 4 screws and install Screw caps.
9. Mount Lower handle on the right side of Upper door by repeating steps 5. ~ 8. above.
Replacing Handles and Door Parts
2
F
172mm
5mm
172mm
27mm
16mm
F
D
B
C
E
5-8
9
4
4
2
3
3
4
2
2
5,6
7
8
4
2
3
3
1
1
1
1
2
4
2
2
2
(J)
Figure M-2
Page 21
21
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
Mounting the Door/Finishing
1. Apply Silicon grease H to the shaded portion of part A(Bottom hinge L) and attach it to the left side.
2. Insert Lower door and fit Center hinge vertically inverted. Remove washer if installed. Tighten the screws temporarily.
3. Fit Upper door and attach Upper hinge together with spacer. Tighten the screws temporarily.
4. Adjust the alignment of the door. Ensure that the gap between the cabinet and door is 12 mm. Tighten the upper hinge
screws.
5. Secure Upper door. Open Lower door and tighten the center hinge screws. (No drawing)
6. Check the following. To readjust the door position, loosen Center and Bottom hinges.
Whether the distance to activate the door switch is correct.
Whether each door can be opened/closed smoothly.
Whether each door is properly sealed when closed. (Check by inserting a sheet of paper between the door and
cabinet when closing. The refrigerator is not properly sealed if the paper falls.)
7. Apply Silicon grease H to the shaded portion of the door packing.
8. Replace the cap in Evaporating pan cover on the right side.
9. Reattach Evaporating pan cover, Upper hinge cover and Top cover.
10. Make sure that each door can be opened and closed normally. (If any of the doors cannot open/closes normally, tilt the
refrigerator slightly backward by screwing out the two adjustable feet.) Furthermore, connect the power plug, make sure
that cold air is not leaking from the door packing, and that the cabinet lamp operates properly when the door is
opened/closed.
Retain removed parts in case doors are to be changed back to right opening.
3
3
12mm
A
2 1.0mm
3
9
4
6
2
7
1
2
1
9
8
9
2
3
3.5 0.5mm
+
+
Figure M-3
Page 22
22
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
COOLING UNIT
Figure C-1. Cooling unit
Hot pipe L
(Side condenser)
Hot pipe
(DP-condenser)
Hot pipe R
(Side condenser)
Evaporator
Suction pipe
Sub. condenser
Compressor
Capillary tube
Dryer
Back condenser
Mark: Refrigerant flow
Mark: Brazing portion
Page 23
23
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
Charge pipe
to Dryer
Hot pipe
to Dryer
Pinch Point
Sub. condenser to
hot pipe
Pinch point
Charge pipe to
Compressor’s process tube
Compressor’s discharge pipe
to Sub. condenser
Suction pipe to
S.P connector
Dryer
to Capillary tube
Suction pipe to
Compressor’s suction tube
Compressor
Suction pipe
Charge pipe
Charge pipe
Capillary tube
Dryer
Hot pipe
S.P. connector
Sub. condenser Back condenser
Evaporator
Figure C-3. Location
Figure C-2. Location
Page 24
24
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
REPLACEMENT PARTS LIST(SJ-58L-A2G/A2B/A2L)
ELECTRIC PARTS
1-1 RTHM-A097CBEZ F-thermostat 1 1 1 AX
1-2 RSTT-A137CBE0 Starting relay 1 1 1 AL
1-3 QSWTDA025CBE0 Defrost timer 1 1 1 AW
1-4 PDMP-A046CBEZ Damper thermo 1 1 1 AX
1-5 FTHM-A028CBKZ Defrost thermo. ass’y 1 1 1 AN
1-6 RMOTRA036CBE0 Fan motor 1 1 1 AW
1-7 QSOCAA073CBEZ Lamp socket 1 1 1 AN
1-8 RLMP-A002CBE0 Lamp 1 1 1 AE
1-9 QACC-A133CBE0 Source cord 1 1 1 AN
1-10 QSW-PA090CBZA Door switch 1 1 1 AS
1-11 RHOG-A150CBEZ Protector 1 1 1 AN
1-17 FFS-TA055CBKZ Fuse ass’y 1 1 1 AL
1-20 FW-VZA143CBEZ Lead ev-cover ass’y 1 1 1 AL
1-21 FHETBA145CBEZ Def. Heater ass’y 1 1 1 BB
1-22 FCNW-A577CBK0 Relay cord s ass’y 1 1 1 AH
1-27 RMOTRA060CBEZ Fan motor(R-fan motor) 1 1 1 AV
1-28 RLMP-A028CBEZ Lamp15w 1 1 1 AG
1-29 QSOCAA072CBEZ Lamp socket 1 1 1 AN
1-30 FTHM-A027CBKZ R fan thermo ass’y 1 1 1 AQ
MECHANICAL PARTS
2-2 JKNB-A036CBFB F-temp. control knob 1 1 1 AD
2-4 LPLTMA568CBEZ Fl plate al. 1 1 1 AF
2-7 FLEGPA077CBKZ Leg holder l ass’y 1 1 1 AQ
2-7-1 FAJS-A009CBK0 Adjustable leg ass’y 2 2 2 AD
2-7-2 LHLD-A533CBPZ Leg holder l 1 1 1 AL
2-8 FLEGPA078CBKZ Leg holder r ass’y 1 1 1 AQ
2-8-2 LHLD-A534CBPZ Leg holder r 1 1 1 AP
2-11 PSPAVA074CBEA Bottom hinge spacer 1 1 1 AD
2-12 PSPAVA075CBEA Center hinge spacer 1 1 1 AD
2-13 DHNG-A363CBMZ Upper hinge ass’y 1 1 1 AE
2-14 DHNG-A365CBMZ Bottom hinge r ass’y 1 1 1 AE
2-15 DHNG-A364CBMZ Center hinge r ass’y 1 1 1 AF
2-16 GCOV-A191CBFZ E.v cover 1 1 1 AS
2-17 LCRA-A010CBE0 Fan clamp 2 2 2 AD
2-19 LHLD-A389CBF0 Motor cushion 2 2 2 AF
2-20 NFANPA020CBFA Propeller fan 100 1 1 1 AE
2-21 PSEL-B845CBEZ E.v cover sealer a 1 1 1 AC
2-22 PSEL-B846CBEZ E.v cover sealer b 1 1 1 AC
2-23 PSEL-A415CBE0 E.v cover sealer c 1 1 1 AC
2-24 PCOVPA175CBFA Terminal cover 1 1 1 AF
