Xerox 9050, 9200, 9040, 9060, 9100 User Manual

9000 Overhead Projector

Illustrated Parts Breakdown

Revision History

Original Issue date: 1994

The release date, revision level, pages changed and a description of the modifications are listed below.

Revision Date Page(s) Changed Description

Rev A 1994 All pages First edition released Rev K 8/2002 Section 14,

Page 41

NOTE 1: Blue text indicates a link to that page.

New Roll Film Kit

All rights reserved. No part of this book covered by the copyrights hereon may be reproduced or copied in any form or by any means-graphic, electronic, or mechanical, including photocopying, taping or information storage and retrieval systems-without written permission of 3M Visual Systems Division.

i

3M™Overhead Projector 9000 Series

This Illustrated Parts Breakdown (IPB) Manual contains the information necessary to locate and identify assemblies, sub-assemblies, and specific parts of the 9000 Series Overhead Projector.

Illustrated Parts Breakdown

Part Numbers

All components available on a replacement basis are listed with their 3M identification number. The parts identification list opposite each illustration provides the description adequate to identify components. If the component is available only as part of the next higher assembly, the description column provides the next higher assembly description or identification number.

Locating and Identifying a Part

If physical appearance and general location of an item are known:

1. Use the IPB Section Titles to help determine which assembly or sub-assembly includes the item.

2. Refer to the view for the assembly or sub-assembly and locate the item on the exploded view. Match the part callout number to the corresponding number in the parts list.

3. Parts shown inside a dashed box can only be ordered as an assembly. Any part or mounting hardware shown outside the box is not included with the assembly.

Machine Identification Plate

The serial number plate for the 9000 is located on the bottom side of the projector. The Machine Identification Plate is divided into the following components:

1. Product Name: The specific version number of the projector.

2. Model Number/Alpha Code: The series number of the projector followed by a three or four character alpha code identifier. The Alpha Code indicates the design level, specific product characteristics, power cord or distribution specific to a country.

3. Lamp: The electrical rating of the lamp.

4. MFG Code: The MFG Code indicates the year and quarter the projector was built. (See the example to the right):

5. S/N: The serial number assigned to this projector.

Ordering Parts

When ordering parts, include the following information:

1. Machine model number and serial number.

2. Parts identification number.

3. Part description.

4. Quantity required.

For U.S. retail customers: Call 1-800-650-8429, or fax 1-800-650-9268. Dealers: Refer to Dealers Guide. 3M Subsidiaries: Contact Export Operations.

Letter Digit

E 1997 1 Jan-Mar F 1998 2 Apr-Jun

H 1999 3 Jul-Sep J- 2000 4 Oct-Dec K 2001 1 Jan-Mar

MFG Code

3M™Overhead Projector 9000 Series

Illustrated Parts Breakdown

Table of Contents

QUICK REFERENCE PARTS INDEX ..................................................................................1

0 OVERVIEW..........................................................................................................................3

1 WIDE ANGLE (OPEN) 293MM HEAD ASSEMBLY..............................................................4

2 ARTICULATE (CLOSED) HEAD ASSEMBLY .....................................................................6

3 TRIPLET AND VARIFOCAL (OPEN) HEAD ASSEMBLIES .................................................8

4 ARM AND FOCUS ASSEMBLY...........................................................................................10

5 TOP COVER........................................................................................................................12

6 BASE ENCLOSURE ............................................................................................................15

7 COOLING FAN ....................................................................................................................20

8 LAMP HOUSING - ENX SINGLE LAMP...............................................................................23

9 LAMP HOUSING - ENX/FXL DUAL LAMP...........................................................................25

10A LAMP HOUSING - EVD DUAL LAMP - 9550 (MFG CODE A3 AND EARLIER)...................27

10B LAMP HOUSING - EVD DUAL LAMP - 9550 (MFG CODE A3 AND LATER).......................29

11 LAMP HOUSING - FNT SINGLE LAMP...............................................................................32

12A LAMP HOUSING - FNT DUAL LAMP (MFG CODE A3 AND EARLIER) ..............................34

12B LAMP HOUSING - FNT DUAL LAMP (MFG CODE A3 AND LATER) ..................................36

13 LAMPCHANGER AND HI/LO LAMP CONTROL MODULE (DUAL LAMP VERSIONS) .......38

14 ROLLxFILMxKIT...................................................................................................................41

15 WIRE JUMPERS..................................................................................................................42

16 SMALL ELECTRICAL PARTS KIT (EUROPE ONLY) .........................................................47

17 SMALL MECHANICAL PARTS KIT (EUROPE ONLY) ........................................................48

18 SMALL PLASTIC PARTS KIT (EUROPE ONLY) ................................................................49

19 KIT FASTENERS 9000 SERIES (EUROPE ONLY) ............................................................51

APPENDIX A SPECIFICATIONS.....................................................................................................A-1

IMPORTANT NOTICE

3M reserves the right to sell or furnish NEW OR RECONDITIONED PARTS.

New and reconditioned parts are covered by the same 3M new parts limited warranty.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Quick Reference Parts Index

Description Part

Number

BLADE, Fan 78-8054-1823-9 7 5 CRADLE, Post (Folding Post) 78-8079-8890-8 6 24 DIODE KIT, Inline 78-8054-1836-1 7 16 FAN MOTOR ASSEMBLY (International) 78-8054-1855-1 7 28 FAN MOTOR ASSEMBLY (U.S.) 78-8114-9015-6 7 29 FOOT 26-1008-5211-5 6 41 FRESNEL LENS, Single Element, Glare Free, 182.9 mm

(9050, 9060, 9070, 9080, 9100 AABD, AJB, AJBW, AJBX, 9200 AACD, AKC, AMD)

FRESNEL LENS, Dual Element, Clear, 182.5mm (9075 AJG only)

FRESNEL LENS, Dual Element, Glare Free, 182. 5 m m (9100 except AABD, AJB, AJBW and AJBX, 9200 except AACD and AJC)

FRESNEL LENS, Dual Element, Clear, 174mm | (9550 except ABAJ)

78-8064-1645-5 5 8A

78-8079-9176-1 5 8B

78-8054-1236-4 5 8C

78-8079-9045-8 5 8D

Figure

No.

Item

No.

FRESNEL LENS, Dual Element, Europe, Glare Fr ee, 174mm (9550 ABHJ)

GLASS, Exit, Articulate (293 mm Singlet Head) 78-8064-1650-5 2 4A GLASS, Coated, Articulate (9075 AJG) 78-8073-2982-2 2 4B

GLASS, Stage (9050, 9060, 9070, 9075, 9080, 9100, 9200, and 9550 Europe)

GLASS, Stage (9550) 78-8079-8975-7 5 6B KNOB, Focus 78-8064-1601-8 4 16 LAMP, Projection, ENX, 82V, 360W 78-8011-1186-1 8 9A LAMP, FXL (9200) 78-8073-7100-6 9 13B LATCH, Top Cover 78-8079-8768-6 5 12 LENS, Triplet, (342 mm) (9200) 78-8064-1833-7 3 3 LENS, Varifocal, (270-325 mm) 78-8073-3296-6 3 4 LENS, Meniscus (355 mm) 78-8011-1440-2 2 14B LENS, Exit, Articulate (355 mm Doublet Head) 78-8014-8812-9 2 5 LENS, Condenser (60mm) 78-8079-9025-0 10A 12

78-8095-8353-3 5 8E

78-8064-1473-2 5 6A

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Quick Reference Parts Index

Description Part

Number

MIRROR ASSEMBLY (Open Singlet) 78-8057-4230-7 1 3 MIRROR ASSEMBLY (Doublet) 78-8064-1457-5 2 17 MIRROR ASSEMBLY, Triplet (9550 - Dark Grey, 4mm) 78-8079-9227-2 3 12A MIRROR ASSEMBLY, Triplet (9200 - Black, 3mm) 78-8079-9156-3 3 12B MOTOR, Fan (230 Volt) 78-8079-8936-9 7 15A MOTOR, Fan (100 Volt) 78-8079-8937-7 7 15B RESISTOR, 1.2 Ohm (9050, 9060, 9070) 78-8073-7127-9 8 14 SOCKET, Single lamp (ENX ) 78-8079-8820-5 8 8 SWITCH, Micro 78-8079-9199-3 7 7 SWITCH, Lampchanger/Hi/Lo, Dimm er 78-8079-8855-1 13 8 THERMOSTAT, Safety (ENX ) 78-8079-8872-6 8 5 THERMOSTAT (9080/ENX, 9100/ENX, 9200/ENX, 9550) 78-8079-8933-6 13 2 TRANSFORMER, EVD, Japan (9550) (100V) 78-8079-9056-5 6 16A

Figure

No.

Item

No.

TRANSFORMER, Auto, EVD (120V) 78-8079-9079-7 6 16B TRANSFORMER, EVD (220V) 78-8079-8991-4 6 16C TRANSFORMER, FNT (100V) 78-8079-8921-1 6 16D TRANSFORMER, FNT, Taiwan (120V) 78-8079-9070-6 6 16E

TRANSFORMER, FNT, Indonesia (127/220V) 78-8079-8920-3 6 16F TRANSFORMER, Auto, Hong Kong, Thailand (220/230V) 78-8073-3009-3 6 16G TRANSFORMER, Auto (230/240V) 78-8073-3010-1 6 16H TRANSFORMER, Auto, Australia, India, New Zealand,

South Africa (240/250V) TRANSFORMER, Brazil (127/220V) (9080 ABDB) 78-8079-9231-4 6 16J

LAMP, EVD (9200 78-8079-8791-8 9 13B LAMP, FNT(9200)

78-8073-3011-9 6 16I

78-8054-1175-4 9 13B

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 0. Machine Overview

SMALL ELECTRICAL PARTS KIT

(EUROPE ONLY)

(See Section 16)

SMALL MECHANICAL PARTS KIT

(EUROPE ONLY)

(See Section 17)

SMALL PLASTIC PARTS KIT

(EUROPE ONLY)

(See Section 18)

KIT FASTENERS 9000 SERIES

(EUROPE ONLY)

(See Section 19)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 1.

Wide Angle (Open) 293mm Head Assembly

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 1.

Wide Angle (Open) 293mm Head Assembly Parts List

Item

No.

0 78-8079-9151-4 HEAD ASSEMBLY, Wide Angle (O pen) , 293mm Singlet 3 1A 78-8014-8951-5 LENS, W ide Angle (293mm) 1 1B 78-8073-2980-6 LENS, W ide Angle (Used on 9075 United States, 9085 United

2 78-8064-1646-3 TUBING, Lens 3

3 78-8057-4230-7 MIRROR ASSEMBLY (Open Singlet) 1

4 78-8064-1605-9 SPRING, Mirror Damping (Used on 9050 and 9080, except

5 (See Note 1) NUT, U-Type, 8-32 1

6 78-8079-8802-3 COVER, Head, Singlet 1

7 (See Note 1) SCREW, Taptite, M3.5 X 8 1

8 (See Note 1) SCREW, Type BT, 8-18 X 7/ 16 1

9 (See Note 1) WASHER, Plain Nylon 1 10 78- 8079- 8803- 1 BRACKET , Lens, Singlet 1 11 JV-0890-0185-1 LABEL, Caution, Japan (9050 ABAJ, 9080 ABDJ, 9200 ABCJ) 1

3M

Part Number

Description Qty.

