Volvo 740 1987 Owner Manual

1987 Volvo 740

1 9 8 7

VOLVO

740

Contents

A comprehensive index is located at the back of this manual.

Presentation Instruments and controls Body and interior Starting and driving Wheels and tires In case of emergency Car care Service and routine

maintenance Specifications Index

All information, illustrations and specifications contained in this manual are based on the latest product information available at the time of publication. Volvo reserves the right lo make model changes at any time, or to change specifications or design without notice and without incurring obligation.

pg. 2 Presentation

file:///K|/ownersdocs/1987/1987_740/87740_00.htm (1 of 3)12/30/2006 7:54:27 AM

1987 Volvo 740

This Owner's manual provides information on driving and maintaining your Volvo It should be noted that there are certain differences among model versions and market requirements; thus, you may find features described and/or pictured in this manual that do not appear on your car. Should you require more detailed information with regard to adjustments or repairs please contact your Volvo dealer. Do not export your Volvo to another country before investigating that country's applicable safety and exhaust emission requirements. In some cases it may be difficult or impossible to comply with these requirements. Modifications to the emission control system(s) may render your Volvo not certifiable for legal operation in the U.S., Canada, and other countries.

pg. 3 Keys

file:///K|/ownersdocs/1987/1987_740/87740_00.htm (2 of 3)12/30/2006 7:54:27 AM

1987 Volvo 740

The key number codes are stamped on a separate tag supplied with the keys. This tag should be separated from the key ring and kept in a safe place. The double-sided tape on the back of the tag can be used to secure it safely. In the event the original keys are lost, duplicates may be ordered from your Volvo dealer. The central locking system is described in detail in section "Door and locks".

Top of Page

file:///K|/ownersdocs/1987/1987_740/87740_00.htm (3 of 3)12/30/2006 7:54:27 AM

1987 Volvo 740

1 9 8 7

VOLVO

740

Instruments and controls

pg. 4 Instruments, Switches and controls

pg. 5 Instruments, Switches and controls

1 Air louver

2 Headlights, parking lights

3 Turn signals, Cruise Control (optional)

12,14

4 Hazard warning flashers

5 Instruments

6 Wiper/washer

7 Air louvers

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (1 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

8 Heating and ventilation

9 Audio cassette/tuner

10 Cigarette lighter

11 Ash tray

12 Electrically-heated passenger seat

13 Parking brake

14 Hood release handle

15 Space for additional equipment 16 Electrically operated windows

17 Rear fog lamps

18 Fog lights (optional, standard on Turbo)

19 Space for additional equipment 20 Space for additional equipment 21 Air louver

22 Starting (ignition) switch/steering wheel lock

23 Space for additional equipment 24 Rear window demister

25 Horn 26 Electrically-heated driver's seat

The pages in this section provide a detailed description of the vehicle's instruments and controls. Note that vehicles may be equipped differently, depending on special legal requirements, etc.

pg. 6 Instruments

NOTE: Canadian model speedometers/odometers indicate kilometers only.

1 Voltmeter (Turbo models) 2 Fuel gauge 3 Clock reset knob 4 Quartz crystal clock 5 Speedometer 6 Trip odometer 7 Trip odometer reset knob 8 Odometer

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (2 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

9 Tachometer (GLE, Turbo models) 10 Instrument panel lamps rheostat 11 Temperature gauge 12 Boost gauge (Turbo models)

pg. 7 Instruments

Quartz crystal clock To reset the hands, push in the reset knob and turn.

Tachometer Reads thousands of engine rpm. Engine should not be operated in red range.

Trip odometer Used for measuring shorter distances. (last figure represents 1/10 mile or km)

Trip odometer reset knob Push in to reset

Temperature gauge The pointer should be approximately midway on the gauge face when driving. If the pointer enters the red range repeatedly, check coolant level and fan belt tension. Do not drive the car with the pointer in the red range. See sections "Coolant" and "Drive belts"

CAUTION! Allow engine to cool before adding coolant.

Fuel gauge The fuel tank capacity is approx. 15.8 US gals (60 liters). The red range represents approx. 2.4 US gals. (9 liters). See "Refueling" for further information.

Instrument panel lamps rheostat Clockwise = brighter. Counterclockwise = dimmer.

Voltmeter (turbo-engine cars only)

The voltmeter indicates the voltage in the electrical system and thereby also the state of the battery.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (3 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

While the car is being driven the pointer should be within the black field. Should the pointer point to the upper or lower red field when driving, this may indicate some fault in the electrical system.

Boost pressure gauge (turbo-engine cars only)

The boost pressure gauge is divided into sections. Black section: The engine acts as a normally-aspirated engine. Best fuel economy is achieved while driving in this range. Yellow section: The turbo is engaged.

pg. 8 Indicator and warning lights

1 (Not connected) 2 (Not connected) 3 ABS-system, see p. 10

4 Service reminder light,

see p. 10

5 (Not connected) 6 Low engine oil pressure 7 Alternator not charging 8 Overdrive (5th gear) engaged (Turbo with manual transmission) 9 High beams 10 Brake failure 11 Parking brake applied 12 Bulb failure 13 Low washer fluid level. If the lamp glows continuously when the engine is running, there is only about 1/2 - 1 US qts. remaining in the washer fluid reservoir. 14 Shift indicator light (manual transmission models) or 4th gear disengaged, Turbo with automatic transmission 15 Fasten seat belts

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (4 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

16 (Not connected) 17 Turn signal, left 18 Turn signal, right

pg. 9 Warning lights

The warning lights described on this page should never stay on when driving When the ignition key is turned on, and before the engine starts, all of the warning lights should be on to test the function of the bulbs. Should a light not go off after the engine has started, the system indicated should be inspected. However, the parking brake reminder light will not go off until the parking brake is fully released.

Alternator warning light If the light comes on while the engine is running, check the tension of the alternator drive belt as soon as possible.

NOTE: This warning light is illuminated if the alternator is not charging. However, parking brake, brake failure and bulb failure warning lights will be illuminated at the same time due to the design of the system.

Brake failure warning light If the light comes on while driving and the brake pedal can be depressed further than normal, it is an indication that one of the brake circuits is not functioning. Stop immediately, open hood and check brake fluid level, see section "brake fluid, power steering". Fluid level below MIN mark :Do NOT drive. Tow car to shop for check/repair of brake system.

Oil pressure warning light If the light comes on during driving, the oil pressure is too low. Stop the car and then stop the engine immediately. Do not drive the car. See section titled "Engine oil". After hard driving, the light will come on occasionally when the engine is idling. This is normal, provided it goes off when the engine speed is increased.

Parking brake reminder light

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (5 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

This light will be on when the parking brake (hand brake) is applied. The parking brake lever is situated between the front seats.

Bulb failure warning light The light will come on if any of the following bulbs are defective: one of the low beam headlights one of the tail lights one of the brake lights when the brake pedal is depressed. Check the fuse and bulb. See sections titled "Replacing bulbs" and "Fuses". Should the warning light come on after a defective outside bulb has been replaced, the corresponding bulb on the other side of the car should also be replaced.

pg. 10 Indicator lights

Service reminder light The light will come on at 5000 mile (8000 km) intervals. It is a reminder to the driver to have the engine oil changed. The light will stay on 2 min. after start until reset by the servicing dealer. For resetting see section "Service diagnosis".

Anti-lock Brake System ABS ABS prevents wheel lock-up during severe braking conditions. If the light comes on while driving there is a malfunction of the ABS system (the standard braking system will however function). The Anti-lock Braking System (ABS) is designed to improve vehicle control (i.e. stopping and steering) during severe braking conditions by limiting wheel lock-up. When the system "senses" impending whel lock-up, braking pressure is automatically modulated in order to help prevent lock-up, which could lead to a skid. While the system is modulating braking pressure, the driver may detect a pulsation of the brake pedal. The on/off switching of the trunk-mounted ABS modulator may also be audible. This is normal. Please be aware that ABS does not increase the absolute braking potential of the vehicle. Thus, while control will be enhanced, ABS will not shorten stopping distances on slippery surfaces.

Shift indicator light (Manual transmission cars only) The Volvo shift indicator light (S.I.L.) is a device designed to help you get even better gas mileage from your Volvo car. Studies have shown that the best fuel economy is obtained by shifting gears at low

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (6 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

engine rpm and high relative engine load. The Volvo S.I.L. is calibrated to show you when to shift for improved mileage without sacrificing smooth acceleration. Use of the S.I.L. is simple. Shift to the next higher gear as soon as the light comes on. You may find after using the S.I.L. for some time that your natural shifting rhythm will adapt to the S.I.L's suggestion. Some drivers may even shift before the light comes on. Obviously, there will be times when you need to shift later than the light would indicate, for example. when climbing hills or trailer lowing. Using the light regularly, however, should result in a mileage improvement of six percent or more. depending on how you normally drive.

Programming instructions for shift indicator If the current supply to the control unit is cut (battery disconnected). the control unit will have to be reprogrammed as the control unit memory will be erased. Drive the car in each gear, first gear not necessary, for approximately 8 seconds. The gear change indicator light will flicker once (0.5 seconds), as each gear is programmed.

NOTE: Remove the foot completely from the clutch pedal after each gear change when programming the control unit.

pg. 11 Starting (ignition) switch

Starting (ignition) switch/steering wheel lock The steering wheel lock might be under tension when the car is parked. Turn the steering wheel slightly to free the ignition key.

A chime will sound if the starting key is left in the ignition lock and front door on the driver's side is opened.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (7 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

pg. 12 Turn signals, Hazard warning flasher

Turn signals 1 Lane change position.

In maneuvers such as lane changing, the driver can flash the turn signals by moving the turn signal lever to the First stop and holding it there. The lever will return to the neutral position when released.

2 Signal lever engaged for normal turns.

NOTE: Defective turn signal bulb will cause turn signal indicator and remaining signal lights to flash

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (8 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

more rapidly than normal.

3 High beam/low beam switch (headlights on). Move the lever towards the steering wheel and release it.

3 Headlight flasher (headlights off). Move the lever towards the steering wheel. The headlight high beam will be on until the lever is released.

Hazard warning flasher The four-way flasher should be used to indicate that the vehicle has become a traffic hazard.

NOTE: Regulations regarding the use of the hazard warning flasher may vary from state to state.

pg. 13 Windshield, Tailgate wipers/washers

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (9 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Wiper/washer 1 Intermittent wiper.

With switch in this position, the wipers will sweep approximately every seventh second.

2 "Single sweep" position. Switch returns automatically when released.

3 Wipers, low speed. 4 Wipers, high speed. 5 Windshield wiper/washer.

The wiper will make 2-3 complete sweeps after the lever is released.

Tailgate window wiper/washer (wagon) The tailgate window wiper/washer is operated by a switch at the end of the wiper lever.

1 The wiper operates continuously. 2 Intermittent position: the wiper strokes approximately every 10 seconds. 3 Tailgate washer.

After the button is released the wiper strokes 2-3 additional times before stopping. The electrical circuit is protected by fuse 14, located in the central electrical unit. See the section entitled

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (10 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

"Fuses".

Adjusting washer nozzles The washer jets should spray the windshield as shown. Use the edge of a small screwdriver to adjust the nozzles, if necessary.

Washer fluid reservoir The washer fluid reservoir is located in the engine compartment and holds approx. 0.5 US gal. (2.0 liters) on sedan models and approx. 0.8 US gal (3.2 liters) on wagon models. During cold weather, the reservoir should be filled with windshield washer solvent.

pg. 14 Cruise control

Cruise control (optional on certain models)

The cruise control switches are located on the turn signal switch lever. To engage and set desired speed: 1 .Set switch (1) to ON.

2. Accelerate to desired cruise speed.

NOTE: The cruise control cannot be engaged at speeds below 22 mph (35 km).

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (11 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

3. Depress SET SPEED switch (2).

Operating brake pedal or clutch pedal (where applicable) This will automatically disengage the cruise control. Previously selected cruise speed is retained in the memory and by momentarily setting the switch to RESUME position that speed will be re-engaged.

NOTE: The vehicle will accelerate very quickly should there be a substantial speed differential when the switch is reset that the vehicle be accelerated manually and the switch reset to RESUME once the speed differential has been reduced.

Acceleration Momentary acceleration, such as for passing, does not interrupt cruise control operation. The previously selected speed will be maintained without having to set switch to RESUME.

To disengage the cruise control system: set switch (1) to position OFF, or depress brake pedal, or depress clutch pedal (where applicable). Switching off the starting (ignition) switch is will automatically disengage the cruise control system.

WARNING! The cruise control should not be used in heavy traffic or when driving on wet or slippery roads. If the gear shift is moved to Neutral while the cruise control is engaged, then depress the brake pedal momentarily, or set the cruise control switch (1) to OFF. This will disengage the cruise control and prevent overreving the engine.

NOTE: When driving on a grade, actual vehicle speed may vary slightly from the set cruise control speed.

pg. 15 Lighting

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (12 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Headlights and position lights

All lights off

Parking lights on

Headlights and parking lights are on if starting (ignition) switch is in position I or II.

If the headlight switch is in position

all lights will go out when starting (igniton) switch is switched

off.

With the headlight switch in position

the parking lights will stay on. Switch from high to low beams, and vice versa, by moving the turn signal switch lever on the left side of the steering column towards the steering wheel.

pg. 16 Rear fog lights, Front fog lights, Power antenna

Rear fog lights The rear fog lights are considerably brighter than the normal tail lights and should be use only when atmospheric conditions, such as fog, rain, snow, smoke or dust reduce the daytime or nighttime visibility of other vehicles to less than 500 ft. (152 meters). The headlights must be switched on. Note that local regulations governing the use of these lights may vary.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (13 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Auxiliary front fog lights (optional on certain models) Auxiliary front fog lights can be switched on only with the low-beam headlights on.

Power antenna The power antenna switch can be used to retract the antenna when the audio system is turned on. This will permit operation of the cassette drive with the antenna in the down position.

CAUTION: Always lower the antenna when entering a garage or car wash to avoid antenna damage.

pg. 17 Rear window demister, Heated front seats

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (14 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Rear window demister To operate, depress the switch. The indicator lamp in the switch will come on. The system will be switched off automatically after 10-15 minutes or when the starting (ignition) key is switched off.

Heated front seats The front seats are equipped with electrically- heated backrests and seat cushions. The heating is thermostatically-controlled and cuts out automatically. Use the switches to disengage the seat heating manually when the seat is not occupied.

Extra heating (certain models) The switch has two positions, one for normal heating and one for extra heating. Right position = normal heating Left position = extra heating

pg. 18 Parking brake, Cigarette lighter, Ash trays

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (15 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Parking brake (hand brake) The lever is situated between the front seats. The brake is applied to the rear wheels.

Always use the parking brake (hand brake) when parking. On hills, also turn the front wheels toward the curb.

In order to obtain the best possible performance of the parking brake, the brake linings should be broken in. See section titled "Brake system".

Cigarette lighter To operate, depress the knob fully. When the knob automatically releases, the cigarette lighter is ready for use. The starting (ignition) switch must be switched on (to position I or II) for the cigarette lighter to function.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (16 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Ash trays To remove the ash trays depress the center spring and remove.

pg. 19 Electrically operated windows

Electrically-operated windows (GLE, Turbo models) The electrically operated windows are controlled by switches from the driver's armrest as shown in the above illustration. The starting (ignition) switch must be ON (position II) for the electrically operated windows to function. The window is lowered if the rear part of the switch is pressed and raised if the front part of the switch is pressed.

WARNING! Remove the starting (ignition) key when children are left unattended in the vehicle.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (17 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Cut-out switch for electrically-operated rear-door windows If the car is equipped with rear door power windows, this function can be disabled by a switch located on the driver's door armrest. This switch is positioned 90° in relation to the other switches.

The rear door windows can be raised or lowered with the respective door switch as well as the

switch on the driver's door.

The rear door windows cannot be raised or lowered with the respective door switch but instead only

with the corresponding switch on the driver's door.

pg. 20 Heating and ventilation

Heating and ventilation Your Volvo is equipped with:

● Heating system

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (18 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

● Heating system combined with air conditioning.

Depending on which function you select, warm of cool/cold air is distributed to the different parts of the passenger compartment. An additional driver's air louver is located beneath the steering column and can be adjusted upwards, downwards, or closed as desired.

Air louvers (dash) A Open B Closed C Directing air flow horizontally D Directing air flow vertically A certain amount of air will always enter through the dash air louvers as long as they are open, independently of the position of the air distribution control. Close the dash air louvers to obtain maximum air flow to floor or windshield.

pg. 21 Heating and ventilation

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (19 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Recirculation interior air enters through panel vents. Very little air is drawn from outside. use this

position to avoid circulating dense exhaust gases (as when driving through a tunnel). Do not use this position for more than 10-15 minutes as very little fresh air will be supplied.

On the system without air conditioning these two symbols represent identical functions.

Always keep the air inlet in front of the windshield clear of snow in winter.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (20 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

pg. 22 Heating and ventilation

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (21 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

* Air conditioning unit not engaged.

pg. 23 Heating and ventilation

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (22 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Additional information and tips

● The air conditioning compressor is engaged only if the temperature is above 46°F (+8°C).

● In all three air conditioning positions the fan runs at speed 1 if the switch is at "0". This is a safety

measure to prevent formation of ice in the system.

● When the outside air is contaminated with exhaust gases, smoke, etc. (as when driving through a

tunnel), move the lever to for a few minutes. In this position very little air is drawn in to the passenger compartment from outside. Do not, however, leave the lever in this position for more than 10-

15 minutes, since hardly any fresh air is being supplied. Regulate the temperature with the temperature control lever.

● The air conditioning unit functions best if used regularly.

Always keep the air inlet grill in front of the windshield clear of snow in winter.

pg. 24 Audio Cassette/Tuner controls and indicators

For complete operating instructions, maintenance guidelines, and specifications, please consult your Audio Cassette/Tuner Instruction Booklet. The Booklet also contains information on radio reception and the radio antenna.

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (23 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

Contents | Top of Page

file:///K|/ownersdocs/1987/1987_740/87740_01.htm (24 of 24)12/30/2006 7:54:28 AM

1987 Volvo 740

1 9 8 7

VOLVO

740

Body and interior

pg. 25 Body and interior

The seats, seat belts, doors, etc. are described on the following pages.

Rear-view/side-view mirrors

Interior light, sun roof

Front seats

Child safety

Seat belts

Doors and locks

Trunk, long load storage

Hood

Passenger compartment, storage spaces

Station wagon tailgate, storage spaces

Folding rear seat (wagon)

Cargo space lighting, spare tire, jack (wagon)

pg. 26 Rear/ side-view mirrors

file:///K|/ownersdocs/1987/1987_740/87740_02.htm (1 of 22)12/30/2006 7:54:30 AM

1987 Volvo 740

Rear-view mirror A Normal position B Night position, reduces glare from following headlights

Side-view mirrors Use the lever to adjust.

file:///K|/ownersdocs/1987/1987_740/87740_02.htm (2 of 22)12/30/2006 7:54:30 AM

1987 Volvo 740

Make-up mirror The make-up mirror is located on the right-side sun visor. Make-up mirror lighting: (GLE, Turbo models) A - OFF B - ON

CAUTION: Never use ice scrapers made of metal as they can easily scratch the mirror surface.

The mirrors should always be adjusted before driving.

pg. 27 Interior light, Sun roof

Interior light

1. Light always on.

2. Light always off.

3. Light is on when either of the front or rear doors are opened.

file:///K|/ownersdocs/1987/1987_740/87740_02.htm (3 of 22)12/30/2006 7:54:30 AM

+ 102 hidden pages