Honeywell F113a6001 Owner's Manual

yrig

g

F112A,C; F113A,C

Portable Air Cleaners

OWNER’S GUIDE

® U.S. Registered Trademark
Cop

ht © 2001 Honeywell

hts Reserved 035-00427-000

All Ri

69- 1506- 1

HOW YOUR PORTABLE AIR CLEANER WORKS

g

g

(

)

g

y

Your air cleaner is effective at removing airborne particulates like dust mite allergens,
pollen, mold spores, bacteria, dust, soot, and tobacco smoke particles. It is also
effective at reducin
from cookin

annoying odors like tobacco smoke, chemical odors, and odors

, when equipped with a CPZ canister.

You can choose models with these filters
odors and extend the HEPA filter life

• a 99.97% High-Efficiency Particulate Air (HEPA) filter that provides high-efficiency
removal of particulates.

• a HEPA filter that removes particulates and a CPZ™ canister that removes volatile

anic compounds (VOC) and odor. This high filtration and adsorption efficiency

or
enables the air cleaner to remove man
odors from the indooor air.

Your unit is one of these models:
F112A,C: 150 cfm, 120V, 60 Hz, 1.85A. Both models are two-speed. Model A has a
HEPA filter and model C has a HEPA filter with a CPZ™ canister.

F113A,C: 300 cfm, 120V, 60 Hz, 1.5A. Both models are three-speed. Model A has a
HEPA filter, model C has a HEPA filter with a CPZ™ canister.

all have a carbon prefilter that helps reduce

:

of the troublesome particles, gases and

69-1506-1 2 035-00427-000

OPERATING YOUR AIR CLEANER

y

g

g

y

y

g

g

g

y

g

y

g

y

y

g

g

g

IMPORTANT

If you have purchased an F112C or an F113C model, you will need to open
the air cleaner and remove the plastic packaging on the CPZ filter. To
reassemble the unit, follow the instructions in the Changing Your Filters sec­tion.

Your air cleaner has a power cord that plugs into a 120 Vac electrical outlet. Before
plugging it in and operating your air cleaner, carefully read all instructions:

WARNING

Electrical Shock Hazard.
Can cause personal injury or equipment damage.

Do not use air cleaner with an
Keep forei
the ventilation or exhaust openin

n objects from blocking the air outlets or intakes, or from entering

solid-state speed control device.

.

1.

Be sure the unit is full
in.

2.

Do not use the air cleaner outdoors.

3.

Place the air cleaner where the cord and unit are not obstacles to emplo
customer traffic flow.

4.

5.

6.

7.

8.

9.

10.

11.

12.

the air cleaner polarized plug (one blade is wider than the other) into the

Plu
polarized outlet as desi
reverse the plu
trician.

ou must use an extension cord, use a heavy duty cord with adequate line

If
size.
Do not run the power cord under carpets or ru
Keep the cord awa
Do not use the air cleaner where combustible
Do not expose the air cleaner to rain or operate near water, in a bathroom, or
other damp location.
Do not sit, stand or place heav

s unplug when not in use and before servicing. To disconnect the air

Alwa
cleaner, first turn the speed control to the Off position before removin
from the outlet.
Do not use the air cleaner with a dama
dropped, dama

assembled and in an upright position before plugging it

ned. Do not attempt to force the plug into the outlet;

and then if it does not fit into the outlet, contact a qualified elec-

s.

from hot surfaces.

ases or vapors are present.

objects on the air cleaner.

ed cord or plug or if the unit was

ed or is malfunctioning.

ee and

the plug

035-00427-000 3 69-1506-1

MAINTAINING YOUR AIR CLEANER

g

y

g

y

y

g

g

y

g

CAUTION

Filter Washing Hazard.
Washing can damage prefilter, HEPA filter and CPZ canister.

Do not wash filters.
Replace filters accordin

Determining When to Replace Your Filters

With proper maintenance, your air cleaner is designed to provide years of high­efficienc
model: a carbon prefilter, a HEPA filter and a CPZ canister on some models.

Replacing Your Prefilter Every Three Months (Quarterly)

The carbon prefilter captures large airborne particles and helps reduce odors.

NOTE: Do not operate the air cleaner without the carbon prefilter.

IMPORTANT:

Replacing Your Primary HEPA FIlter and CPZ Canister

The primary HEPA filter and CPZ canister life expectancy depends on the
concentration of contaminants in the environment where the air cleaner is installed. If
there are sources of lar
heav
reduced.

air cleaning. Your air cleaner contains up to three filters, depending on

Replace the prefilter every three months. If the unit is used in a smoking or
other persisting unpleasant odor environment, consider purchasing a model
with a CPZ canister (F112C or F113C). See Table 1 to select filter part num­bers.

e amounts of particle generation (such as woodworking or

smoking), the useful life of the prefilter and HEPA filter and CPZ canister may be

to recommended schedule.

well recommends changing the HEPA filter and CPZ canister based on

Hone
operatin
and one year for heavy usage. See Table 1 to select filter part numbers.

Whenever the combined air resistance of the carbon filter and the HEPA filter and CPZ
canister becomes excessive due to the amount of contaminants captured, the air
cleaner be
puffs of air can be felt.

When this occurs:

• The carbon prefilter ma

• The HEPA filter and CPZ canister need replacing if the unit continues to pulsate

69-1506-1 4 035-00427-000

conditions—every three years for light usage, two years for normal usage

ins to audibly pulsate. Instead of a steady stream of air at the outlets, rapid

be clogged and needs replacing.

after replacin

the carbon prefilter.

