Mitsubishi Lancer EVOLUTION IV and V Workshop Manual

WORKSHOP MANUAL

EVOLUTION-IV
EVOLUTION-V

Pub. No. S9806CNCP9

General . . . . . . . . . . . . . . . . . . . . . . . .

00

EVOLUTION-IV
EVOLUTION-V

WORKSHOP MANUAL

FOREWORD

This Workshop Manual contains procedures for
service mechanics, including removal, disassembly,
inspection, adjustment, reassembly and
installation. Figures taken from registration
documents are given in metric units only. All other
figures are given in SI units with metric units in
brackets. Use the following manuals in combination
with this manual as required.

Engine . . . . . . . . . . . . . . . . . . . . . . . . .

Engine Lubrication . . . . . . . . . . . . .

Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . .

Engine Cooling . . . . . . . . . . . . . . . . .

Intake and Exhaust . . . . . . . . . . . .

Engine Electrical . . . . . . . . . . . . . . .

Engine and Emission Control . . . .

Clutch . . . . . . . . . . . . . . . . . . . . . . . . .

Manual Transmission . . . . . . . . . . .

Front Axle . . . . . . . . . . . . . . . . . . . . . .

Rear Axle . . . . . . . . . . . . . . . . . . . . . .

Power Plant Mount . . . . . . . . . . . . . .

11
12
13
14
15
16
17
21
22
26
27
32

TECHNICAL INFORMATION MANUAL

N9806CNCP9

All information, illustrations and product
descriptions contained in this manual are current
as at the time of publication. We, however, reserve
the right to make changes at any time without prior
notice or obligation.

July 1998

Front Suspension . . . . . . . . . . . . . . .

Rear Suspension . . . . . . . . . . . . . . .

Service Brakes . . . . . . . . . . . . . . . . .

Parking Brakes . . . . . . . . . . . . . . . . .

Steering . . . . . . . . . . . . . . . . . . . . . . . .

Body . . . . . . . . . . . . . . . . . . . . . . . . . . .

Exterior . . . . . . . . . . . . . . . . . . . . . . . .

Chassis Electrical . . . . . . . . . . . . . .

Electrical Wiring . . . . . . . . . . . . . . . .

33
34
35
36
37
42
51
54

ELECTRICAL

WIRING

CONTENTS

HOW TO READ THE WIRING DIAGRAMS A. . . . . . . . . . . . . . . . . . . . . .

ELECTRICAL WIRING (EVOLUTION-IV) B. . . . . . . . . . . . . . . . . . . . . . .

ELECTRICAL WIRING (EVOLUTION-V) C. . . . . . . . . . . . . . . . . . . . . . . .

NOTES

ELECTRICAL

WIRING

(EVOLUTION-IV)

CONTENTS

B-1

WIRING HARNESS CONFIGURATION

DIAGRAMS 2. . . . . . . . . . . . . . . . . . . . . . . . .

ENGINE COMPARTMENT 2. . . . . . . . . . . . . . . .

DASH PANEL 6. . . . . . . . . . . . . . . . . . . . . . . . . . .

FLOOR, ROOF, AND SEAT 12. . . . . . . . . . . .

LUGGAGE COMPARTMENT 14. . . . . . . . . . . .

SINGLE PART INSTALLATION

POSITION 16. . . . . . . . . . . . . . . . . . . . . . . . .

RELAY 16. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ECU 17. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

SENSOR 18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

SOLENOID VALVE 20. . . . . . . . . . . . . . . . . . . . .

CHECK CONNECTOR AND SPARE

CONNECTOR 21. . . . . . . . . . . . . . . . . . . . . . . . . .

FUSIBLE LINK AND FUSE 22. . . . . . . . . . . . .

GROUND CABLE 22. . . . . . . . . . . . . . . . . . . . . .

GROUND 22. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

CIRCUIT DIAGRAM 23. . . . . . . . . . . . . . . .

CENTRALIZED JUNCTION 23. . . . . . . . . . . . .

POWER DISTRIBUTION SYSTEM 24. . . . . .

STARTING SYSTEM 29. . . . . . . . . . . . . . . . . . .

IGNITION SYSTEM 30. . . . . . . . . . . . . . . . . . . .

CHARGING SYSTEM 31. . . . . . . . . . . . . . . . . .

ENGINE CONTROL SYSTEM 32. . . . . . . . . . .

COOLING SYSTEM 38. . . . . . . . . . . . . . . . . . . .

TAIL LAMP, POSITION LAMP, LICENSE
PLATE LAMP AND LIGHTING MONITOR

ALARM BUZZER 40. . . . . . . . . . . . . . . . . . . . . .

FOG LAMP 42. . . . . . . . . . . . . . . . . . . . . . . . . . .

ROOM LAMP AND LUGGAGE

COMPARTMENT LAMP 43. . . . . . . . . . . . . . . .

TURN-SIGNAL LAMP AND

HAZARD LAMP 44. . . . . . . . . . . . . . . . . . . . . . .

STOP LAMP 47. . . . . . . . . . . . . . . . . . . . . . . . . .

BACK-UP LAMP 48. . . . . . . . . . . . . . . . . . . . . . .

HORN
<VEHICLES WITHOUT SRS AIR BAG> 49.

OIL PRESSURE WARNING LAMP 50. . . . . .

CENTRAL DOOR LOCKING SYSTEM
<VEHICLES WITH KEYLESS ENTRY

SYSTEM> 52. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

HEATER AND MANUAL

AIR CONDITIONER 56. . . . . . . . . . . . . . . . . . . .

FULLY AUTOMATIC AIR CONDITIONER 62
WINDSHIELD WIPER AND WASHER

<INTERMITTENT WIPER> 70. . . . . . . . . . . . . .

REAR WIPER AND WASHER 71. . . . . . . . . .

DEFOGGER AND DOOR MIRROR
HEATER <VEHICLES WITHOUT FULLY

AUTOMATIC AIR CONDITIONER> 72. . . . . .

DEFOGGER AND DOOR MIRROR
HEATER <VEHICLES WITH FULLY

AUTOMATIC AIR CONDITIONER> 74. . . . . .

SPARE CONNECTOR FOR RADIO 76. . . . .

RADIO <4-SPEAKER, 6-SPEAKER> 78. . . .

ANTI-LOCK BRAKE SYSTEM (ABS) 80. . . .

ACTIVE YAW CONTROL SYSTEM (AYC) 86
INTERCOOLER WATER SPRAY SYSTEM 92

B-2

WIRING HARNESS CONFIGURATION DIAGRAMS

– Engine Compartment

WIRING HARNESS CONFIGURATION DIAGRAMS

ENGINE COMPARTMENT

Connector
symbol

–01

A

thru
–50

Ground cable

A-01 (2-B) Brake fluid level switch
A-03 (1-B) Noise condenser
A-04 (1) Alternator
A-05 (4-GR) Alternator
A-09 (1-B) Starter
A-10 (1) Starter
A-12 (2-B) Fuel pressure solenoid valve
A-16 (4-B) Throttle position sensor
A-18 (6-B) Idle speed control servo
A-19 (3-B) Vehicle speed sensor

A-20 (4-B) Windshield wiper motor
A-21 (8-B) Hydraulic unit <vehicles with ABS>
A-22 (2-B) Hydraulic unit <vehicles with ABS>
A-23 (2-B) Waste gate solenoid valve
A-25 (7-B) Air flow sensor
A-26 (2-B) Front speed sensor (LH)

<vehicles with ABS>

A-28 (8-B) Control harness and front harness

combination

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Engine Compartment

B-3

A-29 (2-B) Front harness and battery harness

combination
A-33 (1) Horn (LH)
A-34 (1) Horn (LH)
A-35 (2-BR) Outside air temperature sensor <vehicles

with fully automatic air conditioner>
A-38 (2-B) Engine coolant temperature sensor

A-39 (1-B) Engine coolant temperature gauge unit
A-45 (1) Horn (RH)
A-46 (1) Horn (RH)
A-49 (2-BR) Dual pressure switch
A-50 (2-B) Front speed sensor (RH)

