Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 97-187. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
Corporation. Ranger II is a trademark of Invacare Corporation. Tash is a registered trademark of Tash International Inc.. Therafin is a registered trademark of
W/R/ Medical Electronics Co.. Bussman is a registered trademark of Cooper Industries. MIDI is a registered trademark of Littelfuse Inc.. Dynamic is a
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
NamePhone Numbers
registered trademark of Dynamic Controls Limited.
Form No.
97-187
1
Page 3
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
1004310Positioning Strap, Seat/Chest w/ Auto Style Push
Button Buckle
(Eyelet to Eyelet Length 48")
11A
1034625Positioning Strap, Seat/Chest w/ Auto Style Push
Button Buckle
(Eyelet to Eyelet Length 61")
11B
1034622Positioning Strap, Seat/Chest w/ Auto Style Push
Button Buckle
(Eyelet to Eyelet Length 69")
11C
1034744Positioning Strap, Seat/Chest w/ Hook and Loop
Style Buckle
(Eyelet to Eyelet Length 45")
11A
1034745Positioning Strap, Seat/Chest w/ Hook and Loop
Style Buckle
(Eyelet to Eyelet Length 61")
11B
See ChartBack Upholstery11D
See ChartSeat Upholstery-Nylon11D
See ChartSeat Upholstery-Vinyl11D
See ChartCarrying Pocket11D
See ChartAttaching Hardware11D
A - 16-18" Wide Chairs.
B - 20" Wide Chairs and all Captain Seats.
C - 22" Wide Chairs.
D - Not Shown
NOTE:
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See ChartSeat Upholstery-Nylon11A
See ChartSeat Upholstery-Vinyl11A
See ChartBack Upholstery11A
See ChartAttaching Hardware11A
See ChartCarrying Pocket11A
A - Not Shown
NOTE:
Positioning Straps
Form No.
97-187
24
To order call toll free 1-800-333-6900, or www.invacare.com
Page 26
Solid Folding Seats
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1013218Washer (#10 Flat)181
1016770Bracket, Seat122
1016771Hook, Seat123
7930360Screw, Phillips Pan Head (#10-32 x 11/16")2514
8881110378Solid Folding Seat w/Hdwr (16" W x 16" D) - Vinyl115A
8881110379Solid Folding Seat w/Hdwr (18" W x 16" D) - Vinyl115A
8881110372Solid Folding Seat w/Hdwr (20" W x 16" D) - Nylon115A
8881035936Solid Folding Seat w/ Hardware (20" W x 18" D),
Nylon
115A
See ChartSolid Seat Inserts11B
A - Specify upholstery color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Not Shown
NOTE:
Solid Seat Inserts
Chair
Width x Depth
Upholstery Type
- Nylon
Upholstery Type
- Vinyl
8881034648
8881052563
16" x 16"
See Note(s) ASee Note(s) A
8881034657
8881052564
16" x 17"
See Note(s) ASee Note(s) A
Solid Folding Seats and Inserts
NOTE: Solid Folding Seats measure two inches narrower than actual seat width.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
25
Page 27
Solid Folding Seats and Inserts
Solid Seat Inserts
Chair
Width x Depth
Upholstery Type
- Nylon
Upholstery Type
- Vinyl
8881034666
8881052565
16" x 18"
See Note(s) ASee Note(s) A
8881034650
8881052569
18" x 16"
See Note(s) ASee Note(s) A
8881034659
8881052570
18" x 17"
See Note(s) ASee Note(s) A
8881034668
8881052571
18" x 18"
See Note(s) ASee Note(s) A
8881034652
8881052575
20" x 16"
See Note(s) ASee Note(s) A
8881034661
8881052576
20" x 17"
See Note(s) ASee Note(s) A
8881034670
8881052577
20" x 18"
See Note(s) ASee Note(s) A
A - Specify upholstery color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options." NOTE:
NOTE: Solid Folding Seats measure two inches narrower than actual seat width.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
26
Page 28
Captain Seat Assembly - Before 9/1/02
NOTE: Low Back (L.B.) Captain Seat description changed to Extended Back (E.B.) Captain Seat as of
10/02/00. Captain Seats incorporate an assisted recline of approximately 80 - 114 degrees for extended
backs and 90 - 170 degrees for high back 18" wide models.
Form No.
97-187
27
To order call toll free 1-800-333-6900, or www.invacare.com
Page 29
Captain Seat Assembly - Before 9/1/02
Item #1 - Extended Back Backrest
Extended Back Backrest
(E.B.)
Grey
Fabric/Vinyl
All Grey
Vinyl
Brunswick Buff
All Tan Vinyl
N/AN/A
1071578
E.B.
Before 3/25/98
See Note(s) A
N/AN/A
1078997-NLA
E.B.
3/25/98 - 8/3/99
and Forward Folding
Before 5/12/00
See Note(s) B
N/AN/A
1090374-NLA
E.B.
After 8/3/99
and Forward Folding
After 5/11/00
See Note(s) C
1086109
1081285
N/A
E.B.
Before 7/22/99
See Note(s) BSee Note(s) B
1090376-NLA
1090375-NLA
N/A
E.B.
After 7/21/99
See Note(s) CSee Note(s) C
A - 9-29/64" Backrest Post Spacing.
B - 9" Backrest Post Spacing.
C - 4-3/4" Backrest/Headrest Post Spacing.
NOTE:
Item #2 - High Back Headrest
Headrest
Grey
Fabric/Vinyl
All Grey
Vinyl
Brunswick Buff
All Tan Vinyl
N/AN/A
1071576-NLA
Headrest, High Back
Before 8/16/99
See Note(s) D
N/AN/A
1090379-NLA
Headrest, High Back
After 8/15/99
See Note(s) C
N/A
1090380-NLA
N/AHeadrest, High Back
See Note(s) C
C - 4-3/4" Backrest/Headrest Post Spacing.
D - 4-23/32" Headrest Post Spacing.
NOTE:
NOTE: Low Back (L.B.) Captain Seat description changed to Extended Back (E.B.) Captain Seat as of
10/02/00. Captain Seats incorporate an assisted recline of approximately 80 - 114 degrees for extended
backs and 90 - 170 degrees for high back 18" wide models.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
28
Page 30
Captain Seat Assembly - Before 9/1/02
Item #3 - 18" Wide Extended Back Captain Seat
Captain Seat -
Extended Back
Grey
Fabric/Vinyl
All Grey
Vinyl
Brunswick Buff
All Tan Vinyl
N/AN/A
1091123-NLA
Before 8/4/99
w/Mounting Screws
See Note(s) E, F
N/AN/A
1090371-NLA
After 8/3/99
See Note(s) F, G
1086108-NLA
1081284-NLA
N/ABefore 7/22/99
See Note(s) FSee Note(s) F
1090373-NLA
1090372-NLA
N/AAfter 7/21/99
See Note(s) F, GSee Note(s) F, G
N/AN/A
1085104-NLA
and Forward Folding
Before 5/12/00
See Note(s) F
N/AN/A
1090370-NLA
and Forward Folding
After 5/11/00
See Note(s) F, G
E - After 8/3/99 #1079236 extended back captain seat with mounting screws was replaced by #1091123 due to change in the
backrest post spacing. New bracket head rest #1090374 must be ordered as well to match.
F - For Captain Seats marked NLA, use Captain Seats dated after 8/31/02 as replacements.
G - Backrest/Headrest post spacing changed. When replacing seat assemblies made before the date specified, a new style
backrest or headrest must be ordered as well to match.
NOTE:
NOTE: When converting between high back and extended back captain seats, the wiring harness will also need to be converted. See page
titled "Battery Charger and Harnesses".
Item #3 - 18" Wide High Back Captain Seat
Captain Seat -
High Back
Grey
Fabric/Vinyl
All Grey
Vinyl
Brunswick Buff
All Tan Vinyl
N/AN/A
1070456-NLA
18" Wide High Back
Before 8/16/99
See Note(s) H, F
N/AN/A
1091068-NLA
18" Wide High Back
After 8/15/99
See Note(s) G, F, H
N/A
1091069-NLA
N/A18" Wide High Back
See Note(s) F
F - For Captain Seats marked NLA, use Captain Seats dated after 8/31/02 as replacements.
G - Backrest/Headrest post spacing changed. When replacing seat assemblies made before the date specified, a new style
backrest or headrest must be ordered as well to match.