1

States plus AAW B, ABWB)

1

9080 AJD)

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 2.

Articulate (Closed) Head Assembly

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 2.

Articulate (Closed) Head Assembly Parts List

Item

No.

0A 78-8079-9152-2 HEAD ASSEMBLY, Articulate (Closed), 293mm Singlet, W ide

0B 78-8079-9153-0 HEAD ASSEMBLY, Articulate (Closed), 355mm Doublet 1 0C 78-8073-3115-8 HEAD ASSEMBLY, Articulate (Closed), Coated, 293mm

1A 78-8064-1602-6 CLAMP, Dust Shield and Lens 1 1B 78-8054-1791-8 CLAMP, Dust Shield and Lens (Singlet) (Used on United

2 78-8064-1797-4 SHIELD, Dust (Short) 1

3 78-8064-1562-2 HOUSING, Exit Lens 1 4A 78-8064-1650-5 GLASS, Exit, Articulate (293m m Singlet Head) 1 4B 78-8073-2982-2 GLASS, Coated, Articulate ( 9075 AJG ) 1

5 78-8014-8812-9 LENS, Exit, Articulate (355mm Doublet Head) 1 6A 78-8079-8805-6 COVER, Head, Doublet 1 6B 78-8079-9229-8 COVER, Head, Doublet, Xer ox 1

7 (See Note 1) SCREW, Taptite, M3.5 X 8 1

3M

Part Number

Description Qty.

Angle

Singlet, Wide Angle (9075 AJG)

States versions of: 9070, 9075, 9080 plus AADD, 9085)

1

8 (See Note 1) SCREW, Taptite, M3 X 6 1

9 78-8014-8817-8 SPRING, Tension 3 10 78- 8064- 1643- 0 MOUNT, Lens (293mm Singlet Wide Angle) 1 11 78- 8079- 8804- 9 BRACKET , Lens, Doublet 1 12 78-8011-1445-1 PIVOT 1 13 78-8064-1646-3 TUBING, Lens 2

14A 78-8014-8951-5 LENS, Wide Ang le ( 293m m ) 1 14B 78-8011-1440-2 LENS, Meniscus (355mm) 1 14C 78-8073-2980-6 LENS, Wide Angle (9075 AJG) 1 15A 78-8064-1596-0 CLAMP, Lens (293mm Singlet Head) 1 15B 78-8064-1595-2 CLAMP, Lens (355mm Doublet Head) 1

16 (See Note 1) SCREW, Plastite, 4-20 X 1/ 4 2 17 78- 8064- 1457- 5 MIRROR ASSEMBLY (Doublet) 1 18 JV-0890-0185-1 LABEL, Caution, Japan (9050 ABAJ, 9080 ABDJ, 9200 ABCJ) 1

Note1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 3.

Triplet and Varifocal Head Assemblies

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 3.

Triplet and Varifocal Head Assemblies P ar ts List

Item

No.

0A 78-8079-9154-8 HEAD ASSEMBLY, Triplet (Open) (9200) 1 0B 78-8079-9155-5 HEAD ASSEMBLY, Varifocal (Open) (9550) 1 0C TBD HEAD ASSEMBLY, Triplet (317mm) (9400) 1

1 (See Note 1) NUT, U-Type, 8-32 2

2 (See Note 1) SCREW, Taptite, M3 X 6mm , Black, Zinc 3 3A 78-8097-3693-3 LENS, Triplet, High Resolution (342mm) (9200, 9400 AHRG) 1 3B 78-8014-8916-8 LENS, Triplet (317mm) (9400) 1

4 78-8073-3296-6 LENS, Varifocal (270-325mm) 1

5 78-8079-9014-4 ADAPTER, Lens (9550) 1

6 (See Note 1) SCREW, Taptite, M3.5 X 8 2

7 (See Note 1) SCREW, Plastite, 4-20 X 1/ 4 BZN 3 8A 78-8079-9015-1 COVER, Head (9200, 9400) 1 8B 78-8079-9017-7 COVER, Head (9550) 1

9 (See Note 1) SCREW, Type BT, 8-18 X 7/ 16 2 10 (See Note 1) WASHER, Plain, Nylon 2

3M

Part Number

Description Qty.

11 78- 8079- 9012- 8 BRACKET , Lens ( 9550) 1

12A 78-8079-9227-2 MIRROR ASSEMBLY, Triplet (9550 - Dark G r ey, 4m m) 1 12B 78-8079-9156-3 MIRROR ASSEMBLY, Triplet (9200, 9400 - Black, 3mm) 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 4.

Arm and Focus Assembly

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 4.

Arm and Focus Assembly Parts List

Item

No.

0A DY-0210-2704-9 FOCUS ARM UPGRADE KIT (Europe only) 1 0B 78-8054-1821-3 FOCUS ARM UPGRADE KIT (All versions except 9550)

0C 78-8073-2951-7 FOCUS ARM UPGRADE KIT (9550) (Includes items 1, 2, 9,

1 (See Note 1) SCREW, Plastite, 6-19 X 1/ 2, BZN 4

2 78-8120-2930-0 CAP, Focus Arm 1 3A 78-8079-8745-4 GEAR, Focus 1 3B 26-1009-4445-8 LUBRICANT (All versions) AR

4 (See Note 1) SCREW, Shoulder 2

5 26-1009-4515-8 SPRING, Compression 2

6 78-8079-8747-0 BAR, Pressure 1

7 78-8079-8743-9 CLAMP, Friction 1

8 78-8079-8744-7 RACK, Focus 1

9 (See Note 1) SCREW, Plastite, Sems, 8- 11 X 5/8 2 10 (See Note 1) SCREW, Plastite, Sems, Hex Washer 2

3M

Part Number

Description Qty.

1

(Includes items 1, 2, 3A, 4, 5, 6, 7, 9, 13, 14, 15, and 16)

1

17, 18, 22, and Focus Arm 78-8120-2942-5)

11 78-8079-8798-3 PLATE, Washer 1 12 26-1009-3653-8 CAP, Post (22mm square) 1 13 78-8120-2929-2 ARM, Focus, Plastic 1 14 78-8120-2920-1 PLATE, Standoff 1 15 78-8120-2925-0 PAD, Wear 2 16 78-8064-1601-8 KNOB, Focus 1 17 (See Note 1) SCREW, Plastite, 8-16 X 3/ 8, BZN 2 18 78- 8120- 2933- 4 CLAMP, Fixed Arm (9550) 1 19 JV-0890-0183-6 LABEL, Caution, Japan

(9050 ABAJ, 9080 ABDJ, 9200 ABCJ, 9550 ABHJ)

20A 78-8079-8759-5 POST, Fixed (9050, 9060, 9070, 9075, 9400) 1 20B 78-8079-9088-8 POST, Folding, Long ( 9080, 9100, 9200) 1 20C 78-8079-9089-6 POST, Folding, Long (9550) 1

21 78-8054-1713-2 LABEL, Post, Japan (9050 ABAJ, 9080 ABDJ, 9550 ABHJ) 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 5. Top Cover

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 5.

Top Cover Parts List

Item

No.

1 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 6 2A 78-8120-2943-3 BRACKET, Hinge, Fresnel Lens, Dual Elem ent

2B 78-8120-2941-7 BRACKET, Hinge Fresnel Lens, Single Element

3 78-8073-2955-8 DOOR, Lamp Changer (9080, 9100, 9200) 1 4A 78-8073-2956-6 DOOR, Lamp Changer (9550) 1 4B 78-8095-8398-8 DOOR, Lamp Changer (9400) 1

5 78-8079-9022-7 LABEL, Lamp Indicator (9550) 1 6A 78-8064-1473-2 GLASS, Stage (9050, 9060, 9070, 9075, 9080, 9100, 9200,

6B 78-8079-8975-7 GLASS, Stage (9550) 1 7A 78-8054-1835-3

7B 78-8054-1837-9

7C 78-8054-1839-5 TOP COVER, A4 (9050) 1

3M

Part Number

Description Qty.

(9075, 9085, 9100/FNT, 9200/FNT , 9400, 9550)

(9050, 9060, 9070, 9080, 9100/ENX, 9200/ ENX)

9400, 9550 Europe),

TOP COVER, 10.5″ (267m m ) (without lamp changer door) (9050, 9060, 9070, 9075, 9080, 9085)

TOP COVER, 10.5″ (267mm) (with lamp changer door) (9080, 9100, 9200 AACM, BGC)

1

7D 78-8054-1838-7 TOP COVER, A4 (9080, 9085, 9100, 9200) 1 7E 78-8054-1842-9 TOP COVER, A4

(All 9550 except AAHD, AAHT, and AHHM, AJH)

7F 78-8054-1840-3 TO P COVER, A4 (9550 AAHD, AAHT and AHHM, AJH) 1

7G 78-8073-3108-3 TOP COVER, A4 (9080 Indonesia) 1 7H 78-8073-3106-7 TOP COVER, A4 (9100 Indonesia) 1

7I 78-8073-3107-5 TOP COVER, A4 (9200 Indonesia) 1

7J 78-8054-1842-9 TOP COVER, A4 (9400 Korea and Europe) 1 7K 78-8079-9178-7 TOP COVER, A4, Kit ( 9550 out side U.S.) 1 8A 78-8064-1645-5 FRESNEL LENS, Single Element, Glar e Fr ee, 182.9mm

(9050, 9060, 9070, 9080, 9100 AABD, AJB, AJBW, AJBX, 9200 AACD, AKC, AMD) (Europe)

8B 78-8095-8353-3 FRESNEL LENS, Dual Element, Clear, 182. 5m m

(9075 AJG only)

8C 78-8054-1236-4 FRESNEL LENS, Dual Element, Glare Free, 182.5mm

(9100 except AABD, AJB, AJBW and AJBX, 9200 except AACD and AJC) (Europe)

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 5.

Top Cover Parts List

Item

No.

8D 78-8079-9045-8 FRESNEL LENS, Dual Element, Clear, 174mm

8E 78-8079-9176-1 FRESNEL LENS, Dual Element, Glare Free, 174mm

9A 78-8079-8828-8 RETAINER, Fresnel Lens, Single Elem ent 1 9B 78-8079-8830-4 RETAINER, Fresnel Lens, Dual Element 1

10 78-8079-8939-3 LABEL, Caution (Lens) 1 11 78-8005-0481-9 SPRING

12 78- 8079- 8768- 6 LAT CH, Top Cover 1 13A 78-8079-8748-8 BUTTON, Power Switch, RED (All versions except 9550) 1 13B 78-8079-8974-0 BUTTON, Power Switch, PLUM (9550 except AHHK) 1 13C 78-8079-9165-4 BUTT O N, Power Switch, Korea (9550 AHHK) 1

14 78- 8064- 1515- 0 ACT UATOR, Switch Button 1

15 78- 8079- 8924- 5 SHIELD, Heat , ENX Lamp 1 16A 78-8079-8918-7 SHIELD, Heat, FNT/EVD Lamp ( all FNT and EVD versions 1 16B 78-8095-8339-2 SHIELD, Heat, EVD Lamp (9400, 9550 except AAHD, AAHT, 1

3M

Part Number

Description Qty.