<vehicles with ABS>

B-4

Connector
symbol

–51

A

thru
–131

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Engine Compartment

Ground cable

A-51 (3-B) Crank angle sensor
A-52 (1-B) Oil pressure switch
A-53 (2-B) Injector (No.1)
A-54 (2-B) Injector (No.2)
A-55 (2-B) Injector (No.3)
A-56 (2-B) Injector (No.4)
A-63 (2-B) O2 sensor
A-72 (2-B) Back-up lamp switch
A-73 (1-L) Engine speed detection connector
A-74 (1-B) Fuel pump check connector
A-76 (6) Valve relay <vehicles with ABS>
A-77 (5) Motor relay <vehicles with ABS>
A-78 (2-GR) Side turn signal lamp (LH)

A-80X (5) Horn relay <vehicles with SRS air bag>
A-82X (5) Radiator fan relay (LO)
A-84X (5) Headlamp relay
A-86X (4) Alternator relay
A-88 (6-B) Control harness and battery harness

combination
A-89 (2-BR) Front turn signal lamp (LH)
A-90 (3-B) Headlamp (LH)
A-91 (2) Position lamp (LH)
A-92 (2-B) Fog lamp (LH)
A-94 (4-GR) Radiator fan motor
A-96 (2-GR) Knock sensor

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Engine Compartment

B-5

A-97 (3-B) Camshaft position sensor
A-99 (2-B) Condenser fan motor
A-101 (1) Power steering oil pressure switch
A-102 (1) Spare connector for fog lamp
A-103 (2-B) Fog lamp (RH)
A-104 (2) Position lamp (RH)
A-105 (3-B) Headlamp (RH)
A-106 (1-B) A/C compressor assembly
A-107 (2-BR) Front turn signal lamp (RH)
A-1 10 (3-GR) Ignition coil 1
A-1 11 (3-GR) Ignition coil 2
A-112X (4) Radiator fan relay (HI)
A-113X (4) Condenser fan relay (LO)

A-114X (4) Condenser fan relay (HI)
A-116X (4) A/C compressor relay
A-117 (2-GR) Side turn signal lamp (RH)
A-123 (5-B) Fuel pump relay No.2
A-124 (6-B) Fuel pump resistor
A-125 (2-B) Resistor (for injector)
A-126 (5-B) AYC relay
A-127 (2-B) Secondary air control solenoid valve
A-128 (2-GR) Condenser fan motor
A-129 (2-B) Water spray motor
A-130 (3-B) Water motor
A-131 (1-B) Noise condenser

B-6

DASH PANEL

Connector
symbol

–01

B

thru
–37

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Dash Panel

B-01 (2-R) Passenger seat air bag module (squib)
B-02 (2) Heater water temperature sensor

<vehicles with fully automatic air conditioner>

B-03 (2-B) Air thermo sensor <vehicles with fully

automatic air conditioner>

B-04 (20-B) A/C-ECU <vehicles with fully automatic air

conditioner>

B-05 (16-B) A/C-ECU <vehicles with fully automatic air

conditioner>

B-06 (6) Air outlet change-over damper motor and

potentiometer <vehicles with fully automatic
air conditioner>

B-07 (8) Blower switch

<vehicles with manual air conditioner>
B-08 (25) Meter and gauge
B-09 (25) Meter and gauge
B-10 (22) Body harness and front door harness (RH)

combination
B-11X (8) Rear intermittent wiper relay
B-13X (5) Power window relay
B-15 (20) Front harness and body harness combination
B-16 (6) Front harness and body harness combination
B-17 (14) Front harness and body harness combination

<ABS, AYC>
B-18 (19) Jumper connector (1)

WIRING HARNESS
CONFIGURATION DIAGRAMS

Interior relay box

– Dash Panel

B-7

B-19 (22) Body harness and instrument panel harness

combination
B-21 (2) Stop lamp switch (driver side)
B-22 (16-B) Diagnosis connector
B-24 (26-Y) ABS-ECU
B-25 (16) ABS-ECU
B-26 (2-B) Diode (for ABS circuit)
B-27 (4) Engine control relay
B-28 (4) Fuel pump relay
B-29 (4-B) A/T relay
B-30 (14) Radio or spare connector for radio
B-31 (1) Glass antenna amplifier
B-32 (19-B) Jumper connector (5)

B-33 (2) Blower motor

<vehicles with fully automatic air conditioner>

B-34 (4) Blower high speed relay <vehicles with fully

automatic air conditioner>

B-35 (22) Body harness and front door harness (LH)

combination

B-36 (2) Inside and outside air change-over damper

motor <vehicles with fully automatic air
conditioner>

B-37 (4) Power transistor <vehicles with fully automatic

air conditioner> or resistor <vehicles with
heater or manual air conditioner>

B-8

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Dash Panel

Connector
symbol

B

–38
thru
–65
and
–94
thru
–97

B-38 (2) Sunlight sensor <vehicles with fully

automatic air conditioner>

B-39 (6) Air mix damper motor and potentiometer

<vehicles with fully automatic air condi­tioner>

B-40 (3) Automatic compressor ECU

<vehicles with manual air conditioner>

B-41 (8) A/C switch

<vehicles with manual air conditioner>

B-42 (2) Blower switch illumination lamp <vehicles

with heater or manual air conditioner>

B-43 (6-B) Defogger switch <vehicles with heater or

manual air conditioner>

B-44 (6) Body harness and roof harness combina-

tion <vehicles with sunroof>
B-45 (2-B) Diode (for keyless entry system circuit)
B-46 (2) Spare connector for fog lamp switch

<vehicles without fog lamp>
B-48 (14) Jumper connector (2)
B-49 (14) Jumper connector (3)
B-50 (14-L) Jumper connector (4)
B-51 (21-Y) SRS-ECU

WIRING HARNESS
CONFIGURATION DIAGRAMS

Interior relay box

– Dash Panel

<Vehicles without interior relay box>

B-9

B-52 (16-B) Control harness and body harness

combination <vehicles with ABS>
B-59 (26-Y) Engine-ECU
B-60 (16-Y) Engine-ECU
B-61 (12-Y) Engine-ECU
B-62 (22-Y) Engine-ECU
B-63 (2) Blower motor <vehicles with heater or

manual air conditioner>
B-64 (13) Control harness and body harness

combination

B-65 (16-B) Control harness and body harness

combination

B-94 (13) Control harness and body harness

combination <vehicles with AYC>
B-95 (26-Y) AYC-ECU
B-96 (16) AYC-ECU
B-97 (2) Foot lamp

B-10

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Dash Panel

Connector
symbol

B

–66
thru
–89
and
–98

<Junction block>

<Front view> <Rear view>

<Steering column>

B-66 (2) Junction block and roof harness combination
B-67 (11) Junction block and front harness combination
B-68 (3) Turn signal / hazard flasher unit
B-69 (14) Junction block and instrument panel harness

combination
B-70 (4) Dedicated fuse (for sunroof circuit)
B-71 (5) Defogger relay
B-72 (5) Blower relay
B-73 (1) Junction block and front harness combination
B-74 (10) Junction block and body harness combination
B-75 (10-B) Junction block and body harness combination
B-76 (8) Junction block and body harness combination
B-77 (8) ETACS-ECU
B-78 (4) Junction block and body harness combination

B-79 (12) Junction block and ETACS-ECU combination,

or junction block and ECU combination
B-80 (13) Junction block and body harness combination
B-81 (12) Column switch
B-82 (2-R) Clock spring <vehicles with SRS air bag>
B-83 (6) Ignition switch
B-84 (5) Key reminder switch
B-85 (6) Column switch
B-86 (10) Column switch
B-87 (3) Clock spring (SRS) <vehicles with dual horn>
B-88 (2) Driver seat air bag module (squib)
B-89 (1) Horn switch <vehicles with SRS air bag>
B-98 (5) Steer sensor <vehicles with AYC>

