Citroën Berlingo Dag 2010 Owner's Manual

6

Exterior

Key - Remote control

Complete unlocking of the vehicle.

Complete locking of the vehicle.

2a

Sliding side door

Pull the handle towards you then towards the rear and open the door guiding the rearward sliding until the point of resistance has been passed.

17

2a

Key

: chapter identiﬁ cation

: page identiﬁ cation

Opening the bonnet

Take care when working under the bonnet.

Raise the bonnet slightly by

reaching in a ﬂ at hand, palm

down, to make access to the lever easier. Engage the base of the strut in the hole provided to hold the bonnet open.

High pressure washing of the engine compartment is prohibited, to guarantee correct operation of the vehicle.

6b

2b

6a

4

"Grip Control"

The anti-slip "GRIP CONTROL" Electronic

Stability Programme (ESP) System improves traction on snow, mud and sand.

4

Fuel ﬁ ller ﬂ ap open

A mechanical system prevents opening of the left-hand side door when the

fuel ﬁ ller ﬂ ap is

open.

104

21

126 133

6a 6b2b

4

2c

2e 7b

7a

2d

FAMILIARISATION

Exterior

23

25

Rear roof ﬂ ap

The rear roof ﬂ ap is only

compatible with side hinged doors.

Changing bulbs

142

136, 137

Spare wheel and repair kit

Side-hinged rear doors

Tailgate and rear screen

Use the strap to close the rear tailgate.

Close by pressing ﬁ rmly

without slowing the travel of the tailgate.

22

Asymmetrical (2/3 - 1/3).

This lock makes it possible to keep the large door closed and drive with the small door open.

This control permits opening to approximately 180°.

Parking assistance

100

2d

7b

2c

4

2e

7a

7

8

Interior

INSTRUMENTS AND CONTROLS

1. Lighting and direction indicators

stalk.

2. Instrument panel with display.

3. Wipers, screenwash, trip

computer controls.

4. Ignition.

5. Audio equipment.

6. Driver's airbag, horn.

7. Steering wheel height and reach

adjustment.

8. Cruise control, speed limiter

switch.

9. Control panel, parking

assistance, headlamp beam adjustment, ESP.

10. Bonnet release.

11. Electric exterior mirror

adjustment.

FAMILIARISATION

Interior

CENTRE CONSOLE

1. Gear lever.

2. Control panel: electric windows.

3. Control panel: hazard warning

lamps, central locking.

4. Cigar lighter.

5. Heating-ventilation controls.

6. Storage compartment.

7. Audio equipment.

8. Screen.

104 9. Grip Control.

10. Emergency call.

106

4

9

10

Interior

SIT COMFORTABLY

Steering wheel Storage compartments

Adjust the height and reach of the steering wheel.

The tools are stored under the righthand seat.

Driver's seat

1.

Forwards-backwards adjustment.

Seat cushion

3.

height.

2. Angle.

4. Head restraint

height and angle.

3

Seat belts

Height adjustment. Fastening.

59

39

2

Mirrors

Manual adjustments. Electric adjustments.

107

4

78

3

96

3

FAMILIARISATION

Interior

Lighting off.

Sidelamps.

Main beam headlamps (blue). Dipped headlamps (green).

2 fast. 1 normal.

I intermittent.

0 park.  single wipe.

AUTO, press the stalk down.

Reactivate if the ignition has been off for more than one minute.

AUTO, automatic lighting.

42

45

SEE CLEARLY

Motorway function: press the stalk up

or down to ﬂ ash the direction indicator

three times.

142

Lighting stalk Wiper stalk Changing bulbs

In bad weather or in winter, ensure that

the lamps are not covered with mud or snow.

Special position for the front wipers

For one minute after swiching off the ignition, any action on the wiper stalk places the wiper arms and blades vertically alongside the screen pillars.

46, 151

3

7

11

3

12

Interior

DRIVE SAFELY

Cruise control

The vehicle speed must be higher than 25 mph (40 km/h) with at least 4th gear engaged.

Speed limiter

The minimum speed which can be programmed is 20 mph (30 km/h).

47

3

50

3

Hill start assist Audio system

From the time you release the brake pedal, the vehicle is held for approximately 2 seconds without need to use the parking brake, to allow you to set off.

