Bunn TDO-4, TDO-4T, TDO-5 Owner's Manual

TDO-3.5
TDO-4 & 4T
TDO-5

USE & CARE INFORMATION

CAUTION- CLEAN AND SANITIZE YOUR DISPENSER BEFORE USING. SEE NOTE 1 of DAILY CLEANING.

INTRODUCTION

These dispensers are designed to hold and serve either a three and a half, four or five gallon batch of iced tea or iced

coffee, depending on the model. When proper precautions are followed, tea/coffee may be brewed directly into the dispenser
and then transported to a remote serving location. The dispenser must be placed on a sturdy counter or shelf.

NOTE: The TDO-3.5 dispenser weighs approximately 35 pounds when full. The TDO-4 dispenser weighs approximately
48 pounds when full. The TDO-5 weighs approximately 59 pounds when full. You must be careful when lifting these

dispensers. WHEN THE DISPENSER IS HOLDING LIQUID, LIFT THE DISPENSER USING THE HANDLES ONLY. DO NOT
LIFT THE DISPENSER FROM THE BOTTOM.

REPLACEMENT PARTS

1. 03043.0004 Decal, Fresh Brewed Tea

2. 03043.0005 Decal, Iced Tea (TDO 3.5 Only)

3. 00651.0000 Decal, Bunn

4. 33843.0000 Decal, Cleaning & Sanitizing

5. 00674.0000 Faucet Cleaning Brush

00674.1000 Faucet Cleaning Brush (6 Brushes)

6. 34093.0000 Lid, Oval Reservoir, Flat

34093.0001 Lid, Oval Reservoir, Brew Thru

7. 35136.0001 Retainer with Clip

8. 35880.0000 Lid Retainer Kit (Includes items 6 & 7)

9. 03093.0002 Faucet Wing Nut

10. 01221.0000 C-Ring, Faucet Shank

11. 03260.0002 Faucet Assy (Includes items 12 thru 16)

12. 29163.0003 Faucet Handle, Black

13. 00601.0000 Faucet Spring

14. 00600.0000 Faucet Seat Cup

15. 29164.0000 Faucet Stem

16. 29165.0001 Faucet Bonnet, Black

17. 29166.0002 Faucet Repair Kit (Includes items 12 thru 15)

18. 41183.0000 Faucet Repair Kit (Includes items 9 thru 11)

19. 40363.1000 Pinch Faucet (Includes items 9 & 10)

BUNN-O-MATIC CORPORATION

POST OFFICE BOX 3227

SPRINGFIELD, ILLINOIS 62708-3227

PHONE: [phone] FAX: [phone]

34106.0000J 06/09 © 2001 Bunn-O-Matic Corporation

DAILY CLEANING

CAUTION - CLEAN AND SANITIZE YOUR DISPENSER DAILY

1. Twist the faucet wing nut in a clockwise direction and remove the faucet from the reservoir.

2. Thoroughly clean the inner surfaces of the dispenser and the faucet shank with a brush using a mild cleaner/sanitizer
and water solution then thoroughly rinse the dispenser and faucet shank with warm water.

NOTE - Bunn-O-Matic recommends the use of KAY-5

boro, NC)

Simply pour the cleaner/sanitizer into an empty dispenser. Run a complete brew cycle of just water into the

dispenser and let it set for a minute. Empty the dispenser and thoroughly rinse with warm water.

3. Disassemble the faucet/stem assembly. The faucet cleaning procedure requires a 3-compartment sink. Thoroughly
wash all faucet parts in a mild detergent and water solution in the first sink. Rinse the parts in hot water in the second
sink. Sanitize the parts for one minute in 75°F warm chlorine solution (50 -100 ppm) in the third sink. Do NOT use
full-strength bleach, but a solution with water, of 50 - 100 ppm of chlorine. Reassemble the faucet and attach it to the
dispenser.

4. Wash the entire outside surface of the dispenser with a clean damp cloth.

CAUTION - NEVER KEEP BREWED ICED BEVERAGES OVERNIGHT

BUNN-O-MATIC COMMERCIAL PRODUCT WARRANTY

Bunn-O-Matic Corp. (“BUNN”) warrants equipment manufactured by it as follows:

1) All equipment other than as specified below: 2 years parts and 1 year labor.