NOTES

B-11

B-12

WIRING HARNESS
CONFIGURATION DIAGRAMS

FLOOR, ROOF, AND SEAT

Connector
symbol

D

– Floor, Roof, and Seat

D-01 (20) Receiver

<vehicles with keyless entry system>
D-02 (2) Seat belt switch
D-03 (2) Front door switch (RH)
D-04 (10) Body harness and fuel harness combina-

tion
D-05 (6) Body harness and rear door harness

(RH) combination
D-06 (22) Body harness and rear harness combina-

tion
D-07 (6) Sunroof switch
D-08 (8) Room lamp <vehicles with sunroof>

D-09 (1) Map lamp
D-10 (18) Sunroof ECU
D-11 (2-GR) Room lamp <vehicles without sunroof>
D-12 (8) Sunroof motor
D-13 (3-B) Fuel gauge unit (sub)
D-14 (2-B) Rear speed sensor (LH)

<vehicles with ABS>

D-16 (6) Body harness and rear door harness (LH)

combination
D-17 (2) Front door switch (LH)
D-18 (6) Fuel gauge unit (main)

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Floor, Roof, and Seat

<Power seat>

B-13

D-19 (2-B) Rear speed sensor (RH)

<vehicles with ABS>

D-20 (3-B) Acceleration sensor (longitudinal)

<vehicles with ABS or AYC>
D-21 (1-B) Parking brake switch
D-22 (2-B) High temperature sensor
D-23 Reclining motor
D-24 Slide limit switch

D-25 (2) Body harness and power seat harness

combination and power seat switch
D-26 Slide motor
D-27 (2) Body harness and rear harness combina-

tion <vehicles with AYC>
D-31 (2) Water spray switch
D-32 (3-B) Acceleration sensor (lateral)

<vehicles with AYC>

B-14

WIRING HARNESS
CONFIGURATION DIAGRAMS

LUGGAGE COMPARTMENT

Connector
symbol

F

Glass
antenna
amplifier

– Luggage Compartment

F-01 (1-B) Defogger (–) <vehicles without choke coil>
F-02 (1-B) Defogger (–) <vehicles with choke coil>
F-03 (2) Choke coil
F-04 (3) Choke coil
F-05 (2) Luggage compartment lamp
F-06 (2) High mounted stop lamp (installed on rear

shelf)
F-08 (2-B) Rear speaker (RH)
F-09 (1-B) Defogger (+) <vehicles with choke coil>
F-10 (1-B) Defogger (+) <vehicles without choke coil>
F-11 (3) Rear wiper motor
F-12 (1-B) Rear door switch (RH)
F-13 (2) High mounted stop lamp (installed on rear

spoiler)
F-15 (6) Rear combination lamp (RH)
F-16 (2-GR) Licence plate lamp (RH)

F-17 (1-B) Luggage compartment lamp switch
F-18 (2-GR) Licence plate lamp (LH)
F-20 (6) Rear combination lamp (LH)
F-23 (2-B) Rear speaker (LH)
F-24 (1) Glass antenna <vehicles without diversi-

ty glass antenna>
F-25 (1) Glass antenna
F-26 (1-B) Rear door switch (LH)
F-27 (3-B) Proportioning valve <vehicles with AYC>
F-28 (2-B) Direction valve (LH) <vehicles with A YC>
F-29 (2-B) Direction valve (RH) <vehicles with AYC>
F-30 (8-B) Rear harness and AYC harness combina-

tion
F-31 (2-B) Accumulator pressure switch

<vehicles with AYC>
F-32 (2-B) AYC motor

NOTES

B-15

B-16

SINGLE PART INSTALLATION POSITION – Relay

SINGLE PART INSTALLATION POSITION

RELAY

Name Symbol Name Symbol
AYC relay B Fuel pump relay No.2 B
Condenser fan motor relay (HI) A Radiator fan motor relay (HI) A
Condenser fan motor relay (LO) A Radiator fan motor relay (LO) C

A

Condenser
fan motor
relay (LO)

C

Condenser
fan motor
relay (HI)

Radiator fan
motor relay (HI)

Radiator fan
motor relay (LO)

B

Fuel pump relay No.2

A YC relay

SINGLE PART INSTALLATION POSITION – ECU

ECU

Name Symbol
AYC-ECU A

A

B-17

B-18

SINGLE PART INSTALLATION POSITION – Sensor

SENSOR

Name Symbol Name Symbol
Acceleration sensor (lateral)

<vehicles with AYC>
Acceleration sensor (longitudinal)

<vehicles with ABS and AYC>
Air flow sensor D O2 sensor E
Camshaft position sensor G Steering angle sensor <vehicles with AYC> H
Crank angle sensor A Throttle position sensor C
Engine coolant temperature sensor G

I Knock sensor B

I Outside air temperature sensor

<vehicles with fully automatic air conditioner>

F

A

Crank angle sensor

C

Throttle position
sensor

B

Knock sensor

D

Air flow sensor

SINGLE PART INSTALLATION POSITION – Sensor

B-19

E

G

Camshaft position
sensor

I

O2 sensor

Engine coolant
temperature sensor

F

Outside air
temperature sensor

H

Steering angle sensor

Acceleration
sensor
(longitudinal)

Acceleration sensor
(lateral)

B-20

SINGLE PART INSTALLATION POSITION – Solenoid Valve

SOLENOID VALVE

Name Symbol Name Symbol
Direction valve <vehicles with AYC> D Secondary air control solenoid valve A
Fuel pressure solenoid valve B Waste gate solenoid valve C
Proportioning valve <vehicles with AYC> D

A

Intake manifold
stay

Secondary
air control
solenoid
valve

C

Waste gate
solenoid valve

B

Fuel pressure
solenoid valve

D

Rear combination
lamp (RH)

Proportioning

Direction valve

valve

SINGLE PART
INSTALLATION POSITION

Check Connector and

–

Spare Connector

B-21

CHECK CONNECTOR AND SPARE CONNECTOR

Name Symbol Name Symbol
Engine speed check connector A Fuel pump check connector A

A

Engine speed
check connector

Fuel pump
check connector

B-22

SINGLE PART
INSTALLATION POSITION

FUSIBLE LINK AND FUSE

Fusible Link and Fuse /

–

Ground Cable

<Vehicles with AYC
(vehicles without ABS)>

<Vehicles with AYC
(vehicles with ABS)>

Fusible link

Fusible link

GROUND CABLE

GROUND

1

2 5 6 7

SINGLE PART INSTALLATION POSITION – Ground

B-23

14 15 13 11 12 10 9

1 2

5 6

B-24

7 9

10 11, 1 2

SINGLE PART INSTALLATION POSITION – Ground

11

12

13 14

15

CIRCUIT DIAGRAM – Centralized Junction

CIRCUIT DIAGRAM

CENTRALIZED JUNCTION

FUSIBLE LINK

No. Circuit protected Type Housing color Rated capacity (A)
10 Active yaw control system Screw-in type Yellow 60

Fuse box directly attached on battery

<Vehicles with AYC>

W-R

R/R-B

B-25

CENTRALIZED RELAY

Connector No. Name Connector No. Name
A-82X Radiator fan motor relay (LO) A-113X Condenser fan motor relay (LO)
A-112X Radiator fan motor relay (HI) A-114X Condenser fan motor relay (HI)

Relay box in engine compartment

(A/C relay box)

B-26

CIRCUIT DIAGRAM – Power Distribution System

POWER DISTRIBUTION SYSTEM

FUSIBLE LINK (RELAY BOX IN ENGINE COMPARTMENT)

BATTERY

FUSIBLE LINK
(DIRECTLY
CONNECTED
TO BA TTERY)

STARTING
SYSTEM

ANTILOCK
BRAKE
SYSTEM

DEDICATED FUSE
(A/C RELAY BOX
IN ENGINE
COMPARTMENT)

ACTIVE YA W
CONTROL SYSTEM

CHARGING SYSTEM

DEDICA TED FUSE
(RELA Y BOX
IN ENGINE
COMPARTMENT)

