PS Engineering PAV80 Pilot’s Guide

may also have other rights, which may vary from state to state.
Flying Never Sounded So Good!™
Some states do not allow the exclusion of limitation of incidental or consequential damages, so the above limitation or exclusions may not apply to you.
All items repaired or replaced under this warranty are warranted for the remainder of the original warranty period. PS Engineering, Inc. reserves the rights to make modifications or improvements to the product without obligation to perform like modifications or improvements to previously manufactured products.
Factory Service
The unit is covered by a one-year limited warranty. See warranty information. Call PS Engineering, Inc. at (865) 988-9800 before you return the unit. This will allow the service technician to pro­vide any other suggestions for identifying the problem and recom­mend possible solutions.
After discussing the problem with the technician and you obtain a Return Authorization Number, ship product to:
PS Engineering, Inc. Attn: Service Department 9800 Martel Rd Lenoir City, TN 37772 (865) 988-9800 FAX (865) 988-6619 Email: support@ps-engineering.com
NOTE: PS Engineering will not be responsible for any units shipped in the U. S. Mail. Units received without either a Return Authorization or a contact telephone number will be refused and returned to the sender.
9800 Martel Road
Lenoir City, TN 37772
www.ps-engineering.com
Crew Pass
PAV80
PAV80
High-fidelity Audio-Video
In-Flight Entertainment System
With DVD/MP3/CD Player
and Radio Receiver
Operation Manual
FAA-PMA
PS Engineering, Inc. 2003 ©
Copyright Notice
Any reproduction or retransmittal of this publication, or any portion thereof,
without the expressed written permission of PS Engineering, Inc. is strictly prohibited. For further information contact the Publications Manager at PS
Engineering, Inc., 9800 Martel Road, Lenoir City, TN 37772.
202-800-0101 Page 12 Rev. 2 August 2003
Phone (865) 988-9800.
Pilot’s Guide
Pilot’s Guide
and
and
Operation Manual
Operation Manual
202-800-0101
PAV80 IFE Pilots Guide Page 1 Rev. 2 August 2003
Rev 2 August 2003
Section I, General Information
INTRODUCTION
Congratulations on your selection of the PS Engineering PAV80 In-flight Entertainment system. This system, designed specifically for general aviation, combines a Digital Versatile Disc (DVD) player with CD and MP3 capability with an AM/FM radio for ulti­mate in-flight entertainment capability.
Please read this Pilot Guide so you can become familiar with
the features packed into the PAV80.
EQUIPMENT DESCRIPTION
The PAV80 System is a single panel mounted unit that contains a DVD player with MP3 media capability and an AM/FM radio receiver. It also contains a high-fidelity stereo amplifier to provide the entertainment out­put to the aircraft audio system. Up to four remote-mounted video dis­plays can provide visual entertainment to the passengers (with optional equipment required to use more than one display).
An 8-digit LED display provides information about the systems modes and media in use.
Because of the high-speed data requirements of the DVD mechanism, the radio frequency reception using the internal antenna is limited. Therefore, when used for AM or FM reception, the operator may only receive the most powerful 3 to 5 stations. In contrast to an ADF, where audio fidelity is not important, the PAV80 requires higher signal levels to ensure fidelity.
For optimum performance, some installers may desire an external AM/FM antenna. PS Engineering recommends a Comant CI-222-series.
Section II OPERATION
At PS Engineering we believe that we have made the PAV80 simple to use. However, we have packed loads of features into the system to make it flexible, so it will meet your requirements for cross country flying in light aircraft.
We’ll start with a tour of the front panel. We call it human-machine inter­face, but you can call it knobs and buttons.
the MP3 tagged information screen. Select the General tab to show the informa­tion that can be modified for the PAV80.
