Electrolux NHT8, EHT8, KHT8, AHT8I, EHT8I User Manual

...
Page 1
ENGLISH
EN INDEX
A GENERAL INFORMATION .............................................................................. Page 7
A1 Introduction ...................................................................................................................... Page 7
A2 Definitions ........................................................................................................................ Page 7
A3 Typographical conventions .............................................................................................. Page 7
A4 Machine and Manufacturer’s identification data............................................................... Page 7
A5.1 How to identify the technical data........................................................................ Page 8
A5.2 How to interpret the factory description............................................................... Page 8
A6 Copyright ......................................................................................................................... Page 8
A7 Liability............................................................................................................................. Page 8
A8 Personal protection equipment ........................................................................................ Page 9
A9 Keeping the manual......................................................................................................... Page 9
A10 Users of the manual ........................................................................................................ Page 9
B GENERAL DESCRIPTION OF MACHINE ....................................................... Page 10
B1 General description ......................................................................................................... Page 10
C TECHNICAL DATA ........................................................................................... Page 10
C1 Main technical characteristics.......................................................................................... Page 10
C2 Characteristics of power supply....................................................................................... Page 11
D TRANSPORT, HANDLING AND STORAGE.................................................... Page 12
D1 Introduction...................................................................................................................... Page 12
D1.1 Transport: Instructions for the carrier................................................................... Page 12
D2 Handling .......................................................................................................................... Page 12
D2.1 Procedures for handling operations..................................................................... Page 12
D2.2 Translation ........................................................................................................... Page 12
D2.3 Placing the load................................................................................................... Page 12
D3 Storage ............................................................................................................................ Page 12
E INSTALLATION AND ASSEMBLY ................................................................... Page 13
E1 Customer responsibilities ................................................................................................ Page 13
E2 Characteristics of the place of machine installation......................................................... Page 13
E3 Machine space limits ....................................................................................................... Page 13
E4 Positioning ....................................................................................................................... Page 13
E5 Disposal of packing ......................................................................................................... Page 14
E6 Plumbing connections ..................................................................................................... Page 14
E6.1 Plumbing circuits ................................................................................................. Page 14
E6.2 Installation diagrams............................................................................................ Page 15
E7 Electrical connections...................................................................................................... Page 22
E8 Energy control arrangement ............................................................................................ Page 22
E9 HACCP arrangement....................................................................................................... Page 23
F DESCRIPTION OF CONTROL PANEL ............................................................ Page 24
F1 Basic controls .................................................................................................................. Page 25
G STARTING ........................................................................................................ Page 26
G1 Preliminary checks, adjustments and operational tests................................................... Page 26
G1.1 Electrical and plumbing checks ........................................................................... Page 26
G1.2 Check the positioning of tank components.......................................................... Page 26
3
Page 2
G1.2.1 Check the fitting of filters and overflows............................................ Page 26
G1.2.2 Arm fitting check................................................................................ Page 26
G2 Starting ............................................................................................................................Page 26
G3 Detergent/rinse-aid dispensers and settings ...................................................................Page 26
G4 Setting the dispensers .....................................................................................................Page 27
H GENERAL SAFETY RULES.............................................................................Page 30
H1 Introduction ......................................................................................................................Page 30
H1.1 Protection devices installed on the machine........................................................Page 30
H1.1.1 Guards .............................................................................................. Page 30
H1.2 Safety signs to be displayed on the machine or near the work area ................... Page 30
H2 Decommissioning ............................................................................................................ Page 30
H3 Instructions for use and maintenance ..............................................................................Page 30
H4 Improper use....................................................................................................................Page 31
H5 Residual risks .................................................................................................................. Page 31
I NORMAL MACHINE USE.................................................................................Page 32
I1 Correct use ......................................................................................................................Page 32
I2 Characteristics of personnel enabled to operate on the machine....................................Page 32
I3 First use ........................................................................................................................... Page 32
I4 Daily activation of machine ..............................................................................................Page 32
I5 Wash cycles..................................................................................................................... Page 32
I6 Operation ......................................................................................................................... Page 33
I7 Alarms ............................................................................................................................. Page 35
I8 Hood type dishwasher with incorporated continuous water softener............................... Page 35
I9 Machine cleaning............................................................................................................. Page 36
I9.1 End of service and daily internal cleaning ...........................................................Page 36
I9.2 Exterior cleaning..................................................................................................Page 37
I10 Long idle periods .............................................................................................................Page 37
I11 Maintenance ....................................................................................................................Page 37
I11.1 Preventive maintenance ......................................................................................Page 37
I12 Machine disposal.............................................................................................................Page 38
I13 Troubleshooting ...............................................................................................................Page 38
4
Page 3
ENGLISH
EN INDEX OF FIGURES AND TABLES
INDEX OF FIGURES
Figure 1 Reproduction of the marking/dataplate on the machine..................................................... Page 7
Figure 2 Position of marking............................................................................................................. Page 8
Figure 3 Technical data identification ............................................................................................... Page 8
Figure 4 Example of document identification data. .......................................................................... Page 8
Figure 5 Unpacking .......................................................................................................................... Page 13
Figure 6 Machine positioning ........................................................................................................... Page 13
Figure 7 Removing the film ..............................................................................................................Page 13
Figure 8 Feet adjustment ................................................................................................................. Page 13
Figure 9 Machine fixing clamp.......................................................................................................... Page 13
Figure 10 Feed pipe connection......................................................................................................... Page 14
Figure 11 380-415V 3N ...................................................................................................................... Page 22
Figure 12 400-440V 3 ........................................................................................................................ Page 22
Figure 13 220-240V 3 ........................................................................................................................ Page 22
Figure 14 220-240V 1N ...................................................................................................................... Page 22
Figure 15 Energy control .................................................................................................................... Page 22
Figure 16 HACCP connection position............................................................................................... Page 23
Figure 17 Filters and overflow ............................................................................................................ Page 26
Figure 18 Wash and rinse arms ......................................................................................................... Page 26
Figure 19 Automatic dispenser arrangement ..................................................................................... Page 27
Figure 20 Detergent dispenser terminal block.................................................................................... Page 27
Figure 21 Rinse aid dispenser terminal block .................................................................................... Page 27
Figure 22 Automatic hood opening/closing ........................................................................................ Page 33
Figure 23 YELLOW rack..................................................................................................................... Page 34
Figure 24 GREEN rack....................................................................................................................... Page 34
Figure 25 BLUE rack for glasses........................................................................................................ Page 34
Figure 26 YELLOW container for cutlery............................................................................................ Page 34
Figure 27 Unscrew the salt container cap .......................................................................................... Page 36
Figure 28 Add the salt ........................................................................................................................ Page 36
Figure 29 Filters and overflow ............................................................................................................ Page 36
Figure 30 Wash and rinse arms ......................................................................................................... Page 37
INDEX OF TABLES
Ta bl e 1 Main technical characteristics, performance and consumption.......................................... Page 10
Ta bl e 2 Control panel...................................................................................................................... Page 24
Ta bl e 3 Residual risks..................................................................................................................... Page 31
5
Page 4
Foreword
The instruction manual (hereinafter Manual) provides the operator with useful information for working correctly and safely, facilitating him in using the machine (hereinafter “machine”, “dishwasher” or “equipment”).
The following must not be considered a long and exacting list of warnings, but rather a set of instructions suitable for improving machine performance in every respect and, above all, preventing injury to persons and animals and dam­age to property due to improper operating procedures.
All persons involved in machine transport, installation, starting, use and maintenance, repair and dismantling must consult and carefully read this manual before performing the various operations, for the purpose of avoiding wrong and improper actions that could negatively affect the machine’s integrity or endanger persons.
The manual must always be available to operators and carefully kept in the place where the machine is used so that it is immediately at hand for consultation in case of doubts or whenever required.
If, after reading this manual, there are still doubts regarding machine use, do not hesitate to contact the Manufac­turer, or the authorized assistance centre, to receive prompt and precise assistance for better operation and maxi­mum efficiency of the machine.
During all phases of machine use, always respect the current regulations on safety, work hygiene and environmental protection. It is the user’s responsibility to make sure the machine is started and operated only in optimal safety con­ditions for persons, animals and property.
This appliance is not intended for use by people (including children) with limited physical, sensory or mental abilities or without experience and knowledge of it, unless they are supervised or instructed in its use by a person responsi­ble for their safety.
Children must be supervised to make sure they do not play with the equipment.
6
Page 5
ENGLISH
A GENERAL INFORMATION
A1 Introduction
This chapter describes the symbols used (that mark and identify the type of warning) and gives the defini­tions of terms used in the manual, responsibilities and copyright.
Emergency stop device
a group of components intended for the emergency stop function; the device is activated with a single action and prevents or reduces damage to persons/ machines/property/animals.
Electrocution
an accidental discharge of electric current on a human body.
A2 Definitions
Listed below are the definitions of the main terms used in the Manual. Carefully read them before using the Manual.
Operator
an operator who carries out machine installation, adjustment, use, maintenance, cleaning, repair and transport.
Manufacturer
Electrolux Professional S.p.A. or any other assistance centre authorized by Electrolux Professional S.p.A..
Operator qualified for normal machine use
an operator who has been informed, instructed and trained regarding the tasks and hazards involved in normal machine use.