2-25 PCOV-A253CBFA F lamp cover 1 1 1 AC
2-26 PCOV-A254CBFA R lamp cover 1 1 1 AF
2-27 GCOVPA117CBRA R-c box cover 1 1 1 AT
2-28 HGRL-A182CBRA Fan louver 1 1 1 AW
2-29 GCOV-A162CBFG Upper hinge cover 1 - - AD
2-29 GCOV-A162CBFB Upper hinge cover - 1 - AD
2-29 GCOV-A162CBFK Upper hinge cover - - 1 AL
2-30 PCOV-A255CBFA Fan cover 2 2 2 AD
2-31 JKNB-A033CBFB R-temp. control knob 1 1 1 AD
2-36 PCAP-A006CBFX Screw cover 2 - - AB
2-36 PCAP-A006CBFS Screw cover - 2 - AB
2-36 PCAP-A006CBFU Screw cover - - 2 AB
2-37 PCAP-A056CBFF Screw cover b 2 2 2 AC
2-38 PGID-A156CBFZ R air guider a 1 1 1 AG
2-41 PSEL-B848CBEZ A-sealer thermo. cap 1 1 1 AC
2-49 LSTPPA108CBFA Chilled stopper 2 2 2 AC
2-50 NFANPA019CBFA Propeller fan 80 1 1 1 AM
2-51 PBOX-A121CBFA F lamp box 1 1 1 AF
2-52 PBOX-A122CBFA R lamp box 1 1 1 AM
2-53 LHLD-A536CBFA R fan motor holder a 1 1 1 AF
2-54 LHLD-A537CBFA R fan motor holder b 1 1 1 AE
2-55 HGRL-A188CBFA Multi louver s 1 1 1 AG
2-56 PFPFPB248CBFZ R-louver insu. s 1 1 1 AE
2-57 PSEL-B861CBEZ A-sealer r-louver 2 2 2 AC
2-59 PCOV-A264CBEZ F lamp box cover 1 1 1 AC
2-63 LHLD-A484CBFA Fan motor holder b 1 1 1 AH
2-64 LHLD-A485CBFA Fan motor holder a 1 1 1 AH
2-65 PSEL-B209CBE0 U-sealer handle 2 2 2 AB
2-66 PSHEMA132CBP0 Heater cover al 1 1 1 AD
2-67 LPLTMA570CBPZ Drain support al 1 1 1 AE
2-69 PSEL-B847CBEZ E.v cover sealer d 2 2 2 AC
2-71 PSEL-A552CBE0 Dial sealer 1 1 1 AC
SJ- SJ- SJ-
58L-A2G 58L-A2B 58L-A2L
Page 25
25
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
SJ- SJ- SJ-
58L-A2G 58L-A2B 58L-A2L
2-72 PSEL-B841CBEZ Ra sealer a 2 2 2 AC
2-73 PSEL-B842CBEZ Ra sealer b 1 1 1 AC
2-74 PSEL-B122CBE0 A-sealer thermo. cap. 1 1 1 AB
2-77 LHLD-A359CBFA T-box holder 1 1 1 AE
2-78 LPLTMA399CBP0 Dryer support 1 1 1 AD
2-79 LBND-A019CBE0 Nylon band 1 1 1 AB
2-80 PBOX-A078CBFA Terminal box 1 1 1 AG
2-81 PPIPPA097CBEZ Drain pipe s 1 1 1 AE
2-83 PSEL-B849CBEZ Ra sealer c 1 1 1 AC
2-84 PSEL-B850CBEZ Ra sealer d 1 1 1 AC
2-86 LBND-A026CBE0 Nylon band 1 1 1 AD
2-90 HGRL-A179CBFA F shower duct 1 1 1 AM
2-91 HGRL-A180CBFA F return cover 2 2 2 AC
2-93 PCAP-A068CBFA C sliding cap a 2 2 2 AC
2-95 NROL-A027CBEZ V roller 2 2 2 AC
2-96 LHLD-A535CBFA Shaft holder 2 2 2 AC
2-97 LPIN-A178CB1Z Shaft 2 2 2 AC
2-99 GCOV-A192CBFA Top cover 1 - - AC
2-99 GCOV-A192CBFB Top cover - 1 - AK
2-99 GCOV-A192CBFF Top cover - - 1 AC
2-103 PSEL-B894CBEZ F-shower ins. a 1 1 1 AF
2-104 PSEL-B895CBEZ F-shower ins. b 1 1 1 AE
2-105 PSEL-B896CBEZ A-sealer fs-a 1 1 1 AC
2-106 PSEL-B897CBEZ A-sealer fs-b 2 2 2 AC
DOOR PARTS
3-5 FDORFB299CBKZ F-door ass’y 1 - - BK
3-5 FDORFB306CBKZ F-door ass’y - 1 - BM
3-5 FDORFB313CBKZ F-door ass’y - - 1 BL
3-5-1 LSTPPA107CBFA Fd stopper spring r 1 1 1 AD
3-5-2 NBRGPA022CBFA Nylon bearing 3s 2 2 2 AC
3-5-3 PCOV-A251CBFA Dc cover fr 1 - - AC
3-5-3 PCOV-A251CBFB Dc cover fr - 1 - AC
3-5-3 PCOV-A251CBFF Dc cover fr - - 1 AC
3-6 FPACGA309CBKZ F-door packing 1 1 1 AX
3-7 HDECQA384CBFA Handle trim fl 1 1 1 AD
3-8 JHNDPA117CBFA Door handle fl 1 - - AK
3-8 JHNDPA117CBFB Door handle fl - 1 - AM
3-8 JHNDPA117CBFF Door handle fl - - 1 AP
3-9 PCAP-A067CBFA Screw cover hd 10 - - AC
3-9 PCAP-A067CBFB Screw cover hd - 10 - AC
3-9 PCAP-A067CBFF Screw cover hd - - 10 AC
3-15 FDORRB181CBKZ R-door ass’y 1 - - BP
3-15 FDORRB183CBKZ R-door ass’y - 1 - BP
3-15 FDORRB189CBKZ R-door ass’y - - 1 BN
3-15-1 LSTP-A058CBM0 R-door stopper r 1 1 1 AF
3-15-2 LSTPPA084CBFA Rd-stopper spring r 1 1 1 AD
3-15-3 PCOV-A252CBFA Dc cover rr 1 - - AC
3-15-3 PCOV-A252CBFB Dc cover rr - 1 - AC
3-15-3 PCOV-A252CBFF Dc cover rr - - 1 AC
3-17 FPACGA315CBKZ R-door packing 1 1 1 AY
3-18 HDECQA385CBFA Handle trim rl 1 1 1 AG
3-19 JHNDPA118CBFA Door handle rl 1 - - AK
3-19 JHNDPA118CBFB Door handle rl - 1 - AM
3-19 JHNDPA118CBFF Door handle rl - - 1 AN
3-25 FBDGDA280CBYZ Badge ass’y 1 1 1 AY
OTHER PARTS
4-1 LBND-A023CBE0 L-band c 4 4 4 AC
4-3 LX-VZA003CBE0 Special screw 2 2 2 AB
4-10 QTAN-A013CBE0 Solderless term. a 4 4 4 AH
4-14 LX-WZA013CBE0 Hinge washer 1 1 1 AB
4-15 LX-BZ0202JBE0 Special screw 1 1 1 AA
4-17 LX-WZA003CBE0 Washer 4 4 4 AA
4-18 LX-BZA076CBEZ Handle screw 10 10 10 AC
ATTACHMENT PARTS
5-1 UPOK-A166CBRA Bottle pocket 2 2 2 AN
5-3 UPOK-A168CBRA F door pocket 2 2 2 AP
5-4 UPOK-A165CBRA R door pocket 1 1 1 AN
5-5 UTNA-A282CBFB Egg tray 2 2 2 AG
5-6 FSRA-A193CBYZ Ice cube maker 1 1 1 AS
5-9 FSRA-A194CBKZ F shelf ass’y 1 1 1 AY
5-13 HGRL-A178CBFA Ventilating grille 1 - - AG
5-13 HGRL-A178CBFB Ventilating grille - 1 - AM
Page 26
26
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
HOW TO ORDER REPLACEMENT PARTS
To have your order filled promptly and correctly, please furnish the following information.
