Ford F 59 Commercial Stripped Chassis 2016, F 53 Motorhome Chassis 2016 Owner's Manual

2016 F-Series Super Duty Class A Motorhome

and Commercial Chassis Owner’s Manual

owner.ford.com

ford.ca

December 2015

Second Printing

Owner’s Manual

Motorhome

Litho in U.S.A.

GU9J 19A321 AB

The information contained in this publication was correct at the time of going to print. In the interest of continuous development, we reserve the right to change specifications, design or equipment at any time without notice or obligation. No part of this publication may be reproduced, transmitted, stored in a retrieval system or translated into any language in any form by any means without our written permission. Errors and omissions excepted.

Part Number: 04/2015 20151203170100

Introduction

About This Manual...........................................3

Symbols Glossary.............................................3

California Proposition 65...............................5

Perchlorate..........................................................5

Ford Credit...........................................................5

Replacement Parts

Recommendation........................................6

Special Notices.................................................6

Mobile Communications

Equipment.......................................................7

Export Unique Options...................................7

Environment

Protecting the Environment.........................8

Steering Wheel

Adjusting the Steering Wheel......................9

Cruise Control....................................................9

Wipers and Washers

Windshield Wipers.........................................10

Windshield Washers......................................10

Lighting

Lighting Control................................................11

Instrument Lighting Dimmer........................11

Daytime Running Lamps..............................12

Direction Indicators.........................................12

Instrument Cluster

Gauges.................................................................13

Warning Lamps and Indicators..................15

Audible Warnings and Indicators...............17

Information Displays

General Information.......................................18

Information Messages..................................19

Starting and Stopping the

Engine

General Information......................................22

Ignition Switch.................................................22

Starting a Gasoline Engine.........................22

Engine Block Heater......................................24

Fuel and Refueling

Safety Precautions........................................25

Fuel Quality......................................................26

Running Out of Fuel......................................26

Refueling............................................................27

Fuel Consumption.........................................28

Emission Control System............................29

Transmission

Automatic Transmission.............................32

Brakes

General Information......................................35

Hints on Driving With Anti-Lock

Brakes.............................................................35

Parking Brake...................................................36

Cruise Control

Principle of Operation...................................37

Using Cruise Control......................................37

Load Carrying

Load Limit.........................................................38

Towing

Towing a Trailer...............................................44

Recommended Towing Weights..............45

Essential Towing Checks.............................47

Transporting the Vehicle.............................49

Towing the Vehicle on Four Wheels.......50

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Table of Contents

Driving Hints

Breaking-In........................................................51

Reduced Engine Performance...................51

Economical Driving.........................................51

Driving Through Water..................................52

Roadside Emergencies

Roadside Assistance.....................................53

Hazard Warning Flashers............................54

Jump Starting the Vehicle...........................54

Customer Assistance

Getting the Services You Need..................57

In California (U.S. Only)...............................58

The Better Business Bureau (BBB) Auto

Line Program (U.S. Only)........................59

Utilizing the Mediation/Arbitration

Program (Canada Only).........................60

Getting Assistance Outside the U.S. and

Canada..........................................................60

Ordering Additional Owner's

Literature........................................................61

Reporting Safety Defects (U.S.

Only)...............................................................62

Reporting Safety Defects (Canada

Only)...............................................................62

Fuses

Fuse Specification Chart.............................64

Changing a Fuse.............................................82

Maintenance

General Information.....................................84

Under Hood Overview..................................85

Engine Oil Dipstick........................................86

Engine Oil Check............................................86

Oil Change Indicator Reset........................86

Engine Coolant Check..................................87

Automatic Transmission Fluid

Check.............................................................90

Brake Fluid Check...........................................91

Power Steering Fluid Check.......................93

Fuel Filter..........................................................94

Changing the 12V Battery...........................94

Changing the Engine Air Filter...................96

Vehicle Care

General Information......................................97

Cleaning the Exterior.....................................97

Cleaning the Engine......................................98

Cleaning the Alloy Wheels.........................98

Vehicle Storage...............................................99

Wheels and Tires

Tire Care............................................................101

Using Snow Chains.......................................116

Changing a Road Wheel..............................117

Technical Specifications............................120

Capacities and Specific-

ations

Engine Specifications...................................121

Motorcraft Parts.............................................121

Vehicle Identification Number.................123

Vehicle Certification Label........................123

Transmission Code Designation.............124

Capacities and Specifications.................125

Extended Service Plan

(ESP)

Extended Service Plan (ESP)..................130

Scheduled Maintenance

General Maintenance Information.........132

Normal Scheduled Maintenance...........135

Special Operating Conditions Scheduled

Maintenance...............................................137

Scheduled Maintenance Record............139

Appendices

Type Approvals.............................................150

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Table of Contents

ABOUT THIS MANUAL

Thank you for choosing Ford. We recommend that you take some time to get to know your vehicle by reading this manual. The more that you know about your vehicle, the greater the safety and pleasure you will get from driving it.