2) Electronic circuit and/or control boards: parts and labor for 3 years.

3) Compressors on refrigeration equipment: 5 years parts and 1 year labor.

4) Grinding burrs on coffee grinding equipment to grind coffee to meet original factory screen sieve analysis: parts and labor for 3

years or 30,000 pounds of coffee, whichever comes first.
These warranty periods run from the date of installation BUNN warrants that the equipment manufactured by it will be commercially free
of defects in material and workmanship existing at the time of manufacture and appearing within the applicable warranty period. This
warranty does not apply to any equipment, component or part that was not manufactured by BUNN or that, in BUNN’s judgment, has
been affected by misuse, neglect, alteration, improper installation or operation, improper maintenance or repair, damage or casualty.
This warranty is conditioned on the Buyer 1) giving BUNN prompt notice of any claim to be made under this warranty by telephone
at [phone] or by writing to Post Office Box 3227, Springfield, Illinois 62708-3227; 2) if requested by BUNN, shipping the
defective equipment prepaid to an authorized BUNN service location; and 3) receiving prior authorization from BUNN that the defective
equipment is under warranty.

THE FOREGOING WARRANTY IS EXCLUSIVE AND IS IN LIEU OF ANY OTHER WARRANTY, WRITTEN OR ORAL, EXPRESS OR IMPLIED,
INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF EITHER MERCHANTABILITY OR FITNESS FOR A PARTICULAR
PURPOSE. The agents, dealers or employees of BUNN are not authorized to make modifications to this warranty or to make additional

warranties that are binding on BUNN. Accordingly, statements by such individuals, whether oral or written, do not constitute warranties
and should not be relied upon.
If BUNN determines in its sole discretion that the equipment does not conform to the warranty, BUNN, at its exclusive option while the
equipment is under warranty, shall either 1) provide at no charge replacement parts and/or labor (during the applicable parts and labor
warranty periods specified above) to repair the defective components, provided that this repair is done by a BUNN Authorized Service
Representative; or 2) shall replace the equipment or refund the purchase price for the equipment.

THE BUYER’S REMEDY AGAINST BUNN FOR THE BREACH OF ANY OBLIGATION ARISING OUT OF THE SALE OF THIS EQUIPMENT,
WHETHER DERIVED FROM WARRANTY OR OTHERWISE, SHALL BE LIMITED, AT BUNN’S SOLE OPTION AS SPECIFIED HEREIN,
TO REPAIR, REPLACEMENT OR REFUND.

In no event shall BUNN be liable for any other damage or loss, including, but not limited to, lost profits, lost sales, loss of use of
equipment, claims of Buyer’s customers, cost of capital, cost of down time, cost of substitute equipment, facilities or services, or any
other special, incidental or consequential damages.

®

for this purpose. (Kay-5 is a product of the Kay Chemical Company, Greens-

BrewWISE, BrewLOGIC, BrewMETER, BrewWIZARD, Bunn Gourmet, BUNN Gourmet Ice, BUNN Pour-O-Matic, BUNN, Bunn-OMatic,
Bunn-O-Matic, BUNNlink, BUNNserve, BUNNSERVE, BUNN Espress, Cool Froth, DBC, Dr. Brew, Dual, EasyClear, EasyGard, Easy
Pour, FlavorGard, Gourmet Ice, Gourmet Juice, High Intensity, IMIX, Infusion Series, Intellisteam, Quality Beverage Equipment World­wide, The Mark of Quality in Beverage Equipment Worldwide, My Café, PowerLogic, Safety-Fresh, Scale-Pro, Silver Series, Single,
Smart Funnel, Smart Hopper, SmartWAVE, Soft Heat, SplashGard, System III, ThermoFresh, 392, AutoPOD, AXIOM, Beverage Profit
Calculator, Beverage Bar Creator, BUNNsource, Coffee At Its Best, Digital Brewer Control, Nothing Brews Like a BUNN, Pouring Profits,
Pulse Wave, Signature Series, Smart Heat, Tea At Its Best, The Horizontal Red Line, Titan, Ultra, are either trademarks or registered
trademarks of Bunn-O-Matic Corporation.

34106 012609