1. MODEL NUMBER 2. REF. NO.
3. PART NO. 4. DESCRIPTION
SJ- SJ- SJ-
58L-A2G 58L-A2B 58L-A2L
5-13 HGRL-A178CBFF Ventilating grille - - 1 AN
5-14 USRA-A252CBFA Drain pan 1 1 1 AN
5-15 UYOK-A330CBFA Fruit case 1 1 1 AW
5-16 UYOK-A331CBFA Vegetable case 1 1 1 AZ
5-17 UYOK-A328CBFA Ice storage box 1 1 1 AF
5-18 UYOK-A329CBFA Chilled case 1 1 1 AX
5-19 GDORPA066CBRA Chilled door 1 1 1 AP
5-24 FTNA-A301CBKZ R glass shelf ass’y 1 1 1 BC
5-25 FTNA-A302CBKZ V glass shelf ass’y 1 1 1 BC
5-26 PCAP-A076CBFA Venti. Grille cap 1 - - AC
5-26 PCAP-A076CBFB Venti. Grille cap - 1 - AC
5-26 PCAP-A076CBFF Venti. Grille cap - - 1 AC
5-28 PCAP-A069CBFA V sliding cap l 1 1 1 AC
5-29 PCAP-A070CBFA V sliding cap r 1 1 1 AC
5-31 LRALPA132CBFA Ice tray holder l 1 1 1 AF
5-32 LRALPA133CBFA Ice tray holder r 1 1 1 AF
5-33 LRALPA134CBFA Ice tray holder b 1 1 1 AF
5-34 PCUP-A009CBFA Water cup 1 1 1 AD
5-35 UPOKPA251CBFA Tube stand 2 2 2 AC
5-36 PCOV-A259CBFA Case cover 1 1 1 AH
5-37 UPOK-A167CBRA Utility case pocket 1 1 1 AM
CYCLE PARTS
6-1 PCMPLA201CBEZ Compressor 1 1 1 BX
6-2 PSPAGA054CBEZ Rubber grommet 4 4 4 AH
6-3 FCONSA076CBKZ Sub. Condenser ass’y 1 1 1 AP
6-3-1 PCOV-A256CBFA Pipe protector l 1 1 1 AF
6-3-2 PCOV-A257CBFA Pipe protector r 1 1 1 AF
6-4 FFRM-A112CBKZ Base frame ass’y 1 1 1 AG
6-5 FDRY-A006CBK0 Dryer ass’y 1 1 1 AX
6-9 PSPAFA047CBEZ Sleeve 4 4 4 AE
6-11 PPIPCA356CBEZ S.p connector 1 1 1 AG
6-14 PGUM-A004CBF0 Absorbent rubber a 1 1 1 AH
6-15 PGUM-A002CBF0 Absorbent rubber b 1 1 1 AH
6-18 PPIPCA252CBE0 Charge pipe 2 2 2 AD
6-21 PCOVPA260CBEZ Terminal cover 1 1 1 AK
6-27 PSEL-B899CBEZ S-sealer 1 1 1 AC
MISCELLANEOUS
90-1 TINS-A458CBRZ Operation manual 1 1 1 AF
90-2 TLAB-A473CBR0 Lamp label 1 1 1 AB
90-3 SPAKCI779YDEZ Packing case 58l-f 1 1 1 BC
90-5 TLAB-A897CBEZ Case label a2g 4 - - AC
90-5 TLAB-A916CBEZ Case label a2b - 4 - AC
90-5 TLAB-A927CBEZ Case label a2l - - 4 AC
90-6 CPADBA765YDKZ Bottom pad ass’y 1 1 1 AY
90-7 CPADBA764YDKZ Top pad ass’y 1 1 1 AR
90-8 TLAB-A874CBRZ Warning label 1 1 1 AC
90-9 TINS-A366CBR0 Srv. Station list 1 1 1 AC
Page 27
27
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
REPLACEMENT PARTS LIST(SJ-63L-A2G/A2B/A2L)
ELECTRIC PARTS
1-1 RTHM-A097CBEZ F-thermostat 1 1 1 AX
1-2 RSTT-A137CBE0 Starting relay 1 1 1 AL
1-3 QSWTDA025CBE0 Defrost timer 1 1 1 AW
1-4 PDMP-A046CBEZ Damper thermo 1 1 1 AX
1-5 FTHM-A028CBKZ Defrost thermo. ass’y 1 1 1 AN
1-6 RMOTRA036CBE0 Fan motor 1 1 1 AW
1-7 QSOCAA073CBEZ Lamp socket 1 1 1 AN
1-8 RLMP-A002CBE0 Lamp 1 1 1 AE
1-9 QACC-A133CBE0 Source cord 1 1 1 AN
1-10 QSW-PA090CBZA Door switch 1 1 1 AS
1-11 RHOG-A150CBEZ Protector 1 1 1 AN
1-17 FFS-TA055CBKZ Fuse ass’y 1 1 1 AL
1-20 FW-VZA143CBEZ Lead ev-cover ass’y 1 1 1 AL
1-21 FHETBA145CBEZ Def. Heater ass’y 1 1 1 BB
1-22 FCNW-A577CBK0 Relay cord s ass’y 1 1 1 AH
1-27 RMOTRA060CBEZ Fan motor(R-fan motor) 1 1 1 AV
1-28 RLMP-A028CBEZ Lamp15w 1 1 1 AG
1-29 QSOCAA072CBEZ Lamp socket 1 1 1 AN
1-30 FTHM-A027CBKZ R fan thermo ass’y 1 1 1 AQ
MECHANICAL PARTS
2-2 JKNB-A036CBFB F-temp. control knob 1 1 1 AD
2-4 LPLTMA568CBEZ Fl plate al. 1 1 1 AF
2-7 FLEGPA077CBKZ Leg holder l ass’y 1 1 1 AQ
2-7-1 FAJS-A009CBK0 Adjustable leg ass’y 2 2 2 AD
2-7-2 LHLD-A533CBPZ Leg holder l 1 1 1 AL
2-8 FLEGPA078CBKZ Leg holder r ass’y 1 1 1 AQ
2-8-2 LHLD-A534CBPZ Leg holder r 1 1 1 AP
2-11 PSPAVA074CBEA Bottom hinge spacer 1 1 1 AD
2-12 PSPAVA075CBEA Center hinge spacer 1 1 1 AD
2-13 DHNG-A363CBMZ Upper hinge ass’y 1 1 1 AE
