GB70 Safety Data Sheet
Section 1 Identification.
Product name: Product code:
NOCO® Genius Boost Lithium-ion Jumpstarter
Other means of identification:
Recommended use:
Nominal voltage:
Rated capacity:
Watt hour (electric energy):
Lithium Content:
Manufacturer:
Emergency telephone
number of the company:
Information telephone
number of the company:
Not available.
Rechargeable lithium-ion battery jumpstarter
11.1V
5000mAh
56Wh
.484/kgs
The NOCO Company
30339 Diamond Parkway #102
Glenwillow, OH 44139
PERS (800) 633-8253 USA/CANADA
PERS (801) 629-0667 INTERNATIONAL
(800) 456-6626
Mon-Fri 8:00am to 4:30pm EST
GB70
Section 2 Hazards identification.
Classification: HMIS Ratings: Health: 0 Fire: 0 HMIS Reactivity: 0
This product is an “article” which is a sealed battery and as such is exempted from the requirements of the Hazard Communication Standard and does not require an SDS unless ruptured. The product is not considered dangerous as manufactured.
The sealed lithium-ion battery is not hazardous in normal use. Do not disassemble, crush, heat about 60°C (140°F) or incinerate. Read Owner’s Manual before use.
The chemicals are contained in a sealed enclosure. Risk of exposure only occurs if the product is mistreated, abused, subjected to extreme pressure deformation, high-temperature environment, overload, external short circuit, or disassembled;
compromising the enclosure. In this case, risk of exposure to the electrolytes can occur. Contact with the internal components may cause irritation or severe burns. It is irritating to the eyes, respiratory system and skin. The electrode materials are
only hazardous if the material is released by mechanical damaging of the cell, or if it is exposed to fire.
Page 1 of 7
no.co
GB70 Safety Data Sheet
Section 3 Composition/information on ingredients.
Exposure to hazardous ingredients is not anticipated under normal product use. Risk of exposure occurs only if the product is
mechanically, thermally, or electrically abused to the point of compromising the enclosure.
Chemical Name Molecular Formula CAS Number Concentration %
Lithium Cobalt Oxide LiCoO
Aluminum Al 7429-90-5 <5
Aluminum Foil Al 7429-90-5 12~15
Lithium Hexafluorophosphate LiPF
Copper Cu 7440-50-8 5~10
Graphite C 7782-42-5 11~15
Carbon C 1333-86-4 <2
PVDF (C2H2F2)
Nickle Ni 7440-02-0 <5
2
6
n
12190-79-3 20~30
21324-40-3 10~20
24937-79-9 <3
Section 4 First aid measures.
General advice:
First aid is only applicable in case of a cell rupture.
Ingestion:
Inhalation:
Eye Contact:
Skin contact:
Most important symptoms and
effects, both acute and delayed:
If swallowed do not induce vomiting. Seek medical attention. Ingestion of battery contents may cause mouth, throat, and intestinal burns and damage.
If irritation of nose or throat develops, move away from source of exposure and into fresh
air. Inhalation of a large number of vapors or fumes released due to heat, damage, or
incorect use, may cause respiratory irritation.
For direct contact, flush the affected eye(s) with gentle stream of clean water for at least
15 minutes. If irritation persists; seek medical attention.
Do not use gasolines, thinners, or solvents to remove products from skin. Remove
contaminated clothing. Cleanse affected area(s) thoroughly by washing with mild soap
and water and, if necessary, a waterless skin cleaner. If irritation or redness develops and
persists, seek medical attention. Contact with battery electrolyte may cause burns and
skin irritation.
Contact with internal components may cause allergic skin sensitizations (rash) and irritate
eyes, nose, throat, and respiratory system. Cobalt and cobalt compounds are considered
to be possible human carcinogens.
Page 2 of 7
no.co
GB70 Safety Data Sheet
Section 5 Firefighting measures.
Extinguishing media:
Unsuitable extinguishing media:
Specific hazards arising
from the chemical:
Hazardous combustion product:
Protective equipment and
precautions for firefighters:
Use foam, dry powder, or dry sand, CO2 as appropriate.
CAUTION: Use of water spray when fighting battery fire may be inefficient.
Under fire conditions, batteries may burst and release hazardous decomposition
products. This could result in the release of flammable or corrosive materials.
CO, CO2, metal oxides, irritating fumes.
Firefighters must wear fire resistant protective equipment and an appropriate breathing
apparatus. Fire and toxic gas resistant clothing is recommended. Remove the container
to open space as soon as possible. Be upwind of the fire before extinguishing.
Section 6 Accidental release measures.
Personal precautions,
protective equipment, and
emergency procedures:
Methods for containment:
If the battery material is released, remove personnel from area until fumes dissipate.
Provide maximum ventilation to clear out hazardous gases. The preferred response is to
leave the area, dispose of the case after the batteries have cooled, and vapors have dissipated. Avoid contact with skin and eyes and avoid inhalation of vapors.
Prevent further leakage or spillage if it is safe to do so.
Waste disposal method:
Collect all released material in a plastic lined container. Dispose of according to the
local law and rules. Dispose of in a timely manner as leached substances can be absorbed into the earth, and subsequently the water.
Section 7 Handling and storage.
Precautions to be taken in
handling and storage:
Storage:
Incompatible products:
Always follow the warning information on the batteries and in the manuals of devices.
Only use on the recommended battery types. Keep batteries away from children. For
devices to be used by children, the battery casing should be protected against unauthorized access. Unpacked batteries should not be stored in bulk. In case of battery change
always replace all batteries with new ones of identical type and brand. Do not swallow
batteries. Do not throw batteries into water. Do not throw batteries into fire. Avoid deep
discharge. Do not short-circuit batteries, use recommended charging time and current.
