Weber 52020001 Owner's Manual

ELECTRIC GRILL OWNER’S GUIDE

You must read this Owner’s Guide before operating your electric grill.

MANUAL DEL USUARIO - Pg 13 ENSAMBLAJE - Pg 7

MANUEL UTILISATEUR DU GRILL ELECTRIQUE - Pg 21 ASSEMBLAGE - Pg 7

WARNING!

POTENTIAL SHOCK

HAZARD

This appliance is Rated for

120 volts - 50/60 Hz

Output: 1500 W

Use only Weber Q140TC temperature-

controlling plug.

m This grill is intended for outdoor

household use only. Do not use indoors or for commercial cooking. Fuel, such as charcoal briquettes, is not to be used with appliance.

m The supply cord should be regularly

PLACE STICKER HERE

examined for signs of damage and the appliance is not to be used if the cord is damaged.

IMPORTANT SAFEGUARDS

When using electrical appliances, basic safety precautions

should always be followed including the following:

m Read all instructions. m CAUTION: Grill brushes should be checked for loose

bristles and excessive wear on a regular basis. Replace brush if any loose bristles are found on cooking grates or brush. Weber recommends purchasing a new stainless steel grill brush at the beginning of every spring.

m CAUTION: To ensure continued protection against risk of

electric shock, connect to properly grounded three prong GFI outlets only. Do not use a two prong adapter.

m WARNING: Use only outdoors, do not expose to rain.

This is to prevent electric shock which can cause serious bodily injury or death.

m WARNING: Disconnect appliance from supply circuit

before performing maintenance and cleaning.

m WARNING: For protection against risk of electric shock,

connect to properly grounded outlets only.

m WARNING: For protection against risk of electric shock,

keep extension cord connection dry and off the ground.

m CAUTION: Store Temperature Controller indoors when not

in use.

m Do not place on or near a hot gas or electric burner, or in

a heated oven.

m Use extreme caution when removing tray or disposing of

hot grease.

m Do not clean with metal scouring pads. Pieces can break

off the pad and touch electrical parts, creating a risk of electric shock.

m Do not use charcoal in this appliance.

SAVE THESE INSTRUCTIONS

m Do not touch surfaces that may be hot. Use handles or

knobs provided.

m To protect against electrical shock do not immerse cord,

plugs, portable appliances (or other specific part or parts) in water or other liquid.

m Close supervision is necessary when any appliance is

used by or near children.

m Make sure appliance is OFF and remove plug from outlet

when not in use, before putting on or taking off parts, and before cleaning. Allow to cool before handling.

m Do not operate any appliance with a damaged cord or

plug or after the appliance malfunctions or is dropped or damaged in any manner. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com

m The use of accessories not recommended by Weber may

cause damage or injuries.

m Do not let cord hang over edge of table or counter or

touch hot surfaces.

m Where applicable, always attach plug to appliance and

check that the control is OFF before plugging cord into wall outlet. To disconnect, turn the control to OFF, then remove plug from wall outlet.

m Do not use appliance for other than intended use. m Avoid contacting moving parts.

57504

US - ENGLISH

07/01/13

IMPORTANT SAFEGUARDS

m DANGER

Failure to follow the Dangers, Warnings and Cautions contained in this Owner's Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

m WARNINGS m WARNING: Do not use charcoal or

other combustible fuels in this grill. This grill is not designed for charcoal use and a fire could result. The fire could create an unsafe condition and damage to the grill.

m Always plug Temperature Controller

into grill before plugging power cord into outlet.

m Do not operate unit if plug receptacle

is damaged.

m Operate grill only on a level, stable

surface.

m Do not in any way alter this product or

its use.

m If using an extension cord it must

be rated no less than that of the appliance. Extension cords must be marked with the letter “W” and with a tag stating, “Suitable for use with outdoor appliance”.

m Use shortest length extension cord

possible. Do not connect 2 or more extension cords together.

m Do not immerse grill or Temperature

Controller in water when cleaning.

m Do not leave Temperature Controller

in the ON position during periods of non-use.

m Do not leave grill unattended when

inuse.

m Keep children and pets away from grill

when in use.

m Young children should be supervised

to ensure that they do not play with the appliance.

m This appliance is not intended for use

by young children or infirm persons unless they have been adequately supervised by a responsible person to ensure that they can use the appliance safely.

m Clean grease catch pan regularly. m Locate power cord away from traffic

areas. Arrange the cord so that it will not be pulled or tripped over.

m Do not use grill near combustible

materials such as dry grass, shrubs, etc.

m Do not allow grill to come into close

contact with flammable materials such as paper, walls, draperies, towels, chemicals, etc.

m Do not use as a heater. m Do not move the grill while it is in use.

