Viking VRCI1240GRSS Installation Guide

F20868A EN (020113)

Viking Range Corporation

111 Front Street

Greenwood, Mississippi 38930 USA

[phone]

For product information,

call 1-888-845-4641

U

L

C

U

L

Installation Guide

15”W./24”W.

Undercounter Refrigeration

IMPORTANT – PLEASE READ AND FOLLOW

• Before beginning, please read these instructions completely and carefully.

• DO NOT remove permanently affixed labels, warnings, or plates from the product. This may

void the warranty.

• Please observe all local and national codes and ordinances.

• Please ensure that this product is properly grounded.

• The installer should leave these instructions with the consumer who should retain for local

inspector’s use and for future reference.

It is your responsibility to be sure your undercounter refrigeration is:

• located so the front is not blocked to restrict incoming or discharge air flow.

• properly leveled.

• located in a well ventilated area.

• connected to the proper kind of outlet, with the correct electric supply and grounding. A

115V, 60 Hz, 15 amp fused electrical supply is required.

Note: Time delay fuse or circuit

breaker is recommended.

• not used by anyone unable to operate it properly.

• used only for its intended purpose.

• properly maintained.

•SAVE THESE INSTRUCTIONS•

WARNING

To reduce the risk of fire, electric shock, or injury when using your unit, follow these basic precautions:

• Read all instructions before using the unit.

• Never allow children to operate, play with, or crawl inside the unit.

• Never clean unit parts with flammable fluids. The fumes can create a fire hazard or explosion.

• Always turn the power on/off switch (located behind the air grille on top right side) to the OFF position

before attempting to change light bulbs, clean, or service the unit.

FOR YOUR SAFETY

DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND LIQUIDS IN THE VICINITY OF

THIS OR ANY OTHER APPLIANCE. THE FUMES CAN CREATE A FIRE HAZARD OR EXPLOSION.

Table of Contents

32

IMPORTANT–Please Read and Follow!

A GFI

shall be used if required by NFPA-70 (National Electric Code), federal/state/local

laws, or local ordinances.

• The required use of a GFI is normally related to the location of a receptacle with respect to

any significant sources of water or moisture.

• Viking Range Corporation will NOT warranty any problems resulting from GFI outlets which

are not installed properly or do not meet the requirements below.

If the use of a GFI is required

, it should be:

• Of the receptacle type (breaker type or portable type NOT recommended)

• Used with permanent wiring only (temporary or portable wiring NOT recommended)

• On a dedicated circuit (no other receptacles, switches or loads in the circuit)

• Connected to a standard breaker of appropriate size (GFI breaker of the same size NOT

recommended)

• Rated for Class A (5 mA +/- 1 mA trip current) as per UL 943 standard)

• In good condition and free from any loose-fitting gaskets (if applicable in outdoor situations)

• Protected from moisture (water, steam, high humidity) as much as reasonably possible.

Warnings & Important Information_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 3

Proper Disposal _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 4

Dimensions (15”W. Professional)_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 5

Dimensions (24”W. Professional)_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 6

Dimensions (24”W. Professional)_ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 7

Specifications _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 8

Cutout Dimensions _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 9

General Information _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 10

Anti-Tip Brackets _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 12

Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 13

Kickplate Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 15

Installation Checklist _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 16

Service Information _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 17

DANGER

RISK OF CHILD ENTRAPMENT

Before You Throw Away Your Old Refrigeration Unit:

• Take off the doors.

• Leave the shelves in place so that children may not easily climb inside.

IMPORTANT: Child entrapment and suffocation are

not problems of the past. Junked or abandoned

refrigeration units are still dangerous—even if they

will sit for “just a few days”. If you are getting rid of

your old refrigeration unit, please follow these

instructions to help prevent accidents.

IMPORTANT: Now that you have a new refrigeration

unit, it is extremely important that you dispose of

your old appliance in a way that minimizes the

possibility that children will find it. There have been

many cases in years past of children crawling inside

junked and abandoned refrigeration units and

becoming trapped or suffocated.

Contact your municipal waste disposal authority to

find out the best and safest way to dispose of your old

refrigeration unit.

5-1/16”

(12.9 cm)

94.0° Swing

required for

pull-out shelf

clearance

2-3/16”

(5.6 cm) min.

clearance

from a corner

to achieve 94°

door swing

15-25/32”

(40.1 cm)

min. clearance

for door swing

Power cord 6-5/8”

(16.8 cm) off floor.*

50” (127.0 cm) area in which

electrical outlet must be located

Door Swing

22-1/16”

(56.0 cm)

24-1/16”

(61.1 cm)

26-9/16”

(67.5 cm)

34-1/4”

(87.0 cm)

min.

to

35”

(89.0 cm)

max.

14-7/8”

(37.8 cm)

1

4

-

7

/

8

”

(

3

7

.

8

c

m

)

14-7/8”

(37.8 cm)

30-1/8”

(76.5 cm)

Proper Disposal (of old refrigeration unit)

54

DANGER

Altering, cutting of the power cord, or removal of the power cord, removal of power plug, or

direct wiring can cause serious injury, fire and/or loss of property and/or life and will void the

warranty.

WARNING

• Never attempt to repair or perform maintenance on the unit until the electricity has been

disconnected.

• The anti-tip kit must be installed on this unit before it is used. Never use the drawers,

shelves or doors as steps or to support more than they were designed to support.

CAUTION

• Do not lift unit by drawer or door handles.

• Failure to clean the condenser every three months can cause the unit to malfunction. This

could void the warranty.

• Never install the unit behind closed doors. Be sure front louvered kickplate is free of

obstruction. Obstructing free airflow can cause unit to malfunction, and may void warranty.

Dimensions (15”W. Professional)