Mitsubishi Electronics MXZ-32SV User Manual

SPLIT-TYPE, HEAT PUMP AIR CONDITIONER

SERVICE MANUAL

Inverter-controlled multi system Model

Revision:

• MXZ-32SV - has been added.

• Please void OB254.

E2

No. OB254

REVISED EDITION-A

MXZ-32SV MXZ-32SV -

E1

E2

CONTENTS

1. TECHNICAL CHANGES ····································2

2. PART NAMES AND FUNCTIONS······················2

3. INDOOR/OUTDOOR CORRESPONDENCE TABLE ···························3

4. INDOOR UNITS COMBINATION ·······················4

5. SPECIFICATION·················································8

6. NOISE CRITERIA CURVES······························ 9

7. OUTLINES AND DIMENSIONS······················ 10

Model indication

This manual describes technical data of outdoor unit. For indoor unit refer to the service manuals No. OB229, OB227 REVISED EDITION-B, OB252, OB212, OB239 and OC165 of corresponding models.

8. WIRING DIAGRAM···········································11

9. REFRIGERANT SYSTEM DIAGRAM··············12

10. PERFORMANCE CURVES······························13

11. MICROPROCESSOR CONTROL·····················19

12. TROUBLESHOOTING ······································25

13. DISASSEMBLY INSTRUCTIONS·····················37

14. PARTS LIST······················································40

15. OPTIONAL PARTS ···········································43

1

TECHNICAL CHANGES

MXZ-32RV - ➔ MXZ-32SV -

1. The combination pattern of the indoor unit has increased.

2. Crankcase heater has disused.

3. Refrigerant circuit has changed.

• Disuse of 2-way valve.

• Disuse of capillary tube [3 o [2 o 500.

• Disuse of low pressure switch.

• Disuse of suction pipe temperature thermistor.

MXZ-32SV - ➔ MXZ-32SV -

1. Combinations of the connectable indoor units have increased.

2. Noise filter P.C. board has changed to improve the capacity for protecting the inverter-controlled circuit when the voltage higher than the rated one is aupplied with the inverter-controlled circuit.

3. Noise filter P.C. board for “E1” and “E2” are not interchangeable.

4. Service parts have been changed as follows according to above change;

•The value of R(resistor)has changed. 10Ω ➔ 20Ω

•TB6(terminal block) has been removed.

E1E1

E2E1

2

PART NAMES AND FUNCTIONS

OUTDOOR UNIT

MXZ-32SVMXZ-32SV-

E1 E2

Air outlet

Air inlet

Model indication

(back and side)

2

3

❈There is no combination other than this table.

MXZ-32SV- E1 , MXZ-32SV- E2

OUTDOOR UNIT

Combination of the connectable indoor units

07+07 07+09 07+12 07+18 09+09 09+12 09+18 12+12 12+18

18+18 07+07+07 07+07+09 07+07+12 07+07+18 07+09+09 07+09+12 07+09+18 07+12+12 07+12+18 07+18+18 09+09+09 09+09+12 09+09+18 09+12+12 09+12+18 09+18+18 12+12+12 12+12+18

07+07+07+07 07+07+07+09 07+07+07+12 07+07+07+18 07+07+09+09 07+07+09+12 07+07+09+18 07+07+12+12 07+07+12+18 07+09+09+09 07+09+09+12 07+09+09+18 07+09+12+12 09+09+09+09 09+09+09+12 09+09+09+18 09+09+12+12

NOTE: SLH-1AR is equivalent to class 09 (9000BTU).

INDOOR / OUTDOOR CORRESPONDENCE TABLE

MCFH-13NV, SEH-1.6AR, SLH-1.6AR is equivalent to class 12 (12000BTU). MCFH-18NV, SEH-2AR,SLH-2AR is equivalent to class 18 (18000BTU).