• HEATER AND MANUAL
AIR CONDITIONER

• FULLY AUTOMATIC AIR
CONDITIONER

• COOLING SYSTEM

• HEATER AND MANUAL

AIR CONDITIONER

• FULLY AUTOMATIC
AIR CONDITIONER

• HEATER AND MANUAL
AIR CONDITIONER

• FULLY AUTOMATIC
AIR CONDITIONER

• COOLING SYSTEM

CIRCUIT DIAGRAM – Power Distribution System

B-27

CHARGING
SYSTEM

HEADLAMP
RELAY

HEADLAMP

HEADLAMP

• CLOCK AND MULTI-DISPLAY

• SUNROOF

• CIGARETTE LIGHTER AND ASHTRAY

ILLUMINA TION LAMP

• METER AND GAUGE

• TURN SIGNAL LAMP AND HAZARD LAMP

• TAIL LAMP, POSITION LAMP, LICENCE

PLATE LAMP, AND LIGHTING MONITOR
BUZZER

• DEFOGGER AND DOOR MIRROR HEATER

• ELECTRIC RETRACT ABLE REMOTE

CONTROLLED MIRROR

• HEATER

• HEATER AND MANUAL AIR CONDITIONER

• FOG LAMP

• FOOT LAMP

• FULL Y AUTOMATIC AIR CONDITIONER

• HEADLAMP

• RADIO

• SPARE CONNECT OR FOR RADIO

FOG LAMP SPARE

• HEATER AND
MANUAL AIR
CONDITIONER

• FULLY AUTO­MATIC AIR
CONDITIONER

• COOLING
SYSTEM

CONNECTOR
FOR FOG LAMP

• POWER
WINDOW

• POWER
SEAT

ENGINE
CONTROL
SYSTEM

TURN SIGNAL LAMP
AND HAZARD LAMP

• ACTIVE YAW
CONTROL
SYSTEM

• ANTILOCK
BRAKE
SYSTEM

• STOP LAMP

B-28

CIRCUIT DIAGRAM – Power Distribution System

POWER DISTRIBUTION SYSTEM (CONTINUED)

FUSIBLE
LINK

• ENGINE CONTROL
SYSTEM

• STAR TING SYSTEM

IGNITION
SWITCH

MULTI­PURPOSE
FUSE

• ENGINE
CONTROL
SYSTEM

• CHARGING
SYSTEM

• IGNITION
SYSTEM

• SRS AIR
BAG

• ENGINE
CONTROL
SYSTEM

• BACK-UP
LAMP

TURN SIGNAL LAMP
AND HAZARD LAMP

• SRS AIR BAG

• ACTIVE YAWING CONTROL SYSTEM

• ANTILOCK BRAKE SYSTEM

• IGNITION KEY CYLINDER

ILLUMINA TION LAMP

• IGNITION KEY REMINDER BUZZER

• ENGINE CONTROL SYSTEM

• OIL PRESSURE WARNING LAMP

• SUNROOF

• METER AND GAUGE

• CHARGING SYSTEM

• CENTRAL DOOR LOCKING SYSTEM

• TAIL LAMP, POSITION LAMP, LICENCE PLATE

LAMP, AND LIGHTING MONITOR BUZZER

• FUEL WARNING LAMP

• FOOT LAMP

• BRAKE WARNING LAMP

• RADIO

• SPARE CONNECT OR FOR RADIO

• ACTIVE YA W CONTROL SYSTEM

• ANTILOCK BRAKE SYSTEM

• INTERCOOLER WA TER SPRAY SYSTEM

• DEFOGGER AND DOOR MIRROR HEATER

• TENSION REDUCER SEAT BEL T

• POWER WINDOW

• HEATER

• HEATER AND MANUAL AIR CONDITIONER

• FULL Y AUTOMATIC AIR CONDITIONER

• HEATER AND MANUAL

AIR CONDITIONER

• FULLY AUTOMATIC AIR
CONDITIONER

• COOLING SYSTEM

CIRCUIT DIAGRAM – Power Distribution System

B-29

• WINDSHIELD WIPER,
WASHER

• REAR WIPER,
WASHER

• CIGARETTE
LIGHTER AND
ASHTRAY
ILLUMINATION
LAMP

• ELECTRIC
RETRACTABLE
REMOTE
CONTROLLED
DOOR MIRROR

• ELECTRICALLY
REMOTE
CONTROLLED
DOOR MIRROR

MULTI­PURPOSE
FUSE

• CLOCK AND MULTI­DISPLAY

• CENTRAL DOOR
LOCKING SYSTEM
(VEHICLES WITH
KEYLESS ENTRY
SYSTEM)

• RADIO

• SPARE CONNEC-

TOR FOR RADIO

DEDICATED
FUSE (RELAY
BOX IN ENGINE
COMPARTMENT)

HORN

B-30

CIRCUIT DIAGRAM – Power Distribution System

POWER DISTRIBUTION SYSTEM (CONTINUED)

FUSIBLE
LINK

MULTI­PUR­POSE
FUSE

CENTRAL DOOR
LOCKING SYSTEM

• HEATER

• HEATER AND MANUAL

AIR CONDITIONER

• FULL Y AUTOMA TIC AIR
CONDITIONER

• SRS AIR BAG

• ACTIVE YA W CONTROL SYSTEM

• ANTILOCK BRAKE SYSTEM

• IGNITION KEY CYLINDER ILLUMINATION LAMP

• IGNITION KEY REMINDER BUZZER

• ENGINE CONTROL SYSTEM

• CLOCK AND MULTI-DISPLAY

• METER AND GAUGE

• CENTRAL DOOR LOCKING SYSTEM

• TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP,

AND LIGHTING MONITOR BUZZER

• DEFOGGER AND DOOR MIRROR HEATER

• FULL Y AUTOMATIC AIR CONDITIONER

• RADIO

• SPARE CONNECT OR FOR RADIO

• ROOM LAMP AND LUGGAGE COMPAR TMENT LAMP

DEFOGGER
AND DOOR
MIRROR
HEATER

DEDICATED
FUSE
(INSTALLED
IN JUNCTION
BLOCK)

B-70

SUNROOF

CIRCUIT DIAGRAM – Starting System

STARTING SYSTEM

BATTERY

B-31

IGNITION
SWITCH (ST)

ENGINE
CONTROL
SYSTEM

STARTER

B-32
IGNITION SYSTEM

CIRCUIT DIAGRAM – Ignition System

IGNITION SWITCH (IG1)

ENGINE CONTROL
SYSTEM

NOISE
CONDENSER

INPUT SIGNAL

• IDLE SWITCH

• IGNITION SWITCH (ST)

• CAM POSITION SENSOR

• INTAKE AIR TEMPERATURE SENSOR

• CRANK ANGLE SENSOR

• VEHICLE SPEED SENSOR

• ENGINE COOLANT TEMPERATURE

SENSOR

• BAROMETRIC PRESSURE SENSOR

• KNOCK SENSOR

ENGINE-ECU

IGNITION
COIL 1

IGNITION
COIL 2

NOISE
CON­DENSER

SPARK PLUG

METER AND
GAUGE

ENGINE SPEED
DETECTION CONNECTOR

CIRCUIT DIAGRAM – Charging System

CHARGING SYSTEM

FUSIBLE LINK

• TAIL LAMP, POSITION
LAMP, LICENCE PLA TE
LAMP, AND LIGHTING
MONITOR BUZZER

• POWER SUPPLY

• FOG LAMP

• HEADLAMP

FUSIBLE LINK

B-33

IGNITION
SWITCH (IG1)

COMBINATION
METER

STATOR

COIL

ENGINE-ECU

FIELD COIL

ALTERNATOR
RELAY

ALTERNATOR

IC VOLTAGE REGULATOR

B-34

CIRCUIT DIAGRAM – Engine Control System

ENGINE CONTROL SYSTEM

VACANT
TERMINAL

ENGINE
CONTROL
RELAY

FUSIBLE LINK

FUSIBLE LINK IGNITION SWITCH (IG1)

COMBINATION
METER

ENGINE-ECU

ACTIVE YA W
CONTROL SYSTEM

POWER SUPPL Y

BACK-UP
POWER
SUPPLY

ANTI-LOCK
BRAKE
SYSTEM

CIRCUIT DIAGRAM – Engine Control System

FUEL
PUMP
RESISTOR

IGNITION
SYSTEM

B-35

FUEL PUMP
RELA Y NO.2

FUEL
PUMP
RELAY

FUEL PUMP
INSPECTION
CONNECTOR

FUEL PUMP

B-36

CIRCUIT DIAGRAM – Engine Control System

ENGINE CONTROL SYSTEM (CONTINUED)

