Samsung M8800 Service Manual

GSM TELEPHONE

Samsung M8800

GSM TELEPHONE

CONTENTS

Safety Precautions

1. Specification

2. Product Function

3. Array course control

4. Exploded View and Parts list

5. MAIN Electrical Parts List

6. Block Diagrams

7. PCB Diagrams

8. Chart of Troubleshooting

9. Reference data

10. Disassembly and Assembly

11.

Instructions

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive Devices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM

2-1.

850&900

Specification

Freq.

Band(MHZ)

Uplink/Downlink

ARFCN range

Tx/Rx spacing

Mod. Bit rate/

Bit Period

Time slot

Period/Frame

Period

DCS1800/PCS1900/WCDMA2100 General

/

EGSM

824~849

869~894

128~251

MHz

45

270.833

3.692

576.9

4.615

850

kbps

us

ms

EGSM

Phase

880~915

925~960

1~124 &

975~1023

MHz

45

270.833

3.692

576.9

4.615

900

2

kbps

us

ms

DCS1800

Phase

1710~1785

1805~1880

512~885 512~810 10562~10838

95

270.833

3.692

576.9

4.615

1

MHz

kbps

us

ms

PCS

1900

1850~1910

1930~1990

MHz

80

270.833

3.692

576.9

4.15

kbps

us

ms

WCDMA

1920~1980

2110~2170

MHz

190

Mcps/s

3.84

ms

10

Modulation

MS Power

Power Class

Sensitivity

TDMA Mux

Cell Radius

5

GMSK

0.3

dBm

33

5

pcl

-103

35

~

dBm

pcl

~19

dBm

8888-

Km

5

0.3

33

5

pcl

-103

35

GMSK

dBm

~19

dBm

Km

~

pcl

GMSK

0.3

dBm~0dBm

30

pcl

0

~15

dBm

-100

Km

2

pcl

GMSK

0.3

dBm~0dBm

30

0

pcl

-100

pcl CLASS3

~15

dBm

--

UL:2BPSK

DL:QPSK

MAX:24

dBm

(+1,-3)

MIN

:<-50

-106.7

dBm

2-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

GSM TX power class

2-2.

TX POWER

LEVEL CONTOL

533±2

631±2

729±2

827±2

925±2

10 23±2

11 21±2

12 19±2

EGSM

850/900

dBm

TX POWER

LEVEL CONTOL

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

DCS

1800

dBm

TX POWER

LEVEL CONTOL

030±3

128±3

226±3

324±3

422±3

520±3

618±3

716±3

PCS

1900

dBm

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

dBm

814±3

912±3

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

814±3

912±3

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

15 0±5

dBm

2-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Product Function

3.

Main Function

Camera/CIF Camera

-8M LCD-Main:

Video Recording&Messaging

Music Player(MP3/AAC/AAC+/Enhanced ACC+

Multimedia Message Service(MMS)

Bluetooth Wireless Technology

E-mail

Voice recorder

Java/WAP2.0

Four-band(

USB

-

2.0 FM Radio GPS HSDPA

3.2" 240x4000 262K

850/900/1800/1900

7.2

Color TFT

MHz), UMTS

2100

)

MHz

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

4.

Software Adjustments

4-1.

Test Jig(GH99

RF Test Cable(GH

-36900

39-00985

A)

Test Cable(GH

RF Test Cable(GH

39-01160

A)

99-38251

A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Software Downloading

4-2.

4-2-1.

4-2-2.

■

1.

2.

Pre-requsite for Download

Downloader Program(

•

M8800 Mobile Phone

•

USB Data Link Cable

•

Binary file

•

s

Multiloader V5.50.exe

)

S/W Download Process

Load the binary download program by executing the

Execute the download SW, Multiloader.exe.

Boot the M8800 by pressing'Power ON Key

CAMERA key

'+'

“Multiloader V5.33.exe”

VOLUME DOWN

'+'

Key'at the same time.

if you do properly, you can see the'DOWMLOAD' in the middle of the screen.

-

Connet the USB data cable to the M8800.

3.

Choose MSM6275/MSM6280 and check'Boot Change', then the'Boot' button will

4.

be activate

d.

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array Course Control

Click the'Boot', then the dialogue box is opened. Select the wanted directory, and

5.

press'OK'.

Select'Port Search', then'Port' is activated.

6.

Click'Download', then downloading is executed successively. After10seconds

.

7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

4-3

,

Array Course Control

M8800 rebooting.

Disconnet the USB data cable to the M8800.

