Lab-Line 700, 100IDE, 100JPN, 100-5JPN, 101 User manual

5/04

a OPERATION MANUAL

MANUAL NO 057-139-00

REV. K

ECN 19154

COMPACT, LOW

COST

LAB-LINEs

INCUBATORS

MODEL NO. 700, 100IDE, 100JPN, 100-5JPN, 101, 105, 106, 120, 120JPN, 120-5JPN, 121, 125, 126, 150, 150JPN, 152

3; Barnstead|nternational

<

Var tab

s Here

2555 Kerper Boulevard PO. Box 797

Dubuque. lewa 52001-0797 U.S.A Phone: [phone] or 800-553-0039 Fax. [phone]

E-Mail: mkt@ barnstead com www barnslnad.com

EAGLE OF CONTENTS E

SECTION TITLE

1introduction

2Description

3Specifications

‘4 Installation

5Operation

6Maintenance

7Replacement Parts Warranty

SECTION 1

	INTRODUCTION
THANK	YOU
for selecting Lab-Line Instruments for your equipment needs. For maximum value
and ease of start-up,
PLEASE	PROCEED AS FOLLOWS:

«Inspect the carton and contents for shipping damage. Notify the carrier

immediately

if damage

is found.

e

Use

the

Accessory

Checklist

when

unpacking

to

verify

that

the

complete

unit has

been

received.

Do

not discard packing

materials

until all is

accounted

for.

e

Read

this Operation

Manual

thoroughly

before

decicing

upon

an appropriate

location

for

the

unit:

you

will

want

to consider

the

availability

of

power

and

other

unit requirements, as well as user convenience.

e Insist that every operator of this unit becomes familiar with the Operation Section of this manual.

+Be sure to fill out the Warranty Registration Card and mail it in to Lab-Line

Instruments within seven (7) days after receiving the unit.

IF

after reading this manual you

should

have

any

difficulties

with

the installation

or

operation

instructions,

please

cail:

Lab-Line Customer Relations Department

(563)

556-2241

or

(800)

522-5463

ALL

RIGHT

RESERVED

The

information

contained

in

this

manual

is the

exclusive propeily

of

Lab-Line

Instruments,

Inc.. and

has been

pro-

vided soiely

to enable

the

users

of

the equipment described hereir to operate and maintain such equipment.

Any

other use of this information,

or

the

reproduction

or

transmission

of

all

or

any

portion of this manual without

prior

written

consent of the

manufacturer

is

expressly

prohibited

©

2004.

1 ab-Line

instruments,

Inc.

SECTION 2

DESCRIPTION

The Lab-Line compact. low cost incubators are useful for biochemical.

bacteriological and hematological studies. They provide a controlled

environment for

growing microorganisms,

as

well

as,

for

the

study

of

chick

and invertebrate

embryos.

All models have specially designed heaters

to eliminate the hazards of

open-wire internal heaters.

A pilot

light indicates

when

the heaters

are

activated.

Solid,

corrosion

resistant

aluminum

chamber

walls with

1-inch

(2.5cm) fibergiass insulation help to distribute heat evenly throughout the

chamber.

Powder coated.

durable,

heavy

gauge

steel

exteriors. make

the

units easy to clean and maintain.

A

bimetallic

thermostat

controls

temperature.

Models 105, 106, 125 and

126 have

an

acrylic

outer

door

but.

otherwise, provide the same performance as the

other

units.

Models

150,

150JPN and 152 are Educational

Incubators with

acrylic

outer doors.

These

units are intended for egg incubation and are not

to be

used

for

clinical

purposes.

LEFT-SIDE

VIEW:

DI

©

=

E

E

i

©

Е

LJ

|

LS

©

H

|

=

T

|

THERMOSTAT

n

#920-273-00

«THERMOS

#560-230-00

(KNOB)*

o E u

POWER	SWITCH	STATUS	LAMP
#440-359-00		#360-235-00		(LENS).
		#360-233-01		(LAMP	BASE)*
‘AS LISTED ON UPCOMING REPLACEMENT PARTS		LIST