Miele CS1028LP, CS1028G Installation Manual

Operating and Installation Instructions

Gas Combiset CS 1028

To prevent accidents and appliance damage, read these instructions

before

installation or use.

en - US, CA

M.-Nr. 07 369 720

WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or death.

Do not store or use gasoline or other flammable

–

vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

–

ß Do not try to light any appliance. ß Do not touch any electrical switch. ß Do not use any phone in your building. ß Immediately call your gas supplier from a

neighbor’s phone. Follow the gas supplier’s instructions.

ß If you cannot reach your gas supplier, call the

fire department.

– Installation and service must be performed by a

qualified installer, service agency or the gas supplier. (In Massachusetts a licensed plumber / gas fitter)

–

Note to the installer: Please leave this instruction book with the consumer for the local electrical / gas inspector’s use.

Contents

IMPORTANT SAFETY INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Guide to the combiset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Burner ..........................................................10

Before using the combiset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12

Turning on and off / Regulating .......................................12

Using the cooktop during a power failure ...............................13

Pans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Safety features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Ignition Safety Control ..............................................15

Cleaning and care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Burner ..........................................................17

Frequently asked questions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Technical Service. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

IMPORTANT SAFETY INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Installation dimensions .............................................26

Cutout..........................................................27

Installation of multiple appliances .....................................28

Attach the spring clips and support bars ...............................31

Installing the appliance / appliances...................................33

Removing the appliance ............................................33

Sealing ..........................................................34

Tiled surfaces ....................................................34

Electrical connection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Gas connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Gas pressure regulator .............................................38

Nominal ratings ...................................................39

Converting to another type of gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

Help protect our environment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

IMPORTANT SAFETY INSTRUCTIONS

Children

WARNING- When using your gas appliance follow basic precautions, including the following:

This gas combiset conforms to all uniform safety codes and regulations.

Read all instructions before installation or use to prevent injury and appliance damage.

Keep these operating instructions in a safe place and pass them on to any future user.

SAVE THESE INSTRUCTIONS

Correct usage

Only use the gas combiset for

residential cooking, and for the purposes described in this manual. Other uses are not permitted and can be dangerous.

Children should not be left

unattended in an area where the appliance is in use. Never allow children to sit or stand on any part of the appliance. Caution: Do not store items of interest to children in cabinets above the appliance. Children climbing on the appliance to reach these items could be injured.

The appliance is hot during use and

remains so for some time after being switched off. Keep children away from the appliance.

Keep all pots and pans out of the

reach of children. Danger of burning or scalding.

Ensure that any packing material, is

disposed of safely and kept out of the reach of children. Danger of suffocation!

Persons who lack physical, sensory

or mental abilities, or experience with the appliance should not use it without supervision or instruction by a responsible person.

IMPORTANT SAFETY INSTRUCTIONS

Technical safety

Installation, repair and maintenance

work should be performed by a Miele authorized service technician. Work by unqualified persons could be dangerous and may void the warranty.

Before installing the combiset,

check for externally visible damage. Do not operate a damaged appliance. A damaged gas combiset is a hazard.

Before installation, make sure that

the voltage and frequency listed on the rating label correspond with the household electrical supply. This data must correspond to prevent injury and appliance damage. Consult a qualified electrician if in doubt.

Be certain your appliance is

properly installed and grounded by a qualified technician.

To guarantee the electrical safety of

this appliance, continuity must exist between the appliance and an effective grounding system. It is imperative that this basic safety requirement be met. If there is any doubt, have the electrical system of the house checked by a qualified electrician.

Install the appliance so that the

power cord and gas piping do not come into contact with any portion of the combiset which may become hot during use.

Do not use an extension cord to

connect this appliance to electricity. Extension cords do not guarantee the required safety of the appliance.

Do not operate the appliance until it

has been properly installed in the countertop.

Do not operate any appliance with a

damaged cord or plug, or if the appliance has been damaged in any manner. Contact Miele’s Technical Service Department.