9.

One more Boot the M8800 by pressing'Power ON Key

10.

VOLUME DOWN Key'at the same time.

'

if you do properly, you can see the'DOWMLOAD' in the middle of the screen.

-

Connet the USB data cable to the M8800.

11.

12.

elect the'Boot Change' once more, then'Boot' button will be inactivated, and the

S

CAMERA key

'+'

others('Amss','Rsrc1','Rsrc2','FactoryFS','FOTA', and'ETC') are activated.

Click'AMSS','Rsrc1','Rsrc2', and'FactoryFS' each, and select wanted files.

-

'+

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Select'Port Search', then'Port' is activated.

12.

Array Course Control

Click'Download', then downloading is executed successively.If the download is

.

13

completed, S/W downloading is finished.

Download time:about5minutes

(

)

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5.

5-1.

Cellular phone Exploded View

QME03

QFR01

QLC01

QLB01

QCR32

QMP01

QKP01

QME01

QCR05

QBR04

QSH01

QSP01

QCA02

QRE01

QST01

QCR57

QCK02

QIF01

QSD01

QMI03

QCR32

QCA01

QAN02

QVO01

QCK01

QCR54

QSC01

QBA01

QBA00

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Discription SEC CODE

QAN02 INTENNA-GT_M8800 GH42-01779A

QBA00 NPR COVER-BATT GH71-08641A

QBA01 INNER BATTERY PACK-1000MAH,BLK GH43-02974A

QBR04 PMO BRACKET-KEY GH72-49749A

QCA01 ASSY CAMERA-GT_M8800 GH96-03369A

QCA02 CAMERA MODULE-GT_M8800 GH59-06260A

QCR05 SCREW-MACHINE

QCR32 SCREW-MACHINE

QCR54 SCREW-MACHINE

6001-001478

6001-001700

6001-001645

QFR01 ASSY CASE-FRONT GH98-10189A

QKP01 ASSY KEYPAD-(EU/BLACK) GH98-10192A

QLB01 ASSY BRACKET-LCD GH98-10193A

QLC01 ASSY LCD-LCD MODULE ASSY(M8800 GH96-03364A

QME01 KEY FPCB-GT_M8800,FPCB ASS'Y GH59-06339A

QME03 UNIT-TOUCH WINDOW(M8800) GH59-06337A

QMI03 RMO RUBBER-MIC HOLDER GH73-12285A

QMP01 A/S ASSY-PBA MAIN(GT_M8800 SV GH82-03272A

QSC01 PMO COVER-SCREW GH72-50997A

QSH01 ASSY BRACKET-SHIELD CAN GH98-10194A

QSP01 UNIT-MODULE SPEAKER(AUDIO RECE GH59-06318A

QST0

1

ASSY STYLUS PEN-HANDSTRAP GH98-09735A

QRE01 ASSY CASE-REAR GH98-10190A

QCK01 ASSY KEY-CAM GH98-10648B

QCK02 PMO KEY-HOLD GH72-49762A

QCR57 SCREW-MACHINE

6001-002001

QIF01 PMO COVER-IF V2 GH72-50420A

QSD01 PMO COVER-SD V2 GH72-50419A

QVO01 PMO KEY-VOL V2 GH72-50421A

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE Design LOC Discription

0403-001547

0404-001153

0406-001267

0406-001279

0406-001286

0407-001002

0504-001113

0504-001151

0801-003013

1001-001394

1001-001436

1001-001447

1001-001481

1003-002047

1003-002169

1108-000210

1201-002733

1201-002774

1201-002775

1201-002778

1203-004422

1203-004518

1203-004596

1203-004776

1203-004778

1203-004819

1203-004857

1203-004978

ZD709 DIODE-ZENER

D300 DIODE-SCHOTTKY

ZD704,ZD705,ZD706 DIODE-TVS

D401,D402,D801,D802 DIODE-TVS

D803,D804,ZD500 DIODE-TVS

ZD501,ZD502,ZD503 DIODE-TVS

ZD600,ZD601,ZD602 DIODE-TVS

ZD603,ZD604,ZD605 DIODE-TVS

ZD700,ZD701,ZD707 DIODE-TVS

ZD708,ZD710,ZD711 DIODE-TVS

ZD712,ZD713,ZD714 DIODE-TVS

ZD715 DIODE-TVS

ZD400,ZD401,ZD702 DIODE-TVS

