Ford F 250 2017, F 550 2017 Owner's Manual

2017 SUPER DUTY Owner’s Manual

2017 SUPER DUTY

Owner’s Manual

owner.ford.com

ford.ca

March 2017

Third Printing

Owner’s Manual

Super Duty

Litho in U.S.A.

HC3J 19A321 AC

The information contained in this publication was correct at the time of going to print. In the interest of continuous development, we reserve the right to change specifications, design or equipment at any time without notice or obligation. No part of this publication may be reproduced, transmitted, stored in a retrieval system or translated into any language in any form by any means without our written permission. Errors and omissions excepted.

Part Number: 201702 20170213141229

Introduction

About This Manual...........................................7

Symbols Glossary.............................................8

Data Recording................................................10

California Proposition 65.............................12

Perchlorate.........................................................12

Ford Credit.........................................................12

Replacement Parts

Recommendation.......................................12

Special Notices................................................13

Mobile Communications

Equipment.....................................................14

Export Unique Options.................................14

Environment

Protecting the Environment........................16

Child Safety

General Information.......................................17

Installing Child Restraints............................18

Booster Seats..................................................30

Child Restraint Positioning.........................32

Child Safety Locks..........................................33

Seatbelts

Principle of Operation..................................35

Fastening the Seatbelts..............................36

Seatbelt Height Adjustment.....................40

Seatbelt Warning Lamp and Indicator

Chime.............................................................40

Seatbelt Reminder.........................................41

Child Restraint and Seatbelt

Maintenance................................................42

Seatbelt Extension........................................43

Supplementary Restraints

System

Principle of Operation..................................44

Driver and Passenger Airbags...................45

Side Airbags.....................................................50

Safety Canopy™..............................................51

Crash Sensors and Airbag Indicator........52

Airbag Disposal...............................................53

Keys and Remote Controls

General Information on Radio

Frequencies..................................................54

Remote Control..............................................54

Replacing a Lost Key or Remote

Control...........................................................60

MyKey™

Principle of Operation...................................61

Creating a MyKey............................................62

Clearing All MyKeys.......................................63

Checking MyKey System Status...............63

Using MyKey With Remote Start

Systems.........................................................63

MyKey Troubleshooting...............................64

Doors and Locks

Locking and Unlocking.................................65

Keyless Entry...................................................68

Tailgate

Tailgate Lock....................................................70

Removing the Tailgate.................................70

Tailgate Step.....................................................71

Bed Extender....................................................72

Security

Passive Anti-Theft System.........................74

Anti-Theft Alarm............................................76

Power Running Boards

Using Power Running Boards....................78

Steering Wheel

Adjusting the Steering Wheel...................80

Audio Control...................................................81

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

Voice Control...................................................82

Cruise Control..................................................82

Information Display Control.......................83

Heated Steering Wheel...............................83

Pedals

Adjusting the Pedals....................................84

Wipers and Washers

Windshield Wipers........................................85

Autowipers.......................................................85

Windshield Washers.....................................86

Lighting

General Information......................................87

Lighting Control..............................................87

Autolamps........................................................88

Instrument Lighting Dimmer.....................88

Daytime Running Lamps............................89

Automatic High Beam Control.................89

Front Fog Lamps............................................90

Direction Indicators.......................................90

Spot Lamps.......................................................91

Interior Lamps..................................................91

Ambient Lighting...........................................94

Windows and Mirrors

Power Windows.............................................95

Global Opening..............................................96

Exterior Mirrors................................................96

Interior Mirror...................................................98

Sliding Windows............................................99

Sun Visors.........................................................99

Moonroof........................................................100

Instrument Cluster

Gauges..............................................................102

Warning Lamps and Indicators...............105

Audible Warnings and Indicators...........109

Information Displays

General Information.....................................110

Information Messages.................................127

Climate Control

Manual Climate Control............................144

Automatic Climate Control......................146

Hints on Controlling the Interior

