Evo Classic Series, Companion Classic Series Owner's Manual

Companion Classic Series

the natural way to cookthe natural way to cook

®

®

Owner’s Manual

Certifi cation: ANSI Z21.58-2002/CGA 1.6B-2002
Part #: Residential models: 10-0091-NG, 10-0091-LP, 10-0093-NG, 10-0093-LP
Report# 141-S-02-5
Copyright © 2013

1

For Outdoor

Use Only

Some parts may contain sharp edges
as especially noted in this manual.
Wear protective gloves as necessary.

Warnings

FOR YOUR SAFETY

1. Do not store or use gasoline or other
fl ammable vapors and liquids in the
vicinity of this or any other appliance.

2. An LP Tank not connected for use
shall not be stored in the vicinity of
this or any other appliance.

WARNING

This symbol identifi es the most important safety messaging in this

manual. When you see this symbol, be alert to the possibility of

serious bodily injury if the instructions are not followed.

Be sure to read and carefully follow all of the messages.

FOR YOUR SAFETY

If You Smell Gas:

1. Shut off gas to appliance.

2. Extinguish any open fl ame.

3. Remove grill cooking surface.

4. If odor continues, immediately
call your gas supplier or your fi re
department.

WARNING

It is the responsibility of the assembler/owner to assemble, install

and maintain gas grill. Do not let children operate or play near

your grill. Failure to follow these instructions could result

in serious personal injury and/or property damage.

WARNING

Grill is for outdoor use only. Grill should be operated in a well-

ventilated space. Never operate in an enclosed space, garage

or building. Do not install or use grill within 24” of combustible

materials from back and sides of grill. Grill shall not be located

under unprotected overhead (enclosed carport, garage, porch,

patio) made of combustible construction.

2

EVO RESIDENTIAL LIMITED WARRANTY TERMS

Evo, Incorporated warrants to the original residential consumer-purchaser that the Evo grill shall be free from rust-through
on all metal surfaces and shall be free from defects in materials and workmanship under normal and reasonable use from
the original date of purchase. Evo promises to replace, at its determination, any product or component that is defective
and covered under this warranty for as long as you, the registered original consumer-purchaser, owns the grill. This is your
sole and exclusive remedy. This warranty is for the benefi t of the original consumer-purchaser and is non-transferable. This
warranty is subject to the limitations, exclusions and other provisions listed below.

Limitations Involving Materials and Components:

Warranty does not apply to normal wear and tear, which are expected over the course of ownership. The materials and
components listed below are covered according to the following schedule from the original date of purchase:

• One Year – electrical and electronic components [including, but not limited to, electronic displays, overlay and membrane
switches, temperature sensors (RTD and K-Value Thermal Couple), hot surface igniters, computers,
transformers, heater elements, relays, igniters, ignition controllers, wiring, switches, encoders, outlets and
plugs

• One Year – gas components [including, but not limited to, gas regulator, gas hoses, manifold assemblies]

• One Year – accessories and repair parts

The Warranty Registration Card (or online warranty registration form available at www.evoamerica.com/content/
residential-warranty-registration) must be completed and returned/submitted to Evo, Incorporated within 30 days
from the date of purchase. The original purchase invoice or payment record must be retained and produced upon
request if claims are made under this warranty. To receive a replacement Warranty Registration Card, write or call
the address listed at the bottom of this page. Warranties are void if the original serial numbers have been removed,
altered, or cannot be readily determined.

THIS WARRANTY APPLIES ONLY TO PRODUCTS PURCHASED AND LOCATED WITHIN THE UNITED
STATES OR CANADA.

WHAT IS NOT COVERED BY THIS WARRANTY

1. Conditions and damages resulting from any of the following:

a. Improper or inadequate installation, delivery, use, storage or maintenance
b. Any repair not authorized in writing by Evo, Inc., any modifi cations, misapplications, or unreasonable use
c. Improper setting of any control
d. Harsh environmental conditions, including, but not limited to, continual seawater spray, high pressure water, and direct
contact with corrosive chemicals and materials
e. Excessive or inadequate electrical, or gas supply
f. Accidents, natural disasters, acts of God
g. Conditions covered by the purchaser’s insurance
h. Cleaning supplies and fi lters

2. Products purchased or utilized for commercial use without the express authorization of Evo, Incorporated for such use

3. Labor not pre-authorized by Evo, Incorporated, and labor not performed by an authorized Evo service agency or

representative

4. Pre-authorized warranty labor performed outside of normal business hours, and at overtime and premium rates

5. The cost of service or a service call to:

a. Identify or correct installation errors
b. Transport the product or component for service to/from the manufacturer or service center
c. Instruct the user of the proper use of the product

6. The cost for any inconvenience, personal injury or property damage due to failure of the product, and cost of damage arising

out of the transportation of the product which is covered under different terms with the carrier

7. Natural variations in color and fi nishes that are inherent to the material and unavoidable (and therefore not defects)

ALL IMPLIED WARRANTIES, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY, SUITABILITY,
QUALITY AND/OR FITNESS FOR A PARTICULAR PURPOSE, ARE LIMITED IN DURATION TO THE
EXPRESS WARRANTY PERIODS SPECIFIED ABOVE FOR THE PARTS DESCRIBED THEREIN. EVO,
INCORPORATED MAKES NO OTHER WARRANTY AND WILL NOT BE LIABLE FOR ANY DIRECT OR
INDIRECT, CONSEQUENTIAL OR INCIDENTAL DAMAGES. Some states do not allow limitations on how long an

implied warranty lasts, so the above limitation may not apply to you. Neither Evo manufacturer representatives and dealers,
nor the retail establishment selling this product has any authority to make any warranties or to promise remedies in addition
to or inconsistent with those stated above. The maximum liability to Evo, Incorporated in any event, shall not exceed the
purchase price of the product paid by the original consumer-purchaser. Some states do not allow the exclusion or limitation
of incidental or consequential damages, so the above limitations or exclusions may not apply to you. This warranty gives you
specifi c legal rights, and you may also have other rights which vary from state to state.

3

Table Of Contents Assembly Note

Warnings .............................................................................2

Limited Warranty .................................................................3

Table Of Contents ................................................................4

Assembly Note ....................................................................4

Notes ...................................................................................5

Safety Reminders ................................................................6

Consumer Service ...............................................................6

Before Setting Up Your Grill................................................. 6

Know Y our Grill .................................................................... 7

Exploded View ..................................................................... 7

Installing Cook Surface & Hood...........................................8

Cook Surface To Burner Unit ...............................................8

Hood Handle & Hood Support .............................................8

Resting Hood On Drip Pan ..................................................8

Installation and Storage of LP Tank .....................................9

Removing Leg Support ........................................................ 9

Installing Vinyl Tank Sleeve ................................................. 9

Connecting Regulator To Tank Valve ...................................10

Removal & Storage Of LP Gas Tank ................................... 10

Installing Natural Gas Connection To Grill ...........................11

General Specifi cations For Piping ....................................... 11

Gas Line Piping ................................................................... 11

Installing Natural Gas Hose ................................................. 12

Checking Gas Connection To Grill ....................................... 13

Checking For Gas Leaks .....................................................13

Grill Maintenance, Cooking Techniques, and Recipes ........14

The Evo Companion Series Wheeled Cart is
shipped either a partially assembled or fully
assembled. These instructions do not include
installation of partially assembled units.

4

Notes

To Installer or Person Assembling Grill:

Leave these instructions with consumer.

To Consumer:

Keep these instructions for future reference.

Complete Now For Future Reference

Serial # _____________________________
Date of Purchase ______________________
Place of Purchase _____________________

5