Masterbuilt 20150613 Owner's Manual

ASSEMBLY, CARE & USE MANUAL

WARNING & SAFETY INFORMATION

ELECTRIC PATIO GRILL

MODELS 20150112, 20150213, 20150513, 20150613, 20150713

THIS PRODUCT IS FOR OUTDOOR USE ONLY

Manual Code: 9815110001 052112-02SS

Approximate assembly time : 60 minutes

Tool needed for assembly: Phillips Head Screwdriver

Use only outdoors where it is

well ventilated.

Fuel, such as charcoal briquettes, wood or heat

pellets, are not to be used in the unit.

WARNINGWARNING

This manual contains important

information necessary for the proper

and safe use of this unit.

Read and follow all warnings

and instructions before using

grill and during use.

Keep this manual for future reference.

Failure to follow these warnings and instructions properly could result in personal injury or death.

GENERAL WARNINGS AND SAFETY INFORMATION

READ ALL INSTRUCTIONS

When using electrical appliances, basic safety precautions should always be followed including the following:

• Cannot be operated for more than

• Use GFI protected electrical outlet to reduce the risk of electrical shock.

• For outdoor use only. Do not operate in an enclosed area.

• Unit MUST be on the ground. Do not place unit on tables or counters. Do NOT move unit across uneven surfaces.

• Do not plug in electric grill until fully assembled and ready for use.

• Use only approved grounded electrical outlet.

• Do not use during an electrical storm.

• Do not expose electric grill to rain or water at anytime.

• To protect against electrical shock do not immerse cord, plug or control panel in water or other liquid.

• Do not operate any appliance with a damaged cord or plug, or after appliance malfunctions or has

3 hours.

been damaged in any manner. Contact Masterbuilt Customer Service for assistance at 1-800-489-1581.

• Keep a ﬁ re extinguisher accessible at all times while operating electric smoker.

• Do not let cord hang touch hot surfaces.

• Do not place on or near a hot gas or electric burner, or in a heated oven.

• Keep children and pets away from electric smoker at all times. Do not allow children to use electric smoker. Close supervision is necessary should children or pets be in area where electric smoker is being used.

• Fuel, such as charcoal briquettes, wood or heat pellets, are not to be used in electric grill.

• Never use electric grill as a heater (READ CARBON MONOXIDE HAZARD ON FRONT COVER).

• Use electric grill only on a level, stable surface to prevent tipping.

• Electric grill is HOT while in use and will remain HOT for a period of time afterwards. Use caution.

• Do not touch HOT surfaces.

• Do not allow anyone to conduct activities around electric grill during or following its use until the unit has cooled. Electric grill is HOT during operation and remains HOT for a period of time following use.

• The use of alcohol, prescription or non-prescription drugs may impair the user’s ability to properly assemble or safely operate electric smoker.

• Avoid bumping or impacting electric grill.

• Never move electric grill when in use. Allow electric grill to cool completely before moving or storing.

WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 2

GENERAL WARNINGS AND SAFETY INFORMATION

• Be careful when removing food from electric grill. All surfaces are HOT and may cause burns. Use protective gloves or long, sturdy cooking tools.

• Drip tray is only for the bottom of electric grill. Do not put drip tray on cooking grate this may damage electric grill.

• To disconnect, turn control panel “OFF” then remove plug from outlet.

• Unplug from outlet when not in use and before cleaning. Allow unit to cool completely before adding/removing grate, or drip tray.

• Dispose of cold ashes by placing them in aluminum foil, soaking with water and discarding in a non-combustible container.

• Do not store electric grill with HOT ashes inside unit. Store only when all surfaces are cold.

• Accessory attachments not supplied by Masterbuilt Manufacturing, Inc. are not recommended and may cause injury.

• The use of accessory attachments not recommended by the appliance manufacturer may cause injuries.

• Never use electric grill for anything other than its intended purpose. This unit is not for commercial use.

• Always use electric grill in accordance with all applicable local, state and federal ﬁ re codes.

• Longer detachable power-supply cords or extension cords are available and may be used if care is exercised in their use.

• If a longer detachable power-supply cord or extension cord is used: 1. The marked electrical rating of the cord set or extension cord should be at least as great as the electrical rating of the appliance; and 2. The cord should be arranged so that it will not drape over the counter top or tabletop where it can be pulled by children or tripped over intentionally.

• The extension cord must be a grounding -type 3-wire cord.

• Outdoor extension cords must be used with outdoor use products and are marked with sufﬁ x

“W” and with the statement “Suitable for Use with Outdoor Appliances.

• CAUTION - To reduce the risk of electric shock, keep extension cord connection dry and off the

ground.

• Do not clean this product with a water sprayer or the like.

• Keep hands, hair and face away from the element. Be careful of loose hair and clothing

during operation, they could catch fire.

• Never use glassware, plastic or ceramic cookware on this grill.

• Preheating grill is not necessary. If preheating is desired, open lid with caution.

• Minimum distance from side and back of appliance to walls or railing is 24 inches.

