FIUK0401G62
CHOO CHOO EXPRESS
USE AND CARE
GB
model number IGED10831
6V
1 2 3
4 5 6
7 8 9
121110
151413
B
A
181716
212019
242322
272625
302928
A
B
BA
31 32 33
34
24
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
1 ASGI0071VF
2 SPST0438YF
3 SAGI0437N
4 ASGI0072YF
5 ASGI0073R
6 IAKB0016
7 SPST3750VF
8 SPST3599N
9 SPST0421R
10 IKCB0019
11 SPST0439R
12 SOFF0065Z
13 SPST0334N
14 SPST0407VF
15 SPST3627N
16 SAGI9963JKTB
17 SPST0112N
18 SOGI0097S
19 SPST3611N
20 SPST3634R
SPST3624R
21 SPST0248N
22 SOFF0071Z
23 SPST0432YF
24 MMEV0221
25 MEIE0003
MEIE0004
B
B
A
C
B
C
25
ELECTRIC SYSTEM
DECAL
b = blue
bk = black
r = red
w = white
MEIE0003
MEIE0004
1
OPTION
1
SPST0404YF
2 SPST0405YF
3 SPST0337YF
2 3
32 • Once the charge is completed unplug recharger from wall outlet. Unplug
recharger cord terminal C from battery terminal B.
33 • Plug battery terminal A into vehicle wiring terminal B.
34 • Close and fix the seat with the security screw.
Before riding,charge your batteries for 18 hours to initiate them.Failure to do this
will result in permanent battery damage.
CAUTION
Rechargeable batteries are only to be charged under adult supervision.
Never allow children to handle batteries.
CHARGE BATTERY
• Charge the batteries no longer than 24 hours, following the instructions
enclosed with the battery charger.
• Charge the battery, as the vehicle shows low power, in this way you will avoid
damage to the battery.
• If you don’t use your vehicle for a long period of time unplug the battery from
the main wire harness of the vehicle. Remember to charge the battery at least
every three months.
• Never charge the battery upside down.
• Do not forget batteries during charging! Check them periodically.
• Never use a replacement recharger or batteries unless they are approved by PEG
PEREGO.
• Do not mix old and new batteries.
• Batteries are sealed and maintenance free.
• Battery polarity must be observed when connecting battery to wiring.
WARNING
• BATTERIES CONTAIN TOXIC AND CORROSIVE SUBSTANCES. DO NOT TAMPER
WITH THEM.
• Batteries contain an acid-based electrolyte.
• Do not make direct contact between battery terminals, as this can cause an
explosion or fire.
• Charging produces explosive gases. Charge batteries in a well ventilated area
away from sources of heat and flammable materials.
• Exhausted batteries are to be removed from the vehicle.
• Do not place the batteries near clothing to avoid damage.
IF A LEAK DEVELOPS
Shield your eyes.Avoid direct contact with the electrolyte, protect your hands.
Place battery in a plastic bag and follow directions listed below.
IF ELECTROLYTE COMES IN CONTAC WITH SKIN OR CLOTHING
Flush with cool water for at least 15 minutes.
See a physician at once.
IF ELECTROLYTE IS INJESTED
Give tap water,milk of magnesia or egg whites at once.
Do not induce vomiting.
See a physician at once.
DISPOSAL OF BATTERIES
Help protect the environment!
Do not throw used batteries in your regular,house hold trash.
Dispose of the old batteries in an approved dumping station; contact your local
environmental protection agency office for further information.
CAUTION AA BATTERY
The insertion of batteries must only be carried out or supervised by adults. Do not
let children play with the batteries.
• The batteries should be replaced by an adult.
• Use only the type of battery specified by the manufacturer.
• Respect the polarity +/-
• Do not allow the batteries to be in contact with metal parts (risk of fire or
explosion).
• Always remove the batteries if the toy is not in use for a long period.
• Do not throw batteries on the fire.
• Never attempt to charge batteries that are not rechargeable.
• Remove dead batteries from the toy.
• Dispose of dead batteries into containers provided for the recycling of dead
batteries.
This product conforms to EN 71 and conforms to EN 50088 safety standard for
electric toys.
This vehicle is not intended for use on streets,around traffic or parked cars.
MAINTENANCE AND CARE
• Regularly check the conditions of the vehicle, particularly the electrical system,
the plug connections, the covering caps and the charger. In case of fault,do not
try to use the vehicle and the charger.For repair use only original PEG PEREGO’s
spare parts.
• PEG PEREGO assumes no liability if the electrical system is tampered with.
• Do not leave vehicle or batteries near sources of heat such as radiators, stoves,
fireplaces, etc.