ENGINE
CONTROL
RELAY

CAMSHAFT
POSITION
SENSOR

ENGINE­ECU

CRANK
ANGLE
SENSOR

IDLE SPEED
CONTROL
SERVO

O2
SENSOR

IDLE
SWITCH

THROTTLE POSITION SENSOR

FRONT VIEW

RESISTOR
(FOR INJECTOR)

CIRCUIT DIAGRAM – Engine Control System

B-37

INJECTOR

INJECTOR

INJECTOR INJECTOR

MULTI-PURPOSE
FUSE

• CENTRAL DOOR
LOCKING SYSTEM
<VEHICLES WITH
KEYLESS ENTRY
SYSTEM>

• FULL Y AUT OMATIC
AIR CONDITIONER

DIAGNOSIS
CONNECTOR

B-38

CIRCUIT DIAGRAM – Engine Control System

ENGINE CONTROL SYSTEM (CONTINUED)

ENGINE COOLANT
TEMPERATURE
SENSOR

THROTTLE POSITION
SENSOR

AIR FLOW
SENSOR

INTAKE AIR
TEMPERA TURE SENSOR

BAROMETRIC PRES­SURE SENSOR

IDLE SPEED
CONTROL SERVO

ENGINE-ECU

CHARGING
SYSTEM

ENGINE-ECU

KNOCK
SENSOR

• METER
AND
GAUGE

• RADIO

VEHICLE
SPEED
SENSOR

HIGH TEMPERATURE SENSOR

POWER STEERING OIL
PRESSURE SWITCH

IDLE SPEED
CONTROL SERVO

FUEL
PRESSURE
SOLENOID
VALVE

CIRCUIT DIAGRAM – Engine Control System

IGNITION SWITCH (ST)

SECONDARY

WASTE GATE
SOLENOID
VALVE

AIR CONTROL
SOLENOID
VALVE

B-39

STARTING
SYSTEM

AIR
CONDITIONER

• AIR
CONDITIONER

• COOLING
SYSTEM

IGNITION
SYSTEM

METER AND
GAUGE

ENGINE SPEED
DETECTION CONNECTOR

B-40
COOLING SYSTEM

CIRCUIT DIAGRAM – Cooling System

RADIATOR
FAN MOTOR
RELA Y (HI)

FUSIBLE LINK

IGNITION SWITCH (IG2)

RADIATOR
FAN MOTOR
RELA Y (LO)

RADIATOR
FAN MOT OR

INPUT SIGNAL

• A/C SWITCH

• IDLE SWITCH

• CRANK ANGLE SENSOR

• VEHICLE SPEED SENSOR

• ENGINE COOLANT

TEMPERA TURE SENSOR

• THROTTLE POSITION
SENSOR

ENGINE-ECU

CIRCUIT DIAGRAM – Cooling System

B-41

CONDENSER FAN
MOTOR RELA Y (HI)

DEDICATED
FUSE

FUSIBLE LINK

AUTOMATIC
COMPRESSOR
ECU

• HEATER AND MANUAL
AIR CONDITIONER

• FULLY AUTOMATIC AIR
CONDITIONER

DEDICATED
FUSE

MANUAL AIR
CONDITIONER

FULL AUTOMATIC
AIR CONDITIONER

• HEATER AND MANUAL
AIR CONDITIONER

• FULLY AUTOMATIC AIR
CONDITIONER

CONDENSER
FAN MOT OR
RELA Y (LO)

CONDENSER
FAN MOT OR

B-42

CIRCUIT DIAGRAM –

Tail Lamp, Position Lamp, License Plate Lamp and Lighting Monitor Alarm Buzzer

TAIL LAMP, POSITION LAMP, LICENSE PLATE LAMP AND
LIGHTING MONITOR ALARM BUZZER

COLUMN SWITCH

(TAIL LAMP: LH)

REAR
COMBINATION
LAMP

(TAIL LAMP: RH)

LICENSE
PLATE
LAMP

CIRCUIT DIAGRAM –

COLUMN SWITCH

Tail Lamp, Position Lamp, License Plate Lamp
and Lighting Monitor Alarm Buzzer

B-43

(TAIL LAMP: LH)

REAR
COMBINATION
LAMP

(TAIL LAMP: RH)

LICENSE
PLATE
LAMP

B-44
FOG LAMP

FUSIBLE LINK

DEDICATED
FUSE

CIRCUIT DIAGRAM – Fog Lamp

• CHARGING SYSTEM

• POWER SUPPLY

• HEADLAMP

COLUMN
SWITCH
(LIGHTING
SWITCH)

: • CLOCK, MULTI-DISPLA Y

• CIGARETTE LIGHTER, ASH TRAY
ILLUMINA TION LAMP

• TURNSIGNAL LAMP , HAZARD
WARNING LAMP

• ELECTRIC RETRACTABLE
REMOTE CONTROLLED MIRROR

FOG LAMP
SWITCH

FOG LAMP

CIRCUIT DIAGRAM – Room Lamp and Luggage Compartment Lamp

ROOM LAMP AND LUGGAGE COMPARTMENT LAMP

FUSIBLE LINK

B-45

VEHICLES WITHOUT
SUNROOF

ROOM
LAMP

VEHICLES WITHOUT KEYLESS
ENTRY SYSTEM

MAP LAMP

VEHICLES WITH
SUNROOF

VEHICLES WITH
MAP LAMP

VEHICLES WITH KEYLESS
ENTRY SYSTEM

DIODE

CENTRAL DOOR LOCKING
SYSTEM <VEHICLES WITH
KEYLESS ENTR Y SYSTEM>

ROOM
LAMP

COMBINATION
METER

DEFOGGER

LUGGAGE
COMPARTMENT
LAMP

FRONT
DOOR
SWITCH

REAR
DOOR
SWITCH

LUGGAGE
COMPARTMENT
LAMP
SWITCH

B-46

CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp

TURN-SIGNAL LAMP AND HAZARD LAMP

DEDICATED
FUSE

COLUMN
SWITCH
(LIGHTING
SWITCH)

HAZARD
SWITCH

FUSIBLE LINK

IGNITION SWITCH (IG1) BATTERY

• CHARGING
SYSTEM

• HEADLAMP

FOG LAMP

DEDICATED
FUSE

NOTE

:

• CLOCK AND MULTI-DISPLAY

• CIGARETTE LIGHTER AND

ASHTRA Y ILLUMINATION
LAMP

• ELECTRIC RETRACTABLE
REMOTE CONTROLLED
DOOR MIRROR

• FOG LAMP

TURN SIGNAL
AND HAZARD
FLASHER
UNIT

CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp

B-47

TURN SIGNAL
AND HAZARD
FLASHER UNIT

SIDE TURN
SIGNAL
LAMP

HAZARD SWITCH

FRONT TURN
SIGNAL LAMP

SIDE TURN
SIGNAL
LAMP

B-48

CIRCUIT DIAGRAM – Turn-signal Lamp and Hazard Lamp

TURN-SIGNAL LAMP AND HAZARD LAMP (CONTINUED)

TURN SIGNAL

HAZARD SWITCH

AND HAZARD
FLASHER UNIT

COLUMN SWITCH
(TURN SIGNAL
LAMP SWITCH)

REAR
COMBINATION
LAMP
(TURN: RH)

REAR
COMBINATION
LAMP
(TURN: LH)

COMBINATION
METER

STOP LAMP

DEDICATED
FUSE

STOP
LAMP
SWITCH

CIRCUIT DIAGRAM – Stop Lamp

BATTERY

B-49

ANTI-LOCK
BRAKE
SYSTEM

REAR
COMBINATION
LAMP

(STOP:
RH)

(STOP:
LH)

HIGH
MOUNTED
STOP LAMP

INSTALLED ON
REAR SPOILER

INSTALLED ON
REAR SHELF

VACANT
CONNECTOR
(SOME
MODELS)

HIGH
MOUNTED
STOP LAMP

B-50
BACK-UP LAMP

CIRCUIT DIAGRAM – Back-up Lamp

IGNITION SWITCH (IG1)

BACK-UP
LAMP
SWITCH

REAR
COMBINATION
LAMP
(BACK-UP: LH)

