Nokia 6070 RM-166, 6070 RM-167 Schematic
Service Schematics
Introduction
Important:
This document is intended for use by authorized service centers only.
“Service Schematics“ was created with focus on customer care.
The purpose of this document is to provide further technical repair information for
NOKIA mobile phones on Level 3/4 service activities.
It contains additional information such as e.g. “Component finder”,
“Frequency band table” or “Antenna switch table”.
The “Signal overview” page gives a good and fast overview about the most
important signals and voltages on board.
Saving process time and improving the repair quality is the aim of this document.
It is to be used additionaly to the service manual and other training
or service information such as Service Bulletins.
All measurements were made using following equipment:
Nokia repair SW : Phoenix version 2006.04.6.130
Oscilloscope : Fluke PM 3380A/B
Spectrum Analyzer : Advanced R3162 with an analog probe
RF-Generator/GSM Tester : Rhode & Schwarz CMU 200
Multimeter : Fluke 73 Series II
Exploded view and component disposal
RM-166/167
While every endeavour has been made to ensure the accuracy of this document, some
errors may exist. If the reader finds any errors, NOKIA shall be notified in writing.
Please send E-Mail to: training.sace@nokia.com
Copyright © NOKIA
This material , including documentation and any related computer programs is protected
by copyright, controlled by NOKIA. All rights are reserved. Copying, including reproducing,
modifying, storing, adapting or translating any or all of this material requires the prior
written consent of NOKIA. This material also contains confidential information, which may
not be disclosed to others whitout the prior written consent of NOKIA.
Customer Care / Training & Vendor Development / Content Creation Team
Confidential - Copyright © 2006 NOKIA Only for training purposes
Table of contents
Frontpage 1
DCT-4 common baseband 2
Sytem connector & Audio 3
UEME & SIM 4
UPP, Combo memory & IrDA 5
FM Radio & Camera 6
UI, Vibra & Key PWB 7
RF part 8
Signal overview 9
Component finder - engine 10
Component finder - keyboard 11
Version: 1.0 | 23.04.2006 |
6070 RM-166
RM-167
| Board version: 1vba_30a |
Frontpage
|Page 1(11)
5
7
2
6
9
MODE
RESET
0
TXP
TXA
6
7
8
9
0
3
4
5
2
1
RXIINP
TXIOUTP
TXQOUTP
VREF01
RXIINN
RXQINN
VREF02
RXQINP
TXIOUTN
TXQOUTN
0
1
5
2
PA_IDENT
RFCLK_I
6
PATEMP
RFBUSDA
RFBUSEN1
RFBUSCLK
Components: 2700-2799
SYS_CONN Components: 2000-2059
POWER Components: 2200-2399
Components: 2400-2599
AUDIO Components: 2100-2199
Components: 1470-1499
ADC_FIL TER Components: 2270-2299
PWR_FIL TER Components:2330-2349
Components: 2800-2899
RFCONV(9:0)
RFCONVCTRL(2:0)
RFCONVDA(5:0)
SIMIF(3:0)
SLOW AD(6:0)
UIDRV(5:0)
XAUDIO(17:0)
2
POWER
ueme_discrete
ACCDIF(2:0)
AGND(2:1)