Specialized technician or Technical assistance
an operator instructed/trained by the Manufacturer and who, based on his professional and specific training, experience and knowledge of the accident-prevention regulations, is able to appraise the operations to be carried out on the machine and recognize and prevent possible risks. His professionalism covers the mechan­ical, electrotechnical and electronics fields.
Danger
source of possible injury or harm to health.
Hazardous situation
any situation where an operator is exposed to one or more hazards.
Risk
a combination of probabilities and risks of injury or harm to health in a hazardous situation.
Guards
safety measures consisting of the use of specific tech­nical means (guards and safety devices) for protecting operators against dangers.
Guard
an element of a machine used specifically to provide protection by means of a physical barrier.
Safety device
a device (other than a guard) that eliminates or reduces the risk; it can be used alone or in combina­tion with a guard.
Customer
the person who purchased the machine and/or who manages and uses it (e.g. company, entrepreneur, firm).
A3 Typographical conventions
For best use of the manual, and therefore the machine, it is advisable to have good knowledge of the terms and typographical conventions used in the documenta­tion.
The following symbols are used in the manual to mark and identify the various types of hazards:
WARNING! DANGER FOR THE HEALTH AND
SAFETY OF OPERATORS.
WARNING! DANGER OF ELECTROCUTION - DAN-
GEROUS VOLTAGE.
Machine guards and protection devices marked with this symbol must only be opened by qualified person­nel, after disconnecting the power to the machine.
WARNING! DANGER OF DAMAGE TO THE MACHINE.
Words and safety warnings further explaining the type of hazard are placed next to the symbols in the text. The warnings are intended to guarantee the safety of personnel and prevent damage to the machine or the product being worked.
The drawings and diagrams given in the manual are not in scale. They supplement the written information with an outline, but are not intended to be a detailed representation of the machine supplied.
The numerical values given in the machine installation diagrams refer to measurements expressed in mm (see pargraph E6.2 “Installation diagrams”).
A4 Machine and Manufacturer’s identification
data
A reproduction of the marking or dataplate on the machine is given below.
2012 F.Mod. EHT8I Comm. Model EHT8I PNC 9CGX 504259 00 Ser.Nr. 22006001 EL AC 400V 3N 50 Hz Max 12.9 kW
Min 6.9 kW
Electrolux Professional spa - Viale Treviso, 15 - 33170 Pordenone (Italy)
(AC 230 V / 1+N / 50 Hz; 230 V / 3 / 50 Hz )
T
Figure 1 Reproduction of the marking/dataplate
on the machine.
Nominal 9.9 kW
IP25
7
Page 6
The dataplate gives the product identification and tech-
2012 F.Mod. EHT8I Comm. Model EHT8I PNC 9CGX 504259 00 Ser.Nr. 22006001 EL AC 400V 3N 50 Hz Max 12.9 kW
(AC 230 V / 1+N / 50 Hz; 230 V / 3 / 50 Hz )
Nominal 9.9 kW
Min 6.9 kW
Electrolux Professional spa - Viale Treviso, 15 - 33170 Pordenone (Italy)
IP25
F.Mod. EHT8I
Electrolux Professional spa - Viale Treviso, 15
C1 Main technical characteristics
MODEL EHT8I
Power supply Electric
Power supply voltage V 400 3N
Frequency Hz 50 or 60
Month YearEdition
Number
Document
nical data; the meaning of the information given on it is listed below.
F.Mod..................... factory description of the product
Comm. Model ........ trade description
PNC.......................
production code number
Ser. Nr. ................. serial number
AC 400V 3N ......... power supply voltage
(AC 230 V / 1+N / 50 Hz; 230 V / 3 / 50 Hz)
... electric convertibility
50 Hz..................... power supply frequency
Max 12.9 kW ......... max. power absorbed
Nominal 9.9 kW .....
Min 6.9 kW ............
power absorbed as factory setting power absorbed with min. supply
water temperature of 65°C/ 149°F
2012 ...................... year of construction
CE ......................... CE marking
IP25....................... protection rating
Electrolux Professional spa - Viale Treviso, 15 -33170 Pordenone (Italy)
..... Manufacturer
The marking plate is located on the right side panel of the equipment.
.
Figure 3 Technical data identification
A5.2 How to interpret the factory description
The factory description on the dataplate has the follow­ing meaning (some examples are given below):
Single-skin hood version
(1) (2) (3) (4) (5) (6) (7)
NHT8WSG EHT8 M
Double-skin hood version
(1) (2) (3) (4) (5) (6) (7)
ZHT8 I E L G EHT8 T I E L
Figure 2 Position of marking
WARNING! Do not remove, tamper with or make
the machine marking illegible.
IMPORTANT! Refer to the data given on the machine
marking for relations with the Manufac­turer (e.g. when ordering spare parts, etc.).
IMPORTANT! When disposing of the machine the
marking must be destroyed.
A5 Equipment identification
A5.1 How to identify the technical data
To identify the technical data (Figure 3) read the fac­tory description of the product (F.Mod.) on the data­plate, identify the main machine data and consult the Table 1 “Main technical characteristics, performance and consumption”.
8
Variables description
(1) Mark N = To brand, Z = Zanussi, K = Kipro, A = Alpeninox,
(2) Machine type HT = Hood type
(3) Racks/h 8 = capacity 80 racks/h
(4).. (7) T = automatic, I = double-skin hood, E = Energy
E = Electrolux.
Saving Device, L = De-lime cycle, G = Detergent pump + rinse aid pump + drain pump, DD = Detergent pump, WS = Water softener, M = Marine, USPH = Marine-USPH, 6 = 60 Hz., UK=UK market.
A6 Copyright
This manual is intended for consultation only by the operator and can be given to third parties only with the written permission of Electrolux Professional S.p.A..
A7 Liability
The instructions are updated to the month and year given in the box located at the bottom right of the cover. The edition corresponds to the manual revision number. Every new edition replaces and cancels the previous ones.
DOC. NO. 5956.68U.02
EDITION: 1 04.2013
Figure 4 Example of document identification data.
Page 7
ENGLISH
The Manufacturer declines any liability for damage and malfunctioning caused by:
• non-compliance with the instructions contained in this manual;
• repairs not carried out in a workmanlike fashion, and replacements using spare parts different from those specified in this manual (the fitting and use of non-original spare parts and accessories can nega­tively affect machine operation);
• operations by non-specialized technicians;
• unauthorized modifications or operations;
• inadequate maintenance;
• improper machine use;
• unexpected extraordinary events;
• use of the machine by uninformed and untrained personnel;
• non-application of the current provisions in the country of use, concerning safety, hygiene and health in the workplace.
The Manufacturer declines any liability for damage caused by arbitrary modifications and conversions car­ried out by the user or the Customer.
The employer or workplace manager is responsible for identifying and choosing adequate and suitable per­sonal protection equipment to be worn by operators, in compliance with current regulations in the country of use.
Electrolux Professional S.p.A. declines any liability for possible inaccuracies contained in the manual, if due to printing or translation errors.
Any supplements to the instruction manual the Cus­tomer receives from the Manufacturer must be kept together with the manual, of which they will form an integral part.
A8 Personal protection equipment
Give below is a summary table of the Personal Protec­tion Equipment (PPE) to be used during the various
stages of the machine’s service life.
Stage
Transport
Handling
Unpacking
Assembly
Normal use
Adjustments
Routine cleaning Extraordinar y cleaning
Maintenance
Dismantling
Scrapping
Key:
Protective
garments
C
M M
F
F
M M M (1)
F
F
F
F
F
F
Safety foot-
wear
M
M M
M M M (1) M M (1) M M M
Gloves Glasses Safety
F
F
F
F
C CC CC CC
F
helmet
F
C
CCC
C C
F
F
F
F
F
CC CC CC
M PPE REQUIRED
F
C
(1)
Use heat resistant gloves suitable for contact with
PPE AVAILABLE OR TO BE USED IF NECESSARY PPE NOT REQUIRED
water and the substances used (see the safety data sheet of the substances used to check other possible PPE).
Failure to use the personal protection equipment by operators, specialised technicians or users can involve exposure to chemical risk and possible damage to health.
A9 Keeping the manual
The manual must be carefully kept for the entire life of the machine until decommissioning.
The manual must stay with the machine in case of transfer, sale, hire, granting of use or leasing.
A10 Users of the manual
This manual is intended for:
• the carrier and handling personnel;
• installation and start-up personnel;
• the employer of machine users and the workplace manager;
• operators in charge of normal machine use;
• specialized technicians - technical assistance (see wiring diagram and service manual).
9
Page 8
B GENERAL DESCRIPTION OF MACHINE
B1 General description
The dishwasher is suitable for washing dishes, glasses, cups, cutlery, trays, containers and receptacles in plastic and/or steel used for preparing, cooking and serving; as well as various cooking utensils in ceramic and/or metal.
The machine is designed for the above-mentioned applications. Under no circumstances may the machine be used for other applications or ways not provided for in this manual.
This equipment has been produced to meet the needs for a better work environment and economical efficiency. These dishwashers are used in restaurants, cafeterias, cooking centres and large institutions.
