Page 1
ICE DIVERTER ED/DF DISPENSER KIT
P/N 02394
INSTALLATION MANUAL
Release Date: August 25, 2004
Publication Number: 92303INS
Revision Date: August 22, 2011
Revision: E
Visit the IMI Cornelius web site at
www.cornelius.com for all your Literature needs.
Page 2
The products, technical information, and instructions contained in this manual are subject to change without notice.
These instructions are not intended to cover all details or variations of the equipment, nor to provide for every possible contingency in the installation, operation or maintenance of
son(s) working on the equipment have been trained and are skilled in w
and mechanical equipment. It is assumed that appropriate safety precautions are taken and that all local safety and
construction requirements are being met, in addition to the information contained in this manual.
This Product is warranted only as provided in
ject to all of the restrictions and limitations contained in the Commercial Warranty.
Cornelius’ Commercial Warrant applicable to this Product and is sub-
this equipment. This manual assumes that the per-
orking with electrical, plumbing, pneumatic,
Cornelius will not be responsible for any repair, replacement or
from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal
service conditions with respect to the Product, (2) improper voltage, (3) inadequate wiring, (4) abuse, (5) accident,
(6) alteration, (7) misuse, (8) neglect, (9) unauthorized repair or the failure to utilize suitably qualified and trained persons to perform service and/or repair of the Product, (10) improper cleaning, (11) failure to follow installation, operating, cleaning or maintenance instructions, (12) use of
compatible with the Product) which use voids the entire warranty, (13) Product parts in contact with water or the
product dispensed which are adversely impacted by changes in liquid scale or chemical composition.
other service required by or loss or damage resulting
“non-authorized” parts (i.e., parts that are not 100%
Contact Information:
To inquire about current revisions of this and other documentation or for assistance with any Cornelius product contact:
www.cornelius.com
-238-3600
800
Trademarks and Copyrights:
This document contains proprietary information and it may not be reproduced in any way without permission from
Cornelius.
Printed in U.S.A.
Page 3
Ice Diverter ED/DF Dispensers Installation Instructions
!
WARNING:
STORAGE
HOPPER
GATE
MOUNTING
PLATE
ICE DIVERTER
P/N 15484
ICE CHUTE
FLANGE EXTENDS
INTO STORAGE
HOPPER THROUGH
GATE OPENING
APPLY RTV TO THIS
SURFACE TO SEAL TO
HOPPER GATE
MOUNTING PLATE
GASKET
FLAT WASHER
10-32 NUT
NOTE: For dispensing Scotsman NME654, NME954 and NME 1254 “Nugget” style ice and Cornelius
WCC500 and WCC700 “Chunklet” style ice cubes.
Disconnect power to the unit before servicing. Follow all lock out/tag out procedures established by the user. Verify all
power is off to the unit before performing any work.
Failure to comply could result in serious injury, death or damage to the equipment.
Perform the following procedure:
1. Remove upper front panel/merchandiser from dispenser.
2. Remove ice chute portion and gate restrictor.
3. Install ice diverter as shown (see Figure 1) and reinstall the gate restrictor removed in previous step. Gate
restrictor should be installed in ‘front’ of ice diverter .
Figure 2. Gate Restrictor Full Opening Figure 3. Timer Board Settings Reset
4. Remove screws securing white reflector panel and gain access to electrical box. Locate timer board and
reset agitation timer to 0.5 seconds ‘ON’ and 3 hours ‘OFF’ (see Figure 3).
5. Re-install front panel and plug unit back into outlet.
6. Unit should now be ready to dispense ice for customer use.
© 2004-2011, IMI Cornelius Inc. - 1 - Publication Number: 92303INS
Figure 1. Exploded View of Ice Diverter Installation
Page 4
Page 5
IMI Cornelius Inc.
www.cornelius.com
Loading...