3

07

09

12

18

07+07

07+09

07+12

07+18

09+09

09+12

09+18

12+12

12+18

18+18

07+07+07

07+07+09

07+07+12

07+07+18

07+09+09

07+09+12

07+09+18

07+12+12

07+12+18

07+18+18

90

3.47

4.17

6.67

10.65

7.13

7.50

10.56

14.31

8.80

12.64

17.31

18.33

10.19

11.25

13.80

12.96

13.80

3.79

4.55

7.27

11.62

7.78

8.18

11.52

15.61

9.60

13.79

18.89

20.00

11.11

12.27

15.05

14.14

15.05

2.2

(0.9-2.7)

2.8

(0.9-3.2)

4.0

(0.9-4.5)

5.0

(0.9-5.4)

4.4

(1.8-5.4)

5.0

(1.8-5.8)

6.2

(1.8-6.6)

7.2

(1.8-7.7)

5.6

(1.8-6.2)

6.8

(1.8-7.3)

7.8

(1.8-8.5)

8.0

(1.8-8.8)

8.0

(1.8-8.8)

8.0

(1.8-8.8)

6.6

(2.4-8.1)

7.2

(2.4-8.6)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

7.8

(2.4-8.9)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

0.75

(0.26-0.93)

0.90

(0.26-1.04)

1.44

(0.26-1.70)

2.30

(0.26-2.98)

1.54

(0.58-1.96)

1.62

(0.58-2.05)

2.28

(0.58-2.51)

3.09

(0.58-3.65)

1.90

(0.58-2.18)

2.73

(0.58-3.22)

3.74

(0.58-4.56)

3.96

(0.58-4.90)

3.96

(0.58-4.90)

3.96

(0.58-4.90)

2.20

(0.70-3.65)

2.43

(0.70-4.11)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.80

(0.70-4.23)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

-

2.2

2.8

3.8

4.2

2.8

3.6

4.0

3.1

3.6

3.25

-

2.2

2.8

4.0

5.0

2.8

4.0

5.0

4.0

4.5

4.0

2.2

2.1

1.9

2.8

2.5

2.3

3.1

2.8

3.25

2.2

2.8

4.0

5.0

2.2

2.8

4.0

3.5

4.0

2.2

2.1

1.9

2.2

1.9

1.7

1.8

1.6

1.5

Indoor units combination

Unit A Unit B Unit C Unit D

Cooling capacity (kW)

Total

Outdoor unit

power consumption

(kW)

Current

(A)

Power

factor

(%)

220V 240V

NOTE: Electrical data is for outdoor unit only.

MXZ-32SV -

E1 ,

MXZ-32SV -

E2

4

INDOOR UNITS COMBINATION

NOTE: SLH-1AR is equivalent to class 09 (9000BTU).

MCFH-13NV, SEH-1.6AR, SLH-1.6AR is equivalent to class 12 (12000BTU). MCFH-18NV, SEH-2AR,SLH-2AR is equivalent to class 18 (18000BTU).

4

Indoor units combination

09+09+09

09+09+12

09+09+18

09+12+12

09+12+18

09+18+18

12+12+12

12+12+18

07+07+07+07

07+07+07+09

07+07+07+12

07+07+07+18

07+07+09+09

07+07+09+12

07+07+09+18

07+07+12+12

07+07+12+18

07+09+09+09

07+09+09+12

07+09+09+18

07+09+12+12

09+09+09+09

09+09+09+12

09+09+09+18

09+09+12+12

NOTE: SLH-1AR is equivalent to class 09 (9000BTU).

MCFH-13NV, SEH-1.6AR, SLH-1.6AR is equivalent to class 12 (12000BTU). MCFH-18NV, SEH-2AR,SLH-2AR is equivalent to class 18 (18000BTU).

Unit A Unit B Unit C Unit D

2.67

2.3

2.1

2.0

1.9

1.8

2.67

2.45

2.0

1.87

1.7

1.5

1.8

1.6

1.5

1.4

1.3

1.7

1.5

1.4

1.35

2.0

1.8

1.67

1.65

2.67

2.45

1.87

1.75

1.67

1.65

Cooling capacity (kW)

2.67

2.3

2.1

3.0

2.7

3.1

2.0

1.7

1.5

1.8

1.6

1.5

1.4

1.3

2.1

1.9

2.0

1.8

3.4

3.8

3.0

3.4

3.1

2.67

3.1

2.0

1.87

1.7

1.5

2.2

2.0

1.8

2.6

2.4

2.1

1.9

1.75

2.45

2.0

1.8

1.67

2.35

-

2.0

2.4

2.9

3.5

2.2

2.8

3.2

2.6

3.0

2.1

2.7

3.1

2.45

2.0

2.6

3.0

2.35

Total

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.4-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

8.0

(2.8-9.0)

NOTE: Electrical data is for outdoor unit only.

