Noco G4 User Manual
Owner’s Manual & User Guide
WARNING
WELCOME!
1
Risk of SERIOUS INJURY OR DEATH.
ELECTRICAL SHOCK, EXPLOSION,
FIRE, AND EYE INJURY HAZARDS.
PROTECT YOURSELF AND OTHERS.
Before use, READ AND UNDERSTAND
the manufacturer’s instructions and
Owner’s Manual and User Guide.
Failure to read and understand this
information could result in SERIOUS
INJURY or DEATH.
DO NOT REMOVE OR COVER THIS
INFORMATION.
CONTACTING NOCO GENIUS
About Our Products
For questions regarding our products,
you can contact technical support at:
Phone: 1.800.456.6626
Email: support@geniuschargers.com
You can also nd troubleshooting tips
in this manual. See the section called
“Troubleshooting.” You can also nd
our troubleshooting tips online at:
geniuschargers.com/
support/faq
Thank you for buying the NOCO
Genius G4. SAVE THESE
INSTRUCTIONS. This Owner’s
Manual and User Guide
contains important safety and
operating instructions for model
G4.
WHAT’S IN THE BOX:
• G4 Charger
• (2) Battery Clamp Connectors
• (2) Eyelet Terminal Connectors
• (4) 10’ Extension Cables
• Owner’s Manual & User Guide
About Our Products
NOCO Genius is a brand
of Wicked Smart Battery
Chargers developed by The
NOCO Company.
THE NOCO COMPANY
30339 Diamond Parkway, #102
Glenwillow, OH 44139
United States of America
Hours of Operation:
Between 8AM & 5PM (EST)
Monday through Friday
SAFETY & PRECAUTIONS
PERSONAL PRECAUTIONS
BEFORE CHARGING
LOCATING BATTERY CHARGER
MOUNTING BATTERY CHARGER
USING THE G4
BATTERY SPECS
CHARGE MODES
CONNECTING TO THE BATTERY
USER INTERFACE
HOW TO START CHARGING
FEATURE OVERVIEW
CHARGING STEPS
CHARGING TIMES
MAINTENANCE
TECHNICAL SPECS
TROUBLESHOOTING
LIMITED WARRANTY
REGISTER MY BATTERY CHARGER
2
6
6
7
7
8
8
10
12
13
14
16
18
18
19
20
24
26
geniuschargers.com
SAFETY & PRECAUTIONS
IMPORTANT SAFETY INSTRUCTIONS
SAFETY & PRECAUTIONS
32
DANGER
ELECTRICAL SHOCK HAZARD
CHARGER IS AN ELECTRICAL DEVICE THAT CAN
SHOCK AND CAUSE SERIOUS INJURY.
DO NOT CUT POWER CORDS.
DO NOT SUBMERGE IN WATER OR GET CHARGER WET.
EXPLOSION HAZARD
UNMONITORED, INCOMPATIBLE, OR DAMAGED
BATTERIES CAN EXPLODE IF USED WITH CHARGER.
DO NOT LEAVE CHARGER UNATTENDED WHILE IN USE.
DO NOT ATTEMPT TO CHARGE DAMAGED OR FROZEN
BATTERIES.
USE CHARGER ONLY WITH BATTERIES OF
RECOMMENDED VOLTAGE.
OPERATE CHARGER ONLY IN WELL-VENTILATED
AREAS.
WARNING
FIRE HAZARD
CHARGER IS AN ELECTRICAL DEVICE THAT EMITS
HEAT AND CAN BURN.
DO NOT COVER CHARGER.
DO NOT SMOKE OR USE ANY OTHER SOURCE OF
ELECTRICAL SPARK OR FIRE WHEN OPERATING
CHARGER.
KEEP CHARGER AWAY FROM COMBUSTIBLE
MATERIALS.
WARNING
EYE INJURY HAZARD
BATTERIES CAN EXPLODE AND
CAUSE FLYING DEBRIS.
BATTERY ACID CAN CAUSE EYE
IRRITATION.
WEAR EYE PROTECTION WHEN
OPERATING CHARGER.
AVOID CONTACT WITH EYES
AND WASH HANDS AFTER USING
CHARGER.
IN CASE OF EYE CONTACT, FLUSH
AFFECTED AREA WITH PLENTY OF
WATER.
WARNING
RISK OF EXPLOSIVE GASES
WORKING IN VICINITY OF A LEAD-ACID BATTERY IS
DANGEROUS. BATTERIES GENERATE EXPLOSIVE
GASES DURING NORMAL BATTERY OPERATION. FOR
THIS REASON, IT IS OF UTMOST IMPORTANCE THAT
YOU FOLLOW THE INSTRUCTIONS EACH TIME YOU
USE THE CHARGER.
To reduce risk of battery explosion, follow these
instructions and those published by battery
manufacturer and manufacturer of any equipment
intended to be used in vicinity of battery. Review
cautionary markings on these products and on engine.
BATTERY POSTS, TERMINALS, AND RELATED ACCESSORIES CONTAIN
CHEMICALS, INCLUDING LEAD, KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
ALWAYS WASH YOUR HANDS AFTER HANDLING THESE PRODUCTS.
geniuschargers.com
SAFETY & PRECAUTIONSSAFETY & PRECAUTIONS
54
CAUTION
Do not expose charger to rain or snow.
Use of an attachment not recommended or sold by the battery
charger manufacturer may result in a risk of re, electric shock, or
injury to persons.
To reduce risk of damage to electric plug and cord, pull by plug
rather than cord when disconnecting charger.