1

(9550 U.S. except ABHJ)

1

(9550 ABHJ Europe)

17 78- 8073- 2965- 7 BRACKET , Airflow (9400, 9550) 1

18 (See Note 1) SCREW, Plastite, 6-19 X 3/ 8 2

19 JV-0890-0183-6 LABEL, Caution, Japan (9050, 9080, 9200, 9550) 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 6.

Base Enclosure

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 6.

Base Enclosure Parts List

Item

No.

1A 78-8073-2976-4 BASE, Post, Fixed

1B 78-8079-9095-3 BASE, Post, Folding (9080, 9100) ( Ver sion 2) 1 1C 78-8079-9094-6 BASE, Carrying Handle (9200, 9550) (Version 2) 1 1D 78-8079-9093-8 BASE, Post, Fixed (9050, 9400) (Version 2) 1

2 78-8079-9066-4 FOOT, Support, Side ( Except 9050 AHRS, AHRU, AHRZ,

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 7 4 78-8079-8817-1 PIVOT, Cover 2 5 26-1004-9859-6 CLAMP 1 6 DY-1160-2020-6 STRAIN RELIEF 1 7 78-8073-7212-9 SWITCH, Hi/Lo (9050 AHAF, AHAS, AHAZ, 9075 AJG, 9080

8 78-8079-9007-8 BRACKET, Voltage Select Switch 1 9 (See Note 1) SCREW, Thread Cutting, 8-18 X 5/16 1

3M

Part Number

Description Qty.

1

(9550, 9060 AAEM, AJE, 9070 AJF, 9075 AJG)

1

9080 AHRS, AHRU, AHRZ, 9400 AHRS, AHRU, AHRZ)

1 AHDF, AHDS, AADZ, AHBC, AHBF, AHBS, AHBZ, 9200 AHCC, AHCF, AACS, AHCZ AHMZ, 9550 AHHH)

10 Not Available MIRROR BRACKET ASSEMBLY, First Surface (9550-EVD) 1 11 Not Available MIRROR BRACKET ASSEMBLY (9200) 1 12 78- 8079- 9141-5 MIRROR BRACKET ASSEMBLY

(All ENX & FXL Lamp versions)

13 78- 8079- 9142-3 MIRROR BRACKET ASSEMBLY

(All FNT & EVD Lamp versions)

14A (See Note 1) SCREW, Taptite, M4 X 60 2 14B (See Note 1) SCREW, 8/32 X 1-1/2 (9080 ABDB, 9085 ABWB) 2

15 (See Note 1) SCREW, Taptite, M3.5 X 6 5 16A 78-8079-9056-5 TRANSFORMER, Japan EVD (9550) (100V) 1 16B 78-8079-9079-7 TRANSFORMER, Auto, EVD (120V) 1 16C 78-8079-8991-4 TRANSFORMER, EVD (220V) 1 16D 78-8079-8921-1 TRANSFORMER, FNT (100V) 1 16E 78-8079-9070-6 TRANSFORMER, FNT Taiwan (120V) 1 16F 78-8079-8920-3 TRANSFORMER, FNT, Indonesia (127/220V) 1 16G 78-8073-3009-3 TRANSFORMER, Auto, Hong Kong, Thailand (220/230V) 1 16H 78-8073-3010-1 TRANSFORMER, Auto, FNT, Europe (230/240V) 1

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 6.

Base Enclosure Parts List

Item

No.

16I 78-8073-3011-9 TRANSFORMER, Auto, Australia, India, New Zealand, Sout h

16J 78-8079-9231-4 TRANSFORMER, Brazil, (127/220V) (9080 ABDB) 1 17A (See Note 1) WASHER, Lock #8, Int/ Ext T ooth, #8 2 17B (See Note 1) WASHER, Ext Tooth, Lock, #10 1 18A 78-8073-3007-7 BRACKET, Transformer 1 18B 78-8073-3008-5 BRACKET, Transformer, Small

19 78- 8079- 8810- 6 BRACKET , Backup (Fixed Post)

20 78-8079-8809-8 BLOCK, Post (Fixed Post) 1 21 (See Note 1) BOLT, Post (Fixed Post) 2 22 78-8011-1485-7 WRENCH 1 23 (See Note 1) SCREW, Taptite, M3.5 X 8 2 24 78- 8079- 8890- 8 CRADLE, Post (Folding Post) 1 25 78- 8079- 8846- 0 BRACKET , Pivot (Folding Post)

3M

Part Number

Description Qty.

1

Africa (240/250V)

2

(Not used in European versions)

1

(Not used in European versions)

1

(All folding post versions except 9550 ABHJ)

26 (See Note 1) SPRING, Compression 1 27 (See Note 1) SCREW, Latch (Folding Post) 1 28 78- 8079- 8852- 8 POST LOCK (Folding Post) 1 29 (See Note 1) SCREW, TT, Pan Head, 10- 32 X 5/8 L 1 30 (See Note 1) NUT, Hex, 1/4 - 20, Elastic 1 31 (See Note 1) WASHER 2 32 78-8079-8875-9 PIVOT, Post Mount (Folding Post) 1

33A (See Note 1) BOLT, Pivot (Folding Post)

(All folding post versions except 9550 ABHJ)

33B (See Note 1) BOLT, Pivot (Folding Post) (9550 ABHJ) 1

34 Not Available HANDLE ASSEMBLY (Mfg. Code A3 and earlier) 1 35 (See Note 1) SCREW, Sems, Taptit e, M4 X 8 2 36 78- 8073- 2972- 3 LABEL, Nom , Mexico (Short) (9050 AAAM, 9060 AAEM,

9100 AABM, 9200 AACM, 9550 AHHM)

37A 78-8054-1804-9 POWER CO RD, Australia, 10 Ft. 1 37B 78-8054-1803-1 POWER CO RD, Australia, 15 Ft. 1 37C 78-8054-1799-1 POWER CORD, Europe, 10 Ft. 1

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 6.

Base Enclosure Parts List

Item

No.

37D 78-8054-1802-3 POWER CORD, Europe, 15 Ft. 1 37E 78-8054-1815-5 POWER CO RD, 2 Blade (with ground), 10 Ft.

37F 78-8054-1814-8 POWER CORD, 2 Blade (with ground) , 15 Ft.

37G 78-8054-1810-6 POWER CORD, India, 15 Ft. 1 37H 78-8054-1812-2 POWER CORD, Italy, 15 Ft . 1

37I 78-8054-1797-5 POWER CORD, United Kingdom, 10 Ft 1

37J 78-8054-1798-3 POWER CORD, United Kingdom, 15 Ft . 1

37K 78-8079-8822-1 POWER CO RD, U.S. (120V) 10 Ft. (9050, 9060, 9070, 9075) 1

37L 78-8079-8934-4 POWER CO RD, U.S. (120V) 15 Ft.

37M 78- 8054-1811-4 POWER CORD, 120V, (9550) 1 37N 78-8054-1809-8 POWER CORD, South Af rica, 10 Ft. 1

3M

Part Number

Description Qty.

(9050 AAAT, ABAJ, ARAP)

(9050 AAAB, 9080 AADB, AADT, ABDB, ABDJ, ARDP, 9085 AAWB, ABWB, 9100 AABT, ABBJ, ARBP, 9200 AACT, ABCJ, ARCP, 9550 AAHT, ABHJ and ARHP)

(9100, 9200 ENX and FXL)

1

37O 78-8054-1806-4 POWER CORD, South Africa, 15 Ft. 1

37P 78-8054-1805-6 POWER CO RD, Swiss, 15 Ft. 1 38A (See Note 1) SCREW, Plastite, 6-19 X 1 1 38B (See Note 1) SCREW, Plastite, 6-19 X 1, Torx 1 39A (See Note 1) NUT, Keps, 10-32, External, Lock Wash

(Mfg. Code A3 and earlier)

39B (See Note 1) NUT, Keps, 12-24 (Mfg. Code A3 and later) 2

40 (See Note 1) SCREW, Foot 4 41 26-1008-5211-5 FOOT 4 42 78-8079-8897-3 WRAP, Cord 1 43 78-8073-3039-0 SWITCH, Interlock 1 44 Not Available COVER, Interlock Switch 1 45 (See Note 1) SCREW, End Cap (Mfg. Code A3 and later ) 2 46 78- 8054- 1456- 8 RESISTOR, 220/240V (9550 AHHH) 1 47 78-8033-1666-6 CLIP, Tinnerman 1 48 (See Note 1) SCREW, Mach, M3 X 16 4 49 Not Available BRACKET, Resistor 1

2

50 (See Note 1) NUT, Keps, M3 4

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 6.

Base Enclosure Parts List

Item

No.

51 78- 8079- 9218- 1 ST RAP, Handle (Mfg. Code A3 and later) 1 52 78- 8079- 9217- 3 CAP, End ( Mf g. Code A3 and later) 2 53 78- 8095- 8354- 1 BRACE, Post (9550 ABHJ) 1 54 JV-0890-0183-6 LABEL, Caution, Japan (9050 ABAJ, 9080 ABDJ, 9100 ABBJ

55 78- 8079- 9138- 1 LABEL, Switch, Brazil 1 56 78- 8073- 7127- 9 RESISTOR, 1.2 Ohm, .25 tab (Used on all ENX Lamp models

57 (See Note 1) CLIP, Tinnerman (Used on U.S. versions of: 9050, 9060,

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M

Part Number

Description Qty.

9200 ABCJ, 9550 ABHJ)

of: 9050, 9060, 9070, 9075, 9080 except AADB, 9085, 9100, and also 9200 FXL Lamp models)

9070, 9075)

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 7.

Cooling Fan

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 7.

Cooling Fan Parts List

Item

No.

1 (See Note 1) SCREW, 6-19 X 3/8 L, Plastit e 1 2A 78-8079-8796-7 PLATE, Cord, Large (Black) 1 2B 78-8079-8797-5 PLATE, Cord, Small (Gray) 1

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 3

4 (See Note 1) SCREW, Taptite, M3.5 X 6 4

5 78-8054-1823-9 BLADE, Fan 1

6 (See Note 1) SCREW, Type BT, 4-24 X 5/ 8 1

7 78-8079-9199-3 SWITCH, Micro 1 8A 78-8079-8878-3 LABEL, Lamp Replacement (ENX) 1 8B 78-8079-8977-3 LABEL, Lamp Replacement (FXL) ( 9075, 9200) 1

8C 78- 8079-8979-9 LABEL, Lamp Replacement (EVD International)

8D 78- 8079-8978-1 LABEL, Lamp Replacement (FNT) 1

8E 78-8079-8980-7 LABEL, Lamp Replacement (EVD - U.S. ) 1 8F 78-8079-9084-7 LABEL, Lamp Replacem ent ( J apan) 1

8G JV-0890-0189-3 LABEL, Lamp Replacement, Japan (9050 ABAJ, 9080

3M

Part Number

Description Qty.