The PAV80 can display song name, artist, album, and filename. This corre­sponds to the Track title, Artist, Album, and Track Filename fields shown on the screen. Each of these fields can be modified to the user’s preference. Note: The PAV80 is limited to displaying up to 22 characters in each of these fields. Click on the appropriate field to modify the track title, artist, or album. To modify the filename, select the Rename Files button in the lower left corner. Click on the field labeled New File Name and press OK to change the file name. Press the Apply and OK buttons to update the information
Section IV- Warranty and Service
Warranty
In order for the factory warranty to be valid, the installations in a certified aircraft must be accomplished by an FAA-certified avion­ics shop and authorized PS Engineering dealer. If the unit is being installed by a non-certified individual in an experimental aircraft, a factory-made harness must be used for the warranty to be valid.
PS Engineering, Inc. warrants this product to be free from defect in material and workmanship for a period of one (1) year from the date of installation as recorded in aircraft logbook and/or on FAA Form 337. During the twelve (12) months, PS Engineering, Inc., at its option, will send a replacement unit should be determined to be defective after consultation with a fac­tory technician.
All transportation charges for returning the defective units are the responsibility of the purchaser. All domestic transportation charges for returning the exchange or repaired unit to the pur­chaser will be borne by PS Engineering, Inc. The risk of loss or damage to the product is borne by the party making the shipment, unless the purchaser requests a specific method of shipment. In this case, the purchaser assumes the risk of loss.
This warranty is not transferable. Any implied warranties expire at the expiration date of this warranty. PS Engineering SHALL NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAM­AGES. This warranty does not cover a defect that has resulted from improper handling, storage or preservation, or unreasonable use or maintenance as determined by us. This warranty is void if there is any attempt to dissemble this product without factory au-
thorization. This warranty gives you specific legal rights, and you
at our expense if the unit
202-800-0101 Page 2 Rev. 2 August 2003
PAV80 IFE Pilots Guide Page 11 Rev. 2 August 2003
Volume Control
Men u Se lec tion
Disc Cont rol
Tr ack S elect ion
MENU
1
2 3
NEXT
4
5 6
0
7
8 9
FF
ENTER
UP
DOWN
LEFT
RIGHT
PREV STOP
REW
VOL
UP
EJECT
PLAY
PAUSE
VOL
DN
PAV80 IF E SYSTEM
V O L U
M
E
M E N U
D
I S C
T R A C K
The remote supplied is used to control various functions of the secondary audio output, as well as the DVD menu functions.
Remote Control
(not to scale)
The Remote uses a CR2025 type battery, which is located under the cover on the bottom. Should the remote unintentionally depart the aircraft, additional units are available at 1-800-ICS-AERO
Appendix A – MP3 Creation
Creating MP3s from an Audio CD
Start MusicMatch JukeBox.(www.musicmatch.com which is the small red dot located in the top right corner. This will open the re­corder window located at the bottom of the screen.
Insert an audio CD into the CD drive. MusicMatch will automatically read the disc and display the contents in the recorder window. Press the REFRESH button to check the Internet database for CD information, such as artist, song title, or album. If this information is available, it will automatically be updated in the file.
Select Options->Recorder->Format and select either MP3 or MP3PRO format. You may also set the MP3 file quality under the Options->Recorder->Quality menu.
Select the tracks to be copied to MusicMatch by checking the box next to the desired track. Press the record button in the lower left corner when complete
MusicMatch will then convert the files from the audio CD to MP3 and display them in the Music Library box located in the middle of the screen
To edit the MP3 information, select a file in the Music Library and press the TAG button in the top right corner of the Music Library box. This will display
202-800-0101 Page 10 Rev. 2 August 2003
) Press the recorder button,
Operating Principals
The first thing you will notice about the PAV 80 is the 8-digit dis­play on the front. You’ll notice that it is split into two sections, while displaying the modes. The left side shows the audio source delivered to the front seats in the airplane the right side displays the audio fed to the passengers*.
*NOTE: This description is valid when interfaced with PS Engineering
PMA7000-series audio panels, other audio systems may differ. Consult your
professional installer for details
The PAV80 is divided like this to give the ultimate in multi­tasking entertainment audio. The pilot can listen to music in the FM radio while the passengers may watch the DVD movie.