The special dish racks, that can be equipped with various inserts, offer practical and easy use for obtaining excellent washing results. The electronic system enables complete supervision of the washing process. The control panel also has a display that shows the operating parameters and signals any anomalies.
Systems for scraping and wetting the dishes (e.g. manual prewash spray) and areas for sorting and arranging them in the racks must be arranged ahead of the dishwasher.
C TECHNICAL DATA
C1 Main technical characteristics
MODEL NHT8/ EHT8/
Supply voltage: V 400V 3N 400V 3N(°) 400V 3 440V 3 400V 3N
- convertible to V 230V 3 230V 3(°) - - 230V 3
- convertible to V 230V 1N 230V 1N(°) - - 230V 1N
Frequency Hz 50 50 or 60 50 60 50
Max. power. absorbed kW 12,9 (*) 12,9 (*) 12,9 (*) 12,9 (*) 12,9 (*)
power absorbed as factory setting
Power absorbed with min. supply water temperature of 65°C / 149°F
Boiler heating elements kW 9,0 9,0 9,0 9,0 9,0
Tank heating elements kW 3.0 3,0 3,0 3,0 3,0
Water supply pressure kPa [bar] 50-700 [0,5-7] 50-700 [0,5-7] 50-700 [0,5-7] 50-700 [0,5-7] 50-700 [0,5-7]
Water supply temperature:
- for models without ESD °C/ °F 10-65 / 50-149 10-65 / 50-149 10-65 / 50-149 10-65 / 50-149 10-65 / 50-149
- for models with ESD °C/ °F - 10-20 / 50-68 - - 10-20 / 50-68
Water supply hardness for models without incorporated continuous water softener
Water supply hardness for models with incorporated water softener
Electric conductivity of water for models without incorporated continuous water softener
Concentration of chlorides in water ppm < 20 < 20 < 20 < 20 < 20
Rinse cycle water consumption l 2,0 2,0 2,0 2,0 2,0
Boiler capacity l12 12 12 12 12
Tank capacity l24 24 24 24 24
Cycle duration in High Productivity mode ($) sec. 45(***)-84-150 45(***)-84-150 45(***)-84-150 45(***)-84-150 45(***)-84-150
Cycle duration in ETL-Sanitization mode ($) sec. 57(***)-84-150 57(***)-84-150 57(***)-84-150 57(***)-84-150 57(***)-84-150
Legal noise level Leq dB(A) <68 <63 <68 / <63 <68 / <63 <63
Protection rating IP25 IP25 IPX5 IPX5 IP25
Net weight without/with ESD kg 106 / - 117 / 150 117 / - 117 / - 119 / 152
Power supply cable H07RN-F H07RN-F H07RN-F H07RN-F H07RN-F
Supply cord diameter (min. - max. value) mm 18 - 25 18 - 25 18 - 25 18 - 25 18 - 25
Latent heat without/with ESD kWh 0,5/ - 0,5/ 0,35 0,5/ - 0,5/ - 0,5/ 0,35
Sensible heat without/with ESD kWh 2/ - 2/ 1,49 2/ - 2/ - 2/ 1,49
(*) = If activated by software, coincidence of tank and boiler heating elements. (**) = Activatable via software only by a specialized technician. (***) = With water supply temperature at 65°C / 149°F. ($) = In models with energy saving device (ESD) cycle duration is extended by 11 seconds. (°) = For the model EHT8IELG6: 380-400V 3N convertible 220-230V 3 or 220-230V 1N.
kW 9,9 9,9 9,9 9,9 9,9
kW 6,9 (**) 6,9 (**) - - 6,9 (**)
°f/°d/°e 14/8/10 max 14/8/10 max 14/8/10 max 14/8/10 max 14/8/10 max
°f/°d/°e 53.4/30/37.5 max 53.4/30/37.5 max - - -
S/cm < 400 < 400 < 400 < 400 < 400
KHT8
ZHT8I / AHT8I / EHT8I / NHT8I
EHT8M / EHT8IUSPH5
EHT8M6/ EHT8IUSPH6
ZHT8TIL/ EHT8TIL
10
Table 1 Main technical characteristics, performance and consumption
Page 9
ENGLISH
380-415V 3N 400-440V 3 220-240V 3 220-240V 1N
CSCSCSCS
6,9 kW
9,9 kW
12,9 kW
C = Power supply cable S = On/Off switch
5X2,5 mm
5X2,5 mm
5X4 mm
2
2
2
16A 3P+N
20A 3P+N
32A 3P+N
5X2,5 mm
4X2,5 mm
4X4 mm
2
16A 3P
2
20A 3P
2
25A 3P
4X10 mm
4x4 mm
4X6 mm
2
20A 3P
2
32A 3P
2
50A 3P
3X10 mm
3X10 mm
3x6 mm
2
2
2
40 A 1P+N
60 A 1P+N
70 A 1P+N
Standard cycle time may vary should the inlet water temperature be different from that indicated above.
C2 Characteristics of power supply
The AC power supply to the machine must meet the following conditions:
• max. voltage variation ± 10%
• max. frequency variation ± 1% continuous ± 2% for a short period. Harmonic distorsion, unbalanced three-phase supply voltage, voltage pulses, interruption, dips and the other electric
characteristics must respect the provisions of point 4.3.2 of Standard EN 60204-1 (IEC 60204-1).
IMPORTANT! The machine’s power supply must be protected against overcurrents (short circuits and over-
loads) by fuses or suitable thermal magnetic circuit breakers. These must be fitted on an omnipolar disconnection system having a contact gap of at least 3 mm.
IMPORTANT! For protection against indirect contacts (depending on the type of supply provided for and con-
nection of earths to the equipotential protection circuit) refer to point 6.3.3 of EN 60204-1 (IEC 60204-1) with the use of protection devices that ensure automatic cut-off of the supply in case of isolation fault in the TN or TT systems or, for IT systems, the use of isolation controllers or differ­ential current protection devices to activate automatic power disconnection (an isolation control­ler must be provided for indicating a possible first earth fault of a live part, unless a protection device is supplied for switching off the power in case of a such a fault. This device must activate an acoustic and/or visual signal which must continue for the entire duration of the fault).
For example: in a TT system, a differential switch with cut-in current (e.g. 30 mA) coordinated with the earthing system of the building where the machine is located must be installed ahead of the supply.
IMPORTANT! Customers are requested to follow these instructions, otherwise the Manufacturer does not guar-
antee the machine for continuous operation and/or against faults.
11
Page 10
D TRANSPORT, HANDLING AND STORAGE
D1 Introduction
Transport (i.e. transfer of the machine from one place to another) and handling (i.e. transfer inside work­places) must occur with the use of special equipment of adequate capacity.
The machine must only be transported, handled and stored by qualified personnel, who must have:
- specific technical training and experience;
- knowledge of the safety regulations and applicable laws in the relevant sectors;
- knowledge of the general safety provisions;
- the ability to recognize and avoid any possible haz­ard.
D1.1 Transport: Instructions for the carrier
WARNING! Do not stand under suspended loads
during the loading/unloading phases. Unauthorized personnel must not access the work zone.
IMPORTANT! The machine’s weight alone is not suf-
ficient to keep it steady. The transported load can shift:
- when braking;
- when accelerating;
- in corners;
- on particularly rough roads.
D2.2 Translation
The operator must:
• have a general view of the path to be followed;
• stop the manoeuvre in case of hazardous situa­tions.
D2.3 Placing the load
Before placing the load make sure the path is free and that the floor is flat and can take the load.
D3 Storage
The machine and/or its parts must be stored and protected against damp, in a non-aggressive place free of vibrations and with room temperature of between -10°C / 14°F and 50°C / 122°F.
The place where the machine is stored must have a flat support surface in order to avoid any twisting of the machine or damage to the support feet.
IMPORTANT! Machine positioning, installation and disassembly must be carried out by a specialized technician.
IMPORTANT! Do not make modifications to the parts
supplied with the machine. Any miss­ing or faulty parts must be replaced with original parts.
D2 Handling
Arrange a suitable area with flat floor for machine unloading and storage operations.
D2.1 Procedures for handling operations
For correct and safe lifting operations:
• use the type of equipment most suitable for charac­teristics and capacity (e.g. lift trucks or electric pal­let truck);
• cover sharp edges;
• check the forks and lifting procedures according to the instructions given on the packing.
Before lifting:
• send all operators to a safe position and prevent persons from accessing the handling zone;
• make sure the load is stable;
• make sure no material can fall during lifting, and manoeuvre vertically in order to avoid impacts;
• handle the machine, keeping it at minimum height from the ground.
CAUTION! For machine lifting, do not use mova­ble or weak parts such as casings, electrical raceways, pneumatic parts, etc., as anchoring points.
12
Page 11
ENGLISH
E INSTALLATION AND ASSEMBLY
IMPORTANT! Machine installation operations must
only be carried out by specialized Techni­cians provided with all the appropriate personal protection equipment (safety shoes, gloves, glasses, overalls, etc.), tools, utensils and ancillary means.
E1 Customer responsibilities
The Customer must provide for the following:
- Install a disconnecting switch with a capacity at least equal to that given in the technical data table, a 30mA residual current circuit breaker and an overcurrent device (magnetothermal cut-out with manual reset or fuse) between the appliance and the mains power outlet. The chosen device must be lockable in the open position in case of mainte­nance.
