Cornelius ED200 Parts Manual
ILLUSTRATED PART S LIST
ENDURO - 200/250
Publication Number: 92108IPL
Revision Date: April 4, 2012
Revision: H
Visit the IMI Cornelius web site at
www.cornelius.com for all your Literature needs.
The products, technical information, and instructions contained in this manual are subject to change without notice.
These instructions are not intended to cover all details or variations of the equipment, nor to provide for every possible contingency in the installation, operation or maintenance of
son(s) working on the equipment have been trained and are skilled in w
and mechanical equipment. It is assumed that appropriate safety precautions are taken and that all local safety and
construction requirements are being met, in addition to the information contained in this manual.
This Product is warranted only as provided in
ject to all of the restrictions and limitations contained in the Commercial Warranty.
Cornelius’ Commercial Warrant applicable to this Product and is sub-
this equipment. This manual assumes that the per-
orking with electrical, plumbing, pneumatic,
Cornelius will not be responsible for any repair, replacement or
from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal
service conditions with respect to the Product, (2) improper voltage, (3) inadequate wiring, (4) abuse, (5) accident,
(6) alteration, (7) misuse, (8) neglect, (9) unauthorized repair or the failure to utilize suitably qualified and trained persons to perform service and/or repair of the Product, (10) improper cleaning, (11) failure to follow installation, operating, cleaning or maintenance instructions, (12) use of
compatible with the Product) which use voids the entire warranty, (13) Product parts in contact with water or the
product dispensed which are adversely impacted by changes in liquid scale or chemical composition.
other service required by or loss or damage resulting
“non-authorized” parts (i.e., parts that are not 100%
Contact Information:
To inquire about current revisions of this and other documentation or for assistance with any Cornelius product contact:
www.cornelius.com
-238-3600
800
Trademarks and Copyrights:
This document contains proprietary information and it may not be reproduced in any way without permission from
Cornelius.
Printed in U.S.A.
Enduro 200/250 Illustrated Parts List
19
17
18
18
16
CABINET SECTION ASSEMBLY
Figure 1.
© 2004-2012, IMI Cornelius Inc. - 1 - Publication Number: 92108IPL
Enduro 200/250 Illustrated Parts List
Item
No.
Part No. Name
1 21491 Slide, Gate
2 22081R Restrictor, Gate
3 Not used
4 29541R Plate, Motor Mount
5 29694 Agitator
6 29555 Cover, Rear Wrapper
7 Not Used
Support, Drip Tray (Use for
units built after 11/15/98.
8 620028702
Serieal number cut off: DF –
ZRM1013131 and ED –
62A9841ED343)
9 29540R Cabinet 200
11 29547 Cabinet 250
12 Not Used
13
Contact
Sales
Panel/Cold Plate/Valve Ass’y
14 53011 Fitting, Cold Plate
15 Not Used
16 31007 Boot, Switch
Dispense Lever, Short (Cup
Acti-vated)
Dispense Lever, Long (Cup
Acti-vated)
17
15500
15488
15502 Push Lever Ice Dispense
18 50767 Snap Bushing
19 10145 Pin, Drip Tray
20 Not Shown
21 Not Used
22 Not Used
Not Shown
Not Shown
Dispense Switch Kit
23 02070
(Includes switch #14, boot
#22, spacer #91)
24 27107 Retainer, Ice Dispense lever
25 31928 Bulb, Florescent
Agitator Motor 120 Volt (Use
620314922
26
for units begining with serial
number 62A0540ED248)
33404 Agitator Motor 220-240 Volt
620048092 Capacitor, 250V 20mfd.
32954 Solenoid Assembly, 120 Volt
27
33409
Solenoid Assembly, 220-240
Volt
28 53255 Cover, Access (Cold Plate)
29 Not Shown
30 Not Shown
Item
No.
Part No. Name
31 Not Used
32 Not Shown
33 29542 Bracket, Motor Mount
36 71010 Washer, Captivating No. 8
37 Not Shown
38 Not Used
39 Not Used
40 Not Used
41 Not Used
42 Not Used
43 Not Used
44 Not Used
45 Not Used
46 Not Shown
47 Not Used
48 Not Shown
49
71025 Strap, Motor, 220–240V?
620516432 Strap, Motor, 120V
50 620500901 Ice Chute
52 Not Shown
53
15132 Motor Mount, 220–240V
620052843 Motor Mount, 120V
Merchandiser, Gray (ED250)
53001
53000 Merchandiser, Gray, (ED200)
52912
52911
Merchandiser, Black,
(ED250)
Merchandiser, Black,
(ED200)
15754 Merchandiser, S.S., (ED250)
15755 Merchandiser, S.S., (ED200)
Merchandiser, S.S., (For Lid
& Straw Holder ED250)
Merchandiser, S.S., (For Lid
& Straw Holder ED200)
Merchandiser, S.S., (For
Medallion ED250)
Merchandiser, S.S., (For
Medallion ED200)
Merchandiser, S.S., (For Low
Ice Light ED250)
Merchandiser, S.S., (For Low
Ice Light ED200)
54
55
56
58
620011505
620011509
620011506
620011510
620011507
620011511
52950 Panel, Inner, ED250
52949 White Lens, ED200
53211 Drip Tray, Gray, Insulated
53210 Drip Tray, Black, Insulated
53018 Lid, Dispenser, Gray
52909 Lid, Dispenser, Black
Publication Number: 92108IPL - 2 - © 2004-2012, IMI Cornelius Inc.
Loading...