1

(9400, 9550)

1

ABDJ, 9100 ABBJ, 9200 ABCJ, 9550 ABHJ)

9 (See Note 1) SCREW, Plastite, 4-20 X 3/ 8 1

10A 78-8057-4184-6 LABEL, Fuse, 5 Amp 1 10B 78-8079-9057-3 LABEL, Fuse, Japan 1 10C 78-8079-9018-5 LABEL, Fuse, 4 Amp 1 11A 26-1005-9599-5 FUSE, 5 Amp (100/120V versions) (9550, 9400 Europe) 1 11B 26-1008-6347-6 FUSE, 4 Amp (9050, 9080, 9200 Europe) 1

12 26-1005-6624-4 FUSEHOLDER 1 13 78- 8079- 8874- 2 DUCT , Fan, Forward 1 14 78- 8079- 8873- 4 DUCT , Fan, Rear 1

15A DY-0120-2707-2 MOTOR, Fan (230V) (All European versions) 1 15B 78-8079-8937-7 MOTOR, Fan (100V) 1

16 78- 8054- 1836- 1 DIODE KIT, Inline 1 17 (Part of item 16) SCREW, Plastite, 6-19 X 1/2 1

18 78-8120-2913-6 BRACKET, Motor 1 19 Not Available TAPE, Reflective (9080, 9100, 9200, 9400, 9550) AR 20 78- 8064- 1809- 7 LABEL, Caut ion (Australia) 1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 7.

Cooling Fan Parts List

Item

No.

21A 78-8073-3292-5 LABEL, Service (New Zealand) 1 21B 78-8079-9201-7 LABEL, Service (Australia) 1

21C JV-0891-0182-6 LABEL, Japan (9050 ABAJ, 9080 ABDJ, 9100 ABBJ,

22 Not Available NAMEPLATE, Data REF 23 (See Note 1) SCREW, Taptite, M3.5 X 10 1 24 Not Available TAPE, Reflective, 1 inch AR 25 78- 8003- 8335- 4 WIRE, Tie, Panduit (Not shown) AR 26 (Part of item 16) HOLDER, Diode (Not shown) 1 27 Not Available SHIELD, Winding (Not shown) 1 28 78- 8054- 1855- 1 FAN MOTO R ASSEMBLY - Int ernational (Not shown)

29 78- 8114- 9015- 6 FAN MOTO R ASSEMBLY - U.S. (Not shown)

3M

Part Number

Description Qty.

9200 ABCJ, 9550 ABHJ)

(Includes items 5, 15B, 18, and 27, plus 2 jum pers and 4 screws)

(Includes items 5, 13, 14, 15A, 18, and 27, plus a label, tape, and 8 screws)

1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 8.

Lamp Housing - ENX Single Lamp

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 8.

Lamp Housing - ENX Single Lamp Part s Li st

Item

No.

0 78-8079-9157-1 LAMP MODULE, ENX Single (120V) (Complete assembly) 1

1 78-8079-8752-0 HOUSING, Lamp Module 1 2A 78-8079-8840-3 BRACKET, Support (All versions except 9075 AJG) 1 2B 78-8073-2975-6 BRACKET, Switch, Hi/Low (9075 AJG only) 1

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 3

4 (See Note 1) SCREW, Taptite, M3.5 X 6 4

5 78-8079-8872-6 THERMOSTAT, Safety (ENX ) 1

6 (See Note 1) SCREW, Taptite, M3 X 16 1

7 78-8064-1509-3 COVER, Wire 1

8 78-8079-8820-5 SOCKET, Single lamp (ENX ) 1

9 78-8011-1186-1 LAMP, Projection, ENX, 82V, 360W 1

10 78-8064-1491-4 WIREFORM, Lampholder 1 11 78-8064-1510-1 SPRING, Retainer 1 12 78-8073-7208-7 BRACKET, Socket 1 13 78-8033-1666-6 CLIP, Tinnerman 1

3M

Part Number

Description Qty.

14 78-8073-7127-9 RESISTOR, 1.2 Ohm (9050, 9060, 9070) 1 15 78- 8079- 8895- 7 MOUNT, ENX - Single Lamp 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 9.

Lamp Housing - ENX/FXL Dual Lamp

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 9.

Lamp Housing - ENX/FXL Dual Lamp Parts List

Item

No.

0A 78-8079-9158-9 LAMP MODULE, without Dimmer (120V) (9080)

0B 78-8079-9159-7 LAMP MODULE, with Dimmer (120V) (9100, 9200)

1 78-8095-8343-4 HOUSING, Lamp Module 1

2 (See Note 1) SCREW, Taptite, M3.5 X 6 6

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 3

4 78-8079-8923-7 BRACKET, Wire Cover 1

5 78-8079-8858-5 PLATE, Socket, Dual Lamp (ENX ) 1

6 78-8079-8862-7 EJECTOR, Lamp 2 7,8 Not Used

9 78-8079-8984-9 SLEEVE, Insulator 1

10 (See Note 1) SCREW, Taptite, M3 X 12 2 11 78- 8073- 3017- 6 SOCKET, Lamp, Dual, Black 2 12 Not Used

13A 78-8011-1186-1 LAMP, ENX (9080, 9100) 2

3M

Part Number

Description Qty.

1

(Complete assembly)

1

(Complete assembly)

13B 78-8073-7100-6 LAMP, FXL (9075, 9200) 2

14 78-8079-8863-5 RETAINER, Lamp 1 15 78- 8079- 8856- 9 PLAT E, Lam p, Dual Lamp (ENX) 1 16 78- 8079- 8857- 7 PIVO T, Lamp Mount, Dual Lamp (ENX) 1 17 78- 8079- 8866- 8 SLEEVE, Color Tuning 1 18 78- 8073- 3005- 1 BRACKET , Lamp Mount, ENX (Used on all versions after

serial no. 842643)

19 78- 8079- 8912- 0 KNOB, Color Tuning 1 20 26-1009-7485-1 SPRING 21 (See Note 1) CLIP, Tinnerman 1 22 78- 8079- 8893- 2 SHAFT , Color Tuning 1 23 (See Note 1) CLIP/Clamp, Cable Clamp Acc. 1 24 78- 8079- 8887- 4 ROD, Lamp Changer 1 25 Not Available TAPE, Reflective 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 10A.

Lamp Housing - EVD Dual Lamp (9550)

(Mfg. Code A3 and earlier)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 10A.

Lamp Housing - EVD Dual Lamp (9550)

(Mfg. Code A3 and earlier) Parts List

Item

No.

0 78-8079-9162-1 LAMP MODULE, EVD Dual (120V) (Complete assembly) 1

1 78-8079-8752-0 HOUSING, Lamp Module 1

2 (See Note 1) SCREW, Taptite, M3.5 X 6 3

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 4

4 78-8079-8837-9 HOLDER, Reflector (EVD) 1

5 78-8079-8899-9 REFLECTOR, (60 mm) 1

6 Not Available BRACKET, Dual Lamp (EVD) 1

7 78-8003-8335-4 WIRE, Tie, Panduit 1

8 Not Available LAMP SOCKET ASSEMBLY, Dual 1

9 78-6969-9248-2 LAMP, EVD 2

10 (See Note 1) SCREW, Taptite, M3 X 10 2 11 78-8079-9053-2 SPRING, Catch 1 12 78-8079-9025-0 LENS, Condenser (60 mm) 1 13 78- 8079- 8836- 1 BRACKET , Lens ( Large Condenser) 1 14 78-8079-8930-2 ROD, Center 1

3M

Part Number

Description Qty.

15 78-8079-9008-6 SLIDE, Lamp Changer 1 16 78- 8079- 8896- 5 SPRING, Retaining, Reflector ( EVD) 1 17 (See Note 1) SCREW, Taptite, M3.5 X 12 2 18 78-8079-8931-0 ROD, Slide 2 19 78- 8079- 8814- 8 MOUNT, Lam p Holder (FNT/EVD) 2 20 (See Note 1) RING, Push-on, Truarc 1 21 78- 8079- 8988- 0 ROD, Lamp Changer 1 22 78-8079-9097-9 ROD, Slide 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 10B.

Lamp Housing - EVD Dual Lamp (9550)

(Mfg. Code A3 and later)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 10B.

Lamp Housing - EVD Dual Lamp (9550)

(Mfg. Code A3 and later) Parts List

Item

No.

0 78-8079-9162-1 LAMP MODULE, Dual, EVD (120V) (Complete assembly) 1 1A 78-8079-8752-0 HOUSING, Lamp Module

1B 78-8095-8343-4 HOUSING, Lamp Module,

2 (See Note 1) SCREW, Taptite, M3.5 X 6 3

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 4

4 78-8079-8896-5 SPRING, Retaining, Reflector (EVD) 1

5 78-8079-8899-9 REFLECTOR, (60mm) 1

6 78-8003-8335-4 WIRE, Tie, Panduit 1

7 78-8079-8988-0 ROD, Lamp Change 1

8 78-8079-9203-3 BRACKET, Dual Lamp (EVD) 1

9 78-8073-3015-0 SOCKET ASSEMBLY, Lamp, Dual 1

10 78-6969-9248-2 LAMP, EVD 2 11 (See Note 1) SCREW, Taptite, M3 X 10 2

3M

Part Number

Description Qty.

1

(Used on all versions except 9400 Korea) (See Note 2)

1

(9400 Korea only) (See Note 2)

12 78-8079-9053-2 SPRING, Catch 1 13 78-8079-9025-0 LENS, Condenser (60mm) 1 14 78- 8079- 8836- 1 BRACKET , Lens ( Large Condenser) 1 15 78-8079-8930-2 ROD, Center 1 16 78- 8054- 1763- 7 HOLDER, Reflector (EVD) 1 17 (See Note 1) RING, Push-on, Truarc 1 18 78-8079-8931-0 ROD, Slide 2 19 78- 8079- 8814- 8 MOUNT, Lam p Holder (FNT/EVD) 1 20 78- 8097- 3649- 5 SPACER, Reflector 1 21 78- 8079- 8928- 6 SHAFT , Color Tune, International

(9400 Korea only) (See Note 2) 22A 78-8079-8866-8 SLEEVE, Color Tune (9400 Korea only) (See Note 2) 1 22B 78-8073-3117-4 NUT (9050, 9400) 1 23A (See Note 1) WASHER, Spring (9400 Korea only) (See Note 2) 1 23B 26-1009-9689-6 WASHER, Spr ing (9050, 9400) 1

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 10B.

Lamp Housing - EVD Dual Lamp (9550)

(Mfg. Code A3 and later) Parts List

Item

No.

24A (See Note 1) CLIP, Speed Knob to Shaft (9400 Korea only) (See Note 2) 1 24B 26-1009-7186-5 CLIP, Speed Knob (9050, 9400) 1

25 78- 8079- 8912- 0 KNOB, Color Tuning (9400 Korea only) (See Note 2) 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

Note 2: The 9400 Korean version does not have a specific alpha designator.

3M

Part Number

Description Qty.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 11.

Lamp Housing - FNT Single Lamp

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 11.

Lamp Housing - FNT Single Lamp Part s List

Item

No.