- install an adequate electrical power supply ahead of the machine, according to the equipment’s tech­nical specifications (Table 1 and C2 “Characteris­tics of power supply”);
- the equipotential connection of the workplace elec­trical system to the metal structure of the machine by means of a copper cable of adequate section (see position “EQ” in par. E6.2 “Installation dia­grams”);
- Adducting for the electrical connection between the workplace electric panel and the equipment;
- the water supply and drain connections and other connections as indicated in Table 1 and par. E6 “Plumbing connections”;
Arranging the machine:
• Wear protective gloves and unpack the machine (Figure 5).
Figure 5 Unpacking
• Lift the appliance using a lift truck, remove the base and position the appliance where it is to be installed
(Figure 6).
Figure 6 Machine
positioning
Figure 7 Removing
the film
E2 Characteristics of the place of machine
installation
The machine is designed for installation in professional and not domestic-type kitchens. Water collection traps/ metal grates must be arranged in the floor at the machine discharges (see pargraph E6.2 “Installation diagrams”), possibly replaceable with a single water trap sized for a flow rate of at least 3 l/s.
E3 Machine space limits
A suitable space must be left around the machine (for operations, maintenance, etc.).
The passages enabling personnel to operate on the machine must be at least 50 cm wide, except at the rear of the machine.
The size must be increased in case of use and/or transfer of other equipment and/or means or if exit routes are necessary inside the workplace.
E4 Positioning
The machine must be taken to the place of installation and the packing base removed only when being installed.
• Carefully remove the protective film from the outer panels without tearing it, to avoid leaving traces of glue (Figure 7).
• Adjust the equipment by turning the special adjust­able feet and making sure it is perfectly level, both lengthwise and crosswise (Figure 8).
Figure 8 Feet adjustment
• The appliance must be fixed to the floor using the two clamps supplied (Figure 9).
Figure 9 Machine fixing clamp
13
Page 12
• Accessing the appliance bottom panel.
IMPORTANT
PS
!
• Fit the clamps on feet as shown in supplied techni­cal sheet. Screw the appliance steadily to the floor using hole
• clamps
E5 Disposal of packing
All materials used for packing are environmentally compatible. They can be safely kept, and recycled or burnt in a special waste incineration plant. Plastic parts subject to possible recycling are marked as follows:
PE
PP
Parts in wood and cardboard can be disposed of respecting the current regulations in the country of use.
E6 Plumbing connections
.
polyethylene: outer wrapping, instruc-
tion booklet bag.
polypropylene: roof packing panels,
straps.
polystyrene foam:
corner protectors.
E6.1 Plumbing circuits
Plumbing circuit diagram - manual hood type
without drain pump
Watermark labelled machines must be installed in accordance with AS/NZS 3500.1.
Install the machine water filling and drain pipes accord­ing to the plumbing circuit and installation diagrams given below.
• Connect the appliance water supply pipe “WI” (see paragraph E6.2 Installation diagrams) to the mains, fitting a cut-off cock, the filter provided and a pres­sure gauge between the appliance and the mains (Figure 10).
Figure 10 Feed pipe connection
LEGEND
WI = Water inlet CWI = Cold water inlet (~ 15°C) M1 = Wash pump M3 = Rinse pump M4 = Drain pump M9 = ESD fan motor M10 = ESD fan motor AG = Air Gap YV1 = Filling solenoid valve V = Ventilation
• Check that the dynamic water supply pressure, measured between the appliance and the main, is between 50 and 700 kPa (test while dishwasher tank or boiler is filling with water).
If the pressure is too high, fit a suitable pres­sure reducer on the inlet pipe.
• Connect the waste outlet pipe “D” (see pargraph E6.2 Installation diagrams) to the main drain pipe, fitting a trap, or place the outlet pipe over an S trap set into the floor.
14
Page 13
ENGLISH
Plumbing circuit diagram - manual hood type with drain
pump
Plumbing circuit diagram - automatic hood type with
energy saving device (ESD)
LEGEND
WI = Water inlet CWI = Cold water inlet (~ 15°C) M1 = Wash pump M3 = Rinse pump M4 = Drain pump
M9 = ESD fan motor M10 = ESD fan motor AG = Air Gap YV1 = Filling solenoid valve V = Ventilation
E6.2 Installation diagrams
The following installation diagrams give the machine overall dimensions and position of water and electrical connec­tions.
IMPORTANT! For models without energy saving device (ESD), make sure to install an extractor hood to remove
the steam produced by the machine. For models with energy saving device (ESD), it is not necessary to install an extractor hood
unless the current regulations in the country of use require it. The hood air flow must be calculated taking into account the type of installation and the work environment where it is installed. In any case, an air flow rate of between 1000 m
3
/h and 1500 m3/
h is recommended.
15
Page 14
Installation diagram - manual hood type (single skin) without drain pump and without energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ventilation XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
16
Page 15
ENGLISH
Installation diagram - manual hood type (single skin) with drain pump and without energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ventilation XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
17
Page 16
Installation diagram - manual hood type (double skin) with drain pump and without energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ventilation XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
18
Page 17
ENGLISH
Installation diagram - manual hood type (double skin) with drain pump and with energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ventilation XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
19
Page 18
Installation diagram - automatic hood type with drain pump and without energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ventilation XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
20
Page 19
ENGLISH
Installation diagram - automatic hood type with drain pump and with energy saving device (ESD)
LEGEND
WI Water inlet CWI Cold water inlet D Drain outlet EI Power supply entry EQ Equipotential screw V Ve nti lati on XD Pipe inlet for detergent XR Pipe inlet for rinse aid XI Pipe inlet for de-lime
21
Page 20
E7 Electrical connections
L1
L2
L3
L1
L2
L3
L1
L2
L3
Connection to the power supply must be carried out in conformity with the current regulations and provisions in the country of use.
IMPORTANT! Work on the electrical systems must
only be carried out by a qualified electri­cian.
• Make sure the machine power supply voltage spec­ified on the rating plate (Table 1) matches the mains voltage.
• Make sure the system power supply is arranged and able to take the actual current load and that it is executed in a workmanlike manner according to the regulations in force in the country of use.
• The earth wire at the terminal end must be longer (max. 20 mm) than the phase wires.
• Connect the earth wire of the power supply cable to an efficient earth clamp. The appliance must also be included in a unipotential system, the con­nection being made through the screw “EQ” (see pargraph E6.2 Installation diagrams) marked with
the symbol “ ”. The unipotential wire must have a cross section of 10 mm2.
Open the power supply terminal board and insert the jumpers provided as follows: two jumpers between ter­minals 2 and 4 and two between terminals 4 and 6. Using a suitable power supply cable (see technical data table), connect the three phases to terminals 1, 3 and 5 and the earth wire to the terminal .
Power supply 220-240V 3
Figure 13 220-240V 3
Open the power supply terminal board and insert the jumpers provided as follows: one jumper between termi­nals 1 and 2, one between terminals 3 and 4 and another between terminals 5 and 6. Using a suitable power supply cable (see technical data table), connect the three phases to terminals 1, 3 and 5 and the earth wire to the terminal .
Power supply 380-415V 3N
(standard configuration)
Figure 11 380-415V 3N
Open the power supply terminal board and insert the jumpers provided as follows: two jumpers between ter-
minals 2 and 4 and two between terminals 4 and 6. Using a suitable power supply cable (see technical data
table), connect the three phases to terminals 1, 3 and 5, the neutral to terminal 6 and the earth wire to the termi­nal .
Power supply 400-440V 3
Power supply 220-240V 1N
Figure 14 220-240V 1N
Open the power supply terminal board and insert the jumpers provided as follows: two jumpers between termi­nals 1 and 3, two jumpers between terminals 2 and 4, one jumper between terminals 3 and 5 and another two between terminals 4 and 6.
Using a suitable power supply cable (see technical data table), connect the phase and neutral to terminals 5 and
6 respectively and the earth wire to the terminal .
E8 Energy control arrangement
The machine is arranged for external control of energy consumption.
22
11
12
Figure 12 400-440V 3
Figure 15 Energy control
Page 21
ENGLISH
Connect the energy peak controller across terminals
!
11 and 12 (Figure 15).
CAUTION A normally open (n.o.) contact of the con-
troller must be connected across termi­nals 11 and 12. When this contact closes the boiler heating elements are discon­nected. Using the dishwasher in these conditions may increase the cycle time.
Safety devices
• An automatic reset thermoamperometric protective device incorporated in the windings of the electric pump cuts off the electricity supply in the case of malfunctioning.
• In the event of water mains failure, a device pre­vents water in the boiler from returning into the mains.
• An overflow pipe, connected to the drainage outlet, maintains the water in the tank at a constant level.
Failure to comply with safety rules and regulations relieves the manufacturer of all liability.
E9 HACCP arrangement
In some models the machine is not arranged for the HACCP connection; however, an HACCP kit can be ordered as an accessory.
When the machine is arranged for the HACCP con­nection it is still necessary to order the network con­nection cable.
Connect the HACCP network to terminals 2 and 3 of connector X4.