WARNING

Driving while distracted can result in loss of vehicle control, crash and

injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.

Note: This manual describes product features and options available throughout the range of available models, sometimes even before they are generally available. It may describe options not fitted to the vehicle you have purchased.

Note: Some of the illustrations in this manual may show features as used in different models, so may appear different to you on your vehicle.

Note: Always use and operate your vehicle in line with all applicable laws and regulations.

Note: Pass on this manual when selling your vehicle. It is an integral part of your vehicle.

Note: Either Ford Motor Company or an authorized Ford dealer may have originally sold this incomplete vehicle to a vehicle modifier who upfitted it. As a result, it may have different options and features than described in this manual.

This manual may qualify the location of a component as left-hand side or right-hand side. The side is determined when facing forward in the seat.

E154903

Right-hand side.A Left-hand side.B

SYMBOLS GLOSSARY

These are some of the symbols you may see on your vehicle.

Safety alert

See Owner's Manual

Air conditioning system

Anti-lock braking system

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Introduction

Avoid smoking, flames or sparks

Battery

Battery acid

Brake fluid - non petroleum based

Brake system

Cabin air filter

Check fuel cap

Child safety door lock or unlock

Child seat lower anchor

Child seat tether anchor

E71340

Cruise control

Do not open when hot

Engine air filter

Engine coolant

Engine coolant temperature

Engine oil

Explosive gas

Fan warning

Fasten seatbelt

Front airbag

Front fog lamps

Fuel pump reset

Fuse compartment

Hazard warning flashers

Heated rear window

Heated windshield

Interior luggage compartment release

Jack

Keep out of reach of children

Lighting control

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Introduction

Low tire pressure warning

Maintain correct fluid level

Note operating instructions

Panic alarm

E139213

Parking aid

Parking brake

Power steering fluid

Power windows front/rear

Power window lockout

Service engine soon

Side airbag

Shield the eyes

E138639

Stability control

Windshield wash and wipe

CALIFORNIA PROPOSITION 65

WARNINGS

Some constituents of engine exhaust, certain vehicle components,

certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.

Battery posts, terminals and related

accessories contain lead and lead

compounds, chemicals known to the State of California to cause cancer and reproductive harm. Batteries also contain other chemicals known to the State of California to cause cancer. Wash your hands after handling.

PERCHLORATE

Certain components in your vehicle such as airbag modules, seatbelt pretensioners and remote control batteries may contain perchlorate material. Special handling may apply for service or vehicle end of life disposal.

For more information visit:

Web Address

www.dtsc.ca.gov/hazard-

ouswaste/perchlorate

FORD CREDIT

US Only

Ford Credit offers a full range of financing and lease plans to help you acquire your vehicle. If you have financed or leased your vehicle through Ford Credit, thank you for your business.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Introduction

We offer a number of convenient ways for you to contact us and help to manage your account.

Call 1-800-727-7000. For more information about Ford Credit

and access to the Account Manager, go to www.fordcredit.com.

REPLACEMENT PARTS RECOMMENDATION

We have built your vehicle to the highest standards using quality parts. We recommend that you demand the use of genuine Ford and Motorcraft parts whenever your vehicle requires scheduled maintenance or repair. You can clearly identify genuine Ford and Motorcraft parts by looking for the Ford, FoMoCo or Motorcraft branding on the parts or their packaging.

Scheduled Maintenance and Mechanical Repairs

One of the best ways for you to make sure that your vehicle provides years of service is to have it maintained in line with our recommendations using parts that conform to the specifications detailed in this Owner’s Manual. Genuine Ford and Motorcraft parts meet or exceed these specifications.

Collision Repairs

We hope that you never experience a collision, but accidents do happen. Genuine Ford replacement collision parts meet our stringent requirements for fit, finish, structural integrity, corrosion protection and dent resistance. During

vehicle development we validate that these parts deliver the intended level of protection as a whole system. A great way to know for sure you are getting this level of protection is to use genuine Ford replacement collision parts.

Warranty on Replacement Parts

Genuine Ford and Motorcraft replacement parts are the only replacement parts that benefit from a Ford Warranty. The Ford Warranty may not cover damage caused to your vehicle as a result of failed non-Ford parts. For additional information, refer to the terms and conditions of the Ford Warranty.

SPECIAL NOTICES

New Vehicle Limited Warranty

For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, refer to the Warranty Manual that is provided to you along with your Owner’s Manual.

Special Instructions

For your added safety, your vehicle is fitted with sophisticated electronic controls.

WARNINGS

You risk death or serious injury to yourself and others if you do not

follow the instruction highlighted by the warning symbol. Failure to follow the specific warnings and instructions could result in personal injury.