Outdoor unit

power consumption

(kW)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.70-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

2.98

(0.80-4.27)

Current

(A)

220V 240V

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.80

15.05

13.08

15.05

13.08

15.05

13.08

15.05

Power

factor

(%)

90

5

NOTE: Electrical data is for outdoor unit only.

07

09

12

18

07+07

07+09

07+12

07+18

09+09

09+12

09+18

12+12

12+18

18+18

07+07+07

07+07+09

07+07+12

07+07+18

07+09+09

07+09+12

07+09+18

07+12+12

07+12+18

07+18+18

90

5.23

6.11

8.84

10.65

8.94

9.49

11.81

12.41

10.88

12.13

12.87

11.20

11.57

12.87

5.71

6.67

9.65

11.62

9.75

10.35

12.88

13.54

11.87

13.23

14.04

12.22

12.63

14.04

3.2

(0.9-4.1)

4.0

(0.9-4.8)

6.0

(0.9-7.2)

7.1

(0.9-7.8)

6.4

(1.8-7.2)

7.2

(1.8-8.7)

8.6

(1.8-10.6)

9.0

(1.8-10.9)

8.0

(1.8-10.1)

8.8

(1.8-10.8)

9.3

(1.8-11.2)

9.3

(1.8-11.2)

9.3

(1.8-11.2)

9.3

(1.8-11.2)

8.6

(2.1-10.6)

9.0

(2.1-11.1)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

1.13

(0.27-1.60)

1.32

(0.27-1.70)

1.91

(0.27-2.57)

2.30

(0.27-2.83)

1.93

(0.48-2.30)

2.05

(0.48-2.68)

2.55

(0.48-3.80)

2.68

(0.48-3.89)

2.35

(0.48-3.56)

2.62

(0.48-3.86)

2.78

(0.48-3.98)

2.78

(0.48-3.98)

2.78

(0.48-3.98)

2.78

(0.48-3.98)

2.42

(0.52-3.00)

2.50

(0.52-3.30)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

-

2.87

3.5

4.5

4.9

3.3

4.25

4.6

3.65

4.05

3.8

-

3.2

4.0

5.4

6.2

4.0

5.3

5.95

4.65

5.0

4.65

2.87

2.75

2.4

2.2

3.3

2.8

2.6

3.65

3.4

3.8

3.2

4.0

6.0

7.1

3.2

2.8

4.0

3.5

3.35

4.65

4.3

4.65

2.87

2.75

2.4

2.2

2.7

2.25

2.1

2.0

1.85

1.7

Indoor units combination

Unit A Unit B Unit C Unit D

Heating capacity (kW)

Total

Outdoor unit

power consumption

(kW)

Current

(A)

Power

factor

(%)

220V 240V

NOTE: SLH-1AR is equivalent to class 09 (9000BTU).

MCFH-13NV, SEH-1.6AR, SLH-1.6AR is equivalent to class 12 (12000BTU). MCFH-18NV, SEH-2AR,SLH-2AR is equivalent to class 18 (18000BTU).