Figure 16 HACCP connection position
23
Page 22
F DESCRIPTION OF CONTROL PANEL
Legend
A = On / Off B = Open hood C = Close hood D = “Tank temperature” indicator
light
E = “Water tap” indicator light
F = “Boiler temperature”
indicator light G = Wash cycle 1 H = Wash cycle 2 I = Wash cycle 3 L = High Productivity or ETL-
Sanitization
M = Drain / self-cleaning cycle N = Delime cycle P = ACTIVE/ WASH SAFE
CONTROL
Q = LED bar
IMPORTANT
The GUARANTEED RINSE SYSTEM (GRS) is incorporated in the ACTIVE/ WASH SAFE CONTROL models (see led “P”). The GRS is an automatic rinse time/temperature control system.
Operation is as follows:
• during the wash cycle the indicator light is OFF;
• during the rinse cycle the indicator light comes on and is GREEN;
• at the end of the rinse cycle the indicator light remains GREEN if the rinse temperature and time have been carried out as per the programme, otherwise the indicator light becomes RED;
• upon opening the hood, the indicator light GOES OUT.
If the indicator light becomes RED, for example should the boiler waiting time be disabled, wait for a cou­ple of minutes and then repeat the wash cycle.
The temperature shown on the display is that of the tank if the light “D” is on, or of the boiler if the indicator light “F” is on. The tank temperature is displayed during the wash cycle and the boiler temperature during the rinse cycle.
In automatic versions the machine has a LED bar "Q" which monitors equipment status. When the LED bar is green the machine is ready for washing and when it is blue it indicates wash cycle progress status. After rinsing, the LED bar remains green if the temperature and rinse time were as programmed, otherwise the LED bar turns RED.
B
A
C
L
H
D
E
F
I
N
M
G
P
Q
Q
Described below are all the single keys and functions present in the various control panel models listed above. Some functions are shared by all models of the range, whereas others are available only on several versions.
Table 2 Control panel
24
Page 23
ENGLISH
F1 Basic controls
On/Off
This key indicates the status of the equipment: on or off. When the appliance is on, the key is lit.
Hood opening/closing (for automatic versions only)
These buttons open/close the hood, only in automatic versions.
Wash cycle 1
This button starts wash cycle 1. This cycle is recommen­ded for washing not very dirty dishes.
Wash cycle 2
This button starts wash cycle 2. This cycle is recom­mended for washing normally dirty dishes.
Wash cycle 3
This button starts wash cycle 3. This cycle is recommen­ded for washing very dirty dishes.
High Productivity or ETL-Sanitization mode
This button is used to go from High Productivity wash mode to ETL-Sanitization mode and vice versa.
Drain / self-cleaning cycle
This button starts a drain / self-cleaning cycle.
Delime cycle
This button is used to run a machine water circuit delime cycle with vinegar.
When a cycle is selected, the corresponding button is lit up.
25
Page 24
GSTARTING
IMPORTANT
3
B
2
1
2
1
3
4
A
G1 Preliminary checks, adjustments and
operational tests
IMPORTANT! These operations must only be carried
out by specialized technicians pro­vided with adequate personal protec­tion equipment (e.g. safety footwear, gloves, glasses, etc.), tools and suita­ble ancillary equipment.
G1.1 Electrical and plumbing checks
Before starting the machine:
• check correct connection of the electrical wires that feed the machine;
• make sure the power supply voltage and frequency match the data given in Table 1;
• check correct connection of the water supply and drain pipes (see par. E6 “Plumbing connections”);
• make sure all the guards and safety devices are in place and efficient.
G1.2 Check the positioning of tank components
IMPORTANT! The following operations must be car-
ried out by operators provided with suitable personal protection equipment (e.g. protective gloves, etc.) with the machine switched off and cold.
G1.2.1 Check the fitting of filters and overflows
In versions with supplementary filtering system (FS), make sure the pump suction filter "1", the tank filter "2", the flat filter "3" and the basket filter "4" are correctly fit­ted ("A" - Figure 17). In versions without supplementary filtering system (FS), make sure the pump suction filter "1", the over­flow "2" and the flat filter "3" are correctly fitted ("B" ­Figure 17).
.
G1.2.2 Arm fitting check
Make sure the upper and lower wash and rinse arms are correctly fitted (Figure 18).
Figure 18 Wash and rinse arms
G2 Starting
• Open the water supply cocks.
• Turn the main switch of the machine to “I”.
• Press the On/Off key Table 2 (“A” - “Control panel”).
G3 Detergent/rinse-aid dispensers and
settings
If the appliance is connected to a water softener or osmotic device, contact the detergent supplier for a specific product.
If the peristaltic dispensers are installed in the machine, the detergent/ rinse aid dosage is made automatically according to the desired concentration.
The detergent / rinse aid concentration depends on the product type and the water supply hardness (check the features on the product label).
The peristaltic dispensers (detergent and rinse aid) and the tube inside the rinse aid dispenser require periodical maintenance (at least once or twice a year) or after prolonged periods of machine inactivity.
26
Figure 17 Filters and overflow
1. Dishwasher with incorporated detergent dis­penser (Figure 19).
When the appliance is filled with water for the first time in the day, pump “R” dispenses a detergent quantity in the tank providing a concentration of 2 g/l. In order to change this value, access the parameter Setting the dispensers)
At each cycle, pump “R” dispenses a detergent quan­tity in the tank providing a concentration of 2 g/l. In order to change this value, access the parameter  (see
G4 Setting the dispensers)
Insert the supplied hose into the detergent container.
2. Dishwashers with incorporated peristaltic rinse-aid dispenser (Figure 19).
.
.
 (see
G4
Page 25
ENGLISH
When the appliance is filled with water for the first time
O
P
S
R
O
USr
in the day, pump “S” dispenses a rinse-aid quantity in the boiler providing a concentration of 0,1 g/l. In order to change this value, access the parameter  (see G4 Setting the dispensers)
.
At each rinse cycle, pump “S” dispenses a rinse-aid quantity in the boiler providing a concentration of 0,1 g/ l. In order to change this value, access the parameter  (see
G4 Setting the dispensers)
.
Insert the supplied hose into the rinse-aid container.
Connections for automatic detergent dispenser (Figure 19)
dispensers”).
Figure 21 Rinse aid dispenser terminal block
• Connect the rinse-aid dispenser between termi­nals 8 and 9. These connection points are live during filling of the tank and at the end of the rinse cycle for a set time (see paragraph G4 “Setting the dispensers”).
MANUAL ACTIVATION
Whenever the detergent containers are replaced, it may be necessary to activate the dispensers manually in order to fill the hoses and eliminate any air. Simulta­neously press the buttons, as shown in the figures below. If necessary, repeat this operation several times.
Figure 19 Automatic dispenser arrangement
There are two holes (plugged) “O” (Ø 5mm) for introdu­cing the detergent. These holes may be easily identi­fied from outside by looking for the countersunk marks on the external panel.
Inside the tank there is a hole “P” (Ø 10 mm) closed with a plug, which may be used for mounting a liquid detergent injector.
Electrical connections for automatic detergent and rinse-aid dispensers.
Terminals are available on the power supply terminal board for the electrical connection of external dispen­sers working at 220-240 V. Max. power 30 VA.
Figure 20 Detergent dispenser terminal block
DETERGENT DISPENSER RINSE-AID DISPENSER
G4 Setting the dispensers
All operations should be carried out with the appliance switched on, the hood open and no cycle selected
.
Press the On/Off button ("A" - Ta b le 2 "Control panel") and Wash cycle 1 button ("G" - Ta bl e 2 "Control panel") together for 5 seconds, to access the programming
mode and the display shows the parameter "".
• Connect the detergent dispenser between termi­nals 7 and 9. These connection points are live for a set time during filling of the tank and at the start of the wash cycle (see paragraph G4 “Setting the
27
Page 26
Press the button ("L" - Ta b le 2 "Control panel") twice to
 
USr
 

-
+
access the detergent and rinse aid adjustment para­meters.
The display shows  which is the first parameter of the dispenser family:
Parameter description
Unit of measure of dispensers (= g/l or = seconds)
Initial amount of detergent
Initial amount of rinse-aid Amount of detergent during
the cycle Amount of rinse-aid during the
cycle (*) The values given in the table refer to the factory-
settings.

 


Value (*)

2,00 g/l
0,12 g/l
2,00 g/l
0,12 g/l
• access the programming mode
• access the dispenser family
 
• Select the parameter 
1. Use the Wash cycle 1 ("G" - Table 2 Control panel) and Wash cycle 2 ("H" - Table 2 Control panel) but­tons to select the parameter to modify.
2. Press the button ("L" - Table 2 Control panel) to modify the parameter value.
3. Press the Wash cycle 1 ("G" - Table 2 Control panel) and Wash cycle 2 ("H" - Table 2 Control panel) buttons respectively to decrease/increase the value.
4. Press the button ("L" - Table 2 Control panel) to store the set value and return to parameter selec­tion (see point 1).
For example, to adjust the parameter , proceed as follows:
• modify the parameter value
Press the button ("L" - Table 2 Control panel) to store the set value.
To exit the programming mode, press the Wash cycle 3 button (“I” - Table 2 “Control panel”).
28
Page 27
ENGLISH
External dispenser adjustment
IMPORTANT
With external dispensers, it may be more useful to have the parameters expressed in seconds, setting the parameter  to =seconds. In this way the value of the parameters represents the duration in seconds.
