Page 1
VOLVO S60
WIRING DIAGRAM 2009
TP 39130202
Page 2
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Do not install any accessories in the areas between the A and B-posts, the B and C-posts,
and the C and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box
Changes implemented up to and including May 2008
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Order number TP 39130202
Replaces previous publication 39130201 of Electronic Wiring Diagram (EWD)
Electronic Wiring Diagram (EWD) which can be ordered from the Technical Information Shop
(TIS) at www.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.
© Volvo Car Corporation
Page 3
Table of Contents 1:2
Vehicles with SRS (Airbag)/SIPS bag/IC
(Inflatable curtain)......................................................... 2
Abbreviations................................................................. 5
How to use the wiring diagrams 1:2............................... 6
Overview
Electrical distribution 1:2................................................ 8
Fuses
Engine compartment 11A/1-5 ....................................... 10
Engine compartment 11B/1-12 ..................................... 11
Engine compartment 11B/13-15................................... 12
Engine compartment 11B/16-20................................... 13
Passenger compartment 11C/1-6................................. 14
Passenger compartment 11C/7-13............................... 15
Fuses in passenger compartment 11O/1-2 .................. 16
Cargo compartment 11E............................................... 17
Cargo compartment 11L...............................................18
Central Electronic Module (CEM) F1-F15.....................19
Central Electronic Module (CEM) F16-F34...................20
Rear Electronic Module (REM) F1-F13 ........................ 21
Rear Electronic Module (REM) F17-F38 ...................... 22
Relays
Ignition switch and relays............................................. 23
Engine compartment FMA1 - FST3............................. 24
Other relays ................................................................. 25
Ground connections
Overview...................................................................... 26
31/1 - 31/44 ................................................................. 27
31/46 - 31/67 ............................................................... 28
31/70 - 31/73 ............................................................... 29
31/83 - 31/88 ............................................................... 30
31/89 - 31/93 ............................................................... 31
31/94 - 31/102 ............................................................. 32
31/120 ........................................................................ 33
Control modules
Overview of locations................................................... 34
Overview of designations............................................. 35
Central Electronic Module (CEM) 1:2 .......................... 36
Rear Electronic Module (REM) 1:2.............................. 38
High speed CAN data communication ......................... 40
Low speed CAN data communication.......................... 41
LIN data communication 1:2........................................ 42
Group 23 Fuel system
Engine management system, 5-Cyl. 1:2...................... 44
Engine management system, 5-Cyl. Turbo 1:2 ........... 46
Engine management system, Bi-Fuel 1:2.................... 48
Engine management system, 5-Cyl. Diesel 1:3........... 50
Emission control, 5-Cyl. ............................................... 53
Emission control, 5-Cyl. Turbo..................................... 54
Group 26 Cooling system
Cooling fan................................................................... 55
Cooling fan, Diesel....................................................... 56
Group 27 Engine controls
Cruise control................................................................ 57
Cruise control, Diesel....................................................58
Group 32 Alternator and voltage regulator
Power supply ............................................................... 59
Group 33 Starting system
Starting system ............................................................ 60
Group 35 Lighting
High and low beam (Bi-Xenon) & Day running lights... 61
Active headlights (ABL)................................................ 62
Fog lights ..................................................................... 63
Brake lights .................................................................. 64
Reversing lights ........................................................... 65
Running/parking light, tail lights & license plate lighting... 66
Follow-me-home lighting.............................................. 67
Interior lighting ............................................................. 68
Beam length adjustment .............................................. 69
Auxiliary lights.............................................................. 70
Group 36 Additional electrical equipment
Rain sensor.................................................................. 71
Direction indicators and hazard warning flashers ........ 72
Wiper/washer, windshield ............................................ 73
Wiper/washer, headlights............................................. 74
High pressure headlight washer .................................. 75
Horn ............................................................................. 76
Electronic immobilizer .................................................. 77
Anti-theft alarm ............................................................ 78
Parking assistance....................................................... 79
Accessory Electronic Module (AEM) 1:2...................... 80
Alcolock ....................................................................... 82
Group 37 Wiring and fuses
Diagnostics system...................................................... 83
12V outlet..................................................................... 84
12V outlet, cargo compartment.................................... 85
Tow hitch cable harness, 4-pin .................................... 86
Tow hitch cable harness, 7-pin .................................... 87
Tow hitch cable harness, 13-pin .................................. 88
TP 39130202 S60 2009 3
Page 4
Table of Contents 2:2
Group 38 Instruments
Seat belt reminder ....................................................... 89
Driver information module............................................ 90
Driver information module, Diesel................................ 91
Driver information module, Bi-Fuel .............................. 92
Group 39 Other
Audio with internal amplifier......................................... 93
Audio with external amplifier 1:2.................................. 94
Mobile phone ............................................................... 96
Road Traffic Information (RTI)..................................... 97
Road Traffic Information (RTI) & CD changer ............. 98
Navigation system, portable ........................................ 99
CD changer................................................................ 100
MP3 player................................................................. 101
Satellite radio............................................................. 102
Bluetooth handsfree................................................... 103
Group 43 Transmission
Automatic transmission AW55-51SN/AW51 AWD .... 106
Automatic transmission TF-80SC/ TF-80SC AWD,
Diesel......................................................................... 107
Geartronic AW55-51SN/AW51 AWD......................... 108
Shift lock AW51 & Manual ......................................... 109
Differential Electronic Module (DEM)......................... 110
Group 59 Brake system
Brake Control Module (BCM)..................................... 111
Group 64 Steering
Electronic power steering .......................................... 112
Group 76 Shock absorbers
Four-C........................................................................ 113
Group 83 Doors and openings
Central locking........................................................... 114
Power windows.......................................................... 115
Power sunroof............................................................ 116
Group 84 Exterior decorative elements etc.
Power door mirrors .................................................... 117
Heated door mirrors................................................... 118
Heated rear window................................................... 119
Blind spot information system.................................... 120
Group 85 Interior equipment
Power driver s seat .................................................... 121
Power passenger seat ............................................... 122
Heated seats.............................................................. 123
Group 87 Climate control system,
Accessories
Relay, electric engine heater ..................................... 124
Climate control system 1:2......................................... 125
Climate control system, Diesel 1:2 ............................ 127
Parking heater, auxiliary heater ................................. 129
Parking heater, remote start ...................................... 130
Parking heater, Call start ........................................... 131
Short stop heater ....................................................... 132
Group 88 Internal equipment
Supplemental Restraint System (SRS)...................... 133
Electrically adjustable head restraint ......................... 134
Remote garage door opener...................................... 135
Connectors............................................... 136
Branching points ......................................154
Cable harness routing in vehicle
Engine harness, Gasoline...........................................163
Engine harness, Diesel...............................................164
Engine compartment harness LHD.............................165
Engine compartment harness RHD ............................166
Passenger compartment harness LHD....................... 167
Passenger compartment harness RHD ......................168
Cargo compartment harness ......................................169
Roof harness ..............................................................170
Trunk/tailgate harness ................................................171
Door harness ..............................................................172
Harnesses Bi-Fuel ......................................................173
Component pictures................................ 174
Index 1:2 ................................................... 220
List of components 1:4 ........................... 222
TP 39130202 S60 2009 4
Page 5
Explanations
Abbreviations
Groups
Group 23 = Fuel system
Group 26 = Cooling system
Group 27 = Engine controls
Group 32 = Alternator and voltage regulator
Group 33 = Starting system
Group 35 = Lighting
Group 36 = Additional electrical equipment
Group 37 = Wiring and fuses
Group 38 = Instruments
Group 39 = Other
Group 43 = Transmission
Group 59 = Brake system
Group 64 = Steering
Group 76 = Shock absorbers
Group 83 = Doors and openings
Group 84 = Exterior decorative elements, etc.
Group 85 = Interior equipment
Group 87 = Climate control system
Group 88 = Internal equipment
Ignition switch symbols
X = Accessories (audio position)
S = Powered upon insertion of key
15 = The switch remains connected during
start
15l = Contact is broken while starting
30 = Constant power from the battery
50 = Start
Countries/Markets
A = Austria
AUS = Australia
B = Belgium
CDN = Canada
CH = Switzerland
D = Germany
DK = Denmark
E= Spain
EU/OS = Markets outside USA and Canada
FIN = Finland
GB = Great Britain
ISR = Israel
J = Japan
KOR = Korea
N= Norway
NL = Netherlands
S = Sweden
USA = United States of America
WEU = Western Europe
Other
ABL = Active Bi-Xenon Light
ACC = Accessory
Ag = Silver plated
Au = Gold plated
AMP = Amplifier
AUDIO = Audio system
AUTO = Automatic transmission
Bi-X = Bi-Xenon
BLIS = Blind Spot Information System
CDCH = CD changer beneath parcel shelf
CEM = Central Electronic Module
DIESEL = D5244 T4/T5/T6/T7
DRL = Daytime Running Lights
DSTC = Dynamic Stability Traction Control
ECC = Electronic climate control system
ECPS = Electronic power steering
EXC = Exclusive
EXT. D = Extended electrical distribution
HISPEED = High speed data bus
LH = Left-hand side
LHD = Left-hand drive
LOSPEED = Low speed data bus
MAN = Manual transmission
MCC = Manual climate control system
PETROL = Gasoline
REM = Rear Electronic Module
RH = Right-hand side
RHD = Right-hand drive
RTI = Road Traffic Information
SUM = Suspension Module
SRS = Airbag
T = Turbo engine
W/O = Without
5CYL = 5-cylinder engine
Colors
BL = Blue
BN = Brown
GN = Green
GR = Gray
NL = Natural
LBL = Light Blue
LGN = Light Green
OR = Orange
P= Pink
R= Red
SB = Black
VO = Violet
W= White
Y = Yellow
TP 39130202 S60 2009 5
Page 6
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily
contained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
The first part is a type number that describes the
type of component in question, for example 3/xx.
The second part of the designation is a serial number, for example x/2.
Combined these give a component designation, for
example 3/2.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
List of type numbers
The list shows which type of component that respective type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
1 Battery
2Relay
3 Switch
4 Control module
5 Driver Information Module
6 Electric motor
7Sensor
8 Actuator
9 Heating element
10 Light
11 Fuse
15 Electrical distribution rail/box
16 Audio
17 Service/diagnostics
18 Contact reel
19 Meter
20 Ignition component/shunt
26 Converter
27 Optics
31 Ground connection
53 Branching point
54 Connector
B. Branching points
The wiring diagrams contain numbered branching
points, for example 53/352.
This manual contains a section with a list of branching points. This list shows all the components which
are connected to each branching point.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
C. Connectors
Connectors provide a bridge between two cable harnesses and are described in the "Connectors" section.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
E. Data communication
Today s cars contain CAN and LIN networks that
transfer information. Connections to these networks
are not shown in their entirety in the respective wiring diagram. Complete information on CAN and LIN
communication is found in the section "Control modules".
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbreviations".
G. Component location
The end of the manual contains a section in which
component appearance and location is described in
numeric order. On the EWD disc, components are