6

Indoor units combination

09+09+09

09+09+12

09+09+18

09+12+12

09+12+18

09+18+18

12+12+12

12+12+18

07+07+07+07

07+07+07+09

07+07+07+12

07+07+07+18

07+07+09+09

07+07+09+12

07+07+09+18

07+07+12+12

07+07+12+18

07+09+09+09

07+09+09+12

07+09+09+18

07+09+12+12

09+09+09+09

09+09+09+12

09+09+09+18

09+09+12+12

Heating capacity (kW)

Unit A Unit B Unit C Unit D

3.1

2.65

2.45

2.3

2.2

2.0

3.1

2.9

2.32

2.2

1.9

1.8

2.1

1.8

1.7

1.6

1.95

1.75

1.65

1.55

2.32

2.05

1.95

1.85

3.1

2.65

2.45

3.5

3.3

3.65

3.1

2.9

2.32

2.2

1.9

1.8

2.1

1.8

1.7

1.6

2.45

2.15

2.0

1.95

2.32

2.05

1.95

1.85

3.1

4.0

4.4

3.5

3.8

3.65

3.1

3.5

2.32

2.2

1.9

1.8

2.55

2.3

2.15

3.05

2.8

2.45

2.15

2.0

2.9

2.32

2.05

1.95

2.8

-

2.32

2.7

3.6

3.9

2.55

3.4

3.75

3.05

3.3

2.45

3.25

3.65

2.9

2.32

3.15

3.45

2.8

Total

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.1-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

9.3

(2.8-11.6)

NOTE: Electrical data is for outdoor unit only.

Outdoor unit

power consumption

(kW)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.52-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

2.78

(0.60-3.50)

Current

(A)

220V 240V

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

12.87

14.04

Power

factor

(%)

90

NOTE: SLH-1AR is equivalent to class 09 (9000BTU).

MCFH-13NV, SEH-1.6AR, SLH-1.6AR is equivalent to class 12 (12000BTU). MCFH-18NV, SEH-2AR,SLH-2AR is equivalent to class 18 (18000BTU).

7

5

Outdoor model

Indoor units number Indoor units total capacity (Connectable) indoor units total capacity (Simultaneous operation) Piping total length Connecting pipe length Height difference (Indoor ~ Outdoor) Height difference (Indoor ~ Indoor) Function Capacity Dehumidification Outdoor air flow Power outlet Running current Power input Auxiliary heater Crankcase heater Power factor Starting current Compressor motor current Fan motor current

Model Output Winding resistance(at20:) Model Winding resistance(at20:) Dimensions WOHOD Weight Sound level (Hi) Fan speed (Hi) Fan speed regulator Refrigerant filling capacity(R-22) Refrigerating oil (Model) Thermistor RT61 Thermistor RT62 Thermistor RT63 Thermistor RT65 Thermistor RT66,67 Thermistor RT68,69

kW

R/h

K /h

A A

W

A(kW)

W %

A A A

W

"

  

"



mm

kg

dB

rpm

kg

cc k" k" k" k" k" k"



Compressor

Electrical

data

Fan

motor

Special

remarks

Capacity System

Coefficient of performance(C.O.P)

Outdoor unit power supply

MXZ-32SV -

E1

,

MXZ-32SV - E2

Single phase

220-240V,50Hz

2 to 4 Total model name 42 Total model name 42

Max. 60 Max. 25

10 10

2400-2640

25

— —

90.0

15.05-13.80

0.6

THV-247FBA (ROTARY)

2100

U-V 0.61

V-W 0.61 W-U 0.61

RA6V60-BA

WHT-BLK 78.7 BLK-YLW 26.9

YLW-BLU 11.7 BLU-RED 83.6

900o900o320 (+35)

79

630-675

3

3.9

870 (MS-56)

13.4 (at 100:)

10.0 (at 25:)

17.0 (at 50:)

10.0 (at 25:)

Cooling

8.0 (0.9~9.0) —

15.05-13.80

2980(260~4270)

15.71-14.35

2.68

45-47

Heating

9.3 (0.9~11.6) —

14.04-12.87

2780(270~3500)

13.44-12.27

3.35

46-48

✽1 Electrical data is for only outdoor unit.

TEST CONDITIONS COOLING INDOOR DB27.0°C WB19.0°C

SPECIFICATION

HEATING INDOOR DB20.0°C

OUTDOOR DB35.0°C WB24.0°C OUTDOOR DB 7.0°C WB 6.0°C

8

NOISE CRITERIA CURVES6

90

80

70

60

50

40

30

20

10

63 125 250 500 1000 2000 4000 8000

APPROXIMATE TERESHOLD OF HEARING FOR CONTINUOUS NOISE

NC-60

NC-50

NC-40

NC-30

NC-20

NC-70

OCTAVE BAND SOUND PRESSURE LEVEL, 0dB = 0.0002 MICRO BAR

BAND CENTER FREQUENCIES, Hz

Test conditions.