41

2

Emergency or roadside assistance call

This in-car system allows you to send an emergency or roadside assistance call

to the dedicated CITROËN

centres.

USB Player

9

106

2

33

3

13

Interior

PASSENGER COMPARTMENT SPACE

Front ﬁ ttings

Clipped between row 1 and row 2, this offers an additional storage area and 2 cup holders.

Modutop roof, Scented air freshener

76

77

The multifunction roof console extends the overhead storage compartment.

The fragrance is diffused in the passenger compartment from the vents of the roof console.

Armrest Central storage console

If the vehicle is ﬁ tted with the additional console and an

armrest, to fold the passenger seat to the table position remove the console or the armrest.

80, 82

FAMILIARISATION

60

3

14

REAR FITTINGS

Interior

Interior rack Load space cover, 5 seat version Rear seats, 5 seat version

64

Load space cover, 7 seat version Rear seats, 7 seat version

67

88 94

3 3

Maximum loads

Overhead storage compartment: 5 kg.

Modutop roof:

- central storage compartments: 6 kg,

- box: 10 kg,

- roof bars placed longitudinally or transversely: 35 kg.

Transverse roof bars: 75 kg.

Interior rack: 10 kg per bar.

92

3

5

15

CHILD SAFETY

Interior

Child seats Side door child lock Child monitoring mirror

120

Safety anti-pinch Airbag deactivation

98

97

114

FAMILIARISATION

113

Interior

VENTILATION

16

Heating

Air conditioning

Recommended settings for the Manual Air Conditioning

For optimum use of the system, we recommend:

If I require ...

Heating -

53

3

Cooling

Demisting Defrosting

With Automatic Air Conditioning, operation in AUTO mode is recommended

irrespective of the requirement.

53

3

Air

distribution

Remember to switch the system off when the ambient air suits your requirements.

Temperature Air ﬂ ow

Air

recirculation

AC

3

57

Automatic air conditioning

55

3

KEY

ACCESSES

REMOTE CONTROL

This locks and unlocks the locks on the vehicle and starts the engine.

Central unlocking

Press this button to unlock all of your vehicle's doors.

The direction indicators ﬂ ash twice.

Central locking

Press this button to lock all of your vehicle's doors.

The direction indicators ﬂ ash once.

If one of the doors is open or is not closed correctly, the central locking will not work.

Accesses

Deadlocking

A second press on the closed padlock

on the remote control within ﬁ ve

seconds after locking changes the locking to deadlocking.

This is conﬁ rmed by ﬁ xed lighting

of the direction indicators for

approximately two seconds. Deadlocking renders the exterior

and interior door opening handles inoperative: do not leave anyone inside the vehicle when it is deadlocked.

If deadlocking is activated from inside the vehicle using the remote control, it will change to normal locking when the vehicle is started.

Accesses

Good practice

Take care not to allow the remote control to come into contact with grease, dust, rain or a damp environment.

A heavy object attached to the key (keyring, ...) weighing on the shaft of the key in the switch, may cause a malfunction.

REMOTE CONTROL

Programming the remote control

Following changing of the remote control battery or disconnection of the vehicle battery, the remote control may have to be reprogrammed.

Wait at least one minute before using the remote control.

Insert the key in the ignition switch with the buttons (padlocks) of the remote control facing you.

Switch on the ignition. Press the locking padlock for at least

ﬁ ve seconds within the next ten

seconds. Switch off the ignition. Wait at least one minute before using

the remote control. The remote control is now working

again.

Use only identical batteries or batteries of an equivalent type to those recommended by CITROËN dealers.

Do not discard the remote control batteries, they contain metals which are harmful to the environment.

Deposit them at a CITROËN dealership, or at any other approved collection point.

Folding/unfolding the key

Changing the battery

Battery ref.: CR1620/3 volts.

The information "battery ﬂ at" is given

by an audible signal, accompanied by a message on the display.

To replace the battery, unclip the casing using a coin at the ring.

If the remote control does not work after the battery has been changed, re-programme the remote control.

There is a risk of damage if the replacement battery does not conform.

Press this button to release the key from its housing.

To fold the key, press this chromed button then fold

the key into the housing. If you do not press the button, the mechanism may be damaged.