Operating Controls Overview
Crew Pass
Front Panel Controls
We have two knob/pushbuttons on the PAV80, Volume (1) and Mode (2). The volume control also turns the unit on and off, and is used to select the whether the knob adjusts Crew volume, or the passenger volume level.
The “MODE” (2) knob is used to control the functions of both the crew and passenger, and it changes the disc track if the crew is selected to a disc mode.
Four push buttons (3) grouped around the display control the radio and disc functions. There is an “eye” (4) on the front panel, which received commands from the remote control.
The disc slot (5) is where your favorite music or movie goes in. Give it a gentle push, and the player will roll the disc into the ma­chine.
PAV80 IFE Pilots Guide Page 3 Rev. 2 August 2003
Quick start – Six steps to motion picture success
Okay, you’ve been waiting long enough, let’s see the show! This section will get you enjoying in flight entertainment in a jiffy. Although the PAV80 is designed for in-flight entertainment, we recommend that you familiarize yourself with it on the ground first.
1.Turn on battery and avionics master.
2.If it isn’t on already, turn on the audio panel (or intercom). a. Get comfortable in the headset
b.Turn on the PAV80. It doesn’t come on by itself; we designed it to be off,
until you want it on. Turn the unit on by pressing the volume knob (1).
c. Also turn the display on by pressing the power button. d.Put the DVD into the slot, and push gently until the player takes over. The
display will show “Loading”.
e. After the video shows the copyright restrictions, the Play/Pause will blink. f. When the Play/Pause (►) light begins to blink, push it.
g. Usually a DVD will present you with a menu screen, where you can select
all it special features you want. For a quick movie:
Push the Play/Pause button again, and the movie will play from beginning to end
Action Disc Result
short press
long press
short press
►► press
◄◄ press
Stop
Eject
Pause
Change to FM, AM, AUX (if enabled)
Toggle into Random or normal Sequence play
Video Source Select
The PVT801 is capable of displaying video format in NTSC (USA) or PAL (International) standards. HINT! If your display is behaving strangely, check the video mode. We have some experience in this regard. In addition, the display has two inputs, AV1 and AV2. The AV2 input is not mechanized in the PS Engineering system, so you will not get a picture is the display is inadvertently put in this mode. More experience here.
Radio Operation
Select the AM or FM as above. The display will change to the FM frequency (XX.X), or AM (XXX). The right knob will then increase or decrease the radio frequency. The other quick way to change the radio channel is to push the up or down but­tons to scan for the next available station.
Receiver Threshold Adjustment
The amount of signal required to stop the frequency scan on a forequency can be adjusted to suit your needs. When the crew is in FM or AM mode, press and hold the MODE knob for 3 seconds to enter the sensitivity adjustment. The LED dis­play will show "SENSE xx" where xx is a level from 1-10 (1 is lowest threshold or weakest signal, 10 is more powerful station). This display will revert to the MODE display after 5 seconds with no adjustment. There are two different sensi­tivity levels (FM and AM) and once adjusted, they will be stored in non-volatile memory.
Radio Reception
Because of the high-speed data requirements of the DVD mechanism, the radio frequency reception using the internal antenna is limited. Therefore, when used for AM or FM reception, the operator may only receive the most powerful 3 to 5 stations. In contrast to an ADF, where audio fidelity is not important, the PAV80 requires higher signal levels to ensure fidelity.
For optimum performance, some installers may desire an external AM/FM an­tenna. PS Engineering recommends a Comant CI-222-series.
DATA knob CW
DATA knob CCW
DATA knob Push
202-800-0101 Page 4 Rev. 2 August 2003
Quick Track Select next track and play
Quick Track Select previous track and keep playing
Selects Entertainment Mode
Remote Operation
PAV80 IFE Pilots Guide Page 9 Rev. 2 August 2003
PVT801 Video Display Terminal operation
The on/off switch on the LCD video terminal is independent of the PAV80 itself. This is the round button along the right side of the PVT801. The other buttons control the picture quality of the PVT801, and the input modes.
