Xerox 518 User Manual

XEROX Material Safety Data Sheet MSDS No: A-2006A

Date: 8/14/85
Revision: 1/12/07

Supplier:

Section I - Product Identification
Trade Names/Synonyms: ECP- Magenta Toner Premix/Concentrate for ECP 42 Part No.: 4813-32* 26R351

4813-2* 26R237
Chemical Name: None 4813-1-1* 26R30
4813-16* 26R30-01
WHMIS Status: Class B/Div. 3, Combustible liquid and Class D/Div. 2B, Toxic 4813-16-6* 26R236
4813-32-6* 26R238

Isoparaffinic hydrocarbon solvent (80-100%) 64742-48-9
Polymer (<2%) Trade Secret
Pigment (<2%) Trade Secret

Primary Route of Entry: Symptoms of Overexposure:

Inhalation High vapor concentrations (>1000 ppm) are irritating to
Eyes: the eyes and respiratory tract, and may cause headaches,
Flush with water for 15 minutes. If irritation persist, call a physician. dizziness anesthesia, drowsiness, unconsciousness, and
Skin: other central nervous system effects, including fatality.
Wash with soap and water. If skin is broken, call a physician.
Inhalation: Medical Conditions Generally Aggravated by Exposure:
Remove from exposure. Skin contact may aggravate an existing dermatitis.
Ingestion:
DO NOT induce vomiting, call a physician immediately. Additional Information:
None.

Section III - Toxicology and Health Information

This material has been evaluated by Xerox Corporation. The toxicity data noted below is for isoparaffinic hydrocarbons and similar

nks. i

Oral LD
Dermal LD
Inhalation LC
Eye Irritation: May cause irritation. Ceiling: N.E.
Skin Sensitization: Not a sensitizer. XEL4: 200 ppm (isoparaffinic
Skin Irritation: Not an irritant. hydrocarbon solvent)
Human Patch: Non-sensitizing. May cause irritation and dermatitis with prolonged or repeated contact.
Mutagenicity: No mutagenicity detected in Ames, Pol A+/A-, WP

Exchange, Dominant Lethal and Micronucleus Assays.

Carcinogens: None present
Aquatic LC

Additional Information:

• Isoparaffinic hydrocarbon solvent has a low order of acute oral and dermal toxicity, but minute amounts aspirated into the lungs

during ingestion or vomiting may cause mild to severe pulmonary injury, includ ing fatality.

• Rat inhalation at 900 ppm not fetotoxic or teratogenic.

1

The product does not contain a toxic chemical(s) subject to the reporting requirements of Section 313 of Title III of the Superfund Amendm ents and Reauthorization

Act of 1986 and 40CFR Part 372. Its ingredients do not appear on the California Proposition 65 List.
Canadian Domestic Substances List (DSL)

respective trade secret numbers: Massachusetts, 99-125-002 or -010; New Jersey, 800814- 5000, 800814-5005, 800814-5006; and New York, 206 or 210. They are not
considered Hazardous as defined by WHMIS and a Trade Secret Exemption is not required for Canada.

N.A. - Not Applicable N.E. -None Established N.D. -Not Determined 600E30170

Xerox Corporation Xerox Canada Ltd. Telephone # (s): Safety Information: [phone]
Rochester, NY 14644 5650 Yonge Street Health Emergency: [phone]

North York, Ontario M2M 4G7 Transportation Emergency (Chemtrec): [phone]

Ingredients (% by wt.)

1,2

CAS No.

3
3

Section II - Emergency and First Aid

: >10 g/kg (rat) practically non-toxic. TLV: N.E.

50

: >3.2 g/kg (rabbit) practically non-toxic. PEL: N.E.

50

: >2000 ppm/4 hr (rat); >1800 ppm/6 hr (monkey) practically non-toxic. STEL: N.E.

50

, Mouse Lymphoma, In Vitro Sister Chromatid

2

: None available

50

2

3

These ingredients are claimed as a trade secret by a Xerox supplier. They are registered in the following states under the

All ingredients contained within this product are listed on the

4

XEL-Xerox Exposure Limit.

*Cancelled

XEROX Trade Name: ECP-Magenta Toner Premix/Concentrate for ECP 42 MSDS No.: A-2006A

Section IV - Physical Data

Appearance/Odor: Magenta liquid /slight odor Softening Range: N.A.
Boiling Point: 160 -180

o

C Melting Point: N.A.

Solubility in Water: Immiscible Specific Gravity (H2O=1): 0.77
Evaporation Rate: 0.3, (n-Butylacetate = 1) Vapor Pressure @20oC (mm Hg): 1
Vapor Density (Air=1): 5.0 pH: N.A.
Volatile: ~100% (Wt.) N.A. % (Vol.) Vola tile Organics: 660- 730 g/l

Section V - Fire and Explosion Data
Flash Point (Method Used): 102o-107oF (39-42oC) T.C.C.

Flammable Limits LEL: 0.8%, UEL: 7.0%
NFPA 704: Health - 1, Fire - 2, Reactivity - 1
Extinguishing Media: Foam, dry chemical, CO

, water fog.

2

Special Fire Fighting Procedures: Use air-supplied breathing equipment for enclosed areas. Cool exposed containers with water
spray. Avoid breathing vapor or fumes.
Fire and Explosion Hazards: Do not mix or store with strong oxidants like liquid chlorine or concentrated oxygen.

Section VI -Reactivity Data

Stability: Stable
Hazardous Polymerization: Will Not Occur
Hazardous Decomposition Products: Fumes, smoke and carbon monoxide in the case of incomplete combustion.
Incompatibility (Materials to Avoid): Strong oxidants such as liquid chlorine, concentrated oxygen, sodium/calcium hypochlorite.

Section VII - Special Protection Information
Respiratory Protection: None when used as intended with Xerox Engineering Systems products.

Eye Protection: None when used as intended with Xerox Engineering Systems products.
Protective Gloves: Neoprene or nitrile gloves for prolonged or repeated skin contact.
Other: None when used as intended with Xerox Engineering Systems products.

Section VIII - Special Precautions
Handling and Storage: Keep container closed. Avoid handling near heat, strong light, sparks, oxygen flames, strong oxidants.

Conditions to Avoid: Avoid breathing vapors. Avoid prolonged or repeated skin contact.

Section IX- Spill, Leak, and Disposal Procedures
For Spills or Leakage: Remove ignition sources. Recover free liquid using an absorbent material (vermiculite, fire

retardant, sawdust, etc.).
Waste Disposal Method: The waste toner may be classified as an ignitable hazardous waste under federal and/or state
regulations and should be disposed at an approved disposal site or facility in accordance with federal,
state, and local regulations.

Section X - Transportation Information

D.O.T Combustible liquid, n.o.s. Combustible NA 1993 III Reclassification: 49CFR 173.150 (f) (2) *
(Isoparaffinic hydrocarbon) liquid

I.A.T.A Flammable liquid, n.o.s.
(Isoparaffinic hydrocarbon)

I.M.O Flammable liquid, n.o.s.
(Isoparaffinic hydrocarbon)

*Note: This product has been reclassified as a combustible liquid under DOT when shipped domestically by land only. This product is not regulated by DOT when
shipped in non-bulk quantities of less than 119 gallons. This product is exempt from the Canadian Transportation of Dangerous Goods regulations (section 1.33), when
transported in containers less than 450 liters and not by air.

Proper Shipping Name Hazard Class ID # Packing Group Exceptions may apply

3 UN 1993 III Y309.
3 UN 1993 III 3.4 Limited Quantities

600E30170