Yukon Hawk-20 Owners Manual
D
D
D
Read Instructions Before Using Your New E-bike
i
r
t
H
a
w
k
2
i
r
t
H
a
i
r
w
t
H
a
w
k
0
2
0
k
2
0
N
N
N
a
a
a
v
v
v
i
g
a
t
o
r
S
o
o
F
r
S
F
r
S
F
i
g
a
t
i
g
a
t
2
2
2
6
6
6
N
a
v
i
g
a
t
o
r
S
M
2
N
N
X
X
X
p
p
a
a
p
v
i
g
a
t
o
r
e
a
t
o
r
r
X
F
r
X
F
r
X
F
v
i
g
l
o
r
e
l
o
r
e
l
o
r
6
S
M
2
6
S
M
2
6
2
6
2
6
2
6
X
X
X
p
p
O
O
p
O
u
t
b
a
c
k
2
u
t
b
a
u
t
b
a
l
o
r
e
r
o
o
r
e
r
r
e
r
l
l
c
c
X
X
X
k
k
M
M
M
6
2
6
2
6
2
6
2
6
2
6
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
NOTICE!
NOTICE!
NOTICE!NOTICE!
Before using your new E-bike the first time,
Charge 6hours for Li-ion batteries and 8 hours for SLA(Sealed Lead Acid) batteries
Always recharge the battery before the power indicator shows no power.
Failure to follow these instructions voids any warranty, whether stated or implied
.
Before operating your E-bike
Warning!
This product does not conform to Federal Motor Vehicles Standards and
Is not intended for operation on public streets, roads or highways. Serious
injury can result from the unsafe operations of this vehicle.
This product is not designed to be jumped. If jumped, even from the curb,
The E-bike Frame could break causing serious injury or death.
If jumped, the warranty is void.
Do not operate this product in traffic, on wet, frozen, oily or
Unpaved surfaces or under the influence of drugs and/or alcohol.
Avoid uneven surfaces, potholes, surface cracks and obstacles.
It is recommended that the rider wear leather gloves, kneepads
And leather boots. Always wear a DOT approved helmet.
Never carry passengers on your E-bike.
Check your state and local laws governing the use
of motorized vehicles in your area.
Yukon Trail, Inc. is not responsible for your
Failure to comply with state and local ordinances
Relating to the use of the E-bike.
Failure to follow these operation instructions
can result in serious injury or death.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Congratulations on your new purchase! Our service department is
dedicated to your satisfaction with 877.441.6999. For questions regarding
performance, assembly, operation, parts or return, contact the
Manufacturer directly by calling toll free
DO NOT RETURN TO STORE
877.441.6999.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Before You Ride
About this Manual
It is important for you to understand your new bicycle. By reading this manual
before you go out on your first ride, you will know how to get better
performance, comfort, and enjoyment from your new bicycle.
It is also important that your first ride on your new bicycle is taken in a
controlled environment, away from cars, obstacles, and other cyclists.
General Warning
Bicycles can be hazardous activity even under the best of circumstances.
Proper maintenance of your cycles is your responsibility as it helps reduce the
risk of injury. This manual contains many “Warnings” and “Cautions”
concerning the consequences of failure to maintain or inspect your bicycle.
Many of the warning and cautions say “you may lose control and fall.”
Because any fall can result in serious injury or even death, we do not repeat
the warning of possible injury or death whenever the risk of falling is
mentioned.
A Special Note for Parents
It is a tragic fact that most bicycle accidents involve children. As a parent or
guardian, you bear the responsibility for the activities and safety of your
minor child. Among these responsibility are to make sure that the bicycle
which your child is riding is properly fitted to the child; that is in good repair
and safe operating condition; that you and your child have learned,
understand and obey not only the local motor vehicle, bicycle, and traffic
laws, but also the common sense rules of safe and responsible bicycling , As a
parent, you should read this manual before letting your child ride the bicycle.
Please make sure that your child always wears and ANSI, ASTM, SNELL
approved helmet when riding.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Safety Checklist
Before you ride, it is important to carry out the following safety checks:
1. Brakes
Ensure brake shoe pads are not over worn and are correctly
Ensure front and rear brakes work properly
position in relation o the rims.