2-14 DHNG-A365CBMZ Bottom hinge r ass’y 1 1 1 AE
2-15 DHNG-A364CBMZ Center hinge r ass’y 1 1 1 AF
2-16 GCOV-A191CBFZ E.v cover 1 1 1 AS
2-17 LCRA-A010CBE0 Fan clamp 2 2 2 AD
2-19 LHLD-A389CBF0 Motor cushion 2 2 2 AF
2-20 NFANPA020CBFA Propeller fan 100 1 1 1 AE
2-21 PSEL-B845CBEZ E.v cover sealer a 1 1 1 AC
2-22 PSEL-B846CBEZ E.v cover sealer b 1 1 1 AC
2-23 PSEL-A415CBE0 E.v cover sealer c 1 1 1 AC
2-24 PCOVPA175CBFA Terminal cover 1 1 1 AF
2-25 PCOV-A253CBFA F lamp cover 1 1 1 AC
2-26 PCOV-A254CBFA R lamp cover 1 1 1 AF
2-27 GCOVPA117CBRA R-c box cover 1 1 1 AT
2-28 HGRL-A182CBRA Fan louver 1 1 1 AW
2-29 GCOV-A162CBFG Upper hinge cover 1 - - AD
2-29 GCOV-A162CBFB Upper hinge cover - 1 - AD
2-29 GCOV-A162CBFK Upper hinge cover - - 1 AL
2-30 PCOV-A255CBFA Fan cover 2 2 2 AD
2-31 JKNB-A033CBFB R-temp. control knob 1 1 1 AD
2-36 PCAP-A006CBFX Screw cover 2 - - AB
2-36 PCAP-A006CBFS Screw cover - 2 - AB
2-36 PCAP-A006CBFU Screw cover - - 2 AB
2-37 PCAP-A056CBFF Screw cover b 2 2 2 AC
2-38 PGID-A156CBFZ R air guider a 1 1 1 AG
2-41 PSEL-B848CBEZ A-sealer thermo. cap 1 1 1 AC
2-49 LSTPPA108CBFA Chilled stopper 2 2 2 AC
2-50 NFANPA019CBFA Propeller fan 80 1 1 1 AM
2-51 PBOX-A121CBFA F lamp box 1 1 1 AF
2-52 PBOX-A122CBFA R lamp box 1 1 1 AM
2-53 LHLD-A536CBFA R fan motor holder a 1 1 1 AF
2-54 LHLD-A537CBFA R fan motor holder b 1 1 1 AE
2-55 HGRL-A186CBFA Multi louver m 1 1 1 AG
2-56 PFPFPB239CBFZ R-louver insu. M 1 1 1 AE
2-57 PSEL-B857CBEZ A-sealer r-louver 2 2 2 AC
2-59 PCOV-A264CBEZ F lamp box cover 1 1 1 AC
2-63 LHLD-A484CBFA Fan motor holder b 1 1 1 AH
2-64 LHLD-A485CBFA Fan motor holder a 1 1 1 AH
2-65 PSEL-B209CBE0 U-sealer handle 2 2 2 AB
2-66 PSHEMA132CBP0 Heater cover al 1 1 1 AD
2-67 LPLTMA570CBPZ Drain support al 1 1 1 AE
2-69 PSEL-B847CBEZ E.v cover sealer d 2 2 2 AC
2-71 PSEL-A552CBE0 Dial sealer 1 1 1 AC
SJ- SJ- SJ-
63L-A2G 63L-A2B 63L-A2L
Page 28
28
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
SJ- SJ- SJ-
63L-A2G 63L-A2B 63L-A2L
2-72 PSEL-B841CBEZ Ra sealer a 2 2 2 AC
2-73 PSEL-B842CBEZ Ra sealer b 1 1 1 AC
2-74 PSEL-B122CBE0 A-sealer thermo. cap. 1 1 1 AB
2-77 LHLD-A359CBFA T-box holder 1 1 1 AE
2-78 LPLTMA399CBP0 Dryer support 1 1 1 AD
2-79 LBND-A019CBE0 Nylon band 1 1 1 AB
2-80 PBOX-A078CBFA Terminal box 1 1 1 AG
2-81 PPIPPA097CBEZ Drain pipe s 1 1 1 AE
2-83 PSEL-B849CBEZ Ra sealer c 1 1 1 AC
2-84 PSEL-B850CBEZ Ra sealer d 1 1 1 AC
2-86 LBND-A026CBE0 Nylon band 1 1 1 AD
2-90 HGRL-A179CBFA F shower duct 1 1 1 AM
2-91 HGRL-A180CBFA F return cover 2 2 2 AC
2-93 PCAP-A068CBFA C sliding cap a 2 2 2 AC
2-95 NROL-A027CBEZ V roller 2 2 2 AC
2-96 LHLD-A535CBFA Shaft holder 2 2 2 AC
2-97 LPIN-A178CB1Z Shaft 2 2 2 AC
2-99 GCOV-A192CBFA Top cover 1 - - AC
2-99 GCOV-A192CBFB Top cover - 1 - AK
2-99 GCOV-A192CBFF Top cover - - 1 AC
2-103 PSEL-B894CBEZ F-shower ins. a 1 1 1 AF
2-104 PSEL-B895CBEZ F-shower ins. b 1 1 1 AE
2-105 PSEL-B896CBEZ A-sealer fs-a 1 1 1 AC
2-106 PSEL-B897CBEZ A-sealer fs-b 2 2 2 AC
DOOR PARTS
3-5 FDORFB299CBKZ F-door ass’y 1 - - BK
3-5 FDORFB306CBKZ F-door ass’y - 1 - BM
3-5 FDORFB313CBKZ F-door ass’y - - 1 BL
3-5-1 LSTPPA107CBFA Fd stopper spring r 1 1 1 AD
3-5-2 NBRGPA022CBFA Nylon bearing 3s 2 2 2 AC
3-5-3 PCOV-A251CBFA Dc cover fr 1 - - AC
3-5-3 PCOV-A251CBFB Dc cover fr - 1 - AC
3-5-3 PCOV-A251CBFF Dc cover fr - - 1 AC
3-6 FPACGA309CBKZ F-door packing 1 1 1 AX
3-7 HDECQA384CBFA Handle trim fl 1 1 1 AD
3-8 JHNDPA117CBFA Door handle fl 1 - - AK