AUDIO(6:0)
AUDIODA TA(3:0)
AUDUEMCTRL(3:0)
CHARGER(4:0)
GENIO(31:0)
IACCDIF(5:0)
PUSL(3:0)
PWRONX
RF AUXCONV(2:0)
R FC L K GN D
RFCONVCTRL(2:0)
RFCONVDA(5:0)
RFICCTRL(2:0)
GENIO(31:0)
IAC C D IF(5: 0)
KEYB(10:0)
LCDUI(2:0)
MEMAD(24:16)
MEMADDA(15:0)
MEMCONT(9:0)
PUSL(3:0)
RFCLK
1
UPP
basic8m
AUDIODA TA(3:0)
AUDUEMCTRL(3:0)
SIMIF(3:0)
gnd
MUL TIGND
AGND1
AGND2
IRGND
SIM
GENIO(31:0)
MIC(2:0)
PUSL(3:0)
PWRONX
RF AUX(1:0)
SIMIF(3:0)
SLOW AD(6:0)
UIDRV(5:0)
XEAR(3:0)
XMIC(2:0)
SYS_CONN
ACCDIF(2:0)
AUDUEMCTRL(3:0)
CHARGER(4:0)
GENIO(31:0)
HEADINT(1:0)
HOOKINT
IACCDIF(5:0)
IHF(1:0)
IRGND
HOOKINT
IHF (1:0)
MIC(2:0)
PUSL(3:0)
SLOW AD(6:0)
UIDRV(5:0)
XAUDIO(17:0)
XEAR(3:0)
XMIC(2:0)
AUDIO
AUDIO(6:0)
AUDUEMCTRL(3:0)
EAR(1:0)
GENIO(31:0)
HEADINT(1:0)
GENIO(31:0)
KEYB(10:0)
LCDUI(2:0)
MIC(2:0) PUSL(3:0)
PWRONX
SLOW AD(6:0)
UIDRV(5:0)
AUDUEMCTRL(3:0)
GENIO(31:0)
LCDUI(2:0)
PUSL(3:0)
KEY_UI
EAR(1:0)
CAMERA
Components: 3000-3079
combo128+8mbit
MEMORY
GENIO(31:0)
MEMAD(24:16)
MEMADDA(15:0)
MEMCONT(9:0)
Components: 2900-2999
R FIC C T R L(2:0)
S LO WA D(6:0)
PU S L(3: 0)
RF AUX(1:0)
R FA UX C O NV (2:0)
RFCLK
R FC L K GN D
RFCONV(9:0)
RF_BB
gsm_iset
G E NIO (31:0)
RFCONV_O(9:0)
R FIC C T R L_ O (2:0)
S LO WA D_ O (6:0)
R FA UX C O NV _O (2:0)
RFCLK_I
G E NIO _O (31: 0)
VR6
VR7
VrefRF01
VrefRF02
TXA
TXC
TXIM
TXIP
TXP
TXQM
TXQP
VBA T
VCTCXO
VR1
VR2
VR3
VR4
VR5
schematic
AFC
IPA1
IPA2
Mode
PA_IDENT
RFBusClk
RFBusData
RFBusEna1
RFTEMP
RXI
RXQ
Reset
VR6
VR7
VBA T
VR1
VR2
VR3
VR4
VR5
IPA1
IPA2
RF
Page 4
Page 3
Page 3
Page 4
Page 5
Page 5
Page 5
Page 8
Page 8
Page 7
Page 6
Page 6
IR
GENIO(31:0)
IACCDIF(5:0)
IRIF(2:0)
IRIF_I(1:0)
IRIF(2:0)
IRIF_I(1:0)
FMANT
Components: 6100-6199
FMRADIO
radiohead
AUDUEMCTRL(3:0)
FMANT
GENIO(31:0)
PUSL(3:0)
XAUDIO(17:0)
Customer Care / Training & Vendor Development / Content Creation Team
Confidential - Copyright © 2006 NOKIA Only for training purposes
Version: 1.0 | 23.04.2006 |
6070 RM-166
RM-167
| Board version: 1vba_30a |
DCT-4 common baseband
|Page 2(11)
XMIC P
VCHAR
GND
ACI
Vout
HSEAR N
Fbus RX
Fbus TX
HSEAR P
HSEAR R P
HSEAR R N
XMIC N
GND
R2007
14V/50V
100R
R2004
GND
GND
GND
GND
3n3
X2001
GND
2
+ 1
C2012
G
ND
G N
D
1
2 3
4
ESDA14V2-4BF2
R2000
L2000
MCZ1210AD102T
GND
AGND
2
3
4
5
6
7
8
9
X2002
1
10
11
12
13
14
C2009
/2 27p2
2x27p
L2005 600R/100MHz
600R/100MHz
L2004
3n3
C2013
GND
GND
14V/50V
R2006
GND
C2009
/2 27p1
/2 100R?
R2002
L2001
MCZ1210AD102T
1
2 3
4
J2006
J2005
10n
C2008
VAUX2
GND
3n3
C2021
C2020
3n3
GND
R2010
14V/50V
R201 1
14V/50V
J2008
42R/100MHz
L2003
1.5A
F2000
Close to UEME
22p
C2007
0
1
2
GND
1n0
C2006
V2000
1PMT16A T3
CHARGER(4:0)
GND
220k
R2003
ACI pull up
C201 1
270p
VFLASH1
GND
R2005
100k
2
0
PR O D
T
P
3
P
R
O
D
T
P
7
PR
O
DT
P
2
1
ACCDIF(2:0)
/2 100R?R2002
"MIC1P"
"MICB1"
"EARN"
"EARP"
"MIC1N"
GND
3
4
C 2171
? /2 1n
C2159/2 33n?