Cooling :DB35: WB24: Heating :DB 7: WB 6:

COOL(220V)

NOTCH

COOL(240V)

HEAT(220V) HEAT(240V)

45

SPL(dB(A))

47 46

48

LINE

MXZ-32SV -

E1

MXZ-32SV - E2

9

7

OUTLINES AND DIMENSIONS

OUTDOOR UNIT

MXZ-32SV MXZ-32SV -

Handle for moving

E1 E2

Less than

25

Veranda

Base bollt length

Base

Rubber cushion

Air in

10 35320

23

Unit: mm

2-U-shape notched holes

200 200

Air in

460

33

317

500

Air in

Air out

2-12 ✕ 36 Oval hole

(Base bolt M10)

900

(Base bolt M10)

(16) (16)

27 40

355

Indoor and outdoor connect wiring 23✕45 hole

50

350.0

480.8

531.3

23

387

[

9.52 (flared) 3/8 (C , D unit)

12.7 (flared) 1/2 (A , B unit)

[

88

900

D unit connection C unit connection

B unit connection A unit connection

Liquid pipe

[

6.35 (flared) 1/4

1.Installation space

Note : Leave front and both sides clearance fully.

Note : Leave front and overhead clearance fully.

Note : Leave front, overhead and both clearance fully.

More than

100

More than

500

More than 100

More than

200

More than 350

More than

500

Note : Obsacle on front and rear sid only.

The unit can be used by attaching an optional outdoor outlet guide (MAC-855SG) (but both sides and the top are opend.)

2.Service space

More than

100

More than

350

More than

100

More than 350

Service space

More than

500

10

8

POWER SUPPLY ~/N 220-240V 50Hz

INDOOR UNIT (A)

CIRCUIT BRAKER

TB2

TB3

BLU RED

TB4

X64

GRN/YLW

GRN

CN720

CN601

0

4

X64

LD62

CN913

CN791

CN901

64

2

CN902

CN851 CN852

MF61

21S4

12

21

12

34

123456

12 34567

123456

C65

LD63

LD64

LDB

LD61

LDE

L61

F911

SSR61

X63

X62

X61

1

6

L N

3

N

INDOOR UNIT (B)

BLU ORN

CN602

12

3

N

INDOOR UNIT (C)

BLU YLW

CN603

12

N

INDOOR UNIT (D)

BLU BRN

CN604

12

N

BLK

BRN

GRY

BLK

WHT

YLW

RED

BRN

BLU

ORN

YLW

WHT

ORN

WHT

BLK

BLU

YLW

RED

ORN

RED

YLW

BLK

ORN ORN

BRN GRY

X65

X66

X67

63H2

CN552

CN553

BLK

RELAY

P.C. BOARD

WHT

RED

WHT

V

UW

A

K

L

WHT

NOISE FILTER P.C.BOARD

RED

DS61

DS62

C61

CT 61

C63 C62

+

-

+-+

-

BLKREDR

BLU

LEV A

CN792

123456

RED

BRN

BLU

ORN

YLW

WHT

LEV B

CN793

123456

RED

BRN

BLU

ORN

YLW

WHT

LEV C

CN794 CN722 CN663

63H1 RT63

123456

CN662

1234567812 1234

RED

BLK

RT66 RT68

RT67 RT69

GRY

CN661

CN705

7654321

CN515

1234

4321

CN801

CN501

TAB62

TAB63

T801

CT62

TAB66

TAB65

TAB64

I.P.M P.C. BOARD

F801

(1A)

CN704

CN514

CN554CN551

12345678

RT62

RT61

RT65

GRY

BLK

GRY

BRN

BLU

ORN

YLW

WHT

LEV D

ELECTRONIC CONTROL P.C. BOARD

MC

PE

(1A)