Do not operate charger with damaged cord or plug – replace the
cord or plug immediately.
Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way; take it to a qualied
serviceman.
Do not disassemble charger; take it to a qualied serviceman
when service or repair is required. Incorrect reassembly may
result in a risk of electric shock or re.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning. Turning off
controls will not reduce this risk.
DO NOT USE EXTENSION CORDS unless absolutely necessary. Using
an improper extension cord could result in a risk of re and electric
shock and may result in property damage, personal injury or death. If
extension cord must be used, make sure that:
1.) The pins on the extension cord plug have the same number, size,
and shape as those of the AC power cord plug on the charger.
2.) The extension cord is properly wired and is in good electrical
condition.
3.) The wire size is as specied in Table I below:
TABLE 1:
RECOMMENDED MINIMUM AWG SIZE FOR
EXTENSION CORDS FOR BATTERY CHARGERS
AC INPUT RATING,
AMPERES*
Equal To Or
Greater Than
0
2
3
4
5
6
8
10
12
14
16
18
*If the input rating of a charger is given in watts rather than amperes, the corresponding ampere
rating is to be determined by dividing the wattage rating by the voltage rating - for example:
But Less
Than
2
3
4
5
6
8
10
12
14
16
18
20
25
(7.6)
18
18
18
18
18
18
18
16
16
16
14
14
1250 watts/125 volts = 10 amperes
AWG SIZE OF CORD
Length Of Cord, Feet (m)
50
(15.2)
18
18
18
18
16
16
14
14
12
12
12
12
100
(30.5)
18
16
16
14
14
12
12
10
10
10
8
8
150
(45.6)
16
14
14
12
12
10
10
8
8
8
8
6
geniuschargers.com
SAFETY & PRECAUTIONS
SAFETY & PRECAUTIONS
76
PERSONAL PRECAUTIONS
USE THE FOLLOWING PRECAUTIONS WHEN YOU WORK
NEAR LEAD-ACID BATTERIES:
• Someone should be within range of your voice or close enough to come to
your aid if you have an accident.
• Have plenty of fresh water and soap nearby in case battery acid contacts
skin, clothing, or eyes.
• Wear complete eye protection and protective clothing. Avoid touching your
eyes while working near a battery. If battery acid contacts your skin or clothing,
wash immediately with soap and water. If acid enters an eye, immediately ood
the eye with running cold water for at least ten (10) minutes and seek medical
attention as soon as possible.
• Be extra cautious when handling metal tools around a battery. If you drop
a metal tool near a battery it might spark or create a short circuit between
the battery terminals and some other metal part. Either event may cause a
dangerous electrical shock hazard, a re, or even an explosion, resulting in
property damage, personal injury, or death.
• Never smoke or allow an open spark or ame in the vicinity of the battery or
engine.
• Remove all personal items made of metal, such as, rings, bracelets,
necklaces, and watches when working with a lead-acid battery. A lead-acid
battery can produce a short-circuited current high enough to weld a metal ring
or other piece of jewelry, causing a severe burn.
• This battery charger is for charging LEAD-ACID BATTERIES ONLY. DO
NOT USE THE BATTERY CHARGER FOR DRY-CELL BATTERIES THAT
ARE COMMONLY USED WITH HOME APPLIANCES. THESE TYPES
OF BATTERIES MAY BURST AND MAY CAUSE PROPERTY DAMAGE,
PERSONAL INJURY OR DEATH.
•NEVER charge a frozen battery.
BEFORE CHARGING
• To avoid an electric arc (or spark), turn off or disconnect all of the accessories
in the vehicle. Always remove the cable that is connected to grounded terminal
from battery rst.
• Make sure the area around the battery is well-ventilated while the battery is
being charged. If necessary, use a non-metallic material to blow away the gas
in the area.
• If necessary, clean the battery terminals. Be careful to keep the corrosion and
other debris from coming in contact with your skin or eyes.
• If the battery is not a sealed battery, add distilled water to each cell (if
necessary) until the battery acid solution reaches the level specied by battery
manufacturer. Do not overll. For a battery without cell caps, such as a valve
regulated lead-acid battery (VRLA), carefully follow the battery manufacturer’s
charging instructions.
• Before charging, carefully read the battery manufacturer’s specic
precautions and recommended rates of charge.
• Determine the voltage of the battery by referring to the vehicle’s owner’s
manual and make sure that the charge mode is set at the correct voltage.
• Connect and disconnect the DC output cables only after the battery charger is
placed in the STANDBY mode and the AC cord is removed from the electrical
outlet. Never allow the battery clamp or eyelet terminal connectors to touch
each other.
LOCATING BATTERY CHARGER
• Locate the battery charger as far away from the battery as possible.
• Never place the battery charger directly above the battery; gases from battery
will corrode and damage battery charger.
• When reading electrolyte specic gravity or ling battery, never allow battery
acid to come in contact with the battery charger.
• Do not operate the battery charger in a closed-in area or an area with
restricted ventilation.
• Do not set a battery on top of battery charger.
MOUNTING BATTERY CHARGER
The G4 has four (4) external mounting holes in the casing of the battery
charger enclosure. These external mounting holes can be used to mount the
battery charger permanently in a desired location for battery charging. When
mounting the battery charger to a xed location, keep in mind the distance to
the battery from the battery charger. The G4 comes with an integrated AC cord
management system that allows you to route the AC cord out of any side of
the charger and store excess cord under the charger for convenience and for
professional installations.
geniuschargers.com
Loading...