2
1
C2171
? /2 1n
3
R2160
220R
R2154
?
/2 1k0
GND
GND
C2179
?
/2 22p
C2159
? /2 33n
C2179
?
/2 22p
1
?
2
0
/2 1k0
R2154
4
GND
"EARN"
"EARP"
1
0
J2427
B2400
22p
C2406
J2426
1
23
4
EXC24CB102U
L2150
/2 VWM16V1
R 2151
GND
R2151
/2 VWM16V2
600R/100MHz
L2153
"MICP"
"MICN"
1
GND
22p
C2154
0
R2153
2x2k2
R2156
1k8
1u0
C2175
GND
2
B2402
OUT
1
GND
J2429
J 2430
4
G ND
"MICB2"
"MIC2N"
"HOOKINT"
"MIC2P"
5
/2 1k0
R2174
?
1n0
C2187
GND
C2170
? /2 33n
2x2k2
R2162
R2159
1k0
GND
/2 33n?
C2170
R2174
? /2 1k0
6
C2173
? /2 1n
GND
R2171
1k0
R2158
820R
GND
R2173
220R
1u0
C2176
C2173
? /2 1n
3
"XMICP"
"XMICN"
"HEADINT"
0
XAUDIO(17:0)
"HF"
"HFCM"
C2181
?/2 22p
GND
1
GND
C2181
?/2 22p
2
/2 10R? R2175
/2 10R
R2175
?
"XEARN"
"XEARP"
/2 22p?
C2164
5
GND
6
/2 22p
?
C2164
GND
AUDIO(6:0)
22p
C2180
L2154
33nH
33nH L2155
IHF speaker connection
J2101
J2101_N
J2100_P
J2100
B2401
Earpiece
Microphone
IHF speaker
UEME
UEME
UEME
2.8V
2.8V
External microphone
active = 2.1V
10p
C2016
C2014
10p
C2015
10p
10p
C2017
68nH
L2006
J2010
FMANT
FM radio
Internal microphone
active = 2.1V
IHF -C- Clip s
GN D
X1001 X1002
GN D
GN D GN D
33R
R2 205
33R
R2 202
5R 6
R2 204
5R 6
R2 203
3u3
C2 242
X1003 X1004
GND
L2002
EXC24CB102U
1
4
C2019
3n3
C2018
3n3
GND
R2008
14V/50V
R2009
14V/50V
J2009
GND
2
3
15
16
C2157
?/2 22p
GND
GND
C2157
?/2 22p
/2 10R R2175
/2 10R
R2175
"HFCMR"
"HFR"
Customer Care / Training & Vendor Development / Content Creation Team
Confidential - Copyright © 2006 NOKIA Only for training purposes
Version: 1.0 | 23.04.2006 |
6070 RM-166
RM-167
| Board version: 1vba_30a |
Sytem connector & Audio
|Page 3(11)
GND
GND
GND
C221 1
1u0
470R
R2201
GND
VR6
C2240
1u0
VR1A
VR2
GND
GND
3 2 1 0
GND
C2205
1u0
VR1B
1023
3210
2 1 0
VFLASH1
100n
C2216
GND
GND
GND
1u0
C2202
10n
C2207
1u0
C2227
100n
6
10
VIO
C2229
2
1u0
C2218
1u0
C2226
C2231
1u0
IPA2
VR3
GND
1u0
C2213
1u0
C2204
GND
C2212
GND
1u0
C2224
1u0
17 2 1 16 15 0 7
C2217
100n
C2237
1u0
V5
OSCIN
VBACK
V6
FBUSRXO
V7
V8
SIMCARDDET
HEADINT2
V9
V11
VCHAROUT2
V13
VBA TREGS
V14
GNDREGS
V15
GNDVR1
V16
VR1B
V18
V2
LS
V4
PATEMP
PWRONX
U5
OSCOUT
VRTC
U6
GNDFLASH1
U7
MBUS
U8
AuxDet
U9
V1
PWMO
V10
HOOKINT
VFLASH1
U13
VCHAROUT1
U14
VAUX2
CCN
U15
U16
VBA TVR1
U17
VPUMP
U18
VR1A
VSADRIV2
U2
U3
TXPWRDET
U4
T6
OSCCAP
T7
GNDTH69