H - High back 18" wide captain seats includes all actuator attaching hardware (LESS) the limit switch sensor harness #1074983.
See page titled "Captain Seat Frame and Actuator Hardware".
NOTE:
NOTE: When converting between high back and extended back captain seats, the wiring harness will also need to be converted. See page
titled "Battery Charger and Harnesses".
NOTE: Low Back (L.B.) Captain Seat description changed to Extended Back (E.B.) Captain Seat as of
10/02/00. Captain Seats incorporate an assisted recline of approximately 80 - 114 degrees for extended
backs and 90 - 170 degrees for high back 18" wide models.
Form No.
97-187
29
To order call toll free 1-800-333-6900, or www.invacare.com
Page 31
Captain Seat Assembly - After 8/31/02
NOTE: Captain Seats recline approximately 90 - 114 degrees for semi recline backs and 90 - 170 degrees
for full recline back models. Adjustable depths are (16, 17, 18" deep for 18" wide seats). Recline release
levers are standard on the right side. Semi recline left side release levers can be ordered as a special with
a new captain seat. All full recline captain seats must be ordered as a "special order" to have the limit
switch sensor actuator hardware mounted on the right side.
Form No.
97-187
30
To order call toll free 1-800-333-6900, or www.invacare.com
Page 32
Captain Seat Assembly - After 8/31/02
Backrest/Headrest Extensions and Captain Seat Assemblies
Item NumberDescriptionAll Grey FabricAll Grey VinylAll Tan Vinyl
110696811084081106969
Backrest -
For Semi Recline
1
110696611084091106967
Headrest -
For Full Recline
2
110924811092421109254
18" Wide -
Semi Recline
with Backrest
3
110925111092451109257
18" Wide -
Full Recline
with Backrest
3
NOTE: When converting from a semi recline to a full recline captin seat, a limit switch sensor harness part # 1074983 must be ordered as
well. See page titled "Captain Seat Frame and Actuator Hardware.
NOTE: Actuator mounting hardware is not included with captain seat, see page titled, "Captain Seat Frame and Actuator Hardware."
NOTE: New seat mounting screws #1025713 in (4) are required when converting a captain seat available before 9/1/02 to a captain seat
available after 8/31/02.
NOTE: Captain Seats recline approximately 90 - 114 degrees for semi recline backs and 90 - 170 degrees
for full recline back models. Adjustable depths are (16, 17, 18" deep for 18" wide seats). Recline release
levers are standard on the right side. Semi recline left side release levers can be ordered as a special with
a new captain seat. All full recline captain seats must be ordered as a "special order" to have the limit
switch sensor actuator hardware mounted on the right side.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
31
Page 33
Captain Seat Frame and Actuator Hardware - Before 9/1/02
NOTE: Low Back (L.B.) Captain Seat description changed to Extended Back (E.B.) Captain Seat as of
10/02/00.
Form No.
97-187
32
To order call toll free 1-800-333-6900, or www.invacare.com
Page 34
Captain Seat Frame and Actuator Hardware - Before 9/1/02
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1037610Screw, Hex Head (1/4-20 x 1-5/8")121
1026900Washer (1/4 x 23/32 x 1/16")162
1071603Screw, Hex Head (M6 x 1" x 20MM)143C
1045267Screw, Hex Head (1/4-20 x 3/4")143A,D
1029501Plug Button, Black (1")124
7930333Locknut (1/4-20) 2515
1074115Seat Mounting Hardware, Extended Backs, 18"
1016289Washer, Caplugs (15/32" I.D. x 1-3/32" O.D.)1111
1076568Screw, Hex Head (7/16-20 x 1")1112
1016291Hub Cap, Black1113
1024001Sensor, Actuator Switch1114
16348X007Rivet Washer (1/8 x 3/8 x 1/16")1215
1074128Screw, Phillips Pan Head (#4-40 x 7/16")1216
7930322Screw, Hex Head (M8 x 1-1/4" x 20MM)25117
7930358Washer, Steel (5/16 x 3/4 x 1/16") 25118
1076394Bracket, Upper Limit Sensor Switch 1119
A - All vinyl extended back seats will use hardware noted for extended back models after 3/24/98.
B - Item number 23 is not included with a high back seat assembly.
C - Extended backs before 3/25/98 and All High Backs 18" Wide.
D - Extended backs after 3/24/98 and Forward Folding Seat 18" Wide.
E - Includes items 1-5.
NOTE:
NOTE: Low Back (L.B.) Captain Seat description changed to Extended Back (E.B.) Captain Seat as of
10/02/00.
Form No.
97-187
33
To order call toll free 1-800-333-6900, or www.invacare.com
Page 35
Captain Seat Frame and Actuator Hardware - After 8/31/02
Form No.
97-187
34
To order call toll free 1-800-333-6900, or www.invacare.com
Page 36
Captain Seat Frame and Actuator Hardware - After 8/31/02
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1037610Screw, Hex Head (1/4-20 x 1-5/8")121
1026900Washer (1/4 x 23/32 x 1/16")162
1025713Screw, Hex Head (1/4-20 x 1")143
1029501Plug Button, Black (1")124
7930333Locknut (1/4-20) 2515
1070751Frame, Seat116
1071602Pin, Anchor (Captain Seat)147
1008525Washer, Internal Tooth Lock (#4-40)148
7930339Screw, Phillips Pan Head (#4-40 x 3/8") 2549
B - Item 12 and 13 is not included with a full recline captain seat assembly.
NOTE:
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
35
Page 37
Arms, Adjustable Height Removable
Sling Seat Only
Form No.
97-187
36
To order call toll free 1-800-333-6900, or www.invacare.com
Page 38
Arms, Adjustable Height Removable
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
8881015932Arm Pad, Vinyl, Full Length (14" L x 2" W) - Right111A
8881015933Arm Pad, Vinyl, Full Length (14" L x 2" W) - Left111A
1117328Arm Pad, Full Length, Urethane Waterfall with
Screws, Black
(13" L x 2-5/8" W)
111C,F
1110818Arm Pads, Full Length, Urethane Waterfall
with Screws, Black (13" L x 2-5/8" W) (Pair)
211
8881011811Arm Pad, Vinyl, Desk Length (9" L x 2" W)111A
1117327Arm Pad, Desk Length, Urethane Waterfall with
Screws, Black
(9" L x 2-5/8" W)
111C,F
1110817Arm Pads, Desk Length, Urethane Waterfall with
Screws, Black (9" L x 2-5/8" W) (Pair)
211
1055949Screws, Phillips Pan Head (#10-32 x 1-1/8") 212
1094270Screw, Phillips Pan Head (#10-32 x 1-1/4") (Pair)212D
1071253Arm Top, Adjustable Height with Plug Buttons - Full
Length (Black)
113
1070859Arm Tube, Upper with Plug Buttons (Black) - Desk
Length
113
1027095Plug Button, Black (7/8")124
1065936Plug, Pivot125
47471X074Spring, Arm Lock116
1028594Pin, Arm Lock117
1090768Kit, Lock Handle w/Rivets (both LT & RT side)218
1067734Plug Button, Black (5/8")129
1028645Rivet1610
A - As of 1/3/02 upholstered waterfall armpads were replaced with black urethane waterfall armpads. Order in pairs for chairs
manufactured before 1/3/02.
B - Includes items 2, 4, 5, 6, 10, and 13.
C - Includes items 3, 11, and 12.
D - Includes 7, 8, and 9.
NOTE:
18" Wide Models
Form No.
97-187
41
To order call toll free 1-800-333-6900, or www.invacare.com
Page 43
Oxygen Holder Assembly Kit - Before 4/15/03
Captain Seat, Low Back Models Only
Form No.
97-187
42
To order call toll free 1-800-333-6900, or www.invacare.com
Page 44
Oxygen Holder Assembly Kit - Before 4/15/03
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1080865Pin, Oxygen Holder121A
1035614Plug Button, Black (5/8")112
1080866Decal, Oxygen Warning - English113
1027684Knob, Clamping (Black)124
1086780Package, Protective Caps1025
1073159Pad, Non-Skid116
1080872Strap with Buckle 117
1083052Carton, Shipper118
2000454Bag, Poly (33" W x 39" L)119
1080869Instruction Sheet, Oxygen Holder1110
1080870-NLAOxygen Holder Assembly with Instruction Sheet1111B,C
A - Oxygen holder pins are to be used when backrest is absent.
