Viking VQGPB5200LSS, VQGSB5130NSS Installation

PROFESSIONAL GRILL ACCESSORY

CARE & USE/INSTALLATION

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION

WARNINGS

WARNING

READ THIS MANUAL CAREFULLY and completely before using your grill to reduce the risk of:

1. Fire

2. Burn hazard, personal injury or property damage

3. Ruined steaks or other unpleasant cooking experiences

4. Unapproved installation or servicing.

THIS PRODUCT IS DESIGNED FOR OUTDOOR USE ONLY. Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.

Read this manual thoroughly before installation, use, or servicing of this product.

DANGER

IF YOU SMELL GAS:

1. Shut off all gas supply lines to the grill accessory.

2. Extinguish any open ﬂames.

3. Carefully open the lid. Remember, it may be extremely hot!

4. If odor continues, keep everyone away from the grill accessory and immediately call your gas supplier or your ﬁre department.

WARNING

1. DO NOT store or use gasoline or other ﬂammable vapors and liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

DANGER

S’IL Y A UNE ODEUR DE GAZ:

1. Coupez l’admission de gaz de l’appariel.

2. Éteindre toute ﬂamme nue.

3. Ouvrir le couvercle.

4. Si l’odeur persiste, éloignez-vous de l’appareil et appelez immédiatement le fournisseur de gaz ou le service d’incendie.

AVERTISSMENT

1. Ne pas entreposer ni utiliser de l’essence ni d’autres vapeurs ou liquides inﬂammables dans le voisinage de l’appareil, ni de tout autre appareil.

2. Une bouteille de propane qui n’est pas raccordée en vue de son utilisation, ne doit pas être entreposée dans le voisinage de cet appareil ou de tout autre appareil.

WARNING! CALIFORNIA PROPOSITION 65

1. The burning of gas cooking fuel generates some by-products which are on the list of substances which are known by the State of California to cause cancer or reproductive harm.

2. California law requires businesses to warn customers of potential exposure to such substances. To minimize exposure to the substances, always operate this unit according to the use and care instructions found in this manual. Be certain to provide adequate ventilation when cooking.

3. California Proposition 65 lists “Silica, crystalline” which is used in one of the components of the IR burner, as an agent known to the state of California to cause cancer.

WARNINGS

To obtain replacement parts or service contact:

Viking Range, LLC Preferred Customer Service

111 Front Street Greenwood, Mississippi 38930

888-845-4641

WARNING

• Never use dented, rusty or damaged propane cylinders. Never store additional or empty propane cylinders in the cabinet or in the vicinity of this or any other appliance. Do not store propane cylinders indoors or on their sides.

• Children should never be left alone or unattended in an area where an accessory is located. Place your accessory well away from areas where children play. Do not store items that may interest children in or around the area of your accessory, in your accessory cart, or in the masonry enclosure.

• Never move the accessory when hot. When in use, portions of the accessory are hot enough to cause severe burns.

• Always maintain the required clearances from combustibles as detailed. Accessories are designed for outdoor use only. Never use in a garage, building, shed, breezeway, or other enclosed area. Do not use this equipment under any unprotected overhead combustible construction.

• Grill accessories are not designed or certiﬁed for and are not to be installed in or on recreational vehicles, portable trailers, boats or any other moving installation.

• Always have an ABC Fire Extinguisher accessible — never attempt to extinguish a grease ﬁre with water or other liquids.

• Storing your accessory: Store your accessory in a well-ventilated area. If stored indoors, detach and leave LP cylinder outdoors in a well-ventilated area away from heat and away from where children may tamper with it.

• Keep any electrical supply cord and the fuel supply hose away from any heated surfaces. Electrical cords should be placed away from walkways to avoid tripping hazard.

• Do not repair or replace any part of the accessory unless speciﬁcally recommended in this manual. Other service should be performed by a qualiﬁed technician.

• If the accessory is installed by a professional installer or technician, be sure that he/she shows you where your gas supply shut-off is located. All gas lines must have a shut-off that is readily and easily accessible. If you smell gas, check for gas leaks immediately. Check only with a soap and water solution. (See INDEX: “Leak Testing” for further details.) Never check for gas leaks with an open ﬂame.

• Inspect the LP gas supply hose prior to each use of the accessory. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced before using the accessory.

• Never remove the grounding prong from the plug or use this product with an ungrounded, 2-prong adapter.

THIS MANUAL MUST REMAIN WITH THE PRODUCT OWNER FOR FUTURE REFERENCE.

This product complies with ANSI standard Z21.58/CSA

1.6 latest edition and has been tested and approved by Intertek.

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION |3

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION

WARNINGS

WARNING

1. The outdoor cooking gas appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of 0.5 psi (3.5 kPa).

2. The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psi (3.5 kPa).

STATE OF MASSACHUSETTS

1. Massachusetts requires all gas be installed using a plumber or gas ﬁtter carrying the appropriate Massachusetts license.

2. All permanently-installed natural gas or propane installations require a “T” handle type manual gas valve be installed in the gas supply line to this appliance.

3. This does not apply to portable propane installations using a 20 pound cylinder.

WARNING - ELECTRICAL GROUNDING

• Product installation must meet local electric codes or, in the absence of local codes, the latest edition of the

National Electrical Code ANSI/NFPA No. 70 or the Canadian Electrical Code CGA 1.6b2005.

• Use only a Ground Fault Interrupter (GFI) protected circuit with this outdoor cooking gas appliance.

• This accessory is equipped with a three prong (grounding) electric plug for your protection against shock hazard

and must be plugged directly into a properly grounded three prong outlet. Never cut or remove the grounding prong from this plug.

• Use only extension cords with a 3 prong grounding plug, rated for the power of the equipment, and approved

for outdoor use with a “W-A” marking.

• To protect against electric shock, do not immerse any part of the power cord, an extension cord or any plugs in

water or other liquid.

• Unplug the product from the outlet when not in use and before cleaning. Allow it to cool before putting on or

taking off parts.

• Do not let the cord hang over the edge of a table or touch hot surfaces.

• Do not operate any outdoor cooking gas appliance with a damaged cord, plug, or after the appliance

malfunctions or has been damaged in any manner. Contact the manufacturer for repair.

TABLE OF CONTENTS

USING YOUR ACCESSORY 6

Accessories Covered in this Manual 6

HOW TO LIGHT YOUR ACCESSORY 6 BEFORE YOU START 7

If Shipment Arrives Damaged 7 Important Notes 7

SPECIFICATIONS & INSTALLATION 9 GAS CONNECTIONS 10

Natural Gas 10 LP Gas 11 LP Connections 11

Gas Conversion Kits 11 ELECTRICAL CONNECTIONS 13 Testing the Installation 14

Leak Testing 14

IMPORTANT SAFETY PRECAUTIONS 15 A MESSAGE TO OUR CUSTOMERS 16

USING THE POWER BURNER 17

Smell of Gas While Cooking 17

Yellow Flames 17

LIGHTING INSTRUCTIONS FOR ALL ACCESSORIES 18

Safety Practices and Precautions 18

At Each New Season 18

Purging the Gas Lines 18

Match Lighting 18

Low Heat Flame Adjustment 19

CONTACTING CUSTOMER SERVICE 20 SCHEMATICS 21 VIKING RANGE, LLC LIMITED WARRANTY 22 VIKING RANGE, LLC COMMON AREA LIMITED WARRANTY 23 INDEX 24

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION |5

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION

ACCESSORIES COVERED IN THIS MANUAL

USING YOUR ACCESSORY

This manual covers several accessory appliances and optional accessories for those appliances.

Except where noted, the assembly, installation and use of these accessories is identical.

POWER BURNER

MODEL VQGPB5200(N/L)SS The Power Burner is a dual-ring commercial style burner with a range of 3,000 to 47,000 BTU’s.

HOW TO LIGHT YOUR GRILL ACCESSORY

1. Before each use, complete the checklist below.

2. Make sure all burner control knobs are in the “OFF” position.

3. Push and hold the control knob for 5-7 seconds, allowing the igniter to heat up.

4. Turn the knob to the “LITE” position.

5. After ignition set the knob to the desired setting.

DOUBLE SIDE BURNER

MODEL VQGSB5130(N/L)SS

The double side burner features two 15,000 BTU burners for cooking smaller food items. The side burner is designed for installation in a non-combustible, built-in enclosure.

CHECKLIST BEFORE EACH USE (FOR YOUR SAFETY)

• Do you smell gas? If yes, shut off everything and call the gas company or a qualiﬁed plumber to check for leaks, if not please continue.

• Are you prepared to stay with the side burner during the entire cooking process? If not, gather what you need before starting the lighting process. If yes, please continue.

• Is your cooking area free and clear of any combustibles, besides your food, that might ignite? If no, clear the area before starting the lighting process, If yes, please continue.

• Do all control knobs turn freely? If not, call for service; if yes, please continue.

• If you are using a portable propane cylinder, is it connected and leak tested? If not, check the connection before continuing. If yes please continue.

• Do you know where your side burner’s main gas supply shut-off valve is located? If not, locate it before continuing. If yes, please continue.