FBUSTXO
T8
GNDTH70
T9
BUZZO
U1
HEADINT
U10
VBA TBB1
U11
VBA TAUX2
GNDTH71
T15
T16
CCP
VCORE
T17
T18
VBA TBB4
T2
DLIGHT
T3
VIBRA
T4
VCXOTEMP
GNDTH68
T5
VR2
CALLED2
R2
VSADRIV1
R3
VBA TDRIV
T1
VANA
T10
T11
VBA TBB2
T13
VCHAROUTK
T14
P16
GNDTH67
VBA TVR7
P17
P18
VR6
VDAAUD1
P2
CALLED1
P3
R1
KLIGHT
VBA TVR2
R16
R17
VBA TVR6
R18
N17
N18
VR7
N2
MICBCAP
N3
MICB1
N6
GNDTH57
GNDTH58
N7
N8
GNDTH59
N9
GNDTH60
P1
VSAAUD1
M8
GNDTH51
M9
GNDTH52
MICB2
N1
N10
GNDTH61
GNDTH62
N11
N12
GNDTH63
GNDTH64
N13
N16
VBA TVR4
VR4
GNDTH56
M13
M16
VR5
VBA TVR3
M17
VBA TVR5
M18
MIC3P
M2
MIC3NR
M3
GNDTH49
M6
GNDTH50
M7
GNDTH41
L6
GNDTH42
L7
L8
GNDTH43
GNDTH44
L9
M1
MIC3PR
M10
GNDTH53
GNDTH54
M11
M12
GNDTH55
L11
GNDTH46
L12
GNDTH47
GNDTH48
L13
L16
VBG
L17
VREFRFO1
L18
VR3
L2
MIC2N
L3
MIC3N
K18
VREFRFO2
K2
MICSUB
K3
MIC1P
K6
GNDTH33
GNDTH34
K7
K8
GNDTH35
GNDTH36
K9
MIC2P
L1
L10
GNDTH45
J9
GNDTH28
MIC1N
K1
GNDTH37
K10
K11
GNDTH38
K12
GNDTH39
GNDTH40
K13
VREF278
K16
K17
VREF25RF
GNDTH32
J13
J16
GNDTH66
ISET
J17
VREF25BB
J18
J2
EARP
J3
HFCMR
GNDTH25
J6
J7
GNDTH26
GNDTH27
J8
H2
VSAAUD2
H3
EARN
GNDTH17
H6
H7
GNDTH18
GNDTH19
H8
H9
GNDTH20
J1
HFR
GNDTH29
J10
J11
GNDTH30
J12
GNDTH31
GNDTH12
G9
VDAAUD2
H1
H10
GNDTH21
H11
GNDTH22
GNDTH23
H12
H13
GNDTH24
IPA1
H16
H17
VSACONVTX
H18
IPA2
G13
GNDTH16
G16
GNDTH72
G17
TXQOUTP
AUXOUT
G18
G2
HF
XEAR
G3
G6
GNDTH9
G7
GNDTH10
G8
GNDTH1 1
F3
PAOUTN
F6
GNDTH1
GNDTH2
F7
F8
GNDTH3
F9
GNDTH4
G1
HFCM
G10
GNDTH13
GNDTH14
G11
GNDTH15
G12
F1
PAREFCAP
GNDTH5
F10
F11
GNDTH6
F12
GNDTH7
GNDTH8
F13
TXIOUTP
F16
TXIOUTN
F17
TXQOUTN
F18
D18
VAUX3
D2
VIO
D3
PAV S S
E1
E16
AFCOUT
VSACONVRX
E17
VDACONVTX
E18
E2
PAOUTP
VDD28
C6
Gen18IO1
Gen18IO4
C7
SIMCLKI
C8
C9
MBUSTX
VBA TAUX3
D1
GNDTH65
D16
RXQINN
D17
RXQINP
C14
AUXD
C15
RXQD
C16
RXIINN
C17
C18
RXIINP
C2
VSIM
VAUX1
C3
C4
SIMRST
C5
Gen18IO3
B8
SIMIOCTRL
MBUSRX
B9
VBA TBB5
C1
C10
EARDA TAR
C1 1
FBUSTXI
C12
CBUSCLK
SLEEPCLK
C13
DBUSCLK
TXID
VDACONVRX
B17
SLEEPX
B18
B2
Gen28IO3
B3
Gen28IO1
SIMIODAO
B4
VSIMGND
B5
B7
SIMIODAI
VBA TAUX1
B1
MICDA TA
B10
B11
FBUSRXI
CBUSENX
B12
B13
VSS
B14
UEMINT
DBUSDA
B15
B16
RFCONVCLK
A18
BSI
A2
A3
Gen28IO2
UEMRSTX
A4
SIMCLKO
A5
SMPSCLK
A6
Gen18IO2
A7
A8
Gen18IO5
A9
AUDIOCLK
A10
EARDA TA
A11
CBUSDA
A12
VDD18
A13
A14
DBUSENX
PURX
A15
TXQD
A16