3-8 JHNDPA117CBFB Door handle fl - 1 - AM
3-8 JHNDPA117CBFF Door handle fl - - 1 AP
3-9 PCAP-A067CBFA Screw cover hd 10 - - AC
3-9 PCAP-A067CBFB Screw cover hd - 10 - AC
3-9 PCAP-A067CBFF Screw cover hd - - 10 AC
3-15 FDORRB173CBKZ R-door ass’y 1 - - BQ
3-15 FDORRB174CBKZ R-door ass’y - 1 - BQ
3-15 FDORRB182CBKZ R-door ass’y - - 1 BR
3-15-1 LSTP-A058CBM0 R-door stopper r 1 1 1 AF
3-15-2 LSTPPA084CBFA Rd-stopper spring r 1 1 1 AD
3-15-3 PCOV-A252CBFA Dc cover rr 1 - - AC
3-15-3 PCOV-A252CBFB Dc cover rr - 1 - AC
3-15-3 PCOV-A252CBFF Dc cover rr - - 1 AC
3-17 FPACGA314CBKZ R-door packing 1 1 1 AY
3-18 HDECQA385CBFA Handle trim rl 1 1 1 AG
3-19 JHNDPA118CBFA Door handle rl 1 - - AK
3-19 JHNDPA118CBFB Door handle rl - 1 - AM
3-19 JHNDPA118CBFF Door handle rl - - 1 AP
3-25 FBDGDA280CBYZ Badge ass’y 1 1 1 AY
OTHER PARTS
4-1 LBND-A023CBE0 L-band c 4 4 4 AC
4-3 LX-VZA003CBE0 Special screw 2 2 2 AB
4-10 QTAN-A013CBE0 Solderless term. a 4 4 4 AH
4-14 LX-WZA013CBE0 Hinge washer 1 1 1 AB
4-15 LX-BZ0202JBE0 Special screw 1 1 1 AA
4-17 LX-WZA003CBE0 Washer 4 4 4 AA
4-18 LX-BZA076CBEZ Handle screw 10 10 10 AC
ATTACHMENT PARTS
5-1 UPOK-A166CBRA Bottle pocket 2 2 2 AN
5-3 UPOK-A168CBRA F door pocket 2 2 2 AP
5-4 UPOK-A165CBRA R door pocket 1 1 1 AN
5-5 UTNA-A282CBFB Egg tray 2 2 2 AG
5-6 FSRA-A193CBYZ Ice cube maker 1 1 1 AS
5-9 FSRA-A194CBKZ F shelf ass’y 1 1 1 AY
5-13 HGRL-A178CBFA Ventilating grille 1 - - AG
5-13 HGRL-A178CBFB V entilating grille - 1 - AM
Page 29
29
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
HOW TO ORDER REPLACEMENT PARTS
To have your order filled promptly and correctly, please furnish the following information.
1. MODEL NUMBER 2. REF. NO.
3. PART NO. 4. DESCRIPTION
SJ- SJ- SJ-
63L-A2G 63L-A2B 63L-A2L
5-13 HGRL-A178CBFF V entilating grille - - 1 AN
5-14 USRA-A252CBFA Drain pan 1 1 1 AN
5-15 UYOK-A330CBFA Fruit case 1 1 1 AW
5-16 UYOK-A331CBFA Vegetable case 1 1 1 AZ
5-17 UYOK-A328CBFA Ice storage box 1 1 1 AF
5-18 UYOK-A329CBFA Chilled case 1 1 1 AX
5-19 GDORPA066CBRA Chilled door 1 1 1 AP
5-24 FTNA-A301CBKZ R glass shelf ass’y 2 2 2 BC
5-25 FTNA-A302CBKZ V glass shelf ass’y 1 1 1 BC
5-26 PCAP-A076CBFA Venti. Grille cap 1 - - AC
5-26 PCAP-A076CBFB Venti. Grille cap - 1 - AC
5-26 PCAP-A076CBFF Venti. Grille cap - - 1 AC
5-28 PCAP-A069CBFA V sliding cap l 1 1 1 AC
5-29 PCAP-A070CBFA V sliding cap r 1 1 1 AC
5-31 LRALPA132CBFA Ice tray holder l 1 1 1 AF
5-32 LRALPA133CBFA Ice tray holder r 1 1 1 AF
5-33 LRALPA134CBFA Ice tray holder b 1 1 1 AF
5-34 PCUP-A009CBFA Water cup 1 1 1 AD
5-35 UPOKPA251CBFA Tube stand 2 2 2 AC
5-36 PCOV-A259CBFA Case cover 1 1 1 AH
5-37 UPOK-A167CBRA Utility case pocket 1 1 1 AM
CYCLE PARTS
6-1 PCMPLA201CBEZ Compressor 1 1 1 BX
6-2 PSPAGA054CBEZ Rubber grommet 4 4 4 AH
6-3 FCONSA076CBKZ Sub. Condenser ass’y 1 1 1 AP
6-3-1 PCOV-A256CBFA Pipe protector l 1 1 1 AF
6-3-2 PCOV-A257CBFA Pipe protector r 1 1 1 AF
6-4 FFRM-A112CBKZ Base frame ass’y 1 1 1 AG
6-5 FDRY-A006CBK0 Dryer ass’y 1 1 1 AX
6-9 PSPAFA047CBEZ Sleeve 4 4 4 AE
6-11 PPIPCA356CBEZ S.p connector 1 1 1 AG
6-14 PGUM-A004CBF0 Absorbent rubber a 1 1 1 AH
6-15 PGUM-A002CBF0 Absorbent rubber b 1 1 1 AH
6-18 PPIPCA252CBE0 Charge pipe 2 2 2 AD
6-21 PCOVPA260CBEZ Terminal cover 1 1 1 AK
6-27 PSEL-B899CBEZ S-sealer 1 1 1 AC
MISCELLANEOUS
90-1 TINS-A458CBRZ Operation manual 1 1 1 AF
90-2 TLAB-A473CBR0 Lamp label 1 1 1 AB
90-3 SPAKCI763YDEZ Packing case 63l-f 1 1 1 BD
90-5 TLAB-A897CBEZ Case label a2g 4 - - AC