Front seat mounted rear-facing child

or infant seats should NEVER be

placed in front of an active passenger airbag.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Introduction

On-board Diagnostics (OBD-II)

Your vehicle’s On-board Diagnostics (OBD-II) system has a data port for diagnostics, repair and reprogramming services with diagnostic scan tools. Installing a non-Ford-approved aftermarket OBD plug-in device that uses the port during normal driving, for example remote insurance company monitoring, remote vehicle diagnostics, telematics or engine reprogramming, may cause interference or damage to vehicle systems. We do not recommend or endorse the use of any non-Ford-approved aftermarket OBD plug-in devices. The vehicle Warranty may not cover damage caused by any non-Ford-approved aftermarket OBD plug-in device.

MOBILE COMMUNICATIONS EQUIPMENT

WARNING

Driving while distracted can result in loss of vehicle control, crash and

Using mobile communications equipment is becoming increasingly important in the conduct of business and personal affairs. However, you must not compromise your own or others’ safety when using such equipment. Mobile communications can enhance personal safety and security when appropriately used, particularly in

emergency situations. Safety must be paramount when using mobile communications equipment to avoid negating these benefits. Mobile communication equipment includes, but is not limited to, cellular phones, pagers, portable email devices, text messaging devices and portable two-way radios.

EXPORT UNIQUE OPTIONS

For your particular global region, your vehicle may be equipped with features and options that are different from the features and options that are described in this Owner’s Manual. A market unique supplement may be supplied that complements this book. By referring to the market unique supplement, if provided, you can properly identify those features, recommendations and specifications that are unique to your vehicle. This Owner’s Manual is written primarily for the U.S. and Canadian Markets. Features or equipment listed as standard may be different on units built for Export. Refer to this Owner’s

Manual for all other required information and warnings.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Introduction

PROTECTING THE ENVIRONMENT

You must play your part in protecting the environment. Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps toward this aim.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Environment

ADJUSTING THE STEERING WHEEL

WARNING

Do not adjust the steering wheel

when your vehicle is moving.

E161517

1. Pull and hold the steering wheel

release lever.

2. Adjust the steering wheel to the desired

position then release the lever.

CRUISE CONTROL

E161518

See Cruise Control (page 37).

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Steering Wheel

WINDSHIELD WIPERS

Note: Fully defrost the windshield before

switching on the windshield wipers. Note: Make sure the windshield wipers are

switched off before entering a car wash. Note: Clean the windshield and wiper

blades if they begin to leave streaks or smears. If that doesn't resolve the issue, install new wiper blades.

Note: Do not operate the wipers on a dry windshield. This may scratch the glass, damage the wiper blades or cause the wiper motor to burn out. Always use the windshield washers before wiping a dry windshield.

E161461

Rotate the end of the control:

• away from you to increase the wiper speed

• toward you to decrease the wiper speed

WINDSHIELD WASHERS

Note: Do not operate the wipers on a dry

windshield. This may scratch the glass, damage the wiper blades or cause the wiper motor to burn out. Always use the windshield washer before wiping a dry windshield.

Note: Do not operate the washers when the washer reservoir is empty. This may cause the washer pump to overheat.

Press the end of the stalk to activate the washer.

• A brief press causes a single wipe without washer fluid.

• A quick press and hold causes the wipers to swipe three times with washer fluid.

• A long press and hold will activate the wipers and washer fluid for up to 10 seconds.

E161462

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Wipers and Washers

LIGHTING CONTROL

E161456

Off.A Parking lamps, instrument panel

lamps, license plate lamps and tail lamps.

Headlamps.C

High Beams

E161457

Push the lever away from you to switch the high beam on.

Push the lever forward again or pull the lever toward you to switch the high beams off.

Headlamp Flasher

E161458

Slightly pull the lever toward you and release it to flash the headlamps.

INSTRUMENT LIGHTING DIMMER

Note: If you disconnect the battery or it

becomes discharged, the dimmer switch will require re-calibration. Rotate the dimmer switch from the full dim position to the full dome/on position to reset.

Note: Move the control to the full upright position, past detent, to turn on the interior lamps.

E161459

Move the control up or down to adjust the intensity of the panel lighting.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Lighting

DAYTIME RUNNING LAMPS (If

Equipped)

WARNING

The daytime running lamps system does not activate the rear lamps and

may not provide adequate lighting during low visibility driving conditions. Also, the autolamps switch position may not activate the headlamps in all low visibility conditions, such as daytime fog. Make sure the headlamps are switched to auto or on, as appropriate, during all low visibility conditions. Failure to do so may result in a crash.

The system switches the low beam headlamps on at a reduced intensity in daylight conditions.

To switch the system on, switch the ignition on, and switch the lighting control to the off or parking lamp position.

DIRECTION INDICATORS

E161460

Push the lever up or down to use the direction indicators.

Note: Tap the lever up or down to make the direction indicators flash three times to indicate a lane change.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Lighting

GAUGES

E192271

Engine oil pressure gauge.A Tachometer.B Information display.C Speedometer.D Transmission fluid temperature gauge.E Engine coolant temperature gauge.F Fuel gauge.G

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Instrument Cluster

Engine Oil Pressure Gauge

Indicates engine oil pressure. The needle should stay in the normal operating range (between L and H). If the needle falls below the normal range, stop the vehicle, turn off the engine and check the engine oil level. Add oil if needed. If the oil level is correct, have your vehicle checked by your authorized dealer.