Allow the appliance to cool before moving, cleaning or storing it.

m Do not use grill when raining or

snowing.

m To prevent grill from being splashed

or falling into water, do not use grill within 10 feet of any body of water such as a pool or pond.

m Do not operate grill with a

Temperature Controller that has a damaged cord or plug. Call Weber for a replacement Temperature Controller. The Temperature Controller is made specifically for this grill.

m Pulling Temperature Controller by the

knob could cause the knob to come off. Remove Temperature Controller by gripping on it’s side (Refer to “MAINTENANCE”).

m Do not allow cord to touch the grill

when it is hot.

m This grill is intended for outdoor

household use only. Do not use indoors or for commercial cooking.

m If a flare up occurs, do not use water

to put out fire. Turn grill to OFF. Unplug power cord and wait for grill to cool.

m Make sure no other high wattage

appliances are plugged into the same circuit when using grill.

m Do not clean this product with a water

spray or the like.

m Unplug grill when not in use and

cover when cool. Properly store the appliance indoors when not in use out of the reach of children.

m Use this grill only as described

in this manual. Any other use not recommended in this manual may cause fire, electric shock, or injury to persons.

m Always ensure that electrical socket

being used has the correct rating. Socket must be rated no less than 120V AC.

m This appliance conforms to technical

standards and the safety requirements for electrical devices.

m The grease catch pan must be in place

at all times during grill operation.

m Do not build this model of grill in

any built-in or slide-in construction. Ignoring this warning could cause a fire or an explosion that may damage property or cause serious bodily injury or death.

WARRANTY

Thank you for purchasing a WEBER® product. Weber-Stephen Products LLC (“Weber”) prides itself on delivering a safe, durable and reliable product.

This is Weber’s Limited Warranty provided to you at no extra charge. It contains the information you will need to have your WEBER

product repaired in

the unlikely event of a failure or defect.

WEBER’S RESPONSIBILITIES

Weber provides, to the original purchaser of the WEBER® product (or in the case of a gift or promotional situation, the person for whom it was purchased as a gift or promotional item), that the WEBER® product is free from defects in material and workmanship for the period(s) of time specified below when assembled and operated in accordance with the accompanying Owner’s Guide. (Note: If you lose or misplace your WEBER® Owner’s Guide, a replacement is available online at www.weber.com). Under normal, private single family home or apartment use and maintenance, Weber agrees to repair or replace defective parts within the applicable time periods, limitations and exclusions listed below. THIS LIMITED WARRANTY IS EXTENDED ONLY TO THE ORIGINAL PURCHASER AND IS NOT TRANSFERABLE TO SUBSEQUENT OWNERS, EXCEPT IN THE CASE OF GIFTS AND PROMOTIONAL ITEMS AS NOTED ABOVE.

OWNER’S RESPONSIBILITIES

To ensure trouble-free warranty coverage, it is important that you register your WEBER® product online at www.weber.com or via Weber Customer Service at 1-800-446-1071. Please also retain your original sales receipt and/or invoice. Registering your WEBER® product confirms your warranty coverage and provides a direct link between you and Weber in case we need to contact you.

The Owner must take reasonable care of the WEBER® product and follow all assembly instructions, usage instructions and preventative maintenance as outlined in the accompanying Owner’s Guide. If you live in a coastal area, or have your product located near a pool, maintenance includes regular washing and rinsing of the exterior surfaces as outlined in the accompanying Owner’s Guide. If you believe that you have a part that is covered by this Limited Warranty, please contact Weber Customer Service at 1-800-446-1071 or support@weberstephen.com. Weber will, upon investigation, repair or replace (at its option) a defective part covered by this Limited Warranty. In the event that repair or replacement are not possible, Weber may chose (at its option) to replace the grill in question with a new grill of equal or greater value. Weber may ask you to return parts for inspection, shipping charges to be pre-paid.

This LIMITED WARRANTY does not cover damage, deterioration, discoloration and/or rust caused by:

• Abuse, misuse, alteration, modification, misapplication, vandalism, neglect, improper assembly or installation, and failure to properly perform normal and routine maintenance;

• Insects (such as spiders) and rodents (such as squirrels), including but not limited to damage to burner tubes and/or gas hoses;

• Exposure to salt air and/or chlorine sources such as swimming pools and hot tubs/spas;

• Severe weather conditions such as hail, hurricanes, earthquakes, tsunamis or surges, tornadoes or severe storms.

The use and/or installation of parts on your WEBER® product that are not genuine Weber parts will void this Limited Warranty, and any damages that result are not covered by this Limited Warranty. Any conversion of a gas grill not authorized by Weber and performed by a Weber authorized service technician will void this Limited Warranty.

PRODUCT WARRANTY PERIODS

Cookbox: 5 years, no rust through/burn through

(2 years paint excluding fading or discoloration)

Lid assembly: 5 years, no rust through/burn through

Stainless steel burner tubes: 5 years, no rust through/burn through

Porcelain-enameled cast iron cooking grates: 5 years, no rust through/burn through

Plastic components: 5 years, excluding fading or discoloration

All remaining parts: 2 years

DISCLAIMERS

WEBER MAKES NO IMPLIED WARRANTIES INCLUDING WITHOUT LIMITATION ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, OTHER THAN WHAT IS EXPRESSLY MADE IN THIS LIMITED WARRANTY. NO WARRANTIES SHALL APPLY AFTER THE APPLICABLE PERIODS OF THIS LIMITED WARRANTY. NO OTHER WARRANTIES GIVEN BY ANY PERSON OR ENTITY, INCLUDING A DEALER OR RETAILER WITH RESPECT TO ANY PRODUCT (SUCH AS ANY “EXTENDED WARRANTIES”), SHALL BIND WEBER. THE EXCLUSIVE REMEDY OF THIS LIMITED WARRANTY IS REPAIR OR REPLACEMENT OF THE PART OR PRODUCT. THE TERMS OF THIS LIMITED WARRANTY PROVIDE THE SOLE AND EXCLUSIVE REMEDY ARISING FROM THE SALE OF THE PRODUCTS COVERED HEREBY. WEBER SHALL NOT BE LIABLE FOR ANY SPECIAL, INDIRECT, INCIDENTAL OR CONSEQUENTIAL LOSS OR DAMAGES. SOME JURISDICTIONS DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, OR LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS, SO THE ABOVE EXCLUSIONS OR LIMITATIONS MAY NOT APPLY TO YOU.

IN NO EVENT SHALL RECOVERY OF ANY KIND BE GREATER THAN THE AMOUNT OF THE PURCHASE PRICE OF THE WEBER PRODUCT SOLD.

YOU ASSUME THE RISK AND LIABILITY FOR LOSS, DAMAGE, OR INJURY TO YOU AND YOUR PROPERTY AND/ OR TO OTHERS AND THEIR PROPERTY ARISING OUT OF THE MISUSE OR ABUSE OF THE PRODUCT OR FAILURE TO FOLLOW INSTRUCTIONS PROVIDED BY WEBER IN THE ACCOMPANYING OWNER’S GUIDE.

THIS LIMITED WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS, AND YOU MAY ALSO HAVE OTHER RIGHTS THAT VARY IN DIFFERENT JURISDICTIONS.

PARTS AND ACCESSORIES REPLACED UNDER THIS LIMITED WARRANTY ARE WARRANTED ONLY FOR THE BALANCE OF THE ORIGINAL WARRANTY PERIOD(S).

THIS LIMITED WARRANTY APPLIES TO PRIVATE SINGLE FAMILY HOME OR APARTMENT USE ONLY AND DOES NOT APPLY TO WEBER GRILLS USED IN COMMERCIAL, COMMUNAL OR MULTI-UNIT SETTINGS SUCH AS RESTAURANTS, HOTELS, RESORTS OR RENTAL PROPERTIES.

WEBER MAY FROM TIME TO TIME CHANGE THE DESIGN OF ITS PRODUCTS. NOTHING CONTAINED IN THIS LIMITED WARRANTY SHALL BE CONSTRUED AS OBLIGATING WEBER TO INCORPORATE SUCH DESIGN CHANGES INTO PREVIOUSLY MANUFACTURED PRODUCTS, NOR SHALL SUCH CHANGES BE CONSTRUED AS AN ADMISSION THAT PREVIOUS DESIGNS WERE DEFECTIVE.

(2 years paint excluding fading or discoloration)

WEBER-STEPHEN PRODUCTS LLC Customer Service Center 90 West Hillcrest Boulevard, Suite 308 Schaumburg, IL 60195 USA

The grills illustrated in this Owner’s Guide may vary slightly from the model purchased.

www.weber.com

EXPLODED VIEW, VISION ÉCLATÉE, DIAGRAMA DE DESPIECE - 1400

Q1400_ELECTRIC_US_061013

1. Lid

Tapa Couvercle

2. Handle Spacer

Espaciador del asa Ecarteur de poignée

3. Handle

Asa Poignée

4. Cooking Grate

Rejilla de cocción Grille de cuisson

5. Heat Element Assembly

Ensamble del elemento calentador Elément chauffant

6. Controller Bracket Sleeve

Manga del soporte del regulador Manchon de support de bouton de commande

11 12

7. Temperature Controller with Power Cord

Regulador de temperatura con cordón eléctrico Bouton de commande de température avec

cordon d’alimentation

8. Removable Bowl Liner

Forro de quita y pon del tazón Doublure de bol démontable

9. Cookbox

Caja de cocción Chambre de cuisson

10. Carrying Handle

Asa de carga Poignée de transport

11. Rear Cradle

Bastidor posterior de soporte Socle arrière

12. Front Cradle

Bastidor delantero de soporte Socle avant

13. Cradle Logo

Logotipo del bastidor de soporte Logo de socle

14. Disposable Drip Pan

Bandeja de goteo desechable Lèchefrite jetable

15. Grease Catch Pan

Plato recolector Egouttoir

Q2400_ELECTRIC_US_060313

11 12

EXPLODED VIEW, VISION ÉCLATÉE, DIAGRAMA DE DESPIECE - 2400

1. Lid

Tapa Couvercle

2. Handle Spacer

Espaciador del asa Ecarteur de poignée

3. Handle

Asa Poignée

4. Cooking Grate

Rejilla de cocción Grille de cuisson

5. Heat Element Assembly

Ensamble del elemento calentador Elément chauffant

6. Controller Bracket Sleeve

Manga del soporte del regulador Manchon de support de bouton de commande

7. Temperature Controller with Power Cord

Regulador de temperatura con cordón eléctrico Bouton de commande de température avec cordon

d’alimentation

8. Removable Bowl Liner

Forro de quita y pon del tazón Doublure de bol démontable

9. Cookbox

Caja de cocción Chambre de cuisson

10. Carrying Handle

Asa de carga Poignée de transport

11. Rear Cradle

Bastidor posterior de soporte Socle arrière

12. Front Cradle

Bastidor delantero de soporte Socle avant

13. Cradle Logo

Logotipo del bastidor de soporte Logo de socle

14. Disposable Drip Pan

Bandeja de goteo desechable Lèchefrite jetable

15. Grease Catch Pan

Plato recolector Egouttoir

www.weber.com

PARTS LIST, LISTE DES PIÈCES, LISTA DE PIEZAS

.................................................................... 1

...................................................................................... 1

.................................................................... 1

............................ 2

...................... 2

............................................ 2

......................................................... 1

.................................................................................. 1

..................................................................................... 1

............................................................................... 1

ASSEMBLY, ASSEMBLAGE, ENSAMBLAJE

www.weber.com

GENERAL INSTRUCTIONS

If you have questions or need advice regarding your grill or its safe operation contact the Customer Service Representative in your area. Use the contact information on our web site. Log onto www.weber.com®.

With the Weber roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid produces that “outdoor” flavour in the food. Electricity is easy to use and gives you more cooking control than charcoal fuel.

• These instructions will give you the minimum requirements for assembling your Weber barbecue. Please read the instructions carefully before using your Weber assembly can be dangerous.

• Not for use by children.

• This Weber commercial use.

• Do not leave the Weber when it is in use.

• Any parts sealed by the manufacturer must not be altered by the user.

• Any modification of the appliance may be dangerous.

• Visually inspect cord, plug and Temperature Controller for damage and wear before operation.

• When heating the grill for the first time, it may give off a slight burning odor. The grill is burning off excess lubricants found on the heating element. This does not affect the safety of your grill.

• To prevent fire or electric shock, always use a certified electrician should new circuits or outlets be required.

• Improperly grounded outlets could cause electrical shock.

• The use of an extension cord is not recommended. If you must use an extension cord, use the shortest length extension cord possible. Do not connect 2 or more extension cords together. Keep connections off the ground and dry. Do not let cord hang over edge of table top where it can be tripped over or pulled by children. Only use extension cord labeled for outdoor use.

• Cover grill or store in weather protected area when not in use.

• Clean the grate and cookbox between uses.

electric barbecue you can grill, barbecue,

electric

electric barbecue. Improper

electric barbecue is not intended for

electric barbecue unattended

STORAGE AND/OR NON-USE

• During periods of non-use, the Temperature Controller with power cord should be in the “OFF” position. Store grill indoors.

OPERATING

m WARNING: Your Weber

electric barbecue must not be used upon any combustible surface such as dry grass, shrubs, etc.

m WARNING: Your Weber

electric barbecue is not intended for installation in or on recreational vehicles, SUVs and/or boats.

m WARNING: Do not use the barbecue

within 60 cm (24 in) of combustible materials from the back or sides of the grill. Do not use under any combustible construction.

m WARNING: The entire cooking box

gets hot when in use. Do not leave unattended.

m WARNING: Keep any electrical power

cord away from any heated surface.

m WARNING: Keep the cooking area

clear of inflammable vapours and liquids such as petrol, kerosene, alcohol, etc., and other combustible materials.

m WARNING: When cooking, the

appliance must be on a level, stable surface in an area clear of combustible material.

m WARNING: Keep cord clear of

cookbox.

CATCH PAN AND DISPOSABLE DRIP PAN

Your grill was built with a grease collection system. Check the catch pan and disposable drip pan for grease build-up each time you use your grill.

Remove excess grease with a plastic spatula; see illustration. When necessary, wash the catch pan and drip pan with a soap and water solution, then rinse with clean water. Replace the disposable drip pan as needed.

m WARNING: Check the catch pan and

disposable drip pan for grease buildup before each use. Remove excess grease to avoid a grease fire. A grease fire can cause serious bodily injury or damage to property.

m CAUTION: Do not line the catch pan

with aluminum foil.

(Q® 2400) - Make sure that disposable drip pan (a) rests flat on catch pan (b). A bent drip pan may interfere with removal of catch pan.

BEFORE USING THE GRILL

This appliance is Rated for

120 volts - 50/60Hz,

Output: 1500W

m WARNING: Do not move the Weber

electric grill when operating or while the grill is hot.

m WARNING: Completely unwind power

cord. Keep cord clear of cookbox.

1) Plug temperature controller into grill.

m Always plug temperature controller

fully into grill before plugging power cord into outlet.

COOKING ON YOUR ELECTRIC GRILL

2) Open Lid.

3) Make sure the temperature controller is turned OFF. (Turn control knob counterclockwise to ensure that it is in the OFF position.)

4) Plug in power cord into a protected outlet.

m The appliance should be supplied

through a grounded GFI outlet, 15amp minimum.

5) Preheat the grill. Turn control knob to HIGH (clockwise). The red light indicates that power is on and the heating element is heating up. The red light periodically turns on and off as the heating element adjusts to maintain temperature.

6) Close lid. Preheat time will take approximately 20 minutes, when grilling in a 72˚F air temperature. Colder temperatures and/or wind can cause longer preheating times.

To cook at a lower grill temperature: Preheat

as previously stated. Turn the control knob counterclockwise to desired setting. Start cooking.

m WARNING: When red light is off,

heating element may still be hot.

A - OFF

B - LOW

C - MEDIUM

D - HIGH

www.weber.com

+ 19 hidden pages