90-5 TLAB-A916CBEZ Case label a2b - 4 - AC
90-5 TLAB-A927CBEZ Case label a2l - - 4 AC
90-6 CPADBA765YDKZ Bottom pad ass’y 1 1 1 AY
90-7 CPADBA764YDKZ Top pad ass’y 1 1 1 AR
90-8 TLAB-A874CBRZ Warning label 1 1 1 AC
90-9 TINS-A366CBR0 Srv. Station list 1 1 1 AC
Page 30
30
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
REPLACEMENT PARTS LIST(SJ-68L-A2G/A2B/A2L/R2G)
SJ-68L SJ-68L SJ-68L SJ-68L
-A2G -A2B -A2L -R2G
ELECTRIC PARTS
1-1 RTHM-A097CBEZ F-thermostat 1111 AX
1-2 RSTT-A137CBE0 Starting relay 1111 AL
1-3 QSWTDA025CBE0 Defrost timer 1111 AW
1-4 PDMP-A046CBEZ Damper thermo 1111 AX
1-5 FTHM-A028CBKZ Defrost thermo. ass’y 1111 AN
1-6 RMOTRA036CBE0 Fan motor 1111 AW
1-7 QSOCAA073CBEZ Lamp socket 1111 AN
1-8 RLMP-A002CBE0 Lamp 1111 AE
1-9 QACC-A133CBE0 Source cord 1111 AN
1-10 QSW-PA090CBZA Door switch 1111 AS
1-11 RHOG-A150CBEZ Protector 1111 AN
1-17 FFS-TA055CBKZ Fuse ass’y 1111 AL
1-20 FW-VZA143CBEZ Lead ev-cover ass’y 1111 AL
1-21 FHETBA145CBEZ Def. Heater ass’y 1111 BB
1-22 FCNW-A577CBK0 Relay cord s ass’y 1111 AH
1-27 RMOTRA060CBEZ Fan motor(R-fan motor) 1111 AV
1-28 RLMP-A028CBEZ Lamp15w 1111 AG
1-29 QSOCAA072CBEZ Lamp socket 1111 AN
1-30 FTHM-A027CBKZ R fan thermo ass’y 1111 AQ
MECHANICAL PARTS
2-2 JKNB-A036CBFB F-temp. control knob 1111 AD
2-4 LPLTMA568CBEZ Fl plate al. 1111 AF
2-7 FLEGPA077CBKZ Leg holder l ass’y 1111 AQ
2-7-1 FAJS-A009CBK0 Adjustable leg ass’y 2222 AD
2-7-2 LHLD-A533CBPZ Leg holder l 1111 AL
2-8 FLEGPA078CBKZ Leg holder r ass’y 1111 AQ
2-8-2 LHLD-A534CBPZ Leg holder r 1111 AP
2-11 PSPAVA074CBEA Bottom hinge spacer 1111 AD
2-12 PSPAVA075CBEA Center hinge spacer 1111 AD
2-13 DHNG-A363CBMZ Upper hinge ass’y 1111 AE
2-14 DHNG-A365CBMZ Bottom hinge r ass’y 1111 AE
2-15 DHNG-A364CBMZ Center hinge r ass’y 1111 AF
2-16 GCOV-A191CBFZ E.v cover 1111 AS
2-17 LCRA-A010CBE0 Fan clamp 2222 AD
2-19 LHLD-A389CBF0 Motor cushion 2222 AF
2-20 NFANPA020CBFA Propeller fan 100 1111 AE
2-21 PSEL-B845CBEZ E.v cover sealer a 1111 AC
2-22 PSEL-B846CBEZ E.v cover sealer b 1111 AC
2-23 PSEL-A415CBE0 E.v cover sealer c 1111 AC
2-24 PCOVPA175CBFA Terminal cover 1111 AF
2-25 PCOV-A253CBFA F lamp cover 1111 AC
2-26 PCOV-A254CBFA R lamp cover 1111 AF
2-27 GCOVPA117CBRA R-c box cover 1111 AT
2-28 HGRL-A182CBRA Fan louver 1111 AW
2-29 GCOV-A162CBFG Upper hinge cover 1--1 AD
2-29 GCOV-A162CBFB Upper hinge cover -1-- AD
2-29 GCOV-A162CBFK Upper hinge cover --1- AL
2-30 PCOV-A255CBFA Fan cover 2222 AD
2-31 JKNB-A033CBFB R-temp. control knob 1111 AD
2-36 PCAP-A006CBFX Screw cover 2--2 AB
2-36 PCAP-A006CBFS Screw cover -2-- AB
2-36 PCAP-A006CBFU Screw cover --2- AB
2-37 PCAP-A056CBFF Screw cover b 2222 AC
2-38 PGID-A156CBFZ R air guider a 1111 AG
2-41 PSEL-B848CBEZ A-sealer thermo. cap 1111 AC
2-49 LSTPPA108CBFA Chilled stopper 2222 AC
2-50 NFANPA019CBFA Propeller fan 80 1111 AM
2-51 PBOX-A121CBFA F lamp box 1111 AF
2-52 PBOX-A122CBFA R lamp box 1111 AM
2-53 LHLD-A536CBFA R fan motor holder a 1111 AF
2-54 LHLD-A537CBFA R fan motor holder b 1111 AE
2-55 HGRL-A181CBFA Multi louver l 1111 AG
2-56 PFPFPB233CBFZ R-louver insu. L 1111 AE
2-57 PSEL-B843CBEZ A-sealer r-louver 2222 AC
2-59 PCOV-A264CBEZ F lamp box cover 1111 AC
2-63 LHLD-A484CBFA Fan motor holder b 1111 AH
2-64 LHLD-A485CBFA Fan motor holder a 1111 AH
2-65 PSEL-B209CBE0 U-sealer handle 2222 AB
2-66 PSHEMA132CBP0 Heater cover al 1111 AD
2-67 LPLTMA570CBPZ Drain support al 1111 AE
2-69 PSEL-B847CBEZ E.v cover sealer d 2222 AC
2-71 PSEL-A552CBE0 Dial sealer 1111 AC