• Protect vehicle from water,rain, snow, etc. Do not ride in loose sand or mud as
these substances will cause premature failure of switches,motors and gears.
•PEG PEREGO® thanks you for choosing this product. For over 50 years, PEG
PEREGO has been taking children for an outing: first with its famous baby
carriages and strollers, later with its pedal and battery operated toy vehicles.
•Read this instruction manual carefully to learn the use of this vehicle and to teach
your child safe and enjoyable driving. Please keep this manual for use as a
reference in the future.
•Our toys conform with the safety requirements provided by the Council of the
EEC, of the T.Ü.V.; of the I.I.S.G. Istituto Italiano Sicurezza Giocattoli, and the U.S.
Consumer Toy Safety Specification F963.
•Peg Perego reserves the right to modify or change their product.Price,literature,
manufacturing processes or locations or any combination of these above
mentioned entities may change at any time for any reason without notice with
impunity.
Years 2-4
PEG PEREGO offers after-sales services, directly or with a network of authorized
service centers for repairs or replacement parts. See the back cover of this
instruction manual for a list of service centers.
Peg Perego is at the consumer's service,meeting every need in the best way
possible.This is why our customers' opinions are so important and valuable to us.
We would be very grateful if you would kindly fill in the CUSTOMER SATISFACTION
QUESTIONNAIRE after using one of our products.You will find the questionnaire
on the Internet at "www.pegperego.com/SSCo.html.en-UK". Please note any
observations or suggestions you may have on the questionnaire.
ADULT ASSEMBLY REQUIRED.
USE CARE WHEN UNPACKING AS COMPONENTS TO BE ASSEMBLED MAY POSE A
SMALL PARTS/SHARP EDGE HAZARD.
BATTERY ALREADY INSTALLED IN VEHICLE.
ASSEMBLY
1 • Install the roof.
2 • Pull the sides of the roof and fit as shown the figure.
3 • Press on the roof until it clicks into place.
4 • Screw in the two screws.
5 • Insert the electrical wire fully into the bodywork.
6 • Remove the funnel from inside the engine.
7 • After disconnecting the funnel from the train open funnel by removing top
piece from bottom piece.
8 • Unscrew the panel.
9 • Once you have removed the panel,fit the two AA batteries -Not included- into
their holder,taking care to respect correct polarity. Reassemble the funnel.
10 • Connect the funnel wiring by plugging one into the other.
11 • Install the funnel as shown in the figure pushing it fully into place.
12 • Remove the cover from inside the engine.
13 • Click it onto the bodywork.
14 • Assemble the rails as shown in the figure. ATTENTION: you must position the
train on the tracks so that it runs in a clockwise direction.
15 • Remove the screw at the back of the seat.
16 • Press on the tab and
17 • remove the seat.
18 • Plug battery terminal B into vehicle wiring terminal A.
19 • Reclose the seat back down by inserting the tabs into the two slots (see detail
into figure 20).
20 • Detail. NOTE:Always reclose and rescrew the seat. The train is now ready for use.
VEHICLE FEATURES AND INSTRUCTIONS FOR USE
21 • A: forward button.B: siren button.
OPTION
22 • OVAL CIRCUIT. Circuit: 12 curves (already supplied) and 4 straight.
23 • OPTION: FIGURE-8 CIRCUIT. Circuit: 18 curves (12 already supplied),4 straight
and 4 crossover.
24 • To assembly the crossing of figure-8 circuit overlap the first piece.
25 • Overlap the second piece.
26 • To insert the last piece into the crossing, proceed as shown in the drawing,
rotating the piece in question.
27 • Then continue similarly with the other pieces.
REPLACING THE BATTERY
28 • Unscrew the seat safety screws. Lift up the seat. Unplug vehicle wiring
terminal A from battery terminal B, by pressing terminals on side and pulling
apart. Unscrew and remove battery fastener.
29 • Replace the battery. (NOTE: The replacement battery – separately available – is
a 6v/ 7Ah battery pack). Replace and screw back on the battery fastener.
Connect the two plugs.CAUTION:When you have finished, remember to close
and screw down the seat.
BATTERY RECHARGE
WARNING: BATTERY CHARGING AND EVERY OTHER OPERATION ON THE
ELECTRICAL SYSTEM MUST BE CARRIED OUT BY ADULTS ONLY.
THE BATTERY CAN ALSO BE CHARGED WITHOUT REMOVING IT FROM THE TOY.
30 • Unplug vehicle wiring terminal A from battery terminal B, by pressing
terminals on side and pulling apart.
31 • Plug the battery charger terminal to a wall outlet following the instructions
enclosed. Connect the plug B to the battery charger plug C.
