PRODUCT LITERATURE
W1996 Lennox Industries Inc.
Dallas, Texas
503,517M
9/98 Supersedes 8/96
G23
SERIES
GAS FURNACE
Litho U.S.A.
WARNING |
If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
Do not store or use gasoline or other flam8 mable vapors and liquids in the vicinity of this or any other appliance.
Installation and service must be performed by a qualified installer, service agency or the gas supplier.
WHAT TO DO IF YOU SMELL GAS:
DDo not try to light any appliance.
DExtinguish any open flames.
DDo not touch any electrical switch; do not use any phone in your building.
DImmediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.
DIf you cannot reach your gas supplier, call the fire de8 partment.
G23 Parts Identification
TOP CAP
VENT PIPE
CONNECTION
COMBUSTION AIR
BLOWER
IGNITION
CONTROL
UPPER ACCESS
PANEL
BURNERS
BLOWER
CONTROL BOARD
BLOWER ACCESS
PANEL
DURALOKTM HEAT
EXCHANGER
ASSEMBLY
COMBUSTION AIR
PROVING
(PRESSURE) SWITCH
CABINET
GAS
VALVE
GAS
MANIFOLD
|
BLOWER |
CONTROL BOX |
MOTOR |
|
FIGURE 1
WARNING
Product contains fiberglass wool.
Disturbing the insulation in this product during installation, maintenance, or repair will expose you to fiberglass wool dust. Breathing this may cause lung cancer. (Fiberglass wool is known to the State of California to cause cancer.)
Fiberglass wool may also cause respiratory, skin, and eye irritation.
To reduce exposure to this substance or for further information, consult material safety data sheets available from address shown below, or contact your supervisor.
Lennox Industries Inc.
P.O. Box 799900
Dallas, TX 75379-9900
WARNING
Do not set thermostat below 60_F (16_C) in heating mode. Setting thermostat below 60_F (16_C) re8 duces the number of heating cycles. Damage to the unit may occur that is not covered by the warranty.
WARNING
If overheating occurs or if gas supply fails to shut off, shut off the manual gas valve to the appliance before shutting off electrical supply.
Page 2