Defective components should be

replaced by Miele original spare parts only. Only with these parts can the manufacturer guarantee the safety of the appliance.

Under no circumstance open the

outer casing of the appliance.

While the appliance is under

warranty repairs should only be performed by a Miele authorized service technician. Otherwise the warranty is void.

IMPORTANT SAFETY INSTRUCTIONS

Before servicing, turn off the gas

valve and disconnect the power supply by either removing the fuse, unplugging the unit or manually “tripping” the circuit breaker.

This equipment has not been

designed for maritime use or for use in mobile installations such as aircraft or recreational vehicles. However, under certain circumstances it may be possible for installation in these applications. Please contact the nearest Miele Dealer or the Miele Technical Service Department with specific requirements.

After connecting the appliance test

for leaks according to the installation instructions.

If there is any doubt concerning

installation contact Miele’s Technical Service Department.

Safety

The appliance is hot during use and

remains so for some time after being switched off. Be careful not to touch the appliance if it may still be hot.

Protect your hands with oven mitts

or potholders when using the appliance. Use only dry, heat resistant potholders. Moist or damp potholders used on hot surfaces can result in steam burns. Do not let the potholder touch the hot heating elements. Do not use towels or other bulky items near the appliance.

Be sure drafts do not blow

flammable material toward the flames or push the flames so that they extend beyond the edges of the pan.

Be aware of loose fitting or hanging

garments when operating the combiset, they may present a fire hazard.

Do not heat unopened containers.

Built-up pressure may cause the container to burst and result in injury.

WARNING - NEVER use this appliance as a space heater to heat or warm the room. Doing so may result in carbon monoxide poisoning and overheating.

Install the combiset in a room that

has sufficient ventilation.

This appliance must not be

operated outdoors.

Make sure all components of the

gas burner is assembled correctly before using the combiset.

IMPORTANT SAFETY INSTRUCTIONS

Do not use pans that extend past

the burner grate. Using larger pans may cause the flames to spread out and damage the surrounding countertop or other countertop appliances.

For safety and stability, do not use

pans with a bottom diameter smaller than the burner grate.

Only certain types of glass, ceramic

or other glazed cookware are suitable for use on a combiset without breaking due to the sudden temperature change.

Do not use containers made of

plastic or aluminum. They may melt at high temperatures.

The burner grates supplied with the

appliance must always be used. Never place a pan on the burner by itself.

Do not use aluminum foil to line any

part of the combiset.

For proper lighting and performance

of the burner, keep the igniter clean and dry.

Do not heat empty pots or pans,

they may be damaged.

Always position pan handles and

utensils inward so they do not extend over adjacent work areas, burner or the edge of the combiset.

Do not store items on the appliance

when not in use. Items could melt or catch fire from residual heat or if the appliance is turned on inadvertently.

Never cover the appliance with a

cloth. A fire may result.

Do not let cooking grease or other

flammable materials accumulate on the appliance.

Do not use a steam cleaner to clean

the appliance. Steam could penetrate electrical components and cause a short circuit.

Spills containing salt or sugar

should be removed immediately.

Do not leave the combiset

unattended while in use. Boil-overs cause smoking, and greasy spill-overs may ignite.

Do not use water on grease fires.

Smother any fire or flame, or use a dry chemical or foam-type extinguisher.

For safety reasons the flame should

be adjusted to be the same size as the bottom of the pan or smaller. Do not use small pans with high flame settings as the flames can climb the sides of the pan.

Ensure that the burner is always

covered with a pan.

Only use cooking utensils suitable

for combiset use.

Do not flambé under an exhaust

hood. Flames could be drawn up into the hood by the suction or the grease filters may ignite.

If there is a drawer directly

underneath the appliance without a wooden base in between, ensure that no aerosols, combustible liquids or other easily flammable materials are kept in it. If cutlery inserts are to be placed in the drawer, they must be made of a heat-resistant material.