Keep containers tightly closed in a dry, cool, and well-ventilated place. Store locked up.
Keep out of the reach of children. If battery is subject to storage for long term (more
than 3 months) it is recommended to recharge the battery periodically.
Strong acids. Strong oxidizing agents.
Page 3 of 7
no.co
GB70 Safety Data Sheet
Section 8 Exposure controls/personal protection.
Respiratory protection:
Protective gloves:
Eye protection:
Ventilation:
Other protective equipment:
None (under normal charge and discharge). In case of inaqequite ventilation, use respiratory protection.
Wear rubber protective gloves.
None (under normal charge and discharge).
Use product where there is adequate ventilation.
None (under normal charge and discharge).
Section 9 Physical and chemical data.
Physical state:
Appearance & odor:
Odor Threshold:
Melting/freezing point:
Solid
Silver, odorless
No data available
PH:
No data available
No data available
Boiling point/boiling range:
Flash point:
Evaporation rate:
Flammability (upper
and lower limit):
Vapor pressure:
Vapor density:
Specific gravity:
Solubility:
No data available
No data available
No data available
No data available
No data available
No data available
No data available
Insoluable in water
Section 10 Stability and reactivity data.
Stability:
Incompatability:
Stable under recommended storing conditions.
Avoid contact with strong acids and strong oxidizing agents. Extended exposure to high
temperatures may cause decomposition.
Page 4 of 7
no.co
GB70 Safety Data Sheet
Reactivity:
Hazardous decomposition
products:
Possibility of hazardous reactions:
No data available
Under fire conditions, the electrode materials can form carcinogenic cobalt oxides.
When heated above 150oC the risk of rupture occurs. Due to special safety construction,
rupture implies controlled release of pressure without ignition.
Section 11 Toxicological information.
Communication of physical property, health, and safety information is a key factor in our product safety program. With this
information you can better fulfill your obligation to educate exposed personnel in the proper handling techniques required to
maintain safety in the workplace. Listed in this section is NPCA-HMIS classification for this product.
Unusual hazards:
Routes of entry:
Eyes:
Inhalation:
None known.
Inhalation and skin. Avoid eye contact. Do not ingest.
This material may cause eye irritation. Direct contact may cause burning, tearing and
redness.
This product has low volatility and so is not expected to cause respiratory tract irritation.
Ingestion:
Acute toxicity:
Skin corrosion/irritation:
Eye damage/irritation:
Respiratory sensitization:
Skin sensitization:
Carcinogenicity:
Germ cell mutagenicity:
Reproductive toxicity:
STOT-single exposure:
STOT-repeated exposure:
Aspiration hazard:
Ingestion of this material is not recommended.
No data available.
The liquid in the battery is an irritant.
The liquid in the battery is an irritant.
The liquid in the battery may cause sensitivity in the respiratory tract.
The liquid in the battery may cause sensitivity in the skin.
Cobalt and cobalt compounds are considered to be possible human carcinogens.
No data available.
No data available.
No data available.
No data available.
No data available.
Page 5 of 7
no.co
GB70 Safety Data Sheet
Section 12 Ecological information.
Water hazard class 1
(self-assessment):
Persitance and degradability:
Bioaccumulation:
Other adverse affects:
Slightly hazardous for water.
No information available.
No information available.
No information available.
Section 13 Disposal considerations.
Disposal methods: Dispose of product in accordance with local, county, state and federal regulations.
Section 14 Transport information.
When transported in original packaging, this product complies with all applicable shipping regulations as prescribed by industry and legal standards which include UN Recommendations on the Transport of Dangerous Goods; IATA Dangerous Goods
Regulations (58th Edition) and US DOT requirements.
The product listed in this Safety Data Sheet is less than 100 Whrs. Cells and Batteries have been tested to section 38.3
of the UN Recommendations on the Transport of Dangerous Goods Manual of Tests and Criteria. Original packaging has
passed the 1.2 m drop test.
Air shipment is discouraged unless person preparing or offering product for air shipment is adequately instructed on IATA
Packing Instructions 965 requirements for shipment of lithium ion batteries.
UN number:
Proper Shipping Name:
Air Shipments (IATA):
Sea Shipments (IMO-IMDG):
Europe Road (ADR):
US Road (DOT):
UN3480
Lithium-ion battery
PI 965 Section IB
Special Provision 188
Special Provision 188
173.185(c) A51, A54
Page 6 of 7
no.co
GB70 Safety Data Sheet
Section 15 Regulatory information.
CAS Number USA TSCA EU EINECS China IECSC Canada DSL
1333-86-4 Listed Listed Listed Listed
12190-79-3 Listed Listed Listed Listed
7429-90-5 Listed Listed Listed Listed
24937-79-9 Not Listed Listed Listed Not Listed
7782-42-5 Listed Listed Listed Listed
21324-40-3 Not Listed Listed Listed Not Listed
7440-02-0 Listed Listed Listed Listed
7440-50-8 Not Listed Listed Listed Not Listed
Section 16 Other information.
Prepared on: June 22, 2017
The information herein is presented in good faith and believed to be accurate, based on the present state of knowledge and
current legislation, as of the date of document preparation. This safety data sheet provides guidance on health, safety, environmental, and transportation aspects of the product for users who have professional training.
As this information may be applied under conditions beyond our control and with which we may be unfamiliar; no warranty,
expressed or implied, is given; and this document should not be construed as any guarantee of technical performance or
suitability for particular applications. It is the buyer’s responsibility to ensure that its activities comply with Federal, State, and
local laws.
Page 7 of 7
no.co
Loading...