Listed below are special values usable when external automatic dispensers are connected to the equipment:
-if  the detergent dispenser only
operates during wash pump operation; terminals 7-9 of the main terminal board are powered at the same time.
-if  the detergent dispenser only
operates during filling electrovalve operation for restoring the boiler level; terminals 7-9 of the main terminal board are powered at the same time.
-if  the rinse-aid dispenser only
operates during filling electrovalve operation for restoring the boiler level; terminals 8-9 of the main terminal board are powered at the same time.
-if the rinse-aid dispenser only operates
during wash pump operation; terminals 8-9 of the main terminal board are powered at the same time.
For connections, see the wiring diagram.
The mixing of different types of detergent/rinse-aid will cause crystallisation, which may result in a breakdown of the dosing pump. Failure to observe this condition will invalidate the guarantee and product liability.
Example 1:
Supposing that an external detergent dispenser has been connected with a tank concentration measuring sensor, a standard setting could be as follows:
•
 the parameter value is in seconds.
•  the dispenser is not activated during fill-
ing of the tank.
•  the dispenser is activated during
wash pump operation and, according to the con­centration of detergent detected by the sensor, the correct amount of detergent is dispensed.
Example 2:
Supposing that an external rinse-aid dispenser has been connected with a tank concentration measuring sensor, a standard setting could be as follows:
•  the parameter value is in seconds.
•  the dispenser is activated at each wash
cycle simultaneously with operation of the filling solenoid valve. In this way avoiding modifications to the wiring of the machine.
Suggestion: to check the effectiveness of the rinse­aid, look at freshly washed glasses against the light. Drops of water remaining on the glass indicate an insufficient amount while streaks indicate an excess.
Changing the detergent/rinse-aid type.
If changing to a different detergent/rinse-aid type (even one by the same manufacturer), you must rinse the suction and pressure hoses with fresh water before connecting the new detergent/rinse-aid container.
29
Page 28
H GENERAL SAFETY RULES
H1 Introduction
The machines are provided with electric and/or mechanical safety devices for protecting workers and the machine itself. Therefore the user must not remove or tamper with such devices.
The Manufacturer declines any liability for damage due to tampering or their non-use.
H1.1 Protection devices installed on the machine
H1.1.1 Guards
The guards on the machine are:
- fixed guards (e.g. casings, covers, side panelling, etc.), fixed to the machine and/or frame with screws or quick-release couplings that can only be removed or opened with tools;
- interlocked movable guards (front panels) for access to inside the machine;
- access doors to the machine’s electrical equip­ment, made from hinged panels openable with tools. The door must not be opened during machine movement, if inside the door there is equipment that is hazardous when live or under pressure.
IMPORTANT! Several illustrations in the manual rep-
resent the machine, or parts of it, with­out guards or with guards removed. This is purely for explanatory require­ments. Never operate the machine without the guards or with the safety devices deactivated.
H1.2 Safety signs to be displayed on the
machine or near the work area
MEANING P R O H
I
B
I
T
I O N
D A N G E R
Do not oil, lubricate, repair and adjust moving parts.
Do not remove the safety devices.
Do not use water to extinguish fires (shown on electrical parts).
DANGER OF CRUSHING HANDS
DANGER OF BURNS
DANGER OF ELECTROCUTION (shown on electrical parts with indi-
cation of voltage).
WARNING! Do not remove, tamper with or make
the labels on the machine illegible.
H2 Decommissioning
When the machine is no longer to be used, make it unusable by removing the feed wiring from the power supply and the water connections.
H3 Instructions for use and maintenance
Risks mainly of a mechanical, thermal and electrical nature are present in the machine.
Where possible the risks have been neutralized:
• directly, by means of adequate design solutions,
• or indirectly by using guards, protection and safety devices.
Any anomalous situations are signalled on the control panel display.
During maintenance several risks remain, as these could not be eliminated and which must be neutralized through specific behaviour and precautions.
Do not carry out any control, cleaning, repair or main­tenance operations on moving parts.
Workers must be informed of the prohibition by means of clearly visible signs.
To guarantee machine efficiency and correct opera­tion, periodical maintenance must be carried out according to the instructions given in this manual.
In particular, make sure to periodically check correct operation of all the safety devices and the insulation of
electrical cables, which must be replaced if damaged.
IMPORTANT! Machine maintenance operations must
only be carried out by specialized Technicians provided with all neces­sary personal protection equipment (safety shoes, gloves, glasses, over­alls, etc.), tools, utensils and suitable ancillary means.
WARNING! Never operate the machine by remov-
ing, modifying or tampering with the guards and protection or safety devices.
IMPORTANT! Before carrying out any operation on
the machine, always consult the man­ual which gives the correct procedures and contains important information on safety.
30
Page 29
ENGLISH
H4 Improper use
Improper use is any use differing from that specified in this manual. During machine operation, other types of work or activities considered improper and that in gen­eral can involve risks for the safety of operators and damage to the system are not allowed.
Improper use includes:
• failure to disconnect the power supply with the main switch in “O” off position before carrying out adjust­ment, cleaning, resetting and maintenance opera­tions;
• failure to disconnect the power supply with the main switch in off position “O” at the end of the day;
• lack of machine maintenance, cleaning and periodi­cal checks;
• structural changes or modifications to the operating logic;
• tampering with the guards or safety devices;
• failure to use personal protection equipment by operators, specialized technicians and mainte­nance personnel;
• failure to use suitable accessories (e.g. use of equipment, ladders, etc., unsuitable for carrying out maintenance on equipment positioned inside the machine);
• keeping combustible or flammable materials, or in any case materials not compatible with or pertinent to the work, near the machine;
• incorrect machine installation (see chapter E “Installation and assembly”);
• placing in the machine any objects or things not compatible with washing or that can obstruct/dam­age the machine or persons or pollute the environ­ment;
• non-compliance with the requirements for correct machine use;
• other actions that can cause risks not eliminable by the Manufacturer.
RESIDUAL RISK
Slipping or falling
[ U - M ]
Burns [ U - M - P ]
Electrocution [ M ]
Falling from above [ I - U - M ]
Tipping of loads [ I - M ]
Chemical [ I - U - M - P ]
Crushing or shearing
[ I - U - M ]
DESCRIPTION OF HAZARDOUS SITU­ATION
The operator can slip due to water or dirt on the floor.
The operator deliberately or unintention­ally touches some components inside the machine or dishes at the outfeed without using gloves or without allowing them to cool.
Contact with live parts during mainte­nance operations carried out with the electrical panel powered. The operator intervenes (with a power tool or without disconnecting the power to the machine) lying down on the wet floor.
The operator intervenes on the machine using unsuitable systems to access the upper part (e.g. rung ladders, or climbs on it).
During maintenance on the machine or the packing containing the machine with the use of unsuitable accessories or lift­ing systems or with load unbalanced.
Contact with chemical substances (e.g. detergent, rinse aid, scale remover, etc.) without taking adequate safety precau­tions. Therefore always refer to the safety cards and labels on the products used.
Possible risk of injury to upper limbs during the hood closing operation.
Table 3 Residual risks
H5 Residual risks
The machine has several risks that were not com­pletely eliminated from a design standpoint or with the installation of adequate protection devices.
Nevertheless, through this manual the Manufacturer has taken steps to inform operators of such risks, care­fully indicating the personal protection equipment to be used by them.
Sufficient spaces are provided for during the machine installation phases in order to limit these risks.
To preserve these conditions, the corridors and areas around the machine must always be:
• kept free of obstacles (e.g. ladders, tools, contain­ers, boxes, etc.);
• clean and dry;
• well lit.
For the Customer’s complete information, the residual risks remaining on the machine are given below; such actions are to be considered incorrect and therefore strictly forbidden.
APPLICATION PHASE: I=Installation, U=Normal use, M=Maintenance, P=Cleaning.
31
Page 30
I NORMAL MACHINE USE
IMPORTANT
I1 Correct use
Our appliances are designed and optimized in order to obtain high performance and efficiency. This equip­ment must only be used for its expressly designed pur­pose, i.e. washing dishes with water and specific detergents. Any other use is to be deemed improper.
I2 Characteristics of personnel enabled to
operate on the machine
Operator qualified for normal use must have at least:
• knowledge of the technology and specific experi­ence in operating the machine;
• adequate general basic education and technical knowledge for reading and understanding the con­tents of the manual,
• the capacity for a correct interpretation of the draw­ings, signs and pictograms;
• sufficient technical knowledge for safely performing his duties as specified in the manual;
• knowledge of the regulations on work hygiene and safety.
In the event of a significant anomaly (e.g. short circuits, wires coming out of the terminal block, motor break­downs, worn electrical cable sheathing, etc.) the oper­ator qualified for normal machine use must:
• immediately deactivate the machine by turning the main switch to “O” ;
• close the machine water supply by shutting off the water.
I3 First use
Carry out a couple of cycles without dishes to flush out any industrial grease which has remained in the tank and piping.
The button "A" lights up (Tab le 2 "Control panel"), indi­cating that the dishwasher is powered and that water is being introduced and heated.
The word “FILL” is shown on the display during the entire filling and heating stage:
fIL
Warning, this dishwasher does the first tank filling through several consecutive hot rinse cycles, while the display shows the message FILL (flowing).