FROM INDOOR UNIT

CONNECTING 12V

SYMBOL

C61

C62,63

C65

CT61,62

DS61 DS62

F801 F911

L

L61

SYMBOL

LEV A~D

MC

MF61

R RT61 RT62 RT63 RT65

RT66,67 RT68,69

NAME POWER FACTOR CAPACITOR SMOOTHING CAPACITOR OUTDOOR FAN CAPACITOR CURRENT TRANSFORMER DIODE MODULE DIODE STACK FUSE (1A) FUSE (1A) REACTOR COMMON MODE CHOKE COIL

NAME EXPANSION VALVE COMPRESSOR OUTDOOR FAN MOTOR (INNER FUSE) RESISTOR DISCHARGE TEMPERATURE THERMISTOR DEFROST TEMPERATURE THERMISTOR EVAPORATION TEMPERATURE THERMISTOR FIN TEMPERATURE THERMISTOR GAS PIPE TEMPERATURE THERMISTOR GAS PIPE TEMPERATURE THERMISTOR

SYMBOL

SSR61

T801

TB2,3,4

X61,62,63

X64,65 X66,67

21S4 63H1 63H2

NAME SOLENOID COIL RELAY TRANSFORMER TERMINAL BLOCK FAN MOTOR RELAY RELAY RELAY R.V. COIL HIGH PRESSURE SWITCH HIGH PRESSURE SWITCH

NOTE: 1. About the indoor side electric wiring refer to the indoor unit electric wiring diagram for servicing.

2.Use copper conductors only. (For field wiring)

3.Symboles below indicate. : Terminal block : Connector

POWER SUPPLY ~/N 220-240V 50Hz

INDOOR UNIT (A)

CIRCUIT BRAKER

TB1

TB2

BLU RED

X64

GRN/YLW

GRN

CN720

CN601

0

4

X64

LD62

CN913

CN791

CN901

64

2

CN902

CN851 CN852

MF61

21S4

12

21

12

34

123456

12 34567

123456

C65

LD63

LD64

LDB

LD61

LDE

L61

F911

SSR61

X63

X62

X61

1

6

L N

3

N

INDOOR UNIT (B)

BLU ORN

CN602

12

3

N

INDOOR UNIT (C)

BLU YLW

CN603

12

N

INDOOR UNIT (D)

BLU BRN

CN604

12

N

BLK

BRN

GRY

BLK

WHT

YLW

RED

BRN

BLU

ORN

YLW

WHT

ORN

WHT

BLK

BLU

YLW

RED

ORN

RED

YLW

BLK

ORN ORN

BRN GRY

X65

X66

X67

63H2

CN552

CN553

BLK

RELAY

P.C. BOARD

WHT

RED

WHT

V

UW

A

K

L

WHT

NOISE FILTER P.C.BOARD

RED

DS61

DS62

C61

CT

61

C63 C62

+

-

+-+

-

BLK

RED

R

BLU

LEV A

CN792

123456

RED

BRN

BLU

ORN

YLW

WHT

LEV B

CN793

123456

RED

BRN

BLU

ORN

YLW

WHT

LEV C

CN794 CN722 CN663

63H1 RT63

123456

CN662

1234567812 1234

RED

BLK

RT66 RT68

RT67 RT69

GRY

CN661

CN705

7654321

CN515

1234

4321

CN801

CN501

TAB62

TAB63

T801

CT62

TAB66

TAB65

TAB64

I.P.M P.C. BOARD

F801

(1A)

CN704

CN514

CN554CN551

12345678

RT62

RT61

RT65

GRY

BLK

GRY

BRN

BLU

ORN

YLW

WHT

LEV D

ELECTRONIC CONTROL P.C. BOARD

MC

PE

(1A)