Page 31
31
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
SJ-68L SJ-68L SJ-68L SJ-68L
-A2G -A2B -A2L -R2G
2-72 PSEL-B841CBEZ Ra sealer a 2 2 2 2 AC
2-73 PSEL-B842CBEZ Ra sealer b 1 1 1 1 AC
2-74 PSEL-B122CBE0 A-sealer thermo. cap. 1 1 1 1 AB
2-77 LHLD-A359CBFA T-box holder 1 1 1 1 AE
2-78 LPLTMA399CBP0 Dryer support 1 1 1 1 AD
2-79 LBND-A019CBE0 Nylon band 1 1 1 1 AB
2-80 PBOX-A078CBFA Terminal box 1 1 1 1 AG
2-81 PPIPPA097CBEZ Drain pipe s 1 1 1 1 AE
2-83 PSEL-B849CBEZ Ra sealer c 1 1 1 1 AC
2-84 PSEL-B850CBEZ Ra sealer d 1 1 1 1 AC
2-86 LBND-A026CBE0 Nylon band 1 1 1 1 AD
2-90 HGRL-A179CBFA F shower duct 1 1 1 1 AM
2-91 HGRL-A180CBFA F return cover 2 2 2 2 AC
2-93 PCAP-A068CBFA C sliding cap a 2 2 2 2 AC
2-95 NROL-A027CBEZ V roller 2 2 2 2 AC
2-96 LHLD-A535CBFA Shaft holder 2 2 2 2 AC
2-97 LPIN-A178CB1Z Shaft 2 2 2 2 AC
2-99 GCOV-A192CBFA Top cover 1 - - 1 AC
2-99 GCOV-A192CBFB Top cover - 1 - - AK
2-99 GCOV-A192CBFF Top cover - - 1 - AC
2-103 PSEL-B894CBEZ F-shower ins. a 1 1 1 1 AF
2-104 PSEL-B895CBEZ F-shower ins. b 1 1 1 1 AE
2-105 PSEL-B896CBEZ A-sealer fs-a 1 1 1 1 AC
2-106 PSEL-B897CBEZ A-sealer fs-b 2 2 2 2 AC
DOOR PARTS
3-5 FDORFB299CBKZ F-door ass’y 1 - - 1 BK
3-5 FDORFB306CBKZ F-door ass’y - 1 - - BM
3-5 FDORFB313CBKZ F-door ass’y - - 1 - BL
3-5-1 LSTPPA107CBFA Fd stopper spring r 1 1 1 1 AD
3-5-2 NBRGPA022CBFA Nylon bearing 3s 2 2 2 2 AC
3-5-3 PCOV-A251CBFA Dc cover fr 1 - - 1 AC
3-5-3 PCOV-A251CBFB Dc cover fr - 1 - - AC
3-5-3 PCOV-A251CBFF Dc cover fr - - 1 - AC
3-6 FPACGA309CBKZ F-door packing 1 1 1 1 AX
3-7 HDECQA384CBFA Handle trim fl 1 1 1 1 AD
3-8 JHNDPA117CBFA Door handle fl 1 - - 1 AK
3-8 JHNDPA117CBFB Door handle fl - 1 - - AM
3-8 JHNDPA117CBFF Door handle fl - - 1 - AP
3-9 PCAP-A067CBFA Screw cover hd 10 - - 10 AC
3-9 PCAP-A067CBFB Screw cover hd - 10 - - AC
3-9 PCAP-A067CBFF Screw cover hd - - 10 - AC
3-15 FDORRB166CBKZ R-door ass’y 1 - - 1 BQ
3-15 FDORRB168CBKZ R-door ass’y - 1 - - BR
3-15 FDORRB175CBKZ R-door ass’y - - 1 - BQ
3-15-1 LSTP-A058CBM0 R-door stopper r 1 1 1 1 AF
3-15-2 LSTPPA084CBFA Rd-stopper spring r 1 1 1 1 AD
3-15-3 PCOV-A252CBFA Dc cover rr 1 - - 1 AC
3-15-3 PCOV-A252CBFB Dc cover rr - 1 - - AC
3-15-3 PCOV-A252CBFF Dc cover rr - - 1 - AC
3-17 FPACGA310CBKZ R-door packing 1 1 1 1 AY
3-18 HDECQA385CBFA Handle trim rl 1 1 1 - AG
3-19 JHNDPA118CBFA Door handle rl 1 - - 1 AK
3-19 JHNDPA118CBFB Door handle rl - 1 - - AM
3-19 JHNDPA118CBFF Door handle rl - - 1 - AP
3-25 FBDGDA280CBYZ Badge ass’y 1 1 1 1 AY
OTHER PARTS
4-1 LBND-A023CBE0 L-band c 4 4 4 4 AC
4-3 LX-VZA003CBE0 Special screw 2 2 2 2 AB
4-10 QTAN-A013CBE0 Solderless term. a 4 4 4 4 AH
4-14 LX-WZA013CBE0 Hinge washer 1 1 1 1 AB
4-15 LX-BZ0202JBE0 Special screw 1 1 1 1 AA
4-17 LX-WZA003CBE0 Washer 4 4 4 4 AA
4-18 LX-BZA076CBEZ Handle screw 10 10 10 10 AC
ATTACHMENT PARTS
5-1 UPOK-A166CBRA Bottle pocket 2 2 2 2 AN
5-3 UPOK-A168CBRA F door pocket 2 2 2 2 AP
5-4 UPOK-A165CBRA R door pocket 2 2 2 2 AN
5-5 UTNA-A282CBFB Egg tray 2 2 2 2 AG
5-6 FSRA-A193CBYZ Ice cube maker 1 1 1 1 AS
5-9 FSRA-A194CBKZ F shelf ass’y 1 1 1 1 AY
5-13 HGRL-A178CBFA Ventilating grille 1 - - 1 AG
5-13 HGRL-A178CBFB Ventilating grille - 1 - - AM
5-13 HGRL-A178CBFF Ventilating grille - - 1 - AN
Page 32
32
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
REF. NO. PART NO. DESCRIPTION Q'TY CODE
HOW TO ORDER REPLACEMENT PARTS
To have your order filled promptly and correctly, please furnish the following information.