IMPORTANT SAFETY INSTRUCTIONS

Make certain that the power cords of

small appliances do not come in contact with the appliance. The insulation of the cable could become damaged. Danger of electric shock!

In the event of damage or defect,

turn off the appliance immediately. Turn off the gas shut off valve and disconnect completely from the electrical supply. Contact the Miele Technical Service Department. Do not use the appliance until it has been repaired. Ensure power is not supplied to the appliance while repair work is carried out.

Before discarding an old appliance,

disconnect it from the gas and electrical supply, and cut off the power cord to prevent it from becoming a hazard.

SAVE THESE INSTRUCTIONS AND REVIEW THEM PERIODICALLY

a Burner grate

b Burner

Guide to the combiset

c Control knob

Guide to the combiset

Burner

d Burner cap

e Burner head

f Cover plate

g Ignitor

h Ignition safety control

(Thermocouple)

i Burner base

Before using the combiset

Cleaning the combiset

Before using for the first time clean the appliance as follows:

Remove any protective foil.

Wash the removable parts of the gas

burner in a mild solution of warm water and liquid dish soap.

Dry and reassemble the parts in the

correct order (see "Cleaning and care").

Wipe down the stainless steel

combiset with a suitable cleaner and dry thoroughly.

Metal components have a protective coating which may give off a slight odor the first time your new appliance is heated.

The harmless odor will dissipate after a short time and does not indicate a faulty connection or appliance defect.

Operation

Turning on and off / Regulating

The control knob is used to turn on the burner and to regulate the strength of the flame.

ß The gas supply is turned off

* Ignition setting

& Highest flame

/ Lowest flame

The knob must only be turned left to turn the appliance on and right to turn it off.

If the knob is :

- turned on without pressing it down first,

- turned clockwise to turn on, or

- turned counterclockwise to turn the combiset off,

parts of the combiset might get damaged. The manufacturer cannot be held responsible for these damages.

Turning on

To turn on the burner, press the

control knob down and turn it counterclockwise to the ignition position a to turn on.

When the flame ignites, keep the

control pressed in for 8-10 seconds, and then let go.

If the burner does not ignite or the flame goes out, turn the control knob to "ß". Try again after a few seconds.

If the burner still will not ignite after the second attempt, turn the control knob to "ß" and see "Frequently asked questions".

Adjust the knob to the desired setting.

Operation

Adjusting the flame

The burner can be variably adjusted between the lowest and highest flame by turning the control knob.

Since the outer portion of the flame is much hotter than the center, the flame should be set so that its tips do not spread beyond the sides of the pan. Flame tips which extend beyond the sides of the pan are hazardous.

Turning off

^ Turn the control clockwise to "ß".

This stops the flow of gas and the flame goes out.

Using the cooktop during a power failure

If there is an interruption to the electrical supply, the gas can be ignited using a match.

Press the control knob down and turn

it counterclockwise to the ignition position.

While holding down the knob, light

the gas at the burner with a match.

When the flame appears, keep the control knob pressed in for 8 - 10 seconds to allow the Ignition Safety Control to reach operating temperature.

Pans

Pan size

Set the combiset to a high flame

–

when using a large diameter pan and low flame when using a small diameter pan.

Generally, wide / shallow pans will

–

heat faster and cook more evenly than narrow / tall ones.

– Using oversized pans may cause the

flames to spread out and damage the surrounding countertop or other countertop appliances.

– Do not use small pans with high

flame settings, the flame can climb the sides of the pan.

– Pots with a smaller diameter than the

burner grates and pots that do not sit securely (without wobbling) are hazardous and should not be used.

Suitable pans

Unlike pans used on an electric combiset, the bases do not need to be even for good results.

Thick pan bases will give more even results, as hot spots are reduced due to better heat distribution.

Thin pan bases will conduct the heat faster but not as evenly as thick pan bases. Stir the food frequently to prevent burning.

You can use a wok without any additional rings, trivets, etc.

The burner grates supplied with the appliance must always be used. Never place a pan on the burner by itself.

+ 30 hidden pages