This system let save up to 30% of time than traditional models.
If the hood is opened during this stage the message "CLOSE" will appear on the display:
CLO
The filling and heating stage has finished when the display shows the tank temperature:
55°C
To display the boiler temperature during heating of the tank, leave the hood and press the button “G” (Tabl e 2 “Control panel”).
I4 Daily activation of machine
• Make sure the filters, arms and the overflow are correctly fitted according to that indicated in par. G1.2 “Check the positioning of tank components” and E8 “Energy control arrangement”.
• Open the water supply cocks.
• Activate the main switch by turning it to position “I”.
• Switch on the dishwasher by pressing the button “A”.
• Raise the hood (with an automatic appliance, by pressing the open/close button “B/C” - Ta b l e 2 “Control panel”) and check that all the components are in their correct position.
• Close the hood (with an automatic appliance, by pressing the open/close button “B/C” - Ta b l e 2 “Control panel”).
32
If the indicator "E" (see Table 2 "Control panel") lights up, check that the water cock is open (see par. I7 Allarms).
I5 Wash cycles
The wash cycle includes a wash with hot water and detergent at a temperature of at least 55°C/ 131°F (min. 66°C /150°F for Marine USPH versions) and a rinse with hot water and rinse aid (min. 82°C / min. 180°F).
This machine can operate in 2 modes, "High Producti­vity" and "ETL-Sanitization". When the machine is set in "High Productivity" mode, the parameters that define the cycle times and temperature set points are the standard parameters, whereas when the machine is set in "ETL-Sanitization" mode, the parameters are such as to ensure the "ETL-Sanitization" test (see times table).
Page 31
ENGLISH
Table o f times
IMPORTANT
B
C
End
Standard cycle time with supply water ductivity" mode (factory default setting):
I II III
45 (***)
84 150
in "high pro-
• Pre-wash the dishes by spraying them with cold or lukewarm water, without using any detergent.
• Insert the rack containing the dirty dishes.
• Close the hood and select the suitable wash cycle; the corresponding indicator light comes on and the wash cycle starts.
Standard cycle time with supply water tion mode:
I II III
57 (***)
(***) With supply water temperature at 65°C/ 149°F.
In models with energy saving device (ESD) cycle duration is extended by 11 seconds.
A device lengthens the cycle time if the water in the boiler has not reached the minimum temperature for correct rinsing.
The cycle times and the temperature may be personalised (e.g. increase of the rinse time and temperature).
The cycle times should only be set by a specialised technician.
I6 Operation
The filling and heating stage has finished when the display shows the tank temperature:
84 150
in ETL-Sanitiza-
55°C
The appliance is then ready for use:
• Leave the hood.
With automatic machines, press the button "B" to
open the hood and button "C" (Figure 22) to close it.
Usable wash cycles:
- Cycle I
For lightly soiled dishes: press button “G” (see Tabl e 2 “Control panel” and table of times).
- Cycle II (recommended)
For normally dirty dishes: press button “H”(see Table 2 “Control panel” and table of times).
- Cycle III
For very dirty dishes: press button “I” (see Tabl e 2 “Control panel” and table of times).
- High Productivity or ETL-Sanitization mode
Press and hold down (5 sec.) the button "L" (see Tab l e 2 "Control panel") to switch the machine from "High Productivity" mode to "ETL-Sanitization" mode and vice versa. The button "L " is off when the machine is set in "ETL-Sanitization" mode and lights up when the button is pressed and the machine is configured in "High Productivity" mode (factory default setting).
Figure 22 Automatic hood opening/closing
• Pour the required amount of detergent non-foaming into the tank (in models without automatic dispenser).
• Arrange dishes in the rack, avoiding washing decorated dishes, silverware in contact with other metals and the drying of food residuals on dishes.
Remove large food scraps from the dishes to pre­vent clogging the filters.
Only for models with incorporated water softener
If the salt container is empty, the message 
 is displayed at the start or end of the cycle.
Place the salt in the special container, following the instructions given in the section "Undercounter dish­washer with incorporated continuous water softener”.
• To stop the wash cycle, just press the selected cycle button or leave the hood.
• To continue the wash cycle, just press the selected cycle button or close the hood. The cycle starts again from where it stopped.
•
At the end of the wash, the dishwasher emits a series of beeps and “END” blinks on the display:
lift the hood and remove the rack containing the clean dishes.
33
Page 32
In models with energy saving device (ESD), before the
IMPORTANT
IMPORTANT
IMPORTANT
IMPORTANT
IMPORTANT
3...... ...2
End
message "END", the display shows a countdown for a few seconds:
With automatic machines, the hood opens automa­tically at the end of the wash cycle.
- Delime cycle (if enabled)
Press the button "N" (see Ta bl e 2 Control panel)
to run a machine water circuit delime cycle with vinegar. It is advisable to run this cycle according to that given in the table:
The Delime cycle should
Water hardness
°f °d °e Cycles Days
5 2,8 3,5 1500 50 10 5,6 7,0 750 25 15 8,4 10,5 510 17 20 11,2 14 380 13 25 14 17,5 300 10 30 16,8 21,1 250 8
(*) Considering a rinse time according to the factory settings.
be run approxima tely every (*):
Using cycle 2 for 30 cycles/day, Delime cycle should be run approximately
­every (*):
the
Proceed as follows:
•
Insert the Delime tube present in the machine, identified by an appropriate label, in a container with at least 2l of wine vinegar 6% (2l is the mini­mum amount of vinegar needed for a correct Delime cycle)
.
The appliance will not remove burnt food deposits from dishes. Dishes with burnt-on food deposits should be cleaned mechanically/chemically (for example, pre-wash under running water) before putting them in the dishwasher.
The use of “foaming”/non-specific detergents or in any case detergents used in different ways from that prescribed by the manufacturer, can cause damage to the dishwasher and compromise washing results.
Failure to remove the residuals of detergent possibly used for manual prewash can cause malfunctioning of the dishwasher and compromise washing results.
Change the water in the tank at least once a day.
Type of racks and loading
• YELLOW rack: for 18 plates with maximum diame­ter of 240 mm.
Figure 23 YELLOW rack
• GREEN rack: for 12 bowls with maximum diameter of 240 mm.
Only use wine vinegar (with 6% of acetic acid) and not other descaling substances. Descaling with the use of chemical substances other than vinegar must only be done by a specialized technician.
• Remove the basket with dishes and remove the over­flow "2" (see Figure 17 Filters and overflow).
• Close the hood.
• Activate the delime cycle by pressing the button "N" (see Ta bl e 2 Control panel) for at least 5 seconds.
The delime cycle lasts about 1h 30sec; during this phase the hood must not be opened and no other command can be activated until completion of the cycle in progress. If the machine is turned off during the delime cycle, at the next restart the cycle will resume exactly from where it was inter­rupted, until its completion.
• At the end of Delime cycle, the dishwasher sounds a series of beeps and "END" will flash on the display.
• Refit the previously removed overflow.
Figure 24 GREEN rack
• BLUE rack for glasses: the glasses should be pla­ced upside down.
Figure 25 BLUE rack for glasses
• YELLOW container for cutlery: insert 15 items, with the handles pointing downwards, in each container.
Figure 26 YELLOW container for cutlery
Available as accessories: dividers for glasses and rack for dishes with maximum diameter of 320 mm.
34
Page 33
ENGLISH
Note: if only one type of dish rack is to be used, it is
!
advisable to choose the GREEN rack.
I7 Alarms
In case of a generic dishwasher fault, the display shows the relevant alarm code.
For example:
A 1
List of possible documented machine alarms with respective cause / cure.
Code Description Cause / Solution A1 (*) NO WATER Check that the cock is open.
Check that the water inlet filter is clean. Check the minimum mains pressure. Check that the overflow pipe is inserted.
B1 INEFFICIENT
DRAINAGE
B2
C1..C9 CALL THE
E1..E8 CALL THE
F21..F22 CALL THE
TANK WATER LEVEL TOO HIGH
SERVICE CENTRE
SERVICE CENTRE
SERVICE CENTRE
(*) When the display shows alarm A1, the "water tap" indicator also lights up ("E" - Tab l e 2 "Control panel").
I8 Hood type dishwasher with incorporated
continuous water softener
These models have a continuous softener in the dishwasher water circuit. By means of special resins, this device removes the calcareous substances from the feed water, supplying decalcified water for washing.
For the continuous softener to work properly the resins must be regenerated periodically, with frequency depending on the hardness of the water and the num­ber of wash cycles carried out.
Unlike conventional water softeners, this continuous softener does not require machine stops for regenera­ting the resins.
Check if the overflow has been removed. Check for obstruction on the waste outlet pipe and the overflow aperture.
Check for obstruction on the waste outlet pipe and the overflow aperture.
The appliance continues to operate, but appropriate checks by a technician are recommended.