FROM INDOOR UNIT

CONNECTING 12V

SYMBOL

C61

C62,63

C65

CT61,62

DS61 DS62 F801

F911

L

L61

LEV A~D

SYMBOL

MC

MF61

R RT61 RT62 RT63 RT65

RT66,67 RT68,69

SSR61

T801

NAME POWER FACTOR CAPACITOR SMOOTHING CAPACITOR OUTDOOR FAN CAPACITOR CURRENT TRANSFORMER DIODE MODULE DIODE STACK FUSE (1A) FUSE (1A) REACTOR COMMON MODE CHOKE COIL EXPANSION VALVE

NAME COMPRESSOR OUTDOOR FAN MOTOR (INNER FUSE) RESISTOR DISCHARGE TEMPERATURE THERMISTOR DEFROST TEMPERATURE THERMISTOR EVAPORATION TEMPERATURE THERMISTOR FIN TEMPERATURE THERMISTOR GAS PIPE TEMPERATURE THERMISTOR GAS PIPE TEMPERATURE THERMISTOR SOLENOID COIL RELAY TRANSFORMER

SYMBOL

TB1,2,3,4,5

X61,62,63

X64,65 X66,67

21S4 63H1 63H2

F912 NR63

NAME TERMINAL BLOCK FAN MOTOR RELAY RELAY RELAY R.V. COIL HIGH PRESSURE SWITCH HIGH PRESSURE SWITCH FUSE(3.15A) VARISTOR

NOTE: 1. About the indoor side electric wiring refer to the indoor unit electric wiring diagram for servicing.

2.Use copper conductors only. (For field wiring)

3.Symboles below indicate. : Terminal block : Connector

TB3

TB4

TB5

(3.15A)

N

LD65

F912

NR63

SG79Y085H01

WIRING DIAGRAM

OUTDOOR UNIT

MODELS MXZ-32SV-

E1

E2

11

9

a

b

c

d

Outdoor unit

Indoor units

H

Indoor unit

D

Ball valve with

service port

Ball valve with

service port

Distributor

Strainer

LEV

Oil

separator

Compressor

High pressure switch 1

Accumulator

Capillary tube

Reversing valve

Discharge temperature thermistor

Evaporation temperature thermistor (RT67)

Defrost thermistor

Strainer

Distributor

Outdoor heat exchanger

High pressure switch 2

Unit D gas pipe temperature thermistor

[9.52

Indoor unit

C

Unit C gas pipe temperature thermistor

[9.52

[6

Indoor unit

B

Unit B gas pipe temperature thermistor

[12

Indoor unit

A

Indoor unit

A

Strainer

LEV

[6

Indoor unit

B

Strainer

LEV

[6

Indoor unit

C

Strainer

LEV

[6

Indoor unit

D

Unit A gas pipe temperature thermistor

[12

[16

[9.52

[16

Capillary tube

[2.5✕[0.6✕ 750

[2.5✕ [0.6✕1000

Capillary tube

[4.0✕[2.4✕ 400

Capillary tube

[3.0✕[2.0✕ 200

Refrigerant flow in cooling Refrigerant flow in heating

Reversing valve coil heating ON cooling OFF

REFRIGERANT SYSTEM DIAGRAM

MXZ-32SV MXZ-32SV -

E1 E2

Unit:mm

Piping length each indoor unit (a, b, c, d) 25m Total piping length (a+b+c+d) 60m Height difference between units (H) 10m Bending point for each unit 25 Total bending point 60

❋It does not matter which unit is higher.

● Refrigerant pipe diameter is different according to indoor unit to be connected. When using extension pipes,refer to the

● When diameter of refrigerant pipe is different from that of outdoor unit union, use optional Different-diameter pipe.

tables below.

For further information on Different-diameter pipe,see page BACK COVER.