B - Includes items 1-10.
C - Due to product improvement, see oxygen holder assemblies dated after 4/14/03 that will accommodate both (exposed and
non-exposed) captain seat hinge assemblies. Special orders are no longer needed for exposed hinge assembly models.
NOTE:
Captain Seat, Low Back Models Only
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
43
Page 45
Oxygen Holder Assembly Kit - After 4/14/03
All Captain Seat Models
Form No.
97-187
44
To order call toll free 1-800-333-6900, or www.invacare.com
Page 46
Oxygen Holder Assembly Kit - After 4/14/03
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1116952Oxygen Holder Assembly Kit111A
1116956Assembly, Oxygen Holder (D or E Tanks)111B
1055304Screw, Socket Button Head (1/4-28 x 5/8")132
1025765Locknut (1/4-28)133
1028486Locknut, Low Profile (3/8-16)124
1118889Washer, Steel (3/8 x 7/8 x 1/16")165
1116954Nut, Hex (3/8-16)126
1118888Screw, Hex Head (3/8-16 x 1-1/4")127
1116953Bracket, Oxygen Holder118
1116948Oxygen Holder119C
1080866Decal, Oxygen Warning - English1110
1116950Pad, Non-Skid1111
1116945Spring, Oxygen Holder1112
1072319Screw, Socket Button Head (#10-32 x 1/2")1113
1025735Locknut (#10-32)1114
1116957Instruction Sheet, Oxygen Holder 1115
1021866Bag, Poly (15" Wide x 26" Long)1116
1063960Carton1117
A - For seats with an INTERNAL (Non-Visible) hinge assembly and includes items 2-17.
B - For seats with an EXTERNAL (Visible) hinge assembly and includes items 9-17.
C - Includes items 10-14.
NOTE:
All Captain Seat Models
Form No.
97-187
45
To order call toll free 1-800-333-6900, or www.invacare.com
Page 47
Oxygen Holder Assembly Kit
Sling Seat
Form No.
97-187
46
To order call toll free 1-800-333-6900, or www.invacare.com
Page 48
Oxygen Holder Assembly Kit
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1098857Oxygen Holder, Assembly Kit 111A
1098333Instruction Sheet, Oxygen Holder112
1021148Bag, Poly Zip-Lip (6" Wide x 8-3/4" Long)113
See NoteSee Footnote114B
1021866Bag, Poly (15" Wide x 26" Long)115
1097276Carton, Shipper116
1096839Screw, Hex Head (1/4-20 x 2-1/4")117
1096838Screw, Hex Head (1/4-20 x 2")118
7930333Locknut (1/4-20) 2519
1027684Knob, Clamping (Black)1410
1080866Decal, Oxygen Warning - English1111
1072002Pad, Non Skid1112
A - Includes items 2-6 and 7-9.
B - Oxygen Holder - See item 1.
NOTE:
Sling Seat
Form No.
97-187
47
To order call toll free 1-800-333-6900, or www.invacare.com
Page 49
Rear Casters and Hardware
Form No.
97-187
48
To order call toll free 1-800-333-6900, or www.invacare.com
Page 50
Rear Casters and Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1056739Cap, Head Tube111
1028550Locknut (5/8-18)112
1041444Washer (5/8 x 1-5/16 x 1/8")113
1057949Fork Stem Hardware114F
8881071460Fork and Stem - 6" Casters115A
8881071600Caster Forks, Shock Fork (6")115A
8881058562Caster Forks, Standard Fork (8") 115A,B
8881081119Caster Fork, Standard Fork (8")115A,C
1025726Screw, Hex Head (7/16-20 x 3-1/4")116G
1058744Screw, Hex Head (7/16-20 x 3-1/2")116H
7930329Washer, Steel (15/32 x 5/8 x 3/64")2517
7930331Locknut (7/16-20")2518
1042489Caster Axle Hardware (1 Pair)219E,G
1058890Hardware, Caster, Shock Fork (Pair)219E,H
1072014-NLAWheel with Bearings - Semi Pneumatic (6" x 2")1110I
1115179Wheel with Bearings, 6 x 2" Urethane Deep Profile1110J
1122066Wheels with Bearings, 6 x 2" Urethane Deep Profile2110J
1070811Wheel/Caster, Semi-Pneumatic with Bearings
(8 x 1-3/4")
1110
1002002Wheel with Bearings - Pneumatic (8 x 2")1110
1006049Bearing (7/16")1211
1020592Spacer, Bearing (7/16 x 5/8 x 1-3/4")1112
40176X034Tire, Pneumatic (8" x 2") 1113
1034942Tube, Pneumatic Inner (8" x 2")1114
40176X010Tire Pump11D
A - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Order caster forks in pairs for chairs manufactured before 7/1/98.
C - This fork must be used with chair serial numbers 98F39748 through 98F39877 only.
D - Not Shown.
E - Includes items 6, 7 and 8.
F - Includes items 1, 2 and 3.
G - Standard Forks 6" & 8".
H - Shock Fork 6".
I - Service part No Longer Available 8/15/03. Due to product improvement, order (pair) part number 1122066 dated after
8/14/03 so each side matches. The deep profile caster has 2 tread grooves w/ round corners instead of 4 tread grooves w/
square corners.
J - Service part after 8/14/03
NOTE:
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
49
Page 51
Front Stabilizer Assembly
Before 3/1/2000
NOTE: "New Style" front stabilizer can be assembled to chairs made before 3/1/2000. See conversion kit
before 3/1/2000 on Front Stabilizer with Adjustable Flip-Up Footboard Conversion Kits page.
Form No.
97-187
50
To order call toll free 1-800-333-6900, or www.invacare.com
Page 52
Front Stabilizer Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1028514Screw, Hex Head (5/16-24 x 1-1/2")111
1025764Screw, Hex Head (5/16-24 x 2-1/4")152
1071487Washer, Nylon (23/64 x 1-15/64 x 7/64")123
1071506Spacer (5/16 x 9/16 x 1-33/64)124
1026102Spacer (5/16 x 15/32 x 1/4")125
7930330Locknut (5/16-24)2516
1071507Suspension Arm Plate127
1071528Stabilizer118G
1090135Stabilizer118F
1090396Wheel, Urethane 6" (Light Grey)119C
1071549Hardware, Stabilizer Attaching 1110A,D
1074116Hardware, Stabilizer Attaching, One Piece
Footboard
1110A,B,E
A - Item number 8 and 9 not included.
B - Attaching hardware comes packaged with (5) locknuts, #7930330, used for one piece footboards.
C - Wheel color changed from dark grey to light grey as of 7/28/99. Order in pairs to match for chairs manufactured before
7/28/99.
D - Includes items 1-7.
E - Includes items 2-7.
F - 6/30/99 thru 2/29/00.
G - Before 6/30/99.
NOTE:
Before 3/1/2000
NOTE: "New Style" front stabilizer can be assembled to chairs made before 3/1/2000. See conversion kit
before 3/1/2000 on Front Stabilizer with Adjustable Flip-Up Footboard Conversion Kits page.
Form No.
97-187
51
To order call toll free 1-800-333-6900, or www.invacare.com
Page 53
Front Stabilizer Assembly
After 2/29/2000
NOTE: When converting front stabilizer assemblies made before 3/1/2000, consider the following:
1) When a chair was ordered with an adjustable flip-up footboard before 3/1/2000, the stabilizer and
footboard assemblies must be converted. See Front Stabilizer with Adjustable Flip-Up Footboard
Conversion Kits page.
2) When a chair was ordered with a 14" wheel option before 3/1/2000, new side frames will be needed to
accommodate the stabilizers 14" wheel positioning location.
Form No.