0 Not Available LAMP MODULE, FNT Singlet (230V) (Complet e assem bly) 1 1A 78-8079-8752-0 HOUSING, Lamp Module 1 1B 78-8095-8343-4 HOUSING, Lamp Module 1

2 (See Note 1) SCREW, Taptite, M3.5 X 6 8

3 78-8079-9010-2 THERMOSTAT, Safety (FNT) 1

4 78-8073-2961-6 BRACKET, Lamp Change 1

5 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 1

6 78-8079-8896-5 SPRING, Retaining, Reflector (EVD) 1

7 78-8079-8829-6 REFLECTOR, Metal (32mm) 1

8 78-8079-8841-1 LAMP SOCKET ASSEMBLY, Single 1

9 78-6969-9246-6 LAMP, FNT 1 10 78-8079-9053-2 SPRING, Catch 1 11 78- 8073- 3118- 2 HOLDER, Reflector (FNT) 1 12 78-8012-7827-2 LENS, Condenser 1 13 78- 8079- 8834- 6 BRACKET , Lens ( Sm a ll Condenser ) 1

3M

Part Number

Description Qty.

14 78-8079-8930-2 ROD, Center 1 15 (See Note 1) RING, Push-on, Truarc 2 16 78- 8079- 8814- 8 MOUNT, Lam p Holder (FNT/EVD) 1 17 78-8079-8931-0 ROD, Slide 2

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 12A.

Lamp Housing - FNT Dual Lamp

(Mfg. Code A3 and earlier)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 12A.

Lamp Housing - FNT Dual Lamp

(Mfg. Code A3 and earlier) Parts List

Item

No.

0 78-8079-9161-3 LAMP MODULE, FNT Lamp Changer (230V)

1 Not Available HOUSING, Lamp Module 1

2 (See Note 1) SCREW, Taptite, M3.5 X 6 2

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 4

4 78-8079-8835-3 HOLDER, Reflector (FNT ) 1

5 78-8079-8829-6 REFLECTOR, Metal (32mm) 1

6 Not Available BRACKET, Dual Lamp (FNT ) 1

7 78-8003-8335-4 WIRE, Tie - Panduit 1

8 Not Available LAMP SOCKET ASSEMBLY, Dual 1

9 78-6969-9246-6 LAMP, FNT 1 10 (See Note 1) SCREW, Taptite, M3 X 10 2 11 78-8079-9053-2 SPRING, Catch 1 12 78-8012-7827-2 LENS, Condenser 1 13 78- 8079- 8834- 6 BRACKET , Lens ( Sm a ll Condenser ) 1 14 78-8079-8930-2 ROD, Center 1

3M

Part Number

Description Qty.

1

(Complete assembly)

15 78-8079-9008-6 SLIDE, Lamp Changer 1 16 (See Note 1) SCREW, Taptite, M3.5 X 12 1 17 78- 8079- 8896- 5 SPRING, Retaining, Reflector (EVD) 1 18 78- 8079- 8814- 8 MOUNT, Lam p Holder (FNT/EVD) 1 19 78-8079-8931-0 ROD, Slide 2 20 (See Note 1) RING, Push-on, Truarc 2 21 78- 8079- 8912- 0 KNOB, Color Tuning 1 22 (See Note 1) CLIP, Tinnerman 1 23 26-1008-5200-8 SPRING, Compression 1 24 78- 8079- 8866- 8 SLEEVE, Color Tuning 1 25 78- 8079- 8928- 6 SHAFT , Color Tuning (International) 1 26 78- 8079- 8988- 0 ROD, Lamp Changer 1 27 78-8079-9097-9 ROD, Slide 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 12B.

Lamp Housing - FNT Dual Lamp

(Mfg. Code A3 and later)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 12B.

Lamp Housing - FNT Dual Lamp (Mfg. Code A3 and later) Parts List

Item

No.

0 78-8079-9161-3 LAMP MODULE, FNT Lamp Changer (230V) (Complete) 1

1 78-8095-8343-4 HOUSING, Lamp Module 1

2 (See Note 1) SCREW, Taptite, M3.5 X 6 3

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 4

4 78-8079-8896-5 SPRING, Retaining, Reflector (EVD) 1 5A 78-8079-8829-6 REFLECTOR, Metal (32mm) (9050, 9080, 9100) 1 5B 78-8079-9202-5 REFLECTOR, Metal (60mm) (9200) 1

5C 78- 8079-8899-9 REFLECTOR, 60mm (9550) 1

6 78-8003-8335-4 WIRE, Tie, Panduit 1

7 78-8079-8988-0 ROD, Lamp Changer 1

8 78-8079-9204-1 BRACKET, Dual Lamp (FNT) 1

9 78-8073-3015-0 SOCKET ASSEMBLY, Dual 1 10 78-6969-9246-6 LAMP, FNT 2 11 (See Note 1) SCREW, Taptite, M3 X 10 2 12 78-8079-9053-2 SPRING, Catch 1

13A 78-8012-7827-2 LENS, Condenser 1

3M

Part Number

Description Qty.

13B 78-8079-9025-0 LENS, Condenser (60mm) 1 14A 78-8079-8834-6 BRACKET, Lens (Small Condenser) 1 14B 78-8079-8836-1 BRACKET, Lens (Large Condenser) 1

15 78-8079-8930-2 ROD, Center 1

16A 78-8073-3118-2 HOLDER, Reflector (FNT) 1 16B 78-8054-1763-7 HOLDER, Reflector (EVD) ( 9550) 1

17 (See Note 1) RING, Push-on, Truarc 1 18 78- 8079- 8912- 0 KNOB, Color Tuning 1 19 (See Note 1) CLIP, Speed, Knob to Shaft 1 20 (See Note 1) WASHER, Spring 1 21 78-8073-3117-4 NUT 1 22 78- 8079- 8928- 6 SHAFT , Color Tune, International 1 23 78- 8079- 8814- 8 MOUNT, Lam p Holder (FNT/EVD) 1 24 78-8079-8931-0 ROD, Slide 2 25 (See Note 1) CLIP, Clamp, 0.310 Max (9050 ABAJ, 9080 ABDJ, 9100

ABBJ, 9200 ABCJ, 9550 ABHJ)

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 13.

Lamp Changer & Hi/Lo Lamp Control Module

(Dual Lamp Versions)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 13.

Lamp Changer & Hi/Lo Lamp Control Module

(Dual Lamp Versions) Parts List

Item

No.

0A 78-8079-9147-2 LAMP CHANGER and Hi/Lo Control Module, ENX

0B 78-8079-9149-8 LAMP CHANGER and Hi/Lo Control Module, EVD

0C 78- 8079-9148-0 LAMP CHANGER and Hi/Lo Control Module, FNT

1 (See Note 1) SCREW, Taptite, M3.5 X 6 3 2A 78-8079-8933-6 THERMOSTAT

2B 78-8079-9010-2 THERMOSTAT, Safety

3 (See Note 1) SCREW, Plastite, 6-19 X 5/ 16 1

4 78-8079-8886-6 ADAPTER, Switch, Interlock 1

5 Not Available SW I TCH, Micro 1

3M

Part Number

Description Qty.

(Complete Assembly) (Used on 9000 Series serial no. 842643 and earlier)

(Complete assembly) (Used on 9000 Series serial no. 842643 and earlier) (Used on 9550 serial number 823581 and earlier)

(Complete assembly) (Used on 9000 Series serial no. 842643 and earlier)

(9080/ENX, 9100/ENX, 9200/ENX, 9400, 9550)

(9050/FNT, 9080/FNT, 9100/ FNT, 9200/FNT)

1

6 (See Note 1) SCREW, Taptite, M3 X 12 2

7 (See Note 1) SCREW, Type BT, 4-24 X 5/ 8 2

8 78-8079-8855-1 SWITCH, Lampchanger/Hi/Lo, Dimm er 2 9A 78-8079-8880-9 KNOB, Lamp Changer/Hi/Lo Lamp (Some 9080 versions,

Qty. 1) (Used on 9000 series serial no. 842643 and earlier) (Used on 9550 serial number 823581 and earlier)

9B 78-8073-2962-4 KNOB, Lamp Changer (Used on 9000 Series serial no.

842644 and up) (Used on 9550 serial no. 823582 and up) (9400 - all versions)

10A 78-8079-8879-1 HOUSING, Control, 2 Hole (9100, 9200)

(Used on 9000 Series serial no. 842643 and earlier)

(Used on 9550 serial number 823581 and earlier) 10B 78-8079-8965-8 HOUSING, Control, 1 Hole (9080 Brazil kit) 1 10C 78-8073-2954-1 HOUSING, Lam p Changer (Used on 9550 serial no. 823582

and up) (9400 - all versions) 11A 78-8073-7127-9 RESISTOR, 1.2 Ohm (9080, 9100, 9200 ENX versions) 1 11B 78-8079-9196-9 RESISTOR, .11 Ohm

(9080 AADT, AHDG, 9100 AABT and 9200 AACT ) 12A 78-8073-2987-1 COVER, Resistor, 20W, FXL 1

2

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 13.

Lamp Changer & Hi/Lo Lamp Control Module

(Dual Lamp Versions) Parts List

Item

No.

12B 78-8073-3012-7 COVER, Resistor, 20W, ENX 1 13A 78-8079-8881-7 LEVER, Lamp Changer, ENX/FX L 1 13B 78-8079-8987-2 LEVER, Lamp Changer, EVD/FNT 1

14 Not Available SPRING (Used on 9000 Series serial no. 842643 and earlier) 1 15 78- 8079- 8882- 5 LEVER, Switch, Lamp Hi/Lo, Intensity 1 16 12-7995-0850-7 SPRING 1 17 (See Note 1) WASHER, Lamp Changer (9080, Q ty 1) 2

18A 78-8079-8885-8 BRACKET, Lamp Changer

18B 78-8073-2961-6 BRACKET, Lamp Changer

19 (See Note 1) SCREW, Taptite, 4-24 X 3/4 2

20A 78-8079-8889-0 PCB ASSEMBLY, Lamp Changer (Used on 9550 serial

20B 78-8073-3105-9 PCB ASSEMBLY, Lamp Changer

3M

Part Number

Description Qty.

(Used on 9000 Series serial no. 842643 and earlier) (Used on 9550 serial number 823581 and earlier)

(Used on 9000 Series serial no. 842644 and up) (Used on 9550 serial no. 823582 and up) (9400 - all versions)

number 823581 and earlier) (Not used on 9400)

(Used on 9550 serial no. 823582 and up) (Not used on 9400)

1

21 78- 8095- 8339- 2 T APE, Heat Shield, EVD 1

22A 78-8073-2969-9 SWITCH, Hi/Low (9080 AADT, AHDG, 9085 U.S., plus

AAWB, 9100 Articulate Doublet Head, 9200 Open Triplet Head)

22B 78-8073-2970-7 SWITCH, Hi/Low, EVD

(9400 AHRG, AHRS, AHRU, AHRZ, 9550)

23 (See Note 1) SCREW, Plastite, 4-20 X 3/ 8 BZN 1

Note 1: Order the 9000 Series Hardware Repair Kit (78-8054-1818-9). This kit contains a complete set of hardware for the 9000 Series O.H.P. *For Europe only, see Sections 16, 17, 18, and 19 for Parts Kits.