Speedometer

Indicates vehicle speed. Vehicle speed is limited to either 65 mph (105 km/h) or 75 mph (120 km/h).

Transmission Fluid Temperature Gauge

Normal area

The transmission fluid is within the normal operating temperature (between H and C).

Yellow area

The transmission fluid is higher than normal operating temperature. This can be caused by special operation conditions (i.e. snowplowing, towing or off-road use). Operating the transmission for extended periods of time with the gauge in the yellow area may cause internal transmission damage. Altering the severity of the driving conditions is recommended to lower the transmission temperature into the normal range.

Red area

The transmission fluid is overheating. Stop the vehicle to allow the temperature to return to normal range.

If the gauge is operating in the yellow or red area, stop the vehicle and verify the airflow is not restricted such as snow or debris blocking airflow through the grill. If the gauge continues to show high temperatures, see your authorized dealer.

Engine Coolant Temperature Gauge

WARNING

Never remove the coolant reservoir cap while the engine is running or hot.

At normal operating temperature, the needle will remain in the center section.

Note: Do not restart the engine until the cause of overheating has been resolved.

If the needle enters the red section, the engine is overheating. Stop the engine, switch the ignition off and determine the cause once the engine has cooled down.

Fuel Gauge

Note: The fuel gauge may vary slightly

when your vehicle is moving or on a slope.

Switch the ignition on. The fuel gauge indicates approximately how much fuel you have left in the fuel tank. The arrow adjacent to the fuel pump symbol indicates on which side of your vehicle the fuel filler door is located.

The needle should move toward F when you refuel your vehicle. If the needle points to E after adding fuel, have an authorized dealer check the system soon.

After refueling, some variability in the position of the needle is normal:

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Instrument Cluster

• It may take a short time for the needle to reach F after leaving the gas station. This is normal and depends upon the slope of the pavement at the gas station.

• The fuel amount dispensed into the tank is a little less or more than the gauge indicated. This is normal and depends upon the slope of the pavement at the gas station.

• If the gas station nozzle shuts off before the tank is full, try a different gas pump nozzle.

• There is a small reserve left in the tank when the fuel gauge reaches empty.

Low Fuel Reminder

A low fuel reminder triggers when the fuel gauge needle is at one-sixteenth or about 50 miles (80 km) to empty, whichever occurs first.

Variations: Note: The low fuel warning and distance-to-empty warning can appear at different fuel

gauge positions depending on fuel economy conditions. This variation is normal.

Distance-to-emptyFuel gauge positionDriving type (fuel economy

conditions)

30 miles to 80 miles (48 km

to 129 km)

1/16thHighway driving

10 miles to 35 miles (16 km

to 56 km)

1/16th-1/4Severe duty driving (trailer

towing, extended idle)

WARNING LAMPS AND INDICATORS

The following warning lamps and indicators will alert you to a vehicle condition that may become serious. Some lamps will illuminate when you start your vehicle to make sure they work. If any lamps remain on after starting your vehicle, refer to the respective system warning lamp for further information.

Note: Some warning indicators appear in the information display and function the same as a warning lamp but do not display when you start your vehicle.

Anti-Lock Braking System

If it illuminates when you are driving, this indicates a

malfunction. You will continue to have the normal braking system (without ABS) unless the brake system warning lamp is also illuminated. Have the system checked by your authorized dealer.

Battery

If it illuminates while driving, it

indicates a malfunction. Switch

off all unnecessary electrical equipment and have the system checked by your authorized dealer immediately.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Instrument Cluster

Brake System

E144522

Illuminates when you engage the parking brake with the ignition on.

If it illuminates when you are driving, check that the parking brake is not engaged. If the parking brake is not engaged, this indicates low brake fluid level or a brake system malfunction. Have the system checked immediately by your authorized dealer.

WARNING

Driving your vehicle with the warning lamp on is dangerous. A significant

decrease in braking performance may occur. It will take you longer to stop your vehicle. Have your vehicle checked by your authorized dealer immediately. Driving extended distances with the parking brake engaged can cause brake failure and the risk of personal injury.

Brake Reserve System (If Equipped)

E146190

Illuminates to indicate normal hydromax booster reserve

system activation when the engine is off and the service brake pedal is applied.

This light may also illuminate momentarily if the engine is running and the driver turns the steering wheel fully in one direction while braking.

If the light remains on while the engine is running, this indicates inadequate hydraulic booster pressure or reserve pump system failure. Stop the vehicle as soon as possible and seek service immediately by your authorized dealer.

Cruise Control (If Equipped)

E71340

Illuminates when you switch this feature on. See Using Cruise

Control (page 37).

Direction Indicator

Illuminates when the left or right direction indicator or the hazard

warning flasher is turned on. If the indicators stay on or flash faster, check for a burned out bulb.

Electronic Throttle Control

Illuminates when the engine has

defaulted to a limp-home

operation. See your authorized dealer as soon as possible.

Fasten Safety Belt

It will illuminate and a chime will

sound to remind you to fasten

your safety belt.

High Beam

Illuminates when you switch the

high beam headlamps on. It will

flash when you use the headlamp flasher.

Service Engine Soon

If the service engine soon

indicator light stays illuminated

after the engine is started, it indicates that the On-Board Diagnostics (OBD-II) system has detected a malfunction of the vehicle emissions control system. Refer to On-Board Diagnostics (OBD-II) in the Fuel and Refueling chapter for more information about having your vehicle serviced. See Emission Control System (page 29).

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Instrument Cluster

If the light is blinking, engine misfire is occurring which could damage your catalytic converter. Drive in a moderate fashion (avoid heavy acceleration and deceleration) and have your vehicle serviced immediately.

WARNING

Under engine misfire conditions, excessive exhaust temperatures

could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. Have your vehicle serviced immediately.

The service engine soon indicator light illuminates when the ignition is first turned on prior to engine start to check the bulb and to indicate whether the vehicle is ready for Inspection/Maintenance (I/M) testing.

Normally, the service engine soon light will stay on until the engine is cranked, then turn itself off if no malfunctions are present. However, if after 15 seconds the service engine soon light blinks eight times, it means that the vehicle is not ready for I/M testing. See Emission Control

System (page 29).

Transmission Tow/Haul (If Equipped)

Illuminates when the tow/haul feature has been activated. If the

light flashes steadily, have the system serviced immediately, damage to the transmission could occur.

AUDIBLE WARNINGS AND INDICATORS

Fail-Safe Cooling Warning Chime

Sounds when the coolant gauge pointer has moved to hot. There are three stages of chimes:

• Stage 1 is a single chime when the engine temperature begins to overheat.

• Stage 2 is multiple chimes and engine power becomes limited in order to help cool the engine.

• Stage 3 is multiple chimes and the engine will shut down.

Headlamps On Warning Chime

Sounds when you remove the key from the ignition and open the driver's door and you have left the headlamps or parking lamps on.

Key in Ignition Warning Chime

Sounds when you open the driver's door and you have left the key in the ignition.

Parking Brake On Warning Chime

Sounds when you have left the parking brake on and drive your vehicle. If the warning chime remains on after you have released the parking brake, have the system checked by your authorized dealer immediately.

Shift to Park Warning Chime

Sounds when you open the driver's door and your vehicle is not in park.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Instrument Cluster

GENERAL INFORMATION

WARNING

Driving while distracted can result in loss of vehicle control, crash and

Various systems on your vehicle can be controlled using the information display controls on the steering wheel. Corresponding information is displayed in the information display.

Information Display Controls

E197545

• Press the info button to scroll through trip, outside air temperature, engine hours and miles to empty.

• Press the setup button to scroll through various vehicle feature settings.

• Press the reset button to choose settings, reset information and confirm messages.

Info

E161507

Press the INFO button repeatedly to cycle through the following features:

TRIP

Registers the distance of individual journeys. Press and release the INFO button until the TRIP appears in the display. Press and hold the RESET button to reset

XXX° (outside air temperature)

This displays the outside temperature.

MILES (km) TO E

This displays an estimate of approximately how far you can drive with the fuel remaining in your tank under normal driving conditions. Remember to turn the ignition off when refueling to allow this feature to correctly detect the added fuel.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Information Displays

The DTE function will display a message in the information display when you have approximately 50 miles (80 km), to empty. Press RESET to clear this warning message. It will return at approximately 25 miles (40 km), 10 miles (16 km) and 0 miles (0 km) miles to empty.

DTE is calculated using a running average fuel economy, which is based on your recent driving history of 500 miles (800 km).

ENG HRS

Registers the accumulated time the engine has been running.

System check and vehicle feature customization

E161508

Press the SETUP button repeatedly to cycle the message center through the following features:

Note: When returning to the SETUP menu and a non-English language has been selected, HOLD RESET FOR ENGLISH will be displayed to change back to English. Press and hold the RESET button to change back to English.

PRESS RESET FOR SYS CHECK

When this message appears, press the RESET button and the message center will begin to cycle through the following systems and provide a status of the item if needed.

Note: Some systems show a message only if a condition is present

• ENGINE TEMP

• TRANS TEMP

• OIL PRESSURE

• BRAKE FLUID LEVEL

• FUEL LEVEL (if equipped)

UNITS

Displays the current units English or Metric Press the RESET button to change from

English to Metric.

ENGLISH RESET FOR NEW

Allows you to choose which language the message center will display in. Selectable languages are English, Spanish, or French.

Press the RESET button to cycle the message center through English, Spanish and French language choices. Press and hold the RESET button for two seconds to set the language choice.

INFORMATION MESSAGES

Note: Depending on the vehicle options

equipped with your vehicle, not all of the messages will display or be available. Certain messages may be abbreviated or shortened depending upon which cluster type you have.

Press the RESET button to acknowledge and remove some messages from the information display. Other messages will be removed automatically after a short time.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Information Displays

Certain messages need to be confirmed before you can access the menus.

Engine

ActionMessage

The engine is overheating. Stop your vehicle as soon

as safely possible, turn off the engine. If the warning stays on followed by an indicator chime or continues to come on, contact an authorized dealer as soon as

possible. Never remove the coolant reservoir cap while

the engine is running or hot.

REDUCED ENGINE POWER

The engine is overheating. Stop your vehicle as soon

as safely possible, turn off the engine. If the warning stays on followed by an indicator chime or continues to come on, contact an authorized dealer as soon as

possible.

STOP ENGINE SAFELY

The engine coolant is overheating. Stop your vehicle as soon as safely possible, turn off the engine and let

it cool. Check the coolant and coolant level. If the

warning stays on or continues to come on, contact an

authorized dealer as soon as possible.

CHECK ENGINE TEMPERATURE

A early reminder of a low fuel condition.FUEL LEVEL LOW

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Information Displays

Maintenance

ActionMessage

The engine oil pressure is low. Check the level of the

engine oil. If the oil level is OK and this warning persists,

shut down the engine immediately and contact an

authorized dealer as soon as possible. See Engine Oil

Check (page 86).

LOW OIL PRESSURE

The brake fluid level is low and the brake system

should be inspected immediately. See Brake Fluid

Check (page 91).

BRAKE FLUID LEVEL LOW

The fuel cap is loose, not seated properly or off. Stop

your vehicle when convenient, turn off the engine and

check that you inserted the fuel cap properly. Rotate

the cap until you hear a click. The warning message

switches off after a proper drive cycle is completed.

See Emission Control System (page 29). If the

warning message remains on or continues to comes

back on, see an authorized dealer as soon as possible.

CHECK FUEL CAP

Transmission

ActionMessage

The transmission fluid is overheating. This warning

may appear when towing heavy loads or when driving

in a low gear at a high speed for an extended period

of time. Stop your vehicle as soon as safely possible,

turn off the engine and let the transmission cool.

CHECK TRANS TEMPERATURE

A reminder to apply the brakes, then shift to park.SHIFT TO PARK

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Information Displays

GENERAL INFORMATION

WARNINGS

Extended idling at high engine speeds can produce very high

temperatures in the engine and exhaust system, creating the risk of fire or other damage.

Do not park, idle or drive your vehicle

on dry grass or other dry ground

cover. The emission system heats up the engine compartment and exhaust system, creating the risk of fire.

Do not start the engine in a closed

garage or in other enclosed areas.

Exhaust fumes can be toxic. Always open the garage door before you start the engine.

If you smell exhaust fumes inside

your vehicle, have your vehicle

checked by an authorized dealer immediately. Do not drive your vehicle if you smell exhaust fumes.

If you disconnect the battery, your vehicle may exhibit some unusual driving characteristics for approximately 5 miles (8 kilometers) after you reconnect it. This is because the engine management system must realign itself with the engine. You can disregard any unusual driving characteristics during this period.

The powertrain control system meets all Canadian interference-causing equipment standard requirements regulating the impulse electrical field or radio noise.

When you start the engine, avoid pressing the accelerator pedal before and during operation. Only use the accelerator pedal when you have difficulty starting the engine.

IGNITION SWITCH

E161572

A (accessory) - Allows the electrical accessories, such as the radio, to operate while the engine is not running.

Note: Do not leave the ignition key in this position for too long. This could cause your vehicle battery to lose charge.

B (lock) - Locks the gearshift lever and allows key removal.

C (off) - The ignition is off. Note: When you switch the ignition off and

leave your vehicle, do not leave your key in the ignition. This could cause your vehicle battery to lose charge.

D (on) - All electrical circuits are operational and the warning lamps and indicators illuminate.

E (start) - Cranks the engine.

STARTING A GASOLINE ENGINE

When you start the engine, the idle speed increases, this helps to warm up the engine. If the engine idle speed does not slow down automatically, have your vehicle checked by an authorized dealer.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Starting and Stopping the Engine

Before starting the engine check the following:

• Make sure all occupants have fastened their safety belts.

• Make sure the headlamps and electrical accessories are off.

• Make sure the parking brake is on.

• Make sure the transmission is in park

(P) or neutral (N).

• Turn the ignition key to the on position.

Note: Do not touch the accelerator pedal.

1. Fully press the brake pedal.

2. Turn the key to the start position to start the engine. Release the key when the engine starts.

Note: The engine may continue cranking for up to 15 seconds or until it starts.

Note: If you cannot start the engine on the first try, wait for a short period and try again.

Failure to Start

If you cannot start the engine after three attempts, wait 10 seconds and follow this procedure:

1. Fully press the brake pedal.

2. Fully press the accelerator pedal and hold it there.

3. Start the engine.

Stopping the Engine When Your Vehicle is Stationary

1. Shift into park (P) or neutral (N).

2. Turn the key to the off position.

3. Apply the parking brake.

Stopping the Engine When Your Vehicle is Moving

WARNING

Switching off the engine when the vehicle is still moving will result in a

loss of brake and steering assistance. The steering will not lock, but higher effort will be required. When the ignition is switched off, some electrical circuits, including air bags, warning lamps and indicators may also be off. If the ignition was turned off accidentally, you can shift into neutral (N) and re-start the engine.

1. Put the transmission into neutral (N)

and use the brakes to bring your vehicle to a safe stop.

2. When your vehicle has stopped, shift

into park (P) or neutral (N) and switch the ignition off.

3. Apply the parking brake.

Guarding Against Exhaust Fumes

WARNING

If you smell exhaust fumes inside

your vehicle, have your vehicle

checked by your authorized dealer immediately. Do not drive your vehicle if you smell exhaust fumes. Carbon monoxide is present in exhaust fumes. Take precautions to avoid its dangerous effects.

Important Ventilating Information

If you stop your vehicle and then leave the engine idling for long periods of time, we recommend that you do one of the following:

• Open the windows at least 1 in (3 cm).

• Set your climate control to outside air.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Starting and Stopping the Engine

ENGINE BLOCK HEATER (If

Equipped)

WARNINGS

Failure to follow engine block heater instructions could result in property damage or serious personal injury.

Do not use your heater with ungrounded electrical systems or two-pronged adapters. There is a risk

of electrical shock.

Do not fully close the hood, or allow it to drop under its own weight when

using the engine block heater. This could damage the power cable and may cause an electrical short resulting in fire, injury and property damage.

Note: The heater is most effective when outdoor temperatures are below 0°F (-18°C).

The heater acts as a starting aid by warming the engine coolant. This allows the climate control system to respond quickly. The equipment includes a heater element (installed in the engine block) and a wire harness. You can connect the system to a grounded 120-volt AC electrical source.

We recommend that you do the following for a safe and correct operation:

• Use a 16-gauge outdoor extension cord

that is product certified by Underwriter’s Laboratory (UL) or Canadian Standards Association (CSA). This extension cord must be suitable for use outdoors, in cold

temperatures, and be clearly marked Suitable for Use with Outdoor Appliances. Do not use an indoor extension cord outdoors. This could result in an electric shock or become a fire hazard.

• Use as short an extension cord as possible.

• Do not use multiple extension cords.

• Make sure that when in operation, the

extension cord plug and heater cord plug connections are free and clear of water. This could cause an electric shock or fire.

• Make sure your vehicle is parked in a clean area, clear of combustibles.

• Make sure the heater, heater cord and extension cord are firmly connected.

• Check for heat anywhere in the electrical hookup once the system has been operating for approximately 30 minutes.

• Make sure the system is unplugged and properly stowed before starting and driving your vehicle. Make sure the protective cover seals the prongs of the block heater cord plug when not in use.

• Make sure the heater system is checked for proper operation before winter.

Using the Engine Block Heater

Make sure the receptacle terminals are clean and dry prior to use. Clean them with a dry cloth if necessary.

The heater uses 0.4 to 1.0 kilowatt-hours of energy per hour of use. The system does not have a thermostat. It achieves maximum temperature after approximately three hours of operation. Using the heater longer than three hours does not improve system performance and unnecessarily uses electricity.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Starting and Stopping the Engine

SAFETY PRECAUTIONS

WARNINGS

Do not overfill the fuel tank. The pressure in an overfilled tank may cause leakage and lead to fuel spray

and fire.

The fuel system may be under pressure. If you hear a hissing sound

near the fuel filler inlet, do not refuel until the sound stops. Otherwise, fuel may spray out, which could cause serious personal injury.

Fuels can cause serious injury or

death if misused or mishandled.

Flow of fuel through a fuel pump

nozzle can produce static electricity.

This can cause a fire if you are filling an ungrounded fuel container.

Fuel may contain benzene, which is

a cancer-causing agent.

When refueling always shut the

engine off and never allow sparks or

open flames near the fuel tank filler valve. Never smoke or use a cell phone while refueling. Fuel vapor is extremely hazardous under certain conditions. Avoid inhaling excess fumes.

Observe the following guidelines when handling automotive fuel:

• Extinguish all smoking materials and

any open flames before refueling your vehicle.

• Always turn off the vehicle before

refueling.

• Automotive fuels can be harmful or fatal if swallowed. Fuel such as gasoline is highly toxic and if swallowed can cause death or permanent injury. If fuel is swallowed, call a physician immediately, even if no symptoms are immediately apparent. The toxic effects of fuel may not be visible for hours.

• Avoid inhaling fuel vapors. Inhaling too much fuel vapor of any kind can lead to eye and respiratory tract irritation. In severe cases, excessive or prolonged breathing of fuel vapor can cause serious illness and permanent injury.

• Avoid getting fuel liquid in your eyes. If fuel is splashed in the eyes, remove contact lenses (if worn), flush with water for 15 minutes and seek medical attention. Failure to seek proper medical attention could lead to permanent injury.

• Fuels can also be harmful if absorbed through the skin. If fuel is splashed on the skin, clothing or both, promptly remove contaminated clothing and wash skin thoroughly with soap and water. Repeated or prolonged skin contact with fuel liquid or vapor causes skin irritation.

• Be particularly careful if you are taking Antabuse or other forms of Disulfiram for the treatment of alcoholism. Breathing gasoline vapors could cause an adverse reaction, serious personal injury or sickness. If fuel is splashed on the skin, wash the affected areas immediately with plenty of soap and water. Consult a physician immediately if you experience any adverse reactions.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Fuel and Refueling

FUEL QUALITY

Choosing the Right Fuel

E161513

We recommend regular unleaded gasoline with a minimum pump (R+M)/2 octane rating of 87. Some fuel stations offer fuels posted as regular unleaded gasoline with an octane rating below 87, particularly in high altitude areas. We do not recommend fuels with an octane rating below 87.

For vehicles with EcoBoost engines, to provide improved performance, we recommend premium fuel for severe duty usage such as trailer tow.

Do not use any fuel other than those recommended because they could lead to engine damage that may not be covered by the vehicle Warranty.

Note: Use of any fuel other than those recommended can impair the emission control system and cause a loss of vehicle performance.

Do not use:

• Diesel fuel.

• Fuels containing kerosene or paraffin.

• Fuel containing more than 15% ethanol

or E85 fuel.

• Fuels containing methanol.

• Fuels containing metallic-based

additives, including manganese-based compounds.

• Fuels containing the octane booster additive, methylcyclopentadienyl manganese tricarbonyl (MMT).

• Leaded fuel (using leaded fuel is prohibited by law).

The use of fuels with metallic compounds such as methylcyclopentadienyl manganese tricarbonyl (commonly known as MMT), which is a manganese-based fuel additive, will impair engine performance and affect the emission control system.

Do not be concerned if the engine sometimes knocks lightly. However, if the engine knocks heavily while using fuel with the recommended octane rating, contact an authorized dealer to prevent any engine damage.

RUNNING OUT OF FUEL

Avoid running out of fuel because this situation may have an adverse effect on powertrain components.

If you have run out of fuel:

• You may need to cycle the ignition from off to on several times after refueling to allow the fuel system to pump the fuel from the tank to the engine. On restarting, cranking time will take a few seconds longer than normal. With keyless ignition, just start the engine. Crank time will be longer than usual.

• Normally, adding 1 gallon (3.8 liters) of fuel is enough to restart the engine. If the vehicle is out of fuel and on a steep grade, more than 1 gallon (3.8 liters) may be required.

• The service engine soon indicator may come on. For more information on the service engine soon indicator, See

Warning Lamps and Indicators

(page 15).

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Fuel and Refueling

REFUELING

WARNINGS

Fuel vapor burns violently and a fuel fire can cause severe injuries.

Read and follow all the instructions on the pump island.

Turn off your engine when you are refueling.

Do not smoke if you are near fuel or refueling your vehicle.

Keep sparks, flames and smoking materials away from fuel.

Stay outside your vehicle and do not leave the fuel pump unattended when refueling your vehicle. This is

against the law in some places.

Keep children away from the fuel pump; never let children pump fuel.

Do not use personal electronic devices while refueling.

Wait at least 10 seconds before removing the fuel pump nozzle to allow any residual fuel to drain into

the fuel tank.

Stop refueling after the fuel pump nozzle automatically shuts off for the

second time. Failure to follow this will fill the expansion space in the fuel tank and could lead to fuel overflowing.

Do not remove the fuel pump nozzle

from its fully inserted position when

refueling.

Use the following guidelines to avoid electrostatic charge build-up when filling an ungrounded fuel container:

• Place approved fuel container on the ground.

• Do not fill a fuel container while it is in the vehicle (including the cargo area).

• Keep the fuel pump nozzle in contact with the fuel container while filling.

• Do not use a device that would hold the fuel pump handle in the fill position.

Fuel Filler Cap

WARNINGS

The fuel system may be under pressure. If you hear a hissing sound

near the fuel filler door, do not refuel until the sound stops. Otherwise, fuel may spray out, which could cause serious personal injury.

If you do not use the proper fuel filler

cap, excessive pressure or vacuum

in the fuel tank may damage the fuel system or cause the fuel cap to disengage in a collision, which may result in possible personal injury.

Note: If you must replace the fuel filler cap, replace it with a fuel filler cap that is designed for your vehicle. The customer warranty may be void for any damage to the fuel tank or fuel system if the correct genuine Ford, Motorcraft or other certified fuel filler cap is not used.

Your fuel tank filler cap has an indexed design with a 1/4th turn on and off feature. When fueling your vehicle:

1. Put your vehicle in park (P).

2. Switch the engine off.

3. Carefully turn the filler cap

counterclockwise until it spins off.

4. Pull to remove the cap from the fuel

filler pipe.

Motorhome (TY3) , enUSA, Edition date: 04/2015, Second Printing

Fuel and Refueling

+ 130 hidden pages