ZD703 DIODE-TVS

D400 IC-ANALOG SWITCH

TR400 TRANSISTOR

U105 IC-ANALOG SWITCH

U300 IC-ANALOG SWITCH

U602,U700,U815,U818 IC-ANALOG SWITCH

U504 IC-ANALOG SWITCH

U302,U600 IC-ANALOG SWITCH

U403 IC-ANALOG SWITCH

U604 IC-DRIVER

U701 IC-DRIVER

UME300 IC-MCP

U502 IC-AUDIO AMP

U100 LNA_GPS

U106 IC-TRANSCEIVER

PAM100 IC-TRANSCEIVER

U811 IC-DC/DC CONVERTER

U401 IC-POWER AMP

U503 IC-DC/DC CONVERTER

U603,U810 IC-DC/DC CONVERTER

U402 IC-POWER SUPERVISOR

U816 IC-DC/DC CONVERTER

U601 IC-DRIVER

U619 IC-DC/DC CONVERTER

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

1203-005069

1203-005250

1203-005403

1203-005478

1203-005479

1203-005485

1203-005487

1204-002924

1205-003228

1205-003288

1205-003297

1205-003419

1205-003498

1205-003611

1209-001766

1404-001224

2007-000137

2007-000140

2007-000143

2007-000144

2007-000145

2007-000147

2007-000148

2007-000151

2007-000157

2007-000161

2007-000162

2007-000163

2007-000164

2007-000165

2007-000171

2007-000172

2007-000174

2007-001119

U400 IC-DC/DC CONVERTER

U610,U621 IC-DC/DC CONVERTER

U800 IC-DC/DC CONVERTER

U607 IC-DC/DC CONVERTER

U615 IC-DRIVER

U620,U821 IC-DC/DC CONVERTER

U801 IC-DC/DC CONVERTER

U200 IC-MULTI REG

U501 IC-MULTI REG

U817 IC-DRIVER

U104 IC-TRANSCEIVER

U201 IC-TRANSCEIVER

UCP300 IC-MODEM

U802 IC-DC/DC CONVERTER

U702 IC-DRIVER

TH300 THERMISTOR-NTC

R200,R201 R-CHIP

R112,R706 R-CHIP

R204,R205,R828,R829 R-CHIP

R407 R-CHIP

R621 R-CHIP

R308 R-CHIP

R712 R-CHIP

R413 R-CHIP

R842 R-CHIP

R310 R-CHIP

R522 R-CHIP

R804 R-CHIP

R619 R-CHIP

R320,R630 R-CHIP

C841,L201,R100,R101 R-CHIP

R206,R210,R316,R424 R-CHIP

R502,R505,R519,R831 R-CHIP

R846,R847 R-CHIP

R111,R208,R632,R633 R-CHIP

R105 R-CHIP

R515,R521 R-CHIP

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2007-001217

2007-001285

2007-001291

2007-001298

2007-001305

2007-001333

2007-001339

2007-002797

2007-003015

2007-003030

2007-007092

2007-007132

2007-007197

2007-007309

2007-007310

2007-007314

2007-007334

2007-007468

2007-007528

2007-007586

2007-007741

2007-008040

2007-008045

2007-008046

2007-008049

2007-008052

2007-008055

2007-008419

2007-008483

2007-008486

2007-008516

R102 R-CHIP

R114 R-CHIP

R509,R511 R-CHIP

R113 R-CHIP

R106,R107 R-CHIP

R714 R-CHIP

R807 R-CHIP

R203 R-CHIP

R110 R-CHIP

R103,R104 R-CHIP

R510,R709 R-CHIP

R410 R-CHIP

R702,R703,R705,R715 R-CHIP

R716 R-CHIP

R109 R-CHIP

R818 R-CHIP

R409 R-CHIP

R612 R-CHIP

R400 R-CHIP

R517,R520 R-CHIP

R311 R-CHIP

R312 R-CHIP

R837 R-CHIP

R202,R318,R412,R600 R-CHIP

R614,R708,R801,R824 R-CHIP

R840 R-CHIP

R115,R116 R-CHIP

R305 R-CHIP

R507,R508,R626,R711 R-CHIP

R713,U611 R-CHIP

R325,R421,R610,R611 R-CHIP

R817 R-CHIP

R309 R-CHIP

R408 R-CHIP

R404,R405,R411,R414 R-CHIP

R422,R830 R-CHIP

R300,R302,R303,R304 R-CHIP

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2007-008516

2007-008542

2007-008548

2007-008588

2007-008686

2007-008806

2007-009084

2007-009111

2007-009115

2007-009157