97-187
52
To order call toll free 1-800-333-6900, or www.invacare.com
Page 54
Front Stabilizer Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1028514Screw, Hex Head (5/16-24 x 1-1/2")111
1094630Spring, Dual Compression Column Assembly112
1025764Screw, Hex Head (5/16-24 x 2-1/4")123
40117X006Bearing (5/8")124
1094616Swing Arm with Bearings, Right115
1094617Swing Arm with Bearings, Left115
7930330Locknut (5/16-24)2516
1071487Washer, Nylon (23/64 x 1-15/64 x 7/64")127
1094621Stabilizer Assembly, Right118A,D
1094622Stabilizer Assembly, Left118A,D
1094624Stabilizer Assembly, One Piece Footboard, Right118A,E
1094625Stabilizer Assembly, One Piece Footboard, Left118A,E
1056739Cap, Head Tube119
1028550Locknut (5/8-18)1110
1041444Washer (5/8 x 1-5/16 x 1/8")1111
1057949Fork Stem Hardware1112G
1094607Fork Assembly (7")1113
7930331Locknut (7/16-20")25114
7930329Washer, Steel (15/32 x 5/8 x 3/64")25115
1025726Screw, Hex Head (7/16-20 x 3-1/4")1116
1042489Caster Axle Hardware (1 Pair)2117F
1094620Wheel with Bearings (7" x 2")1118H
1094618Tire, Urethane (7" x 2" )1119
10628452 Piece Rim with Hardware1120
1006057Spacer, Bearing (7/16 x 5/8 x 1-3/4)1121
1006049Bearing (7/16")1222
1095097Front Stabilizer Assembly Kit1123B
1095096Instruction Sheet, Front Stabilizer Assembly Kit11C
A - Item number 2 not included.
B - Includes items 2, 8, 12, 13, 17-22 and Instruction sheet.
C - Not Shown.
D - Includes items 1 and 3-7.
E - Inlcudes items 3-7.
F - Includes items 14-16.
G - Includes items 9-11.
H - Includes items 19-22.
NOTE:
After 2/29/2000
NOTE: When converting front stabilizer assemblies made before 3/1/2000, consider the following:
1) When a chair was ordered with an adjustable flip-up footboard before 3/1/2000, the stabilizer and
footboard assemblies must be converted. See Front Stabilizer with Adjustable Flip-Up Footboard
Conversion Kits page.
2) When a chair was ordered with a 14" wheel option before 3/1/2000, new side frames will be needed to
accommodate the stabilizers 14" wheel positioning location.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
53
Page 55
16" Wide Chairs - #1095098
Part NumberDescriptionQuantity
1
Front Stabilizer with
Adj. Flip-Up Footboard
Conversion Kit For 16" Wide
1095098
See Note(s) A
1
Stabilizer Assembly,
One Piece Footboard, Right
1094624
1
Stabilizer Assembly,
One Piece Footboard, Left
1094625
2Fork Assembly (7")1094607
2Wheel with Bearings (7" x 2")1094620
2Caster Hardware1042489
2Fork Attaching Hardware1057949
2
Spring, Dual
Column Assembly
1094630
1
Instruction Sheet,
Front Stabilizer
1095096
1
Footboard Mounting
Hardware (Pair)
1094628
1
Footboard Hardware
(Pair)
1094629
1
Footboard, Black
16" Wide Chairs
1097175
1
Instruction Sheet,
Footboard Assembly
1095125
A - Includes all items listed below NOTE:
Front Stabilizer with Adjustalbe Flip-Up
Footboard Conversion Kits
For Chairs Made Before 3/1/2000
To order call toll free 1-800-333-6900, or www.invacare.com
See Note(s) ASee Note(s) A
A - Sold in pairs only
B - No Longer Available. Order the long cap Motor/ Gearbox Assembly part numbers 1071593 and 1071594 in pairs.
NOTE:
NOTE: Light Duty, 250-S models use long cap motors.
NOTE: See page for 4-Pole Motors with brake levers for chairs made after 3/14/99.
NOTE: MWD-R motor/gearbox is also used as a RWD-L motor/gearbox and MWD-L motor/gearbox is used as a RWD-R. The part numbers
are already switched around respectively for this MWD page.
Drive Wheel, 2 Pole Motor and Gearboxes - (Items 6-32)
Item
Number
Description
Ranger II MWD
W.S.T. w/Brake Lever
(Before 3/15/99)
Ranger II MWD
Basic (Long Cap)
Ranger II MWD
Basic (Short)
1044044561-0051064336
Brushes
w/Cap (Pair)
6
1050305N/A1050305
Screw, Phillips
Pan Head
(4-40 x 1/4")
7
N/AN/A
5165204-NLA
Coupling w/ Cup (1"
Diameter)
8
See Note(s) F
N/AN/A
50000X007
Coupling w/ Cup
(1-5/16" Diameter)
8
See Note(s) G
N/AN/A
50000X341-NLA
Spacer
(5/16 x 7/16 x 7/32")
9
See Note(s) A
N/AN/A1043594
Screw, Socket Head
(1/4-20 x 1-1/8")
10
Drive Wheel
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
58
Page 60
Motor, 2-Pole, Gearboxes and
Drive Wheel, 2 Pole Motor and Gearboxes - (Items 6-32)
To order call toll free 1-800-333-6900, or www.invacare.com
59
Page 61
Motor, 2-Pole, Gearboxes and
Drive Wheel, 2 Pole Motor and Gearboxes - (Items 6-32)
Item
Number
Description
Ranger II MWD
W.S.T. w/Brake Lever
(Before 3/15/99)
Ranger II MWD
Basic (Long Cap)
Ranger II MWD
Basic (Short)
102126010212601021260
Cable Tie
(5-5/8" Long)
30
1074974-NLA1074974-NLA1074974-NLA
Shroud Cover, Black
Drive Wheel
31
102326410232641023264Key32
A - Spacer not needed after 6/30/98
B - Drive Wheel comes with a locking tab and instruction sheet
C - As of 10/20/99 the "Solid" Flat Free Insert was replaced with a "Foam Fill" process. When a Flat Free Insert is requested, a
complete wheel must be ordered
D - Weight Shifting Tilt takes a quantity of 2 per side for item 29
E - Short end of clutch lever was lengthened form 2" to 2-3/4" long as of 12/11/00. Replace in pairs for chairs made before 12/11/00
F - Coupling with Cup for chairs manufactured before 11/12/01 - Use part # 50000X007 as a direct replacement part.
G - After 11/11/01 Coupling with Cup was resized from approximately 1" to 1-5/16" diameter and can be used as a direct
replacement for part number 5165204
NOTE:
Drive Wheel
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
60
Page 62
Motor, 4-Pole, Gearboxes and Drive Wheel
Form No.
97-187
61
To order call toll free 1-800-333-6900, or www.invacare.com
To order call toll free 1-800-333-6900, or www.invacare.com
62
Page 64
Motor, 4-Pole, Gearboxes and Drive Wheel
Item
Number
Description
Ranger II M.W.D. and
W.S.T. w/ Brake Lever
(After 3/14/99)
1101725
Plastic Tip
(After 10/28/01)
10
1082985Slotted Plate11
1064177
Drive Wheel with Foam Fill
(12-1/2")
12
See Note(s) A
1064178
Drive Wheel, Pneumatic
(12-1/2")
12
See Note(s) A
1011524
Tire
(12-1/2" x 2-1/4")
13
1073936-NLA
Flat Free Insert14
See Note(s) B
1011525
Tube
(12-1/2" x 2-1/4")
15
1023264Key16
1023262
Washer
(11/32 x 13/16 x 1/8")
17
1064179
Washer, Locking Tab
(Pair)
18
7930322
Screw, Hex Head
(M8 x 1-1/4 x 20MM) (Pkg. of 25)
19
1074974-NLA
Shroud Cover Black,
Drive Wheel
20
1071505
Screw, Socket Head
(M6 x 20MM)
21
1071504
Screw, Socket Head
(M6 x 35MM)
22
See Note(s) C
1021260
Cable Tie
(5-5/8" Long)
23
A - Drive wheel comes with a locking tab and instruction sheet.
B - As of 10/20/99, the "solid" flat free insert was replaced by a "foam fill" process. When a Flat Free Insert is requested, a
complete wheel must be ordered.
C - Weight Shifting Tilt takes only 2 per side for item 22.
D - Coupling with Cup for chairs manufactured before 11/12/01 - Use part # 50000X007 as a direct replacement part.
E - After 11/11/01 Coupling with Cup was resized from approximately 1" to 1-5/16" diameter and can be used as a direct
replacement for part number 5165204
F - When a new gearbox or mounting screws are ordered, (2 ea.) metric and (2 ea.) non-metric screws (item 9) must be ordered.
Invacare Corp. utilizes alternate suppliers for this part number.