1

3M Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 14.

Roll Film Kit

Side-to-Side Installation

1

2

Section 14.

Roll Film Kit Parts List

Front-to-Rear Installation

1

Item

No.

1A 78-6969-9586-5 KIT, Roll Film, 10-1/ 4 in. (260.4mm) (Complete assembly) 1 1B 78-6969-7455-5 KIT, Roll Film, 11-1/ 4 in. (285.7mm) (Complete assembly) 1 2A 78-9020-1282-8 FILM, Roll, 10-1/4 in. (260.4mm) 1 2B 78-6969-1751-3 FILM, Roll, 11-1/4 in. (285.7mm) 1

3M

Part Number

Description Qty.

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 15.

Wire Jumpers (1 of 4)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 15.

Wire Jumpers (2 of 4)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 15.

Wire Jumpers (3 of 4)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 15.

Wire Jumpers (4 of 4)

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 15.

Wire Jumpers Parts List

Item

No.

1 78-8079-8913-8 JUMPER, Diode to Resistor and Micro Switch to Thermostat 2 2 78-8079-8971-6 JUMPER, 22” 2 3 78-8079-8972-4 JUMPER, 17” (Blue) 1 4 78-8079-8973-2 JUMPER, Switch to Fuse 2 5 78-8064-1792-5 JUMPER, Ground (Green/Yellow)

6 78-8073-3297-4 JUMPER, 3.5” (Brown) 1 7 78-8073-3102-6 JUMPER, Resistor, 5.5” (Quantity 1 on some versions) 2 8 78-8073-3018-4 JUMPER, 8.75” 1

9 78-8073-3019-2 JUMPER, 12” 1 10 78-8079-8992-2 JUMPER, 9.75” (9075 AJG only) 1 11 78-8073-3297-4 JUMPER, 3.5” (Brown) 1 12 78-8079-9005-2 JUMPER, 12.5” (Black) 1 13 78- 8079- 9006- 0 JUMPER, 12.5” ( White) 1 14 78- 8073- 3014- 3 JUMPER, 26” (Yellow) 1

3M

Part Number

Description Qty.

1

(Not used on Japan machines)

15 78-8079-9180-3 JUMPER, 21” (Brown) 1 16 78- 8097- 3545- 5 JUMPER, 7” (Blue) 1 17 78-8065-8479-9 WIRE, Lead, Diode 1 18 78- 8065- 8268- 6 LEAD ASSEMBLY, Fuse, Kill Switch 1 19 78-8073-3103-4 JUMPER, 7” (9075 AJG only) 1 20 78- 8073- 3013- 5 JUMPER, PCB Switch 2 21 78- 8073- 2973- 1 JUMPER, PCB Switch, 5” 1 22 78- 8097- 3548- 9 JUMPER, 25” (White) 1 23 78-8079-8973-2 JUMPER, 10”, Switch/Fuse (Black) 1 24 78- 8095- 8299- 8 JUMPER, Power Switch to Power Supply (9080 ABDB) 1 25 78-8097-3550-5 JUMPER, 23” (Black) 1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 16. Small Electrical Parts Kit (No Picture)

(Europe only)

Item

No.

0 DY-0210-2716-3 Small Electrical Parts Kit 1

1 - - - Circuit Breaker, 10A 1 2 - - - Fuse, 5 Amp, 5x20mm, Slow Acting 4 3 - - - Fuse, 4 Amp, 5x20mm, Time Lag 4 4 - - - Circuit Breaker, 5A 1 5 - - - Receptacle, Schurter 1 6 - - - Fuse, 16A, 250V 2 7 - - - Switch, Hi/Low, EVD 1 8 - - - Switch, Interlock, Version 2 1

9 - - - Cover, Interlock Switch 1 10 - - - Cover, Interlock Switch, 9700 1 11 - - - Thermostat, Let run, 9850 1 12 - - - Switch, Hi/Low 1

3M

Part Number

Description Qty.

Kit Includes:

13 - - - Switch, Hi/Lo 1 14 - - 15 - - 16 - - - Switch, Interlock 1 17 - - 18 - - - Switch, Hi/Low 1 19 - - - Fuseholder 1 20 - - - Fuse, T8A 2 21 - - - Fuseholder 1 22 - - - Switch, Lamp Changer/Dimmer 1 23 - - - Switch, On/Off 1 24 - - - Fan 1 25 - - - Blade, Fan 1

Thermostat, (190°F/88° C) Thermostat, Safety (FNT 165°F/74°C)

Thermostat, 9700 OHP (210°F/98°C)

1 1

1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 17. Small Mechanical Parts Kit (No Picture)

(Europe only)

Item

No.

0 DY-0210-2718-9 Small Mechanical Parts Kit 1

1 - - - Nut 1 2 - - - Rod, Color Tuning ( MH) 1 3 - - - Rod, Gear Tr ack (MH) 1 4 - - - Gear, Focus 1 5 - - - Bar, Pressure 1 6 - - - Plate, Washer 2 7 - - - Bracket, Backup 1 8 - - - Retainer, Fresnel, Single Element 2

9 - - - Retainer, Fresnel, Dual Element 2 10 - - - Bracket, Pivot 1 11 - - - Mount, Post, Pivot 1 12 - - - Shaft, Color Tune, Intl. 1 13 - - - Plate, Standoff 2 14 - - - Rod, Lamp Changer 1 15 - - - Rod, Lamp Changer, Secondary 1 16 - - - Bracket, Dual Lamp (EVD) 1 17 - - - Bracket, Dual Lamp (FNT ) 1 18 - - - Stop, Leg 1 19 - - - Shield, Heat, Corner 1 20 - - - Actuator, Interlock 1 21 - - - Brace, Post 2 22 - - - Wrench 1 23 - - - Lever, Lamp Changer 1 24 - - - Lever, Lamp Changer 1 25 - - - Gear, Track 1 26 - - - Gear, Color Tuning 1 27 - - - Rod, Color Tuning 1 28 - - - Spacer, Reflector 1 29 - - - Spacer, Condenser 1 30 - - - Clamp, Fixed Arm 1 31 - - - Shield, Winding 1 32 - - - Rod, Center 1 33 - - - Rod, Slide 1

3M

Part Number

Description Qty.

Kit Includes:

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 18. Small Plast ic Parts Kit (No Picture)

(Europe only)

Item

No.

0 DY-0210-2717-1 Small Plastic Parts Kit 1

1 - - - Bushing, 0.375 dia. 2 2 - - - Bushing, 0.75 dia. 2 3 - - - Clip/Clamp, 0.310 dia. 1 4 - - - Foot 4 5 - - - Fastener, Push-In, 0.133 Max Chassis 2 6 - - - Spacer, PCB, Nylon, 1/2 inch Spac. 2 7 - - - Fastener, Panel 2 8 - - - Bushing, 0.50 dia. 2

9 - - - Plug, Dome 2 10 - - - Clip/Clamp, 1/2 inch dia. 2 11 - - - Pad, Wear 2 12 - - - Cap, 4-6-8 Screw Size 2 13 - - - Housing, Mirror, Black 1

3M

Part Number

Description Qty.

Kit Includes:

14 - - - Actuator, Switch Button 1 15 - - - Knob, Focus 2 16 - - - Tubing, Lens 3 17 - - - Retainer, Knob 1 18 - - - Housing, Lamp Changer 1 19 - - - Door, Lamp Changer 1 20 - - - Door, lamp Changer, LED 1 21 - - - Knob, Lamp Changer 1 22 - - - Foot, Base, 9700 2 23 - - - Clamp, Friction 1 24 - - - Rack, Focus 1 25 - - - Button, Power Switch (Red) 1 26 - - - Latch, Top Cover 1 27 - - - Plate, Cord, Small (Gray) 1 28 - - - Block, Post 1 29 - - - Pivot, Cover 4 30 - - - Latch, Folding Post 1 31 - - - Cradle, Post 1

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 18. Small Plast ic Parts Kit (Continued)

(Europe only)

Item

No.

32 - - - Knob, Color Tuning 1 33 - - - Button, Switch (Plum) 2 34 - - - Foot, Support, Side 2 35 - - - Insulator, Hi/Lo Switch 2 36 - - - Cap, End 2 37 - - - Strap, Handle 1 38 - - - Plate, Base, Head 1 39 - - - Handle 1 40 - - - Foot, Isolation 2 41 - - - Foot, Side 2 42 - - - Handle Retainer 1 43 - - - Pivot, Post, Magnifier 1 44 - - - Insulator, Switch, 9700 2 45 - - - Plug, Head 1 46 - - - Bezel, Outlet 1

3M

Part Number

Description Qty.

47 - - - Door, Lamp Changer 1 48 - - - Shield, Exhaust 1 49 - - - Knob, Color Tuning 1 50 - - - Bushing 2 51 - - - Knob, Magnifier 1 52 - - - Pad, Wear 2 53 - - - Cap, Focus Arm, 9000 1 54 - - - Tie Wrap, T 18 R 2 55 - - - Strain Relief 2 56 - - - Insulator, 6.3 2 57 - - - Grommet, Rubber, 0.5 lg = 50mm Schwarz 2

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 19. Kit Fasteners 9000 S er ies (No Picture)

(Europe only)

Item

No.

0 DY-0210-2715-5 Kit Fasteners 9000 Series 1

1 - - - Washer, Plain, Zinc 2

2 - - - Washer, Plain 2

3 - - - Spring, Extension 2

4 - - - Screw, Plastite, 6-19x3/8, Zinc 6

5 - - - Washer, Nylon 2

6 - - - Screw, Machine, M3x8, Bzn 4

7 - - - Screw, Plastite, Bzn (4-20x3/8, 6-19x1/2, and 8- 16x3/8) 4 10 - - - Screw, Taptite, Bzn (8-32x3/8 and 10-32x3/8) 4 12 - - - Nut, Keps, 10-32, Zinc 1

13 - - - Screw, Plastite, 6-19x1, Zinc 1 14 - - - Nut, M3x0.5 1 15 - - - Washer, Nylon 4

3M

Part Number

Description Qty.

Kit Includes:

each each

16 - - - Screw, Taptite, M4x6, Bzn 4 17 - - - Screw, Taptite, M3x6, Zinc 4 18 - - - Screw, Machine, 6-32x3/8 4 19 - - - Ring, Retaining 4 20 - - - Nut, Hex, 1/4-20, Nylon insert, Zinc 4 21 - - - Screw, Plastite, 6-19x3/8, Bzn 4 22 - - - Screw, Taptite, M3.5x6 Torx 4 23 - - - Clip, Speed, Knob to Shaft 4 24 - - - Washer 4 25 - - - Screw, Taptite, M4x16 1 26 - - - Screw, Taptite 4 27 - - - Spring, Compression 2 28 - - - Washer, Spring 2 29 - - - Washer, Plain 2 30 - - - Screw, Taptite, M4x8, Bzn 4 31 - - - Ring, Retaining 2 32 - - - Nut, Keps 2 33 - - - Screw, Taptite, M3.5x0.6x8 4

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 19. Kit Fasteners 9000 S er ies (Continued)

(Europe only)

Item

No.