1. MODEL NUMBER 2. REF. NO.
3. PART NO. 4. DESCRIPTION
SJ-68L SJ-68L SJ-68L SJ-68L
-A2G -A2B - A2L -R2G
5-14 USRA-A252CBFA Drain pan 1111 AN
5-15 UYOK-A330CBFA Fruit case 1111 AW
5-16 UYOK-A331CBFA Vegetable case 1111 AZ
5-17 UYOK-A328CBFA Ice storage box 1111 AF
5-18 UYOK-A329CBFA Chilled case 1111 AX
5-19 GDORPA066CBRA Chilled door 1111 AP
5-24 FTNA-A301CBKZ R glass shelf ass’y 3333 BC
5-25 FTNA-A302CBKZ V glass shelf ass’y 1111 BC
5-26 PCAP-A076CBFA Venti. Grille cap 1--1 AC
5-26 PCAP-A076CBFB Venti. Grille cap -1-- AC
5-26 PCAP-A076CBFF Venti. Grille cap --1- AC
5-28 PCAP-A069CBFA V sliding cap l 1111 AC
5-29 PCAP-A070CBFA V sliding cap r 1111 AC
5-31 LRALPA132CBFA Ice tray holder l 1111 AF
5-32 LRALPA133CBFA Ice tray holder r 1111 AF
5-33 LRALPA134CBFA Ice tray holder b 1111 AF
5-34 PCUP-A009CBFA Water cup 1111 AD
5-35 UPOKPA251CBFA Tube stand 2222 AC
5-36 PCOV-A259CBFA Case cover 1111 AH
5-37 UPOK-A167CBRA Utility case pocket 1111 AM
CYCLE PARTS
6-1 PCMPLA201CBEZ Compressor 1111 BX
6-2 PSPAGA054CBEZ Rubber grommet 4444 AH
6-3 FCONSA076CBKZ Sub. Condenser ass’y 1111 AP
6-3-1 PCOV-A256CBFA Pipe protector l 1111 AF
6-3-2 PCOV-A257CBFA Pipe protector r 1111 AF
6-4 FFRM-A112CBKZ Base frame ass’y 1111 AG
6-5 FDRY-A006CBK0 Dryer ass’y 1111 AX
6-9 PSPAFA047CBEZ Sleeve 4444 AE
6-11 PPIPCA356CBEZ S.p connector 1111 AG
6-14 PGUM-A004CBF0 Absorbent rubber a 1111 AH
6-15 PGUM-A002CBF0 Absorbent rubber b 1111 AH
6-18 PPIPCA252CBE0 Charge pipe 2222 AD
6-21 PCOVPA260CBEZ Terminal cover 1111 AK
6-27 PSEL-B899CBEZ S-sealer 1111 AC
MISCELLANEOUS
90-1 TINS-A458CBRZ Operation manual 1111 AF
90-2 TLAB-A473CBR0 Lamp label 1111 AB
90-3 SPAKCI754YDEZ Packing case 68l-f 1111 BD
90-5 TLAB-A897CBEZ Case label a2g 4--- AC
90-5 TLAB-A916CBEZ Case label a2b -4-- AC
90-5 TLAB-A927CBEZ Case label a2l --4- AC
90-5 TLAB-A930CBEZ Case label r2g ---4 AC
90-6 CPADBA765YDKZ Bottom pad ass’y 1111 AY
90-7 CPADBA764YDKZ Top pad ass’y 1111 AR
90-8 TLAB-A874CBRZ Warning label 1111 AC
90-9 TINS-A366CBR0 Srv. Station list 1111 AC
Page 33
33
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
A
B
C
D
E
F
G
H
A
123456
123456
B
C
D
E
F
G
H
DOOR PARTS
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
3-6
3-5
3-9
3-8
3-9
4-18
3-5-2
5-3
5-4
5-5
5-1
3-5-3
3-15-3
3-5-1
3-5-2
3-15-2
3-17
5-35
3-15
4-18
4-18
3-9
3-9
5-34
5-36
5-37
3-9
3-9
3-9
4-18
4-18
4-18
4-18
4-18
4-18
4-18
3-9
3-9
3-7
3-19
3-18
3-25
3-9
3-15-1
Page 34
34
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
A
B
C
D
E
F
G
H
A
123456
123456
B
C
D
E
F
G
H
CABINET PARTS
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
2-29
2-13
2-99
2-90
2-49
2-49
2-97
2-95
2-95
2-96
2-96
2-91
2-7
2-7-2
2-7-1
2-8
2-8-2
2-7-1
2-11
2-14
5-31
5-17
5-6
5-32
5-33
5-9
5-24
5-14
1-10
2-15
2-37
5-13
5-26
4-3
4-14
5-15
5-25
5-16
5-29
5-28
2-93
2-93
5-18
5-19
2-36
2-36
2-12
2-106
2-104
2-103
2-105
Page 35
35
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
A
B
C
D
E
F
G
H
A
123456
123456
B
C
D
E
F
G
H
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
6-11
6-15
6-14
6-1
4-1
2-86
2-31
6-9
6-2
4-17
1-2
6-4
6-3
6-3-1
1-9
2-80
2-77
2-24
6-18
6-5
6-18
4-10
2-78
2-66
2-67
2-81
2-4
1-21
1-22
6-21
4-15
1-11
2-2
2-30
2-25
6-3-2
1-29
2-59
2-51
90-2
1-8
2-72
1-4
2-41
2-83
2-73
2-71
2-38
2-74
2-84
2-30
2-79
1-30
1-3
2-27
2-54
1-27
2-53
1-7
1-28
2-52
2-17
90-8
2-57
2-56
2-55
2-26
2-63
2-19
1-6
2-19
2-64
2-20
2-17
2-22
2-23
1-17
4-1
1-5
2-69
1-1
1-20
2-65
2-21
2-16
2-28
2-50
6-27
CABINET PARTS
Page 36
36
SJ-58L-A2
SJ-63L-A2
SJ-68L-A2/R2
2000 SHARP CORP. (05K0.12E) Printed in Japan
52APSF/ 52APLF/ 52APEF/ 56APSF/ 56APLF/ 56APEF/ 60APSF/ 60APLF/ 60APEF/ 60APGF
Loading...