Accesses

When purchasing a second-hand vehicle:

- have the keys memorised by a CITROËN dealer to ensure that the keys in your possession are the only ones which can start the vehicle.

Good practice

Do not make any modiﬁ cations to the

electronic immobiliser system. Operating the remote control, even

when it is in your pocket, may result in involuntary unlocking of the doors.

The simultaneous use of other high frequency equipment (mobile telephones, domestic alarms…), may interfere with the operation of the remote control temporarily.

ELECTRONIC IMMOBILISER

All of the keys contain an electronic immobiliser device.

This device locks the engine supply system. It is activated automatically when the key is removed from the ignition.

After the ignition is switched on, a dialogue is established between the key and the electronic immobiliser system.

The metal part of the key must be unfolded correctly for correct dialogue to take place.

The remote control does not operate while the key is in the ignition, even if the ignition is off.

As a safety precaution (with children on board), remove the key from the ignition when leaving the vehicle, even for a short time.

If you lose your keys

Visit a CITROËN dealer with the vehicle's V5 registration document and

your identiﬁ cation document.

A CITROËN dealer will be able to retrieve the key code and the transponder code so that a replacement key can be ordered.

Accesses

SLIDING SIDE DOORS

From the outside

Pull the handle towards you then towards the rear and open the side door guiding the rearward sliding to beyond the point of resistance to hold it open.

A mechanical system prevents opening of the left-hand side door when the fuel

ﬁ ller ﬂ ap is open.

FRONT DOORS

From the outside

Use the remote control to lock/unlock the vehicle.

Insert the metal part of the key in the lock on the driver's side if the remote control does not work.

From the inside

Use the door opening control to unlock and open the door concerned.

Accesses

From the inside

Unlock the side door using this handle and open it, guiding the rearward sliding to the point of resistance. Pass this point to hold the door open.

Close the side door using the handle to start the sliding and pass the point of resistance. Then, use the shaped recess at the top of the door pillar to guide the door until it locks.

Do not use the grab handle to slide the door.

Good practice

Take care not to block the guide space

on the ﬂ oor to allow the door to slide

correctly. If your vehicle is parked on a slope,

guide the sliding of the side door. In fact, the door could open or close more rapidly due to the slope of the ground and could cause injury.

For safety and operation reasons, do not drive with the sliding side doors open.

Operation in the event of a battery failure

Front and side passenger doors

In the event of a malfunction of the battery or of the central locking, use the lock to lock the doors mechanically.

 To open the door and get out of the

vehicle, pull the interior control.

 To lock the door, insert the key in

the lock, located on the edge of the door, then turn it one eighth of a

turn .

Driver’s door

 Insert the key in the lock, then turn

it to the right to lock or to the left to unlock.

Accesses

TAILGATE

From inside

Tailgate screen

The opening rear screen allows you to access the rear of the vehicle directly, without having to open the tailgate.

Emergency control

In the event of a central unlocking operating fault, this permits unlocking of the tailgate from the inside.

Insert a small screwdriver in the opening, between the door and the

ﬂ oor. To unlock the lock, move the

catch to the left then push the tailgate.

From outside

Locking/unlocking is by means of the remote control.

To open, press the control below the trim then raise the tailgate.

A pull strap is available to close the tailgate in the high position.

Guide the closing of the tailgate to the balance point of its travel then apply

a ﬁ nal press on the tailgate to close it

fully.

Opening

After unlocking the vehicle using the remote control or the key, press the control and raise the rear screen to open it.

Closing

Close the rear screen by pressing the centre of the glass until it is fully closed.

The tailgate and tailgate screen cannot both be open at the same time, to prevent damage to the glass and the screen itself.

Accesses

HINGED REAR DOORS

From outside

To open, pull the handle towards you.

Pull the lever to open the right-hand door.

To close, start with the right-hand door then close the left-hand door.

With the roof rear ﬂ ap, the rear bumper

has been strengthened to serve as a footrest on accessing the vehicle.

Practice

It is possible to drive with the right-hand door open to make the transportation of long loads easier. The left-hand door is kept closed by the distinctive "yellow" lock, positioned at the base of the door. This closed door must not be used as a load retainer.

Driving with the right-hand door open is a special dispensation. Comply with the usual safety indications to attract the attention of other drivers.

The hinged rear doors are asymmetrical (2/3 - 1/3), with the smaller door on the right.

