Miele KM 400, KM 402 Fryer, KM 408-1 Fitting instructions

Installation Instructions

KM 400 Electric Cooktop
KM 402 Fryer
KM 408-1 Contact Grill
KM 410 Electric Grill

To prevent accidents and
machine damage,
read the Operating Manual
before installation or use.

]ö

M.-Nr. 05 060 861

Contents

Contents

Warning and Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Safety distance above the appliances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Safety distance between the KM 410 and a venting hood. . . . . . . . . . . . . . . . . 4

Appliance dimensions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

KM 400 / KM 408-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

KM 402. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

KM 410. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Cutting out the countertop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Laying out the support bars and clamps. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Securing the support bars . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Wood or Corian countertops. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Granite countertops . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Securing the spring clamps. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Granite countertops . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Locking the appliance into place. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Electrical connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

2

Warning and Safety instructions

Warning and Safety instructions

Note to the installer:
Please leave this instruction book
with the consumer for the local elec­trical inspector’s use.

Installation

The minimum distances given in
these Installation Instructions must
be observed in order to ensure safe
operation. Failure to do so in­creases the risk of fire.

The countertop must be bonded with
heat resistant (212 °F/100 °C) adhesive
to prevent distortion or dissolving.

Deep fryers must not be installed next
to gas cooktops. Gas flames can ignite
splattering oil. A distance of at least
12" (305 mm) should be maintained be­tween these two appliances.

The cooktops should only be installed
as shown in Figs. 1 & 2, while mainten­ing the required safety distances
shown. Do not install the cooktop be­tween 2 tall cabinets as this is a fire ha­zard.

Fig. 1

recommended

Fig. 2

possible but not
recommended

= minimum distance

b

for:
KM 400, KM 402,
KM 408-1 = 2" (50 mm)
KM 410 =10" (250 mm)

Cooktops should not be installed
above a dishwasher, washer, dryer,
freezer or refrigerator. The heat gener­ated by cooktops could damage these
aplliances.

Fig. 3

not allowed

3

Warning and Safety instructions

Safety distance above the appliances

Fig. 4

As a general rule there must be at least
30 inches (760 mm) between the top of
the appliance and any cabinet above
it,

. If the cabinet manufacturer rec-

c

ommends a different distance, follow
that manufacturer’s recommendation.

When installing the cooktops under an
exhaust hood, always observe the mini­mum distances recommended by the
hood manufacturer.

Safety distance between the KM 410
and a venting hood

The minimum safety distance be­tween the KM 410 and the bottom
of a venting hood should be no less
than 26" (650 mm).

The filters of the venting hood should
be cleaned regularly.

Never leave the grill unattended when
in use.

If more than one appliance is in­stalled beneath a hood and they
have different mimimum safety dis­tances, the greater distance should
be adhered to.

All dimensions in this instruction book
are given in inch and mm.

Keep this instruction book in a safe
place and pass it on to any future
owner.

4

Appliance dimensions

KM 400 / KM 408-1

Appliance dimensions

Clamps

b

Please allow an additional 3/4"

c

(18 mm) depth below the cooktop for
clearance of the power supply cord.

Fig. 5

5