NOTE: best results will be obtained with some shade on the
PVT801 screen.
PVT801 MENU
The on-screen display for the PVT801 controls the picture tint and color, as well as the brightness. A final selection will restore the factory default settings (when you get totally confused!) Press the MENU icon to activate the on screen menu display, select the secured
function by touching the menu button again, and then use the up and down ar­rows to slew the range.
COLOR
BRIGHT
TINT
RESET
Detailed Operation
On/Off
Push once to turn the unit on. Push again momentarily, and the unit goes off, dis­playing “shutdown” as the system performs house­keeping chores before going to sleep.
Push on-off
NOTE: It is NOT necessary to “shutdown” the PAV80 before turning the
avionics master off. However, if the PAV80 is switched off in the middle of a movie, it will not remember the place where it stopped, and start over from the beginning.
Volume control for crew
Twisting the volume knob clockwise will increase the CREW volume. The dis­play will change to VOL, followed by a number representing the volume level.
Volume control for passengers
To change the Passenger volume control from the PAV80
panel, push AND HOLD the volume control until the right side of the
display changes to VOL. Then the volume of the entertainment going
to the passengers can be changed. In addition to the PAV80 controls, the passengers can control their
volume from the remote control, simply by pressing the up and down volume buttons. The
display will show the new volume level.
VOL
UP
VOL
DN
V O L U
M
E
Changing the display brightness
202-800-0101 Page 8 Rev. 2 August 2003
PAV80 IFE Pilots Guide Page 5 Rev. 2 August 2003
Audio Source Selection
The PAV80 system offers unprecedented control over the internal and external audio sources, for true multi-tasking audio. The split functions allow the crew to listen to a different audio source than the passengers, or the same source.
Source Selection
source, or AXA, which is just the audio portion without video. There is only one input, so you can’t use AUX and AXA at the same time.
Although the unit is capable of OFF/OFF mode combination, there isn’t any reason to use this mode, except for silent movies.
Playing discs
No disc Inserted
PUSH
BLINK
TURN
CREW SOURCE SELECTION
PUSH
BLINK
TURN
PASSENGER SOURCE SELECTION
PUSH
Push the right knob (MODE) to enter the source selection mode. When the button is pushed once, the left side of the display (Crew) can be changed. Push again and the passengers’ audio source is changed. The mode is accepted- Locked in- when the but­ton is pushed again. to change the passengers’ audio source, press the mode button twice, until the right side of the display blinks. Then select the source, and press again to accept your new audio source.
Audio Combinations
The PAV80 has effectively three different audio sources, the internal disc (DVD, CD, or MP3), the radio (AM or FM), or an auxil­iary input. The auxiliary is sub divided into AUX, which is audio/video from a external
SELECT
SELECT
CREW PASSENGERS
DISC DISC DISC RADIO DISC DISC
RADIO DISC RADIO RADIO RADIO AUX RADIO AXA RADIO OFF
AUX RADIO AUX AUX AUX OFF AXA DISC AXA AXA AXA RADIO AXA OFF
OFF DISC OFF RADIO OFF AUX OFF AXA OFF OFF
AXA
OFF
PUSH
(Accept)
PUSH
(Accept)
DVD disc Inserted
MP3 disc Inserted
Audio CD disc Inserted
Your PAV80 can play many different types of recorded disc media, including CD, CD-R, CD-RW, MP3, and DVD. This means that virtually any music you have, from a prerecorded audio CD, or a home movie stored on a DVD, can be played in your unit.
Simply insert the disc into the slot. The PAV80 will accept the disc, and auto­matically detect the type of media.
PAV80 panel Unit Display Dimming
The display is adjusted for ambient light conditions by the connection to the aircraft dimmer bus. If the radio light dimmer is turned all the way off, the dis­play will be at full intensity. So, if your PAV80 display seems dim, check your radio light dimmer control.
202-800-0101 Page 6 Rev. 2 August 2003
PAV80 IFE Pilots Guide Page 7 Rev. 2 August 2003
Loading...