Page 1
16. DESIGN RELATED PARTS
DECAL CABINET
SIDE RIGHT
999-1154
MARQUEE
999-1152
DECAL BEZEL LEFT
INSTRUCTION
999-1158
DECAL CONTROL
PANEL
999-1159
DECAL FRONT
WOMAN
999-1161
DECAL RIGHT SIDE
COIN BOX
999-1163
DECAL SEAT
RIGHT SIDE
999-1166
DECAL UPPER
BONUS/GAME OVER
999-1156
TIRE TREAD
FLAT DECAL
999-1164
DECAL BEZEL RIGHT
INSTRUCTION
999-1155
DECAL LOWER
GETAWAY
HOLDER POP PANEL
999-1151
POP DISPLAY
999-1150
999-1157
DECAL SEAT
LEFT SIDE
999-1165
DECAL LEFT SIDE
COIN BOX
999-1162
DECAL CABINET
SIDE LEFT
999-1153
77
DECAL FRONT
MAN
999-1160
Page 2
17. PARTS LIST
1 TOP ASSY WRD
11
8
9
1
5
2
6
4
14
3
ITEM NO. PART NO. DESCRIPTION
1 WRD-2500 ASSY HANDLE
2 CTA-1650 BRAKE UNIT
3 SEAT CABI
4 999-1167 FOOT REST
5 999-1168 VENT -4 HOLE AIR BLACK PDRCOAT
6 999-1065 VENT -8 HOLE AIR BLACK PDRCOAT
7 LOC. PURCHASE WOOFER
8 29 INCH MONITOR
9 CABINET
10 AC UNIT
11 999-1170 27” BEZEL
12 999-0169 CASTER
13 999-0167 LEG LEVELER
14 999-1169 COVER FOOT REST
7
12
10
13
78
Page 3
2 ASSY HANDLE (WRD-2500) (D-1/2)
8
7
Details of
79
M6 SCREW FASTENING TORQUE TO BE : 8.8N•m
Page 4
2 ASSY HANDLE (WRD-2500) (D-2/2)
ITEM NO. PART NO. DESCRIPTION
1 WRD-2550 ASSY BRAKE MEDHA
2 WRD-2600 ASSY THROTTLE
3 HLD-2002 GRIP LEFT
4 MJT-3603X MOUNT BLOCK
5 MJT-3612 HANDLE HOLDER
6 WRD-2501 HANDLE BAR
7 WRD-2502 WIRE MOUNT PLATE
8 WRD-2503 WIRE STAY
9 WRD-2504 HOLE LID
10 WRD-2505 STICKER MASTER CYLINDER
101 280-6623-1S-0 PLASTIC TIE BELT PLT-1S-0
201 000-T00412-0B M SCR TH BLK M4 X 12
202 020-000620-0Z HEX SKT H CAP SCR BLK 0Z M6 X 20
203 060-F00600-0B FLT WSHR BLK M6
204 060-S00600-0B SPR WSHR BLK M6
205 000-T00310-0C M SCR TH CRM M3 X 10
206 050-F00300 FLG NUT M3
207 060-F00300-0B FLT WSHR BLK M3
80
Page 5
3 ASSY CENTERING BASE (WRD-2100) (D-1/2)
Light Receiving Side
Light Emitting Side
6
The tightening torque to each screw shall be 2.45 N•m.
81
Page 6
3 ASSY CENTERING BASE (WRD-2100) (D-2/2)
ITEM NO. PART NO. DESCRIPTION
1 WRD-2101 FRONT COVER
2 WRD-2102 CENTERING ARM L
3 WRD-2103 CENTERING ARM R
4 WRD-2104 SW BRKT
5 WRD-2105 SPRING HOLD
6 100-5050 ROLLER BEARING 19
7 421-7226-12-91 STICKER L LONG
8 421-7226-21-91 STICKER U LONG
101 370-5232 PHOTO SENSOR OMT-01DS
102 280-0419 HARNESS LUG
201 000-P00410-S M SCR PH W/S M4 X 10
202 060-F00400 FLT WSHR M4
203 050-U00300 U NUT M3
204 060-S00300 SPR WSHR M3
205 060-F00300 FLT WSHR M3
206 050-U00600 U NUT M6
207 000-P00312-W M SCR PH W/FS M3 X 12
209 050-H00300 HEX NUT M3
210 000-P00408 M SCR PH M4 X 8
211 060-S00400 SPR WSHR M4
301 WRD-60003 WH CENTERING MECHA01
82
Page 7
4 ASSY HANDLE MECHA (WRD-2000) (D-1/3)
Grease the gear and sliding section.