REAR
COMBINATION
LAMP
(BACK-UP: RH)

CIRCUIT DIAGRAM – Horn <Vehicles without SRS Air Bag>

HORN <VEHICLES WITHOUT SRS AIR BAG>

IGNITION SWITCH (ACC)

DEDICATED
FUSE

B-51

HORN
(RH)

COLUMN
SWITCH

HORN
(LH)
(DUAL HORN
ONLY)

VACANT CONNECTOR
(SOME MODELS)

HORN
SWITCH

B-52

CIRCUIT DIAGRAM – Oil Pressure Warning Lamp

OIL PRESSURE WARNING LAMP

IGNITION
SWITCH (IG1)

COMBINATION
METER

OIL
PRESSURE
SWITCH

CHARGING
SYSTEM

NOTES

B-53

B-54

CIRCUIT DIAGRAM –

Central Door Locking System <Vehicles with Keyless Entry System>

CENTRAL DOOR LOCKING SYSTEM <VEHICLES WITH KEYLESS
ENTRY SYSTEM>

FUSIBLE LINK

IGNITION SWITCH (IG1)

RECEIVER

KEY
REMINDER
SWITCH

DOOR LOCK
ACTUATOR
(FRONT: RH)

CIRCUIT DIAGRAM –

Central Door Locking System
<Vehicles with Keyless Entry System>

B-55

DOOR LOCK
ACTUATOR
(FRONT: LH)

DOOR LOCK
ACTUATOR
(REAR: RH)

DOOR LOCK
ACTUATOR
(REAR: LH)

B-56

CIRCUIT DIAGRAM –

<Vehicles with Keyless Entry System>

CENTRAL DOOR LOCKING SYSTEM <VEHICLES WITH KEYLESS ENTRY
SYSTEM> (CONTINUED)

MULTI-PURPOSE
FUSE

VEHICLES WITHOUT SUNROOF VEHICLES WITH SUNROOF

VEHICLES WITH
MAP LAMP

Central Door Locking System

ROOM
LAMP

SUNROOF

DIODE

MAP LAMP

ROOM
LAMP

COMBINATION
METER

FRONT
DOOR
SWITCH

REAR DOOR
SWITCH

FRONT VIEW

CIRCUIT DIAGRAM –

IGNITION SWITCH (ACC)

Central Door Locking System
<Vehicles with Keyless Entry System>

RADIO

B-57

RECEIVER

RECEIVING
ANTENNA

• ANTI-LOCK BRAKE
SYSTEM

• ENGINE CONTROL
SYSTEM

• FULL Y AUTOMATIC
AIR CONDITIONER

DIAGNOSIS
CONNECTOR

CONTROL
CIRCUIT

TRANSMITTER

B-58

CIRCUIT DIAGRAM – Heater and Manual Air Conditioner

HEATER AND MANUAL AIR CONDITIONER

• CHARGING
SYSTEM

• POWER
SUPPLY

• HEADLAMP

DEDICATED
FUSE

FOG LAMP

COLUMN
SWITCH
(LIGHTING
SWITCH)

FUSIBLE LINK

FUSIBLE LINK

BLOWER
MOTOR

IGNITION
SWITCH (IG2)

BLOWER
MOTOR
RELAY

RESISTOR

BLOWER SWITCH

CIRCUIT DIAGRAM – Heater and Manual Air Conditioner

B-59

HEATER CONTROL
PANEL ILLUMINA TION
LAMP

COLUMN
SWITCH

BLOWER
SWITCH

A/C
SWITCH

AUTOMATIC
COMPRESSOR
ECU

BLOWER
SWITCH

B-60

CIRCUIT DIAGRAM – Heater and Manual Air Conditioner

HEATER AND MANUAL AIR CONDITIONER (CONTINUED)

FUSIBLE LINK

IGNITION
SWITCH (IG2)

RADIATOR
FAN MOTOR
RELA Y (HI)

RADIATOR
FAN MOT OR

RADIATOR
FAN MOTOR
RELA Y (LO)

INPUT SIGNAL

• A/C SWITCH

• IDLE SWITCH

• CRANK ANGLE SENSOR

• VEHICLE SPEED SENSOR

• ENGINE COOLANT

TEMPERA TURE SENSOR

• THROTTLE POSITION
SENSOR

ENGINE-ECU

CIRCUIT DIAGRAM – Heater and Manual Air Conditioner

AUTOMATIC

FUSIBLE LINK

DEDICATED
FUSE

COMPRESSOR ECU

B-61

CONDENSER
FAN MOTOR
RELA Y (HI)

DEDICATED
FUSE

CONDENSER
FAN MOTOR
RELA Y (LO)

CONDENSER
FAN MOT OR

B-62

CIRCUIT DIAGRAM – Heater and Manual Air Conditioner

HEATER AND MANUAL AIR CONDITIONER (CONTINUED)

AUTOMATIC
COMPRESSOR
ECU

DUAL
PRESSURE
SWITCH

FUSIBLE LINK

DEDICATED
FUSE

A/C
COMPRESSOR
RELAY

ENGINE-ECU

REFRIGERANT
TEMPERATURE
SWITCH

A/C COMPRESSOR
AND MAGNETIC
CLUTCH

NOTES

B-63

B-64

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

FULLY AUTOMATIC AIR CONDITIONER

FUSIBLE LINK

IGNITION
SWITCH (IG2)

BLOWER
MOTOR
RELAY

BACK-UP
POWER
SUPPLY

POWER TRAN­SISTOR DRIVE
CIRCUIT

BLOWER
MOTOR

BLOWER
HIGH SPEED
RELAY

POWER
SUPPLY

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

B-65

• CHARGING
SYSTEM

• POWER
SUPPLY

• HEADLAMP

DEDICATED
FUSE

FOG
LAMP

COLUMN
SWITCH
(LIGHTING
SWITCH)

FUSIBLE LINK

POWER
TRANSISTOR

POWER TRAN­SISTOR DRIVE
CIRCUIT

BLOWER
MOTOR

BLOWER HIGH
SPEED RELA Y

AIR MIX DAMPER
POTENTIOMETER

B-66

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

FULLY AUTOMATIC AIR CONDITIONER (CONTINUED)

AIR OUTLET CHANGEOVER
POTENTIOMETER

DEDICATED IC

HEATER W ATER

AIR THERMO SENSOR

DEDICATED IC DEDICATED IC

TEMPERA TURE SENSOR

AIR OUTLET CHANGEOVER
DAMPER MOTOR

AIR MIX DAMPER
MOTOR

INSIDE AND OUTSIDE AIR
CHANGEOVER DAMPER MOTOR

FRONT VIEW

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

B-67

OUTSIDE AIR TEMPERA TURE SENSOR

SUNLIGHT SENSOR

DIAGNOSIS
CONNECTOR

DEFOGGER

• ANTI-LOCK
BRAKE
SYSTEM

• ENGINE CON­TROL SYSTEM

• CENTRAL
DOOR LOCK­ING SYSTEM
<VEHICLES
WITH KEYLESS
ENTRY SYS­TEM>

MULTI-PURPOSE
FUSE

B-68

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

FULLY AUTOMATIC AIR CONDITIONER (CONTINUED)

FUSIBLE LINK

IGNITION
SWITCH (IG2)

RADIATOR
FAN MOT OR
RELA Y (HI)

RADIATOR
FAN MOT OR

RADIATOR
FAN MOTOR
RELA Y (LO)

INPUT SIGNAL

• A/C SWITCH

• IDLE SWITCH

• CRANK ANGLE SENSOR

• VEHICLE SPEED SENSOR

• ENGINE COOLANT

TEMPERA TURE SENSOR

• THROTTLE POSITION
SENSOR

ENGINE-ECU

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

FUSIBLE LINK

DEDICATED
FUSE

B-69

CONDENSER
FAN MOTOR
RELA Y (HI)

DEDICATED
FUSE

CONDENSER
FAN MOTOR
RELA Y (LO)

CONDENSER
FAN MOT OR

B-70

CIRCUIT DIAGRAM – Fully Automatic Air Conditioner

FULLY AUTOMATIC AIR CONDITIONER (CONTINUED)