They are ﬁ tted with a central lock.

Accesses

From inside

Pull the handle towards you to open the left-hand door.

Opening to approximately 180°

A check strap system permits

extension of the opening from approximately 90° to approximately 180°.

Pull the yellow control when the door is open.

The check strap will re-attach automatically on closing.

Accesses

REAR ROOF FLAP

This rear roof ﬂ ap is only compatible

with the hinged doors.

To open the rear roof ﬂ ap:

- raise the black paddle of the toggle,

- relieve the toggle by pressing the

rear roof ﬂ ap (downwards) then

release the hook,

- lift the rear roof ﬂ ap,

- pass the point of resistance to

secure the rear roof ﬂ ap using the

support struts.

To close the rear roof ﬂ ap:

- check that the support bar is secured correctly,

- lower the rear roof ﬂ ap,

- while pressing the rear roof ﬂ ap

(downwards), take hold of the two loops of the spring then place the hook in its housing,

- lower the black paddle to secure

the rear roof ﬂ ap.

Securing the rear roof ﬂ ap places it

on the seal correctly and guarantees sealing without noise.

Support bar

A support bar is provided for transporting long loads, after opening

the rear roof ﬂ ap.

Fold back the support bar by lifting the lever.

Support it to the door pillar. Support the long loads to be

transported, lift them and reposition the support bar with one hand.

Ensure that it is secured correctly by pressing the handle downwards past the point of resistance and secure the

loads ﬁ rmly.

The side supports can be used as hooking points.

The rear bumper has been strengthened to serve as a footrest on entering the vehicle.

Never drive without the support bar in place.

The rear doors only lock when the support bar is installed.

When the rear roof ﬂ ap is open, take

care when driving where height is restricted.

Never rest loads directly on the rear doors.

Comply with the usual indications, to attract the attention of other drivers.

Accesses

CENTRAL LOCKING

Protection against attack

Locking while driving

When the vehicle moves off, as soon

as you reach approximately 6 mph

(10 km/h), the system locks the doors. A noise characteristic of central locking is heard. The diode on the control on the fascia central control panel comes on.

During the journey, opening a door results in complete unlocking of the vehicle.

In the event of a serious impact, the doors are unlocked automatically to permit access by the emergency services.

Activating/deactivating the function

An initial press permits central locking of the vehicle, when all of the doors are closed.

A second press permits central unlocking of the vehicle.

The control is inactive when the vehicle has been locked using the remote control or the key from the outside.

The doors can still be opened from the inside.

The control diode:

- ﬂ ashes when the doors are locked

with the vehicle stationary and the engine off,

- comes on when the doors are locked and from the time the ignition is switched on.

With the ignition on, press and hold this button to activate or deactivate the function.

Door open warning light

If this warning light comes on, check that all of your vehicle's doors are closed correctly.

Instruments and controls

INSTRUMENT PANEL

Displays

INSTRUMENTS AND CONTROLS

Dials

1. Distance recorder in kilometres/

miles.

2. Display.

3. Fuel level, coolant temperature.

4. Rev counter.

5. Trip distance recorder/service

indicator zero reset.

6. Instrument panel lighting rheostat.

- Speed limiter/cruise control.

- Kilometres/Miles travelled.

- Service indicator, engine oil level indicator, total kilometres/miles.

- Presence of water in the diesel

ﬁ lter.

- Diesel pre-heating.

Screens

The information is presented on board the vehicle in different display formats according to the vehicle's equipment.

Instruments and controls

Instrument panel without display

Centre console without display

To adjust the time of the clock, use the left-hand button on the instrument panel then carry out the operations in the following order:

- turn to the left: the minutes ﬂ ash,

- turn to the right to increase the minutes (hold the button to the right for rapid scrolling),

- turn to the left: the hours ﬂ ash,

- turn to the right to increase the hours (hold the button to the right for rapid scrolling),

- turn to the left: 24H or 12H is displayed,

- turn to the right to select 24H or 12H,

- turn to the left to complete the time adjustment.

After approximately 30 seconds

without any action, the display returns to the normal display.

Centre console with display

The display - time sequence is linked according to model (version). The access to the "Date" adjustment is only active when the model version offers a date in words.