Ensure brake control cables are lubricated, correctly adjusted
and display no obvious wear.
Ensure brake control levers are lubricated and tightly secured
to the handlebar.
2. Wheel and Tires
Ensure rims run true and have no obvious wobbles or kinks.
Ensure all wheels spokes are tight and not broken.
Check that axle nuts are tight. If your bicycle is fitted with
Ensure tires are inflated to within the recommended limit as
displayed on the tire sidewall
Ensure tires have tread and have no bulges or excessive wear.
quick release axles, make sure locking levers are correctly
tensioned and in the closed position.
3. Steering
If the bicycles is fitted with handlebar end extensions, ensure
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Ensure handlebar and stem are correctly adjusted and tightened,
and allow proper steering.
Ensure that the handlebars are set correctly in relation to the
forks and direction of travel.
Check that the headset locking mechanism is properly adjusted
and tightened.
they are properly position and tightened.
4. Chain
Extra care is required in wet or dusty conditions.
Ensure chain is oiled, clean and runs smoothly.
5. Bearing
Check headset, wheel bearings, pedals bearing and bottom
Ensure pedals are securely tightened to the cranks.
bracket bearings.
6. Cranks and Pedals
Ensure cranks are secure to axle and are not bent.
Ensure pedals are securely tightened to the cranks
7. Derailleurs
Ensure derailleur, shift levers and shift and brake cables are
Check that front and rear mechanisms are adjusted and function
properly.
Ensure shift and brake levers are attached to the handlebar.
properly lubricated.
8. Frame and Fork
If either are bent or broken, they should be replaced.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Check that the frame and fork are not bent or broken
9. Accessories
Ensure all other fittings on the bike are properly and securely
Ensure the rider is wearing a helmet.
Ensure that all reflectors are properly fitted and not obscured.
fastened, and functioning.
10. Motor Drive Assembly and Throttle
Ensure all motor drive components are correctly mounted and
functioning properly.
11. Battery Pack
Ensure the batteries are in good operation condition and kept
fully charged and properly secured and locked.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Helmets
It is strongly advised that a properly fitting, ANSL or SNELL approved, bicycle
safety helmet be worn at all times when riding your bicycle. In addition, if
you are carrying a passenger on a child safety seat, they must also be wearing
a helmet.
The correct helmet should:
-be comfortable
-be lightweight
-have good ventilation
-fit correctly
-cover forehead
Always wear a properly fitted helmet which covers the forehead when
riding a bicycle. Many states require specific safety devices. It is your
responsibility to familiarize yourself with the law of the state where you
ride and to comply with all applicable laws, including properly equipping
yourself and your bikes as the law requires. Reflectors are important
safety devices which are designed as an integral part of your bicycle.
Federal regulations require every bicycle to be equipped with front, rear,
wheel, and pedal reflectors. Theses reflectors are designed to pick up and
reflect street lights and car lights in a way that helps you to be seen and
recognized as a moving bicyclist. Check reflectors and their mounting
brackets regularly to make sure they are clean, straight, unbroken and
securely mounted, Have your dealer replace damaged reflectors and
straighten or tighten and that are bent or broken.
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
Component List
D
i
r
t
H
a
w
k
2
D
D
i
r
t
H
a
i
r
w
t
H
a
w
k
k
0
2
0
2
0
N
N
N
a
a
a
v
v
v
i
g
a
t
o
r
S
F
2
i
g
a
t
o
r
a
t
o
r
i
g
6
S
F
2
S
F
2
6
6
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
N
N
N
a
a
a
v
v
v
i
g
a
t
o
r
S
M
2
i
g
a
t
o
r
a
t
o
r
i
g
S
S
M
M
2
2
6
6
6
O
u
t
b
a
c
k
2
O
u
t
b
u
a
t
b
a
O
DO NOT RETURN STORE. For questions regarding assembly and use, call Customer Service: 877-441-6999.
c
c
k
k
6
2
6
2
6
Loading...