2007-009158

2007-009170

2007-009171

2007-009408

2203-000233

2203-000254

2203-000278

2203-000330

2203-000386

2203-000438

2203-000466

2203-000489

2203-000627

2203-000696

2203-000725

2203-000812

R306,R406,R415,R416 R-CHIP

R417,R419,R423,R627 R-CHIP

R628,R631,R636,R637 R-CHIP

R827,R832 R-CHIP

R319,R620 R-CHIP

R704 R-CHIP

R503,R504,R601,R607 R-CHIP

R812 R-CHIP

R321,R402,R403 R-CHIP

R317,R833 R-CHIP

R707,R815 R-CHIP

R307,R835 R-CHIP

R822 R-CHIP

R209 R-CHIP

R700,R701,R823 R-CHIP

R313,R314,R315,R401 R-CHIP

R326,R327 R-CHIP

C105,C123,C124,C128 C-CER,CHIP

C134,C154,C158,C187 C-CER,CHIP

C189 C-CER,CHIP

C137,C160,C707 C-CER,CHIP

C102,C219,C552,C554 C-CER,CHIP

C413,C432 C-CER,CHIP

C833,C834,C835,C836 C-CER,CHIP

C141,C146,C148,C180 C-CER,CHIP

C200 C-CER,CHIP

C220 C-CER,CHIP

C106 C-CER,CHIP

C127,C136,C142,C143 C-CER,CHIP

C145,C149,C150,C152 C-CER,CHIP

C159,C162,C163,C175 C-CER,CHIP

C188,C812 C-CER,CHIP

C161,C191 C-CER,CHIP

C621 C-CER,CHIP

C104,C108,C113,C114 C-CER,CHIP

C115,C135,C147,C151 C-CER,CHIP

C164,C171,C172,C173 C-CER,CHIP

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2203-000812

2203-000854

2203-000995

2203-001383

2203-001385

2203-001405

2203-002709

2203-005234

2203-005288

2203-005382

2203-005552

2203-005682

2203-005719

2203-005725

2203-005727

2203-005729

2203-005732

2203-005736

2203-005777

2203-005806

2203-006047

2203-006048

2203-006121

C190,C439,C441,C443 C-CER,CHIP

C553 C-CER,CHIP

C545,C546,C556,C557 C-CER,CHIP

C122 C-CER,CHIP

C177 C-CER,CHIP

C101,C103,C117,C129 C-CER,CHIP

C838,C839 C-CER,CHIP

C205,C511,C515,C516 C-CER,CHIP

C519,C547,C555 C-CER,CHIP

C825 C-CER,CHIP

C100 C-CER,CHIP

C166 C-CER,CHIP

C116 C-CER,CHIP

C109 C-CER,CHIP

C208,C311,C314,C317 C-CER,CHIP

C423,C425,C427,C444 C-CER,CHIP

C446,C447,C448,C451 C-CER,CHIP

C452,C542,C550,C551 C-CER,CHIP

C607,C609,C611,C613 C-CER,CHIP

C615,C623,C625,C627 C-CER,CHIP

C700,C701,C705,U822 C-CER,CHIP

C445,C449 C-CER,CHIP

C133,C144 C-CER,CHIP

C548,C549,C831,C832 C-CER,CHIP

C709,C710,C711 C-CER,CHIP

C118,C119 C-CER,CHIP

C221,C422,C431,C438 C-CER,CHIP

C169 C-CER,CHIP

C201,C203,C211,C301 C-CER,CHIP

C324,C325,C326,C327 C-CER,CHIP

C328,C336,C339,C340 C-CER,CHIP

C341,C342,C346,C351 C-CER,CHIP

C365 C-CER,CHIP

C316 C-CER,CHIP

C442,C537,C538,C540 C-CER,CHIP

C702,C706,C827 C-CER,CHIP

C222 C-CER,CHIP

6-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2203-006194

2203-006208

2203-006257

2203-006260

2203-006305

2203-006307

2203-006324

2203-006348

2203-006361

2203-006399

2203-006423

2203-006556

2203-006562

C202,C204,C207,C310 C-CER,CHIP

C313,C329,C330,C331 C-CER,CHIP

C332,C333,C334,C337 C-CER,CHIP

C343,C344,C345,C347 C-CER,CHIP

C349,C350,C355,C357 C-CER,CHIP

C632,C634,C635,C815 C-CER,CHIP

C518,C522,C523,C527 C-CER,CHIP

C529,C530,C531 C-CER,CHIP

C126 C-CER,CHIP

C541 C-CER,CHIP

C435 C-CER,CHIP

C601,C602,C603 C-CER,CHIP

C433,C434,C703 C-CER,CHIP

C712 C-CER,CHIP

C318,C319,C415,C416 C-CER,CHIP

C132,C140,C206,C303 C-CER,CHIP