To adjust the time and date indicated on the display, refer to the "Adjusting the date and time" section of chapter 9.

Instruments and controls

WARNING LAMPS

Each time the vehicle is started: a series of warning lamps comes on applying a self-test check. They switch off almost

immediately. When the engine is running: the warning lamp becomes a warning if it remains on continuously or ﬂ ashes.

This initial warning may be accompanied by an audible signal and a message which appears on the display. Do not ignore these warnings.

Warning lamp is indicates Solution - action

STOP

lit, associated with another warning lamp and accompanied by a message on the display.

major faults linked with

the "Brake ﬂ uid level",

"Engine oil pressure and temperature", "Coolant temperature", "Electronic brake force distribution" and "Power steering" warning lights.

You must stop, park and switch off

the ignition. Have the fault checked by a CITROËN dealer.

Handbrake/

Brake ﬂ uid

level/EBFD

lit.

that the handbrake is applied or has not been released fully.

Releasing the handbrake switches off the warning lamp.

lit. a low brake ﬂ uid level. Top up using a ﬂ uid recommended by CITROËN.

remaining on even though the level is correct and associated with the ABS warning lamp.

a failure of the electronic brake force distribution.

You must stop, park and switch off the

ignition. Have the fault checked by a CITROËN dealer.

Engine oil pressure and temperature

lit while driving.

insufﬁ cient pressure or a

high temperature.

Park and switch off the ignition then allow to cool. Visually check the level. Chapter 6, "Levels" section.

remaining on, even though the level is correct.

a major fault. Have the fault checked by a CITROËN dealer.

Instruments and controls

Warning lamp is indicates Solution - action

Coolant

temperature and level

lit with needle in the red zone.

an abnormal increase in temperature.

Park and switch off the ignition then allow to cool. Visually check the level.

ﬂ ashing. a drop in the coolant level.

Chapter 6, "Levels" section. Consult a CITROËN dealer.

Service

lit temporarily. minor faults or warnings.

Consult the warnings log on the display or on the screen. If your vehicle is equipped with a trip computer or a screen: refer to the "Audio equipment - Trip computer" section of chapter 9. Consult a CITROËN dealer.

remaining on. major faults.

Driver's

seat belt not fastened

lit then

ﬂ ashing.

the driver has not fastened his seat belt.

Pull the strap then insert the tongue in the buckle.

accompanied by an audible signal then remains on.

the vehicle is moving with the driver's seat belt not fastened.

Check that the seat belt is fastened by pulling the strap. Chapter 4, "Seat belts" section.

Instruments and controls

Warning lamp is indicates Solution - action

Front/side air bag

ﬂ ashing or

remaining on.

a failure of an air bag.

Have the system checked by a CITROËN dealer without delay. Chapter 4, "Air bags" section.

Front

passenger air bag disarmed

lit.

the intentional disarming of this air bag in the presence of a rear-facing child seat.

Chapter 4, "Air bags-child safety" section.

Low fuel level

lit with gauge needle in the red zone.

that there remain 8 litres of fuel when the lamp comes on.

You must ﬁ ll up with fuel to avoid running out.

This warning lamp comes on each time you

switch on the ignition until you have ﬁ lled up. Capacity of the tank: approximately 60 litres.

Never risk driving until the tank is empty, this could damage the antipollution and injection systems.

ﬂ ashing.

cutting off of the supply following a serious impact.

Restore the supply. Chapter 6, "Fuel" section.

EOBD

emission control system

ﬂ ashing or

remaining on.

a failure of the system.

There is a risk of damage to the catalytic converter. Have the system checked by a CITROËN dealer.

Battery charge

lit.

a fault in the charging circuit.

Check the battery terminals, … Chapter 7, "Battery" section.

ﬂ ashing.

placing of the active functions on standby (economy mode).

Chapter 7, "Battery" section.

remaining on, in spite of the checks.

a faulty circuit, an ignition or injection malfunction.

Have the fault checked by a CITROËN dealer.

ABS

Instruments and controls

Warning lamp is indicates Solution - action

Power steering

lit. a malfunction of the system.

The vehicle retains conventional steering without assistance. Have the system checked by a CITROËN dealer.

Door open detection

lit and accompanied by a message on the display.

that a door is not closed correctly.

Check that all of the doors are closed.