Climate.........................................................147

Heated Windows and Mirrors..................150

Heated Exterior Mirrors..............................150

Cabin Air Filter...............................................150

Remote Start...................................................151

Seats

Sitting in the Correct Position..................152

Head Restraints.............................................152

Manual Seats.................................................154

Power Seats....................................................155

Memory Function..........................................157

Rear Seats.......................................................159

Heated Seats.................................................160

Climate Controlled Seats...........................161

Front Seat Armrest......................................162

Rear Seat Armrest........................................163

Universal Garage Door

Opener

Universal Garage Door Opener...............164

Auxiliary Power Points

Auxiliary Power Points...............................168

Storage Compartments

Center Console..............................................170

Overhead Console........................................170

Under Seat Storage.....................................170

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

Starting and Stopping the

Engine

General Information.....................................173

Ignition Switch................................................173

Keyless Starting.............................................174

Starting a Gasoline Engine - 6.2L/

6.8L................................................................174

Starting a Diesel Engine - 6.7L

Diesel.............................................................176

Diesel Particulate Filter..............................180

Switching Off the Engine - 6.7L

Diesel.............................................................181

Engine Idle Shutdown..................................181

Engine Block Heater....................................182

Fuel and Refueling

Safety Precautions......................................184

Fuel Quality - E85........................................185

Fuel Quality - Diesel....................................186

Fuel Quality - Gasoline..............................188

Running Out of Fuel....................................189

Selective Catalytic Reduction System -

Diesel............................................................189

Refueling - Gasoline....................................193

Refueling - Diesel.........................................194

Fuel Consumption.......................................196

Emission Control System - Gasoline......197

Emission Control System - Diesel........200

Transmission

Automatic Transmission..........................205

Power Take-Off...........................................209

Four-Wheel Drive

Using Four-Wheel Drive.............................210

Rear Axle

Limited Slip Differential.............................219

Electronic Locking Differential................219

Brakes

General Information.....................................221

Hints on Driving With Anti-Lock

Brakes...........................................................222

Parking Brake.................................................223

Hill Start Assist.............................................223

Traction Control

Principle of Operation................................225

Using Traction Control...............................225

Stability Control

Principle of Operation................................226

Using Stability Control...............................227

Terrain Control

Principle of Operation................................229

Using Hill Descent Control.......................229

Parking Aids

Principle of Operation.................................231

Rear Parking Aid............................................231

Rear View Camera.......................................232

360 Degree Camera...................................235

Cruise Control

Principle of Operation................................239

Using Cruise Control...................................239

Using Adaptive Cruise Control...............240

Driving Aids

Lane Keeping System................................246

Blind Spot Information System.............248

Cross Traffic Alert........................................253

Steering...........................................................255

Collision Warning System.........................257

Load Carrying

Load Limit......................................................260

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

Bed Ramps....................................................264

Towing

Towing a Trailer.............................................267

Trailer Reversing Aids.................................268

Trailer Sway Control....................................276

Recommended Towing Weights............276

Essential Towing Checks..........................280

Towing the Vehicle on Four Wheels......289

Driving Hints

Breaking-In.....................................................292

Economical Driving.....................................292

Driving Through Water...............................293

Floor Mats.......................................................293

Snowplowing................................................294

Roadside Emergencies

Roadside Assistance..................................297

Hazard Flashers...........................................298

Fuel Shutoff - 6.2L/6.8L...........................298

Jump Starting the Vehicle........................299

Post-Crash Alert System...........................301

Transporting the Vehicle...........................301

Towing Points...............................................302

Customer Assistance

Getting the Services You Need..............304

In California (U.S. Only)............................305

The Better Business Bureau (BBB) Auto

Line Program (U.S. Only).....................306

Utilizing the Mediation/Arbitration

Program (Canada Only).......................307

Getting Assistance Outside the U.S. and

Canada........................................................307

Ordering Additional Owner's

Literature....................................................308

Reporting Safety Defects (U.S.