Toward VOLUME D-Cut
83
Page 8
4 ASSY HANDLE MECHA (WRD-2000) (D-2/3)
ITEM NO. PART NO. DESCRIPTION
1 WRD-2100 ASSY CENTERING MECHA
2 WRD-2001 STOPPER BRKT
3 WRD-2002 STOPPER SHAFT
4 WRD-2003 STOPPER ROT
5 WRD-2004 MAIN SHAFT
6 WRD-2005 SHAFT HOLDER UPPER
7 WRD-2006 SHAFT HOLDER LOWER
8 WRD-2007 SW SHADE
9 WRD-2009 HOLD CAM
10 WRD-2010 SPRING SUS
11 WRD-2011 SPRING HOOK
12 WRD-2012 GUIDE SHAFT
13 WRD-2013 GUIDE BLOCK
14 WRD-2014 STOPPER HOLDER
15 WRD-2015 STOPPER PP
16 WRD-2016 REAR COVER
17 WRD-2017 VR BRKT
18 WRD-2018 MECHA COVER
19 WRD-2019 MECHA BASE
20 WRD-2020 BASE BRKT
21 WRD-2021 ROSTA BASE
22 WRD-2022 ROSTA HOLDER
23 WRD-2023 GEAR BASE
24 WRD-2024 GEAR NUT PLATE
25 WRD-2025 HIDE PLATE
26 WRD-2026 TOP COVER
27 601-6555 GEAR Z=30 M=0.75
28 601-6450 GEAR 110
29 601-10999 TORSION RUBBER KURASHIKI 18 X 30
30 100-5071 BEARING 30
101 220-5373 VOL CONT B-5K
102 310-5029-F20 SUMITUBE F F 20MM
103 280-5009 CORD CLAMP 21
84
Page 9
4 ASSY HANDLE MECHA (WRD-2000) (D-3/3)
ITEM NO. PART NO. DESCRIPTION
201 030-000820-S HEX BLT W/S M8 X 20
202 050-H00800 HEX NUT M8
203 060-S00800 SPR WSHR M8
204 060-F00800 FLT WSHR M8
205 000-P00416-W M SCR PH W/FS M4 X 16
206 000-P00420-S M SCR PH W/S M4 X 20
207 029-0427 HEX SKT H CAP SCR M4 X 10
208 000-P00408-W M SCR PH W/FS M4 X 8
209 060-S00400 SPR WSHR M4
210 060-F00400 FLT WSHR M4
211 000-P00612-S M SCR PH W/S M6 X 12
212 060-F00600 FLT WSHR M6
213 060-S00600 SPR WSHR M6
214 050-U00600 U NUT M6
215 050-H01200 HEX NUT M12
216 060-F01200 FLT WSHR M12
217 060-S01200 SPR WSHR M12
218 028-C00412-P SET SCR CH CUP P M4 X 12
219 028-C00406-P SET SCR CH CUP P M4 X 6
220 065-S025S0-Z STP RING BLK 0Z S25
221 000-P00412-W M SCR PH W/FS M4 X 12
222 000-P00512-W M SCR PH W/FS M5 X 12
301 WRD-60004 WH HANDLE MECHA01
85
Page 10
5 ASSY BRAKE MECHA (WRD-2550) (D-1/2)
GREASING
SCREW, NUT FASTENING TORQUE TO BE
M4 : 1.8 N•m
M6 : 7.3 N•m
Grease the gear and sliding section.
86
Page 11
5 ASSY BRAKE MECHA (WRD-2550) (D-2/2)
ITEM NO. PART NO. DESCRIPTION
1 HLD-2501 BRAKE MASTER CASE
2 HLD-2502 MASTER CASE HOLDER
3 HLD-2503 MASTER CASE COVER
4 HLD-2504 BRAKE GEAR
5 HLD-2505 IDOL GEAR
6 HLD-2506 PIVOT SHAFT
7 HLD-2507 VR BRKT
8 HLD-2508 LEVER STOPPER
9 HLD-2509 IDOL GEAR SHAFT
10 WRD-2551 MASTER PISTON
11 280-6619 RUBBER FOOT T 3G
12 HLD-2512 BRAKE LEVER
13 HLD-2513 VR COVER
14 HLD-2514 RETURN SPRING
101 220-5484 VOL CONT B-5K OHM
102 601-7944 GEAR 15
103 310-5029-F20 SUMITUBE F F 20MM
104 280-5275-SR10 CORD CLAMP SR10
201 000-T00408-0B M SCR TH BLK M4 X 8
202 050-C00400-3B CAP NUT TYPE3 BLK M4
203 000-P00408-W M SCR PH W/FS M4 X 8
204 030-000620-SB HEX BLT W/S BLK M6 X 20
205 028-A00306-P SET SCR HEX SKT CUP P M3 X 6
206 FAS-500015 CAP NUT BLK M6
207 065-S016H0-Z STP RING BLK OZ H16
208 068-441616 FLT WSHR 4.4-16 X 1.6
209 060-F00600-0B FLT WSHR BLK M6
210 000-P00408 M SCR PH M4 X 8
211 060-S00400 SPR WSHR M4
212 060-F00400 FLT WSHR M4
301 WRD-60006 WH BRAKE MECHA01
87
Page 12
6 ASSY THROTTLE (WRD-2600) (D-1/2)
SCREW FASTENING TORQUE TO BE
M3 : 0.75 N•m
M4 : 1.8 N•m
Grease the gear section.