linked to the relevant diagram.
TP 39130202 S60 2009 6
Page 7
How to use the wiring diagrams 2:2
GN-W
AF EDCB
30+
1
1
11C/ 7
11C/ 6
2
2
List of symbols
= System voltage
= Ground connection via wiring
R
3/254
SWM
R
21
54/13
= Ground connection in
component/chassis
LIN
7
4/70
UEM
3
VO-W
BN
5
13
8
7/149
RSM
1
2
3
4
LIN
4/56
D:11
CEM
D:58
C:31
D:50
D:35
CAN
D:34
D:49
LIN
54/16
W
BN
VO-W
W-BL
W
GN
1
BN
2
3
4
54/13
BL-W
BN
53/505
VO-W
W
14
BN
20
53/503
1
R
11
R
CAN
LIN
20
= Screened wire
= Branching point
= Twisted cable
= Electrical connection
= Variant
10/1-2
6/1
53/331
53/397
L
31/93
321
H
BN
4
SB
BN
BN
31/98
31/83
= CAN communication
= CAN high data signal (CAN H)
= CAN low data signal (CAN L)
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
G
CAN
= CAN communication
= Connection with distribution
21
41
box
= Further connection to...
B
A
1
= Connector between cable
harnesses
1
= Connector connected in
component
TP 39130202 S60 2009 7
Page 8
Overview
Electrical distribution 1:2
15/31
DIESEL
20/16
R
53/329
4/109:11
1
11B/1
2
54/1C
1
SB
1
11A/1
2
R
1
2
1
11B/2
2
1
11A/2
2
Bi-Fuel
W/O Bi-Fuel
1
11B/3
2
R-W
3(30)1(86)
1
11B/4
2
FMA2
R
R
R
R
R-W
1
11A/3
2
53/399
1
11B/5
2
2/32
1
11A/4
2
4/71:2
R
PETROL
2
Bi-FuelBi-Fuel
1
11B/6
2
R
1
11A/5
2
A1 A1 A1
123
R-W
1
11B/7
2
DIESEL
1
FMA3
3(30)1(86)
PETROL
1
11B/8
2
R
R-W
R
R
Y
1
11B/9
2
2/35
17/17
1
2
2
11B/10
SB
R
R
R
R
1
11B/14
2
1
11B/15
2
1
11B/16
2
BL-R
1
11B/17
2
1
11B/18
2
BL
1
11B/19
2
1
11B/20
2
R-W
1
11B/21
2
1
11B/11
2
BL-R
GN-OR
Bi-Fuel
W/O Bi-Fuel
1
11B/12
2
1
11B/13
2
53/305
DIESEL
GN-OR
DIESEL
1
FMA1
3(30)1(86)
2/22
BL-R
2
1
FMI2
3(30)1(86)
2/133
GN-OR
GR
GN-GR
BU-RD
1
2
FMI1
3(30)1(86)
4/56C:7
4/46B:29
54/1B:6
4/56B:1
6/114:1
4/46B:38
4/46B:42
4/56C:3
6/1:2
6/1:1
Y-W
Y-W
Y
Y
BL
5(87)2(85)
5(87)2(85)
3
4
Y
5(87)2(85)
4
3
BL-R
4
DIESEL
R-SB
GN-Y
2/182
1
2
FST3
3(30)1(86)
2/90
GN-Y
2
R-W
1
FST1
3(30)1(86)
GN-Y
2/91
1
2
FST2
3(30)1(86)
4(87a)
5(87)2(85)
3
5
4
DIESEL
DIESEL
4(87a)
5(87)2(85)
3
5
RD-WH
BK
GN-W
GN-W
GN-R
BL-OR
BL-OR
Y
8/84:1
4/46B:44
4/46B:32
54/1B:8
4/56C:6
4/46B:44
6/104:2
54/146
1
R
2
11L/1
5(87)2(85)
4
4(87a) 5(87)2(85)
35
4
4(87a) 5(87)2(85)
35
4
4(87a)
35
GN-SB
GR-SB
GR
4/56C:25
53/331
4/56C:4
1
R
BA
DC FGE
TP 39130202 S60 2009 8
Page 9
Overview
Electrical distribution 2:2
ABCDEFG
DIESEL
VO
53/408
VO
1 1
2 2
VO
VO
3/1
S
37506
11C/2
5
X
11C/3
3/157:1
4/9:55/B:27
4
30
15
15 15I
1
11
1
11C/4
11C/5
222
R-SB
BL-R
8
BL-R
53/443
BL-R
BL-R
BL-R
Y
Y-W
1
11C/61111C/7
2 22
16/65:1
3/157:2
4/9B:28/56
11C/8
1
11C/91111C /10
2 22
4/56
C:13
D:16
C:14
D:15
D:60
D:8
D:35
D:50
CEM
CAN
LIN
F3, 5-10,
17-23,
31-32 ,34
F1-2, 11,
13-16,
26-30, 33
F29
53/403
R
12
53/415
R
6/25
50
R
BL
R-W
BL-R
R
M
31
1
30
53/3009
R
A:1
B+
6/26
ACM
G
LIN
RR
SB
31
R
R
R
R
1 1
11C/1111C/1
11C/1311C/12
2 2
54/40C
4/58
B:2
B:24
B:3
B:16
E:A
E:B
A:23
BL
11E
R
54/40D
R
2
1
67
2
245222322
R
R
R
R
Y-R
SB
31/53
1
R
1
2
R
1/1
12V
+
-
A:29
C:14
C:13
A:13
K:1
REM
CAN
LIN
F1-38
TP 39130202 S60 2009 9
Page 10
Fuses
Engine compartment 11A/1-5
5
4
3
2
1
11A Fuses in the engine compartment
No. Fuse function via A
1 4/109 Glow plug control unit (GCU)
20/22-26 Glow plug
2 6/29 Motor, cooling fan 4/71 60
3- --
4- --
5- --
-
4/109
60
TP 39130202 S60 2009 10
Page 11
Fuses
Engine compartment 11B/1-12
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
1 4/16 Brake Control Module (BCM) - 30
2 4/16 Brake Control Module (BCM) - 30
3 6/104 High pressure headlight washer 2/182 35
4 6/35 Fuel pump, auxiliary heater
6/73 Coolant pump, auxiliary heater
9/30 Auxiliary heater
5 54/8 Connector cable harness extra lights, 30-feed - 20
6 6/25 Starter motor 2/35 35
7 2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent wiping
6/1 Windshield wiper motor
8 4/83 Fuel pump control module
6/33 Fuel pump
9 4/28 Transmission Control Module (TCM), TF-80SC/TF-80SC AWD - 15
10 4/46 Engine Control Module (ECM), Diesel
20/3-8 Spark plug and ignition coil
11 6/44 Cooling fan, electrics box, engine compartment
7/51 Accelerator pedal sensor
8/3 Electromagnetic clutch, climate control system
12 7/17 Mass airflow sensor (MAF), Diesel - 5
4/46 Engine Control Module (ECM), Gasoline
7/17 Mass airflow sensor (MAF), Gasoline
8/6-11 Injectors, Gasoline
6
5
4
3
2
1
4/7
4/7
4/7
2/91
-
2/90, 2/91
4/56
4/56
-
-
-
-
2/22
-
-
-
continues
25
25
15
20
10
15
TP 39130202 S60 2009 11
Page 12
Fuses
Engine compartment 11B/13-15
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
13 4/46 Engine Control Module (ECM), 5-Cyl. not turbo
4/50 Electronic Throttle Module (ETM), Bi-Fuel
6/120 Throttle body motor, 5-Cyl. not turbo
4/46 Engine Control Module (ECM), Diesel
6/118 Control motor, swirl throttle, Diesel
6/120 Throttle body motor, Diesel
8/98 Fuel pressure control valve, Diesel
8/111 Fuel flow control valve
14 7/15 Front heated oxygen sensor, Diesel - 10
4/46 Engine Control Module (ECM), Bi-Fuel
7/15 Front heated oxygen sensor
7/82 Rear heated oxygen sensor
15 6/67 Pump, fuel leakage control
6/105 Fuel distributor gas, Bi-Fuel
8/18 EVAP valve
8/19 Solenoid, variable valve timing intake
8/28 Turbo control valve
8/75 Valve, fuel cut-off DFCO
8/81 Solenoid, variable valve timing exhaust
9/32 PTC resistor, crankcase ventilation
4/109 Glow plug control unit (GCU)
6/143 Turbo control motor, Diesel
8/64 Solenoid valve, engine pad
8/113 Bypass valve, EGR cooling, Diesel
8/120 EGR valve, Diesel
6
5
4
3
2
1
-
-
4/46
4/46
4/46
4/46
4/46
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
continues
10
15
20
10
15
TP 39130202 S60 2009 12
Page 13
Fuses
Engine compartment 11B/16-21
9
8
7
13
21
17
16
12
20
11
15
19
10
14
18
11B Fuses in the engine compartment
No. Fuse function via A
16 10/1 Left front lamp housing, daytime running lights
10/70 Left-hand low beam
17 10/2 Right front lamp housing, daytime running lights
10/66 Right-hand low beam
19 2/32 Main relay, engine management system
4/46 Engine Control Module (ECM)
20 10/11 Front left running/parking light
10/12 Front right running/parking light
10/71 Side running light, front left
10/73 Side running light, front right
21 6/114 Vacuum pump 2/133 20
6
5
4
3
2
1
4/56
4/56
4/56
4/56
-
-
4/56
4/56
4/56
4/56
20
20
5
15
TP 39130202 S60 2009 13
Page 14
Fuses
Passenger compartment 11C/1-6
11C /1
11C/3011C/2011C/10
11C/3811C/2911C/1911C/9
11C Fuses in the passenger compartment
No. Fuse function via A
1 4/52 Power Seat Module (PSM)
6/16 Driver seat motor, backrest angle
6/17 Driver seat motor, up/down front edge
6/18 Driver seat motor, up/down rear edge
6/19 Driver seat motor, forward/backward
2 6/20 Passenger seat motor, forward/backward
6/64 Passenger seat motor, backrest angle
6/65 Passenger seat motor, up/down front edge
6/66 Passenger seat motor, up/down rear edge
3 6/28 Motor, passenger compartment fan 4/31 30
4 3/75 Right-hand front door lock unit
3/127 Passenger/Driver Door Module (PDM)/(DDM)
6/60 Motor, front right power window
6/63 Right-hand power door mirror
9/34 Right-hand heated door mirror
10/149 Right-hand rearview mirror lighting
5 3/74 Left-hand front door lock unit
3/126 Driver/Passenger Door Module (DDM)/(PDM)
6/58 Motor, front left power window
6/62 Left-hand power door mirror
9/33 Left-hand heated door mirror
10/148 Left-hand rearview mirror lighting
6 3/117 Switch unit, dome light
4/33 Sunroof Module (SRM)
4/70 Upper Electronic Module (UEM)
4/76 Remote control unit for garage door opener
7/149 Rain Sensor Module (RSM)
10/114 Left-hand vanity mirror lighting
10/115 Right-hand vanity mirror lighting
10/150 Rear reading light
continues
4/52
4/52
4/52
4/52
3/27
3/27
3/27
3/27
3/127
-
3/127
3/127
3/127
3/127
3/126
-
3/126
3/126
3/126
3/126
4/70
4/70
4/70
4/70
4/70
4/70
4/70
25
25
25
25
10
TP 39130202 S60 2009 14
Page 15
Fuses
Passenger compartment 11C/7-13
11C /1
11C/3011C/2011C/10
11C/3811C/2911C/1911C/9
11C Fuses in the passenger compartment
No. Fuse function via A
7 6/15 Sunroof motor 4/33 15
8 3/157 Passenger Airbag Cut Off Switch (PACOS)
4/9 Supplemental Restraint System (SRS)
4/28 Transmission Control Module (TCM)
4/46 Engine Control Module (ECM)
4/56 Central Electronic Module (CEM)
4/58 Rear Electronic Module (REM)
11O/1 Fuse in extra fuse holder, passenger compartment
11O/2 Fuse in extra fuse holder, passenger compartment
16/65 Antenna ring/ignition switch illumination
9 3/111 Light Switch Module (LSM)
3/254 Steering Wheel Module (SWM)
4/68 Steering Wheel Angle Sensor Module (SAS)
17/13 Data link connector
10 16/1 Audio Module (AUM) - 20
11 16/2 Amplifier - 30
12 16/46 RTI display - 10
13 16/60 Phone Module (PHM) - 5
3/1
3/1
3/1, 4/56
3/1, 4/56
3/1
3/1
3/1
3/1
-
-
3/254
-
7,5
5
TP 39130202 S60 2009 15
Page 16
Fuses
Fuses in passenger compartment 11O/1-2
11O/1-2
11O/1-2 Fuses in the extra fuse holder passenger compartment
No. Fuse function via A
1 Alcolock
Alcolock
2 Alcolock -5
2/241 5
TP 39130202 S60 2009 16
Page 17
Fuses
Cargo compartment 11E/1-7
11E/7
11E/1
11E Fuses by battery
No. Fuse function via A
1 4/58 Rear Electronic Module (REM)
Main fuse for: F1-F38
4 4/56 Central Electronic Module (CEM)
Main fuse for: F1-F2, F11, F13-F16, F26-F30, F33
5 4/56 Central Electronic Module (CEM)
Main fuse for: F3, F5-F10, F17-F23, F31-F32, F34
6 11C/1-5 Fuses in passenger compartment fuse box - 50
7 11C/6-13 Fuses in passenger compartment fuse box - 50
-
-
-
-
-
-
60
50
50
TP 39130202 S60 2009 17
Page 18
Fuses
Cargo compartment 11L
11L Fuse Diesel
No. Fuse function via A
1 11B/9 Fuses in engine compartment fuse box
11B/10-15 Fuses in engine compartment fuse box
-
2/32
50
TP 39130202 S60 2009 18
Page 19
Fuses
Central Electronic Module (CEM) F1-F15
1
31 32 33
6
5
4
19 20
7
8
9
10
11
12
21
24
22
23
25 26
3
363534
18
17
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F1 9/13 Seat Heating Module (SHM), right - 15
F2 9/12 Seat Heating Module (SHM), left - 15
F3 16/10 Horn 1
16/11 Horn 2
F8 16/35 Siren Control Module (SCM) - 5
F9 3/9 Brake light contact - 5
F10 3/112 Climate Control Module (CCM)
4/7 Combustion Preheater Module (CPM)
4/52 Power Seat Module (PSM)
5/1 Driver Information Module (DIM)
6/48 Damper Motor Module (DMM), recirculation
6/69 Damper Motor Module (DMM), ventilation/floor/defroster
6/95 Damper Motor Module (DMM), temperature, left side
6/96 Damper Motor Module (DMM), temperature, right side
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/93 Occupant Weight Sensor (OWS)
7/159 Air Quality Sensor (AQS)
F11 9/1 Front 12V outlet
9/25 Rear 12V outlet
16/45 Portable navigation system
F14 6/3 Right-hand headlight wiper motor
6/4 Left-hand headlight wiper motor
F15 4/16 Brake Control Module (BCM) - 5
2
13
14 15
16
28
30
29
27
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
continues
15
10
15
15
TP 39130202 S60 2009 19
Page 20
Fuses
Central Electronic Module (CEM) F16-F34
1
31 32 33
6
5
4
19 20
7
8
9
10
11
12
21
24
22
23
25 26
3
363534
18
17
4/56 Central Electronic Module (CEM)
No. Fuse function via A
F16 4/99 Electronic power steering control module
4/118 Headlamp control module (HCM)
6/38 Left-hand headlight level adjustment motor
6/39 Right-hand headlight level adjustment motor
10/1 Left front lamp housing, Bi-Xenon
10/2 Right front lamp housing, Bi-Xenon
F17 10/5 Front left fog light - 7,5
F18 10/6 Front right fog light - 7,5
F21 3/156 Gear Selector Module (GSM)
4/28 Transmission Control Module (TCM)
8/36 Shift lock solenoid
8/134 Solenoid, reverse interlock, manual
F22 10/68 Left-hand high beam - 10
F23 10/64 Right-hand high beam - 10
F28 3/27 Switch unit, power passenger seat
16/1 Audio Module (AUM)
16/46 RTI display
F29 6/31 Feed pump, ejectors
8/88 Rear solenoid, fuel tank, Bi-Fuel
8/89 Front left solenoid, fuel tank, Bi-Fuel
8/90 Front right solenoid, fuel tank, Bi-Fuel
F30 27/3 Left Camera Module (LCM)
27/4 Right Camera Module (RCM)
F33 2/133 Relay vacuum pump - 20
F34 6/3 Right-hand headlight wiper motor
6/4 Left-hand headlight wiper motor
6/127 Washer motor
2
13
14 15
16
28
30
29
27
-
-
-
-
-
-
-
-
3/156
-
-
-
-
4/58
4/58
4/58
4/58
-
-
-
-
-
10
10
5
7,5
5
15
TP 39130202 S60 2009 20
Page 21
Fuses
Rear Electronic Module (REM) F1-F13
4
5
3
21
9
6
1110 12
8
7
16
13 1514
27 28
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F1 10/48 Right-hand reversing light
10/55 Left-hand reversing light
F2 10/3 License plate lighting
10/19 Auxiliary brake light
10/42 Rear right running/parking light
10/44 Right-hand tail light lamp 1
10/46 Fog light, right rear
10/49 Rear left running/parking light
10/51 Left-hand tail light lamp 1
10/53 Fog light, left rear
10/127 Lighting, cargo compartment, left-hand side
10/128 Lighting, cargo compartment, right-hand side
F3 4/78 Accessory Electronic Module (AEM)
4/106 Control module, remote parking heater start
F5 4/58 Rear Electronic Module (REM) - 10
F6 16/15 CD changer
16/36 TV receiver
16/45 Road Traffic Information module (RTI)
16/46 RTI display
16/149 MP3 player
F7 17/39 13-pin outlet, tow hitch cable harness - 15
F8 17/19 12V outlet, cargo compartment - 15
F9 3/86 Rear right door power window switch
6/93 Motor, rear right power window
F10 3/85 Rear left door power window switch
6/92 Motor, rear left power window
F13 8/85 Thermostatic switch and fuel filter heating - 15
1817 19
29
31
3332 34 35
20302221
262324 25
37
36
38
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
3/86
-
3/85
continues
10
20
15
7,5
20
20
TP 39130202 S60 2009 21
Page 22
Fuses
Rear Electronic Module (REM) F17-F38
4
5
3
21
9
6
1110 12
8
7
16
13 1514
27 28
4/58 Rear Electronic Module (REM)
No. Fuse function via A
F17 16/145 Satellite radio receiver - 5
F19 8/59 Rear left head restraint solenoid
8/60 Rear right head restraint solenoid
F20 17/38 7-pin outlet, tow hitch cable harness
17/39 13-pin outlet, tow hitch cable harness
F21 Spare - 10
F23 4/82 Differential Electronic Module (DEM) - 7,5
F24 4/84 Suspension Module (SUM) - 15
F26 4/86 Parking Assistance Module (PAM) - 5
F27 Main fuse for F20-F21, F23-F24 and F26 - 30
F28 3/76 Left-hand rear door lock unit
3/77 Right-hand rear door lock unit
3/78 Trunk lid lock unit
6/37 Lock motor, fuel filler cover
F29 4/110 Trailer Module (TRM)
- running lights
- left-hand direction indicator
26/4 Cable harness, tow hitch cable harness
- running lights
- direction indicator, left
F30 4/110 Trailer Module (TRM)
- brake lights
- fog lights
- right-hand direction indicator
F31 Main fuse for: F37-F38 - 40
F37 9/2 Heated rear window 16/16 20
F38 9/2 Heated rear window 16/16 20
1817 19
20302221
29
31
3332 34 35
262324 25
37
36
38
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
-
15
20
15
25
25
TP 39130202 S60 2009 22
Page 23
Relays
Ignition switch and relays
1423
15 15 30
S
15IX50
Position
Key Out
0
I
II
III
30
X
X
X
X
X
Terminal
15
XXXX
X
X
X
X
15I
S1550
X
XX
XX
Term.
1
2
3
4
5
6
7
8
587 6
Color
BL-R
Y
R-SB
VO
Y-W
BL
Relays, general
The diagram indicates two or three different designations for the relay s position. This
is described below.
ABC
2
1(86)
1
3(30)
A = Corresponds to the position on the back
of the relay box (wiring side)
B = Corresponds to the position on the relay.
C = An old designation that may be found on
the relay.