34 - - - Clip, U-Type 2 35 - - - Screw, Taptite, 4/40x3 4 36 - - - Screw, Taptite, M4x10, Blk 4 37 - - - Screw, Plastite, 8-11x5/8 Lg, 4 38 - - - Screw, Plastite, Hex Head W asher HD 2 39 - - - Washer, Wave 4 40 - - - Nut, U-Type 4 41 - - - Washer, Caplug, Metal 4 42 - - - Screw, Foot 4 43 - - - Screw, Shoulder 4 44 - - - Bolt, Post 4 45 - - - Bolt, Pivot 2 46 - - - Spring, Retaining, Reflector (EVD) 5 47 - - - Spring, Catch 4 48 - - - Screw, End Cap 4

3M

Part Number

Description Qty.

49 - - - Spring, Torsion, Leg 4 50 - - - Screw, Retainer 4 51 - - - Screw, Shoulder, 9000/1700 4 52 - - - Ring, Push-On 1 53 - - - Spring, Lee 2

54 - - - Screw, M4x16, Z 7 1 55 - - - Screw, Tap (Bz 2.9x6.5 and B 3.9x9.5) 1

57 - - - Screw, 5.5x16 1 58 - - - Screw, Varifocal Lens. 4 59 - - - Screw, Lens (M3x16, M4x6, and M4x8) 4

60 - - - Screw, Taptite, M3x8 2 61 - - - Screw, Taptite, M3.5x8 8 62 - - - Screw, Lens, M3x10 1 63 - - - Screw, Taptite, M3x12 4 64 - - - Screw, Taptite, M3.5x6 6 65 - - - Screw, Lens, art., 3x16 4

each

66 - - - Screw, Plastite (3.5x8 and 4.2x12) 4

each

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

Section 19. Kit Fasteners 9000 S er ies (Continued)

(Europe only)

Item

No.

67 - - - Screw, Plastite, 3.5x25, Torx 4 68 - - - Screw, Taptite, M4x25 1 69 - - - Screw, Lower, art. 1 70 - - - Nut, Hex, M3 1 71 - - - Nut, M4 1 72 - - - Washer 1 73 - - - Washer, Lock 4 74 - - - E-Ring 1 75 - - - Ring, Retaining 1 76 - - - Tie Wrap T 18 R 2 77 - - - Strain Relief 2 78 - - - Glider 2 79 - - - Spring, Compression 2 80 - - - Screw, Post, Latch, Spring 4

3M

Part Number

Description Qty.

3M™ Overhead Projector 9000 Series

Appendix A SPECIFICATIONS

Specifications

Model Description

9000 Overhead Projector

Country Power Cord Model Alpha Stock Number Voltage/Hz Agency

Australia Australian 9050 AHAA 78-9236-5681-9 230/50 SAA A4 Open Singlet No Internal Fixed FNT No

Australia Australian 9080 AHDA 78-9236-5667-8 240/50 SAA A4 Open Singlet Yes External Folding FNT No

Australia Australian 9100 AHBA 78-9236-5655-3 240/50 SAA A4 Art Doublet Yes External Folding FNT No

Australia Australian 9200 AHCA 78-9236-5643-9 240/50 SAA A4 Open Triplet Yes External Folding FNT Yes Other

Australia Australian 9550 AHHA 78-9236-5634-8 240/50 SAA A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Brazil United States 9080 AADB 78-9236-5668-6 127/50/60 10.5 Open Singlet Yes External Folding ENX No Resistor

Brazil United States

15’

Chile Italian 9100 AHBC 78-9236-5830-2 230/50 A4 Art Doublet Yes External Folding FNT No Dimmer Switch

Chile Italian 9200 AHCC 78-9236-5828-6 230/50 A4 Open Triplet Yes External Folding FNT Yes

Chile Italian 9550 AHHC 78-9236-5829-4 230/50 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

9550 AAHB 78-9236-6180-1 127/60 None A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Stage Size

Head Type

Lamp Changer

Color Tuning

Post Type

Lamp Type

Handle Lamp Control

Lamps Installed

1

2

1

2

Fresnel Power Fuse Amps

9000 Single Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer 1.7

9550 Dual Element Clear Transformer 2.5

9000 Single Element Glare Free Diode 3

9550 Dual Element Clear Transformer 5A 4.5 Yes

2100 Dual Element Glare Free Transformer 1.7 Yes

2100 Dual Element Glare Free Transformer T4A 1.7 Yes

9550 Dual Element Clear Transformer T4A 2.5 Yes

Cord Storage

9000 Overhead Projector

 3M 2000

Europe Std. European 9050 ABAS 78-9236-5684-3 127/220/50 A4 Open Singlet No Internal Fixed FNT No

Europe Std. European 9050 AHAS 78-9236-5682-7 230/50 European A4 Open Singlet No Internal Fixed FNT No Voltage Switch

Europe Std. European 9080 ABDS 78-9236-5721-3 127/220/50 A4 Open Singlet Yes External Folding FNT No Voltage Switch

Europe Std. European 9080 AHDS 78-9236-5669-4 230/50 European A4 Open Singlet Yes External Folding FNT No

Europe Std. European 9080 AHTS 78-9236-5870-8 230 /50 European A4 Open Singlet Yes External Folding FNT No Voltage Switch

Europe Std. European 9100 ABBS 78-9236-5722-1 127/220/50 A4 Art Doublet Yes External Folding FNT No Voltage Switch

Europe Std. European 9100 AHBS 78-9236-5656-1 230/50 European A4 Art Doublet Yes External Folding FNT No Voltage Switch

Europe Std. European 9200 ABCS 78-9236-5723-9 127/220/50 A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

Europe Std. European 9200 AHCS 78-9236-5644-7 230/50 European A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

Europe Std. European 9200 AHMS 78-9236-5873-2 230/50 European A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

1

2

1

2

9000 Single Element Glare Free Transformer 3

9000 Single Element Glare Free Transformer 1.7

9000 Single Element Glare Free Transformer 3 Yes

9000 Single Element Glare Free Transformer 1.7

9000 Single Element Glare Free Transformer T4A 1.7 Yes

2100 Dual Element Glare Free Transformer 3 Yes

2100 Dual Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer 3 Yes

2100 Dual Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer T4A 1.7 Yes

A–1

3M™ Overhead Projector 9000 Series

Specifications

Model Description

9000 Overhead Projector

AgencyVoltage/HzStock NumberModel AlphaPower CordCountry

Europe Std. European 9550 AHHS 78-9236-5635-5 230/50 European 10.5 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Europe Std. European 9550 AHSS 78-9236-5876-5 230/50 European A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Hong Kong United

Kingdom

Hong Kong United

Kingdom

Hong Kong United

Kingdom

Hong Kong United

Kingdom

Hong Kong United

Kingdom

Europe Std. European 9400 AHRS 78-9236-6272-6 230/50 A4 Open Triplet Yes External Fixed EVD No Dimmer Switch

India Other 9080 AHDG 78-9236-5962-3 230/50 A4 Open Singlet Yes External Folding FNT No

Japan Japan 9050 ABAJ 78-9236-5685-0 100/50/60 MITI A4 Open Singlet No Internal Fixed FNT No

Japan Japan 9080 ABDJ 78-9236-5671-0 100/50/60 MITI A4 Open Singlet Yes External Folding FNT No

Japan Other–Two

Blade 15’

Japan Japan 9100 ABBJ 78-9236-5658-7 100/50/60 MITI A4 Art Doublet Yes External Folding FNT No

Japan Japan 9200 ABCJ 78-9236-5646-2 100/50/60 MITI A4 Open Triplet Yes External Folding FNT Yes

Japan Japan 9550 ABHJ 78-9236-5705-6 100/50/60 MITI A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

9050 AHAH 78-9236-5683-5 220/50 A4 Open Singlet No Internal Fixed FNT No

9080 AHDH 78-9236-5670-2 220/50 A4 Open Singlet Yes External Folding FNT No

9100 AHBH 78-9236-5657-9 220/50 A4 Art Doublet Yes External Folding FNT No

9200 AHCH 78-9236-5645-4 220/50 A4 Open Triplet Yes External Folding FNT Yes

9550 AHHH 78-9236-5636-3 220/50 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

9080 ABDB 78-9236-6165-2 120/220/60 None 10.5 Open Singlet Yes External Folding ENX No Voltage Switch

Stage Size

Head Type

Lamp Changer

Color Tuning

Post Type

Lamp Type

Lamp ControlHandle

Lamps Installed

2

1

2

1

2

AmpsFusePowerFresnel

9550 Dual Element Glare Free Transformer T4A 2.5

9550 Dual Element Glare Free Transformer 1.7 Yes

9000 Single Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer 1.7

9550 Dual Element Clear Transformer 2.5

9400 Dual Element Glare Free Transformer T5A 2.5 No

9000 Single Element Glare Free Transformer T4A 1.7 Yes

9000 Single Element Glare Free Transformer

9000 Single Element Glare Free Transformer 5A 4.5 No

2100 Dual Element Glare Free Transformer

9550 Dual Element Glare Free Transformer Yes

Cord Storage

9000 Overhead Projector

 3M 2000

Korea European 9550 AHHK 78-9236-5810-4 220/60 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Mexico United States

10’

Mexico United States

15’

Mexico United States

15’

Mexico United States

15’

New Zealand Australian 9050 AHAN 78-9236-5686-8 230/50 A4 Open Singlet No Internal Fixed FNT No

9050 AAAM 78-9236-6177-7 127/60 None 10.5 Open Singlet No None Fixed ENX No Dimmer Switch

9100 AABM 78-9236-6178-5 127/60 None 10.5 Art Doublet Yes External Folding ENX No Voltage Switch

9200 AACM 78-9236-6179-3 127/60 None 10.5 Open Triplet Yes External Folding FXL Yes Voltage Switch

9550 AHHM 78-9236-5637-1 127/50/60 None A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

2

1

2

1

9550 Dual Element Clear Transformer T5A 2.5 Yes

9000 Single Element Glare Free Line, Diode None 4.5 No

9000 Single Element Glare Free Line, Diode None 4.5 Yes

9550 Dual Element Clear Transformer 5A 4.5 Yes

9000 Single Element Glare Free Transformer 1.7

A–2

3M™ Overhead Projector 9000 Series

Specifications

Model Description

9000 Overhead Projector

AgencyVoltage/HzStock NumberModel AlphaPower CordCountry

New Zealand Australian 9080 AHDN 78-9236-5672-8 240/50 A4 Open Singlet Yes External Folding FNT No

New Zealand Australian 9100 AHBN 78-9236-5659-5 240/50 A4 Art Doublet Yes External Folding FNT No

New Zealand Australian 9200 AHCN 78-9236-5647-0 240/50 A4 Yes External Folding FNT Yes

New Zealand Australian 9550 AHHN 78-9236-5638-9 240/50 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Philippines United States 9050 ARAP 78-9236-5687-6 240/60 A4 Open Singlet No Internal Fixed FNT No