AUTONOMY OF THE FULL SALT CONTAINER ACCORDING TO THE CHANGE IN INLET WATER HARDNESS
The salt container must be filled
Water hardness
°f °d °e Cycles Days
15 8,4 10,6 2700 90 20 11,2 14 2180 73 25 14 17,6 1575 53 30 16,9 21,1 1035 35 35 19,7 24,6 855 30 40 22,5 28,1 675 23 45 25,2 31,6 450 15 50 28,1 35,1 270 9
(*) Considering a rinse time according to the factory settings.
approximately every (*):
Using cycle 2 for 30 cycles/day, the salt container must be fil led approximately every (*):
-
Salt container
The water can only be softened if there is salt in the special container. The salt container must be filled when the dishwasher is started the first time and
whenever the message
  appears and an
audible alarm sounds.
No salt in the container
IMPORTANT:
Only use coarse salt with a purity level of
99.8% NaCl. The use of salt with a lower purity level can cause clogging of the salt container filter and malfunctioning of the water softener.
When the salt container is empty, the message 
 appears on the display and an audible alarm
sounds. Wash cycles can be started just the same, even if the display signals no salt; in which case the water used for washing is not softened.
How to fill the salt container
• Raise the hood (with an automatic appliance, by pressing the open/close button “B/C” - Ta b l e 2 “Control panel”).
• Switch off the dishwasher by pressing button “A” (Tab le 2 “Control panel”).
• Unscrew cap "A" (Figure 27) of the salt container, turning it anticlockwise.
35
Page 34
instructions and observe the safety rules given in the
A
NaCl (2 kg)
!
!
1
B
2
3
3
4
2
1
A
information cards provided with the product or sub­stance.
In order to reduce the environmental impact of pollut­ant substances, clean the equipment (externally and internally where necessary) with products that are
more than 90% biodegradable.
CAUTION! Do not use steel wool or similar mate-
rial to clean s/steel surfaces. Do not use detergents containing chlorine.
Figure 27 Unscrew the salt container cap
•
Pour approx. 1.5 kg of coarse salt [NaCl] in container "A" (an amount sufficient to fill the salt container up to the rim) using the special funnel supplied (Figure 28)
Figure 28 Add the salt
IMPORTANT: Only salt may be placed in the salt con-
tainer. Do not introduce any other chemical substances such as detergent, rinse aid or descaling agent, since these would inevita­bly damage the appliance. Such damage invalidates any warranty and relieves the manufacturer of all liability.
• Remove any traces of salt from the filling hole and the container thread of the closing cap.
• Refit the cap of container "A", turning it clockwise and making sure it is tight.
.
IMPORTANT! Do not clean the machine with jets of
water.
CAUTION! Contact with chemical substances (e.g.
detergent, rinse aid, scale remover, etc.) without taking appropriate safety precautions (e.g. personal protection equipment) can involve exposure to chemical risk and possible damage to health. Therefore always refer to the safety cards and labels on the products used.
I9.1 End of service and daily internal cleaning
The appliance is designed to carry out an automatic cleaning cycle to help flush out any residues and to guarantee greater health and hygiene:
• Lift the hood and take out the rack containing the clean dishes.
• In versions with supplementary filtering system (FS), remove the basket filter "1", the flat filter "2", the tank filter "3" and the pump suction filter "4" (“A”
-
Figure 29).
• In versions without supplementary filtering system (FS), remove the flat filter "1", the overflow "2" and the pump suction filter "3" (“B” - Figure 29).
.
IMPORTANT: The message several wash cycles even after topping-
up the salt, as the salt must circulate in the entire system. Correct operation of the dishwasher is not, however, affected.
The salt container always has water in it, therefore it is normal if water comes out during filling


may appear for
.
I9 Machine cleaning
Cleaning must be carried out after every day of use. Use hot water, a neutral detergent/detersive if neces­sary, and a soft brush or sponge. If another type of detergent is used carefully follow the manufacturer’s
36
Figure 29 Filters and overflow
• Close the hood.
• Select the drain cycle by pressing button “M” (Ta b l e 2 “Control panel”).
Page 35
ENGLISH
The message "CLE" ("CLEAN") will be displayed
IMPORTANT
End
H
I
F
throughout the drain cycle:
To reduce the emission of pollutants into the environ­ment, clean the appliance (externally and where necessary internally) with products having a biodegra­dability of over 90%.
Leave the hood raised whenever the appliance is not in use.
CLE
• After a few minutes, 3 beeps indicate the end of thecleaning cycle and “END” blinks on the display:
• Switch off the dishwasher by pressing button “A” (Ta b l e 2 “Control panel”).
• Switch off at the mains.
• Close the water supply cock.
• Replace the filter and the overflow.
Cleaning the nozzle jets
• Remove the upper and lower wash arms "F" and rinse arms "I", undoing the ring nut "H" (Figure 30).
Figure 30 Wash and rinse arms
• Carefully clean the washing and rinse jets and clean everything with hot water and neutral deter­gent/detersive, if necessary using a soft brush or sponge. Do not use sharp implements to clean the nozzle holes, which could otherwise be damaged.
Upon completion of cleaning operations, replace the parts removed previously.
I9.2 Exterior cleaning
Before carrying out any cleaning operations, turn off the power at the mains.
Clean the stainless steel surfaces using warm soapy water; never use detergents containing abrasive substances nor steel scrapers, common wire wool, brushes or scrapers; rinse thoroughly using a wet cloth and carefully wipe dry. Clean the control panel using a soft damp cloth and a neutral detergent if necessary.
Do not wash the appliance using direct or high­pressure water jets.
I10 Long idle periods
Whenever the dishwasher is not going to be used for a long period of time (e.g. one month), carefully carry out the following instructions.
• Close the water supply cock.
• Completely drain the tank.
• Remove and carefully clean the filters.
• Completely drain the incorporated dispenser hoses, removing them from the containers. Repeat the procedure described in the paragraph “Manual activation” at least 3 times.
• Completely drain the boiler.
• Clean the inside and outside of the machine as indicated in par. I9.1 “End of service and daily inter­nal cleaning” and I9.2 “Exterior cleaning”.
• Spread a film of paraffin oil over the steel surfaces.
When using the machine again, follow the indications in par. I4 “Daily activation of machine”.
I11 Maintenance
Inspection and maintenance intervals depend on the actual machine operating conditions (total wash hours) and ambient conditions (presence of dust, damp, etc.), therefore precise time intervals cannot be given. In any case, to minimize interruptions of the service, careful and periodical machine maintenance is advisable.
Therefore, it is advisable to:
• Descale the boiler, inside surfaces of the tank and the machine piping once or twice a year (call tech­nical assistance).
• Every month descale the wash and rinse jets with vinegar or scale remover.
• The internal hose of the rinse-aid and detergent peristaltic dispenser should undergo periodic main­tenance (once or twice a year).
• If present, clean the finned coil of the energy saving device once or twice a year (call technical assis­tance).
It is also advisable to stipulate a scheduled pre­ventive maintenance contract with technical assis­tance.
I11.1 Preventive maintenance
The preventive maintenance call can be activated (call technical assistance).
On reaching the set number of cycles (e.g. 20000), a technical assistance call message appears on the dis­play.
This message suggests calling a specialized techni­cian, for a general check of the equipment.
37
Page 36
I12 Machine disposal
At the end of the product’s life cycle, make sure the equipment is not dispersed in the environment. The equipment must be disposed of in compliance with current regulations in the country of use.
All metal parts are in s/steel (AISI 304) and removable. Plastic parts are marked with the letters of the material.
The symbol on the product indicates that this product should not be treated as domestic waste, but must be correctly disposed of in order to prevent possi­ble negative consequences for the environment and the human health.
Regarding the recycling of this product, please contact the sales agent or dealer of your product, your after­sales service or the appropriate waste disposal service.
I13 Troubleshooting
DISHWASHER DOES NOT WASH WELL
1. Check if the suction filter is dirty and clean it thoroughly.
2. Check if the wash jets are clogged by solid food remains.
3. Check that the initial amount of detergent or subse­quent additions are correct.
4. The selected wash cycle is too short. Repeat the cycle.
5. Check that the tank temperature is at least 55°C / 131°F.
6. Check that the dishes are stacked correctly in the racks.
GLASSES AND DISHES ARE NOT DRIED PROPERLY
1. Check that there is rinse-aid in the container and if nec­essary top up.
2. Check the set amount of rinse-aid (see “setting the dispensers” paragraph).
3. Check that the water temperature is between 80°C and 90°C.
CONDENSATION ON GLASSES
1. Check that there is rinse-aid in the container and if nec­essary top up.
2. Check the set amount of rinse-aid (see “setting the dispensers” paragraph).
3. Remove the rack of glasses immediately the cycle has ended.
STAINS ON THE GLASSES
1. Only use “non-foaming” products for professional dishwashers.
EXCESSIVE FOAM IN THE TANK
1. Check that the wash water temperature is not less than 55°C / 131°F.
2. Check if the amount of product dispensed by the deter­gent dispenser is excessive (see “setting the dispen­sers” paragraph).
3. Ensure that the tank has not been cleaned with unsui­table cleaners. Drain the tank and rinse thoroughly before new wash cycles.
4. If a foaming detergent has been used, drain and refill the tank with water until the foam disappears.
SMEARS OR SPOTS ON THE GLASSES
1. Reduce the amount of rinse-aid (see “setting the dispensers” paragraph).
THE WASH OR RINSE ARMS TURN SLOWLY
1. Remove and thoroughly clean the arms.
2. Clean the wash pump suction filter.
38
Loading...