DUAL
PRESSURE
SWITCH

DEDICATED
FUSE

DEDICATED
FUSE

ENGINE-ECU

A/C COMPRESSOR
RELAY

REFRIGERANT
TEMPERA TURE SWITCH

A/C COMPRESSOR
AND MAGNETIC
CLUTCH

NOTES

B-71

B-72

CIRCUIT DIAGRAM – Windshield Wiper and Washer <Intermittent Wiper>

WINDSHIELD WIPER AND WASHER <INTERMITTENT WIPER>

IGNITION SWITCH (ACC)

COLUMN
SWITCH

INTERMITTENT WIPER RELA Y

IN CASE OF
OPERATION
INTERVAL
FIXED TYPE
INTERMITTENT
WIPER

VARIABLE INTER­MITTENT WIPER
CONTROL SWITCH

WINDSHIELD
WASHER
SWITCH

WASHER MOTOR

WINDSHIELD
WIPER SWITCH

WINDSHIELD
WIPER MOTOR

CIRCUIT
BREAKER

CIRCUIT DIAGRAM – Rear Wiper and Washer

REAR WIPER AND WASHER

B-73

IGNITION SWITCH (ACC)

WINDSHIELD WIPER
AND WASHER

COLUMN
SWITCH

REAR
WIPER
MOTOR

REAR
INTERMITTENT
WIPER RELAY

WASHER
MOTOR

B-74

CIRCUIT DIAGRAM –

without Fully Automatic Air Conditioner>

DEFOGGER AND DOOR MIRROR HEATER <VEHICLES WITHOUT FULLY AUTOMATIC AIR CONDITIONER>

Defogger and Door Mirror Heater <Vehicles

FUSIBLE LINK

DEDI­CATED
FUSE

FOG
LAMP

COLUMN
SWITCH
(LIGHT­ING
SWITCH)

IGNITION SWITCH (IG2) FUSIBLE LINK

• CHARGING
SYSTEM

• POWER SUPPLY

• HEADLAMP

DEFOGGER
RELAY

DEFOGGER
SWITCH

VEHICLES WITHOUT
GLASS ANTENNA

DEFOGGER

VEHICLES WITH
GLASS ANTENNA

CIRCUIT DIAGRAM –

Defogger and Door Mirror Heater <Vehicles
without Fully Automatic Air Conditioner>

DEFOGGER
RELAY

B-75

PRINTED
HEATER
WIRE

DOOR
MIRROR

PRINTED
HEATER
WIRE

ROOM LAMP AND LUGGAGE
COMP ARTMENT LAMP

DEFOGGER

VEHICLES
WITH GLASS
ANTENNA

VEHICLES
WITH
DIVERSITY
ANTENNA

CHOKE
COIL

B-76

CIRCUIT DIAGRAM –

Defogger and Door Mirror Heater <Vehicles with Fully Automatic Air Conditioner>

DEFOGGER AND DOOR MIRROR HEATER
<VEHICLES WITH FULLY AUTOMATIC AIR CONDITIONER>

IGNITION SWITCH (IG2) FUSIBLE LINK

DEFOGGER
RELAY

DEFOGGER

VEHICLES WITHOUT
GLASS ANTENNA

VEHICLES WITH
GLASS ANTENNA

CIRCUIT DIAGRAM –

Defogger and Door Mirror Heater
<Vehicles with Fully Automatic Air Conditioner>

DEFOGGER
RELAY

B-77

PRINTED
HEATER
WIRE

DOOR
MIRROR

PRINTED
HEATER
WIRE

ROOM LAMP AND LUGGAGE
COMP ARTMENT LAMP

DEFOGGER

VEHICLES
WITH GLASS
ANTENNA

CHOKE
COIL

VEHICLES
WITH
DIVERSITY
ANTENNA

B-78

CIRCUIT DIAGRAM – Spare Connector for Radio

SPARE CONNECTOR FOR RADIO

FUSIBLE LINK

• CHARGING
SYSTEM

• POWER
SUPPLY

• HEADLAMP

DEDICATED
FUSE

FOG
LAMP

COLUMN
SWITCH
(LIGHTING
SWITCH)

SPARE
CONNECTOR
FOR RADIO

IGNITION SWITCH (ACC)

CENTRAL
DOOR LOCKING
SYSTEM
<VEHICLES
WITH KEYLESS
ENTRY SYSTEM>

FUSIBLE LINK

SPARE CONNECT OR
FOR REAR SPEAKER

CIRCUIT DIAGRAM – Spare Connector for Radio

B-79

<VEHICLES WITH
POLE ANTENNA>

POLE
ANTENNA

ANTENNA
FEEDER
LINE

<VEHICLES WITH
GLASS ANTENNA>

REAR WINDOW
GLASS ANTENNA

GLASS ANTENNA
AMPLIFIER

METER AND GAUGE

IGNITION SWITCH (IG1)

ANTENNA
FEEDER
LINE

• SUNROOF

• SEAT BELT

WARNING LAMP

• FOOT LAMP

SPARE CONNECTOR FOR
DOOR SPEAKER

ENGINE
CONTROL
SYSTEM

VEHICLE
SPEED
SENSOR

B-80

CIRCUIT DIAGRAM – Radio <4-speaker, 6-speaker>

RADIO <4-SPEAKER, 6-SPEAKER>

DEDICATED
FUSE

FOG LAMP

COLUMN
SWITCH
(LIGHTING
SWITCH)

FUSIBLE LINK

• CHARGING
SYSTEM

• POWER
SUPPLY

• HEADLAMP

CENTRAL
DOOR LOCK­ING SYSTEM
<VEHICLES
WITH KEYLESS
ENTRY SYS­TEM>

IGNITION SWITCH (ACC)

FUSIBLE LINK

<VEHICLES WITH
POLE ANTENNA>

POLE ANTENNA

ANTENNA
FEEDER
LINE

AM/FM RADIO

REAR SPEAKAER

TWEETER (LH)
<VEHICLES WITH
6 SPEAKERS>

<VEHICLES WITH
GLASS ANTENNA>

REAR
WINDOW
GLASS
ANTENNA

CIRCUIT DIAGRAM – Radio <4-speaker, 6-speaker>

<VEHICLES WITH GLASS
DIVERSITY ANTENNA>

REAR
WINDOW
GLASS
ANTENNA

GLASS ANTENNA AMPLIFIER

B-81

IGNITION
SWITCH (IG1)

ANTENNA
FEEDER LINE

METER
AND
GAUGE

• SUNROOF

• SEAT BEL T

WARNING
LAMP

• FOOT
LAMP

VEHICLE
SPEED
SENSOR

ENGINE
CONTROL
SYSTEM

DOOR
SPEAKER (LH)

DOOR
SPEAKER (RH)

TWEETER (RH)
<VEHICLES WITH
6 SPEAKERS>

B-82

CIRCUIT DIAGRAM – Anti-lock Brake System (ABS)

ANTI-LOCK BRAKE SYSTEM (ABS)

DEDICATED
FUSE

STOP
LAMP
SWITCH

BATTERY

FUSIBLE LINK

STOP LAMP

BACK-UP
POWER
SUPPLY

ENGINE CONTROL
SYSTEM

CIRCUIT DIAGRAM – Anti-lock Brake System (ABS)

IGNITION SWITCH (IG2)

B-83

• ACTIVE
YA W CONTROL
SYSTEM

• INTERCOOLER
WA TER SPRA Y
SYSTEM

VEHICLES WITHOUT AYC

VEHICLES
WITH AYC

B-84

CIRCUIT DIAGRAM – Anti-lock Brake System (ABS)

ANTI-LOCK BRAKE SYSTEM (ABS) (CONTINUED)

IGNITION SWITCH (IG1)

COMBINATION
METER

FUSIBLE LINK

MULTI-PURPOSE
FUSE

VALVE
RELAY

DIODE

MOTOR
RELAY

ACTIVE YA W
CONTROL
SYSTEM

CIRCUIT DIAGRAM – Anti-lock Brake System (ABS)

ACCELERA TION SENSOR (LONGITUDINAL)