2(85)
4(87a)
5(87)
5
3
4
TP 39130202 S60 2009 23
Page 24
Relays
Engine compartment FMA1 - FST3
FST3
FMA3
FMI1
FMA2 FST2
FST1FMA1
FMI2
Relays in the engine compartment
Pos Relay function
FMA1 2/35 Starter motor
FMA3 2/32 Main relay, engine management system
FMI1 2/133 Relay vacuum pump
FMI2 2/22 Relay, climate control system
FST1 2/90 Relay, windshield wiper, low/high speed
FST2 2/91 Relay, intermittent wiping
FST3 2/182 Relay, high pressure headlight washer motor
TP 39130202 S60 2009 24
Page 25
Relays
Other relays
Accessory relays
Pos Relay function
Engine
compartment
Cargo
compartment
Front member 2/192 Relay, electric engine heater
By the climate
control system
2/64 Auxiliary light (accessory) relay
2/191 Relay, remote parking heater start, radio signal
2/71 Relay cellular phone handsfree
2/240 Alcolock relay, wake-up
2/241 Alcolock relay, interior lighting
TP 39130202 S60 2009 25
Page 26
Ground connections
Overview
31/2
31/95
31/93
31/53
31/83
31/70
31/44
31/102
31/4
31/91
31/89
31/88
31/96
31/1
31/94
31/84
31/10
31/6
31/66
31/98
31/46
31/47
31/72
31/67
31/48
31/73
31/5
31/120
TP 39130202 S60 2009 26
Page 27
Ground connections
31/1 - 31/44
31/1 Right MacPherson strut tower
6/3 Right-hand headlight wiper motor
6/104 High pressure headlight washer motor
7/5 Washer fluid level sensor
31/2 Left MacPherson strut tower
4/46 Engine Control Module (ECM), Diesel
4/71 Cooling fan control module
31/4 Engine
31/44 Ground connection
31/5 D-post, right-hand
9/2 Heated rear window
31/6 A-post, left-hand side
2/240 Alcolock relay, wake-up, accessories
2/241 Alcolock relay, interior lighting, accessories
3/6 Hazard warning flasher switch
3/117 Switch unit, dome light
4/31 Fan control module, RHD
4/33 Sunroof Module (SRM)
4/56 Central Electronic Module (CEM), LHD
4/76 Remote control unit for garage door opener
6/15 Sunroof motor
10/29 Glove compartment lighting
10/114 Left-hand vanity mirror lighting
10/125 Left-hand front courtesy lighting
10/126 Right-hand front courtesy lighting
10/150 Rear reading light
16/65 Antenna ring/ignition switch illumination
Alcolock, accessories
31/10 A-post, right-hand side
4/31 Fan control module, LHD
4/56 Central Electronic Module (CEM), RHD
4/84 Suspension Module (SUM)
9/1 Front 12V outlet
9/25 Rear 12V outlet
16/45 Portable navigation system
31/44 Left-hand side member, lower engine compartment
31/4 Ground connection
TP 39130202 S60 2009 27
Page 28
Ground connections
31/46 - 31/67
31/46 Rear seat riser, left-hand side
3/27 Switch unit, power passenger seat, RHD
3/76 Left-hand rear door lock unit
3/85 Rear left door power window switch
4/52 Power Seat Module (PSM), LHD
4/82 Differential Electronic Module (DEM)
8/51 Front left side airbag igniter
8/59 Rear left head restraint solenoid
9/12 Seat Heating Module (SHM), left
31/47 Rear seat riser, left-hand side
4/58 Rear Electronic Module (REM)
31/48 Rear seat riser, right-hand side
4/83 Fuel pump control module
6/31 Feed pump, ejectors
6/33 Fuel pump
31/53 Firewall
1/1 Battery
31/66 Front seat riser, left-hand side
3/126 Driver/Passenger Door Module (DDM)/(PDM)
9/33 Left-hand heated door mirror
10/15 Direction indicator, left door mirror
10/148 Left-hand rearview mirror lighting
27/3 Left Camera Module (LCM)
31/67 Front seat riser, right-hand side
3/27 Switch unit, power passenger seat, LHD
3/77 Right-hand rear door lock unit
3/86 Rear right door power window switch
3/127 Passenger/Driver Door Module (PDM)/(DDM)
4/52 Power Seat Module (PSM), RHD
6/35 Fuel pump, auxiliary heater
7/93 Occupant Weight Sensor (OWS)
8/52 Front right side airbag igniter
9/13 Seat Heating Module (SHM), right
9/34 Right-hand heated door mirror
10/16 Direction indicator, right door mirror
10/149 Right-hand rearview mirror lighting
27/4 Right Camera Module (RCM)
TP 39130202 S60 2009 28
Page 29
Ground connections
31/70 - 31/73
31/70 Left-hand side member, lower engine compartment
10/65 Auxiliary light, front right, accessories
10/69 FL auxiliary light, accessories
31/72 Cargo compartment
4/58 Rear Electronic Module (REM)
4/86 Parking Assistance Module (PAM)
7/100 Inclination Sensor Module (ISM)
10/18 Lamp housing, rear left
10/127 Lighting, cargo compartment, left-hand side
16/15 CD changer, accessories
16/45 Road Traffic Information module (RTI)
16/149 MP3 player, accessories
31/73 Rear seat riser, right-hand side
2/191 Relay, remote parking heater start, radio signal, accessories
4/78 Accessory Electronic Module (AEM)
4/106 Control module, remote parking heater start, accessories
8/60 Rear right head restraint solenoid
8/85 Thermostatic switch and fuel filter heating
8/88 Rear solenoid, fuel tank, Bi-Fuel
8/89 Front left solenoid, fuel tank, Bi-Fuel
8/90 Front right solenoid, fuel tank, Bi-Fuel
10/17 Lamp housing, rear right
10/128 Lighting, cargo compartment, right-hand side
10/218 Remote start indicator light, accessories
17/19 12V outlet, cargo compartment
TP 39130202 S60 2009 29
Page 30
Ground connections
31/83 - 31/88
31/83 A-post, left-hand side
4/33 Sunroof Module (SRM)
4/70 Upper Electronic Module (UEM)
5/1 Driver Information Module (DIM)
7/122 Mass movement sensor, front
7/149 Rain Sensor Module (RSM)
10/19 Auxiliary brake light
10/115 Right-hand vanity mirror lighting
10/150 Rear reading light
16/65 Antenna ring/ignition switch illumination
31/98 Ground connection
31/84 A-post, right-hand side
3/111 Light Switch Module (LSM)
3/112 Climate Control Module (CCM)
3/254 Steering Wheel Module (SWM)
4/68 Steering Wheel Angle Sensor Module (SAS)
4/118 Headlamp control module (HCM)
6/48 Damper Motor Module (DMM), recirculation
6/69 Damper Motor Module (DMM), ventilation/floor/defroster
6/95 Damper Motor Module (DMM), temperature, left
6/96 Damper Motor Module (DMM), temperature, right
6/102 Damper Motor Module (DMM), defroster
6/103 Damper Motor Module (DMM), floor/ventilation
7/159 Air Quality Sensor (AQS)
16/1 Audio Module (AUM)
16/2 Amplifier
16/46 RTI display
16/60 Phone Module (PHM)
17/13 Data link connector
17/40.2 Auxiliary input (AUX)
31/88 Engine, ignition coils, group 1
20/3 Spark plug and ignition coil
20/4 Spark plug and ignition coil
TP 39130202 S60 2009 30
Page 31
Ground connections
31/89 - 31/93
31/89 Engine, ignition coils, group 2
20/5 Spark plug and ignition coil
20/6 Spark plug and ignition coil
20/7 Spark plug and ignition coil
31/91 Engine
4/50 Electronic Throttle Module (ETM), Bi-Fuel
9/32 PTC resistor, crankcase ventilation, Bi-Fuel
31/93 Left MacPherson strut tower
2/91 Relay, intermittent wiping
3/10 Reversing light contact, MAN
3/62 Hood alarm contact
3/156 Gear Selector Module (GSM), TF-80SC/TF-80SC AWD
4/7 Combustion Preheater Module (CPM)
4/28 Transmission Control Module (TCM), TF-80SC/TF-80SC AWD
4/56 Central Electronic Module (CEM)
4/99 Electronic power steering control module
6/1 Windshield wiper motor
6/4 Motor, left-hand headlight
6/38 Left-hand headlight level adjustment motor
6/114 Vacuum pump
7/4 Brake fluid level sensor
7/51 Accelerator pedal sensor
7/73 Coolant level sensor
8/36 Shift lock solenoid, TF-80SC/TF-80SC AWD
8/37 Automatic transmission
8/84 Switch, vacuum pump
8/134 Solenoid, reverse interlock, manual
9/30 Auxiliary heater
10/1 Left-hand front lamp housing
10/5 Front left fog light
10/11 Front left running/parking light
10/13 Front left direction indicator
10/71 Side running light, front left
16/10 Horn 1
16/11 Horn 2
20/16 Capacitor
TP 39130202 S60 2009 31
Page 32
Ground connections
31/94 - 31/102
31/94 Right MacPherson strut tower
3/156 Gear Selector Module (GSM), AW55-51SN/AW51 AWD
4/28 Transmission Control Module (TCM), AW55-51SN/AW51 AWD
6/39 Right-hand headlight level adjustment motor
8/36 Shift lock solenoid, AW55-51SN/AW51 AWD
10/2 Right-hand front lamp housing
10/6 Front right fog light
10/12 Front right running/parking light
10/14 Front right direction indicator
10/73 Side running light, front right
16/35 Siren Control Module (SCM)
31/95 Left MacPherson strut tower
4/16 Brake Control Module (BCM)
31/96 Right MacPherson strut tower
4/46 Engine Control Module (ECM)
4/71 Cooling fan control module, Diesel
6/105 Fuel distributor gas, Bi-Fuel
9/32 PTC resistor, crankcase ventilation, Gasoline, 5-Cyl.
31/98 Windshield member, upper
3/117 Switch unit, dome light
4/33 Sunroof Module (SRM)
4/70 Upper Electronic Module (UEM)
7/122 Mass movement sensor, front
7/149 Rain Sensor Module (RSM)
10/19 Auxiliary brake light
10/115 Right-hand vanity mirror lighting
10/150 Rear reading light
31/83 Ground connection
31/102 Front member
2/192 Relay, electric engine heater, accessories
TP 39130202 S60 2009 32
Page 33
Ground connections
31/120
31/120 Cargo compartment, accessories
4/110 Trailer Module (TRM)
16/15 CD changer
16/45 Road Traffic Information module (RTI)
16/46 RTI display
16/145 Satellite radio receiver
17/37 4-pin outlet, tow hitch cable harness
17/38 7-pin outlet, tow hitch cable harness
17/39 13-pin outlet, tow hitch cable harness
26/4 Tow hitch cable harness converter, USA
TP 39130202 S60 2009 33
Page 34
Control modules
Overview of locations
TCM
4/71
4/31
ECM
PDM/
DDM
RCM
AUM
CCM
OWS
PHM
SHM
BSC
DIM
UEM
SRM
RSM
SRS
AEM
GSM
HCM
SUM
DEM
RTI
ISM
TRM
REM
PAM
SWM
SCM
ACM
ETM
SAS
SHM
LCM
PSM
AQS
LSM
DMM
TP 39130202 S60 2009 34
CPM
BCM
17/13
CEM
DDM/
PDM
Page 35
Control modules
Overview of designations
Unit Designation
ACM 6/26 Alternator Control Module (ACM)
AEM 4/78 Accessory Electronic Module (AEM)
AQS 7/159 Air Quality Sensor (AQS)
AUM 16/1 Audio Module (AUM)
BCM 4/16 Brake Control Module (BCM)
BSC 7/164 Body Sensor Cluster Stability Sensor (BSC)
CCM 3/112 Climate Control Module (CCM)
CEM 4/56 Central Electronic Module (CEM)
CPM 4/7 Combustion Preheater Module (CPM)
DDM/PDM 3/126 Driver/Passenger Door Module (DDM)/(PDM)
DEM 4/82 Differential Electronic Module (DEM)
DIM 5/1 Driver Information Module (DIM)
DMM Damper Motor Module (DMM)
-6/48 Damper Motor Module (DMM), recirculation
-6/69 Damper Motor Module (DMM), ventilation/floor/defroster
-6/95 Damper Motor Module (DMM), temperature, left side
-6/96 Damper Motor Module (DMM), temperature, right side
-6/102 Damper Motor Module (DMM), defroster
-6/103 Damper Motor Module (DMM), floor/ventilation
ECM 4/46 Engine Control Module (ECM)
ETM 4/50 Electronic Throttle Module (ETM)
GSM 3/156 Gear Selector Module (GSM)
HCM 4/118 Headlamp control module (HCM)
ISM 7/100 Inclination Sensor Module (ISM)
LCM 27/3 Left Camera Module (LCM)
LSM 3/111 Light Switch Module (LSM)
OWS 7/93 Occupant Weight Sensor (OWS)
PAM 4/86 Parking Assistance Module (PAM)
PDM/DDM 3/127 Passenger/Driver Door Module (PDM)/(DDM)
PHM 16/60 Phone Module (PHM)
PSM 4/52 Power Seat Module (PSM)
RCM 27/4 Right Camera Module (RCM)
REM 4/58 Rear Electronic Module (REM)
RSM 7/149 Rain Sensor Module (RSM)
RTI 16/45 Road Traffic Information module (RTI)
SAS 4/68 Steering Wheel Angle Sensor Module (SAS)
SCM 16/35 Siren Control Module (SCM)
SHM Seat Heating Module (SHM)
-9/12 Seat Heating Module (SHM), left
-9/13 Seat Heating Module (SHM), right
SRM 4/33 Sunroof Module (SRM)
SRS 4/9 Supplemental Restraint System (SRS)
SUM 4/84 Suspension Module (SUM)
SWM 3/254 Steering Wheel Module (SWM)
TCM 4/28 Transmission Control Module (TCM)
TRM 4/110 Trailer Module (TRM)
UEM 4/70 Upper Electronic Module (UEM)
4/31 4/31 Fan control module
4/71 4/71 Cooling fan control module
17/13 17/13 Data link connector
TP 39130202 S60 2009 35
Page 36
Control modules
Central Electronic Module (CEM) 1:2
30+
30+
30+
11B/8
GN
BL-R
BL-R
W
53/443
BL-R
BL-R
16/65:1
A
4/28A:11
4/9:56/B:28
3/157:2
17/13
36
CAN
1411
HISPEED
3:1A_13/51
2:1A_13/51
1:1
A_13/51
4/46
GN
W
B-FuelB-Fuel
R
10/126:2
10/125:2
10/13:1
10/11:2
10/14:1
10/12:2
3/254:9
3/254:10
GN
GN
GN
GN
54/22
9
54/23
9
RR
R
53/399
1
1
R
11B/16 11B/17
2
2
6/3:1
6/4:1
6/127:1
6/127:2
9/1:2
9/25A:1
1
1
11B/20
2
2
3/6:1
3/6:3
16/10:1
16/11:1
4/46B:33
4/46B:23
4/46B:26
4/46B:48
4/46B:38
R-SB
R-SB
DIESEL
W/O DIESEL
DIESEL
DIESEL
54/4
1
2
16/60:17
16/65:3
16/65:2
8/37A:3
3/10:1
MAN
4/58A:18
4/9B:2/30
6/39:2
6/38:2
2/64:1
9/25A:2
8/134:3
3/156A:3
6/62:4
6/63:4
4/46B:37
4/46B:41
4/58A:13
4/118A:1
6/62:12
6/63:12
MAN (M66)
AUT
BL-R
W/O DIESEL
DIESEL
HCM
GN
GN-W
ACC
54/23
6
54/22
6
54/8
2
O
54/10
2
54/11
2
54/10
7
54/11
7
W
W
GN
GN-W
Y-R
Y
Y-W
Y-SB
Y
Y-R
BL
VO
BL-R
Y-W
Y
R-SB
R-SB
R-W
R
BL-OR
GN-R
Y-GR
Y-GR
W-SB
Y-W
BL
GR
BL-YAW55-51SN / AW51 AWD
Y-GR
GN-Y
Y-W
GN-BNGN-BN
GN-RGN-R
BN-WBN-W
Y-W
BL-W
BL-W
BL-RBL-R
BL-R
BL-R
BL-R
Y-R
Y-R
GN-W
GN
LOSPEED
BLIS
BLIS
4/56
D:40
B:24
B:16
C:5
C:15
D:1
D:2
B:31
B:32
D:7
D:17
B:30
B:21
B:29
B:2
A:17
B:3
D:14
D:22
B:15
C:35
D:19
D:56
D:57
C:28
A:15
D:20
C:11
C:12
C:9
D:12
D:23
A:8
C:14
A:23
A:4
D:55
F11
F30
F29
F16
D:48 D:33
F34
F3
A:12
BL-R
CEM
CAN
LIN
A:29
BL-R
D:16 C:14
TF-80SC(AWD)
BL-R
C:13
TP 39130202 S60 2009 36
Page 37
Control modules
Central Electronic Module (CEM) 2:2
A
4/56
BL-R
Y-W
LHD
3/1
D:60
4
30
6137
Y
D:15VOD:8
D:6
1
11E/4
2
54/16
54/22
54/23
30+
1
11E/1
2
4
1
1
BL-GN
BL-GN
3/9:1
3/9:5
4/99:2
7/149:4
2/35:4
2/35:2
2/91:4
2/90:4
2/182:4
6/1:3
7/5:1
16/65:5
10/29:1
53/437
BL
BL
54/9:4
6/38:3 / 10/1A:7
4/99:4
6/39:3 / 10/2A:7
BN
53/397
4/16:4
2/133:2
10/5:1
W
W
10/6:1
10/1A:1
10/2A:1
10/2A:2
10/1A:2
54/11:12
54/10:12
6/26:B1
4/28A:35
3/156:A1
8/134:1
10/1A:6
10/2A:6
10/1A:3/A:2, 10/11:1, 10/71:1
10/2A:3/A:2, 10/12:1, 10/73:1
6/3:2
6/4:2
9/12:4
9/13:4
54/36:5
54/36:3
54/36:1
54/36:2
7/12:4
7/12:1
7/12:5
16/35:1
16/1A:2
GN-R
GN-R
3/27:3
3/27:3
31/93
30+
R-SB
5
15X50 S
15I
53/408
VO
GR-W
GN
Bi-X
Bi-X
VO
VO
54/22
5
5
GN
GN
Bi-X
Bi-X
54/23
F10
F21
F16
F15
F33
F17
F18
F22
F23
F14
E:BE:A
F9
B:11
C:34
C:17
D:11
C:6
C:7
C:4
C:3
C:25
C:31
C:10
D:13
D:9
A:10
B:10
B:23
B:5
B:22
B:1
B:17
B:18
B:27
B:28
B:4
B:7
C:16
B:20
A:25
B:8
B:9
C:19
C:20
F2
A:19
F1
A:18
A:16
D:43
D:44
D:45
D:29
D:30
D:42
F8
B:25
A:6
CEM
CAN
LIN
SBSB
C:1 C:2
F28
A:22
RHD
D:24
B:19
1
11C/8
2
1
11C/7
2
1
11E/5
2
4/9B:27/55
3/157:1
10/1A:5
10/2A:5
R
R
54/40D
2
1
R
Y-R
GN-W
54/13
W W BL-W
BL-OR
GN-OR
GR
Y
GN-SB
BL-W
Y-GN
GN-R
W
VO-W
VO-W
VO
SB
BL
GN-GR
P
P
BL
W
BL-Y
BL-W
GN-W
GN-W
GN-W
VO-W
VO-W
VO-W
BL-GN
BL-P
W
GR
VO
VO
BL
BL
BL
GN
BL
BN
BL
Y
BN
R
VO
VO
VO
53/398
53/301
LHD
RHD
14
54/22
54/23
54/23
54/22
RHD
LHD
54/1B
54/22
54/23
54/22
54/23
54/24
54/25
54/25
54/24
R
R
ECPS
VO
BL
ECPS
VO
SB
Bi-X
7
Bi-X
7
BL-Y
3
BL-Y
3
12
AW51
AUTO
MAN (M66)
DRL
4
DRL
4
GR
2
GR
2
2
2
14
14
31/6
31/10
TP 39130202 S60 2009 37
Page 38
Control modules
Rear Electronic Module (REM) 1:2
30+
1
11E/1
2
R
4/58
K:I
REM
4/56A:23
10/127:2
10/128:2
7/156
P
3/1:8
8/85:1
4/78A:2
3/75:3
7/12:3
3/62:1
3/74:3
3/78:2
3/78:1
16/149:2
16/15:2
16/45D:1
4/82:1
4/84C:1
4/86A:1
16/145A:7
16/16:1
8/59:1
8/60:1
17/19:2
1
2
3
4
54/11
54/4
GR-R
VO
Y
Y-GR
Bi-fuel
Bi-fuel
Bi-fuel
Bi-fuel
P
Y
SUM
PAM
54/35
54/43
54/3.1
54/10
54/54
1
2
3
4
3
48
143
8
54/74
2
Y-R
W
W
GR-R
VO
Y
Y-GR
BL
BLBL
R
PP
GN
YY
PP
GR-W
BL-SB
R-W
R-W
R-W
BLBL-R
BL
BL
BL-R
R
R
Y-R
Y-R
R
Diesel
AWD
D:14
D:15
D:27
C:13
C:14
B:8
B:27
A:13
D:2
D:11
D:8
A:29
B:15
B:22
D:29
C:1
C:4
C:12
F:8
F:2
A:14
A:30
B:21
A:15
A:16
A:25
B:28
B:31
F13
F28
F6
F23
F24
F26
F17
F38
F37
CAN
LIN
F3
F27
F31
F19
F8
3/85:5
3/85:1
3/85:3
3/86:5
3/86:1
3/86:3
3/76:2
3/76:5
3/76:8
3/76:6
3/76:4
P
BL
VO
GR
Y
54/21
8
5
6
GN-BNGN-BN
YY
BL
54/20
8
5
6
54/20
3
4
9
10
11
GN-BNGN-BN
YY
BLBL
54/43
8
7
1
P
BL
VO
GR
Y
GN-W
Y
GN-BN
Y
BLBL
A:1
A:19
A:2
B:1
B:30
B:2
C:3
C:5
A:27
A:24
A:23
D:26
D:31
F10
F9
F28
7/100
1
ISM
30
2
A:32
SB
31/47
D:12
53/602
SB SB
31/72
TP 39130202 S60 2009 38
Page 39
Control modules
Rear Electronic Module (REM) 2:2
4/58
REM
CAN
LIN
BL
B:25
F2
D:1
Y-R
GR
54/54
Y-R
1
7
54/106
Y-R
Y-R
Y-R
PEM
Bi-Fuel
Bi-Fuel
Bi-Fuel
6/31
8/89:1
8/90:1
8/88:1
10/18A:1,10/17A:1,(10/49,10/42)
Bi-X
C:11
C:6
C:9
B:23
D:5
D:6
F:3
F:10
F:5
A:6
A:18
B:3
GN-R
GR
BN-W
BL
GR
GR-W
GR-GN
GR
BL-BN
BN-R
Y-R
GN-Y
Y
Y
11
54/13
W/O SUM
W/O SUM
W/O SUM
54/32
1
2
3
Y-R
BL-R
GR-W
BN
W/O SUM
W/O SUM
W/O SUM
7/120
5
4
1
10/17A:3,10/48
10/17B:1,10/17B:3
10/18B:1,10/18B:3
1
2
10/3
3
3/78:4
10/19:1
4/56A:15
10/17B:4
10/18B:4
F1
F28
F27
F29
F30
F20
B:7
B:10
B:11
B:4
B:9
B:26
D:33
D:28
B:24
B:12
A:20
A:21
D:32
E:A
E:B
E:C
E:D
E:E
F7
E:G
E:J
E:K
E:L
E:M
E:H
E:F
BL
GN-W
GN
P
6/37
BL-SB
M
1
YY
P
BL
VO
GR
GN
GN-W
GN-W
R
R
P
GN-R
GN-Y
Y
R
GN
GN-W
GR
R
R
BL
Y-SB BL
BL-Y
R-W
2
13 POLE
7 POLE
7 POLE
13 POLE
54/43
2
5
11
6
3
13 POLE / 7POLE
USA 4-POLE
13 POLE
13 POLE / 7POLE
USA 4-POLE
53/735
Y
P
BL
VO
GR
7
7
54/11
54/10
54/21
11
3
4
9
10
Y
P
BL
VO
GR
GN-W
GN
10/18A:3,10/51
10/17A:2
10/18A:2
10/18B:2,10/17B:2
3/77:4
3/77:2
3/77:5
3/77:8
3/77:6
6/63:12
6/62:12
4/86A:12
4/86A:12
4/110A:6, 4/110A:12, 26/4:4
4/110B:2
4/110A:11
4/110A:9
4/110B:1
17/39:9
4/110B:5
4/110B:3
4/110B:4
4/1
10A:7
4/110A:7, 4/110A:8
17/39:8
4/110A:2, 17/38:2
17/39:10
TP 39130202 S60 2009 39
Page 40
Control modules
High speed CAN data communication
4/50
ETM
CAN
GN
MAN
W
3
4
4/46
AUTO
GN
W
ECM
CAN
DIESEL
Bi-Fuel
AUTO
B:22
B:23
B:13
B:1
B:2
B:14
W
GN
4/28
TCM
AW55-51SN
AW51AWD
CAN
W
GN
A:37
A:55
B:13
B:1
4/46
MAN
MAN
AUTO
AUTO
ECM
CAN
5 CYL
W
W
GN
GN
W
GN
17/13
3/254
4/68
CAN
SWM
SAS
CAN
6
14
W
GN
4/56
D:33
D:48
CEM
CAN
LIN
4
3
W
GN
DSTC
DSTC
D:31
D:46
C:21
53/430
C:22
53/431
HS CAN
High
Low
4/84
4/118
4/82
SUM
CAN
HCM
CAN
DEM
CAN
A:16
A:15
A:4
A:3
7
8
4/28
TCM
CAN
TF-80SC
(AWD)
W
GN
W
GN
GN
W
A:14
A:6
GN
W
DIESEL
DIESEL
54/74
1
3
54/57.1
7
6
FOUR-C
FOUR-C
GN
W
53/353
53/352
GN
W
53/567
53/568
W
GN
GN
W
W
GN
GN
W
HCM AWD/
HCM AWD/ FOUR-C
AWD W/O FOUR-C W/O HCM
AWD W/O FOUR-C W/O HCM
AWD
AWD
FOUR-C
FOUR-C
FOUR-C
AUTO
AUTO
FOUR-C
FOUR-C
GN
W
GN
53/585
W
53/584
W
GN
7/164
BSC
CAN
4/16
BCM
CAN
11
W
GN
11
12
15
54/3.1
29
25
DSTC
54/3.1
22
21
W
GN
DSTC
DSTC
2
W
1
GN
2WD HCM
2WD HCM
2WD W/O HCMDSTC
2WD W/O HCM
W
GN
D:47
HCM W/O FOUR-C
HCM W/O FOUR-C
D:32
TP 39130202 S60 2009 40
Page 41
Control modules
Low speed CAN data communication
4/56
CEM
53/517
CAN
53/516
D:37
D:52
D:39
D:54
D:38
D:53
D:34
D:49
W
GN
W
GN
54/10
3
4
54/13
5
6
W
GN
W
GN
W
GN
4/9
B:24/52
B:26/54
3/126
DDM/PDM
A:2
A:3
4/70 16/60
3
5
W
GN
SRS
CAN
CAN
UEM
CAN
B:23/51
B:25/53
16/1
5/1
8
7
AUM
CAN
PHM
1
2
4
5
7
8
0#
CAN
DIM
CAN
3/112
CCM
C°/F°
W
GN
A:7
A:8
3
22
6
10
9
W
GN
W
GN
53/433
W
GN
A:10
A:8
A:11
A:9
CAN
53/434
3/127
45/11
W
GN
9
10
GN
W
W
3
GN
4
PDM/DDM
A:2
A:3
CAN
LS CAN
High
Low
53/435
D:40
D:55
D:36
53/436
D:51
D:35
D:50
W
GN
17/13
4/78
16/45
W
GN
AEM
CAN
RTI
3
CAN
11
4/52
54/24 LHD
54/25 RHD
12
11
W
GN
PSM
B:2
B:3
CAN
4/58
C:14
C:13
D:30
D:19
REM
53/663
A:4
A:3
W
GN
W
GN
53/664
CAN
D:4
D:3
GN
W
D:20
D:21
CAN
TP 39130202 S60 2009 41
Page 42
Control modules
LIN data communication 1:2
4/28
TCM
AW50/51
B:21
GN-W
54/3.1
5
GN-W
A:2
3/156
GSM
3/155
4/28
TF-80SC
(AWD)
4/7
GN-W
LIN
TCM
LIN
CPM
LIN
6
A:7
GN-W
54/57.1
3
16/35
2
SCM
LIN
27/4
27/3
RCM
LIN
LCM
LIN
GN-W
DIESEL
54/3.1
15
7/149
5
5
54/11
GN-W GN-W
54/10
GN-W GN-W
4/56
C:16
RSM
LIN
12
12
CEM
P
GN-W
1
D:24
W
RHD
LHD
54/13
15
W/O Sunroof
54/16
1
GN
LIN
4/33
SRM
PP
A:4
LIN
P
P
4/70
UEM
21
13
LIN
3/111
LSM
A:1
B+
/26
6
ACM
G
LIN
B:1
54/9
6
GN-W
C:32
D:41
GN-W
D:58
LIN
GN-W
3
LIN
3/4
SWSL
31
GN-W
GN-W
54/1B
12
GN-W
EXC. DIESEL
4/46
A:88
ECM
LIN
DIESEL
3/131
SWSR
LIN
LIN
2
A:2
4
18/4
3/254
SWM
7
LIN
TP 39130202 S60 2009 42
Page 43
Control modules
LIN data communication 2:2
4/9
3/112
9/13
SRS
LIN
CCM
LIN
SHM
C:1/57
A:12
A:7
GN/W
GN-W
GN-W
54/25
7/93
OWS
USA/CDN
54/25
10
E
LIN
6/69 MCC
6/48 RHD
6/95
6/103 ECC
DMM
2
Y-G N
LIN
Y-G N
7/159 RHD
AQS
2
LIN
6/48 LHD
ECC
GN-W
GN-W
54/132
2
5
GN-Y
Y
Y
53/461
RHD MCC
53/460
6/96
ECC
4A:2
6/102
DMM
9/12
4/58
LIN
SHM
LIN
REM
LIN
D:26
D:32
A:2
54/24
4
GN-W
GN-W
4/118
HCM
Y
2
LIN
7/159 LHD
ECC
AQS
2
Y
LIN
7/100
ISM
2
LIN
4/86
PAM
A:12
LIN
10/1
LHCU
LIN ABL
A:7
54/22
12
54/3.1
13
A:5
GN-WGN-W GN-W GN-W
LIN
A:7
54/3.1
25
54/23
12
A:7
10/2
RHCU
LIN ABL
TP 39130202 S60 2009 43
Page 44
Group 23 Fuel system
Engine management system, 5-Cyl. 1:2
30+
15/31_A1:2
R
1
11B/19
2
GN-OR
11
11B/11
2
BL-R
R
2/32
FMA3
2(85)
4
2
1(86)
Y
1
11B/10 11B/12
2
2
GN
GN-W
5 2 14 3
GN
GN-W
3(30)
5(87)
11B/13
2
GN-SB
GN
GN-W
1
3
Y
11
11B/15
2
GN-GR
54/1B
GN-GR
8/6
8/7
8/8
8/9
8/10
7/17
7/81
7/16
7/8
P
P
7/35
QLT
7/6
MAF
P
R
A
Y-W
2
1
2
1
2
1
2
1
2
1
1
2
3
4
5
2
1
3
1
2
1
3
2
1
GN
GN
GN
GN
GN
GN
GN
BN-SB
BN-SB
VO-W
GR-R
BN-SB
BN-SB
VO-W
BN-GR
3
VO-W
2
BN-SB
1
BL-W
BN-SB
7/24
7/25
53/315
4/71:4
53/332
Ag
1
BN-SB
2
Ag
SB
1
R
2
W
53/319
BL-W
BN-W
Y-W
P-W
GN
VO-W
VO
VO
GN-R
GR-W
GN-R
BN-SB
VO-W
A:16
A:32
A:15
A:33
A:70
A:14
A:7
A:60
A:22
A:23
A:40
A:61
A:58
A:21
A:68
A:39
A:46
A:64
A:48
A:66
A:4
4/46
ECM
5 CYL
W/O T
B
CAN
9/32
GN-W
4
20/3
SB
53/309
SB
31/88
GN-GR
2
1
SB
SB
SB
SB
3
20/4
31
20/5
20/6
20/7
6/120
31/89
ETA
53/314
2
1
GN-W
4
2
GN-W
4
2
13
GN-W
4
2
13
GN-W
4
2
13
1
2
3
Au
4
Au
5
Au
M
6
Au
53/328
R-W
R-W
R-W
R-W
R-W
GN
GN
SB
BL-R
53/326
53/360
SB
31/96
BL
BN
R-W
Y
P
VO
BL-R
GN-Y
W
GN
BN
GN-SB
SB
SB
SB
SB
A:31
A:30
A:28
A:29
A:51
A:50
A:35
A:36
A:43
A:25
A:5
A:6
A:34
A:52
A:53
A:54
A:62
A:17
C
TP 39130202 S60 2009 44
Page 45
Group 23 Fuel system
Engine management system, 5-Cyl. 2:2
30+
1
11C/8
2
1
11C/7
2
11
11E/5
11E/4
2
11E/1
2
30+
30+
1
2
A
B
4/46
ECM
CAN
5 CYL
W/O T
B:38
B:11
B:26
B:23
B:37
B:8
B:46
R
Y-W
Y-GR
GN-R
BL-R
Y
GR
3/1
54/3.1
18
R-SB
30
50 S
7
53/443
4/56
B:11
C:34
D:16
D:60
C:35
C:21
C:22
C:5
F9
CEM
CAN
LIN
C:14
A:16
BL
R
3/9
4
5
15X
15I
1
BL-R
1
5
Y-R
BL-R
Y-W
R
2
R
E:A
E:B
B:16
D:43
D:44
D:45
R
54/40D
1
11B/8
2
R
R
GN
BL
BN
15/31_A1:3
R-W
11
11B/7
2
7/73:1
GR
5/1:2
C
B:44
B:15
B:4
B:29
B:1
B:13
B:48
B:5
B:17
B:9
B:25
BN
W
SB
GR-R
BN-SB
GR-W
BL-W
BL-R
53/305
GN-W
AUTO
MAN MAN
53/324
MAN
MAN
BL-R
53/329
53/397
BL-R
SB
BN
BN
BN
6/62
SB
M
y F
M
x
SB
BN
54/3.1
7/123
2
4
6
W
7
M
7/105
LHD 3 / RHD 4
LHD 2 / RHD 5
LHD 1 / RHD 6
LHD 5 / RHD 2
LHD 6 / RHD 1
LHD 4 / RHD 3
31/93
2/22:4
54/10
6
5
7/51
BNBN
OR-W
6/44
2 3
2
M
1
54/36
5
4
3
2
1
SB
6/33
PE
31/48
TP 39130202 S60 2009 45
Page 46
Group 23 Fuel system
Engine management system, 5-Cyl. Turbo 1:2
30+
15/31_A1:2
R
1
2
11B/19
R
2/32
FMA3
2(85)
4
3(30)
23
GN-OR
11B/11
2
5(87)
1(86)
Y
11
2
GN-W
5 2 3
9/32
GN
R
A
Y-W
B
A:38
A:16
A:34
A:15
A:33
A:17
A:14
A:26
A:22
A:58
A:5
A:23
A:4
A:60
A:39
A:68
A:3
A:2
A:40
A:31
A:46
A:64
A:45
A:67
A:30
A:48
A:66
A:50
A:7
A:52
A:51
A:36
A:19
A:59
A:35
A:20
A:1
A:53
A:54
A:63
4/46
ECM
CAN
5 CYL
T
GN-GR
8/28
8/6
8/7
1
8/8
8/9
8/10
Y
1
1
11B/15
11B/1211B/10
2
2
7/17
7/165
GN-GR
54/1B
GN-GR
53/309
7/16
7/8
P
7/156
B5244T5
B5254T2 USA
B5254T2 KOR
7/35
QLT
20/3
SB
GN-GR
1
2
SB
31/88
SB
SB
SB
SB
20/4
20/5
20/6
20/7
31/89
1
2
2
1
2
1
2
1
2
1
2
1
MAF
2
5
3
4
1
P
2
3
4
1Ag
Ag
2
1
3
2
1
P
2
3
4
Ag
1
Ag
2
Ag
3
GN-W
4
GN-W
2
31
31
31
31
BL
4
GN-W
2
13
BN
4
GN-W
2
Y
GN-W
4
2
P
GN-W
4
2
VO
6/120
GN
GN
GN
GN
GN
GN
GN
GN
VO
GR-W
VO-W
BN-SB
GN-R
VO-W
Y
GR-R
BN-SB
BN-SB
VO-W
BN-P
BN-SB
GN-R
VO-W
GN-GR
BL-W
BN-SB
VO-W
ETA
53/328
Au
Au
Au
Au
Au
Au
7/24
7/23
7/25
1
2
3
4
5
6
53/315
7/6
P
53/319
1
2
1
2
1
2
1
BL-R
GN-Y
W
GN
BN
GN-SB
53/326
53/332
54/53
1
2
3
4
4/71:4
SB
BL-W
BN-W
Y-W
P-W
GN
VO-W
BN-SB
BN-SB
SB
BN
Y-SB
R
W
BN-SB
VO-W
VO
SB
SB
SB
BL-R
31/96
C
TP 39130202 S60 2009 46
Page 47
Group 23 Fuel system
Engine management system, 5-Cyl. Turbo 2:2
30+
1
11C/8
2
1
11C/7
2
11
11E/5
11E /4
2
11E/1
2
30+
30+
1
2
A
B
4/46
ECM
CAN
5 CYL
R
Y-W
B:38
B:11
B:26
B:23
T
B:37
B:8
B:46
B:44
B:47
B:15
B:4
B:29
B:1
B:13
Y-GR
GN-R
BL-R
Y
GR GR
GN-W
YY
SB
BN
MAN
BN
W
3/1
50 S
54/3.1
18
MAN
MAN
AUTO
MAN
53/324
R-SB
30
7
4
5
15X
53/443
1
BL-R
BN
BN
6/62
15I
5/1:2
M
y F
M
x
7/73:1
2/22:4
54/3.1
6
7
M
54/3.1
8
7/123
2
4
W
3/9
54/10
6
5
1
BNBN
OR-W
5
Y-R
BL-R
Y-W
4/56
F9
B:11
R
R
R
CEM
15/31_A1:3
R-W
54/40D
R
Y-R
GN
BL
BN
4/83
SB
53/579
BL
6/31
BN
1
R
PEM
GN
8
11B/8
3
BL
11B/7
2
4/58
REM
CAN
LIN
B:25
B5244T5
B5254T2 USA
B5254T2 KOR
541 2
W-SB
W
42
PE
312
C:13
9
10
11
2
C:14
6/33
2
CAN
C:34
D:16
D:60
C:35
C:21
C:22
C:5
LIN
F29
A:16
C:14
BL
54/36
6
5
4
3
2
1
2
3
SB
R
E:A
E:B
B:16
A:23 A:13
D:43
D:44
D:45
Y
BL
SB
SB
7/105
B:48
SB
C
B:5
B:17
B:9
B:25
GR-R
BN-SB
GR-W
BL-W
BL-R
53/305
BL-R
53/329
BL-R
SB
53/397
LHD 3 / RHD 4
LHD 2 / RHD 5
LHD 1 / RHD 6
LHD 5 / RHD 2
LHD 6 / RHD 1
LHD 4 / RHD 3
SB
BN
7/51
2
6/44
6/33
PE
M
1
31/93
31/48
TP 39130202 S60 2009 47
Page 48
Group 23 Fuel system
Engine management system, Bi-Fuel 1:2
30+
9/32
15/31_A1:2
R
1
R
11B/19
2
GN-OR
Y
1
2
GN-GRGN-GR
3 2 14 5
54/1B
53/309
GN-GR
2
1
SB
11B/1211B/15
2
GN
2/32
FMA
2(85)4
3(30)
2
1(86)
5(87)
11
11B/13
11B/10 11B/11
2
2
GN-W
GN-SB GN-SB
GN-W
R
Y-W
BL
BN
R-W
P
VO
VO
BL-R
GN-Y
SB
SB
SB
A:16
A:34
A:15
A:33
A:70
A:14
A:60
A:22
A:23
A:40
A:61
A:58
A:21
A:43
A:39
A:46
A:64
A:48
A:66
A:31
A:30
A:28
A:29
Y
A:51
A:50
A:56
A:38
A:37
A:55
A:36
A:53
A:54
A:62
SB
CAN
2
1
2
1
2
1
2
1
2
1
1
2
3
4
5
1
2
3
1
2
1
3
2
1
2
3
1
4
2
1
4
2
13
4
2
4
2
4
2
7/24
7/25
GN-W
GN-W
GN-W
GN-W
GN-W
GN
GN
GN
GN
GN
GN
GN
BN-SB
GN-R
BN-SB
VO-W
BN-SB
BN-SB
VO-W
BN-GR
VO-W
GN-R
BN-SB
1
2
1
2
53/328
53/315
53/332
R-W
R-W
R-W
R-W
R-W
4/71:4
1
2
3
4
5
6
BN
W
GN
53/326
SB
8/6
8/7
3
1
3
8/8
8/9
8/10
Y
11
2
7/17
7/81
MAF
P
7/16
7/8
P
7/201
P
7/6
P
20/3
SB
3
20/4
SB
31/88
31/89
20/5
SB
31
20/6
31
SB
20/7
31
SB
4/50
ETM
53/319
HISPEED
BL-W
BN-W
Y-W
P-W
GN
VO-W
VO
GN-R
GR-W
GR-R
BN-SB
VO-W
BN-SB
BN-SB
SB
R
W
53/360
A:4
A:7
A
B
4/46
ECM
CAN
5CYL
W/O T
Bi-Fuel
31/91
BL-R
31/96
SB
C
D
GN-GR
GN-GR
TP 39130202 S60 2009 48
E
F
Page 49
Group 23 Fuel system
Engine management system, Bi-Fuel 2:2
30+
5
15X
53/443
1
BL-R
VO
1
11C /7
2
15I
1
2
8/75
BL-R
Y-W
3/9
1
5
R
Y-R
GN-GR
B:11
C:34
D:16
D:60
C:35
C:21
C:22
C:5
C:14
A
B
4/46
ECM
CAN
5CYL
W/O T
Bi-Fuel
B:38
B:11
B:26
B:8
B:23
B:37
B:39
B:1
B:13
R
Y-W
VO
Y-GR
Y
GN-R
BL-R
54/7
1
3/1
30
50 S
7/73:1
1
11C/8
2
R-SB
4
7
4/56
F9
CEM
CAN
LIN
F29
A:23
11
11E/5
2
R
54/40D
2
R
E:A
E:B
B:16
R
A:16
BL
D:45
BN
D:44
BL
SB
11E /4
54/36
6
5
4
3
2
1
R
1
R
11E/1
2
30+
1
2
1
6/33
11B/8
2
30+
15/31_A1:3
R-W
1
11B/7
2
P
C
D
E
F
B:15
B:4
B:29
B:44
B:46
B:48
B:32
B:50
B:5
B:17
B:9
B:25
SB
BL-R
GN-GR
GN-GR
MAN
GN-W
GR
SB
W
P-SB
GR-R
BN-SB
GR-W
BL-W
BL-R
SB
BN
BN
W
MAN
MAN
C:14
C:13
54/3.1
18
53/329
53/39753/305
4/58
54/7
3
2
BN
AUTO
MAN
53/324
REM
CAN
LIN
GR
SB SB
BN
BL-R
2/22:4
5/1:2
3/LHD 4RHD
2/LHD 5RHD
1/LHD 6RHD
5/LHD 2RHD
6/LHD 1RHD
4/LHD 3RHD
A:13
B:25
7/123
2
4
BN
W
P-SB
7/51
31/93
6/62
M
M
y F
M
x
54/3.1
6
7
54/10
BN BN
6
W
Y-R
Y-R
5
OR-W
Y-R
54/106
7/105
3
2
Y-R
1
2
7
8
SB
Y-R
SB
Y-R
SB
1
2
1
2
1
2
8/89
8/90
8/88
54/54
SB
SB
53/604
2
6/105
1
2
M
3
4
6/44
M
SB
1
31/73
31/48
TP 39130202 S60 2009 49
SB
Page 50
Group 23 Fuel system
Engine management system, 5-Cyl. Diesel 1:3
30+
1
11A/1
2
30+
15/31_A1:2
R
1
11B/19
2
GN-OR
1
11B/10
2
GN-W
54/1B
2/32
2(85)
1(86)
FMA3
3(30)
5(87)
1
1
3
Y
1
4
2
1
11B/12 11B/13 11B/11 11B/15
2
2
GN
GN-SB
2
BL-R
54/146 11L/1
RR
1
8/6
8/7
8/8
8/9
8/10
Y
1
7/25
1
7/190
2
2
11B/14
7/191
7/16
GN-GR
3
GN-BN
72
7/8
7/17
P
MAF
1
2
1
Au
2
Au
30+
1
2
3
YR-W
A
4/46
W-SB
1
Au
2
W
Au
P-SB
Au
1
2
P
Au
Y-VO
Au
1
2
Y
Au
1
Au
BL-SB
2
BL
Au
1
Au
GN-SB
2
GN
Au
GR-R
GR
4
3
2
1
54/100
1
2
Au
1
Au
2
Au
1
Au
2
GR-R
GR
W
BN
W
GN
GR-R
BN-SB
BN-SB
BN-GR
VO-W
GR-W
GR-R
BN-SB
GN
A:1
A:50
A:25
A:75
A:3
A:74
A:2
A:73
A:26
A:49
A:77
A:53
A:84
A:62
A:58
A:8
A:60
A:56
A:76
A:79
A:43
A:86
A:59
A:29
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
ECM
CAN
LIN
DIESEL
54/1C
4/109
R
1
R
11 10 9 7 6
GCU
4 3 2 1
5
7/15
8/64
8/113
8/120
6/143
6/26B:1
Au
GR
4
O
2
3
5
1
2
SB
6
1
2
1
2
1
Au
2
Au
3
Au
4
5
6
Au
1
2
3
M
4
GN-BN
Au
Au
Au
Au
Au
BL-R
GN-GR
GN-GR
GN-GR
MAN
GN-GR
OR-SB
MAN
Y
GN-W
GN-GR
BN-SB
Ag
Ag
Ag
GN-GR
BN-SB
GN
GN-W
WW
GN-ORGN
ORR
SB
53/335
YY
BL-GR
GN
BN
A:48
A:6
A:80
A:57
A:31
A:32
A:90
A:37
A:46
A:92
A:66
A:71
A:28
A:9
A:21
A:88
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
R-W
R-W
R-W
R-W
R-W
GN-SB
1
7/162
7/165
1
1
1
1
1
20/22
20/23
20/24
20/25
20/26
Au
P
2
Au
3
Au
1
P
2
4
3
BL-R
GN-SB
GN-W
Y-W
GN-Y
GN-W
Y-SB
Y-W
Y
A:64
A:65
A:19
A:87
A:85
A:82
A:15
Ag
Ag
Ag
Ag
Ag
Ag
Ag
B
C
D
TP 39130202 S60 2009 50
Page 51
Group 23 Fuel system
Engine management system, 5-Cyl. Diesel 2:3
30+
1
11C/7
2
15/31_A1:3
4/56
F9
B:11
R
3/9
1
5
15X
1
BL-R
15I
5
Y-R
BL-R
Y-W
C:34
D:16
D:60
C:15
C:21
C:22
C:35
C:5
CEM
CAN
LIN
C:14
4/28
TCM
A:5
CAN
A
4/46
ECM
CAN
LIN
DIESEL
1
11C/8
Y-W
B:42
Ag
SB
B:2
Ag
Ag
Ag
B:4
B:6
SB
53/395
SB
SB
3/1
2
R-SB
4
30
50 S
7
53/443
31/2
W-SB
B:38
Ag
Y-GR
B:48
Ag
B:33
Ag
Ag
Ag
BL-OR
BL-R
B:41
YY
B:34
54/57.1
5
11B/8
B:16
E:A
E:B
D:43
D:44
D:45
A:16
2
R
1
11E/4
4/58
30+
1
R
REM
CAN
LIN
54/35
11E/1
2
K:1
F13
C:13
C:14
B:15
54/35
8/85
2
SB
4
SB
BL
3
BL
1
30+
11
11E/5
2
R
R-W
1
2
54/40D
R
R
R
2
GN
BL
BN
BL
53/604
VO
B:58
Ag
GR GR
B:37 2
Ag
GN-OR
B:29
Ag
BL-OR
B:44
Ag
SB
B:12
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
B
C
B:40
B:32
B:35
B:23
B:22
B:7
B:24
B:15
B:47
B:1
B:3
B:5
BN
GN-W
Y
BN-SB
GR-W
GR-R
BL-W
GN-SB
GN-SB
GN-W
BL-R
GN-SB
54/3.1
MAN
MAN
53/394
18
BL-R
53/329
53/305
4/71:4
SB
53/397
5/1
2/35:2
2/35:4
DIM
CAN
7/123
2
4
54/36
6
5
4
3
2
1
2/22:4
7/51
3/LHD 4RHD
2/LHD 5RHD
1/LHD 6RHD
5/LHD 2RHD
6/LHD 1RHD
4/LHD 3RHD
SB
SB
BN
7/73
1
SB
2
6/33
PE
SB
D
31/93
31/48
31/73
TP 39130202 S60 2009 51
Page 52
Group 23 Fuel system
Engine management system, 5-Cyl. Diesel 3:3
4/46
7/154
7/174
P
7/173
8/98
7/166
QLT
6/118
ECM
1
Au
2
Au
1
Au
2
Au
3
Au
1
2
3
1
Au
2
Au
Ag
1
Ag
2
Ag
3
1
2
3
4
5
Y-GR
BN
BN
GR
BL-SB
BL-Y
BL
GR-R
GR
BN-GR
BN-SB
VO-W
GR
GR-R
VO-W
BN-P
BN-SB
W
A:61
A:78
A:44
A:63
A:41
A:10
A:33
A:7
A:23
A:93
A:34
A:36
A:42
A:4
A:5
A:81
A:40
A:52
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
Ag
CAN
LIN
DIESEL
6/120
ETA
8/111
1
Au
4
Au
2
Au
3
Au
6
Au
1
Au
M
2
Au
BN
GN-SB
BN-SB
GN-R
VO-W
GR-R
GR
A:24
A:72
A:67
A:18
A:11
A:47
A:94
Ag
Ag
Ag
Ag
Ag
Ag
Ag
TP 39130202 S60 2009 52
Page 53
Group 23 Fuel system
Emission control, 5-Cyl.
R
2/32
1
3(30)
3
5(87)
Y
11
11B/14
54/1B
11B/15
22
GN-GR
37
FMA3
1(86)
2(85)
11B /19
2
4
30+
15/31_A1:2
R
1
2
GN-OR
Y-W
GN-GR
54/3.2
1
2
C:21
C:22
4/56
CEM
CAN
LIN
GN-GR
GN-R
GN-BN GN-BN
8/19
8/18
7/15
7/82
7/172
54/34
2
R-SB
2
3
GN
A:12
A:2
4/46
ECM
CAN
B:38
B:34
GN-R
GN-GR
1
GN-GR
2
Y-R
1
GN-GR
2
BL-GN
53/309
6/67
54/34
1
4
M
1
BL-SB GN-GR
3 4
5 CYL
W/O T
B:40
GN
A:69
GN-BN
GN-BN
1
2
O
2
O
2
1
2
3
4
3
1
2
4
3
BL-R
GN-R
Y-W
GN-BN
BL
GN
BN-SB
Bi-Fuel
53/304
BN-SB
A:18
A:42
A:41
A:11
A:24
A:61
B:7
BL-SB
53/319
Bi-Fuel
R
Bi-Fuel
SB
BL
Bi-Fuel
A:57
A:65
A:47
B:1
B:13
3
4
GN
BL-SB
TP 39130202 S60 2009 53
Page 54
Group 23 Fuel system
Emission control, 5-Cyl. Turbo
1
2/32
3(30)
30+
4/56
C:21
C:22
CEM
CAN
LIN
15/31_A1:2
R
R
1
11B/19
2
FMA3
1(86)
GN-OR
2
8/81
8/19
8/18
2(85)
4
Y-W
54/3.2
1
2
GN-GR
GN-R
54/34
B:38
B:34
2
R-NG
R-SB
2
6/67
1
RG-NG
4
3
2
NB-NG
11B/14
Y
11
11B/15
2
RG-NG
5(87)
GN-GR
4/46
54/1B
GN-BN
2
1
GN-W
GN-GR
37
ECM
RG-NG
A:21
CAN
M
1
2
1
2
GN-GR
Y-R
GN-GR
W
53/309
A:13
A:9
5 CYL T
B:40
GN
3
GN
3
NG
54/34
3
1
BS-LB
4
7/15
7/82
B:7
BL-SB
53/304
A:18
A:42
A:41
A:28
A:24
A:6
A:61
A:62
B:1
B:13
A:29
A:65
A:47
A:27
R
SB
BL
BL-SB
4
3
O
2
Ag
5
Ag
1
Ag
2
Ag
6
2
1
O
2
4
3
W
GN-BN
Y
GN-SB
BL-SB
GN-R
GN-R
GN-BN
SB
GR
4
53/375
53/376
BL-SB
7/172
R
SB
R
SB
1
2
3
1
2
3
7/173
TP 39130202 S60 2009 54
Page 55
Group 26 Cooling system
Cooling fan
30+
1
11A/2
2
R
4/46
ECM
5 Cyl T
4/71
7/16
7/8
P
1
2
1
2
3
BN-SB
BN-SB
BN-P
VO-W
53/319
BN-SB
GR-R
VO-W
A:4
A:60
A:68
A:39
53/332
VO
2
4
54/1B
13
Bi-Fuel / 5 CYL W/O T
VOVO
A:7
B:1
B:13
A:7
CAN
4/46
ECM
6/29
31/2
5 Cyl W/O T
Bi-Fuel
1
7/16
7/8
P
1
2
1
2
3
GR-R
BN-SB
BN-SB
BN-GR
VO-W
53/319
BN-SB
VO-W
A:40
A:61
CAN
A:21
A:58
53/332
SB
B:1
B:13
TP 39130202 S60 2009 55
Page 56
Group 26 Cooling system
Cooling fan, Diesel
30+
1
11A/2
2
R
4/46
ECM
6/29
4/71
7/16
1
2
7/8
2
4
1
1
P
2
3
GR-R
BN-SB
BN-SB
BN-GR
VO-W
VO
A:60
A:56
A:76
A:79
A:43
B:58
B:23
B:22
DIESEL
CAN
31/96
SB
TP 39130202 S60 2009 56
Page 57
Group 27 Engine controls
Cruise control
53/438
BN
4/56
CEM
CAN
C:34
6/120
6/120
30+
R
F9
ETA
ETA
1
11C/7
2
53/425
D:32
D:47
B:11
M
M
D:58
C:21
C:22
D:34
D:49
1
2
R
GN-W
R
Y-R
BN
1
2
3
4
5
6
1
2
3
4
5
6
11C/9
3/9
5CYL T
5CYL T
5CYL T
5CYL T
5CYL T
5CYL T
5CYL W/O T
5CYL W/O T
5CYL W/O T
5CYL W/O T
5CYL W/O T
5CYL W/O T
R
7
1
5
7/31
N
7/124
3/254
2
1
2
SWM
CAN
LIN
BL-R
GN-Y
W
GN
BN
GN-SB
BL-R
GN-Y
W
GN
1
3
2
8
BL-R
GN-Y
W
GN
BN
GN-SB
18/4
A:36
A:59
A:35
A:20
A:35
A:36
A:43
A:25
A:56
A:38
A:37
A:55
B:13
A:19
A:5
A:6
BN-P
Y-R
BL
GN
BN
B:1
A:1
2 -
4/46
6 +
4
ECM
CAN
30+
4/16
45
46
7
3
5
BCM
CAN
34
33
11
15
3/4
SWSL
1
2
3
4
5
LIN
B:11
B:38
B:15
B:4
BN
MAN
BN-GR
Y-GR
1
11B /19
2
GN-OR
R
Y-W
SB
BN
53/324
B:9
B:17
B:5
B:25
GR-W
BN-SB
GR-R
BL-W
1/LHD 6RHD
2/LHD 5RHD
3/LHD 4RHD
5/LHD 2RHD
4/LHD 3RHD
6/LHD 1RHD
2
4
7/51
1
2
1(86)
2
4
2(85)
7/123
MAN
BL-R
7/32
N
FMA32/32
3(30)
5(87)
11B/11
R
1
3
Y
1
2
BL-R
15/31_A1:2
11B/13
GN-SB
14
54/1B
1
2
53/305
4/28
AW50/51
53/329
TCM
CAN
B:13
B:1
B:21
B:14
B:2
GN
GN
W
W
GN-W
54/3.1
GN-W
5 A:2
3/156
GSM
LIN
31/84
4/50
ETM
CAN
LIN
5/1
Bi-Fuel
Bi-Fuel
Bi-Fuel
Bi-Fuel
SB SB
DIM
8
W
7
GN
31/93
53/397
BN
CAN
1
W
GN
GN-SB
BN
HISPEED
HISPEED
Bi-Fuel
Bi-Fuel
2
3
4
6
5
31/91
TP 39130202 S60 2009 57
Page 58
Group 27 Engine controls
Cruise control, Diesel
53/438
4/56
CEM
CAN
C:34
30+
F9
B:11
R
1
2
C:21
C:22
D:32
D:47
D:34
D:49
11C/7
53/425
D:58
R
GN-W
R
Y-R
BN
1
11C/9
2
R
3/9
30+30+
7/31
1
N
2
7/124
3/254
7
SWM
CAN
LIN
2
1
5
BN-P
Y-R
1
BL
3
GN
2
BN
18/4
8
6 +
4
2 -
4/46
B:23
ECM
B:22
CAN
4/16
45
BCM
46
7
3
CAN
5
BN-GR
34
Y-G R
33
11
15
3/4
SWSL
1
2
3
4
5
R
1
11B/19
2
GN-OR
Y-W
2
1
7/32
N
2/32
2
4
1(86)
2(85)
15/31_A1:2
FMA3
3(30)
5(87)
R
1
3
Y
1
11B /11
2
BL-R
B:42
B:12
B:40
LIN
SB
BN
MAN
MAN
2
4
7/123
DIESEL
7/51
2/LHD 5RHD
3/LHD 4RHD
1/LHD 6RHD
5/LHD 2RHD
4/LHD 3RHD
6/LHD 1RHD
8/111
B:24
B:7
1
M
2
GR-R
GR
A:47
A:94
B:15
B:47
GR-W
BN-SB
GR-R
BL-W
4/28
TCM
A:14
W
A:6
A:7
GN
GN-W
54/57.1
3
GN-W
54/3.1
GN-W
5 A:2
3/156
GSM
LIN
53/329
SB SB
BN
TF-80SC
(AWD)
CAN
LIN
BL-R
53/305
31/84
5/1
DIM
CAN
53/397
8
W
7
GN
BN
31/93
TP 39130202 S60 2009 58
Page 59
Group 32 Alternator and voltage regulator
Power supply
4/58
REM
6/25
50
M
31
CAN
LIN
4/56
CEM
CAN
LIN
1
30
R
53/3009
R
R
A:1
6/26
B+
ACM
G
LIN
B:1
GN-W
31
54/1B
12
GN-W
C:16
C:14
C:13
D:50
D:35
D:49
D:34
C:21
C:22
GN
W
4/46
DIESEL
GN-W
A:88
ECM
Ag
DIESEL
CAN
LIN
B:23
B:22
17/17
1/1
SB
12V
SB
31/53
TP 39130202 S60 2009 59
Page 60
Group 33 Starting system
Starting system
30+
1
11B/6
2
R-W
1
11B/7
2
1
2
R-SB
11C/8
30+
1
11C/7
2
GN-R GN-R
6/25
2
0
5
30
M
31
17/17
1/1
12V
54/1B
8
1
R
53/3009
R
SB
2/35
3(30)
1
3
5(87)
R
FMA1
1(86)
2(85)
6/26A:1
2
4
DIESEL
BL-OR
DIESEL
GN-OR
GN-OR
BL-OR
EXC DIESEL
EXC DIESEL
3/1
30
50 S
7
4
5
3
15I1515X
1
4/56
C:6
C:7
D:60
D:15
D:16
C:28
Y-W
Y
BL-R
BL-Y
5 CYL
AUTO
8/37
BL-R
53/443
A:3
BL-OR
GN-R
C:22
C:21
D:49
D:34
C:5
CEM
CAN
LIN
31/53
EXC. DIESEL
DIESEL
4/46
A:77
A:53
B:23
B:33
B:29
B:44
B:23
DIESEL
SB
B:22
B:13
B:1
ECM
CAN
B:12
B:15
B:4
B:40
B:34
GR-R
GR
MAN
MAN
MAN
MAN
54/100
1
2
DIESEL
PETROL
PETROL
DIESEL
Y
SB
GR-R
GR
SB
SB
BN
BN
54/57.1
5
8
SB
7/25
1
2
DIESEL
BN
53/324
Y
SB
MAN
AUTO
AUTO
PETROL
7/123
2
4
A:6
A:14
A:5
A:9
4/28
DIESEL
TCM
TF-80SC
AWD
CAN
53/329
A:9
AUTO ST- ST+
5 CYL
53/331
53/397
BN BN BN-SB
31/93
TP 39130202 S60 2009 60
Page 61
jj
Group 35 Lighting
High and low beam (Bi-Xenon) & Day running lights
30+
1
11C/7
2
1
11C/9
2
11
11E/5
2
11E /4
2
30+
30+
1
11E/1
2
R
R
53/425
3/254
8
SWM LSM
2
7
LIN
BN
R
3/111
R
R
R
15/31_A1:1
54/40D
BL
BL-R
1
R
11B/17
53/399
R
1
2
Bi-Fuel
R
1
161B/
2
4/56
F22
CEM
CAN
LIN
F23
F16
B:23
VO
D:49
D:34
GN-W
GN-W
1
3
D:58
D:41
B:27
B:8
B:7 B:4
C:1
2
R
E:A
E:B
B:2
B:3
B:28
B:9
C:2
53/398
DRL
BL
BL-GN
LIN
5
54/22
Bi-X
VO
BL-W
GR-W
11
557 74433
Bi-X
GN
54/23
VO
BL-Y
DRL
BL-P
W
53/438
BN
BN
A:4
10/2
BL
10/64
A:1
A:6
10/66
A:2
BIFUNC
GDL
A:7
W
BL-GN
BL-Y
BL
GN
A:5
DRL
Bi-X
Bi-X
W
BL-GN
BL-Y
BL
GN Bi-X
DRL
Bi-X
10/1
BIFUNC
GDL
BL
10/70
DIP DIPPOS POSDRL DRLMAIN MAIN
A:7
A:2 A:6A:5 A:1
10/68
SB
A:4
54/22 54/23
53/301
53/397
SB
10 10
SB
53/303
SBBN
SB
SB
SB
BN
31/84
31/93
31/94
TP 39130202 S60 2009 61
Page 62
Group 35 Lighting
Active headlights (ABL)
30+
3/254
4/68
1
11C/7
2
SWM
LIN
SAS
8
R
53/425
R
7
18/4
7/91
1
11C/9
2
30+
5/1
DIM
8
7
CAN
11
11E/5
2
R
11E/4
2
R
30+
1
11E/1
2
R
15/31_A1:1
54/40D
BL
BL-R
BL
BN
1
R
7/12
R
1
171B/
512
53/399
R
11B /16
2
3
Bi-Fuel
1
2
4
4/56
D:49
D:34
GN-W
GN-W
D:47
D:32
D:58
D:41
D:46
D:31
R
3/111
1
LSM
3
CEM
CAN
LIN
F16
A:4
Y-R
2
R
E:A
E:B
B:2
B:3
D:29
D:42
2
BN
CAN
BN
53/438
4
3
10/1
LHCU
LIN ABL
A:1
4/118
A:3
A:4
A:7
GN-W
54/3.154/3.1
54/2354/22
GN
W
25
GN-W
12
A:7
10/2
RHCU
LIN ABL
HCM
LIN
GN-W
5
13
GN-W
12
A:7
BN
A:5
CAN
LIN
A:6
BN
31/84
TP 39130202 S60 2009 62
Page 63
Group 35 Lighting
Fog lights
30+
1
11C/9
2
R
1
11C/7
2
3/111
LSM
5/1
DIM
30+
1
1
7
8
2
R
RR
1
11E/511E/4
2
11E/1
2
53/438
53/425
10/5
R
1
2
CAN
54/40D
1
4/56
CEM
BN
5
LIN
3
GN-W
D:41
B:17
A:15
CAN
LIN
F17
F18
D:34
D:49
E:B
E:A
B:18
D:35
D:50
R
W
GN
10/6
1
P
1
P
4/58
2
GN-Y
A:18
REM
C:13C:13
C:14
K:1
K:1
R
2
BN
53/301
53/397
CAN
SB
SB
P
10/18
SB
BN
B:2
10/53
A:1 A:2 A:3
53/601
B:6
A:4
SB
SB
B:4
LIN
P
53/303
BN
A:4
SB
10/17
B:6
A:3 A:2 A:1
B:2
10/46
53/604
SB
31/84
31/93
31/72
31/73
31/94
TP 39130202 S60 2009 63
Page 64
Group 35 Lighting
Brake lights
30+
1
2
11E/1
1
2
RR
11E/5
5/1
DIM
CAN
8
7
10
9
D:49
D:34
E:A
D:35
D:50
4/56
CEM
CAN
LIN
F9
B:11
C:34
A:15
GN-Y
R
3/9
Y-R
54/13
Y-R
11
1
Y-R
1
5
10/19
2
54/40D
R
GN
W
4/58
C:13
C:14
REM
K:I
CAN
LIN
A:18
A:6
B:3
5
BN
53/503
BN
10/18
Y
10/50
B:4
B:6
Y
10/17
SB
53/601
31/72
53/604
SB
SB
31/73
SB
B:6
B:4
10/43
31/98
20
54/13
BN
BN
31/83
TP 39130202 S60 2009 64
Page 65
Group 35 Lighting
Reversing lights
30+
Y-GR
C:28
4/56
CEM
CAN
LIN
A:15
C:22
C:21
D:35
D:50
GN-Y
GN
4/28
TCM
CAN
LIN
B:1
B:13
B:2
B:14
1
11E/1
2
4/58
A:18
REM
C:14
W
C:13
CAN
LIN
K:1
R
F1
3/10
Au
Au
MAN
1
2
MAN
SB
53/329
SB
10/18
BL
A:3
10/55
A:4
53/601
B:7
B:23
53/604
BL
10/17
SBSB
A:4
A:3
10/48
31/93
53/397
BN
SB
31/72
SB
31/73
TP 39130202 S60 2009 65
Page 66
Group 35 Lighting
Running/parking light, tail lights & license plate lighting
3/111
LSM
BN
LIN
1
R
11E/4
2
2
30+
1
11E /1
2
10/17
B:3
GR
B:1
54/23
5/1
DIM
8
7
10
CAN
9
GR
10/2
A:4
SB
SB
54/22
SB
10/12
DIPPOSDRLMAIN
BIFUNC
GDL
A:3
GR
GR
SB
GR
10/73
2
1
210
53/303
30+ 30+
15/31_A1:2
1
11C/7
2
1
3
5
R
1
53/301
10/1
BIFUNC
GDL
10/71
SBBN
1
11C /9
2
R
53/425
10/11
DIP POS DRL MAIN
A:3
GR
GR
2
GR
54/22
210
A:4
SB
SB
10/18
1
2
SB SB
GR-W
B:1
11B/20
R-W
GN-W
W
B:3
GR
GR-W
D:49
D:34
D:35
D:50
B:24
D:41
C:19
C:14
C:13
D:1
D:6
4/56
4/58
CEM
CAN
LIN
REM
CAN
F:5
LIN
E:B
C:20
K:1
D:5
F:10
F:3
BL-BN
R
54/40D
1
R
GR
GR
GR-GN
1
10/3
3/35
3
53/438
BN
31/84
53/397
31/93
GR
31/73
53/604
SB
A:4
B:6
10/45
A:1
10/44
BN
10/42
SB
SB
31/94
10/51
10/49
A:1
10/52
B:6
A:4
SB
SB
53/601
SB
31/72
TP 39130202 S60 2009 66
Page 67
Group 35 Lighting
Follow-me-home lighting
30+
1
2
R
1
11C/411C/5
2
4/70
UEM
16/59
R
3
CAN
5
LIN
1
54/10
R
3/126
B:12
DDM/PDM PDM/DDM
CAN
53/514
A:2
B:8
B:5
SBSB
VO-SB
SB
6
54/11
3/127
53/515
1
R
B:12
A:2
A:3A:3
CAN
B:8
B:5
SBSB
VO
SB
6
31/66
6/62
M M
y
F
11
M
x
SB
10/148 10/149
13
54/1154/10
53/501
11
SB
SB
6/63
M M
M
y
F
x
13
31/67
TP 39130202 S60 2009 67
Page 68
Group 35 Lighting
Interior lighting
2
10/126
4
SB
30+
1
11E/4
2
54/40D
RR
1
W
W
16/65
10/115
2
10/125
4
SB
53/405
SB
31/6
E:B
D:1
D:2
SB
10/114
3 1
BN
53/583
SB
22
54/13
SB
4/56
5
6
CEM
CAN
D:13
GN-R
13
SB
BN
D:9
VO-W
53/505
D:50
D:35
D:34
D:49
VO-W
VO-W
54/10
53/514
54/10
53/604
1
11C/5
2
R
1
1
11
SB
31/66
SB
30+
54/13
1
11C/6
2
R
1 2
R
R
R
1
11C /7
2
W
12
10/29
A:2
3/117
A:3
A:4
A:5
A:7
A:8
A:10
BN
GR
GN-Y
W
Y
BL
VO-W
BN
4/70
18
6
19
16
4
3
5
8 20
53/503
UEM
CAN
LIN
BN
11
1
15
7
17
14
BN
BN
31/98
C:14
C:13
BL-Y
W-SB
10/150
W-Y
BL-R
54/13
20
4/58
1
31/83
30+
R
REM
BN
1
11E /1
2
K:1
CAN
LIN
627
F:2
D:29
D:33
C:3
C:12
F:5
D:11
D:2
4
53/601
31/72
P
P
P
P
BN-R
2
10/127
4
SB W
SB
54/43
4
W
2
10/128
4
SB
SB
31/73
54/11
P
R
SB
3/126
30+
1
11C/4
2
R
1
3/127
PDM/DDM
A:6
R
B:12
CAN
54/43
5
A:2
A:3
B:5
P
54/11
54/21
3/75
LK
DL
ULK
KEY
31
4
BN
B:5
B:12
DDM/PDM
A:2
A:3
CAN
A:6
3/74
LK
DL
ULK
KEY
31
4
BN
SB
SB SB
31/46
53/500
54/20
8
3
M1
M1
12
P
M2
CL BLL
54/20
54/10
M2
BLLCL
BL-SB
3/78
1
2
T
4
SB
BN-R
53/515
P
3/77
3
T
M3
3
8
P
M1
DL
M2
31
1
2
T
M3
BLLCL
SB
12
54/21 54/11
P
SB
SB
11
SB
53/501
3/76
3
T
M3
M1
DL
M2
CL BLL
31
1
2
T
M3
SB
31/67
TP 39130202 S60 2009 68
Page 69
Group 35 Lighting
Beam length adjustment
6/38
30+
1
11E/1
54/40D
1
R
1
11E /4
22
4/56
CEM
D:41
GN-W
30+
1
11C/7
53/425
3/111
3
1
11C /9
22
R
R
1
LSM
F16
B:23
D:50
D:35
D:32
D:47
C:11
GN-BN
3/59
VOVO
W/O Bi-X
54/23
BL
BL
3
GN-R
2
1
SB
1
6
SB
10
LIN
5
E:B
BLBL
54/22
1
R
GN-R
C:12
CAN
LIN
VO
53/398
3
GN-R
2
SB
1
6
SB
10
6/39
53/301
53/397
Bi-Xenon
SB
SB
BN
4/58
4/84
REM
CAN
LIN
SUM
CAN
C:11
C:6
C:9
C:13
C:14
A:25
A:28
A:23
A:15
A:16
GN-R
GR
BN-W
R-W
Y-R
GR
54/32
1
2
3
54/107
6
7
3
W/O SUM
W/O SUM
W/O SUM
SUM
SUM
SUM
BL-R
GR-W
BN
R-W
Y-R
GR
7/120
5
4
1
53/303
SB
BN
BN
53/438
BN
31/93
31/94
31/84
TP 39130202 S60 2009 69
Page 70
Group 35 Lighting, Accessories
Auxiliary lights
30+
1
1
1B/5
2
3/112
CCM
C°/F°
3/60
4/56
CEM
CAN
D:50
D:35
CAN
R-SB
A:11A:9
1
54/8
2
R
R
BN-W
BN-W
2/64
30
87
4
3
BL
C:9
R
2
86
85
1
LIN
10/69
BL
1
SB
2
BL
1
SB
2
10/65
SB
31/70
TP 39130202 S60 2009 70
Page 71
Group 36 Additional electrical equipment
Rain sensor
11C/7
30+
1
1
11C/6
2
2
R
R
GN-W
3/254
7
SWM
LIN
7/149
RSM
LIN
5/1
DIM
8
7
10
9
CAN
54/13
21
4/70
UEM
3
5
1
2
3
4
W
BN
VO-W
54/16
1
2
3
4
GN
BN
VO-W
WW-BL
53/505
VO-W
13
CAN
8
LIN
1
R
11
20
R
D:58
4/56
CEM
6/1
L
53/331
53/397
CAN
LIN
D:11
C:31
D:53
D:38
D:34
D:49
H
4
SB
BN
321
W
BL-W
54/13
14
BN
20
53/503
BN
BN
BN
31/93
BN
31/83
31/98
TP 39130202 S60 2009 71
Page 72
Group 36 Additional electrical equipment
Direction indicators and hazard warning flashers
30+
11
R
1
R
CEM
CAN
R
2
R
E:B
11E/5
2
E:A
D:50
D:35
B:32
3/254
SWM
CAN
LIN
11E/4
2
4
3
7
GN-W
54/40D
4/56
D:34
D:49
D:58
B:31
5/1
DIM
8
7
10
9
CAN
6 12
6/62 10/15
M
M
F
Y
M
X
10/13
1
2
LCM
LIN
GN
GN
10/11
53/514
SB
SB SB
SB
11
10
54/22
54/10
SB
2
GN
53/301
GN
54/22 54/10
9
1
3
GN
GN-W
A:12
A:15
GN-W
GN-Y
A:21
B:11
C:14
C:13
3/6
D:22
4/58
10
LIN
Y
3
REM
CAN
LIN
D:14
Y-W
1
5
SB
53/405
A:13A:18
A:20
B:10
A:29
A:4
6 12
RCM
LIN
10/16
SBSB
6/63
M
GN
Y-R
GN-W
GN-W
M
F
Y
M
X
54/2354/11
977
GN
GN
10/14
1
2
10/12
53/51553/501
GN
1
2
3
SB
GN-W
SB
10 11
54/23
SB
54/11
SBSB
53/303
SB
10/18
10/17
53/397
10/54
BN
SB
A:2
31/93
A:4
SB
53/601
SB
31/72
SB
53/604
SB
31/73
A:4
10/47
A:2
31/6
SB
31/94
BN
31/67
TP 39130202 S60 2009 72
Page 73
Group 36 Additional electrical equipment
Wiper/washer, windshield
R
1
11E/1
2
30+
1
2
3/254
SWM
LIN
9
7
Y-R
GN-W
R
R
Y
GR
BL-W
30+
R-SB
1
11B/7
2
11
11E/5
11E/4
2
R
54/40D
2
D:58
C:31
D:7
E:B
E:A
C:3
C:4
4/56
F34
CEM
CAN
LIN
D:50
D:35
D:34
D:49
C:10
B:29
B:21
GN-Y
Y-R
Y
FST1
2/90
GN-Y
GN-Y
1(86)
FST2
2/91
2
1(86)
2(85) 5(87) 4(87a)
435
2
1
3(30)
435
4(87a)5(87)2(85)
1
3(30)
R-W
2
B:30
Y
BL
6/1
12 3
H
L
6/127
1
7/5
1
2
GR-SB
53/331
53/397
31/93
4
SB
SB
53/302
SB
BN BN
31/1
TP 39130202 S60 2009 73
Page 74
Group 36 Additional electrical equipment
Wiper/washer, headlights
30+
11
11E/5
2
R
11E/4
2
R
54/40D
2
1
1
11E /1
2
3/254
SWM
LIN
4/56
7
GN-W
R
R
D:58
E:B
E:A
CAN
LIN
F34
F14
B:19
VO
VO
CEM
D:50
D:35
D:34
D:49
C:10
GN-Y
B:29
Y-R
B:21
Y
2
B:30
Y-S B
Y-W
6/127
1
6/4
53/331
3 2
SB
1
6/3
3
SB
1
7/5
2
1
2
SB
53/302
53/397
31/93
SB
BN BN
31/1
TP 39130202 S60 2009 74
Page 75
Group 36 Additional electrical equipment
High pressure headlight washer
3/254
SWM
LIN
7
GN-W
D:58
4/56
CEM
CAN
D:50
D:35
D:34
D:49
C:25
GN-SB
FST3
2/182
1(86)
2(85)
30+
1
11B/3
2
R-W
GN-Y
235
5(87)
41
4(87a)
3(30)
LIN
C:10
GN-Y
7/5
1
2
6/104
2
1
SB
53/302
SB SB Y
31/1
TP 39130202 S60 2009 75
Page 76
Group 36 Additional electrical equipment
Horn
1
11E/5
2
30+
1
11E /4
2
30+
1
1
11C/7 11C/9
2
2
1
2
RR
53/425
R
3/254
BN
2
7
SWM
LIN
8
18/4
1
2
3/37
54/40D
2 1
R
53/438
GN-W
D:58
4/56
F3
CEM
CAN
LIN
Y
10
D:17
E:A
E:B
B:15
D:50
D:35
D:34
D:49
R-SB
R-SB
R
R
1
2
54/4
53/382
54/4
16/10
1
R-SB
2
SB
16/11
1
R-SB
2
SB
SB
4
BN
31/84
SB
53/331
BN
53/397
BN
31/93
TP 39130202 S60 2009 76
Page 77
Group 36 Additional electrical equipment
Electronic immobilizer
30+
1
11C/7
2
5
15I1515X
1
BL-R
5/1
DIM
CAN
1
11C /8
2
R-SB
3/1
4
30
50 S
8
7
10
9
4/46
ECM
CAN
B:1
B:13
B:23
B:22
DIESEL
16/65
53/400
D:57
D:56
4/56
CEM
CAN
LIN
C:22
C:21
D:34
D:49
5
6
1
IPS
2
ICK
3
IDS
7
BN
BN
BL-R
GR
BL
53/443
31/83
TP 39130202 S60 2009 77
Page 78
Group 36 Additional electrical equipment
Anti-theft alarm
3/112
CCM
A:2
A:3
A:6
3/126
DDM/PDM
A:6
3/74
KEY
BN
C°/F°
CAN
A:10 A:8
3/127
PDM/DDM
CAN
A:13A:12
VO-W
BL-W
3/75
LK
M3
M2
ULK
KEY
BN
CAN
BL-W
ULK
31
BLL CL
31
4
A:2
A:3
A:13A:12
VO-W
513
LK
M2
4
DL
M1
M3
CLBLL
M1
DUL
DL
T
315
T
DUL
54/20
53/500
31/46
A:9
3/76
31
DUL
12
SB
SB
SB
DL
1
3/174
A:11
M1
CL
54/21
53/501
54/20
M2
BLL
3/77
31
31/67
DUL
1
P
3
P
2
T
M3
P
2
DL
M1
SBSB
12
SB
T
M3
M2
BLLCL
P
PP
3
54/11
8
54/10
8
54/21
54/43
P
P
30+
4/70
22
10
1
22
7/12
1
3
4
11E /4
2
5
54/40D
4/56
CEM
D:42
15
LIN
BN
E:B
D:50
CAN
D:35
LIN
D:34
D:49
F8
B:25
4/33
A:4
SRM
P
LIN
15
P
P
2
R
1
3
SB
R
R
1 2
54/13
R
R
11
1
21
UEM
16/59
3
CAN
5
LIN
20
P
P
54/13
54/3.1
16/35
SCM
53/303
BN
31/94
1
11C/7 11C /6
4/58
7/100
ISM
1
30
LIN
31
5
P
5
P
4
SB
2
GN-W
BN-R
3/78
Y
21
3
53/602
SB
31/72
D:31
D:26
C:14
C:13
D:33
BL-SB
4
54/3.1
54/4
3/62
53/382
54/4
53/331
53/397
31/93
REM
CAN
LIN
14
C:3
C:1
K:1
C:4
F:2
F:5
C:12
D:29
YSB
GN
R
7/122
MMS
3
GR
Y
3
Y
1
2
53/503
SB
4
BN BN SB
5
BN
BN
31/98
1
54/13
GR-W
BN
20
BN BN
31/83
1
11E /1
2
R
1
R
30+
1
2
TP 39130202 S60 2009 78
Page 79
Group 36 Additional electrical equipment
Parking assistance
BL
B:21
4/58
REM
F26
30+
1
11E/1
2
F27
GN-W
D:32
C:14
C:13
CAN
LIN
K:1
R
ACC
LF/O
RF/O
7/207
RHD
LHD
RHD
LF/I
RF/I LF/I LF/O
LHD
7/206
RHD
RF/I RF/O
LHD
7/205
7/204
llll
1 23123 123 123
BL
SB
GN
BL
SB
VO
Y
BL
SB
BL
53/1300
53/1301
RHD
LHD
W
SB
53/602
BL
54/1300
54/1400
4/86
A:12
A:1
SB
SB
A:8
C:7/
C:8/
C:9
C:5C:1/
C:6/
C:10/
C:11/
C:12
SB
W
BL
3
2 1
l
1
2
BL
GN
12 4563
BL
GN
B:8
B:2
PAM
C:1/
C:3 C:2 C:4
C:6/
C:7/
C:10/
C:8/
C:11/
C:9
C:12
SB
Y
BL
3
2 1
l
VO
VO
B:7
LIN
C:1/
C:7/
C:8/
C:9
4 563
Y
W
Y
W
B:5
B:6
SB
3
l
SB
SB
SB
B:1
C:6/
C:10/
C:11/
C:12
VO
BL
21
C:1/
C:7/
C:8/
C:9
C:6/
C:10/
C:11/
C:12
SB
GN
BL
3
2
1
l
31/72
7/131
LR/O
LR/I
7/1337/132
RR/I
7/134
RR/O
TP 39130202 S60 2009 79
Page 80
Group 36 Additional electrical equipment, Accessories
Accessory Electronic Module (AEM) 1:2
30+
1
11E /1
2
R
4/78
SB
AEM
CAN
A:1
A:2
A:4
A:3
GN
4/58
W
R
D:30
D:19
B:22
C:13
C:14
F3
REM
CAN
LIN
K:1
53/604
W
GN
4/56
D:35
D:50
SB
5/1
DIM
CAN
7
8
9
10
GN
W
D:49
D:34
CEM
CAN
LIN
31/73
TP 39130202 S60 2009 80
Page 81
Group 36 Additional electrical equipment, Accessories
Accessory Electronic Module (AEM) 2:2
A:1
A:3
B:26
B:50
A:2
A:4
B:1
B:25
Pos Function Type
A:1 Electrical distribution Ground
A:2 Electrical distribution Feed
A:3 CAN communication Input/output signals
A:4 CAN communication Input/output signals
B:1 Remote heater start, minicall Feed
B:2 Remote heater start, minicall Ground
B:3 Remote heater start, minicall
Remote heater start, radio signal
B:5 Engine heater Steering, alternating
B:6 Parking assistance Feed
B:7 Parking assistance Input signal
B:8 Parking assistance Ground
B:11 Handsfree, audio disengage Input signal
B:12 Audio disengage Output signal
B:13 Rheostat, audio Output signal
B:14 Speed signal, audio
Speed signal, RTI Japan
B:15 Alarm signal Output signal
B:16 Alarm signal Output signal
B:30 Antenna amplifier, audio Feed
B:33 Alarm signal
RTI Japan
B:34 Alarm signal
Reverse gear signal, RTI Japan
Input signal
current feed
Output signal
Output signal
Output signal
Steering, X-feed
Output signal
TP 39130202 S60 2009 81
Page 82
Group 36 Additional electrical equipment, Accessories
Alcolock
4/56
CEM
CAN
LIN
E:B
D:60
D:15
D:9
D:49
D:34
54/40D
R
Y-W
Y
W
30+
R
1
11E/4
2
1
10X/29
30+
1
11C/7
2
3/1
50
7
736 1 8
3X/1
3X/1
5
S
3
Y
X
VO
6
1
11C /8
2
R-SB
4
R-SB
4
30
15
15 15I
1
-R
BL
R-SB
B
L
-R
1
1
11O/2 11O/1
8
BL
2
2
R-SB
1
BL-R
2
Y-W
3
Y-W
4
A
VO
-R
BL
BL
L
C
O
53/408
SB
SB
W
2/240
4/58A:29
52 4
2
R-SB
5
4
SB
12
W
SB
53/443
L
O
C
K
53/405
31/6
12
31
3
1
BN-SB
5
10/29
W
52 4
2/241
SB
SB
5
4
2
3
1
31
SB
6
R
7
TP 39130202 S60 2009 82
Page 83
Group 37 Wiring and fuses
Diagnostics system
30+
HISPEED
HISPEED
HISPEED
HISPEED
HISPEED
HISPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
LOSPEED
C:21
C:22
D:31
D:46
D:32
D:47
D:34
D:49
D:35
D:50
D:36
D:51
D:37
D:52
D:38
D:53
D:39
D:54
4/56
CEM
CAN
LIN
D:48
D:33
D:40
D:55
53/438
HISPEED
HISPEED
LOSPEED
LOSPEED
BN
1
11C/9
2
R
1
11C /7
2
53/425
W
W
BN
BN
17/13
GN
3
45
CAN
6
16
1411
R
GN
31/84
TP 39130202 S60 2009 83
Page 84
Group 37 Wiring and fuses
12V outlet
30+
11
11E/1
2
54/40D
11E /4
2
RR
1
4/56
CEM
CAN
LIN
E:B
F11
A:17
X
D:12
D:50
D:35
D:34
D:49
Y-W
10/161
Y-W
1
2
SB
B:3 B:1
A:2
VO
VO
9/1
2
1
SB
SB
FOUR-CFOUR-C
53/406
A:3A:1
SB
9/25
SB
31/10
TP 39130202 S60 2009 84
Page 85
Group 37 Wiring and fuses, Accessories
12V outlet, cargo compartment
30+
1
11E/1
2
4/58
REM
17/19
R
R
K:1
B:31
F8
C:14
C:13
CAN
LIN
5/1
DIM
CAN
10 9 78
2
1
SB
31/73
TP 39130202 S60 2009 85
Page 86
Group 37 Wiring and fuses, Accessories
Tow hitch cable harness, 4-pin
4/110
TRM
A:8
+30
1
11E/1
2
R
17/37
A:7
B:4
GN-W
A:3
Stop/Turn Right
A:5
Stop/Turn Left
A:4
Position
A:10
GND
B:5
Stop/Turn Signal
Left
B:3
Stop/Turn Signal
Right
26/4
5
6
71
A:9
A:11
B:2
A:6
R
A:12
R
4
3
2
R
1
2
3
4
W
GN
Y
BN
SB
Y-W
SB
R
4/58
REM
R
BL-W
OR-W
VO
P
Y-W
GN-W
BN-W
R
R
31/120
F29
F30
E:A
E:B
E:C
E:D
E:E
E:J
E:K
E:L
E:M
K:1
SB
C:13
C:14
CAN
LIN
TP 39130202 S60 2009 86
Page 87
Group 37 Wiring and fuses, Accessories
Tow hitch cable harness, 7-pin
+30
1
1E/11
2
4/110
TRM
17/38
A:8
Y-SB
A:5
Turn Left
A:2
BL
Fog Light
A:3
Turn Right
A:4
Position
A:1
Stop Lights
A:10
GND
Y
BL
1
6
2
7
5
3
4
W
GN
BN Y-SB
SB
R
53/733
SB
53/735
53/734
SB
BL-Y
A:7
B:4
B:3
B:5
B:1
A:9
A:11
B:2
A:6
A:12
R
R
R
OR-W
Y-W
GN-W
VO
P
BL-W
RR
BN-W
R
R
4/58
REM
31/120
F29
E:A
E:B
E:H
E:F
EXT. D6
C:13
C:14
Reverse
Lights
F20
CAN
LIN
F27
F30
E:C
E:D
E:E
E:J
E:K
E:L
E:M
K:1
TP 39130202 S60 2009 87
Page 88
Group 37 Wiring and fuses, Accessories
Tow hitch cable harness, 13-pin
+30
1
11E/1
2
4/110
TRM
17/39
8
97
1
6 10
24
3
13 12
A:8
W
W
W
W Y-SB
W
W
115
53/734
SB
A:5
A:2
A:3
A:4
A:1
A:10
Turn Left
Fog Light
Turn right
Position
Stop Lights
GND
4/58
A:7
B:4
B:3
B:5
B:1
A:9
A:11
B:2
A:6
A:12
R
R
R
R
R
BL-W
OR-W
Y-W
VO
P
GN-W
BN-W
R
R
REM
W
RESERVE:
INDICATION TRAILER
W
RESERVE:
CHARGING COMMON RETURN
F29
E:A
W
W
W
W
W
53/733
SB
E:H
E:G
E:F
EXT. D6
C:13
C:14
Reverse Lights
F7
F20
CAN
LIN
F27
F30
E:B
E:C
E:D
E:E
E:J
E:K
E:L
E:M
K:1
31/120
TP 39130202 S60 2009 88
Page 89
Group 38 Instruments
Seat belt reminder
4/9
SRS
A:25/25
A:26/26
B:25/53
B:23/51
B:24/52
B:26/54
CAN
LIN
C:25/81
C:26/82
VO
OR-SB
VO
OR-SB
54/24
17 1
18
54/25
17
18
3/93
2
H
3/94
1
2
H
3
5
4/70
7/31
N
UEM
CAN
LIN
1
2
BN-P
Y-R
5/1
DIM
CAN
8
7
10
9
4/16
BCM
45
46
CAN
34
BN-GR
33
Y-GR
2
1
7/32
N
11
15
TP 39130202 S60 2009 89
Page 90
Group 38 Instruments
Driver information module
A:2
A:3
3/127
7/16
7/6
7/35
QLT
PDM/DDM
CAN
1
2
1
P
1
2
3
A:18
A:14
BN-SB
VO-W
GR
W
5CYL T
5CYL W/O T
BN-SB
53/332
53/319
6/63
MFM
M
5CYL W/O T
5CYL T
5CYL T
5CYL W/O T
7/25
5CYL W/O T
5CYL T
5CYL T
5CYL W/O T
y
x
7/31
N
7/11
3 2
GR-R
GR-R
BN-SB
BN-SB
BN-SB
BN-SB
R
W
BL-W
BL-W
VO-W
VO-W
4/16
1
2
BN-P
Y-R
3/47
1
Y
4/46
A:4
A:40
A:61
A:60
A:26
A:39
A:48
A:66
A:68
A:40
A:39
A:58
ECM
CAN
B:46
B:8
B:13
B:1
54/3.1
GR
Y
7/73
BCM
45
46
5/1
5
2
GR
18
7/4
1
2
SB
CAN
DIM
CAN
34
33
11
15
VO-W VO-W
3
8
7
10
9
4
6
16
Y-R Y-R
1
2
SB
53/329
SB
53/397
BN
53/437
W
GN
53/400
BN-GR
Y-GR
EXT.D1
BN
BN
A:10
D:34
D:49
53/302
4/56
7/5
7/32
1
2
CEM
F10
CAN
LIN
C:10
GN-Y
1
SB
SB
N
11E /5
D:50
D:35
C:21
C:22
E:A
D:45
D:44
D:43
54/40D
BN
BL
GN
R
2
R
54/36
6/33
7/130 7/143
2
BL
GN
6/31
E
7/130 7/143
9428
P
312
B5244T5, B525T2 USA, B5254T2 KOR
30+
11
11E/1
2
PE
2
213
10
6/33
BN
31/93
31/83
31/1
TP 39130202 S60 2009 90
Page 91
Group 38 Instruments
Driver information module, Diesel
A:2
A:3
7/16
3/127
PDM/DDM
CAN
1
2
7/25
1
2
7/166
QLT
4/16
7/31
N
1
2
BN-P
Y-R
6/63
MFM
y
M
x
7/11
3/47
1
Y
A:18
A:14
3 2
GR
W
4/46
A:60
GR-R
BN-SB
A:56
ECM
CAN
B:37
B:35
54/3.1
GR
Y
7/73
DIESEL
GR-R
GR
1
2
3
54/100
1
2
GR-R
GR
BN-GR
BN-SB
VO-W
A:77
A:53
A:34
A:36
A:42
B:22
B:23
BCM
45
46
5/1
5
2
GR
18
7/4
1
34 BN-GR
33
CAN
11
15
VO-W VO-W
3
DIM
CAN
8
7
10
9
4
6
16
Y-R Y- R
1
53/437
W
GN
Y-GR
EXT.D1
BN
53/400
2
2
SB
SB
SB
BN
53/329
53/397
BN
A:10
D:34
D:49
53/302
4/56
7/5
7/32
1
2
CEM
F10
CAN
N
LIN
GN-Y
SB
SB
C:10
1
2
D:47
D:32
C:21
C:22
E:A
E:B
D:45
D:44
D:43
BN
GN
R
54/40D
BL
2
R
54/36
6/33
7/130 7/143
30+
11
11E /5
2
PE
11E/4
2
R
1
R
213
31/93
31/83
31/1
TP 39130202 S60 2009 91
Page 92
Group 38 Instruments
Driver information module, Bi-Fuel
6/63
7/6
P
7/16
7/25
7/31
N
M
1
2
1
2
MM
F
y
x
7/11
2
3
1
1
2
BN-SB
53/319
BN-P
Y-R
W
GR
BN-SB
GR-R
BN-SB
R
W
45
46
A:14
A:18
A:39
A:40
A:61
A:48
A:66
4/16
BCM
CAN
3/127
PDM/DDM
CAN
4/46
ECM
CAN
34 BN-GR
Y-GR
33
11
15
A:2
A:3
B:46
GR
7/73
A:55
A:37
B:1
B:13
30+
11
1
2
7/32
N
11E/5
11E /4
2
R
R
54/40D
2
R
VO-W
1
R
53/437
5/1
3/47
1
Y
54/3.1
YB:8
7/4
1
3
DIM
5
2
CAN
6
GR
18
16
Y-R Y- R
1
8
7
10
9
4
53/400
2
SB
2
SB
53/329
SB
53/397
11E/1
2
VO-W
EXT. D1
BN BN
1
2
E:B
E:A
A:10
D:34
D:49
7/5
53/302
4/56
F10
CEM
CAN
LIN
GN-Y
SB
F16
C:10
1
2
A:4
D:50
D:35
C:21
C:22
D:45
D:44
6/33
Y-R
BN
BL
54/36
A:13
P
4/58
REM
21
7/143
CAN
LIN
C:13C:14
D:8
D:27
D:15
D:14
54/54
7/156
VO
Y
GR-R
21
Y
VO
GR-R
1 2 3 4
P
Y-G R
43
Y-GR
BN
31/93
31/83
SB
31/1
TP 39130202 S60 2009 92
Page 93
Group 39 Other
Audio with internal amplifier
17/40.2
AUX
A:1
A:2
A:3
A:4
BL-W
W
SCRN
BL-BN
54/134.2
1
2
3
4
53/466
30+
1
11E/1
2
SCRN
11
2
R
54/40D
1
R
16/1
A:5
BL-W
A:4
W
A:3
BL-BN
AUM
CAN
30+
1
B:11
B:12
B:5
B:6
A:7
A:8
E:1
E:2
E:3
E:4
E:5
E:6
E:7
E:8
VO
D:37
D:52
D:58
E:A
E:B
A:6
GR-W
GR
GR-R
GR
4/56
F28
R
CEM
CAN
LIN
54/11
9
10
NL
NL
NL
NL
NL
NL
NL
NL
53/525
53/526
GR-R
GR
54/144
MELBUS
11C/10
2
1
2
3
4
5
6
7
8
11E/511E/4
2
R
2
R
A:2
X
A:1
30
+ RR
- RR
+ RF
- RF
1
11C/11
2
GR-W
GR
54/21
1
2
GR-W
GR
GR-W
GR
GR-R
GR
GR-R
GR
16/18
1
2
16/5
1
2
16/3
1
2
16/56
1
2
16/55
1
2
4/56D:58
BN
+ LF
- LF
+ LR
- LR
B:1
B:2
B:7
B:8
GR-R
GR
GR-W
GR
54/10
9
10
GR-R
GR
53/523
53/524
GR-W
GR
54/20
1
2
GR-W
GR
16/4
1
2
16/6
1
2
16/17
GR-W
GR
BL-W
A:9
+ ANT
C:1
54/145
BN
53/448
A:12
BN
31
3/254
18/4
SWM
7
CAN
LIN
+
6
4
LIN
-
2
C:2
1
3/4
SWSL SWSR
1
3
4
5
LIN
C:1
16/16
16/67
A:1
A:22
A:3
A:4
A:5
2
3/131
4/16
BCM
CAN
LIN
16/9
AM/FM
TV
TV
9/2
11
15
1
2
RTI/TV
TV
16/68
31/84
TP 39130202 S60 2009 93
Page 94
Group 39 Other
Audio with external amplifier 1:2
30+
1
11E/1
2
1 2
1
11E/4
2
R
54/40D
R
R
GN-W
1
R
11E/5
2
E:A
E:B
D:58
4/56
CEM
CAN
LIN
F28
A:6
D:37
D:52
30+
1
11C/10111C/11
2
R
2
16/1
A:1
30
A:2
VO
X
A:7
A:8
AUM
CAN
R
A
B
A:5
A:4
A:3
W
BL-BN
BL-W
1
W
2
SCRN
3
BL-BN
4
SCRN
54/134.2
BL-W
53/466
A:12
31
BN
53/448
A:1
A:2
A:3
A:4
BN
BN
17/40.2
AUX
BN
C
54/144
MELBUS
1
2
3
4
5
6
7
8
31/84
16/9
NL
NL
NL
NL
NL
NL
NL
NL
E:1
E:2
E:3
E:4
E:5
E:6
E:7
E:8
A:9
+ ANT
C:1 C:1
BL-W
AM/FM
TV
TV
16/16
RTI/TV
TV
9/2
2
16/68
+ CS
- CS
C:2
54/145
1
A:10
A:11
GR-R
GR
16/67
1
16/26
2
3/254
7
SWM
CAN
LIN
18/4
A:1
A:22
A:3
3/131
LIN
4/16
BCM
CAN
11
15
3/4
SWSL SWSR
LIN
1
3
4
5
LIN
+
6
4
-
2
TP 39130202 S60 2009 94
Page 95
Group 39 Other
Audio with external amplifier 2:2
16/2
AMPLIFIER
A
R
A:1
B
B:11
B:12
B:5
B:6
B:1
B:2
B:7
B:8
GR-W
GR
GR-R
GR
GR-R
GR
GR-W
GR
8
54/14
7 2 1 6 5 12 11
GR
GR-WGRGR-R
GR
GR-RGRGR-W
C
BN
A:2
GR
53/524
GR-W
GR
53/523
GR-W
10 9
GR
GR-R
54/11
54/10
GR
53/526
910
GR-R
GR
GR-W
53/525
GR
GR-W
2
16/17
1
54/20
GR
2
16/6
12
GR-W
1
GR
2
16/4
GR-R
1
GR
2
16/55
GR-R
1
GR
2
16/56
GR-R
1
2
16/3
GR
54/21
GR-R
1
GR
2
16/5
12
GR-W
1
2
16/18
TP 39130202 S60 2009 95
1
Page 96
Group 39 Other
Mobile phone
30+
11
11C/11
2
11C/13
2
16/62
HANDSET
R-W
GR-R
GR
54/24 LHD
54/25 RHD
9
10
GR
W
16/78
1
2
16/77
W
SB
16/60
6
3
4
5
6
7
W
BN
GN
R-W
3
12
2
14
13
22
PHM
4
11
145
3
1
2
6
5
7
9
8
0#
C:1 A
GSM
B:1
GPS
A:1
A:1S
54/143
16/63
16/64
1
2
GSM/GPS
B
4/56
CEM
CAN
LIN
D:58
D:52
D:37
D:19
Y-W
GN-W
3/254
7
10
SWM
CAN
LIN
17
18/4
CAN
53/438
+
6
4
-
2
18
BN
BN
3/131
A:1
A:22
A:3
LIN
LIN
3/4
SWSL SWSR
1
3
4
5
LIN
31/84
TP 39130202 S60 2009 96
Page 97
Group 39 Other
Road Traffic Information (RTI)
30+30+
30+
54/40D
E:1
2
1
11C/12
16/71
C:1
C:2
C:3
C:4
C:5
C:6
C:7
C:8
C:9
C:10
C:S
D:1
D:5
R
GN
VO
P
BN
BL
SB
Y
GR
W
R-W
SB
B:1
B:2
B:3
B:4
B:5
B:6
B:7
B:8
B:9
B:10
B:S
16/46
DPY
1
2
R
A:3
A:1
A:2
A:4
A:5
11E/1
53/602
R-W
R-W
BN
BN
C:14
C:13
K:1
53/423
BN
4/58
REM
F6
B:8
R-W
1
11C /11
2
TV
R
1
R
1
11E/4
2
VO
16/16
16/68
D:37
D:52
D:58
E:B
4/56
CEM
F28
A:6
16/67
D:50
D:35
AM/FM
TV
VO
16/9
RTI/TV
16/45
16/36
TV
TV
TV
TV
TV-TUNER
A:1
A:8
A:9
A:7
A:13
A:15
B:4
W
B:3
BN
B:2
SB
B:10
R
B:5
Y
B:1
SB
RTI
DVD
D:3
D:4
TV
CAN
16/1
AUM
A:2
A:8
A:7
54/10
CAN
16/4
B:5
B:6
B:2B:1
LHD
LHD
GR-R
GR
54/11
10
9 10
LHD
LHD
GR-R
GR
1
2
16/3
RHD
GR
RHD
GR
2
RHD
GR-R
9
RHD
GR-R
1
4/56D:58
3/254
7
SWM
CAN
LIN
18/4
16/47
6
4
2
GPS
+
-
53/448
A
3/4
SWSL SWSR
1
LIN
3
4
5
LIN
A:1
A:22
A:3
A:4
A:5
SB
31/72
3/131
LIN
B:1
B:2
B:3
B:4
B:5
BN
31/84
3/135
TP 39130202 S60 2009 97
Page 98
Group 39 Other, Accessories
Road Traffic Information (RTI) & CD changer
30+
1
11E/4
2
54/40D
RR
1
VO
VO
16/1
AUM
A:1
A:2
X
CAN
A:7
A:8
A:9
A:10
A:11
A:12
D:58
D:37
D:52
E:B
A:6
X
R
VO
W
GN
BL-W
GR-R
GR
BN
4/56
F28
CEM
CAN
LIN
16X/1A
1
2
3
4
5
6
7
8
9
10
11
12
D:35
D:50
W
GN
R-W
C:14
C:13
B:8
4/58
F6
REM
CAN
LIN
K:1
D:20
D:21
R-W
30+
1
11E/1
2
R
GN
W
16/15
CD-
2
CHANGER
SB
1
W
GN
16/46
DPY
16/45
RTI
A:3
x
A:1
A:2
A:4
A:5
R-W
R-W
BN
BN
53/736
53/737
SB
1/120
3
SB
R-W
D:1
D:5
DVD
CAN
D:3
D:4
TP 39130202 S60 2009 98
Page 99
Group 39 Other, Accessories
Navigation system, portable
30+
11
11E/1
2
11E/4
2
RR
1
54/40D
4/56
CEM
CAN
LIN
E:B
F11
A:17
D:50
D:35
D:34
D:49
16/45
X
VO VO
9X/1
2
1
VO VO
2
9/1
1
SB
SB
FUSE 2A
NAVI
21
1
PORTABLE
2
3
FOUR-CFOUR-C
SB
SB
53/406
SB
31/10
TP 39130202 S60 2009 99
Page 100
Group 39 Other, Accessories
CD changer
30+
1
11E/1
2
1
11E/4
2
30+
1
11E/1
2
1
11C /10
2
30+
1
11C /11
2
16/45
RTI
DVD
D:1
D:3
D:4
D:5
R-W
GN
W
BN
R-W
R-W
RTI
16X/45D
1
2
3
4
5
R
RTI
R-W
W/O RTIW/O RTI
W
GN
R
RTI
RTI
R-W
R-W
4/58
K:1
B:8
16/15
2
REM
CAN
LIN
F6
CD-
CHANGER
1
C:14
C:13
GN
R
4/56
1
CEM
D:37
LIN
F28
E:B
A:6
D:52
W
D:35
D:50
CAN
54/40D
R
VO
X
16/1
AUM
A:2
X
R
A:1
30
CAN
A:8
A:7
A:12
BN
31
CAN
53/602
RTI
SB
RTICDCH
W/O RTI
W/O AMP
AMP
BN
53/448
RTI
SB
SB
SB
31/12031/72
31/84
BN
TP 39130202 S60 2009 100
Loading...