G - As of May 2008, the Metal Motor End Cap will be replaced with a Composite Motor End Cap. The change does not affect form,
fit, function or aesthetics.
NOTE:
NOTE: See page for 2-Pole Motors with brake levers for chairs made before 3/15/99.
NOTE: MWD-R motor/gearbox is also used as a RWD-L motor/gearbox and MWD-L motor/gearbox is used as a RWD-R. The part numbers
are already switched around respectively for this MWD page.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
63
Page 65
Drive Wheel (14" x 3") and Hub Mount
Optional on Chair As Of 10/15/99
Form No.
97-187
64
To order call toll free 1-800-333-6900, or www.invacare.com
Page 66
Drive Wheel (14" x 3") and Hub Mount
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1090649Assembly, Drive Wheel, Pneumatic (14" x 3")111
1090650Drive Wheel Assembly w/ Flat Free Insert (14" x 3")111
1101754Tire with Flat Free (14" x 3")112
1039652Tire, Pneumatic (14" x 3")113
1039651Tube (14" x 3")114
1090651Rim, 8" with Hardware (14 x 3" Wheel)115A
7930322Screw, Hex Head (M8 x 1-1/4" x 20MM)2517
1064179Kit, Locking Tab Washers with Instruction Sheet228
1023262Washer (11/32 x 13/16 x 1/8")119
1024444Locknut (5/16-24)1410
1086681-NLAHub, Wheel (14" x 3")1111
1023264Key (6 MM x 6MM x 40 MM)1112
A - Hardware consists of: 8 ea. Screw, Hex Head Cap (1/4-20 x 3/4"); 8 ea. Locknut, High Profile (1/4-20).
B - Includes items 7-12 and instruction sheet.
NOTE:
Optional on Chair As Of 10/15/99
Form No.
97-187
65
To order call toll free 1-800-333-6900, or www.invacare.com
Page 67
Battery Boxes and Trays
NOTE: Light Duty, 250-S Models use UI batteries with 22NF battery boxes.
Form No.
97-187
66
To order call toll free 1-800-333-6900, or www.invacare.com
Page 68
Battery Boxes and Trays
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1097007Battery Box Assembly, Rear (22NF)121G
1097003Battery Box Top, Rear (22NF)122A,B,G
1057944Battery Box Bottom with Strap123H
1057954Battery Strap123
1041433Pin, Handle123
1071532Battery Tray Assembly with Hardware114I
1071490Tray with Strap and Buckle125
1025752Screw, Hex Head (1/4-20 x 1-1/2")146
1071566Pin, Tray147
15680X012Collar, Anti-Rattle (7/8")148
7930333Locknut (1/4-20) 2519
1071531Tray Support1110
1021406Screw, Hex Head (1/4-20 x 1-1/4") 1411
1074127Decal, Tray1112
1071543Bracket, Tray1213
1071505Screw, Socket Head Cap with Patch (M6 x 20MM)1314
1071504Screw, Socket Head Cap with Patch (M6 x 35MM)1315J
1079193Battery Tray with Strap, Weight Shifting Tilt1116
A - As of 11/5/99 the battery harness fuse changed from Bussman 60 AMP to a MIDI 80 AMP fuse. This battery box top is
compatible for all chairs manufactured before 11/5/99 and must be ordered whenever a replacement Bussman 60 AMP
fuse is requested.
B - It is recommended that new terminal hardware be ordered when a new battery box top is ordered.
C - Hardware includes small battery terminal caps (gray and orange), 1/4-20 x 7/8" hex flange screws, 1/4-20 hex flange nuts,
cable ties, locking tab washers and instruction sheet for two batteries.
D - Hardware includes battery clamps, battery clamp caps (red and black), small battery terminal caps (red and black), 1/4-20
x 7/8" hex flange screws, 1/4-20 hex flange nuts, cable ties and locking tab washers for two batteries.
E - Not Shown.
F - After 11/4/99 - Dual Battery Box or After 11/9/00 - Single Battery Box.
G - 22NF and UI 250-S Models.
H - #1057944 includes: (2) each #1057954 Battery Strap and (2) each #1041433 Handle Pin.
I - Includes items 5-13.
J - (3) each required for Non-Weight Shifting Tilt and (2) each required for Weight Shifting Tilt.
K - 250-S Models.
NOTE:
NOTE: Light Duty, 250-S Models use UI batteries with 22NF battery boxes.
67
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
Page 69
Battery Charger and Harnesses
Light Duty, 250-S models use a 4 amp. battery charger, #1061411.
Form No.
97-187
68
To order call toll free 1-800-333-6900, or www.invacare.com
Page 70
Battery Charger and Harnesses
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1053834Harness, Wiring, Standard111H
1070590Harness, Wiring111I
1039773Screw, Phillips Pan Head (#6-32 x 1-1/8")142J
1011980Screw, Phillips Pan Head (#6-32 x 3/4")123
1061323Washer, Nylon (11/64 x 1/2 x 1/8") 144
P0870X050Nut, Keps (#6-32)125
P0870X000Nut, Hex Keps (#4-40)126
7930318Screw, Phillips Pan Head (#4-40 x 1/2")2517
1083929Cable, Charger Extension (24" Long Round Plug)1114
1089627Cord, AC Power Line 115vac (2-prong off-board
11'6"L)
1115
1090357Wrap, Slit Wire Harness (1/2" O.D.) (36" Long Cut
To Length)
1116C
1098892Fuse, 15 Amp. (Buss ATC-15)1217E
1090117Fuse, 15 Amp. (Buss Mini ATM-15)1217K
1095502Package, Cable Ties (11-1/2" Long)101D,F
A - #1070573 was replaced with #1076390 and serves as a direct replacement for low back captain seats and sling seats with
shrouds for chairs manufactured before 7/1/99.
B - On 7/18/01 Lester 8 amp. battery charger was reinstated.
C - Plastic wire replaced mesh fabric and heat shrink 9/1/99. Part #1090357 can be used for chairs manufactured before
9/1/99 as well.
D - Not Shown.
E - Before 4/1/03. Charger extension cable requires 1 fuse and wire harness requires 2 fuses
F - Package of 10.
G - Light Duty, 250-S Models Only.
H - Low Back Captain Seat, Sling Seat with Shrouds and Weight Shifting Tilt.
I - High Back Captain Seat.
J - (4) each Weight Shifting Tilt; (2) each Non-Weight Shifting Tilt.
K - After 3/31/03. Charger extension cable requires 2 fuses and wire harness requires 2 fuses
L - CTE 8 Amp. charger replaced the obsoleted 4 Amp. charger as of 4/1/04.
M - CTE charger introduced 4/1/04. Used on Gel Cell or AGM (Absorbed Glass Mat) batteries. For wet cell batteries refer to
the 8 amp. Lester charger.
M1 - CTE charger looks exactly the same as Dynamic’s charger except for the company name that is silk screened on the
narrow side panel, where the charger plug is (hard wired) attached. Serial number starts with 04A00000001.
NOTE:
Light Duty, 250-S models use a 4 amp. battery charger, #1061411.
69
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
Page 71
Shroud Covers - Before 3/1/00
Form No.