ABS remaining on.

a failure of the anti-lock braking system.

The vehicle retains conventional braking. Consult a CITROËN dealer.

ESP

ﬂ ashing.

triggering of the ASR or ESP regulation.

The system optimises drive and permits improvement of the directional stability of the vehicle. Chapter 4, "Driving safety" section.

remaining on.

a malfunction of the system.

E.g.: under-inﬂ ation of the

tyres.

E.g.: check the pressure of the tyres. Have the system checked by a CITROËN dealer. (Wheel speed sensor, hydraulic block, ...).

remaining on with the diode on the button (on the fascia) lit.

deactivation of the system at the request of the driver.

Operation of the system is deactivated. Reactivation is automatic above 30 mph (50 km/h)

or after pressing the button (on the fascia).

Instruments and controls

Warning lamp is indicates Solution - action

Particle emission ﬁ lter

lit.

a malfunction of the particle

emission ﬁ lter (diesel

additive level, risk of clogging, ...).

Have the ﬁ lter checked by a CITROËN dealer.

Chapter 6, "Levels" section.

Dipped

headlamps/ Daytime lights

lit.

a manual selection or automatic lighting.

Turn the ring on the lights stalk to the second position.

lighting of the dipped headlamps from the time the ignition is switched on: daytime lights (depending on the country in which the vehicle is sold).

Chapter 3, "Steering wheel controls" section.

Main beam headlamps

pulling of the stalk towards you.

Pull the stalk to return to dipped headlamps.

Direction indicators

ﬂ ashing with

buzzer.

a change of direction via the lights stalk, to the left of the steering wheel.

To the Right: control to be pushed upwards. To the Left: control to be pushed downwards.

Front fog lamps

lit. a manual selection.

The fog lamps only operate if the side lights or dipped headlamps are on.

Rear fog lamps

lit. a manual selection.

The fog lamps only operate if the side lights or dipped headlamps are on. In conditions of normal visibility, take care to switch them off to avoid breaking the law. "This light is a dazzling red."

Instruments and controls

Warning lamp on the display

is indicates Solution - action

Cruise control

lit. cruise control selected.

Manual selection. Chapter 3, "Steering wheel controls" section.

Speed limiter lit. speed limiter selected.

Manual selection. Chapter 3, "Steering wheel controls" section.

Diesel pre-heating

lit.

climatic conditions requiring pre-heating.

Wait until the warning light is switched off before operating the starter.

Presence of

water in the

diesel ﬁ lter

lit and accompanied by a message on the display.

water in the diesel ﬁ lter.

Have the ﬁ lter bled by a CITROËN dealer without

delay. Chapter 6, "Checks" section. According to country.

Service spanner

lit.

that a service will be due shortly.

Refer to the list of checks in the Maintenance and Warranty Guide. Have the service carried out by a CITROËN dealer.

Time ﬂ ashing. adjustment of the time.

Use the left-hand button on the instrument panel. Chapter 2, at the beginning of the "Instruments and controls" section.

Instruments and controls

FUEL GAUGE

COOLANT TEMPERATURE

The fuel level is tested each time the key is turned to the "running" position.

The gauge is positioned on:

- 1: the fuel tank is full,

approximately 60 litres.

- 0: the reserve is now being

used, the warning light comes on continuously. The reserve when

the warning ﬁ rst comes on is approximately 8 litres.

The needle is positioned before the red zone: normal operation.

In arduous conditions of use or hot climatic conditions, the needle may move close to the red graduations.

What you should do if the needle enters the red zone:

Reduce your speed or let the engine run at idle.

What you should do if the warning light comes on:

- stop immediately, switch off the ignition. The fan may continue to operate for a certain time up to

approximately 10 minutes,

- wait for the engine to cool down in order to check the coolant level and top it up if necessary.

As the cooling system is pressurised, follow this advice in order to avoid any risk of scalding:

- wait at least one hour after switching off the engine before carrying out any work,

- unscrew the cap by 1/4 turn to allow the pressure to drop,

- when the pressure has dropped,

check the level on the expansion

bottle,

- if necessary, remove the cap to top up.

If the needle remains in the red zone, have the system checked by a CITROËN dealer.

Refer to the "Levels" section of chapter 6.

Refer to the "Fuel" section of chapter 6.