88
Page 13
6 ASSY THROTTLE (WRD-2600) (D-2/2)
ITEM NO. PART NO. DESCRIPTION
1 HLD-2601 THROTTLE CASE LOWER
2 HLD-2602 THROTTLE CASE UPPER
3 HLD-2603 INNER GRIP
4 HLD-2604 ACCEL GEAR
5 HLD-2605 BASE PLATE
6 HLD-2606 ACCEL GEAR SHAFT
7 HLD-2607 ACCEL VR BRKT
8 HLD-2608 SPRING HOOK
9 HLD-2609 RETURN SPRING
10 HLD-2610 VR COVER
11 HLD-2611 ACCEL GRIP
12 HLD-2612 SLIDE PLATE
14 HLD-2613 SPRING STOPPER
15 HLD-2614 GEAR SPRING
101 220-5484 VOL CONT B-5K OHM
102 601-7944 GEAR 15
103 310-5029-F20 SUMITUBE F F 20MM
201 000-T00408-0B M SCR TH BLK M4 X 8
202 000-P00408-W M SCR PH W/FS M4 X 8
203 000-F00408 M SCR FH M4 X 8
204 030-000625-SB HEX BLT W/S BLK M6 X 25
205 060-F00600-0B FLT WSHR BLK M6
206 028-A00306-P SET SCR HEX SKT CUP P M3 X 6
207 012-P00306 TAP SCR #2 PH 3 X 6
208 000-P00408 M SCR PH M4 X 8
209 060-S00400 SPR WSHR M4
210 060-F00400 FLT WSHR M4
301 WRD-60005 WH THROTTLE01
89
Page 14
7 BRAKE UNIT (CTA-1650) (D-1/2)
GREASING
GREASING
BOTH SIDES
GREASING
GREASING
90
Page 15
7 BRAKE UNIT (CTA-1650) (D-2/2)
ITEM NO. PART NO. DESCRIPTION
1 CTA-1601 PEDAL BASE
2 CTA-1651 BRAKE PEDAL
3 CTA-1603 PEDAL SHAFT
4 CTA-1604 STOPPER BLOCK
5 CTA-1605 RUBBER PLATE
6 CTA-1606 RUBBER CASE
7 CTA-1607 VR BRKT
8 HLD-2805 TORSION SPRING
9 HLD-2808 RUBBER HOLDER
10 601-6450 GEAR 110
11 601-7944 GEAR 15
12 CTA-1608 SUPPORT BRKT
101 220-5373 VOL CONT B-5K
220-5484 VOL CONT B-5K OHM
102 310-5029-F20 SUMITUBE F F 20MM
103 280-0419 HARNESS LUG
201 000-P00412-W M SCR PH W/FS M4 X 12
202 000-P00408-W M SCR PH W/FS M4 X 8
203 050-U00800 U NUT M8
204 060-F00800 FLT WSHR M8
205 028-A00308-P SET SCR HEX SKT CUP P M3 X 8
206 020-000416-0Z HEX SKT H CAP SCR BLK 0Z M4 X 16
207 060-S00400 SPR WSHR M4
208 050-F00400 FLG NUT M4
209 020-000408-0Z HEX SKT CAP SCR BLK 0Z M4 X 8
210 060-F00400 FLT WSHR M4
301 CTA-60050 WIRE HARN BRAKE
91
Page 16
8 SEAT CABI
6
1
2
3
5
ITEM NO. PART NO. DESCRIPTION
1 999-1171 COVER SEAT VACUUM FORM
2 999-1172 FENDER VACUUM FORM
3 999-1173 S/A; SEAT & FENDER
4 999-0167 LEG LEVELER
5 999-1174 WOOD DOOR SEAT
6 999-1175 PLATE TREAD
4
92
Page 17
9 SW UNIT (CTA-1160)
3
1
2
ITEM NO. PART NO. DESCRIPTION
1 LOC. PURCHASE 5 K POTENTIOMETER & VOLUME KNOB
2 LOC. PURCHASE MOM. PUSH BUTTON SW
3 LOC. PURCHASE COIN METER 6 VOLTS
93
Page 18
10 ASSY MAIN BD
1
2
3
8
7
Note: Make sure that there is no parts, wiring, etc.
in the slash mark portions.
6
5
4
ITEM NO. PART NO. DESCRIPTION
1 837-13551-92 I/O CONTROL BD
2 400-5397-01 POWER SUPPLY FOR JVS
3 838-13759 RECT BD CTA
4 838-11651-01 PC BLOW PASS AMP w/LARGE HEAT SINK
5 838-13616 AUDIO POWER AMP 2 CH
6 600-7009-3000 ASSY RGB CABLE SUB 15P
7 840-0046D-01 ASSY CASE NAO2 WRD US
8 600-7141-200 USB CABLE
94
Page 19
11 ASSY XFMR (NOB-4100)
1
2
3
4
Note: Make sure that there is no parts, wiring, etc.
in the slash mark portions.
ITEM NO. PART NO. DESCRIPTION
1 998-0147 TRANSFORMER 12V HA MCI-4-06-7012
2 998-0146 TRANSFORMER MCI 4-06-8036
3 LOC. PURCHASE FUSE BLOCK
4 LOC. PURCHASE LINE FILTER 6 AMP
95
Loading...