Aiwa CSD-ED67 U, CSD-ED65 EZ, CSD-ED59 HA, CSD-ED59 K, CSD-ED59 LH Service Manual

...
Page 1
U,EZ
LH,K,HA
EZ
U
SERVICE MANUAL
COMPACT DISC STEREO
RADIO CASSETTE RECORDER
MODEL BASIC TAPE MECHANISM
CSD-ED57/59
CSD-ED65/67
• This Service Manual contains information about the difference between the CD MECHANISM “CMS-B31TG6” / “DA11T3C” and “KSM-213 CDM” for the MODEL CSD-ED57(U,EZ) / 59(LH,K,HA) / 65(EZ) / 67(U). If requiring other information, see Service Manual of CSD-ED57(U) / 59(LH,K) / 67(U), (S/M Code No. 09-992-402-4R1), CSD-ED57(EZ) / 59(HA) / 65(EZ), (S/M Code No. 09-995-402-4R2).
TN51RV-240 DA11T3C
BASIC CD MECHANISM
CMS-B31TG6TN21ZVC-1816
S/M Code No. 09-004-402-4S1
SUPPLEMENT
DATA
Page 2
PROTECTION OF EYES FROM LASER BEAM DURING SERVICING
This set employs laser. Therefore, be sure to follow carefully the instructions below when servicing.
WARNING!!
WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION. BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 30cm FROM THE SURFACE OF THE OBJEC­TIVE LENS ON THE OPTICAL PICK-UP BLOCK.
s Caution: Invisible laser radiation when
open and interlocks defeated avoid exposure to beam.
s Advarsel: Usynlig laserståling ved åbning,
når sikkerhedsafbrydere er ude af funktion. Undgå udsættelse for stråling.
VAROITUS!
Laiteen Käyttäminen muulla kuin tässä käyttöohjeessa mainitulla tavalla saataa altistaa käyt-täjän turvallisuusluokan 1 ylittävälle näkymättömälle lasersäteilylle.
VARNING!
Om apparaten används på annat sätt än vad som specificeras i denna bruksanvising, kan användaren utsättas för osynling laserstrålning, som överskrider gränsen för laserklass 1.
CAUTION
Use of controls or adjustments or performance of proce­dures other than those specified herin may result in hazardous radiation exposure.
ATTENTION
L’utillisation de commandes, réglages ou procédures autres que ceux spécifiés peut entraîner une dangereuse exposition aux radiations.
ADVARSEL
Usynlig laserståling ved åbning, når sikkerhedsafbrydereer ude af funktion. Undgå udsættelse for stråling.
This Compact Disc player is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT label is located on the rear exterior.
CLASS 1 LASER PRODUCT KLASSE 1 LASER PRODUKT LUOKAN 1 LASER LAITE KLASS 1 LASER APPARAT
Precaution to replace Optical block
Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode.
1) After the connection, remove solder shown in right figure.
SF-P101NR
PICK-UP ASSY. P.C.B
CMS-B31TG6
PICK-UP ASSY. P.C.B
Solder
Solder
– 2 –
Page 3
WIRING - 1 (57/59 : MOTOR-1)
H MOTOR-1 C.B
CD MOTOR C. B
123456789101112131415
A
B
M1
M2
M2
(SLED MOTOR)
M1
M2
SW1
SW1
PIN3
65 3 1
TO C CD MAIN C.B
CN402
M1
(SPINDLE MOTOR)
SW1
(INSIDE LIMIT SWITCH)
C
D
E
F
G
H
I
J
K
LD
FOCUS/TRACKING
COIL
PICK UP ASSY
SHORT
LAND
PD1C
119753
L
M
N
O
P
Q
R
S
11315
21416 12 10 8 6 4
T
TO C CD MAIN C.B
CN401
– 3 –
U
Page 4
WIRING - 2 (65/67 : MOTOR-1)
123456789101112131415
A
H MOTOR-1 C.B
M2
+
(SLED MOTOR)
_
(INSIDE LIMIT SW)
6 5
3
CN402
PIN3
1
TO C CD MAIN C.B
PICK UP ASSY
SW1
SF-P101NR
M2
SW1
(SPINDLE MOTOR)
_
M1
M1
B
C
D
E
F
+
G
H
I
J
16
1
FC401
TO C CD MAIN C.B
CN401
K
L
M
N
O
P
Q
R
S
4
T
U
Page 5
SCHEMATIC DIAGRAM - 1 (MOTOR-1)
CD MOTOR C.B
H MOTOR-1 C.B
PIN3
SPINDLE +
SPINDLE -
SLED +
SLED -
CN402
LIMIT SW LIMIT SW
TO C CD MAIN C.B
PICK-UP ASSY
1 2 3 4 5 6
(INSIDE LIMIT SW)
PICK-UP ASSY
PDIC
+2.5V
+5V
SHORT
LAND
LD
SW1
M1
M
M
M2
(SPINDLE MOTOR)
M2
M1
(SLED MOTOR)
C1
C2
FC401
1
VREF
2
5V
3
E
4
D
5
A
6
B
7
C
8
F
9
GND
10
C3
SFR1
11 12 13
FOCUS +
14
TRACKING -
15
TRACKING +
16
FOCUS -
VR PD
LD
CN401
TO C CD MAIN C.B
TRACKING
FOCUSING
5
Page 6
CD MECHANISM EXPLODED VIEW 1 / 1 (57/59)
1
5
6
7
2
4
A
9
CD MECHANISM PARTS LIST 1 / 1 (57/59)
13
P.C.B
3
8
10
PART NO.
NO.
1 M8-ZZK-L90-07A CMS-B31TG6 ASSY 2 SJ-660-060-1G0 COVER GEAR 3 SJ-660-060-1D0 GEAR(A) 4 SJ-660-060-1B0 GEAR(B) 5 SJ-660-060-1F0 GEAR(C)
6 SJ-700-060-1A0 SHAFT UP 7 SJ-750-060-1F0 PICKUP ASSY 8 SJ-310-060-1A0 MOTOR FEED 9 S4-090-001-740 SW,LEAF 10 SJ-370-060-1A0 CONN,WAFER
A SJ-600-060-1O0 SCREW-PH(+M2+3)
DESCRIPTIONREF. NO. KANRI
– 6 –
Page 7
CD MECHANISM EXPLODED VIEW 1 / 1 (65/67)
SHAFT,SLIDE
B
SF-P101NR
CHASSIS
B
1
2
A
A
3
6
SPINDLE MOTOR (M1)
5
CD MECHANISM PARTS LIST 1 / 1 (65/67)
PART NO.
NO.
1 S2-121-A28-400 COVER GEAR 2 S2-511-A21-000 GEAR MIDDLE 3 S2-511-A21-100 GEAR,DRIVE 4 9X-262-576-910 MOTOR GEAR ASSY 5 91-564-722-110 CONNECTOR,6P
6 91-572-085-120 LEAF SW A S1-PN2-03R-OSE SCR PAN PCS 2-3 B 87-261-073-410 SCR S-TPG FLT 2.6-6
ALL M8-ZZK-E90-070 DA11T3C
DESCRIPTIONREF. NO. KANRI
4
P.C.B
7
Page 8
2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111
Printed in Singapore9301978 0251431
Loading...