Indoor unit

class Pipe diameter

07/09

12(13)

18

Liquid 6.35(1/4) Liquid 6.35(1/4)

Gas 9.52(3/8) Gas 9.52(3/8)

Liquid 6.35(1/4) Liquid 6.35(1/4)

Gas 12.7(1/2) Gas 12.7(1/2)

Liquid 6.35(1/4) Liquid 6.35(1/4)

Gas 15.88(5/8) Gas 15.88(5/8)

Extension pipe diameter

12

Outdoor unit union diameter

For

Indoor unit A

Indoor unit B

Indoor unit C

Indoor unit D

Liquid 6.35(1/4)

Gas 12.7(1/2)

Liquid 6.35(1/4)

Gas 12.7(1/2)

Liquid 6.35(1/4)

Gas 9.52(3/8)

Liquid 6.35(1/4)

Gas 9.52(3/8)

Unit : mm (inch)

10

Wet-and dry-bulb thermometers

07 class

7.5

7.0

6.4

5.9

5.3

4.8

8.7

8.1

7.4

6.8

6.2

5.6

10.8

10.1

9.3

8.5

7.7

7.0

6.7

6.2

5.8

5.3

4.8

4.3

18 class

12 class

09 class

32.3

29.8

27.3

24.9

22.4

19.9

17.4

14.9

38.2

35.3

32.4

29.4

26.5

23.5

20.6

17.6

25.9

23.9

21.9

19.9

17.9

15.9

13.9

11.9

27.7

25.6

23.4

21.3

19.2

17.0

14.9

12.8

07 class

09 class

12 class

18 class

PERFORMANCE CURVES

The standard data contained in these specifications apply only to the operation of the air conditioner under normal conditions, since operating conditions vary according to the areas where these units are installed. The following information has been provided to clarify the operating characteristics of the air conditioner under the conditions indicated by the performance curve.

(1) GUARANTEED VOLTAGE

198 ~ 264V

(2) AIR FLOW

Air flow should be set at MAX.

(3) MAIN READINGS

(1) Indoor intake air wet-bulb temperature : °CWB (2) Indoor outlet air wet-bulb temperature : °CWB (3) Outdoor intake air dry-bulb temperature : °CDB

}

Cooling

(4) Total input: W (5) Indoor intake air dry-bulb temperature : °CDB (6) Outdoor intake air wet-bulb temperature : °CWB (7) Total input : W

}

Heating

Indoor air wet/dry-bulb temperature difference on the left side of the chart on page 14 and 15 shows the difference between the indoor intake air wet/dry-bulb temperature and the indoor outlet air wet/dry-bulb temperature for your reference at service.

How to measure the indoor air wet-bulb/dry-bulb temperature difference

1. Attach at least 2 sets of wet-and dry-bulb thermometers to the indoor air intake as shown in the figure, and at least 2 sets of wet-and dry-bulb thermometers to the indoor air outlet. The thermometers must be attached to the position where air speed is high.

2. Attach at least 2 sets of wet-and dry-bulb thermometers to the outdoor air intake. Cover the thermometers to prevent direct rays of the sun.

3. Check that the air filter is cleaned.

4. Open windows and doors of room.

5. Press the EMERGENCY OPERATION switch once(twice) to start the EMERGENCY COOL(HEAT) MODE.

6. When system stabilizes after more than 15 minutes, measure temperature and take an average temperature.

7. 10 minutes later, measure temperature again and check that the temperature does not change.

INDOOR UNIT OUTDOOR UNIT

10-1-1.CAPACITY AND THE INPUT CURVES

13

10-3-.2.Capacity and input correction by inverter output frequency

0 50 100 150

0.5

1.0

1.5

<COOL>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

2.0

Frequency

<COOL>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<HEAT>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

Frequency

<HEAT>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<COOL>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

2.0

Frequency

<COOL>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<HEAT>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

Frequency

<HEAT>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<COOL>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

2.0

Frequency

<COOL>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<HEAT>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

Frequency

<HEAT>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<COOL>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

2.0

Frequency

<COOL>Total input

Hz

0 50 100 150

0.5

1.0

1.5

<HEAT>Capacity

Frequency

Hz

0 50 100 150

0.5

1.0

1.5

Frequency

<HEAT>Total input

Hz

1. 07-class unit in single operation

2. 09-class unit in single operation

3. 12-class unit in single operation

4. 18-class unit in single operation

(OUTDOOR UNIT:MXZ-32SV)

The dotted line on graphs connects the frequency range in normal operation shown by the full line and the frequency in test run shown by the point.

14

Mitsubishi Electronics MXZ-32SV User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual