Wells PC-1M Service Manual

WELLS MANUFACTURING COMPANY

2 Erik Circle: P.O. Box 280Verdi, NV 89439

(702) 345-0444 FAX # (702) 345-0569

PC-1M PASTA RETHERMALI2ER

20Qv, 2200W, 10.6A

Installation and Operating Instructions

Plug power cord into appropriate receptacle (type L6-20P ). Check nameplate for correct voltage.

2. Connect flexible water supply hose to fitting on left side of unit (minimum 20 psi and .5 gpm water supply required).

3. Close drain valve on left side of unit,

4. Place basket support rack in bottom of pan.

5. Close hinged cover.

6. Turn power switch to ON position. The red indicator light will come on. The fill spout will automatically fill unit with water to the correct operating level. This takes approximately 5 minutes.

•

7. Allow the Pasta Rethermalizer to preheat for 30 minutes. The white thermostat indicator light will cycle off when water is at correct operating temperature.

8. Load one to three baskets with pasta and place in preheated water. Press timer switch to energize cook cycle. Yellow timer light will flash during cook cycle. Alarm will sound at end of cook cycle. Press timer switch to end cook cycle alarm. Remove pasta baskets from water.

9. water level will be automatically maintained while unit is turned on.

EPC09/25/9132002-IIPC-1M Rev. A

MANUFACTURERS OF COMMERCIAL COOKING EOUIPMENT

Use breakfast cart to transport

Use necessary precautions, such as gloves, to handle hot rethermalizer, or

proportioner, and a warm solution of McD Sanitizer, wash and sanitize the

water pan

top and cover assembly

Make sure the water sensing probe on the

DAILY CLEANING PROCEDURES

PC-1M Pasta Rethermalizer

Place the power switch in the "OFF" position.

Unplug the rethermalizer. Disconnect water supply hose.

Open drain valve and drain water into appropriate container using attached hose.

CAUTION: Equipment and water are hot.

the rethermalizer to sink area.

let it cool before handling.

Remove the portion baskets and basket support rack.

Using a hot solution of McD All Purpose Concentrate (APC) from the sink

side of the water pan and drain system are thoroughly cleaned.

Wash and sanitize portion baskets and basket support rack. Set aside to air dry overnight.

CAUTION: Do not immerse rethermalizer in water. Damage will occur if unit is submerged.

Store rethermalizer in designated area.

CHECK CALIBRATION AND DE-LIME WATER PAN MONTHLY. MORE FREQUENT DE- LIMING MAY BE NECESSARY IF WATER SUPPLY HAS HIGH MINERAL CONTENT.

9/91 :slc

+ 3 hidden pages