Only)............................................................309

Reporting Safety Defects (Canada

Only)............................................................309

Fuses

Fuse Specification Chart.............................311

Changing a Fuse..........................................320

Maintenance

General Information....................................322

Opening and Closing the Hood..............322

Under Hood Overview - 6.2L...................323

Under Hood Overview - 6.7L Diesel......324

Under Hood Overview - 6.8L..................326

Engine Oil Dipstick - 6.2L/6.8L...............327

Engine Oil Dipstick - 6.7L Diesel.............327

Engine Oil Check - 6.2L/6.8L...................327

Engine Oil Check - 6.7L Diesel................328

Changing the Engine Oil and Oil

Filter..............................................................329

Changing the Coalescer Filter

Element......................................................330

Oil Change Indicator Reset.......................331

Engine Coolant Check - 6.2L/6.8L........332

Engine Coolant Check - 6.7L Diesel......336

Automatic Transmission Fluid

Check...........................................................340

Transfer Case Fluid Check........................343

Brake Fluid Check........................................343

Power Steering Fluid Check....................344

Washer Fluid Check....................................344

Draining the Fuel Filter Water Trap - 6.7L

Diesel...........................................................345

Fuel Filter - 6.2L/6.8L................................346

Changing the 12V Battery.........................347

Checking the Wiper Blades.....................349

Changing the Wiper Blades.....................349

Adjusting the Headlamps........................349

Changing a Bulb............................................351

Bulb Specification Chart..........................354

Changing the Engine Air Filter - 6.2L/

6.8L...............................................................356

Changing the Engine Air Filter - 6.7L

Diesel............................................................357

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

Changing the Engine-Mounted and

Diesel Fuel Conditioner Module Fuel

Filters - 6.7L Diesel..................................359

Vehicle Care

General Information...................................364

Cleaning Products.......................................364

Cleaning the Exterior..................................365

Waxing.............................................................366

Cleaning the Engine...................................366

Cleaning the Exhaust - 6.7L Diesel........367

Cleaning the Windows and Wiper

Blades..........................................................367

Cleaning the Interior...................................368

Cleaning the Instrument Panel and

Instrument Cluster Lens.......................368

Cleaning Leather Seats.............................369

Repairing Minor Paint Damage..............370

Cleaning the Wheels..................................370

Vehicle Storage..............................................371

Wheels and Tires

General Information...................................374

Tire Care...........................................................377

Using Snow Chains.....................................394

Tire Pressure Monitoring System..........394

Changing a Road Wheel...........................402

Technical Specifications............................413

Capacities and Specific-

ations

Engine Specifications - 6.2L.....................415

Engine Specifications - 6.7L Diesel........415

Engine Specifications - 6.8L....................416

Motorcraft Parts - 6.2L...............................417

Motorcraft Parts - 6.7L Diesel..................418

Motorcraft Parts - 6.8L..............................419

Vehicle Identification Number...............420

Vehicle Certification Label........................421

Transmission Code Designation.............421

Capacities and Specifications - 6.2L....422

Capacities and Specifications - 6.7L

Diesel............................................................427

Capacities and Specifications -

6.8L...............................................................434

Audio System

General Information..................................440

Audio Unit - Vehicles With: AM/FM/

CD...................................................................441

Audio Unit - Vehicles With: AM/FM/CD/

SYNC............................................................443

Audio Unit - Vehicles With: AM/FM/CD/

Touchscreen Display..............................447

Digital Radio..................................................449

Satellite Radio...............................................451

USB Port.........................................................454

SYNC™

General Information...................................455

Using Voice Recognition...........................457

Using SYNC™ With Your Phone...........459

SYNC™ Applications and Services.......471

Using SYNC™ With Your Media

Player...........................................................476

SYNC™ Troubleshooting.........................485

SYNC™ 3

General Information...................................493

Home Screen................................................504

Using Voice Recognition...........................505

Entertainment................................................512

Climate............................................................522

Phone...............................................................524

Navigation......................................................530

Apps.................................................................538

Settings............................................................541

SYNC™ 3 Troubleshooting......................553

Accessories

Accessories....................................................566

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

Auxiliary Switches.......................................567

Ford Protect

Ford Protect....................................................571

Scheduled Maintenance

General Maintenance Information........573

Normal Scheduled Maintenance..........576

Special Operating Conditions Scheduled

Maintenance..............................................581

Scheduled Maintenance Record............591

Appendices

End User License Agreement..................601

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Table of Contents

ABOUT THIS MANUAL

Thank you for choosing Ford. We recommend that you take some time to get to know your vehicle by reading this manual. The more that you know about your vehicle, the greater the safety and pleasure you will get from driving it.

WARNING

Driving while distracted can result in loss of vehicle control, crash and

injury. We strongly recommend that you use extreme caution when using any device that may take your focus off the road. Your primary responsibility is the safe operation of your vehicle. We recommend against the use of any hand-held device while driving and encourage the use of voice-operated systems when possible. Make sure you are aware of all applicable local laws that may affect the use of electronic devices while driving.

Note: This manual describes product features and options available throughout the range of available models, sometimes even before they are generally available. It may describe options that are not on your vehicle. It is possible that either Ford Motor Company or an authorized Ford dealer may have originally sold an incomplete vehicle to a vehicle modifier who upfitted it. As a result, some of the options and features on this vehicle may differ from what we describe in this manual.

Note: Some of the illustrations in this manual may show features as used in different models, so they may appear differently to you on your vehicle.

Note: Always use and operate your vehicle in line with all applicable laws and regulations.

Note: Pass on this manual when selling your vehicle. It is an integral part of the vehicle.

Note: Your vehicle’s powertrain control systems can detect and store information about vehicle modifications that increase horsepower and torque output such as whether or not performance-enhancing powertrain components commonly referred to as performance chips have been used. This information will stay in the system’s memory and cannot be erased even if the modification is removed. Ford Motor Company, Ford of Canada, Ford of Mexico and service or repair facilities can retrieve this information when servicing your vehicle. Ford Motor Company may use this information to determine if your warranty covers any needed repairs.

Note: Some aftermarket products may cause severe engine, transmission and exhaust system damage. See your warranty information for more details.

Your new diesel engine may feel, drive and function somewhat differently than a gasoline engine. Therefore, it is very important that you read and thoroughly familiarize yourself and others operating the vehicle with this guide. There is a special procedure for turning off the diesel engine. See Starting a Diesel Engine (page 176). It is important to read and understand this material in order to maintain the best service life for your engine.

Ford may discontinue models or change specifications without any notice and without incurring obligations.

This manual may qualify the location of a component as left-hand side or right-hand side. The side is determined when facing forward in the seat.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

E154903

Right-hand sideA Left-hand sideB

Note: Throughout this guide, you will find warnings identified by the warning symbol. Warnings remind you to be especially careful to reduce the risk of personal injury.

SYMBOLS GLOSSARY

These are some of the symbols you may see on your vehicle.

Air conditioning system

E231157

Air conditioning system lubricant type

Anti-lock braking system

Avoid smoking, flames or sparks

Battery

Battery acid

Brake fluid - non petroleum based

Brake system

Cabin air filter

Check fuel cap

Child safety door lock or unlock

Child seat lower anchor

Child seat tether anchor

E71340

Cruise control

Do not open when hot

Engine air filter

Engine coolant

Engine coolant temperature

Engine oil

Explosive gas

Fan warning

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

Fasten seatbelt

E231160

Flammable

Front airbag

Front fog lamps

Fuel pump reset

Fuse compartment

Hazard warning flashers

Heated rear window

Heated windshield

Interior luggage compartment release

Jack

Keep out of reach of children

Lighting control

Low tire pressure warning

Maintain correct fluid level

Note operating instructions

Panic alarm

E139213

Parking aid

Parking brake

Power steering fluid

Power windows front/rear

Power window lockout

E231159

Requires registered technician

Safety alert

See Owner's Manual

E231158

See Service Manual

Service engine soon

Side airbag

Shield the eyes

E138639

Stability control

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

Windshield wash and wipe

DATA RECORDING

Service Data Recording

Service data recorders in your vehicle are capable of collecting and storing diagnostic information about your vehicle. This potentially includes information about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company (Ford of Canada in Canada), and service and repair facilities may access or share among them vehicle diagnostic information received through a direct connection to your vehicle when diagnosing or servicing your vehicle. Additionally, Ford Motor Company (Ford of Canada, in Canada) may, where permitted by law, use vehicle diagnostic information for vehicle improvement or with other information we may have about you, (for example, your contact information), to offer you products or services that may interest you. Data may be provided to our service providers such as part suppliers that may help diagnose malfunctions, and who are similarly obligated to protect data. We retain this data only as long as necessary to perform these functions or to comply with law. We may provide information where required in response to official requests to law enforcement or other government authorities or third parties acting with lawful authority or court order, and such information may be used in legal proceedings. For U.S. only (if equipped), if you choose to use connected apps and services, such as SYNC Vehicle Health Report or MyFord Mobile App, you consent that certain diagnostic information may

also be accessed electronically by Ford Motor Company and Ford authorized service facilities, and that the diagnostic information may be used to provide services to you, personalizing your experience, troubleshoot, and to improve products and services and offer you products and services that may interest you, where permitted by law. For Canada only, for more information, please review the Ford of Canada privacy policy at www.ford.ca, including our U.S. data storage and use of service providers in other jurisdictions who may be subject to legal requirements in Canada, the United States and other countries applicable to them, for example, lawful requirements to disclose personal information to governmental authorities in those countries. See SYNC™ (page 455).

Event Data Recording

This vehicle is equipped with an event data recorder. The main purpose of an event data recorder is to record, in certain crash or near crash-like situations, such as an airbag deployment or hitting a road obstacle; this data will assist in understanding how a vehicle’s systems performed. The event data recorder is designed to record data related to vehicle dynamics and safety systems for a short period of time, typically 30 seconds or less.

The event data recorder in this vehicle is designed to record such data as:

• How various systems in your vehicle were operating;

• Whether or not the driver and passenger safety belts were buckled/fastened;

• How far (if at all) the driver was depressing the accelerator and/or the brake pedal; and

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

• How fast the vehicle was traveling; and

• Where the driver was positioning the steering wheel.

This data can help provide a better understanding of the circumstances in which crashes and injuries occur.

Note: Event data recorder data is

recorded by your vehicle only if a non-trivial crash situation occurs; no data is recorded by the event data recorder under normal driving conditions and no personal data or information (e.g., name, gender, age, and crash location) is recorded (see limitations regarding 911 Assist and Traffic, directions and Information privacy below). However, parties, such as law enforcement, could combine the event data recorder data with the type of personally identifying data routinely acquired during a crash investigation.

To read data recorded by an event data recorder, special equipment is required, and access to the vehicle or the event data recorder is needed. In addition to the vehicle manufacturer, other parties, such as law enforcement, that have such special equipment, can read the information if they have access to the vehicle or the event data recorder. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent, unless pursuant to court order or where required by law enforcement, other government authorities or other third parties acting with lawful authority. Other parties may seek to access the information independently of Ford Motor Company and Ford of Canada.

Note: Including to the extent that any

law pertaining to Event Data Recorders applies to SYNC or its features, please note the following: Once 911 Assist (if equipped) is enabled (set ON), 911 Assist may, through any paired and connected cell phone, disclose to emergency services that the vehicle has been in a crash involving the deployment of an airbag or, in certain vehicles, the activation of the fuel pump shut-off. Certain versions or updates to 911 Assist may also be capable of being used to electronically or verbally provide to 911 operators the vehicle location (such as latitude and longitude), and/or other details about the vehicle or crash or personal information about the occupants to assist 911 operators to provide the most appropriate emergency services. If you do not want to disclose this information, do not activate the 911 Assist feature. See SYNC™ (page 455).

Additionally, when you connect to Traffic, Directions and Information (if equipped, U.S. only), the service uses GPS technology and advanced vehicle sensors to collect the vehicle’s current location, travel direction, and speed (“vehicle travel information”), only to help provide you with the directions, traffic reports, or business searches that you request. If you do not want Ford or its vendors to receive this information, do not activate the service. For more information, see Traffic, Directions and Information, Terms and Conditions. See SYNC™

(page 455).

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

CALIFORNIA PROPOSITION 65

WARNINGS

Some constituents of engine exhaust, certain vehicle components,

certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.

Battery posts, terminals and related

accessories contain lead and lead

compounds, chemicals known to the State of California to cause cancer and reproductive harm. Batteries also contain other chemicals known to the State of California to cause cancer. Wash your hands after handling.

PERCHLORATE

Certain components in your vehicle such as airbag modules, seatbelt pretensioners and remote control batteries may contain perchlorate material. Special handling may apply for service or vehicle end of life disposal.

For more information visit:

Web Address

www.dtsc.ca.gov/hazard-

ouswaste/perchlorate

FORD CREDIT

US Only

Ford Credit offers a full range of financing and lease plans to help you acquire your vehicle. If you have financed or leased your vehicle through Ford Credit, thank you for your business.

We offer a number of convenient ways for you to contact us, and to manage your account.

Call 1-800-727-7000. For more information about Ford Credit

and access to the Account Manager, go to www.ford.com/finance.

REPLACEMENT PARTS RECOMMENDATION

We have built your vehicle to the highest standards using quality parts. We recommend that you demand the use of genuine Ford and Motorcraft parts whenever your vehicle requires scheduled maintenance or repair. You can clearly identify genuine Ford and Motorcraft parts by looking for the Ford, FoMoCo or Motorcraft branding on the parts or their packaging.

Scheduled Maintenance and Mechanical Repairs

One of the best ways for you to make sure that your vehicle provides years of service is to have it maintained in line with our recommendations using parts that conform to the specifications detailed in this Owner’s Manual. Genuine Ford and Motorcraft parts meet or exceed these specifications.

Collision Repairs

We hope that you never experience a collision, but accidents do happen. Genuine Ford replacement collision parts meet our stringent requirements for fit, finish, structural integrity, corrosion protection and dent resistance. During

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

vehicle development we validate that these parts deliver the intended level of protection as a whole system. A great way to know for sure you are getting this level of protection is to use genuine Ford replacement collision parts.

Warranty on Replacement Parts

Genuine Ford and Motorcraft replacement parts are the only replacement parts that benefit from a Ford Warranty. The Ford Warranty may not cover damage caused to your vehicle as a result of failed non-Ford parts. For additional information, refer to the terms and conditions of the Ford Warranty.

SPECIAL NOTICES

New Vehicle Limited Warranty

For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, see the Warranty Guide that is provided to you along with your Owner’s Manual.

Special Instructions

For your added safety, your vehicle has sophisticated electronic controls.

WARNINGS

You risk death or serious injury to yourself and others if you do not

follow the instruction highlighted by the warning symbol. Failure to follow the specific warnings and instructions could result in personal injury.

Never place front seat mounted

rear-facing child or infant seats in

front of an active passenger airbag.

On Board Diagnostics Data Link Connector

WARNING

Do not connect wireless plug-in devices to the data link connector.

Unauthorized third parties could gain access to vehicle data and impair the performance of safety related systems. Only allow repair facilities that follow our service and repair instructions to connect their equipment to the data link connector.

Your vehicle has an OBD Data Link Connector (DLC) that is used in conjunction with a diagnostic scan tool for vehicle diagnostics, repairs and reprogramming services. Installing an aftermarket device that uses the DLC during normal driving for purposes such as remote insurance company monitoring, transmission of vehicle data to other devices or entities, or altering the performance of the vehicle, may cause interference with or even damage to vehicle systems. We do not recommend or endorse the use of aftermarket plug-in devices unless approved by Ford. The vehicle Warranty will not cover damage caused by an aftermarket plug-in device.

Using your Vehicle With a Snowplow

More information and guidelines for using your vehicle with a snowplow are in this Owner's Manual. See Snowplowing (page

294).

Using your Vehicle as an Ambulance

If your light truck has the Ford Ambulance Preparation Package, it may be utilized as an ambulance. We urge ambulance manufacturers to follow the recommendations of the Ford Incomplete Vehicle Manual, Ford Truck Body Builder’s

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

Layout Book and the Qualified Vehicle Modifiers (QVM) Guidelines as well as pertinent supplements. For additional information, please contact the Truck Body Builders Advisory Service at http://www.fleet.ford.com/truckbbas/ and then by selecting Contact Us or by phone at 1–877–840–4338.

Use of your Ford light truck as an ambulance, without the Ford Ambulance Preparation Package voids the Ford New Vehicle Limited Warranty and may void the emissions warranties. In addition, ambulance usage without the preparation package could cause high underbody temperatures, overpressurized fuel and a risk of spraying fuel which could lead to fires.

If your vehicle has the Ford Ambulance Preparation Package, it will be indicated on the Safety Compliance Certification Label. The label is on the driver side door pillar or on the rear edge of the driver door. You can determine whether the ambulance manufacturer followed Ford’s recommendations by directly contacting that manufacturer. The Ford Ambulance Preparation Package is only available on certain diesel engine equipped vehicles.

Using your Vehicle as a Stationary Power Source

Information and guidelines for operating a vehicle with an aftermarket power take-off system are in this Owner's Manual. See

Power Take-Off (page 209).

MOBILE COMMUNICATIONS EQUIPMENT

WARNING

Driving while distracted can result in loss of vehicle control, crash and

Using mobile communications equipment is becoming increasingly important in the conduct of business and personal affairs. However, you must not compromise your own or others’ safety when using such equipment. Mobile communications can enhance personal safety and security when appropriately used, particularly in emergency situations. Safety must be paramount when using mobile communications equipment to avoid negating these benefits. Mobile communication equipment includes, but is not limited to, cellular phones, pagers, portable email devices, text messaging devices and portable two-way radios.

EXPORT UNIQUE OPTIONS

For your particular global region, your vehicle may be equipped with features and options that are different from the features and options that are described in this Owner’s Manual. A market unique supplement may be supplied that complements this book. By referring to the market unique supplement, if provided, you can properly identify those features,

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

recommendations and specifications that are unique to your vehicle. This Owner’s Manual is written primarily for the U.S. and Canadian Markets. Features or equipment listed as standard may be different on units built for export. Refer to this Owner’s

Manual for all other required information and warnings.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Introduction

PROTECTING THE ENVIRONMENT

You should play your part in protecting the environment. Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps toward this aim.

For more information visit Ford Motor Company's Environmental information and initiatives:

Web Address

www.sustainability.ford.com

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Environment

GENERAL INFORMATION

See the following sections for directions on how to properly use safety restraints for children.

WARNINGS

Always make sure your child is secured properly in a device that is

appropriate for their height, age and weight. Child safety restraints must be bought separately from your vehicle. Failure to follow these instructions and guidelines may result in an increased risk of serious injury or death to your child.

All children are shaped differently.

The National Highway Traffic Safety

Administration and other safety organizations, base their recommendations for child restraints on probable child height, age and weight thresholds, or on the minimum requirements of the law. We recommend that you check with a NHTSA Certified Child Passenger Safety

WARNINGS

Technician (CPST) to make sure that you properly install the child restraint in your vehicle and that you consult your pediatrician to make sure you have a child restraint appropriate for your child. To locate a child restraint fitting station and CPST, contact NHTSA toll free at 1-888-327-4236 or go to www.nhtsa.dot.gov. In Canada, contact Transport Canada toll free at 1-800-333-0371 or go to www.tc.gc.ca to find a Child Car Seat Clinic in your area. Failure to properly restrain children in child restraints made especially for their height, age and weight, may result in an increased risk of serious injury or death to your child.

On hot days, the temperature inside the vehicle can rise very quickly.

Exposure of people or animals to these high temperatures for even a short time can cause death or serious heat related injuries, including brain damage. Small children are particularly at risk.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

Recommendations for Safety Restraints for Children

Recommended restraint

type

Child size, height, weight, or ageChild

Use a child safety seat

(sometimes called an

infant carrier, convertible

seat, or toddler seat).

Children weighing 40 lb (18 kg) or less

(generally age four or younger).

Infants or

toddlers

Use a belt-positioning

booster seat.

Children who have outgrown or no longer

properly fit in a child safety seat (gener-

ally children who are less than 4 ft. 9 in.

(1.45 m) tall, are greater than age four and less than age 12, and between 40 lb (18 kg) and 80 lb (36 kg) and upward to

100 lb (45 kg) if recommended by your

child restraint manufacturer).

Small children

Use a vehicle seatbelt having the lap belt snug and low across the hips,

shoulder belt centered

across the shoulder and

chest, and seatback

upright.

Children who have outgrown or no longer

properly fit in a belt-positioning booster

seat (generally children who are at least

4 ft. 9 in. (1.45 m) tall or greater than 80 lb (36 kg) or 100 lb (45 kg) if recommended by child restraint manufacturer).

Larger children

• You are required by law to properly use safety seats for infants and toddlers in the United States and Canada.

• Many states and provinces require that small children use approved booster seats until they reach age eight, a height of 4 feet 9 inches (1.45 meters) tall, or 80 lb (36 kg). Check your local and state or provincial laws for specific requirements about the safety of children in your vehicle.

• When possible, always properly restrain children 12 years of age and under in a rear seating position of your vehicle. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in a front seating position.

INSTALLING CHILD RESTRAINTS

Child Seats

E142594

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

Use a child safety seat (sometimes called an infant carrier, convertible seat, or toddler seat) for infants, toddlers, or children weighing 40 lb (18 kg) or less (generally age four or younger).

Using Lap and Shoulder Belts (Except Front Center Position of Super Cab and Crew Cab)

WARNINGS

Airbags can kill or injure a child in a child restraint. Never place a

rear-facing child restraint in front of an active airbag. If you must use a forward-facing child restraint in the front seat, move the seat upon which the child restraint is installed all the way back.

Airbags can kill or injure a child in a

child restraint. Properly restrain

children 12 and under in the rear seat whenever possible.

Depending on where you secure a

child restraint, and depending on the

child restraint design, you may block access to certain seatbelt buckle assemblies and LATCH lower anchors, rendering those features potentially unusable. To avoid risk of injury, make sure occupants only use seating positions where they are able to be properly restrained.

When installing a child safety seat with combination lap and shoulder belts:

• Use the correct seatbelt buckle for that

seating position.

• Insert the belt tongue into the proper

buckle until you hear a snap and feel it latch. Make sure the tongue is securely fastened in the buckle.

• Keep the buckle release button

pointing up and away from the safety seat, with the tongue between the child restraint and the release button, to prevent accidental unbuckling.

• Place the vehicle seat upon which the child restraint will be installed in the upright position.

• Put the seatbelt in the automatic locking mode. This vehicle does not require the use of a locking clip.

Perform the following steps when installing the child restraint with combination lap and shoulder belts:

Note: Although the child restraint illustrated is a forward facing child restraint, the steps are the same for installing a rear facing child restraint.

E142528

1. Position the child safety seat in a seat with a combination lap and shoulder belt.

E142529

2. Pull down on the shoulder belt and then grasp the shoulder belt and lap belt together.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

E142530

3. While holding the shoulder and lap belt portions together, route the tongue through the child restraint according to the child restraint manufacturer's instructions. Be sure the belt webbing is not twisted.

E142531

4. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) for that seating position until you hear a snap and feel the latch engage. Make sure the tongue is latched securely by pulling on it.

E142875

5. To put the retractor in the automatic locking mode, grasp the shoulder portion of the belt and pull downward until you pull all of the belt out.

Note: The automatic locking mode is available on the front passenger and rear seats. This vehicle does not require the use of a locking clip.

6. Allow the belt to retract to remove slack. The belt clicks as it retracts to indicate it is in the automatic locking mode.

7. Try to pull the belt out of the retractor to make sure the retractor is in the automatic locking mode (you should not be able to pull more belt out). If the retractor is not locked, unbuckle the belt and repeat Steps 5 and 6.

E142533

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

8. Remove remaining slack from the belt. Force the seat down with extra weight, for example, by pressing down or kneeling on the child restraint while pulling up on the shoulder belt in order to force slack from the belt. This is necessary to remove the remaining slack that will exist once the extra weight of the child is added to the child restraint. It also helps to achieve the proper snugness of the child restraint to your vehicle. Sometimes, a slight lean toward the buckle helps to remove remaining slack from the belt.

9. Attach the tether strap (if the child restraint is equipped).

E142534

10. Before placing the child in the seat,

forcibly move the seat forward and back to make sure the seat is securely held in place.

To check this, grab the seat at the belt path and attempt to move it side to side and forward and back. There should be no more than 1 in (2.5 cm) of movement for proper installation.

We recommend checking with a NHTSA Certified Child Passenger Safety Technician to make certain the child restraint is properly installed. In Canada, check with Transport Canada for referral to a Child Car Seat Clinic.

Using Lap and Shoulder Belts (Front Center Position of Super Cab and Crew Cab)

WARNINGS

Airbags can kill or injure a child in a child restraint. Never place a

Never place front seat mounted

rear-facing child or infant seats in

front of an active passenger airbag.

Always use both the lap and

shoulder portion of the seatbelt in

the center seating position.

The belt webbing below the tongue is the lap portion of the combination lap and shoulder belt. The belt webbing above the tongue is the shoulder belt portion of the combination lap and shoulder belt.

E142528

1. Position the child safety seat in the

front center seat.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

E162708

2. Slide the tongue up the webbing.

E142530

3. While holding both shoulder and lap portions next to the tongue, route the tongue and webbing through the child restraint according to the child restraint manufacturer's instructions. Be sure that the belt webbing is not twisted.

E142531

E142533

5. While pushing down with your knee on the child restraint, pull up on the shoulder belt portion to tighten the lap belt portion of the combination lap and shoulder belt.

6. Allow the seatbelt to retract and remove any slack in the belt to securely tighten the child safety seat in the vehicle.

7. Attach the tether strap (if the child restraint is equipped).

E142534

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

8. Before placing the child in the seat, forcibly move the seat forward and back to make sure the seat is securely held in place. To check this, grab the seat at the belt path and attempt to move it side to side and forward and back. There should be no more than 1 in (2.5 cm) of movement for proper installation.

9. Check from time to time to be sure that there is no slack in the lap and shoulder belt. The shoulder belt must be snug to keep the lap belt tight during a crash.

Using Inflatable Seatbelts (Rear Seat Outboard Positions) (If Equipped)

E142528

1. Position the child safety seat in a seat with a combination lap and shoulder belt.

E146522

2. After positioning the child safety seat in the proper seating position, grasp the shoulder belt and lap belt together behind the belt tongue.

E142530

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

E146523

E146524

5. To put the retractor in the automatic locking mode, grasp the lap portion of the inflatable seatbelt and pull upward until you pull all of the belt out.

Note: The automatic locking mode is available on the front passenger and rear seats.

Note: Unlike the standard seatbelt, the inflatable seatbelt's unique lap portion locks the child restraint for installation. The ability for the shoulder portion of the belt to move freely is normal, even after the lap belt has been put into the automatic locking mode.

Note: The lock-off device on some child restraints may not accommodate the shoulder portion of the inflatable seatbelt. Follow all instructions provided by the manufacturer of the child restraint regarding the necessary and proper use of the lock-off device. In some instances, these devices have been provided only for use in vehicles with seatbelt systems that would otherwise require a locking clip.

6. Allow the belt to retract to remove slack. The belt clicks as it retracts to indicate it is in the automatic locking mode.

E146525

8. Remove remaining slack from the belt. Force the seat down with extra weight, for example, by pressing down or kneeling on the child restraint while pulling down on the lap belt in order to force slack from the belt. This is

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

necessary to remove the remaining slack that will exist once the extra weight of the child is added to the child restraint. It also helps to achieve the proper snugness of the child restraint to your vehicle. Sometimes, a slight lean toward the buckle will additionally help to remove remaining slack from the belt.

9. Attach the tether strap (if the child restraint is equipped).

E142534

10. Before placing the child in the seat,

forcibly move the seat forward and back to make sure the seat is securely held in place. To check this, grab the seat at the belt path and attempt to move it side to side and forward and back. There should be no more than 1 in (2.5 cm) of movement for proper installation.

Using Lower Anchors and Tethers for CHildren (LATCH)

WARNINGS

Do not attach two child safety restraints to the same anchor. In a

crash, one anchor may not be strong enough to hold two child safety restraint attachments and may break, causing serious injury or death.

Depending on where you secure a

child restraint, and depending on the

The LATCH system is composed of three vehicle anchor points: two lower anchors where the vehicle seatback and seat cushion meet (called the seat bight) and one top tether anchor behind that seating position.

LATCH compatible child safety seats have two rigid or webbing mounted attachments that connect to the two lower anchors at the LATCH equipped seating positions in your vehicle. This type of attachment method eliminates the need to use seatbelts to attach the child restraint. However, you can still use the seatbelt to attach the child restraint if the lower anchors are not used. For forward-facing child restraints, you must also attach the top tether strap to the proper top tether anchor if a top tether strap has been provided with your child restraint.

Your vehicle has LATCH lower anchors for child restraint installation at the following seating positions (LATCH is not available on Regular Cab):

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

Crew Cab and Super Cab

E166694

E166695

The lower LATCH anchors are at the rear section of the rear seat between the cushion and seatback. Follow the child restraint manufacturer's instructions to properly install a child restraint with LATCH attachments.

Follow the instructions later in this chapter on attaching child safety seats with tether straps.

Attach LATCH lower attachments of the child restraint only to the anchors shown.

Use of Inboard Lower Anchors from the Outboard Seating Positions (Center Seating Use)

WARNING

The standardized spacing for LATCH lower anchors is 11 in (280 mm)

center to center. Do not use LATCH lower anchors for the center seating position unless the child restraint manufacturer's instructions permit and specify using anchors spaced at least as far apart as those in this vehicle.

The lower anchors at the center of the second row rear seat are spaced 26 in (652 mm) apart. The standardized spacing for LATCH lower anchors is 11 in (280 mm) center to center. You cannot install a child restraint with rigid LATCH attachments at the center seating position. LATCH compatible child restraints (with attachments on belt webbing) can only be used at this seating position provided that the child restraint manufacturer's instructions permit use with the anchor spacing stated. Do not attach a child restraint to any lower anchor if an adjacent child restraint is attached to that anchor.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

Each time you use the safety seat, check that the seat is properly attached to the lower anchors and tether anchor, if applicable. Tug the child restraint from side to side and forward and back where it is secured to the vehicle. The seat should move less than 1 in (2.5 cm) when you do this for a proper installation.

If the safety seat is not anchored properly, the risk of a child being injured in a crash greatly increases.

Combining Seatbelt and LATCH Lower Anchors for Attaching Child Safety Seats

When used in combination, either the seatbelt or the LATCH lower anchors may be attached first, provided a proper installation is achieved. Attach the tether strap afterward, if included with the child restraint.

Using Tether Straps

Many forward-facing child safety seats include a tether strap which extends from the back of the child safety seat and hooks to an anchoring point called the top tether anchor. Tether straps are available as an accessory for many older safety seats.

Contact the manufacturer of your child restraint for information about ordering a tether strap, or to obtain a longer tether strap if the tether strap on your safety seat does not reach the appropriate top tether anchor in the vehicle.

The passenger seats of your vehicle may have built-in tether strap anchors behind the seats as described below.

The tether anchors in your vehicle may be loops of webbing above the seatback or an anchor bracket behind the seat on the rear edge of the seat cushion.

The rear seat in the Crew Cab and Super Cab has three straps along the top of the seatback that function as both routing loops for the tether straps and anchor loops.

The tether strap anchors in your vehicle are in the following positions (shown from top view):

Regular Cab

E166696

Note: The center top tether anchor is not available if there is no center seat.

Super Duty (TFE) Canada/United States of America, enUSA, Edition date: 201702, Third Printing

Child Safety

+ 612 hidden pages

Ford F 250 2017, F 550 2017 Owner's Manual

Specifications and Main Features

Frequently Asked Questions

User Manual

ABOUT THIS MANUAL

Introduction

SYMBOLS GLOSSARY

DATA RECORDING

CALIFORNIA PROPOSITION 65

PERCHLORATE

FORD CREDIT

REPLACEMENT PARTS RECOMMENDATION

SPECIAL NOTICES

MOBILE COMMUNICATIONS EQUIPMENT

EXPORT UNIQUE OPTIONS

PROTECTING THE ENVIRONMENT

Environment

GENERAL INFORMATION

Child Safety

INSTALLING CHILD RESTRAINTS