TRANSFORMER
CIRCUIT

B-85

NOISE
FILTER

AMPLI­FYING
CIRCUIT

ACTIVE YAW
CONTROL SYSTEM

LOW­PASS
FILTER

DETEC­TION
CIRCUIT

FRONT SPEED SENSOR

REAR SPEED SENSOR

B-86

CIRCUIT DIAGRAM – Anti-lock Brake System (ABS)

ANTI-LOCK BRAKE SYSTEM (ABS) (CONTINUED)

HYDRAULIC
UNIT

INLET
VALVE

FRONT
(LH)

VALVE
RELAY

FRONT
(RH)

REAR
(LH)

REAR
(RH)

OUTLET
VALVE

FRONT
(LH)

FRONT
(RH)

REAR
(LH)

MOTOR
RELAY

REAR
(RH)

• CENTRAL DOOR
LOCKING SYSTEM
<VEHICLES WITH
KEYLESS ENTRY
SYSTEM>

• FULL Y AUT OMATIC
AIR CONDITIONER

FRONT VIEW

DIAGNOSIS
CONNECTOR

NOTES

B-87

B-88

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

ACTIVE YAW CONTROL SYSTEM (AYC)

FUSIBLE
LINK

INTERCOOLER
WA TER SPRA Y
SYSTEM

IGNITION
SWITCH (IG2)

ACCELERA­TION
SENSOR
(LATERAL)

ACCEL­ERATION
SENSOR
(LONGITU­DINAL)

BACK-UP
POWER
SUPPLY

ENGINE
CONTROL
SYSTEM

ANTI-LOCK
BRAKE
SYSTEM

• SUNROOF

• SEAT BELT

WARNING
LAMP

• METER AND
GAUGE

• FOOT LAMP

• RADIO

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

IGNITION
SWITCH (IG1)

B-89

BATTERY

ENGINE-ECU

DEDICATED
FUSE

COMBINATION
METER

STOP
LAMP

STOP
LAMP
SWITCH

ENGINE
CONTROL
SYSTEM

THROTTLE
POSITION
SENSOR

B-90

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

ACTIVE YAW CONTROL SYSTEM (AYC) (CONTINUED)

<VEHICLES WITH ABS>

MOTOR
RELA Y (ABS)

ANTI-LOCK
BRAKE
SYSTEM

FRONT SPEED SENSOR REAR SPEED SENSOR

FRONT VIEW

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

B-91

<VEHICLES
WITHOUT ABS>

FRONT SPEED SENSOR REAR SPEED SENSOR

STEERING
ANGLE
SENSOR

(MUL TI-PURPOSE FUSE )

B-92

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

ACTIVE YAW CONTROL SYSTEM (AYC) (CONTINUED)

FUSIBLE LINK

AYC
RELAY

AYC MOT OR

FRONT VIEW

PROPOR­TIONING
VALVE

DIRECTION
VALVE

CIRCUIT DIAGRAM – Active Yaw Control System (AYC)

• CENTRAL DOOR
LOCKING SYSTEM
<VEHICLES WITH
KEYLESS ENTRY
SYSTEM>

• FULLY AUTOMA TIC
AIR CONDITIONER

B-93

ACCUMULATOR
PRESSURE
SWITCH

DIAGNOSIS
CONNECTOR

B-94

CIRCUIT DIAGRAM – Intercooler Water Spray System

INTERCOOLER WATER SPRAY SYSTEM

IGNITION
SWITCH (IG2)

VEHICLES WITHOUT
ABS AND AYC

WATER
SPRAY
SWITCH

WATER
SPRAY
MOTOR

VEHICLES WITH
ABS OR AYC

• ACTIVE Y AW CONTROL
SYSTEM

• ANTI-LOCK BRAKE
SYSTEM

ELECTRICAL

WIRING

(EVOLUTION-V)

CONTENTS

C-1

WIRING HARNESS CONFIGURATION

DIAGRAMS 2. . . . . . . . . . . . . . . . . . . . . . . . .

ENGINE COMPARTMENT 2. . . . . . . . . . . . . . . .

DASH PANEL 6. . . . . . . . . . . . . . . . . . . . . . . . . . .

FLOOR, ROOF, AND SEAT 10. . . . . . . . . . . .

LUGGAGE COMPARTMENT 12. . . . . . . . . . . .

SINGLE PART INSTALLATION

POSITION 13. . . . . . . . . . . . . . . . . . . . . . . . .

RELAY 13. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

ECU 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

SENSOR 14. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

SOLENOID VALVE 16. . . . . . . . . . . . . . . . . . . . .

CHECK CONNECTOR AND SPARE

CONNECTOR 17. . . . . . . . . . . . . . . . . . . . . . . . . .

FUSIBLE LINK AND FUSE 17. . . . . . . . . . . . .

GROUND CABLE 18. . . . . . . . . . . . . . . . . . . . . .

GROUND 18. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

CIRCUIT DIAGRAM 19. . . . . . . . . . . . . . . .

CENTRALIZED JUNCTION 19. . . . . . . . . . . . .

POWER DISTRIBUTION SYSTEM 20. . . . . .

STARTING SYSTEM 25. . . . . . . . . . . . . . . . . . .

IGNITION SYSTEM 26. . . . . . . . . . . . . . . . . . . .

CHARGING SYSTEM 27. . . . . . . . . . . . . . . . . .

ENGINE CONTROL SYSTEM 28. . . . . . . . . . .

ROOM LAMP AND LUGGAGE

COMPARTMENT LAMP 36. . . . . . . . . . . . . . . .

TURN-SIGNAL LAMP AND

HAZARD LAMP 38. . . . . . . . . . . . . . . . . . . . . . .

STOP LAMP 41. . . . . . . . . . . . . . . . . . . . . . . . . .

BACK-UP LAMP 42. . . . . . . . . . . . . . . . . . . . . . .

OIL PRESSURE WARNING LAMP 43. . . . . .

CENTRAL DOOR LOCKING SYSTEM
<VEHICLES WITH KEYLESS ENTRY

SYSTEM> 44. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

HEATER AND MANUAL

AIR CONDITIONER 48. . . . . . . . . . . . . . . . . . . .

FULLY AUTOMATIC AIR CONDITIONER 54
WINDSHIELD WIPER AND WASHER

<INTERMITTENT WIPER> 61. . . . . . . . . . . . . .

REAR WIPER AND WASHER 62. . . . . . . . . .

DEFOGGER AND DOOR MIRROR
HEATER <VEHICLES WITHOUT FULLY

AUTOMATIC AIR CONDITIONER> 64. . . . . .

DEFOGGER AND DOOR MIRROR
HEATER <VEHICLES WITH FULLY

AUTOMATIC AIR CONDITIONER> 66. . . . . .

SPARE CONNECTOR FOR RADIO 68. . . . .

RADIO <4-SPEAKER, 6-SPEAKER> 70. . . .

ANTI-LOCK BRAKE SYSTEM (ABS) 74. . . .

ACTIVE YAW CONTROL SYSTEM (AYC) 80
INTERCOOLER WATER SPRAY SYSTEM 86

COOLING SYSTEM 34. . . . . . . . . . . . . . . . . . . .

C-2

WIRING HARNESS
CONFIGURATION DIAGRAMS

– Engine Compartment

WIRING HARNESS CONFIGURATION DIAGRAMS

ENGINE COMPARTMENT

Connector
symbol

–01

A

thru
–50

Ground cable

A-01 (2-B) Brake fluid level switch
A-03 (1-B) Noise condenser
A-04 (1) Alternator
A-05 (4-GR) Alternator
A-09 (1-B) Starter
A-10 (1) Starter
A-12 (2-B) Fuel pressure solenoid valve
A-16 (4-B) Throttle position sensor
A-18 (6-B) Idle speed control servo
A-19 (3-B) Vehicle speed sensor

A-20 (4-B) Windshield wiper motor
A-21 (8-B) Hydraulic unit <vehicles with ABS>
A-22 (2-B) Hydraulic unit <vehicles with ABS>
A-23 (2-B) Waste gate solenoid valve
A-25 (7-B) Air flow sensor
A-26 (2-B) Front speed sensor (LH) <vehicles with

ABS>

A-28 (8-B) Control harness and front harness

combination