Philippines United States 9080 ARDP 78-9236-5673-6 240/60 A4 Open Singlet Yes External Folding FNT No

Philippines United States 9100 ARBP 78-9236-5660-3 240/60 A4 Art Doublet Yes External Folding FNT No

Philippines United States 9200 ARCP 78-9236-5648-8 240/60 A4 Open Triplet Yes External Folding FNT Yes

Philippines Other–Two

Blade 15’

9550 ARHP 78-9236-5639-7 240/60 None A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Stage Size

Head Type

Lamp Changer

Color Tuning

Post Type

Lamp Type

Lamp ControlHandle

Lamps Installed

1

2

1

2

AmpsFusePowerFresnel

9000 Single Element Glare Free Transformer 3

2100 Dual Element Glare Free Transformer 1.7

9550 Dual Element Clear Transformer 2.5

9000 Single Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer 1.7

9550 Dual Element Clear Transformer 5A 2.5 Yes

Cord Storage

9000 Overhead Projector

Saudi Arabia United States 9050 AAAD 78-9236-5689-2 127/60 10.5 Open Singlet No Internal Fixed ENX No Resistor

Saudi Arabia European 9050 AHAD 78-9236-5694-2 230/50 A4 Open Singlet No Internal Fixed FNT No

Saudi Arabia European 9080 AHDD 78-9236-5680-1 230/50 A4 Open Singlet Yes External Folding FNT No

Saudi Arabia United States 9080 AADD 78-9236-5675-1 127/60 10.5 Open Singlet Yes External Folding ENX No Resistor

Saudi Arabia United States 9100 AABD 78-9236-5662-9 127/60 10.5 Art Doublet Yes External Folding ENX No Dimmer Switch

Saudi Arabia United States 9200 AACD 78-9236-5650-4 127/60 10.5 Open Triplet Yes External Folding FXL Yes Dimmer Switch

Saudi Arabia United States 9550 AAHD 78-9236-5725-4 127/60 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

South Africa South Africa 9050 AHAR 78-9236-5688-4 240/50 SABS A4 Open Singlet No Internal Fixed FNT No

South Africa South Africa 9080 AHDR 78-9236-5674-4 240/50 SABS A4 Open Singlet Yes External Folding FNT No

South Africa South Africa 9100 AHBR 78-9236-5661-1 240/50 A4 Art Doublet Yes External Folding FNT No

South Africa South Africa 9200 AHCR 78-9236-5649-6 240/50 A4 Open Triplet Yes External Folding FNT Yes

South Africa South Africa 9550 AHHR 78-9236-5640-5 240/50 SABS 10.5 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

1

2

1

2

9000 Single Element Glare Free Diode 4.5

9000 Single Element Glare Free Transformer 1.7

9000 Single Element Glare Free Diode 4.5

9550 Dual Element Clear Transformer 4.5 Yes

9000 Single Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer 1.7

9550 Dual Element Clear Transformer 2.5

 3M 2000

A–3

3M™ Overhead Projector 9000 Series

Specifications

Model Description

9000 Overhead Projector

AgencyVoltage/HzStock NumberModel AlphaPower CordCountry

Switzerland Swiss 9050 AHAZ 78-9236-5690-0 230/50 SEV A4 Open Singlet No Internal Fixed FNT No Voltage Switch

Switzerland Swiss 9080 AHDZ 78-9236-5676-9 230/50 SEV A4 Open Singlet Yes External Folding FNT No Voltage Switch

Switzerland Swiss 9080 AHTZ 78-9236-5872-4 220/50 SEV A4 Open Singlet Yes External Folding FNT No Voltage Switch

Switzerland Swiss 9100 AHBZ 78-9236-5663-7 230/50 SEV A4 Art Doublet Yes External Folding FNT No Voltage Switch

Switzerland Swiss 9200 AHCZ 78-9236-5651-2 230/50 SEV A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

Switzerland Swiss 9200 AHMZ 78-9236-5875-7 230/50 SEV A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

Switzerland Swiss 9550 AHHZ 78-9236-5724-7 230/50 SEV A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Switzerland Swiss 9550 AHSZ 78-9236-5878-1 230/50 SEV A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Switzerland Swiss 9400 AHRZ 78-9236-6274-2 230/50 SEV A4 Open Triplet Yes External Fixed EVD No Dimmer Switch

Taiwan Japan 9050 AAAT 78-9236-5691-8 120/60 A4 Open Singlet No Internal Fixed FNT No

Taiwan Japan 9080 AADT 78-9236-5677-7 120/60 A4 Open Singlet Yes External Folding FNT No

Taiwan Japan 9100 AABT 78-9236-5664-5 120/60 A4 Art Doublet Yes External Folding FNT No

Taiwan Japan 9200 AACT 78-9236-5652-0 120/60 A4 Open Triplet Yes External Folding FNT Yes

Taiwan Japan 9550 AAHT 78-9236-6022-5 120/60 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Thailand European 9050 AHAF 78-9236-5834-4 220/50 A4 Open Singlet No Internal Fixed FNT No

Thailand European 9080 AHDF 78-9236-5835-1 220/50 A4 Open Singlet Yes External Folding FNT No Dimmer Switch

Thailand European 9100 AHBF 78-9236-5836-9 220/50 A4 Art Doublet Yes External Folding FNT No Dimmer Switch

Thailand European 9200 AHCF 78-9236-5837-7 220/50 A4 Open Triplet Yes External Folding FNT Yes Dimmer Switch

Thailand European 9550 AHHF 78-9236-5833-6 220/50 A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Stage Size

Head Type

Lamp Changer

Color Tuning

Post Type

Lamp Type

Lamp ControlHandle

Lamps Installed

1

2

1

2

1

2

AmpsFusePowerFresnel

9000 Single Element Glare Free Transformer 1.7

9000 Single Element Glare Free Transformer T4A 1.7 Yes

2100 Dual Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer T4A 1.7 Yes

9550 Dual Element Glare Free Transformer 2.5 Yes

9550 Dual Element Glare Free Transformer T4A 1.7 Yes

9400 Dual Element Glare Free Transformer T5A 2.5 No

9000 Single Element Glare Free Transformer 3

2100 Dual Element Glare Free Transformer 3

9550 Dual Element Clear Transformer 4.5 No

9000 Single Element Glare Free Transformer T4A 1.7 No

9000 Single Element Glare Free Transformer T4A 1.7 Yes

2100 Dual Element Glare Free Transformer T4A 1.7 Yes

9550 Dual Element Clear Transformer T4A 2.5 Yes

Cord Storage

9000 Overhead Projector

 3M 2000

United Kingdom

9050 AHAU 78-9236-5692-6 240/50 European A4 Open Singlet No Internal Fixed FNT No

9080 AHDU 78-9236-5678-5 240/50 European A4 Open Singlet Yes External Folding FNT No

9080 AHTU 78-9236-5871-6 240/50 European A4 Open Singlet Yes External Folding FNT No Voltage Switch

9100 AHBU 78-9236-5665-2 240/50 European A4 Art Doublet Yes External Folding FNT No

1

2

9000 Single Element Glare Free Transformer 1.7

9000 Single Element Glare Free Transformer T4A 1.7 Yes

2100 Dual Element Glare Free Transformer 1.7

A–4

3M™ Overhead Projector 9000 Series

Specifications

Model Description

9000 Overhead Projector

AgencyVoltage/HzStock NumberModel AlphaPower CordCountry

United Kingdom

United States United States 9050 AJA 78-9236-5693-4 120/60 UL/CSA 10.5 Open Singlet No Internal Fixed ENX No Resistor

United States United States 9060 AJE 78-9236-5695-9 120/60 UL/CSA 10.5 Art Doublet Yes Internal Fixed ENX No Resistor

United States United States 9070 AJF 78-9236-5696-7 120/60 UL/CSA 10.5 Closed Singlet No Internal Fixed ENX No Resistor

United States United States 9080 AJD 78-9236-5679-3 120/60 UL/CSA 10.5 Closed Singlet Yes External Folding ENX No Resistor

United States United States 9100 AJB 78-9236-5666-0 120/60 UL/CSA 10.5 Art Doublet Yes External Folding ENX No Dimmer Switch

United States United States 9100 AJBX 78-9236-6049-8 120/60 UL/CSA 10.5 Art Doublet Yes External Folding ENX No Dimmer Switch

United States United States 9200 AJC 78-9236-5654-6 120/60 UL/CSA 10.5 Open Triplet Yes External Folding FXL Yes Dimmer Switch

United States/Canada

United States United States

United Kingdom

United States 15’

15’

9200 AHCU 78-9236-5653-8 240/50 European A4 Open Triplet Yes External Folding FNT Yes

9200 AHMU 78-9236-5874-0 240/50 European A4 Open Triplet Yes External Folding FNT Yes Voltage Switch

9550 AHHU 78-9236-5641-3 240/50 European A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

9550 AHSU 78-9236-5877-3 240/50 European A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

9400 AHRU 78-9236-6273-4 240/50 European A4 Open Triplet Yes External Fixed EVD No Dimmer Switch

9075 AJG 78-9236-6164-2 120/60 UL/CSA 10.5 Closed Singlet No Internal Fixed ENX No Voltage Switch

9200 BGC 78-9236-6187-6 120/60 UL 10.5 Closed Singlet Yes External Folding FXL Yes Dimmer Switch

9550 AJH 78-9236-5642-1 120/60 UL/CSA A4 Varifocal Yes Internal Folding EVD Yes Dimmer Switch

Stage Size

Head Type

Lamp Changer

Color Tuning

Post Type

Lamp Type

Lamp ControlHandle

Lamps Installed

2

1

2

1

2

AmpsFusePowerFresnel

2100 Dual Element Glare Free Transformer 1.7

2100 Dual Element Glare Free Transformer T4A 1.7 Yes

9550 Dual Element Glare Free Transformer 2.5

9550 Dual Element Glare Free Transformer T4A 1.7 Yes

9400 Dual Element Glare Free Transformer T5A 2.5 No

9000 Single Element Glare Free Diode 4.5

9000 Single Element Glare Free Diode None 4.5 Ye s

9000 Single Element Glare Free Diode 4.5

9000 Dual Element Clear Diode None 4.5 No

9000 Single Element Glare Free Line Diode None 4.5 Yes

9550 Dual Element Clear Transformer None 4.5 Yes

Cord Storage

 3M 2000

A–5

3M™ Overhead Projector 9000 Series Illustrated Parts Breakdown

p

m

http://www.mmm.com/presentations

http://www.3M.com/meetings

e-m ail:

Important Notice

All statements, technical information, and recommendations related to 3M’s products are based on information believed to be reliable, but the accuracy or completen ess is not guaranteed. Before u s i ng this product, you must evaluate it and determine if it is suitable for your intended application. You assume all risks and liability associated with such use. Any statements related to the product which are not contained in 3M’s current publications, or any contrary statements contained on your purchase order shall have no force or effect unless expressly set forth in a written agreement signed by an authorized officer of 3M.

resentations@mmm.co

Xerox 9050, 9200, 9040, 9060, 9100 User Manual

Specifications and Main Features

Frequently Asked Questions

User Manual