A17
RXID
GND
VANA
D2200
UEMEK_V2.0_LF_WDENA
BTEMP
A1
GND
13
12985436
302931
1u0
C2215
C2214
1u0
1u0
GND
GND
C2206
1u0
C2234
210
GND
VR4
234
C2222
1u0
0
08 9 7 6 5 4 3 2 1
GND
1
GND
GND
GND
C2230
1u0
GND
GND
VFLASH1
1u0
5432
GND
C2223
VAUX2
IPA1
GND
VANA
VR7
GND
GND
VAUX1
VCORE
GND
100n
C2220
VBA TBB
GND
5
C2228
GND
C2225
100n
1u0
C2208
GND
1u0
GND
1u0
2 1 0
C2235
VIO
VR5
1u0
VBA TBB
C2209
C2232
1u0
1u0
C2219
543210
GND
VANA
GND
4 3 5 2 1 0
GND
1u0
C2233
C2238
1u0
GND
C2236
1u0
GND
GND
C2203
1u0
GND
GND
GND
CBUSCLK
AGND2
AGND1
XAUDIO(17:0)
AGND1
AUDIO(6:0)
RFCONV(9:0)
RF AUXCONV(2:0)
AGND2
AGND2
AUDUEMCTRL(3:0)
GENIO(31:0)
PUSL(3:0)
AUDIO(6:0)
XAUDIO(17:0)
ACCDIF(2:0)
RFCONVDA(5:0)
AUDIODA TA(3:0)
IACCDIF(5:0)
RFCONVCTRL(2:0)
UIDRV(5:0)
C2273
1n0
GND
1n0
C2272
C2270
10n
GND
VANA
VAUX3
L2200
42R/100MHz
1u0
GND
C2239
R2272
100k
VFLASH1
100k
R2270
VANA
GND
X2000
VBA T
BSI
GND
J2001
J2003
J2000
J2002
J2004
R2001
GND
C2001
4u7
GND
GND
VBA TBB
VBA TT
BSI
BTEMP
4k7
R2274
4k7
R2273
65410
SLOW AD(6:0)
SIMIODAO
SIMCLKO
SIMRST
R2701
10k
CLK
GND
R2700
EMIF03-SIM01F2
R2
R3
R1
CLK
GND
0
1
2
3
100n
C2703
GND
X270 0
VSIM
VSIM
SIMDA TA
GND
SIMCLK
SIMRST
C2702
47p
GND
GND
6
91485-0001
1
2
43
5
SIM connector
10n
C2201
C2200
1u0
GND
GND
R2200
therm1
27k
R2903
GND
27k
R2423
GND
47p
C2400
102
CHARGER(4:0)
R7700
0R
PA_IDENT
GND
3.3V
G2400
J2428
GND
10p
C2210
B2200
C2241
10p
GND
47k
R2900
R2901
C2901
C2900
10k
GND
GND
10k
100p
100p
C2221
100n
GND
UPP
UPP, UI, FM radio
System
connector
System
connector
System
connector
System
connector
PA identification
~4V
~4V
~4V
2.8V
2.8V
2.8V
2.8V
1.8V
1.8V
2.8V
2.8V if accessory connected
1.35V
2.8V
2.8V
2.8V
2.8V
2.8V
4.75V
32.768kHz
Power switch
RF part
RF part
RF part
Battery
connector
OP E N
PA R7 000
AG ILE N T
RF M D
HITA C HI
39K
S HO RT
not needed
10n
C2271
R2271
100k
VANA
GND
GND
27p
C2005
UI
VANA_EXT
J2800
2
1
VREFRF01=1.35V
VCHARIN2
V12
VCHARIN1
U12
T12
VCHARINK
B6
TESTMODE
PAVDD1
PAVDD2
E3
F2
VSIM = 1.8V/3V
Unpressed ~ 4V
S 2419
G ND
UEMEK
Customer Care / Training & Vendor Development / Content Creation Team
Confidential - Copyright © 2006 NOKIA Only for training purposes
Version: 1.0 | 23.04.2006 |
6070 RM-166
RM-167
UEME & SIM
|Page 4(11)
| Board version: 1vba_30a |
Loading...