ENGLISH
CUSTOMER SERVICE
ASSEMBLY INSTRUCTIONS
BATTERY MAINTENANCE AND SAFETY
VEHICLE MAINTENANCE AND SAFETY
• When operating in overload conditions, such as soft deep sand, mud or rough
uneven terrain, the overload circuit breaker will automatically disconnect the
power. After 10 or more seconds,the circuit breaker will automatically reset,
howevere you must eliminate overload conditions to resume normal driving.
• Periodically lubricate (with a light weight oil) moving parts, such as wheel
bearings, steering linkages,where they rotate or touch one another.
• The vehicle’s surface can be cleaned with a dampcloth. Do not use abrasive
cleaners.The cleaning must be carried out by adults only.
• Never disassemble the vehicles mechanisms or motors unless authorized by
PEG PEREGO.
Conforms a EN 50088
Recargeable battery 6V 4,5Ah sealed lead-acid battery.
One 60W motor
SAFETY
WARNING! THE CAR MUST BE USED UNDER ADULT SUPERVISION.
• A child must be 2 years of age or older for the necessary coordination and
maturation to operate this motorized vehicle safely.
• Never use the vehicle on steep slopes or near steps or stairs. This vehicle is not
suitable for use on public highways.
• Children should always wear shoes when riding in or driving a ride-in/ride-on
vehicle.
• Do not allow children to place their hands, feet or any part of their body,
clothing or other articles near the moving parts while vehicle is in operation.
• Do not allow the electrical components, motors,wiring, switches of your
motorized vehicle to become wet and never wash it with a hose.
• Never use gasoline or other flammable substances near the vehicle.
• The vehicle is constructed just for one child.
DON'T STOP THE FUN:always have freshly charged, back-up batteries on hand.
For your child’s safety: please read and follow all instructions below before
operating.
• ATTENTION:
Make sure that all bolts are correctly tightened.
• FORWARD SPEED:
With both hands on the handlebars, press down on the forward button; the
vehicle goes forward at 1.5 mph.
• BRAKE:
To stop let go of the forward button.
Teach your child the proper use of this vehicle for a safe and fun play time.
• Before starting be sure that the way is free from people and objects.
• Drive with both hands on the handlebar and keep your eyes on the road at all
times.
• Stop in time to avoid accidents.
• CAUTION! When operating in overload conditions, such as soft deep
sand, mud or rough uneven terrain, the overload circuit breaker will
automatically disconnect the power. After 10 or more seconds,the circuit
breaker will automatically reset, howevere you must eliminate overload
conditions to resume normal driving.
IF THE VEHICLE DOES NOT OPERATE?
• Check that all the plugs are properly connected.
• Check the forward button, if vehicle no runs replace switch.
• Check that the battery is connected to the electrical system.
IF THERE IS NO POWER?
• Fully recharge the batteries. If the problem persists,check with an Authorized
PEG PEREGO Service Center.
PROBLEMS?
RULES FOR SAFE DRIVING
PEG PEREGO S.p.A.
via DE GASPERI 50 20043 ARCORE (MI) ITALIA
tel. 039·60881 fax 039·615869-616454
assistenza: tel.039·6088213 fax 039·3309992
PEG PEREGO U.S.A Inc.
3625 INDEPENDENCE Dr. FORT WAYNE IN 46808
phone 260·4828191 fax 260·4842940
call us toll free 1·800·728·2108
llame USA gratis 1·800·225·1558
llame Mexico gratis 1·800·710·1369
PEG PEREGO CANADA Inc.
585 GRANITE COURT PICKERING ONT. CANADA L1W3K1
phone 905·8393371 fax 905·8399542
call us toll free 1·800·661·5050
PEG Kinderwagenvertriebs- und Service GmbH
Rudolf-Diesel-Straße 6 D - 85221 Dachau (Germany)
Tel. 0049 / 08131 / 5185-12 Fax 0049/ 08131 / 5185-40
e-mail: info@peg.de
AND DISTRIBUTED IN UNITED KINGDOM AND EIRE BY:
MAMA'S AND PAPA'S LTD
HUDDERSFIELD HD5 0RH ENGLAND
toy helpline: (01484) 438222
BURIGOTTO S/A INDÚSTRIA E COMÉRCIO
RUA CEARÁ,406 - VILA SÃO CRISTOVAN - LIMEIRA SP
CEP 13480-565 - TEL (19) 451 0420 - FAX (19) 451 6994
WWW.BURIGOTTO.COM.BR e-mail: info@burigotto.com.br
www.pegperego.com
CHOO CHOO EXPRESS
model number IGED10831
Loading...