IMPORTANT

g eq

q

(

ying

g

ying

Replace the HEPA filter and CPZ canister every one to three years, depend­ing on the environment where the air cleaner is operating.

Table 1. Selecting Your Replacement Filters.

Air Cleaner

Model No.

F112A6003 38002 21500 N/A

F112C6001 38002 28720 32000232

F113A6001 38002 24000 N/A

F113C6009 38002 28600 32000231

Prefilter

Part No.

HEPA Filter

Part No.

CPZ Canister

Part No.

Changing Your Filters

CAUTION

Electrical Shock Hazard.
Can cause personal injury or equipment damage.

Disconnect power before servicin

NOTE: No tools are re

1.

Disassemble the unit as follows
a. Loosen the carr
b. Lift the grille cover from the unit.
c. Lift the HEPA filter with carbon prefilter from the base.
d. Remove the CPZ canister, if applicable.
e. Remove the two velcro strips from the top and bottom of the prefilter and

remove it from the HEPA filter.

f. Wrap the new prefilter around the HEPA filter and replace the top and bottom

2.

velcro strips.
Reassemble the unit as follows:
a. Place the assembled HEPA filter with carbon prefilter on the base.
b. Replace the CPZ canister, if applicable.
c. Replace the
d. Reattach the carr

sure not to over-tighten.

uired for disassembly or assembly.

handle by turning it counterclockwise.

rille cover.

handle and turn it clockwise until securely tight. Be

uipment.

see Fig.1):

035-00427-000 5 69-1506-1

RETRACTABLE
HANDLE

GRILLE COVER

CPZ CANISTER
(F112C/F113C MODELS ONLY)

HEPA FILTER

CARBON PREFILTER

BASE ASSEMBLY
(CONTROLS AND MOTOR)

M14826

Fig. 1. Air Cleaner components.

69-1506-1 6 035-00427-000

Determining What to Do When Your Air Cleaner Does Not

y

gag

Operate

• Check to make sure the power cord is correctly connected in the outlet.

• Test the outlet with another appliance or lamp.

• Check the fuse or circuit breaker; the circuit ma

are also in use.

• Check to determine if the thermal overload protection device on the air cleaner
motor has en
control to Off and wait 30 to 45 minutes before plugging it in and turning to On.

IMPORTANT

Do not attempt to repair the unit yourself.

• If none of the above procedures restores operation, call the authorized Honeywell
distributor where the unit was purchased for further information.

ed to turn off the air cleaner. If it has, turn the air cleaner motor

be overloaded if other appliances

035-00427-000 7 69-1506-1

FIVE-YEAR LIMITED WARRANTY

y

y

y

y

y

y

q

g

y

y

y

Honeywell warrants this product, excluding all filters, to be free from defects in the
workmanship or materials, under normal use and service, for a period of five (5) years
from the date of purchase b
the product is defective or malfunctions, Hone
Honeywell’s option) within a reasonable period of time.

If the product is defective, return it, with a bill of sale or other dated proof of purchase,
to the authorized Hone
distributor for futher instructions.

the consumer. If, at any time during the warranty period,

well shall repair or replace it (at

well distributor where you purchased it or contact the

This Warrant

if it is shown by Honeywell that the defect or malfunction was caused by damage

appl

does not include removal or reinstallation costs. This Warranty shall not

that occurred while the product was in the possession of a consumer.

well’s sole responsibility shall be to repair or replace the product within the

Hone
terms stated above. HONEYWELL SHALL NOT BE LIABLE FOR ANY LOSS OR
DAMAGE OF ANY KIND, INCLUDING ANY INCIDENTAL OR CONSEQUENTIAL
DAMAGES RESULTING, DIRECTLY OR INDIRECTLY, FROM ANY BREACH OF
ANY WARRANTY, EXPRESS OR IMPLIED, OR ANY OTHER FAILURE OF THIS
PRODUCT. Some states do not allow the exclusion or limitation of incidental or

uential damages, so this limitation may not apply to you.

conse

THIS WARRANTY IS THE ONLY EXPRESS WARRANTY HONEYWELL MAKES ON
THIS PRODUCT. THE DURATION OF ANY IMPLIED WARRANTIES, INCLUDING
THE WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, IS HEREBY LIMITED TO THE FIVE YEAR DURATION OF THIS
WARRANTY. Some states do not allow limitations on how lon
lasts, so the above limitation ma

not apply to you.This warranty gives you specific

an implied warranty

legal rights, and you may have other rights that vary from state to state.

If

ou have any questions concerning this warranty, please write to:

Commercial Air Products, Customer Relations Dept, 1985 Douglas Dr N, MN10-2528,
Golden Valle

, MN 55422-39927 or call 1-800-345-6770, ext. 788, Monday-Friday,

7:00 a.m. to 5:30 p.m., Central time.

Home and Building Control Home and Building Control

Honeywell Honeywell Limited-Honeywell Limitée
1985 Douglas Drive North 35 Dynamic Drive
Golden Valley, MN 55422 Scarborough, Ontario

69-1506-1 G.H. Rev. 06-01 035-00427-000

M1V 4Z9 www.cleanairfacility.com

Printed in U.S.A. on recycled
paper containing at least 10%
post-consumer paper fibers.