• Do not use unit near heat sensitive or combustible structures such as vinyl or wood siding.

WARNINGS & IMPORTANT SAFEGUARDS CONTINUED ON PAGE 3

GENERAL WARNINGS AND SAFETY INFORMATION

• Fatty foods (hamburgers,etc.) can have excess grease and cause ﬂ are ups. When cooking fatty

foods use a low setting with lid open.

• Clean internal base pan before each use. This will cut down on build-up and ﬂ are-ups.

• Do not expose electric grill to rain. Do not use around water or operate on wet surfaces. This

could cause an electric shock leading to injury and death.

• Be sure drip tray is clean before each use.

SAVE THESE INSTRUCTIONS

WARNING

COMBUSTION BY-PRODUCT PRODUCED WHEN USING THIS PRODUCT CONTAINS CHEMICALS

KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS,

OTHER REPRODUCTIVE HARM, OR CANCER.

THE MATERIALS USED IN THIS PRODUCT MAY CONTAIN LEAD A CHEMICAL KNOWN TO THE

STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS AND OTHER REPRODUCTIVE HARM.

STOP!

DO NOT RETURN TO RETAILER For Assembly Assistance, Missing or Damaged Parts

Call: MASTERBUILT Customer Service at 1-800-489-1581.

Please have Model Number and Serial Number available when calling.

These numbers are located on silver label on back of unit.

PARTS LIST

14f

14b

PART NO QTY DESCRIPTION PART NO QTY DESCRIPTION

1 1 Grill Lid 14b 1 Back Panel

2g 1 Temperature Gauge 15 2 Hub Cap 2b 1 Temperature Gauge Base 16 2 Wheel

3 1 Right Side Shelf 17 2 Foot 4 1 Heating Element 18* 2 Leg

5 1 Grill Base 19* 2 Wheel Leg 6 1 Left Side Shelf 20 1 Cooking Grate

7 1 Drip Tray 21 1 Warming Rack 8 1 Drip Tray Bracket 22 2 Seat 91Reﬂ ector Plate 23 1 Right Bottom Hinge

10 1 Controller 24 1 Left Bottom Hinge 11a 2 Front right/Back left Support 25 1 Left Lid Hinge 11b 2 Front left/Back right Support 26 1 Right Lid Hinge

12 1 Bottom Shelf 27 1 Handle

13 2 Side Panel 28 1 Logo Base

14f 1 Front Panel

*Legs are marked with stickers (FR-Front Right, FL-Front Left, BR-Back Right, BL-Back Left) to correspond easily with parts 11a and 11b during assembly Steps 3-5.

HARDWARE LIST

(A)

Thumb Screw

Qty: 2

(E)

M8x55

Phillips Head Screw

Qty:2

(I)

Flat Washer

Qty: 8

(B)

M6x35

Phillips Head Screw

Qty: 2

(F)

Bakelite Spacer

Qty: 2

(J)

Flat Washer

Qty: 5

PARTS LIST

(C)

34x25

Flat Washer

Qty: 4

(G)

M6x13

Phillips Head Screw

Qty: 40

(K)

Flat Washer

Qty: 2

(D)

M4x40

Phillips Head Screw

Qty: 2

(H)

M4x12

Phillips Head Screw

Qty: 3

(L)

M6x8

Phillips Head Screw

Qty: 4

PART NO REPLACEMENT PART PART NO REPLACEMENT PART

9915110002 Lid Kit - Blue 9915110016 Rear Left Leg Kit 9915110003 Base Kit - Blue 9915110017 Rear Right Leg Kit 9915110004 Lid Handle Kit 9915110018 Front Panel Kit 9915110005 Hinge Kit 9915110019 Back Panel Kit 9915110006 Right Side Shelf Kit 9915110020 Side Panel Kit 9915110007 Left Side Shelf Kit 9915110021 Bottom Shelf Kit 9915110008 Logo Plate Kit 9915110022 Wheel Kit 9915110009 Temperature Gauge Kit 9910090010 Element Kit 99151 10010 Drip Tray Kit 90151 10002 Foot 9915110011 Grill Seat Kit 9015110003 Warming Rack 9915110012 Front Left/Back Right Leg Kit 9015110004 Cooking Grate 9915110013 Front Right/Back Left Leg Kit 9015110005 Reﬂ ector Plate 9915110014 Front Left Leg Kit 9015110001 Grill Cover 9915110015 Front Right Leg Kit 9007090063 Analog Control w/ Power Cord 9015110006 Hub Cap 9915110023 Lid Kit - Red

9915110024 Lid Kit - Black 9915110025 Base Kit - Red 9915110026 Base Kit - Black 9915110001 Hardware Kit

9815110001 Instruction Manual

STOP!

DO NOT RETURN TO RETAILER For Assembly Assistance, Missing or Damaged Parts

Call: MASTERBUILT Customer Service at 1-800-489-1581.

Please have Model Number and Serial Number available when calling.

These numbers are located on silver label on back of unit.

+ 14 hidden pages