97-187
70
To order call toll free 1-800-333-6900, or www.invacare.com
Page 72
Shroud Covers - Before 3/1/00
Item #'s 1-5 Shroud Covers Before 3/1/00
Item
Number
Candy Apple
Red
Description
Bright Plum
Metallic
Bright Blue
Metallic
Bright Silver
Metallic
Blue Green
Chameleon
1085094
1074944
1074945
1074943
1074942
Side Panel
(Captain)
- Right
1
See Note(s) B, DSee Note(s) B, DSee Note(s) B, DSee Note(s) B, DSee Note(s) B, D
1085095
1074948
1074949
1074947-NLA
1074946
Side Panel
(Captain)
- Left
1
See Note(s) B, D See Note(s) A, D, B See Note(s) B, DSee Note(s) B, DSee Note(s) B, D
1085092
1074977-NLA
1074978
1074976
1074975
Side Panel
(Sling Seat)
- Right
1
See Note(s) B, D See Note(s) A, D, B See Note(s) B, DSee Note(s) B, D See Note(s) A, B, D
1085093
1074981
1074982
1074980
1074979
Side Panel
(Sling Seat)
- Left
1
See Note(s) B, ESee Note(s) B, ESee Note(s) B, ESee Note(s) B, E See Note(s) B, D, E
1085088
1074972-NLA
1074973
1074971
1074970-NLA
Battery Cover
- 16" Wide
2
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C, ASee Note(s) C
1085087
1074968
1074969
1074967
1074966-NLA
Battery Cover
- 18" Wide
2
See Note(s) A, CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1085086-NLA
1074964
1074965
1074963-NLA
1074962
Battery Cover
- 20" Wide
2
See Note(s) CSee Note(s) ASee Note(s) CSee Note(s) CSee Note(s) C
1085091
1074960
1074961-NLA
1074959
1074958-NLA
Trunk Lid
- 16" Wide
3
See Note(s) A, CSee Note(s) CSee Note(s) A, CSee Note(s) CSee Note(s) C
1085090
1074956
1074957
1074955
1074954
Trunk Lid
- 18" Wide
3
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1085089
1074952
1074953
1074951
1074950-NLA
Trunk Lid
- 20" Wide
3
See Note(s) A, CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1070562
1070562
1070562
1070562
1070562
Rear Storage
Compartment,
- 16" Wide
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1070561
1070561
1070561
1070561
1070561
Rear Storage
Compartment,
- 18" Wide
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1070560
1070560
1070560
1070560
1070560
Rear Storage
Compartment,
- 20" W
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
10716551071655107165510716551071655
Storage Shelf,
Rear
5
A - Shrouds made before 3/1/00 are NLA. See page titled, "Shroud Covers - After 2/29/00" and select a color conversion package.
B - Decals not included. See page titled, "Packaging, Literature and Decals."
C - Captain seat shrouds on 18" wide only.
D - Side Panel (Captain Seat) includes rubber bushing.
E - Side Panel (Sling Seat) includes rubber bushing.
NOTE:
Form No.
97-187
71
To order call toll free 1-800-333-6900, or www.invacare.com
Page 73
Shroud Covers - Before 3/1/00
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See ChartItem #'s 1-5 Shroud Covers - Before 3/1/00111-5
1070565Bracket, Shroud, Right116
1070566Bracket, Shroud, Left116
1045267Screw, Hex Head (1/4-20 x 3/4")147
1028516Washer (3/16 x 7/16 x 1/16")128
7930332Locknut, High Profile (#10-32)2519
1070575Screw, Phillips Head (#10-32 x 7/8")1210
1070588Screw, Truss Head (#10-32 x 1/2")1611
1028755Screw, Phillips Pan Head (#10-32 x 5/8")1412
1070587Washer, Flat (3/16 x 5/8 x 1/16")1413
1070564Side Panel Attaching Hardware11A,B
1070577Plate, Trunk Clip1214
1070583Stud, Wing Head (3/4" Long)1215
1070581Washer, Nylon Cupped (9/32 x 19/32 x 3/32")1416
1070580Washer, Nylon Retainer (1/4 x 1/2 x 1/32")1417
1013497Fastener, 1/4 Turn Clip-On1418
1070585Stud, Oval Slotted (1" Long)1219C
1070574Stud, Wing Head (1" Long) 1219D
1070556Fastener, Dual Lock (1" Wide x 2" Long)1220
1070555Fastener, Dual Lock (5/8" Wide x 2" Long)1221
1070594Bushing, Rubber1222
1070563Plate, Trunk1223
1070582Rivet1424
1062096-NLAFastener, Loop (1/2" Wide x 1" Long)1425
A - Not Shown.
B - Includes items 6-13.
C - Before 2/11/98.
D - After 2/10/98.
NOTE:
Form No.
97-187
72
To order call toll free 1-800-333-6900, or www.invacare.com
Page 74
Shroud Covers - After 2/29/00
Form No.
97-187
73
To order call toll free 1-800-333-6900, or www.invacare.com
Page 75
Shroud Covers - After 2/29/00
Item #'s 1-5 Shroud Covers After 2/29/00
Item
Number
Description
Ocean
Blue
Emerald
Green
Liquid
Black
Candy
Apple
Red
1102264-NLA
1102265-NLA
1102267-NLA
1102266-NLA
Side Panel
(Captain)
- Right
1
See Note(s) B, A, DSee Note(s) B, A, DSee Note(s) B, D, ASee Note(s) B, A, D
1102268-NLA
1102269-NLA
1102271-NLA
1102270-NLA
Side Panel
(Captain)
- Left
1
See Note(s) B, A, DSee Note(s) B, A, DSee Note(s) B, A, DSee Note(s) B, D, A
1102272-NLA
1102273-NLA
1102275-NLA
1102274-NLA
Side Panel (Sling
Seat)
Right
1
See Note(s) BSee Note(s) B, A, DSee Note(s) B, D, ASee Note(s) B, A, DSee Note(s) B, A, D
1102276-NLA
1102277-NLA
1102279-NLA
1102278-NLA
Side Panel (Sling
Seat)
Left
1
See Note(s) B, D, ASee Note(s) B, D, ASee Note(s) B, D, ASee Note(s) B, D, A
1094735
1094736
1094738
1094737
Battery Cover
- 16" Wide
2
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1094731-NLA
1094732
1094734-NLA
1094733-NLA
Battery Cover
- 18" Wide
2
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1094727
1094728
1094730
1094729
Battery Cover
- 20" Wide
2
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1102260-NLA
1102261-NLA
1102263-NLA
1102262-NLA
Trunk Lid
- 16" Wide
3
See Note(s) B, CSee Note(s) B, CSee Note(s) B, CSee Note(s) B, C
1102256-NLA
1102257-NLA
1102259-NLA
1102258-NLA
Trunk Lid
- 18" Wide
3
See Note(s) B, CSee Note(s) B, CSee Note(s) B, CSee Note(s) B, C
1102252-NLA
1102253-NLA
1102255-NLA
1102254-NLA
Trunk Lid
- 20" Wide
3
See Note(s) B, CSee Note(s) B, CSee Note(s) B, CSee Note(s) B, C
1070562
1070562
1070562
1070562
Rear Storage
Compartment
- 16" Wide
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1070561
1070561
1070561
1070561
Rear Storage
Compartment
- 18" Wide
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1070560
1070560
1070560
1070560
Rear Storage
Compartment
- 20" Wide
4
See Note(s) CSee Note(s) CSee Note(s) CSee Note(s) C
1071655107165510716551071655
Rear Storage
Compartment,
Shelf-Black
5
A - Decals not included. See page titled, "Packaging, Literature and Decals."
B - Dual lock fasteners and spacers are not included with shrouds. See item 20.
C - Captain seat shrouds on 18" wide only.
D - Side Panel includes Rubber Bushing.
NOTE:
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
74
Page 76
Shroud Covers - After 2/29/00
Color Conversion Package, Captain Seat
Ocean BlueEmerald GreenLiquid BlackCandy Apple Red
1096873-NLA
1096874-NLA
1096876-NLA
1096875-NLA
See Note(s) A, C, BSee Note(s) A, B, CSee Note(s) A, B, CSee Note(s) A, B, C
A - Decals not included. See page titled, "Packaging, Literature and Decals."
B - Not Shown.
C - Includes items 1,3,8,9,10,11,12 and 13.
NOTE:
Color Conversion Package, Sling Seat
WidthOcean BlueEmerald GreenLiquid BlackCandy Apple Red
1096881-NLA
1096882-NLA
1096884-NLA
1096883-NLA
16" Wide
See Note(s) A, B, CSee Note(s) A, C, BSee Note(s) A, B, CSee Note(s) A, B, C
1096877-NLA
1096878-NLA
1096880-NLA
1096879-NLA
18" Wide
See Note(s) A, B, CSee Note(s) A, B, CSee Note(s) A, C, BSee Note(s) A, B, C
1096885-NLA
1096886-NLA
1096888-NLA
1096887-NLA
20" Wide
See Note(s) A, C, BSee Note(s) A, C, BSee Note(s) A, C, BSee Note(s) A, C, B
A - Decals not included. See page titled, "Packaging, Literature and Decals."
B - Not Shown.
C - Includes items 1, 3, 8, 9, 10, 11, 12 and 13.
NOTE:
75
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
Page 77
Shroud Covers - After 2/29/00
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See ChartItem #'s 1-5 Shroud Covers After 2/29/00111-5
See ChartColor Conversion Package, Captain Seat11B
See ChartColor Conversion Package, Sling Seat11B
1070565Bracket, Shroud, Right116
1070566Bracket, Shroud, Left116
1045267Screw, Hex Head (1/4-20 x 3/4")147
1028516Washer (3/16 x 7/16 x 1/16")128
7930332Locknut, High Profile (#10-32)2519
1070575Screw, Phillips Head (#10-32 x 7/8")1210
1070588Screw, Truss Head (#10-32 x 1/2")1611
1028755Screw, Phillips Pan Head (#10-32 x 5/8")1412
1070587Washer, Flat (3/16 x 5/8 x 1/16")1413
1070564Side Panel Attaching Hardware11B,C
1070577Plate, Trunk Clip1214
1070583Stud, Wing Head (3/4" Long)1215
1070581Washer, Nylon Cupped (9/32 x 19/32 x 3/32")1416
1070580Washer, Nylon Retainer (1/4 x 1/2 x 1/32")1417
1013497Fastener, 1/4 Turn Clip-On1418
1070574Stud, Wing Head (1" Long) 1219
1097290Dual Lock Fastner/ Spacer Kit1120A
1070594Bushing, Rubber1221
1070563Plate, Trunk1222
1070582Rivet1423
1062096-NLAFastener, Loop (1/2" Wide x 1" Long)1424
A - Kit includes 2 ea. dual lock fasteners (5/8" W x 2" L) and (1" W x 2" L), 4 ea. dual lock spacers and instruction sheet.
B - Not Shown.
C - Includes items 6-13.
NOTE:
Form No.
97-187
76
To order call toll free 1-800-333-6900, or www.invacare.com
Page 78
Shroud Covers
Weight Shifting Tilt
Before 3/1/00
Form No.
97-187
77
To order call toll free 1-800-333-6900, or www.invacare.com
Page 79
Shroud Covers
Item #'s 1-3 Shroud Covers Before 3/1/00 Weight Shifting Tilt
Item
Number
Description
Bright Plum
Metallic
Bright
Blue
Metallic
Blue
Green
Chameleon
Candy
Apple
Red
1085100-NLA
1080687-NLA
1080686
1080685
Side Panel
- Right
1
See Note(s) A, BSee Note(s) A, BSee Note(s) A, B, CSee Note(s) A, B, C
1085101-NLA
1080690-NLA
1080689
1080688
Side Panel
- Left
1
See Note(s) A, BSee Note(s) A, BSee Note(s) A, C, BSee Note(s) C, A, B
1085103-NLA
108069610806951080694Battery Cover2
See Note(s) C
1085102-NLA
108069310806921080691Trunk Lid3
See Note(s) C
A - Decals not included. See page titled, "Packaging, Literature and Decals."
B - Side Panel includes Rubber Bushing.
C - Shrouds made before 3/1/00 are NLA. See shrouds made after 2/29/00 and select color conversion package.
NOTE:
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See ChartItem #'s 1-3 Shroud Covers Before 3/1/00 Weight
Shifting Tilt
111-3
1079197Bracket, Side Shroud, Right114
1079198Bracket, Side Shroud, Left114
1045267Screw, Hex Head (1/4-20 x 3/4")145
1028516Washer (3/16 x 7/16 x 1/16")126
7930332Locknut, High Profile (#10-32)2517
1070575Screw, Phillips Head (#10-32 x 7/8")128
1070588Screw, Truss Head (#10-32 x 1/2")129
1028755Screw, Phillips Pan Head (#10-32 x 5/8")1210
1070587Washer, Flat (3/16 x 5/8 x 1/16")1211
1079196Side Panel Attaching Hardware11A,B
1070577Plate, Trunk Clip1212
1070588Screw, Truss Head (#10-32 x 1/2")1613
7930332Locknut, High Profile (#10-32)25114
1070583Stud, Wing Head (3/4" Long)1215
1070581Washer, Nylon Cupped (9/32 x 19/32 x 3/32")1416
1070580Washer, Nylon Retainer (1/4 x 1/2 x 1/32")1417
1013497Fastener, 1/4 Turn Clip-On1418
1070594Bushing, Rubber1219
40157X019Spacer, Coved (1/4 x 7/8 x 7/16")1220
A - Not Shown.
B - Includes items 4-11 and 20.
NOTE:
Weight Shifting Tilt
Before 3/1/00
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
78
Page 80
Shroud Covers
Weight Shifting Tilt
After 2/29/00
Form No.
97-187
79
To order call toll free 1-800-333-6900, or www.invacare.com
Page 81
Shroud Covers
Item #'s 1-3 Shroud Covers After 2/29/00 Weight Shifting Tilt
Item
Number
DescriptionOcean BlueEmerald GreenLiquid BlackCandy Apple Red
1102284-NLA
1102285-NLA
1102287-NLA
1102286-NLA
Side Panel
- Right
1
See Note(s) A, B, CSee Note(s) A, C, BSee Note(s) A, B, CSee Note(s) A, C, B
1102288-NLA
1102289-NLA
1102291-NLA
1102290-NLA
Side Panel
- Left
1
See Note(s) A, C, BSee Note(s) A, B, CSee Note(s) A, B, CSee Note(s) A, C, B
109477510947761094778-NLA1094777Battery Cover2
1102280-NLA
1102281-NLA
1102283-NLA
1102282-NLA
Trunk Lid3
See Note(s) BSee Note(s) BSee Note(s) BSee Note(s) B
A - Decals not included. See page titled, "Packaging, Literature and Decals."
B - Dual lock fasteners and spacers are not included with shrouds. See item 12.
C - Side Panel includes Rubber Bushing.
NOTE:
Color Conversion Package
Ocean BlueEmerald GreenLiquid BlackCandy Apple Red
1096889-NLA
1096890-NLA
1096892-NLA
1096891-NLA
See Note(s) A, B, CSee Note(s) A, C, BSee Note(s) A, B, CSee Note(s) A, C, B
A - Includes items: 1, 3, 6, 7, 8, 9, 10 and 11. See category titled, "Shroud Covers After 2/29/00 Weight Shifting Tilt."
B - Decals not included. See category titled, "Packaging, Literature and Decals."
C - Not Shown.
NOTE:
Weight Shifting Tilt
After 2/29/00
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
80
Page 82
Shroud Covers
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
See ChartItem #'s 1-3 Shroud Covers After 2/29/00 Weight
Shifting Tilt
111-3
1079197Bracket, Side Shroud, Right114
1079198Bracket, Side Shroud, Left114
1045267Screw, Hex Head (1/4-20 x 3/4")145
1028516Washer (3/16 x 7/16 x 1/16")126
7930332Locknut, High Profile (#10-32)2517
1070575Screw, Phillips Head (#10-32 x 7/8")128
1070588Screw, Truss Head (#10-32 x 1/2")129
1028755Screw, Phillips Pan Head (#10-32 x 5/8")1210
1070587Washer, Flat (3/16 x 5/8 x 1/16")1211
1097290Dual Lock Fastner/ Spacer Kit1112A
1079196Side Panel Attaching Hardware11B,C
1070577Plate, Trunk Clip1213
1070588Screw, Truss Head (#10-32 x 1/2")1414
7930332Locknut, High Profile (#10-32)25115
1070583Stud, Wing Head (3/4" Long)1216
1070581Washer, Nylon Cupped (9/32 x 19/32 x 3/32")1417
1070580Washer, Nylon Retainer (1/4 x 1/2 x 1/32")1418
1013497Fastener, 1/4 Turn Clip-On1419
1070594Bushing, Rubber1220
NOTE: Pivot/ Slide tube mounting hardware not included.
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
83
Page 85
Front Rigging Reference Chart
2" and 4" Longer Pivot/ Slide Tubes
Pivot/ Slide Tubes with Footplates
Riggings16-20" Wide-Right16-20" Wide-Left
10864971086494
PW93/PW93E -
Standard Aluminum - 2" Longer
10864981086495
PW93/PW93E -
Standard Aluminum - 4" Longer
10865171086515
PW93/PW93E -
Extra Large - 2" Longer
10865181086516
PW93/PW93E -
Extra Large - 4" Longer
10865231086519
P93M -
Extra Large - 2" Longer
10865241086520
P93M -
Extra Large - 4" Longer
10865311086529
P904A (16-20")
Standard Aluminum - 2" Longer
10865321086530
P904A (16-20")
Standard Aluminum - 4" Longer
10865511086541
P904A (16-20")
Extra Large - 2" Longer
10865521086542
P904A (16-20")
Extra Large - 4" Longer
NOTE: Pivot/Slide tube mounting hardware not included.
NOTE: Footplate Codes: Standard Aluminium (1650) and Extra Large (1350).
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
84
Page 86
PW93 Footrest Supports
Color
Form No.
97-187
85
To order call toll free 1-800-333-6900, or www.invacare.com
Page 87
PW93 Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1020719Anti-Rattle, Black111
47565X057Bushing (7/32 x 3/8 x 11/32")112
7930328Screw, Phillips Pan Head (#10-32 x 11/16")2513
7930335Screw, Phillips Pan Head (#10-32 x 1/2")2514
1035539Handle, Release (Black) - Right115
1035540Handle, Release (Black) - Left115
7930332Locknut, High Profile (#10-32)2516
1028846Rivnut (#10-32)117
1028707Spring, Release - Right118
1028708Spring, Release - Left118
15680X012Collar, Anti-Rattle (7/8")119
1070759Screw, Hex Head (1/4-20 x 1-1/2")1110
1026099Spacer, Coved (1/4 x 11/16 x 1/2")1211
7930338Nut, Acorn (1/4-20)25112
1020534Insert, Threaded1113
1074143Kit, Slide Tube Mounting Hardware1114
8881070776Footrest Support Assembly, Adult, Color - Right11A,B
8881070777Footrest Support Assembly, Adult, Color - Left11A,B
A - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Not Shown.
NOTE:
Color
Form No.
97-187
86
To order call toll free 1-800-333-6900, or www.invacare.com
Page 88
PW93ST Footrest Supports
Color
Form No.
97-187
87
To order call toll free 1-800-333-6900, or www.invacare.com
Page 89
PW93ST Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
7930328Screw, Phillips Pan Head (#10-32 x 11/16")2511
7930335Screw, Phillips Pan Head (#10-32 x 1/2")2512
1035539Handle, Release (Black) - Right113
1035540Handle, Release (Black) - Left113
1006490Tip, Plastic, Black 11A,B
1026107Screw, Phillips Pan Head (#10-32 x 1-3/8")11A,B
1028485-NLANut, Hex (#10-32)11A,B
7930332Locknut, High Profile (#10-32)2514
1028846Rivnut (#10-32)115
1030434Cushion, Tubular Foam116
1030435Cover, Foam Cushion117
1028707Spring, Release - Right118
1028708Spring, Release - Left118
47565X057Bushing (7/32 x 3/8 x 11/32")119
15680X012Collar, Anti-Rattle (7/8")1110
1070759Screw, Hex Head (1/4-20 x 1-1/2")1111
1026099Spacer, Coved (1/4 x 11/16 x 1/2")1212
7930338Nut, Acorn (1/4-20)25113
1020534Insert, Threaded1114
1074143Kit, Slide Tube Mounting Hardware1115D
8881070784Footrest Support Assembly, Adult, Color - Right11B,C
8881070785Footrest Support Assembly, Adult, Color - Left11B,C
A - These items are only required on Release Handles for chairs built before 10/1/00.
B - Not Shown.
C - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
D - Per Side.
NOTE:
Color
Form No.
97-187
88
To order call toll free 1-800-333-6900, or www.invacare.com
Page 90
PW93E Footrest Supports
Color
Form No.
97-187
89
To order call toll free 1-800-333-6900, or www.invacare.com
Page 91
PW93E Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
15680X012Collar, Anti-Rattle (7/8")121
1027095Plug Button, Black (7/8")122
1022874Bumper113
1030979Screw, Phillips Pan Head Tap (#10-32 x 3/4")114
1035539Handle, Release (Black) - Right115
1035540Handle, Release (Black) - Left115
1025716Screw, Phillips Pan Head (#10-32 x 11/16")116
47565X057Bushing (7/32 x 3/8 x 11/32")117
1026114Screw, Phillips Pan Head (#10-32 x 1/2")118
1028707Spring, Release - Right119
1028708Spring, Release - Left119
1028846Rivnut (#10-32)1110
1025735Locknut (#10-32)1111
1074108Cap, End Tube (3/4")1112
1020534Insert, Threaded1113
1070759Screw, Hex Head (1/4-20 x 1-1/2")1114
1026099Spacer, Coved (1/4 x 11/16 x 1/2")1215
1044214Nut, Hex with Nylon Cap (1/4-20)1116
1074143Kit, Slide Tube Mounting Hardware1117
8881070768Footrest Support Assembly, Adult, Color - Right11A,B
8881070769Footrest Support Assembly, Adult, Color - Left11A,B
A - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Not Shown.
NOTE:
Color
Form No.
97-187
90
To order call toll free 1-800-333-6900, or www.invacare.com
Page 92
P93M Footrest Supports
Color
Form No.
97-187
91
To order call toll free 1-800-333-6900, or www.invacare.com
Page 93
P93M Footrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
7930359Screw, Phillips Pan Head (#10-32 x 1/2")2511
7930360Screw, Phillips Pan Head (#10-32 x 11/16")2512
47565X057Bushing (7/32 x 3/8 x 11/32")113
1107321Nut, Low Cap (5/16"-24)114
1027095Plug Button, Black (7/8")215
11232X009Screw, Lug (5/16-24 x 1-3/8")116
1008935Spring, Release - Right117
1008936Spring, Release - Left117
1022874Bumper118
1030979Screw, Phillips Pan Head Tap (#10-32 x 3/4")119
67005X000Rivnut (#10-32)1110
7930365Locknut (#10-32)25111
1035539Handle, Release (Black) - Right1112
1035540Handle, Release (Black) - Left1112
1006490Tip, Plastic, Black 1113C
8881037836Footrest Support Assembly, Adult, Color - Right11A,B
8881037837Footrest Support Assembly, Adult, Color - Left11A,B
A - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Not Shown.
C - Before 10/1/00.
NOTE:
Color
Form No.
97-187
92
To order call toll free 1-800-333-6900, or www.invacare.com
Page 94
P904A Legrest Supports
Color
Form No.
97-187
93
To order call toll free 1-800-333-6900, or www.invacare.com
Page 95
P904A Legrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1027095Plug Button, Black (7/8")111
11919X000Screw, Truss Head (3/8-16 x 1-1/2") 112
1058636Washer, Nylon (25/64 x 7/8 x 1/32")123
40363X000Hex Nut (3/8"-16)114
7930330Locknut (5/16-24)2515
1026030Screw, Lug (5/16-24 x 1-3/8")116
8881048851Tube, Elevating Support (Color) - Right117A
8881048852Tube, Elevating Support (Color) - Left117A
1027097Plug Button, Black (3/4")118
8881058664Tube, Legrest Support (Color) - Right119A
8881058665Tube, Legrest Support (Color) - Left119A
1022874Bumper1110
1030979Screw, Phillips Pan Head Tap (#10-32 x 3/4")1111
8881058646Legrest Support Assembly w/o Pad, Adult, Color -
Right
11A,B
8881058647Legrest Support Assembly w/o Pad, Adult, Color -
Left
11A,B
A - Specify frame color when ordering. See page titled, "Frame Finishes, Touch-Up Paint and Upholstery Options."
B - Not Shown.
NOTE:
Color
Form No.
97-187
To order call toll free 1-800-333-6900, or www.invacare.com
94
Page 96
PAL4A Articulating Legrest Supports
Chrome
Form No.
97-187
95
To order call toll free 1-800-333-6900, or www.invacare.com
Page 97
PAL4A Articulating Legrest Supports
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1058478Tube, Legrest Support, Right111
1058479Tube, Legrest Support, Left111
1027097Plug Button, Black (3/4")112
40363X000Hex Nut (3/8"-16)133
1022854Screw, Slotted Head Shoulder (1/2 x 1-1/8")114
1022877Tube Support and Drive Link - Right115
1022878Tube Support and Drive Link - Left115
1022848Slide Tube, Articulating (Chrome) - Right 116
1022849Slide Tube, Articulating (Chrome) - Left 116
1027377Washer (#20)117
7930363Package, Locknut (5/16"-24)2518
11232X009Screw, Lug (5/16-24 x 1-3/8")119
1022866Screw, Socket Button Head (3/8-16 x 3/4")1210