C304,C305,C306,C308 C-CER,CHIP

C309,C312,C315,C320 C-CER,CHIP

C321,C322,C323,C338 C-CER,CHIP

C348,C352,C353,C354 C-CER,CHIP

C356,C358,C360,C361 C-CER,CHIP

C362,C363,C412,C500 C-CER,CHIP

C503,C608,C610,C612 C-CER,CHIP

C614,C616,C624,C626 C-CER,CHIP

C628,C640,C641,C708 C-CER,CHIP

C713,C715,C800,C803 C-CER,CHIP

C804,C805,C806,C807 C-CER,CHIP

C808,C813,C814,C817 C-CER,CHIP

C818,C819,C820,U806 C-CER,CHIP

U808 C-CER,CHIP

C364 C-CER,CHIP

C410,C411,C436,C450 C-CER,CHIP

C504,C520,C524,C526 C-CER,CHIP

C532,C533,C534,C618 C-CER,CHIP

C619,C620,C629,C636 C-CER,CHIP

C637,C638,C639,C642 C-CER,CHIP

C643,C644,C645,C646 C-CER,CHIP

6-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2203-006562

2203-006648

2203-006668

2203-006681

2203-006712

2203-006824

2203-006825

2203-006838

2203-006839

2203-006841

2203-006872

2203-006890

2203-007270

2203-007271

2404-001339

2404-001377

2404-001381

2404-001496

2404-001506

2703-001178

2703-001231

C647,C648,C649,C704 C-CER,CHIP

C826,C829,C830,U613 C-CER,CHIP

C714 C-CER,CHIP

C300 C-CER,CHIP

C107,C120,C121,C130 C-CER,CHIP

C131,C138,C139,C153 C-CER,CHIP

C155,C167,C183,C185 C-CER,CHIP

C186,C193 C-CER,CHIP

C156,C157,C178 C-CER,CHIP

C179,C182,C184,C400 C-CER,CHIP

C414,C417,C418,C419 C-CER,CHIP

C816 C-CER,CHIP

C335,C359 C-CER,CHIP

C457,C801,C802,C821 C-CER,CHIP

C822,C823,C824,C837 C-CER,CHIP

U813 C-CER,CHIP

C209,C213,C214,C401 C-CER,CHIP

C402,C403,C404,C405 C-CER,CHIP

C407,C409,C440,C505 C-CER,CHIP

C506,C600,C617,C809 C-CER,CHIP

C828,C840 C-CER,CHIP

C437,C810,U804 C-CER,CHIP

C210,C212,C215,C218 C-CER,CHIP

C406,C408,C420,C421 C-CER,CHIP

C428,C429,C430,C501 C-CER,CHIP

C502 C-CER,CHIP

U805,U80 C-CER,CHIP

C192,C194,C424,C426 C-CER,CHIP

C453,C456,C633,C811 C-CER,CHIP

C302,C307,C454 C-CER,CHIP

TA802 C-TA,CHIP

TA501 C-TA,CHIP

TA800,TA801 C-TA,CHIP

TA100,TA700,TA701 C-TA,CHIP

TA500 C-TA,CHIP

L112,L803 INDUCTOR-SMD

L801 INDUCTOR-SMD

6-7

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2703-001409

2703-001733

2703-001737

2703-001748

2703-001749

2703-001751

2703-002170

2703-002176

2703-002198

2703-002200

2703-002203

2703-002204

2703-002207

2703-002208

2703-002268

2703-002308

2703-002314

2703-002365

2703-002368

2703-002506

2703-002557

2703-002700

2703-002710

2703-003258

2703-003260

2703-003347

2801-004339

2801-004458

2809-001280

2901-001353

2901-001498

2904-001658

2904-001702

2909-001307

2910-000024

L115,L118 INDUCTOR-SMD

L129 INDUCTOR-SMD

C110 INDUCTOR-SMD

L126 INDUCTOR-SMD

L131 INDUCTOR-SMD

L130 INDUCTOR-SMD

L117,U101 INDUCTOR-SMD

L122 INDUCTOR-SMD

L101,L123,L124 INDUCTOR-SMD

L102,L108 INDUCTOR-SMD

L104 INDUCTOR-SMD

L119 INDUCTOR-SMD

L127 INDUCTOR-SMD

L125 INDUCTOR-SMD

L113,L116 INDUCTOR-SMD

L107 INDUCTOR-SMD

L105 INDUCTOR-SMD

L100 INDUCTOR-SMD

C216,L120 INDUCTOR-SMD

C165,C174 INDUCTOR-SMD

L200 INDUCTOR-SMD

L114 INDUCTOR-SMD

L110 INDUCTOR-SMD

L400,L401,L402 INDUCTOR-SMD

L800 INDUCTOR-SMD

L602,L603 INDUCTOR-SMD