• Are all burners properly seated in the side burner? If not, seat the burners properly before continuing. If yes please continue.

• Is the wind blowing just lightly and not blowing on the side burner? If not, wait until the wind subsides and then continue with the lighting process.

BEFORE YOU START

WARNING

• Never install this product into a combustible enclosure. Doing so could result in ﬁre, property damage and personal injury.

• Never locate the accessory under a roof or overhang, in a building, garage, shed or other such enclosed area.

• Installation must conform with local codes or, in the absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, or Natural Gas and propane Installation Code, CSA B149.1, or Propane Storage and Handling Code, B149.2, in Canada.

IF SHIPMENT ARRIVES DAMAGED

VISIBLE LOSS OR DAMAGE

Be certain any visible damage to the carton is noted on freight bill or express receipt and signed by the person making delivery.

FILE CLAIM FOR DAMAGES IMMEDIATELY, regardless of extent of damage.

IMPORTANT NOTES

WHERE’S THE WIND?

When selecting a suitable location, consider important factors such as exposure to the wind and foot-trafﬁc patterns.

If you have a freestanding grill, position it so the prevailing wind blows into the front control panel (at your back when grilling), supporting the proper front-to-rear airﬂow.

Built-in accessories located in areas with prevailing winds should be protected by a wind barrier.

CONCEALED LOSS OR DAMAGE

If damage is unnoticed until the accessory is unpacked, nontify the transportation company or carrier immediately and ﬁle a “concealed damage” claim with them. This should be done within (15) days of the date delivery is made to you. Be sure to hold on to the container for inspection. We cannot assume responsibility for damage or loss incurred in transit. (See INDEX: “Obtaining Service” for further details.)

ARE YOU “ON-THE-LEVEL”?

Proper leveling during installation is critical. An accessory that is out of level will cause erratic burner combustion and inefﬁcient, uneven heating. A carpenter’s spirit level should be used to level the accessory both front-to-back and side-to-side.

If the ﬂoor is uneven or has a decided slope, re-leveling may be required each time you move a freestanding unit.

HOW LONG IS YOUR RUN?

Keep all gas supply lines as short as possible because gas lines lose pressure over distance and with each elbow and tee that is added. This drop in pressure affects accessory performance. (See INDEX: “Gas Supply Line Runs” for further details.)

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION |7

SIDE BURNER ACCESSORY CARE & USE/INSTALLATION

BUILT-IN INSTALLATIONS

BEFORE YOU START...continued

CLEARANCE TO COMBUSTIBLE MATERIALS

Built-in accessories are intended for installation in a built-in enclosure constructed of non-combustible materials.

The accessory drops into the opening shown in the cutout detail drawing and hangs from its counter-top trim. A deck is not required to support it from the bottom.

Pay special attention to the provisions shown for gas line hook-up. (See INDEX: “Cut-out Dimensions for Built-in Grills & Accessories”)

Installation provisions may be made for the power burner installation. The power burner cooking height may be reduced to better accommodate large cooking pots. Clearances to combustible material must be maintained as outlined below. No combustible material shall be used in the construction of a counter top using a recessed application.

The enclosure should have ventilation holes to prevent gas build-up in the event of a leak. The counter should be ﬂat and level. (Refer to ANSI Z21.58 Standard for Outdoor Cooking Gas Appliances, Section 1.7 Enclosures For Self Contained LP-Gas Supply Systems or local codes for additional information.)

Minimum clearance from the sides and back of the accessory to adjacent combustible construction below the counter top is 12” from the sides and back.

Dégagement minimal entre les parois latérales et l’arrière de l’appariel et la construction combustible au-dessous du panneau supérieur de l’appareil (30 cm à partir des parois latérales et 30 cm à partir de l’arrière).

Minimum clearance from sides and back of unit to adjacent combustible construction extending above the counter top is 18” from the sides and back.

Dégagement horizontal minimal entre les parois latérales et l’arrière de l’appariel et la construction verticale combustible au-dessus de l’appareil (45.7 cm à partir des parois latérales et 45.7 cm à partir de l’arrière).

Do not use this appliance under unprotected overhead combustible surfaces.

Ne pas utiliser cet appareil sous une surface combustible.

The grill accessory may be powered from either a 120 volt, 60 hertz, 15 amp GFI certiﬁed outlet installed by a qualiﬁed electrician OR it may be powered directly from your grill transformer power supply.

When a grill is not available or if the grill is not located close enough to the accessory a LASK (Accessory Switch Kit) is available as an optional purchase.

+ 17 hidden pages