OSC400 CRYSTAL-SMD

OSC800 CRYSTAL-SMD

TCX200 OSCILLATOR-VCTCXO

F600,F601,F602 FILTER-EMI SMD

F607,F700,U608,U609 FILTER-EMI SMD

U616,U617,U618 FILTER-EMI SMD

F100 FILTER-SAW

F101 FILTER-SAW

F200 FILTER-LC

DUF100 DUPLEXER-FBAR

FEM100 FEM

6-8

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

SEC CODE Design LOC Discription

2911-000096

3003-001136

3301-001534

3301-001659

3301-001812

3404-001303

3705-001503

3708-001947

3709-001336

3709-001464

3710-002681

3711-005728

3711-005836

3711-006141

3711-006327

3711-006803

4202-001446

4302-001130

MIC500 MICPHONE

F608,L600,L601 BEAD-SMD

L202 BEAD-SMD

L700,L701,L702,L703 BEAD-SMD

TAC700,TAC701,TAC702 SWITCH-TACT

TAC703,TAC704 SWITCH-TACT

RFS100 CONNECTOR-COAXIAL

CN800 CONNECTOR-ZIP

SLC500 CONNECTOR-ZIP

SIM400 CONNECTOR-CARD EDGE

CD400 CONNECTOR-CARD EDGE

IFC700 SOCKET-INTERFACE

HDC602 HEADER-BOARD TO BOARD

HEA601 HEADER-BOARD TO BOARD

HDC603 HEADER-BOARD TO BOARD

HDC600,HEA700 HEADER-BOARD TO BOARD

BTC700 HEADER-BATTERY

ANT200 NPR-ANTENNA CONTACT

BAT400 BATTERY-LI(2ND)

GH13-00066A UCP800 IC-MULTI REG

GH71-08426A ANT100,ANT101,ANT102 NPR-ANTENNA CONTACT

GH71-08426A ANT_GND100 NPR-ANTENNA CONTACT

GH71-08426A SHUTTER700 NPR-ANTENNA CONTACT

GH71-08426A SHUTTER701 NPR-ANTENNA CONTACT

2007-010045

R811 R-CHIP

Please consult the GSPN website(Samsung Portal) for the most recent version of the product's part list.

6-9

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Disassembly and Assembly Instructions

7.

Disassembly

7-1.

1

Be care of Shooting out damage and scratch not to

1)

occur.

Screw SIZE

2)

TORQUE

3)

Unsrew4points from the rear case

1)

: 1.4M*5.0L

: 1.2 ~ 1.4

Kgf.cm

2

When you disjointarear case from right side to left

1)

side, be care of hooks and key hanging.

Disjoint hooks

1)

3 4

Be care of Shooting out damage and scratch not to

1)

occur.

Disjointarear ase usingadisjointing knife.

1)

.

Disjointarear ase usingadisjointing knife.

1)

Be care of Shooting out damage and scratch not to

1)

occur.

.

7-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5 6

Be care of Shooting out damage and scratch not to

1)

Disjointarear ase usingadisjointing knife.

1)

occur.

Disjointarear ase usingadisjointing

1)

knife.

Be care of Shooting out damage and scratch not to

1)

occur.

.

7 8

DisassembleaREAR case.

1)

DisassembleaSUB PBA Connector and

1) TSP FPCB.

Be care of damage of connector and FPCB.

7-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

9 10

Be care of damage of connector and FPCB.

1)

Disassemble LCD FPCB Connector

1)

First unscrew Intenna screw1point and

1)

disjoint Intenna.

When unscrew, be care of Shooting out damage and

1)

scratch not to occur

Screw SIZE

2)

TORQUE

3)

: 1.4M x 3.0L

: 1.0 ~ 1.2

Kgf.cm

Disjoint Intenna.

1)

11 12

Be care of damage of surrounding components.

1)

Disassemble connector.

1)

Be care of damage of connector and FPCB.

1)

7-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization