Page 1
Service Manual
ViewSonic VX700-3
Model No.VLCDS26104-3W
17” Color TFT LCD Display
(VX700-3_SM_648 -Rev.1a-Feb 2003)
ViewSonic
381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583
Page 2
Copyright
Copyright¤ 2002 by ViewSonic Corporation. All rights reserved. No part of this publication may be
reproduced, transmitted, transcribed, stored in a retrieval system, or translated into any language or
computer language, in any form or by any means, electronic, mechanical, magnetic, optical, chemical,
manual or otherwise, without the prior written permission of ViewSonic Corporation.
Disclaimer
ViewSonic makes no representations or warranties, either expressed or implied, with respect to the
contents hereof and specifically disclaims any warranty of merchantability or fitness for any particular
purpose. Further, ViewSonic reserves the right to revise this publication and to make changes from time
to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or
changes.
Trademarks
ViewSonic is a registered trademark of ViewSonic Corporation.
All other trademarks used within this document are the property of their respective owners.
Revision History
Revision Date Description Of Changes Approval
1a 02/07/03 Initial Reversion DCN-3052 C.Shen
!
ViewSonic Corporation
j!
Confidential – Do Not Copy VX700-3
Page 3
Content
1. Engineering Specifications . ...........................................................................................1
1. Scope ..........................................................................................................................1
2. Electrical Characteristics .............................................................................................4
3. Mechanical Characteristics .......................................................................................14
4. Packaging .................................................................................................................15
5. Environmental Characteristics...................................................................................15
6. Factory setting...........................................................................................................15
Appendix I Preset Signal Timings ..............................................................................17
Analog timing mode table.......................................................................................18
Digital timing mode table........................................................................................20
Appendix II EDID Code...............................................................................................23
Analog....................................................................................................................23
Digital .....................................................................................................................23
Appendix III Label Printing..........................................................................................25
ID LABEL ...............................................................................................................25
Bar Code label/Serial No Label ..............................................................................25
2. Front Panel Function Control Description...................................................................26
1. User control functions................................................................................................26
2. OSD operation flow ...................................................................................................27
3. Circuit Description .........................................................................................................38
1. Interface Board..........................................................................................................38
2. Audio Board ..............................................................................................................42
4. Troubleshooting Flow Chart .........................................................................................45
1. Figure of Waveform...................................................................................................45
2. No Display on Screen (Screen is black, LED is off)...................................................48
3. No Display on Screen ( LED is green).......................................................................49
4. No Power On.............................................................................................................50
5. No Sound (Test signal: 1r.m.s sine waveform ) .........................................................51
6. Show “No Signal” on screen......................................................................................53
7. Keypad can not work.................................................................................................53
5. Adjust Procedure ...........................................................................................................54
1. Preparation Of Manual Alignment .............................................................................47
2. Color Temperature Alignment....................................................................................48
3. Factory Preset Setting...............................................................................................50
!
ViewSonic Corporation
jj!
Confidential – Do Not Copy VX700-3
Page 4
6. Mechanical Assembly....................................................................................................59
7. Sche matic Daigrams......................................................................................................65
8. PCB LAYOUT..................................................................................................................74
9. Recommended Spare Parts List ...................................................................................76
10. Complete Parts List .....................................................................................................78
ViewSonic Corporation
jjj!
Confidential – Do Not Copy VX700-3
Page 5
1. Engineering Specifications
1. Scope
The following specifications are applicable to model VX700-3 17 inch color LCD monitor.
General Description (VX700-3 )
LCD
Chi-Mei 17.0” SXGA TFT- MVA (premium)
Size
Effective Display Size
Pixel Pitch
Resolution
Brightness
Contrast Ratio
Color
Viewing Angle
Surface treatment
Input Signals RGB
Analog 0.7 Vp-p /
75ȍ
17.0 inches diagonal
337.92 mm X 270.34 mm (typical)
0.264 mm X 0.264 mm
1280 x 1024 dot (SXGA)
250 cd / m² (typ.), 200 min.
(500):1(typ.), 350 min.
16,777,216
Up 85° Down 85° (typical)
Left 85° Right 85°(typical)
CR>10:1
Anti-Glare
Positive Polarity
TTL level
Separate sync.
Composite sync
Sync-On-Green
Digital
TMDS.
Input connector Analog mini D-sub 15 pin x 1
Digital DVI-D x 1
Audio min-Din 2 channel x 2
Micro-phone jack
Speaker Max 3W x 2
Main IC GM5120
!
ViewSonic Corporation
2!
Confidential – Do Not Copy VX700-3
Page 6
Display Colors 16,777,216
Preset Timings SXGA/60Hz, 75Hz,
XGA/60Hz, 70Hz, 75Hz, 85Hz
SVGA/56Hz, 60Hz, 72Hz, 75Hz, 85Hz
VGA/60Hz, 72Hz, 75Hz, 85Hz
Dos-text/70Hz
Synchronization Horizontal
Vertical
30 kHz to 83 kHz
50 Hz to 75 Hz
(automatically)
(automatically)
Non-interlaced
Max Pixel Rated
135Mhz
Resolution Horizontal
Vertical
Active Display
Area
Horizontal
Vertical
1280 dots
1024 lines
337.92 mm (typical)
270.34 mm (typical)
(Active display area is dependent upon signal timings)
Power Supply
AC adapter input AC90V-264V 50 / 60 Hz
Rating
AC Power
Consumption
45W
less than 3W
On mode
Off mode( w/o audio cable connected )
Current Rating AC input
DC input
Dimensions Net
Gross
Weight Net
Gross
Environmental
Conditions
Operating
Temperature
Operating Humidity
Storage Temperature
Storage Humidity
0.7A
4.0A
@AC 100-240V
@DC 12.0V
410 (W) x 432 (H) x 180.6 (D) mm
486 (W) x 525 (H) x 275 (D) mm
6.0Kg
8.7Kg
0 to 50°C (PANEL SURFACE)
20 to 80% ( no condensation, <
wetbulb 29 degree C )
-20 to 60°C
5 to 85% ( no condensation, <
wetbulb 29 degree C )
ViewSonic Corporation
!
3!
Confidential – Do Not Copy VX700-3
Page 7
Accessories AC power cord-UL
1.8m
Regulatory
Standards
AC power cord-Schuko
Analog VGA cable
DVI-D cable
Audio cable
Micphone cable
ViewSonic CD-Wizard
1.8m
1.8m
1.8m
1
1
1
UL, CSA or cUL, CB Report, CE, FCC-B, DOC-B, TUV/Ergo
(which covers ISO13406-2 and MPRIII), TUV/GS, PCT
(GOST-R) with 20 Hygienic certificates, PCBC (B Mark),
SEMKO, DEMKO, FIMKO, NEMKO, BSMI, VCCI, CCIB/EMC,
CCEE, PSB (Singapore Safety), TCO’99, NOM and Argentina
IRAM (thru TUV).
Osd Language English, French, German, Spanish, Finnish, Italian, Japanese,
Traditional Chinese, Simplified Chinese
Others Tilt Angle 20° up / 5° down
Power Saving System
User Control with On Screen Display- VESA DDC1/2B
compatible ( digital port DDC2B only)
!
ViewSonic Corporation
4!
Confidential – Do Not Copy VX700-3
Page 8
2. Electrical Characteristics
2.1 Power Supply
2.1.1 AC Input
Input Voltage AC90-264V
Frequency 47 / 63Hz
Power Consumption:
45 W (typ) on mode
Less than 3W power save mode (audio cable not connected)
Current Rating 0.7A @ AC100-240V
2.2 LCD
LCD Chi-Mei panel(TFT-MVA)
Effective display size 337.92 (H) x 270.34 (V) mm (typ)
17.0” / 43 cm diagonal
Pixel number 1280 x 1024 pixels
Color filter arrangement R.G.B. vertical stripe
Display method TFT, normally black
Drive method Active matrix (TFT) - MVA
Dot pitch 0.088 (H) x 0.264 (V) mm
Pixel pitch 0.264 (H) x 0.264 (V) mm
Dot number 1280 x 1024 x 3 dots
Backlight Edge-lighting type with 4 CCFLs
(Cold Cathode Fluorescent Tube)
Brightness 200 cd / m2(min: center / all white)
Contrast ratio 350:1 (min)
Display color 16,777,216
Typical viewing angle Up 85° / down 85° / right 85° / left 85°
(Contrast ratio>10 at Ta=25°C, 77°F)
Response time 25 msec (Typical at 25 degree C)
2.3 Interface Signals
2.3.1 RGB Video Signals
2.3.1.1 Separate Sync. Signals
Analog R, G, B 0 - 0.7 Vp-p
!
ViewSonic Corporation
5!
Confidential – Do Not Copy VX700-3
Page 9
Signal Level 75ȍ ± 5%
Sync Level TTL level
Sync Polarity independent
2.3.1.2 Sync On green, Composite Sync
2.3.2 TMDS digital Signals
2.3.2.1 Video type
DVI 1.0 complia nt
2.3.3 Audio spec.
2.3.3.1 Line input connection
3.5 mm stereo jack x 1
2.3.3.2 Line input signal & impedance
1.3Vrms, 10 kOhm
2.3.3.3 OUTPUT SIGNAL AT SPEAKER TERMINAL
3W @ < 5% DISTORTION
2.3.3.4 Frequency Response
400 Hz – 20 KHz
2.3.3.5 Connector PC99 requirement Audio in
Lime Green pantone # 577C
2.3.3.6 Cable length
1.8 m
2.3.3.7 Audio DPMS
Speakers stay on when the rest of the monitor is in power saving.
2.3.3.8 Speakers
Impedance 4 Ohm
Output Wattage 3.0W (max.) x 2
2.3.4 Input Signal Connectors
2.3.4.1 Analog RGB Video Input: 15 pin mini D-sub
ViewSonic Corporation
!
PIN NO. Separate Sync
1 RED
2 GREEN
6!
Confidential – Do Not Copy VX700-3
Page 10
3 BLUE
4 GROUND
5 GROUND
6 GROUND
7 GROUND
8 GROUND
9 +5V
10 GROUND
11 N.C
12 SDA
13 H.SYNC
14 V.SYNC
15 SCL
5 1
15
2.3.4.2 Digital TMDS DVI-D Connector
24 pin DVI-D connector pin assignment
Pin No. Signal Name Description
10
6
11
1 RX2- TMDS negative differential input, channel 2
2 RX2+ TMDS positive differential input, channel 2
3 GND Logic Ground
!
ViewSonic Corporation
4 Reserved 4 Reserved. No connection
5 Reserved 5 Reserved. No connection
6 DDC-CLK DDC2B Clock
7 DDC-DAT DDC2B Data
7!
Confidential – Do Not Copy VX700-3
Page 11
8 Reserved 8 Reserved. No connection
9 RX1- TMDS negative differential input, channel 1
10 RX1+ TMDS positive differential input, channel 1
11 GND Logic Ground
12 Reserved 12 Reserved. No connection
13 Reserved 13 Reserved. No connection
14 VCCX Power
15 GND Logic Ground
16 SENS SENSE Pin, Pull High
17 RX0- TMDS negative differential input, channel 0
18 RX0+ TMDS positive differential input, channel 0
19 GND Logic Ground
20 Reserved 20 Reserved. No connection
21 Reserved 21 Reserved. No connection
22 GND Logic Ground
23 RXC+ TMDS positive differential input, reference clock
24 RXC- TMDS negative differential input, reference
clock
2.3.4.3 Audio Connector
2.5 mm Stereo jack x 1,
3.5mm Microphone jack x 1
2.3.5 Signal Timing
2.3.5.1 User Timing Mode memory
Always do auto image adjust after timing mode change
2.3.5.2 Timing mode Change
Maximum time for mode Change with auto image adjust 7 sec.
2.3.5.3 Signal Timing Table
!
ViewSonic Corporation
8!
Confidential – Do Not Copy VX700-3
Page 12
The factory test input video signal is defined as the following table:
Pr
H.sync V.sync
No. Frequency Frequency H-SYNC
POL.
-SYNC
D
MOD [1] 31.468 ±1.0KHz 70.0 ±1.0Hz + - 640X350(70) Text mode
MOD [2] 31.468 ±1.0KHz 70.0 ±1.0Hz - + 720X400(70) Dos text
MOD [3] 31.468 ±1.0KHz 59.94 ±1.0Hz - - 640X480(60) VESA STANDARD
MOD [4] 35.01 ±1.0KHz 66.67 ±1.0Hz - - 640X480(66) MAC
MOD [5] 37.86 ±1.0KHz 72.81 ±1.0Hz - - 640X480(72)
ESA STANDARD
MOD [6] 37.5 ±1.0KHz 75.0 ±1.0Hz - - 640X480(75) VESA STANDARD
MOD [7] 43.27 ±1.0KHz 85.0 ±1.0Hz - - 640X480(85)
ESA STANDARD
MOD [8] 35.16 ±1.0KHz 56.25 ±1.0Hz + + 800X600(56) VESA STANDARD
MOD [9] 37.88 ±1.0KHz 60.32 ±1.0Hz + + 800X600(60) VESA STANDARD
MOD [10] 48.077 ±1.0KHz 72.19 ±1.0Hz + + 800X600(72)
MOD [11] 46.875 ±1.0KHz 75.0 ±1.0Hz + + 800X600(75)
ESA STANDARD
ESA STANDARD
MOD [12] 53.67 ±1.0KHz 85.0 ±1.0Hz + + 800X600(85) VESA STANDARD
MOD [13] 49.72 ±1.0KHz 74.5 ±1.0Hz - - 832X624(75) MAC
MOD [14] 48.363 ±1.0KHz 60.0 ±1.0Hz - - 1024X768(60) VESA STANDARD
n
MOD [15] 58.01 ±1.0KHz 72.08 ±1.0Hz - - 1024X768(72) VESA STANDARD
MOD [16] 60.023 ±1.0KHz 75.0 ±1.0Hz + + 1024X768(75) VESA STANDARD
MOD [17] 68.67 ±1.0KHz 85.0 ±1.0Hz + + 1024X768(85) VESA STANDARD
MOD [20] 63.981 ±1.0KHz 60.02 ±1.0Hz + + 1280X1024(60) VESA STANDARD
MOD [21] 79.976 ±1.0KHz 75.0 ±1.0Hz + + 1280X1024(75) VESA STANDARD
2.4 Luminance Control
Analog signal (6500K)
Over 200 cd / m2 (@ Cont / Bright max)
Digital signal (6500K)
Over 200 cd / m2 (@ Cont / Bright max)
2.5. Synchronization
Horizontal: 30 to 83 kHz
Vertical: 50 to 75 Hz Non-interlaced
maximum 75Hz @ 1280 x 1024 mode
Recommended 60Hz @ 1280 x 1024 mode
ViewSonic Corporation
8!
Confidential – Do Not Copy VX700-3
Page 13
2.6 Display Characteristics
2.6.1 Picture Size
Horizontal Width 337.92 mm (typical)
Vertical Width 270.34 mm (typical)
2.6.2 Optical Characteristics
General qualities: The following data was measured by BM7 of TOPCON
Data are panel optical data, for analog signal there are +- 5% tolerance.
Item Code Conditions Min. Typ. Max. Unit
Contrast CR
White
Brightness
L
VMAX
Uniformity of
Brightness
Response
Tpd All White ĺ All Black
At 25 degree
Right ĬR
Viewing Left ĬL
Angle Up ĭH
Down ĭL
White㧛Black at Image
Center
FULL White 200 250
Bmin
Bmax
All Black ĺ All White
CenterCR㧪10
350 (500)
70 80
㧙
10
15
㧙
㧙
㧙
㧙
85
85
85
85
㧙㧙
㧙
㧙
㧙
cd / m
2
%
ms
ms
Degree
㧙
Degree
㧙
Degree
㧙
Degree
㧙
Luminance
control
All White(digital signal
or analog 6500k)
Brightness at center of
>=200 (cont / bright
backlight max)
display surface
These characteristics were measured under the following conditions:
Temperature: 77 ± 6°F, 25 ± 5°C
!
ViewSonic Corporation
:!
Confidential – Do Not Copy VX700-3
Cd / m
2
Page 14
Viewing angle:
U = 0°, AR = 0°
A
Warm Up time: minimum 30 minutes
Measuring instrument: TOPCOM BM-7 Luminance Meter
Measuring distance: 500 mm
Measuring angle: 2°
500mm
BM-7
2 Degree
Notes:
(Note 1) Contrast ratio is defined as the following formula.
Brightness(Luminance) with all pixels at "w h i t e "
Bri
Contrast ratio =
htness with allpixels at "black"
(Note 2) Viewing angle is measured as follows:
0QTOCN
Ǿࠑǰࠑ
ǰ .ࠑ
:
QENQEM
;
Ǿ .ࠑ
ǰ.
Ǿ.
’
Ǿ*
ǰ4
QENQEM
Ǿ *ࠑ
;
’
:
ǰ 4ࠑ
(Note 3) Definition of response time is as follows:
Response time is measured when the display data is changed from white to black.
!
ViewSonic Corporation
21!
Confidential – Do Not Copy VX700-3
Page 15
White(TFT OFF)
White
Optical
Response
Black(TFT ON) White(TFT OFF)
100
㧑
90
㧑
10
㧑
0
㧑
T
R
T
F
(Note 4) Judge points for brightness uniformity .
Brightness uniformity is judged at nine (9) points on display area:
128 512 896
98
384
670
(9)
(6)
(3)
(8)
(5)
(2)
(7)
(4)
(1)
Bmin
BUNI
㧩
Bmax
Bmax : Maximum Brightness
Bmin : Minimum Brightness
!
ViewSonic Corporation
22!
Confidential – Do Not Copy VX700-3
Page 16
2.6.3. LCD Panel
Mechanical
Active Area (mm) 337.92 x 270.34
Pixel pitch (mm) 0.264 (0.088x3)
Mass typical (g) 2200
Panel dimensions (WxDxH) mm 383.5x306x20 mm(typ)
Resolution 1280 x 1024
Surface Treatment with Haze value Anti-glare, 3H
Panel Model number M170E4-L02 (17” TFT)
Panel Interfaces Dual LVDS
Optical performance
Contrast ratio (500):1 Typical
350 :1 Minimum
Luminance of white(center) 250 nits Typical
200 nits Minimum
White Uniformity 75% (5 points measurement)
Chromaticity values (red, green, blue) center ‘x = +/- 0.030
‘y = +/- 0.030
Color temperature ‘x = 0.310 +/- 0.030
‘y = 0.330 +/- 0.030
EBU 85% Min
Colors True 8 bits (16.7M)
Viewing Angle H, V (CR >10) H= 170 deg, V= 170 deg
Film Used wide viewing film
Response time ms Typical Tr = 15ms ; Tf = 10ms
Maximum Tr = 30ms; Tf = 25ms
Number of Back Light(CCFL) 4 – Edge type back light
Backlight (hrs) 40,000 hours minimum; 50,000 hours typical
ViewSonic Corporation
!
23!
Confidential – Do Not Copy VX700-3
Page 17
2.7 Power Management
Unit will enter power saving mode under the following conditions:
Power Management condition and status
State Signals Power Video LCD LED
Horizontal Vertical Video Supply Circuit
On Pulses Pulses Active On On On Green
Stand-by No Pulses Pulses Blanking Off Off Amber
Suspend Pulses No
Off No Pulses No
Complete N/A N/A N/A Off Off
2.8 FullScan Capability
When the input display mode is not 1280x1024, the image area is changed as follows:
Flex Scan Input display Expanded Rate Expanded
Mode Mode Resolution Horizontal Vertical Resolution
Expansion 1 640x350 2 2.93 1280x1024
Expansion 2 640x400 2 2.56 1280x1024
Expansion 3 640x480 2 2.13 1280x1024
Pulses
Pulses
Expansion 4 720x400 1.78 2.56 1280x1024
Expansion 5 800x600 1.6 1.71 1280x1024
Expansion 6 832x624 1.54 1.64 1280x1024
Expansion 7 1024x768 1.25 1.33 1280x1024
Expansion 8 1152x864 1.11 1.19 1280x1024
Standard 1280x1024 1 1 1280x1024
ViewSonic Corporation
!
24!
Confidential – Do Not Copy VX700-3
Page 18
3. Mechanical Characteristics
3.1 Dimensions
Net: 410 (W) x 432 (H) x 181 (D) mm
Gross: 486 (W) x 525 (H) x 275 (D) mm
3.2 Weight
N e t : 6 . 0 K g
Gross: 8.7 Kg
3.3 Base Rotation
Tilt: up 20 ° / down 5 °
3.4 Labeling
3.4.1 ID Label (Paste on Rear Cover)
Material: Polyester’s
Color: Black (same as plastic color) / White (Letter)
Size: 50 (W) X 25 (H) mm
Location: Rear Back Label
Contents: Appendix III
3.4.2 Bar Code Number Label (Carton Box)
Material: Art Paper
Color: White (Base) / Black (Letter)
Size: 76 (W) X 76 (H) mm
Location: Carton Box (Side Wall)
Contents: Appendix III
3.4.3 Serial Number Label (Rear Back Label)
Material: Art Paper
Color: White (Base) / Black (Letter)
Size: 25 (W) X 50 (H) mm
Location: Paste on Rear Back Label
Contents: Appendix III
3.5 Serial Number Format
Serial No. PPP
YY WW XXXXX
!
ViewSonic Corporation
25!
Serial No. (5-digit)
Manufacturing week
Last digit of manufacturing year
Regional Product ID Code :
VX700 3 A23
Confidential – Do Not Copy VX700-3
Page 19
3.6 UPC Coding (Code 39 format)
Worldwide Model UPC Code: 766907 80253 5
4. Packaging
4.1 Carton Box
Dimensions: 486mm (W) x 525mm (H) x 275mm (D)
Color: 4-Color printing box
Material: BC-FLUTE or Equivalent, double wall
5. Environmental Characteristics
5.1 Operating Conditions
Temperature: 0 through + 40° C
Humidity: 8% To 80% (39 degree welt bulb)
Altitude: 0 – 3,000 Meter
5.2 Non-operating Conditions
Temperature: -20 through +60 ° C
Humidity: 5% To 95% (39 degree welt bulb)
Altitude: 0 – 12,000 meter
6. Factory setting
6.1 OSD
Brightness 100%(based on 0-100%)
Contrast 80 %( based on 0-100%)
AutoTune Executed
Color Temperature 6500k
V o l u m e 5 0 %
Balance 50%
Bass/Treble 50%
OSD Timeout 15 Sec
Language English
OSD position Center
6.2 Power Switch
OFF
!
ViewSonic Corporation
26!
Confidential – Do Not Copy VX700-3
Page 20
Appendix I Preset Signal Timings
H-Video
Horizontal
V-Video
Vertical
H active
H front H back
H pulse
H total
V active
V front
V pulse
V total
V back
!
ViewSonic Corporation
28!
Confidential – Do Not Copy VX700-3
Page 21
Analog timing mode table
1 2 3 4 5 6 7
Signal name symbolTEXT
mode
TEXT
mode
VGA MAC-II VESA-VGAVESA-VGAVESA-V
GA
H-frequency (kHz) 31.468 31.469 31.468 35.001 37.5 37.862 43.269
V-frequency (Hz) 70.087 70.087 59.941 66.667 75 72.807 85.005
Pixel rate (MHz) 25.175 28.322 25.175 30.240 31.5 31.501 36.000
H-sync Ths 96 108 96 64 64 40 56
H-back porch Thb 48 54 48 96 120 128 80
Count num
Thd 800 900 800 864 840 832 832
(H-total)
H- front porch Thf 16 18 16 64 16 24 56
V-sync Tvs 2 2 2 3 3 3 3
V-back porch Tvb 60 35 33 39 16 28 25
Count num
Tvd 449 449 525 525 500 520 509
(V-total)
V-front porch Tvf 37 12 10 3 1 9 1
H-sync. Polarity Positive Negative Negative NegativeNegative NegativeNegativ
e
V-sync Polarity Negative Positive Negative NegativeNegative NegativeNegativ
e
H-resolution (dots) 640 720 640 640 640 640 640
V-resolution (lines) 350 400 480 480 480 480 480
8 9 10 11 12 13 14
Signal name SymbolIBM-8514ASVGA SVGA SVGA SVGA MAC
XGA
16"
H-frequency (kHz) 35.156 37.879 48.077 46.875 53.674 49.725 48.363
V-frequency (Hz) 56.250 60.317 72.188 75.000 85.061 74.5 60.004
Pixel rate (MHz) 36.000 40.000 50.000 49.500 56.250 57.283 65.000
H-sync Ths 72 128 120 80 64 64 136
H-back porch Thb 128 88 64 160 152 224 160
ViewSonic Corporation
!
29!
Confidential – Do Not Copy VX700-3
Page 22
Count num
Thd 1024 1056 1040 1056 1048 1152 1344
(H-total)
H- front porch Thf 24 40 56 16 32 32 24
V-sync Tvs 2 4 6 3 3 3 6
V-back porch Tvb 22 23 23 21 27 39 29
Count num
Tvd 625 628 666 625 631 667 806
(V-total)
V-front porch Tvf 1 1 37 1 1 1 3
H-sync. Polarity Negative Positive Positive Positive Positive NegativeNegativ
e
V-sync Polarity Negative Positive Positive Positive Positive NegativeNegativ
e
H-resolution (dots) 800 800 800 800 800 832 1024
V-resolution (lines) 600 600 600 600 600 624 768
15 16 17 18 19 20 21
Signal name SymbolXGA XGA XGA XGA SXGA 720P SXGA
H-frequency (kHz) 56.476 58.099 60.023 68.677 63.981 79.976 45.000
V-frequency (Hz) 70.069 72.082 75.029 84.997 60.02 75.025 60.00
Pixel rate (MHz) 75.000 78.084 78.750 94.500 108 135 74.250
H-sync Ths 136 136 96 96 112 40 144
H-back porch Thb 144 160 176 208 248 270 248
Count num
Thd 1328 1344 1312 1376 1688 1658 1688
(H-total)
H- front porch Thf 24 24 16 48 48 60 16
V-sync Tvs 6 6 3 3 3 5 3
V-back porch Tvb 29 29 28 36 38 20 38
Count num
Tvd 806 806 800 808 1066 750 1066
(V-total)
V-front porch Tvf 3 3 1 1 1 5 1
!
ViewSonic Corporation
2:!
Confidential – Do Not Copy VX700-3
Page 23
H-sync. Polarity Negative Negative Positive Positive Positive Positive Negativ
e
V-sync Polarity Negative Negative Positive Positive Positive Positive Negativ
e
H-resolution (dots) 1024 1024 1024 1024 1280 1280 1280
V-resolution (lines) 768 768 768 768 1024 1024 720
Digital timing mode table
1 2 3 4 5 6 7
Signal name symbolTEXT
mode
TEXT
mode
VGA VGA VESA-VGAVESA-VGAVESA-V
GA
H-frequency (kHz) 31.468 31.469 31.468 31.468 37.5 37.862 43.269
V-frequency (Hz) 70.087 70.087 60.000 59.941 75 72.807 85.005
Pixel rate (MHz) 25.175 28.322 25.175 25.175 31.5 31.501 36.000
H-sync Ths 96 108 96 96 64 40 56
H-back porch Thb 48 54 48 48 120 128 80
Count num
Thd 800 900 800 800 840 832 832
(H-total)
H- front porch Thf 16 18 16 16 16 24 56
V-sync Tvs 2 2 2 2 3 3 3
V-back porch Tvb 60 35 35 33 16 28 25
Count num
Tvd 449 449 449 525 500 520 509
(V-total)
V-front porch Tvf 37 12 10 6 1 9 1
H-sync. Polarity Positive Negative Negative Negative Negative Negative Negative
V-sync Polarity Negative Positive Negative Negative Negative Negative Negative
H-resolution (dots) 640 720 640 640 640 640 640
V-resolution (lines) 350 400 400 480 480 480 480
ViewSonic Corporation
!
31!
Confidential – Do Not Copy VX700-3
Page 24
8 9 10 11 12 13 14
Signal name SymbolIBM-8514ASVGA SVGA SVGA SVGA XGA XGA
H-frequency (kHz) 35.156 37.879 48.077 46.875 53.674 48.363 56.476
V-frequency (Hz) 56.250 60.317 72.188 75.000 85.061 60.004 70.069
Pixel rate (MHz) 36.000 40.000 50.000 49.500 56.250 65.000 75.000
H-sync Ths 72 128 120 80 64 136 136
H-back porch Thb 128 88 64 160 152 160 144
Count num
Thd 1024 1056 1040 1056 1048 1344 1328
(H-total)
H- front porch Thf 24 40 56 16 32 24 24
V-sync Tvs 2 4 6 3 3 6 6
V-back porch Tvb 22 23 23 21 27 29 29
Count num
Tvd 625 628 666 625 631 806 806
(V-total)
V-front porch Tvf 1 1 37 1 1 3 3
H-sync. Polarity Negative Positive Positive Positive Positive Negative Negative
V-sync Polarity Negative Positive Positive Positive Positive Negative Negative
H-resolution (dots) 800 800 800 800 800 1024 1024
V-resolution (lines) 600 600 600 600 600 768 768
15 16 17 18 19
Signal name SymbolXGA XGA XGA SXGA HD-720P
H-frequency (kHz) 58.099 60.023 68.677 63.981 45.000
V-frequency (Hz) 72.082 75.029 84.997 60.02 60.00
Pixel rate (MHz) 78.084 78.750 94.500 108 74.250
H-sync Ths 136 96 96 112 40
H-back porch Thb 160 176 208 248 270
Count num
Thd 1344 1312 1376 1688 1658
(H-total)
ViewSonic Corporation
!
32!
Confidential – Do Not Copy VX700-3
Page 25
H- front porch Thf 24 16 48 48 60
V-sync Tvs 6 3 3 3 5
V-back porch Tvb 29 28 36 38 20
Count num
Tvd 806 800 808 1066 750
(V-total)
V-front porch Tvf 3 1 1 1 5
H-sync. Polarity Negative Positive Positive Positive Negative
V-sync Polarity Negative Positive Positive Positive Negative
H-resolution (dots) 1024 1024 1024 1280 1280
V-resolution (lines) 768 768 768 1024 720
ViewSonic Corporation
!
33!
Confidential – Do Not Copy VX700-3
Page 26
Appendix II EDID Code
Analog
128 BYTES OF EDID CODE:
0 1 2 3 4 5 6 7 8 9
________________________________________
0 | 00 FF FF FF FF FF FF 00 5A 63
10 | 11 8F 01 01 01 01 01 0C 01 03
20 | 0E 22 1B 78 2A 47 06 A5 5C 47
30 | 9C 25 1E 4F 54 BF EF 00 81 80
40 | 01 01 01 01 01 01 01 01 01 01
50 | 01 01 01 01 30 2A 00 98 51 00
60 | 2A 40 30 70 13 00 52 0E 11 00
70 | 00 1E 00 00 00 FF 00 41 32 33
80 | 30 32 30 31 30 30 30 30 31 0A
90 | 00 00 00 FD 00 32 4B 1E 53 0E
100 | 00 0A 20 20 20 20 20 20 00 00
110 | 00 FC 00 56 58 37 30 30 2D 33
120 | 0A 20 20 20 20 20 00 73
Digital
128 BYTES OF EDID CODE:
0 1 2 3 4 5 6 7 8 9
________________________________________
0 | 00 FF FF FF FF FF FF 00 5A 63
10 | 11 8F 01 01 01 01 01 0C 01 03
20 | 80 22 1B 78 2A 47 06 A5 5C 47
30 | 9C 25 1E 4F 54 BF EF 00 81 80
40 | 31 0A 01 01 01 01 01 01 01 01
50 | 01 01 01 01 30 2A 00 98 51 00
60 | 2A 40 30 70 13 00 52 0E 11 00
70 | 00 1E 00 00 00 FF 00 41 32 33
80 | 30 32 30 31 30 30 30 30 31 0A
90 | 00 00 00 FD 00 32 4B 1E 53 0E
100 | 00 0A 20 20 20 20 20 20 00 00
110 | 00 FC 00 56 58 37 30 30 2D 33
120 | 0A 20 20 20 20 20 00 C8
ViewSonic Corporation
!
34!
Confidential – Do Not Copy VX700-3
Page 27
Appendix III Label Printing
ID LABEL
Bar Code label/Serial No Label
ViewSonic VX700
Model Number: VLCDS26104-3W
Serial Number: A23YYWWnnnnn
ViewSonic
VX700
7 6 690 7 802 53 5
MODEL NUMBER: VLCDS26104-3W
SERIAL NUMBER: A23 YYWWnnnnn
Made In China
UPC
3
ViewSonic Corporation
!
36!
Confidential – Do Not Copy VX700-3
Page 28
2. Front Panel Function Control Description
1. User control functions
Control buttons:
-
+
1
2
1. Press power button to power on LCD monitor. Led on the power button will turn Green.
2. P ress ‘2” button while no OSD will toggle the digital input port and analog input port to display.
3. Press “up” and ‘down” button simultaneously will reset the contrast and brightness to default.
4. Press ‘1” button will enter OSD main menu.
5. P ress “volume plus”, “volume minus” can directly adjust the audio volume.
6. Press “mute” button can directly mute on or off the audio volume.
ViewSonic Corporation
!
37!
Confidential – Do Not Copy VX700-3
Page 29
2. OSD operation flow
The following steps show how to access the Main Menu, Submenus, and controls within each
Submenu. Details on the controls follow the steps listed below.
Note: Any OSD setting will only save after user totally exit OSD menu.
1 Press the [1] button to display the Main Menu shown below.
2 Press the [ ź] or [ Ÿ] button to scroll to the desired menu option.
3 Press the [2] button to select the menu option.
4 Press the [ ź] or [ Ÿ] button to select submenu option.
5 After making adjustments, press the [1] button exit the screen, must exit the OSD
to save the settings .
Main Menu
Auto Image Adjust
Contrast/Brightness
Input Select
Audio
Color Adjust
Information
Manual Image Adjust
Setup Menu
Memory Recall
1 : Exit 2 : Select
Auto Image Adjust
waviness and distortion. Press the [2] button to confirm to do auto adjust.
automatically sizes, centers, and fine tunes the video signal to eliminate
NOTE: Auto Image Adjust works with most common video card. If using the function
does n ot work on your ViewPanel®, Lower the video refresh rate to 60 Hz and
try again. (See computer or graphic card user guide to adjust refresh rate.) The
panel may be manually tuned using the horizontal and vertical phase controls
shown below.
!
ViewSonic Corporation
38!
Confidential – Do Not Copy VX700-3
Page 30
Contrast adjusts foreground white level of screen image.
[Ÿ ] increase contrast, [ź ] decease contrast.
Shortcut: Before displaying the OnView menu, press the [ź] or [Ÿ] button to adjust. Press
button [2] to toggle between brightness and contrast.
Brightness
adjusts backlight brightness level of screen image.
[Ÿ ] increase brightness, [ź ] decease brightness.
Input Select press [ź ] or [Ÿ ] button to select Input Source.
Audio press [ ź] or [ Ÿ] button to scroll desired menu option.
Press [2] button to select submenu option.
ViewSonic Corporation
!
39!
Confidential – Do Not Copy VX700-3
Page 31
Audio
Volume
Balance
Bass
Treble
Mute
1 : Exit 2 : Select
Volume increase the volume, decreases the volume,
Balance adjusts the proportion of sound coming from each speaker.
[ź ] directs more of the sound to the left speaker; [Ÿ ] directs more of the sound to the right
speaker.
Bass/Treble adjusts the high (treble) and low (bass) frequency audio output
Press [2] button to select bass adjustment.
Bass
press [ź ] or [Ÿ] to adjust bass.
ViewSonic Corporation
!
3:!
Confidential – Do Not Copy VX700-3
Page 32
Treble press [ ź] or [ Ÿ] to adjust treble.
!
ViewSonic Corporation
41!
Confidential – Do Not Copy VX700-3
Page 33
Mute
Color Adjust
Color Adjust provides four preset color adjustment: 9300K, 6500K, 5400K, 5000K for improved
brightness and color saturation. Press button [2] to select the preset color. Press button [ź] or
[Ÿ ] to fine tune the color response.
9300K —Adds blue to screen image for cooler white (used in most office settings
with fluorescent lighting).
6500K—Adds red to screen image for warmer white and richer red.
5400K—Adds green to screen image for a darker color.
5000K—Adds blue and green to screen image for a darker color.
User color
—Individual adjustments for red (R), green (G), blue(B).
1 To adjust selected color, press [ź ] or [Ÿ].
2 Press button [2] to set adjustment and select next color to adjust.
User Color
Red
-+
Green
Blue
-+
-+
- :
1 : Exit 2 : Select
!
ViewSonic Corporation
+ :
42!
Confidential – Do Not Copy VX700-3
Page 34
Information
Manual Image Adjust
VLCDS26104-3W
A23020101001
H/V Position Press the [2] button to select H-Position or V-Position.
H-Position
moves screen image left or right.
[ź] move screen image to left, [ Ÿ] moves screen image to right .
Press the [2] button to toggle between H. and V. Position.
V-Position moves screen image up or down.
[ź] move screen image down, [ Ÿ] moves screen image up .
ViewSonic Corporation
!
43!
Confidential – Do Not Copy VX700-3
Page 35
H-Size adjusts the width of screen image. [ź] decreases
Width of screen image, [Ÿ ] increases width of image.
Fine-Tune
Sharpness adjusts the cl arity of a non-SXGA (1280 x 1024) RGB signal Press [ ź]
Or [Ÿ ] to adjust.
ViewSonic Corporation
!
44!
Confidential – Do Not Copy VX700-3
Page 36
Setup Menu
Setup Menu
Language
Resolution Notice
OSD Position
OSD Timeout
OSD Background
Touch Tone
1 : Exit 2 : Select
Language Select allows the user to choose from available languages.
᧯խ֮
១᧯խ֮
ֲء
Resolution Notice
Notice.
ViewSonic Corporation
!
press the [ź ] or [Ÿ ] button to select the Enable or Disable the Resolution
45!
Confidential – Do Not Copy VX700-3
Page 37
Resolution Notice
Enable
Disable
1 : Exit
2 : Select
OSD Position press the [2] button to select the OSD H-Position or OSD V-Position.
OSD H-Position
[ź ] moves OSD left; [Ÿ ] moves the OSD right.
OSD V-Position [ź] moves OSD down; [ Ÿ ] moves the OSD up.
OSD Timeout sets the length of time the OnScreen Display screen is displayed before exiting.
ViewSonic Corporation
!
46!
Confidential – Do Not Copy VX700-3
Page 38
OSD Background
ViewSonic Corporation
!
47!
Confidential – Do Not Copy VX700-3
Page 39
Memory Recall
Returns the adjustments back to factory settings (only if the LCD Display is operating in a factory
preset mode).
Press the [2] button to select the Memory Recall menu option.
Note:
OSD Controls
Auto Image Adjust*, Contrast/Brightness, Input Select, Color Adjust [9300K, 6500K(default),
5400, 5000, R, G, B], Information [Mode, Model Number, Serial Number], Manual Image Adjust
[H. Size*, H. Position*, V. Position*, Fine Tune*, Sharpness], Setup Menu [Language,
Resolution Notice, OSD Position, OSD Timeout, OSD Background], Memory Recall
* These functions are not available in Digital Mode.
OSD Auto Save
Memory Recall is to recall the following functions to factory setting: Contrast, Brightness, H
Size, H/V Position, Color Temperature @ 6500K, OSD Position, Sharpness, & OSD Timeout.
The OSD shall save new settings when it is turned off by the user or when it times out. There
shall not be a separate save.
!
ViewSonic Corporation
48!
Confidential – Do Not Copy VX700-3
Page 40
3. Circuit Description
Function Block
1. Interface Board
1.1 Power Supply (DC/DC Converter)
IC100 is a linear regulator that converts a 12V DC input voltage into regulated and stable
output voltages of 5V respectively.
1.2 Micro-Controller
IC400 (scaler) built-in a micro-controller and extra a flash ROM (IC402---39SF010). It plays a
major role in the digital control of the LCD monitor. IC400 acts as a Key control, DPMS power
saving control, auto-detect controller, and controller of IC400 to do image process.
ViewSonic Corporation
!
49!
Confidential – Do Not Copy VX700-3
Page 41
Pin 114 controls Inverter enable or disable
Pin 113 enable vcc for panel
Pin 125 send a HI signal when audio is invalid
send a LOW signal when audio is valid
pin 5 receive HI signal from IC401 pin 3 to reset
pin 1, 4, 39, 43, 46, 47, 125, 206 make key function operate when press key button
(receive LOW signal from key button.)
2
pin 51, 52 communicate with IC404 (EEPROM) by I
C
pin 48 detect audio in
pin 51, 52 do ISP(in-system program)
Pin 40 controls the brightness of panel
Pin 41, 42 controls LED (orange and green) on /off
Pin 123 control audio board 12V on/off
Pin 126 control IC500, IC501 (LVDS Transmitter) on/off.
1.3. Image Processor
IC400 (gm5120) is an all-in-one image processor for displays with a dual (analog and digital) interface
supporting resolutions up to SXGA. It provides integrated ADC/PLL and a DVI compliant TMDS
receiver and MCU, a high quality zoom and shrink scaling engine, an on-screen display (OSD)
controller, a microprocessor and many other functions in a single device. This high level of integration
enables simple, flexible, cost-effective solutions featuring fewer required components.
The gm5120 chip has three ADC’s (analog-to-digital converters), one for each color
(red, green, and blue) and supports digital separate sync (HSYNC/VSYNC), digital composite
sync, and analog composite sync (also known as sync-on-green, or SOG). All sync types are
supported without the need for external sync separation / extraction circuits.
The gm5120 features four clock inputs. All additional clocks are internal clocks derived from one
or more of these four, using Direct Digital Synthesis (DDS).
TCLK is generated using an external crystal (recommended) or an external clock oscillator.
(1) Input Clock (TCLK). The external connection to the oscillator is via the TCLK and
XTAL pads. A 14.3MHz crystal source is recommended, as internal PLL and logic
ViewSonic Corporation
!
4:!
Confidential – Do Not Copy VX700-3
Page 42
circuits derive the required clock frequencies from this single source by default. Other
crystal frequencies may be used, but require custom bootstrapping and programming. In
lieu of using a crystal oscillator, XTAL can be driven by a single-ended TTL/CMOS input
clock (e.g. for testing of the IC) – the TCLK pin should be grounded through a 2.7k pulldown
resistor to maintain the correct duty cycle for the clock.
(2) TMDS Differential Input Clock (RC+ and RC-)
(3) Video Clock (VCLK) input pin
(4) Host Interface Transfer Clock (HCLK for 6-Wire nibble; SCL for 2-wire serial)
The gm5120 has an Input Format Measurement block (the IFM) providing the capability
of measuring the horizontal and vertical timing parameters of the input video source. This
information may be used to determine the video format and to detect a change in the input
format. It is also capable of detecting the field type of interlaced formats.
The IFM features a host programmable reset; separate from the regular gm5120 soft
reset.This reset disables the IFM, reducing power consumption. The IFM is capable of
operating while gm5120 is running in power down mode.
Horizontal measurements are measured in terms of the selected IFM_CLK (either
T_CLK or R_CLK/4), while vertical measurements are measured in terms of HSYNC
pulses.
The gm5120 OSD controller supports both character-mapped and bitmapped modes. A
user programmable palette of 256 true colors (255 colors, + 1 transparent) is available.
In character mapped mode, a maximum of four colors per character are available.
In 8-bit bitmapped mode, any pixel can be assigned any one of 256 user-defined true
colors.
In 4-bit bitmapped mode, any pixel can be assigned any one of 16 user-defined true colors
(15 colors plus one transparent).
The gm5120 incorporates an embedded microprocessor, or OCM (On-Chip
Microprocessor).This processor is intended to simplify the gm5120 system software
implementation by providing embedded macro functions such as OSD menu configurations.
It is not intended to replace the system microprocessor.
ViewSonic Corporation
!
51!
Confidential – Do Not Copy VX700-3
Page 43
An arbitration mechanism handles the register access requests from the OCM and the
system. micro.
1.4 LVDS Transmitter
IC500, 501 (SN75LVDS83) FlatLink transmitters contains four 7-bit parallel-load
serial-out shift registers, a ҏ c lock synthesizer, and five low-voltage differential-signaling
(LVDS) line drivers in a single integrated circuit. These functions allow 28 bits of
single-ended low-voltage TTL (LVTTL) data to be synchronously transmitted over five
balanced-pair conductors for receipt by a compatible receiver,
When transmitting, data bits D0 through D27 are each loaded into registers upon the
edge of the input clock signal (CLKIN). The rising or falling edge of the clock can be
selected by way of the clock select (CLKSEL) terminal. The frequency of CLKIN is
ViewSonic Corporation
!
52!
Confidential – Do Not Copy VX700-3
Page 44
multiplied seven times () and then used to unload the data registers in 7-bit slices and
serially. The four serial streams and a phase-locked clock (CLKOUT) are then output to
LVDS output drivers. The frequency of CLKOUT is the same as the input clock, CLKIN.
The SN75LVDS83 requires no external components and little or no control. The data
bus appears the same at the input to the transmitter and output of the receiver with the data
transmission transparent to the user. The only user intervention is the possible use of the
shutdown/clear (SHTDN) active-low input to inhibit the clock and shut off the LVDS output
drivers for lower power consumption. A low-level signal on SHTDN clears all internal
registers to a low level.
1.5 DDC 1/2 B
IC600 (24LC02) & IC602 (24LC21A) can continuously transmit its extended identification,
“EDID” using DDC1 communication channel. In addition, the monitor can respond to a request
for EDID, or complete VDIF, to be transmitted using DDC2, level B commands. Pin6 SCL is
clock input for DDC 2B, pin5 SDA for data input, and pin7 VCLK is clock input for DDC1.
In DDC1 data transfer (UNI-directional mode), the VCLK input pin is used as an input
clock for data transmission and SDA output pin is used as serial data line the SCL pin will
hold high. The DDC2B node (BI-directional mode) BUS consists of two wires. SCL is for
the data transmission clock and SDA is for the data line.
2. Audio Board
2.1 Audio processor
ICA2 (PT2313L) is a four-channel digital audio processor utilizing CMOS
Technology .Volume, Bass, Treble, Balance, Front/Rear Fader Processor are incorporated
into a single chip. Loudness function and Selectable input gain are also provided to build a
highly effective electronic Audio processor having the highest performance and reliability
with the least external components. and all functions are programmable using the IIC BUS
!
ViewSonic Corporation
53!
Confidential – Do Not Copy VX700-3
Page 45
PIN# PIN NAME I/O DESCRIPTION
1 REF - Analog reference voltage(1/2 VDD)
2 VDD - Supply input voltage
3 Agnd - Analog ground
4 Treb_L I Left channel input for treble control
5 Treb_R I Right channel input for treble control
6 RIN I Audio processor right channel input
7 Rout O Gain output and input selector for right
channel
8 Louder I Right channel loudness input
9 Rin 3 I Right channel input 3
10 Rin 2 I Right channel input 2
11 Rin 1 I Right channel input 1
12 Loud_L I Left channel loudness input
13 Lin 3 I Light channel input 3
14 Lin 2 I Light channel input 2
15 Lin 1 I Light channel input 1
16 LIN I Audio processor left channel input
17 Lout O Gain output and input selector for left
channel
18 Bin _L I Left bass controller input channel
19 Bout _L O Left bass controller output channel
20 Bin _R I Right bass controller input channel
21 Bout _R O Right bass controller output channel
22 RRout O Right rear speaker output
23 LRout O Left rear speaker output
24 RFout O Right front speaker output
25 LFout O Left front speaker output
26 Dgnd - Digital ground
27 Date I IIC Date
28 Clk I IIC Clk
ICA1 control & regulate the voltage (12Vto9V) to the ICA2 Volume signal through ICA2
pin24 (right) pin25 (left) into audio amplifier ICA3.
!
ViewSonic Corporation
54!
Confidential – Do Not Copy VX700-3
Page 46
2.2 Audio amplifier:
ICA3 (TDA1517) is an integrated class-B dual output amplifier; it contains two identical
amplifier differential input stages. The gain of each amplifier is fixed at 20 dB.
Pins 1 and 9 are right and left channel inputs respectively. Pins 4 and 6 are right and
left channel outputs which connect to two 8 OHM speakers. Pin 8 is the mute/stand-by Pin
7 is the voltage input for ICA1
ViewSonic Corporation
!
55!
Confidential – Do Not Copy VX700-3
Page 47
4. Troubleshooting Flow Chart
1. Figure of Waveform
FIG1 12V FIG2 5V
FIG 3. 3.3V FIG 4. 2.5V
FIG 5. 32 GRAY SIGNAL INPUT FIG 6. H-SYNC
ViewSonic Corporation
!
56!
Confidential – Do Not Copy VX700-3
Page 48
FIG 7. V-SYNC FIG 8. 14.3M CLOCK
FIG 9. DISPLAY CLOCK FIG 10. DISPLAY H-SYNC
FIG 11. DISPLAY V-SYNC FIG 12. DISPLAY ENABLE
FIG 13. LVDS TX0+ FIG 14. LVDS TX0-
!
ViewSonic Corporation
57!
Confidential – Do Not Copy VX700-3
Page 49
FIG 15. LVDS CLOCK+ FIG 16. LVDS CLOCK-
FIG 17. AUDIO SINE SIGNAL IN FIG 18. AUDIO SINE SIGNAL OUT
ViewSonic Corporation
!
58!
Confidential – Do Not Copy VX700-3
Page 50
2. No Display on Screen (Screen is black, LED is off)
Is screen black?
YES NO
-
Check that C202 positive is at 5V. ( FIG 2.)
Check that the voltage level of CN100 is
YES NO
YES NO
approximately 12V
Check
Check CN301 pin1
IC100 failure
is12V, pin5 is 5V
YES NO
Inverter failure
Check IC400
Pin 114 failure
FB100, FB101
failure
F100 or power board failure
ViewSonic Corporation
!
59!
Confidential – Do Not Copy VX700-3
Page 51
3. No Display on Screen (LED is green)
Is the backlight lit?
YES
Check that the cable is fully
connected to CN500
Check IC500 ,IC501
Pin47 (FIG.13 )
Pin48 (FIG.14 )
Pin39 (FIG.15 )
Pin40 (FIG.16)
YES
Failure point
The cable is
disconnected
NO
NO
Check that the cable is fully
connected between the
Inverter and Interface board
NO YES NO
Failure point
The cable is disconnected
YES
Check CN301 pin1 is12V,
pin5 is 5V
Check IC502
Pin 2, 4 is low
YES
Check IC502
Pin5, 6, 7, 8 is
About 5V
voltage
Failure point
1.IC500, IC501 failure
2.IC400 failure
NO
IC502 failure
NO
IC502 failure
YES
Inverter failure
NO
IC400 Pin 114 failure
ViewSonic Corporation
!
5:!
Confidential – Do Not Copy VX700-3
Page 52
4. No Power On
Check that CN100 Pin1 is approximately 12V
YES NO
Check that F100 output is
Failure point
12V
1. Power Board failure
2. Disconnected between CN100 and power board
NO
YES
Failure point
Check that FB100, FB101
is 12V
F100 failure
YES NO
Check that IC100
Failure point
pin 2 is about 5V
NO
Failure point
1.L200 failure
2.D200 failure
3.IC100 failure
!
ViewSonic Corporation
FB100, FB101 failure
61!
Confidential – Do Not Copy VX700-3
Page 53
5. No Sound (Test signal: 1r.m.s sine waveform)
Check that ICA3 Pin 7 is approximately 12V
YES NO
Check that ICA1 Pin 3 is
approximately 9V
YES
Check ICA2 pin11
Pin15 signal is
FIG 17.
YES
YES
Check ICA3 pin 4, 6
is FIG18.
NO
Check ICA1 pin2
is about 12V
NO
Check that Q306 Pin 4 is
Low voltage
Check Q306
Pin5, 6, 7, 8 is12V
NO
Q306 failure
Failure point
1.ICA1 failure
2.IC400 pin 123 failure
NO YES
Failure point
1.JA1 failure
2.IC400 pin123 failure
YES
Check ICA5,ICA6 pin 4 is
about 5V
YES
ICA5 or ICA6 failure
!
ViewSonic Corporation
1. QA6 or QA7 failure
NO
2. ICA3 failure
IC400 pin 125 failure
62!
NO
Failure point
Confidential – Do Not Copy VX700-3
Page 54
6. Show “No Signal” on screen
(Test pattern: 32 gray 1280X1024 60HZ)
Check the signal level of R610,
R611, R612 is FIG 5.
YES
Check the HS and VS is
FIG 6. and FIG 7.
7. Keypad can not work
NO
NO
Failure point
1. The video connector is disconnected
2. Signal cable is disconnected
Check that the cable is
fully connected between
the Interface board and
Key board
YES NO
Failure point
1. IC400 pin 1, 4, 42, 43, 46,
47, 125,206 failure
2. TACT switch failure
ViewSonic Corporation
!
Failure point
The cable is disconnected
64!
Confidential – Do Not Copy VX700-3
Page 55
5. Adjust Procedure
1. Preparation of manual alignment
1.1 The alignment procedure is performed after unit has been
completely assembled and before set inspection.
1.2 Before alignment, set should be burned -in for over 30MIN.
1.3 M easuring equipment used pre-programmed chroma 2226 or
equivalent products.
C olor meter-- M inol ta CA2 10 or equivalent products.
210 mm
CA110
1.4 M ethods to enter/exit factory mode
1.4.1 Press “2” and “down” key and power on to set the monitor to the burn-in
mode.
1.4.2 Press “vol-” and “1” key and power on to set the monitor to the factory
mode.
1.4.3 To ensure the monitor is under factory mode, check the status in the OSD
menu screen.
ViewSonic Corporation
!
65!
Confidential – Do Not Copy VX700-3
Page 56
Factory
VX700-3 01/10 / 2003
Color Temp
Factory Default
Brightness
Blacklevel
AutoColor
Initial
EDID
CopyColorTemp
Gamma
Otherwise, follow the procedure described in session 1.4.1 to enter the factory
mode again
1.4.3 Under factory mode, press “power” key. the monitor will exit factory mode
and enter normal display mode .
1.5 M ethods to enter/exit manual color alignment menu
Under factory mode, select "C olor T emp M anual" from factory OSD menu. It will
display the following color temperature adjust menu.
Use “up” and “down” to move cursor between items “9300”, “6500”,”5400”
and”5000”. Press “2” to select which color temperature to be adjusted. It will
!
ViewSonic Corporation
66!
Confidential – Do Not Copy VX700-3
Page 57
show following menu.
Use “2” key to switch r, g, b, driver. “up” or “down” key to adjust the R. G.B value
corresponding to the selected item.
2. Color temperature alignment
Before manual ly adjusting color temperature, set OSD contrast 80%, brightness 100%
(factory default), enter into factory mode and select “color temp
Manual” item.
2.1 9300°k alignment
2.1.1 U se “up” or “down” key to move cursor to 9300 color temperature. Then
press “2” key to select 9300 color temperature adjustment.
2.1.2 Use “2” to move cursor to r-driver or g-driver or b-driver and then press
“up” or “down” key to adjust it to meet following chromaticity spec.
9300 k Ш X = 0.2830.003, Y = 0.298±0.003 y>= 150cd/m
2.1.3 P ress “1” to exit 9300 color temperature adjustment and do another
color temperature adjustment.
The above result R,G,B gain will automatically be saved when exiting the
factory mode OSD menu.
2
.
2.2 6500°k alignment
!
ViewSonic Corporation
67!
Confidential – Do Not Copy VX700-3
Page 58
2.2.1 U se “up” or “down” key to move cursor to 6500 color temperature. Then
press “2” key to select 6500 color temperature adjustment.
2.2.2 Use “2” to move cursor to r-driver
or g-driver or b-driver and then press
“up” or “down” key to adjust it to meet following chromaticity spec.
6500 k Ш X = 0.313 0.003, Y = 0.329±0.003 y>= 180cd/m
2.2.3 Press “1” to exit 6500 color temperature adjustment and do another
color temperature adjustment.
The above result R,G,B gain will automatically be saved , when exiting
the Factory mode OSD menu.
2.3 5400°k alignment
2.3.1 U se “up” or “down” key to move cursor to 5400 color temperature. Then
press “2” key to select 5400 color temperature adjustment.
2.3.2 Use “2” to move cursor to r-driver or g-driver or b-driver and then press
2
.
“up” or “down” key to adjust it to meet following chromaticity spec.
5400°k ШX = 0.332 0 .003, Y = 0.348±0.003 y>= 180cd/m
2.3.3
Press “1” to exit 5400 color temperature adjustment and do another
color temperature adjustment. when exit factory mode OSD menu, the
above result R,G,B gain will automatically be saved
2.4 5000°k alignment
2.4.1 U se “up” or “down” key to move cursor to 5000 color temperature. Then
press “2” key to select 5000 color temperature adjustment.
2.4.2 Use “2” to move cursor to r-driver or g-driver or b-driver and then press
“up” or “down” key to adjust it to meet following chromaticity spec.
5000 k Ш X = 0.346 0.003, Y = 0.359±0.003 y>= 180cd/m
2
.
2
.
ViewSonic Corporation
!
68!
Confidential –DoNotCopy VX700-3
Page 59
2.4.3 P ress “1” to exit 5000 color temperature adjustment and do another color
temperature adjustment.
The above result R,G,B gain will automatically be saved, when exiting the
the factory mode OSD menu.
3. Factory preset setting
3.1 I n factory mode OSD main menu select factory default setting. Press “2”
to confirm the selectio n.
!
ViewSonic Corporation
69!
Confidential – Do Not Copy VX700-3
Page 60
6. Mechanical Assembly
ViewSonic Corporation
!
6:!
Confidential – Do Not Copy VX700-3
Page 61
ViewSonic Corporation
71!
Confidential – Do Not Copy VX700-3
Page 62
ViewSonic Corporation
72!
Confidential – Do Not Copy VX700-3
Page 63
!
ViewSonic Corporation
73!
Confidential – Do Not Copy VX700-3
Page 64
ViewSonic Corporation
!
74!
Confidential – Do Not Copy VX700-3
Page 65
Mechanical Parts List
Item VIEWSONIC P/N Reference No Description
1 M-SCW-0824-0696 3102030800 SCREW MACHINE M4 x 0.7 x 6
2 M-SCW-0814-0692 3105124000 SCREW MACHINE M4 x 0.7 x 6
3 M-SCW-0824-0620 3109020500 SCREW TAPPING 4 x 18 in
4 M-CV-0830-2355 3390301701 BASE COVER
5 M-CV-0830-2305 3390102400 FRONT COVER NECK
6 M-MS-0808-8160 3371005201 BRACKET NECK
7 M-MS-0808-8159 3371004902 BRACKET BASE SPCC
8 M-SCW-0814-0691 3105120100 SCREW M4 x 0.7 x 12 (REMARK: HINGE SUB-ASSY+REAR
9 M-CV-0830-2306 3390301600 REAR NECK COVER
10 M-CV-0830-2315 3790180100 REAR BACK COVER ASSY
11 M-MS-0808-8163 3461750601 HINGE SUB ASSY R
12 M-MS-0808-8164 3461750701 HINGE SUB ASSY L
13 C-BC-0302-0479 3362136000 R/C ASSY
14 M-SCW-0824-0697 3109025400 SCREW T4 x 1.58 x 20 (2 PCS)
15 E-SK-0412-0071 3790193500 SPEAKER LEFT
16 M-SCW-0824-0620 3109020500 SCREW T4 x 1.6 x 10 (4 PCS)
17 M-SCW-0814-0694 3109015000 SCREW T3 x 1.27 x 8 (3 PCS)
18 M-CV-0830-2385 3368205500 SPEAKER COVER ASSY
19 PL-FK-0709-0114 3360727100 FUNCTION KEY
20 B-KB-0207-0030 5600110075 KEY PAD ASSY
21 C-FP-0301-0777 3361074000 F/B ABS SV-651
22 M-SCW-0824-0433 3100301200 SCREW T4 x 1.58 x 20 (2 PCS)
23 E-SK-0412-0070 3790193400 SPEAKER RIGHT
24 M-SCW-0824-0433 3100301200 SCREW M3 x 0.5 x 12 (4 PCS)
25 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.5 x 6 (3 PCS)
26 B-AC-0215-0038 N/A AUDIO BOARD
27 B-SB-0221-0458 N/A INVERTER BOARD
28 M-SCW-0824-0732 3109010900 SCREW TM3 x 0.5 x 4 (2 PCS)
29 M-LCD-0826-0133 N/A PANEL
30 M-MH-0822-0005 3460141600 BRACKET D-SUB
31 M-CV-0830-2388 3461222900 SHIELD CAN INVERTER
32 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.5 x 6
34 M-MH-0822-0006 3460141700 BRACKET PANEL
35 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.5 x 6 (2 PCS)
36 M-CV-0830-2387 3461222800 SHIELD CAN INTERFACE
37 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.5 x 6
38 M-CV-0830-2386 3461222700 SHIELD CAN POWER
39 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.5 x 6 (2 PCS)
40 M-SCW-0824-0410 3100300600 SCREW MM3 x 0.5 x 6 (4 PCS)
41 N/A POWER BOARD
42 M-SCW-0824-0413 3109011400 SCREW TM3 x 0.6 x 6
43 B-IF-0222-0033 N/A INTERFACE BOARD
44 B-SB-0221-0450 5600200113 MICROPHONE BOARD
45 M-CV-0830-2355 3390301701 BASE COVER
46 PL-PD-0714-0068 3240957500 RUBBER FOOT
47 PL-PD-0714-0067 3240956800 RUBBER FOOT
48 M-SCW-0824-0410 3100300600 SCREW MACHINE M3 x 0.5 x 6
49 PL-PD-0714-0068 3240957500 RUBBER FOOT
50 M-SCW-0814-0693 3105124500 SCREW MACHINE M4 x 0.7 x 6
51 M-MS-0808-8303 3211024500 MYLAR (1 PCS)
52 N/A TAPE (4 PCS)
53 P-FM-0602-0765 350008460X CUSHION LEFT EPS
54 P-FM-0602-0764 350008450X CUSHION RIGHT EPS
55 3500926200 PE BAG
56 P-BX-0601-0697 3512211500 CARTON (485 x 275 x 528)
57 M-MS-0808-8222 3532034200 MANUAL ASSY
58 A-CD-VX700-2 3532035100 CD 120 x 120 VIEWSONIC
59 A-AD-0114-0094 0993009600 ADAPTER DC 12V 60W
60 N/A CABLE ASSY
61 A-AU-0120-0033 3080005100 CABLE AUDIO L=1800 BLK PC99
62 A-MC-0105-0017 3080005200 CABLE MICROPHONE L=1800 BLK PC99
63 M-MS-0808-8033 3080412101 CABLE D-SUB TO D-SUB RGB BLK LINK
64 M-MS-0808-8041 3080412401 CABLE DVI-D/DVI-D SINGLE LINK
65 A-PC-0106-0191 3090121400 AC POWER CORD US 3PIN L=1800
66 A-PC-0106-0192 3090121500 AC POWER CORD EURO 3PIN L=1800
ViewSonic Corporation
75!
Confidential – Do Not Copy VX700-3
Page 66
7. Schematic Diagram
ViewSonic Corporation
65!
Confidential – Do Not Copy VX700-3
Page 67
L17KMW/L18HMW 05AAW LCD MONITOR BLOCK DIAGRAM
CN601
HD-15
15PINS
CN600
DVI-D
24PINS
5V
IC602
HD-15
DDC
EEPROM
5V
IC600
DVI-D
DDC
EEPROM
ADAPTER
PWR
RGB
HS
VS
VGA_SDA
VGA_SCL
DVI_SDA
DVI_SCL
VGA_SDA
VGA_SCL
DVI_SDA
DVI_SCL
12V
POWER
I/F
IC603
74F14
5V
12V
5V
DVDD2.5
DVDD3.3
LVDS3.3
ANALOG I/P
Hsync
Vsync
IC400
DISPLAY ENGINE
GM5120
ADC+DVI+SCALER+MCU
DIGITAL
I/P X 8PINS
VGA_SDA
VGA_SCL
DVI_SDA
DVI_SCL
CN302
AUDIO
3.3V 2.5V
BACKLIGHT_EN
BACKLIGHT_CONTROL
3.3V 3.3V
IC500
LVDS
3.3V 3.3V
IC501
PANEL_EN
SDA
SCL
LVDS LVDS
5V
IC402
FLASH
EEPROM
(F/W)
5V
IC404
DATA
EEPROM
KEY
BOARD
5V
IC502
SI9933ADY
VPNL
12V
INVERTER
CN500
LVDS
OUT
CON
LCD
PANEL
ViewSonic Corporation
66!
Confidential – Do Not Copy VX700-3
Page 68
ViewSonic Corporation
67!
Confidential – Do Not Copy VX700-3
Page 69
ViewSonic Corporation
68!
Confidential – Do Not Copy VX700-3
Page 70
ViewSonic Corporation
69!
Confidential – Do Not Copy VX700-3
Page 71
ViewSonic Corporation
70!
Confidential – Do Not Copy VX700-3
Page 72
ViewSonic Corporation
71!
Confidential – Do Not Copy VX700-3
Page 73
ViewSonic Corporation
72!
Confidential – Do Not Copy VX700-3
Page 74
8. PCB Layout
!
ViewSonic Corporation
73 !
!
Confidential – Do Not Copy VX700-3
Page 75
!
ViewSonic Corporation
74!
Confidential – Do Not Copy VX700-3
Page 76
!
ViewSonic Corporation
75!
Confidential – Do Not Copy VX700-3
Page 77
9. Recommended Spare Parts List
VX700-3 Recommanded Spare Parts List
Item VIEWSONIC P/N Reference NO DESCRIPTION REMARKS
A-AD-0114-0181
1
2
A-PC-0106-0193
3
A-AU-0120-0033
4
A-MC-0105-0017
5
M-MS-0808-8033
6
M-MS-0808-8041
7
A-PC-0106-0229
8
M-SCW-0824-0410
9
M-SCW-0824-0433
10
M-SCW-0824-0433
11
M-SCW-0824-0690
12
M-SCW-0824-0690
13
M-SCW-0814-0691
14
M-SCW-0814-0692
15
M-SCW-0814-0693
16
M-SCW-0814-0693
17
M-SCW-0814-0693
18
M-SCW-0824-0732
19
M-SCW-0824-0413
20
M-SCW-0824-0413
21
M-SCW-0824-0413
22
M-SCW-0824-0413
23
M-SCW-0824-0413
24
M-SCW-0824-0413
25
M-SCW-0824-0413
26
M-SCW-0824-0413
27
M-SCW-0814-0694
28
M-SCW-0824-0620
29
M-SCW-0824-0620
30
M-SCW-0824-0393
31
M-SCW-0824-0733
32
M-SCW-0824-0733
33
M-MS-0808-8040
34
M-MS-0808-8040
35
M-LB-0813-0712
36
M-MS-0808-4686
37
M-MS-0808-8151
38
M-MS-0808-7739
39
M-LB-0813-0384
40
M-LB-0813-0758
41
M-LB-0813-0700
42
M-LB-0813-0714
43
M-MS-0808-7740
44
C-BC-0302-0477
45
C-BC-0302-0478
46
PL-FK-0709-0114
47
M-CV-0830-2381
48
M-CV-0830-2382
49
C-FP-0301-0777
50
M-CV-0830-2383
51
M-CV-0830-2384
52
M-CV-0830-2385
53
C-BC-0302-0479
54
M-MS-0808-8159
55
M-MS-0808-8160
56
M-MH-0822-0002
57
M-MH-0822-0004
58
M-MS-0808-8162
0993023000
3070000501
3080005100
3080005200
3080412101
3080412401
3090119001
3100300600
3100301200
3100301200
3105051501
3105051501
3105120100
3105124000
3105124500
3105124500
3105124500
3109010900
3109011400
3109011400
3109011400
3109011400
3109011400
3109011400
3109011400
3109011400
3109015000
3109020500
3109020500
3109020700
3109026000
3109026000
3110250000
3110250000
3200449700
3200462800
3200641801
3200648800
3200712700
3201942300
3202207300
3202310700
3211024600
3360240100
3360240400
3360727100
3360916300
3360916400
3361074001
3361204400
3361204500
3368205500
3368213600
3371004902
3371005202
3371005500
3371005701
3421024500
POWER 90-264VAC 12VDC 4.16A
COMPUTER USE
AC POWER CORD L1800 BLACK EURO
CABLE AUDIO L=1800 BLK PC99
CABLE MICPHONE L=1800 BLK PC99
CABLE D-SUB TO D-SUB RGB BLK L
CABLE DVI-D/DVI-D SINGLE LINK
AC POWER CORD L1830 BLACK US
SCREW M M3*0.5*6 PAN C S+P S20 POWER BD&PANEL BKT
SCREW M M3*0.5*12 PAN C S+P S2 PANEL/COVER LCD+R/C
SCREW M M3*0.5*12 PAN C S+P S2 PANEL+COVER LCD
SCREW M #4-40*7 HEXH #4-40*3 S CONN. D-SUB
SCREW M #4-40*7 HEXH #4-40*3 S CONN. DVI-D
SCREW M M4*0.7*12 PAN C S+P S1 HINGE SUB+R/C
SCREW M M4*0.7*6 PAN C S18C NI HINGE SUB+NECK BRKT
SCREW M M4*0.7*6 FF C S18C ZN NECK BRKT+BTTM COVER
SCREW M M4*0.7*6 FF C S18C ZN PANEL BRKT+BACK CABINET
SCREW M M4*0.7*6 FF C S18C ZN NECK SUB ASSY+BASE COVER
SCREW T M3*0.5*4 BIND C S18C Z IVT BD&PANEL BKT I/F BD
SCREW T M3*0.5*6 BIND C S18C Z I/F BD & PANEL BKT
SCREW T M3*0.5*6 BIND C S18C Z D-SUB BKT& PANEL BKT
SCREW T M3*0.5*6 BIND C S18C Z I/F SHIELD CAN & D-SUB BKT
SCREW T M3*0.5*6 BIND C S18C Z AUDIO BD&PANEL BKT
SCREW T M3*0.5*6 BIND C S18C Z KEY BD GND& PANEL BKT
SCREW T M3*0.5*6 BIND C S18C Z AUDIO BD+ICA3
SCREW T M3*0.5*6 BIND C S18C Z POWER SHIELD CAN&PANEL BKT
SCREW T M3*0.5*6 BIND C S18C Z IVT COVER& PANEL BKT
SCREW T ij 3*1.27*8 PAN C S20C K/B+SPK COVER
SCREW T ij 4*1.6*10 PAN C S18C BACK CABINET+PANEL BRKT
SCREW T ij 4*1.6*10 PAN C S18C FOR F/B +RC
SCREW T M4*0.7*8 PAN C S S18C AC SOCKET GND
SCREW T ij 4*1.27*12 FPH C S18C SPEKER & BACK CABINET
SCREW T ij 4*1.27*12 FPH C S18C NECK F/C+BKT NECK
WASHER SPRING SWRT CONN. D-SUB
WASHER SPRING SWRT CONN. DVI-D
LABEL WARING AIR SHIPPING
NAME PLATE AL+PC VSC 3-BIRD LO
NAME PLATE AL 43*6.9*1.15T VIE F/B
NAME PLATE ABS 94HB VIEWSONIC
LABEL CONTROL 100*90 STICK ON PALLET
LABEL ID 160*43 VSC VX700-3
LABEL MIC IN 10.2*15 BRACKET NE
LABEL HV WARNING 100*25
MYLAR 408*326 T.2 FRONY BEZE
R/C ABS VSC02B VX700-2
CABINET BACK ABS 41 VX700-2
FUNCTION KEY ABS VSC02B S7LFA1
ARM FRONT ABS 41 VX700-2
ARM REAR ABS 41 VX700-2
F/B ABS SV-651 VX700-3
COVER SPEAKER ABS 41 VX700-2
COVER BASE ABS 41 VX700-2
SPEAKER COVER ASSY L17KMW05AAW
R/C ASSY L17KMW05AAW
BRKT BASE SPCC T=2 ZN BLK
BRACKET MECK SPCC T=2 ZN BLUE
BRACKET VESA MOUNTING SECC T=1 FOR CABINET BACK
BRACKET KENSINGTON SECC T=1.2 FOR CABINET BACK
CABLE CLAMP GROUNDING SPCC T.3 K/B WIRE+PANEL BRKT
ViewSonic Corporation
77!
Confidential – Do Not Copy VX700-3
Page 78
59
M-MH-0822-0005
60
M-MH-0822-0006
61
M-MH-0822-0006
62
M-MH-0822-0007
63
M-CV-0830-2386
64
M-CV-0830-2387
65
M-CV-0830-2388
66
M-MS-0808-8163
67
M-MS-0808-8164
68
P-FM-0602-0764
69
P-FM-0602-0765
70
M-MS-0808-7741
71
A-CD-VX700-3
72
M-WR-0828-0680
73
M-WR-0828-0681
74
M-WR-0828-0682
75
M-WR-0828-0683
76
M-WR-0828-0684
77
M-WR-0828-0641
78
E-SK-0412-0070
79
E-SK-0412-0071
80
B-SB-0221-0458
81
M-MS-0808-7742
82
M-LCD-0826-0133
83
B-AC-0215-0038
84
B-IF-0222-0033
85
B-KB-0207-0030
86
B-SB-0221-0450
3460141600
3460141700
3460141700
3460144800
3461222700
3461222800
3461222900
3461750601
3461750701
3500084500
3500084600
3532059100
3532059200
3610171100
3670190300
3670190400
3670190500
3670190600
3670459102
3790193400
3790193500
4900502800
5011086400
5051700501
5600110046
5600110051
5600110075
5600200113
BRACKET D-SUB SECC 211.5*23.8
BRACKET PANEL SECC 388.2*310.6 FIX ON PANEL BKT&36701903XX
BRACKET PANEL SECC 388.2*310.6
BRACKET CONN SECC 41.7*30 T0.6
SHIELD CAN POWER SPTH 164.2*86
SHIELD CAN INTERFACE SPTH 214*
SHIELD CAN INVERTER SPTH 191.2
HINGE SUB ASSY R
HINGE SUB ASSY L
END BLOCK EPS
END BLOCK EPS
MANUAL PACKING ASSY VSC VX700CD-ROM VSC A-CD-VX700-3
SOCKET AC ASSY VX700
WIRE WITH HOUSING 1007 #28 L35 KEY BD TO I/F
WIRE WITH HOUSING 1007 #28 L12 AUDIO TO I/F
WIRE WITH HOUSING 1007 #28 L24
WIRE WITH HOUSING 1007 #28 L10
WIRE WITH HOUSING 1007 #28 L=4 AUDIO/BD JA2
SPEAKER-R ASSY L17KMW05AAW
SPEAKER-L ASSY L17KMW05AAW
DC-AC INVERTER 12V/1900V 4L 17
MANUAL QUICK START GUIDE VSC V
LCD 17" TFT PANEL
LCD AUDIO BD ASSY L19EMW 05AAW
LCD I/F BD ASSY L17KMW 05AAW
LCD FUN KEY BD ASSY L17KMW 05A
MICROPHONE BD ASSY
500*250*180
500*250*180
ViewSonic Corporation
77!
Confidential – Do Not Copy VX700-3
Page 79
10. Complete Parts List
VS Model Name:
VX700-3
ITEM VIEWSONIC P/N REFERENCE NO. DESCRIPTION
1 A-AD-0114-0181 0993023000 POWER 90-264VAC 12VDC 4.16A CO
2 A-PC-0106-0193 3070000501 AC POWER CORD L1800 BLACK EURO
3 A-AU-0120-0033 3080005100 CABLE AUDIO L=1800 BLK PC99
4 A-MC-0105-0017 3080005200 CABLE MICPHONE L=1800 BLK PC99
5 M-MS-0808-8033 3080412101 CABLE D-SUB TO D-SUB RGB BLK L
6 M-MS-0808-8041 3080412401 CABLE DVI-D/DVI-D SINGLE LINK
7 A-PC-0106-0229 3090119001 AC POWER CORD L1830 BLACK US
8 M-SCW-0824-0410 3100300600 SCREW M M3*0.5*6 PAN C S+P S20
9 M-SCW-0824-0433 3100301200 SCREW M M3*0.5*12 PAN C S+P S2
10 M-SCW-0824-0433 3100301200 SCREW M M3*0.5*12 PAN C S+P S2
11 M-SCW-0824-0690 3105051501 SCREW M #4-40*7 HEXH #4-40*3 S
12 3105051501 SCREW M #4-40*7 HEXH #4-40*3 S
13 M-SCW-0814-0691 3105120100 SCREW M M4*0.7*12 PAN C S+P S1
14 M-SCW-0814-0692 3105124000 SCREW M M4*0.7*6 PAN C S18C NI
15 M-SCW-0814-0693 3105124500 SCREW M M4*0.7*6 FF C S18C ZN
16 M-SCW-0814-0693 3105124500 SCREW M M4*0.7*6 FF C S18C ZN
17 M-SCW-0814-0693 3105124500 SCREW M M4*0.7*6 FF C S18C ZN
18 M-SCW-0824-0732 3109010900 SCREW T M3*0.5*4 BIND C S18C Z
19 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
20 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
21 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
22 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
23 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
24 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
25 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
26 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C Z
27 M-SCW-0814-0694 3109015000 SCREW T ij 3*1.27*8 PAN C S20C
28 M-SCW-0824-0620 3109020500 SCREW T ij 4*1.6*10 PAN C S18C
29 M-SCW-0824-0620 3109020500 SCREW T ij 4*1.6*10 PAN C S18C
30 M-SCW-0824-0393 3109020700 SCREW T M4*0.7*8 PAN C S S18C
31 M-SCW-0824-0733 3109026000 SCREW T ij 4*1.27*12 FPH C S18C
32 M-SCW-0824-0733 3109026000 SCREW T ij 4*1.27*12 FPH C S18C
33 M-MS-0808-8040 3110250000 WASHER SPRING SWRT
34 M-MS-0808-8040 3110250000 WASHER SPRING SWRT
35 M-LB-0813-0712 3200449700 LABEL WARING
36 M-MS-0808-4686 3200462800 NAME PLATE AL+PC VSC 3-BIRD LO
37 M-MS-0808-8151 3200641801 NAME PLATE AL 43*6.9*1.15T VIE
38 M-LB-0813-0384 3200712700 LABEL CONTROL 100*90
39 M-LB-0813-0551 3200744000 LABEL BAR CODE 55*15 VSC-G
40 M-LB-0813-0696 3200753101 LABEL BAR CODE 76*121 VIEWSONI
41 M-LB-0813-0759 3200930800 LABEL VER. CONTROL 20*20 VIEWS
42 M-LB-0813-0758 3201942300 LABEL ID 160*43 VSC VX700-3
43 M-LB-0813-0700 3202207300 LABEL MIC IN 10.2*15
44 M-LB-0813-0714 3202310700 LABEL HV WARNING 100*25
45 M-MS-0808-7740 3211024600 MYLAR 408*326 T.2
46 M-MS-0808-8202 3220133600 TAPE W=10 #1350F-1 3M
!
47 M-MS-0808-6072 3220140600 TAPE W=37 #1350F-2 3M
48 3220605633 TAPE W=45 #7290 NITTO
49 3221101900 TAPE W=76 PP47 50M 4P
ViewSonic Corporation
78!
Confidential – Do Not Copy VX700-3
Page 80
50 3221407510 TAPE W=7 VHB4926 E468
51 3240659901 INSULATOR 192.5*40*0.4T
52 PL-PD-0714-0067 3240956800 RUBBER FOOT 81*13*3T BLK
53 PL-PD-0714-0068 3240957500 RUBBER FOOT 75*10 T3
54 M-MS-0808-8155 3240959801 RUBBER HOLD PLUG OD5.2 H3.8 BL
55 3343705302 HSK AL T=1.5 21*9
56 C-BC-0302-0478 3360240400 CABINET BACK ABS 41 VX700-2
57 4020371607 PLASTIC ABS 94HB 41 D-180
58 4020371609 PLASTIC ABS 94HB 41 SD-0150
59 4020371614 PLASTIC ABS 94HB 41 PA-707
60 M-CV-0830-2381 3360916300 ARM FRONT ABS 41 VX700-2
61 4020371607 PLASTIC ABS 94HB 41 D-180
62 4020371609 PLASTIC ABS 94HB 41 SD-0150
63 4020371614 PLASTIC ABS 94HB 41 PA-707
64 M-CV-0830-2382 3360916400 ARM REAR ABS 41 VX700-2
65 4020371607 PLASTIC ABS 94HB 41 D-180
66 4020371609 PLASTIC ABS 94HB 41 SD-0150
67 4020371614 PLASTIC ABS 94HB 41 PA-707
68 C-FP-0301-0777 3361074001 F/B ABS SV-651 VX700-3
69 4020372907 PLASTIC ABS 94HB 5140 D-180
70 4020372908 PLASTIC ABS 94HB 5140 HF-380
71 4020372909 PLASTIC ABS 94HB 5140 SD-0150
72 4020372914 PLASTIC ABS 94HB 5140 PA-757
73 M-CV-0830-2384 3361204500 COVER BASE ABS 41 VX700-2
74 4020371607 PLASTIC ABS 94HB 41 D-180
75 4020371609 PLASTIC ABS 94HB 41 SD-0150
76 4020371614 PLASTIC ABS 94HB 41 PA-707
77 M-CV-0830-2385 3368205500 SPEAKER COVER ASSY L17KMW05AAW
78 PL-FK-0709-0114 3360727100 FUNCTION KEY ABS VSC02B S7LFA1
79 4020372907 PLASTIC ABS 94HB 5140 D-180
80 4020372908 PLASTIC ABS 94HB 5140 HF-380
81 4020372909 PLASTIC ABS 94HB 5140 SD-0150
82 4020372914 PLASTIC ABS 94HB 5140 PA-757
83 M-CV-0830-2383 3361204400 COVER SPEAKER ABS 41 VX700-2
84 4020371607 PLASTIC ABS 94HB 41 D-180
85 4020371609 PLASTIC ABS 94HB 41 SD-0150
86 4020371614 PLASTIC ABS 94HB 41 PA-707
87 C-BC-0302-0479 3368213600 R/C ASSY L17KMW05AAW
88 M-MS-0808-7739 3200648800 NAME PLATE ABS 94HB VIEWSONIC
89 4020371607 PLASTIC ABS 94HB 41 D-180
90 4020371609 PLASTIC ABS 94HB 41 SD-0150
91 4020371614 PLASTIC ABS 94HB 41 PA-707
92 C-BC-0302-0477 3360240100 R/C ABS VSC02B VX700-2
93 4020371607 PLASTIC ABS 94HB 41 D-180
94 4020371609 PLASTIC ABS 94HB 41 SD-0150
95 4020371614 PLASTIC ABS 94HB 41 PA-707
96 M-MS-0808-8159 3371004902 BRKT BASE SPCC T=2 ZN BLK
97 3371005203 BRACKET HINGE SPCC 128.1*156 T
98 M-MH-0822-0002 3371005500 BRACKET VESA MOUNTING SECC T=1
99 M-MH-0822-0004 3371005701 BRACKET KENSINGTON SECC T=1.2
100 M-MS-0808-8162 3421024500 CABLE CLAMP GROUNDING SPCC T.3
ViewSonic Corporation
79!
Confidential – Do Not Copy VX700-3
Page 81
101 M-MH-0822-0005 3460141600 BRACKET D-SUB SECC 211.5*23.8
102 M-MH-0822-0006 3460141700 BRACKET PANEL SECC 388.2*310.6
103 M-MH-0822-0007 3460144800 BRACKET CONN SECC 41.7*30 T0.6
104 M-CV-0830-2386 3461222700 SHIELD CAN POWER SPTH 164.2*86
105 M-CV-0830-2387 3461222800 SHIELD CAN INTERFACE SPTH 214*
106 M-CV-0830-2388 3461222900 SHIELD CAN INVERTER SPTH 191.2
107 M-MS-0808-8163 3461750601 HINGE SUB ASSY R
108 M-MS-0808-8164 3461750701 HINGE SUB ASSY L
109 3463000700 CONDUCTIVE AL 15*25 T0.06
110 3463001100 CONDUCTIVE AL 25*60 T0.06
111 3463001100 CONDUCTIVE AL 25*60 T0.06
112 3463001100 CONDUCTIVE AL 25*60 T0.06
113 3463010500 CONDUCTIVE COPPER 18*6 T0.06
114 3472853200 CONDUCTIVE SPONGE 50*6*6.5
115 P-FM-0602-0764 3500084500 END BLOCK EPS (R) 500*250*180
116 P-FM-0602-0765 3500084600 END BLOCK EPS (L) 500*250*180
117 M-MS-0808-7674 3500932401 PE BAG 500*640 T=0.06 CLEAN
118 3510441700 TRAY 1136*1010*142H(INSIDE) VX
119 3510552000 TUBE 1126*1000*1050(H) LCD 17"
120 3510807600 ANGLE PAPER 2190*55*55
121 3510878500 CAP PAPER 1110*980*120
122 P-BX-0601-0786 3512234400 CARTON 476*263*522 VSC VX700-3
123 3520034700 PALLET FUMIGATED 982*1140*120
124 M-MS-0808-5135 3520082400 PE FILM t=0.02mm W=500
125 3520084000 PE SHEET 1800*1600*0.15
126 M-MS-0808-7748 3520087700 PE SHIELDING BAG 280*200
127 3520130500 DRYER 15G 80*60
128 PL-SP-0723-0002 3520142700 PLASTIC STRIP W=12 T.5 BLACK
129 M-MS-0808-7741 3532059100 MANUAL PACKING ASSY VSC VX700130 M-MS-0808-8396 3520094201 PE BAG 260*155*0.1T
131 M-MS-0808-7742 5011086400 MANUAL QUICK START GUIDE VSC V
132 A-CD-VX700-3 3532059200 CD-ROM VSC A-CD-VX700-3
133 3610171101 SOCKET AC ASSY L17KMW05AAW
134 3642312200 WIRE WITH TERMINAL 1015#18 BLK
135 3670190301 WIRE WITH HOUSING 20276 #30 L2
136 M-WR-0828-0682 3670190400 WIRE WITH HOUSING 1007 #28 L12
137 M-WR-0828-0683 3670190500 WIRE WITH HOUSING 1007 #28 L24
138 M-WR-0828-0684 3670190600 WIRE WITH HOUSING 1007 #28 L10
139 3670473700 WIRE WITH HOUSING 2547 #28 L47
140 E-SK-0412-0070 3790193400 SPEAKER-R ASSY L17KMW05AAW
141 E-SK-0412-0071 3790193500 SPEAKER-L ASSY L17KMW05AAW
142 B-SB-0221-0458 4900502800 DC-AC INVERTER 12V/1900V 4L 17
143 B-IF-0222-0033 5600110051 LCD I/F BD ASSY L17KMW 05AAW
144 0313151000 RES CH 1/4W 150 J 1206
145 0313151000 RES CH 1/4W 150 J 1206
146 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
147 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
148 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
149 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
150 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
151 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
ViewSonic Corporation
80!
Confidential – Do Not Copy VX700-3
Page 82
152 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
153 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
154 E-R-0405-7041 0343000300 RES CH 1/10W ZERO J 0603
155 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
156 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
157 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
158 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
159 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
160 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
161 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
162 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
163 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
164 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
165 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
166 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
167 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
168 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
169 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
170 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
171 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
172 E-R-0405-6684 0343101300 RES CH 1/10W 100 J 0603
173 E-R-0405-7054 0343102300 RES CH 1/10W 1K J 0603
174 E-R-0405-7054 0343102300 RES CH 1/10W 1K J 0603
175 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
176 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
177 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
178 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
179 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
180 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
181 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
182 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
183 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
184 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
185 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
186 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
187 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
188 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
189 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
190 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
191 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
192 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
193 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
194 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
195 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
196 E-R-0405-6685 0343103300 RES CH 1/10W 10K J 0603
197 0343201300 RES CH 1/10W 200 J 0603
198 0343201300 RES CH 1/10W 200 J 0603
199 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
200 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
201 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
202 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
ViewSonic Corporation
81!
Confidential – Do Not Copy VX700-3
Page 83
203 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
204 E-R-0405-7042 0343220300 RES CH 1/10W 22 J 0603
205 E-R-0405-6687 0343222300 RES CH 1/10W 2.2K J 0603
206 E-R-0405-6687 0343222300 RES CH 1/10W 2.2K J 0603
207 E-R-0405-6687 0343222300 RES CH 1/10W 2.2K J 0603
208 0343223300 RES CH 1/10W 22K J 0603
209 0343223300 RES CH 1/10W 22K J 0603
210 0343223300 RES CH 1/10W 22K J 0603
211 0343223300 RES CH 1/10W 22K J 0603
212 E-R-0405-7058 0343330300 RES CH 1/10W 33 J 0603
213 E-R-0405-7058 0343330300 RES CH 1/10W 33 J 0603
214 E-R-0405-7058 0343330300 RES CH 1/10W 33 J 0603
215 E-R-0405-7043 0343392300 RES CH 1/10W 3.9K J 0603
216 E-R-0405-6690 0343470300 RES CH 1/10W 47 J 0603
217 E-R-0405-6690 0343470300 RES CH 1/10W 47 J 0603
218 E-R-0405-6690 0343470300 RES CH 1/10W 47 J 0603
219 E-R-0405-6690 0343470300 RES CH 1/10W 47 J 0603
220 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
221 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
222 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
223 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
224 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
225 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
226 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
227 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
228 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
229 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
230 E-R-0405-7033 0343471300 RES CH 1/10W 470 J 0603
231 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
232 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
233 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
234 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
235 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
236 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
237 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
238 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
239 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
240 E-R-0405-7031 0343472300 RES CH 1/10W 4.7K J 0603
241 0343685300 RES CH 1/10W 6.8M J 0603
242 0343750300 RES CH 1/10W 75 J 0603
243 0343750300 RES CH 1/10W 75 J 0603
244 0343750300 RES CH 1/10W 75 J 0603
245 0343823300 RES CH 1/10W 82K J 0603
246 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
247 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
248 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
249 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
250 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
251 0619700605 RES ARRAY 1/16W 22 J 16P8R 4*1
252 0619900705 RES ARRAY 10K J 8P4R 1206
253 0619900705 RES ARRAY 10K J 8P4R 1206
ViewSonic Corporation
82!
Confidential – Do Not Copy VX700-3
Page 84
254 0619900712 RES ARRAY 10K J 8P4R 1206
255 0619900712 RES ARRAY 10K J 8P4R 1206
256 0730060412 CRYSTAL 14.318MHZ+-30PPM AT-49
257 E-FS-0410-0074 0841110702 FUSE F/P 4A 125V UL CSA
258 148121011303 CAP AL CP 16V 100U M 6.3*5.4
259 148121011303 CAP AL CP 16V 100U M 6.3*5.4
260 148121011303 CAP AL CP 16V 100U M 6.3*5.4
261 148121011303 CAP AL CP 16V 100U M 6.3*5.4
262 148121011303 CAP AL CP 16V 100U M 6.3*5.4
263 148121011303 CAP AL CP 16V 100U M 6.3*5.4
264 148121011303 CAP AL CP 16V 100U M 6.3*5.4
265 148121011308 CAP AL CP 16V 100U M 6.3*5.5
266 148121011308 CAP AL CP 16V 100U M 6.3*5.5
267 148121011308 CAP AL CP 16V 100U M 6.3*5.5
268 148121011308 CAP AL CP 16V 100U M 6.3*5.5
269 148121011308 CAP AL CP 16V 100U M 6.3*5.5
270 148121011308 CAP AL CP 16V 100U M 6.3*5.5
271 148121011308 CAP AL CP 16V 100U M 6.3*5.5
272 E-C-0404-4857 148124701303 CAP AL CP 16V 47U M 6.3*5.4
273 E-C-0404-4857 148124701303 CAP AL CP 16V 47U M 6.3*5.4
274 E-C-0404-4857 148124701303 CAP AL CP 16V 47U M 6.3*5.4
275 148124701308 CAP AL CP 16V 47U M 6.3*5.5
276 148124701308 CAP AL CP 16V 47U M 6.3*5.5
277 148124701308 CAP AL CP 16V 47U M 6.3*5.5
278 149121001108 CAP AL CP 16V 10U M 4*5.5
279 149121001133 CAP AL CP 16V 10U M 4*5.4
280 149122211333 .AP AL CP 16V 220U M 6.3*7.7
281 149122211333 .AP AL CP 16V 220U M 6.3*7.7
282 149124711408 CAP AL CP 16V 470U M 8*10.5
283 149124711408 CAP AL CP 16V 470U M 8*10.5
284 E-C-0404-4856 149124711433 CAP AL CP 16V 470U M 8*10
285 E-C-0404-4856 149124711433 CAP AL CP 16V 470U M 8*10
286 149142211408 CAP AL CP 25V 220U M 8*10.5
287 149142211408 CAP AL CP 25V 220U M 8*10.5
288 149142211433 CAP AL CP 25V 220U M 8*10
289 149142211433 CAP AL CP 25V 220U M 8*10
290 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
291 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
292 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
293 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
294 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
295 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
296 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
297 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
298 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
299 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
300 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
301 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
302 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
303 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
304 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
ViewSonic Corporation
83!
Confidential – Do Not Copy VX700-3
Page 85
305 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
306 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
307 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
308 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
309 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
310 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
311 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
312 E-C-0404-4869 1511454000 CAP MC CP 50V .01U J X7R 0603
313 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
314 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
315 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
316 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
317 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
318 E-C-0404-4878 1511514000 CAP MC CP 50V 22P J C0G 0603
319 E-C-0404-4881 1514504000 CAP MC CP 50V 5P C C0G 0603
320 E-C-0404-4881 1514504000 CAP MC CP 50V 5P C C0G 0603
321 1547667100 CAP MC CP 16V 1U Z Y5V 0805
322 1547667100 CAP MC CP 16V 1U Z Y5V 0805
323 1547667100 CAP MC CP 16V 1U Z Y5V 0805
324 1547667100 CAP MC CP 16V 1U Z Y5V 0805
325 1547667100 CAP MC CP 16V 1U Z Y5V 0805
326 1547667100 CAP MC CP 16V 1U Z Y5V 0805
327 1547667100 CAP MC CP 16V 1U Z Y5V 0805
328 1547667100 CAP MC CP 16V 1U Z Y5V 0805
329 1547667100 CAP MC CP 16V 1U Z Y5V 0805
330 1552458000 CAP MC CP 25V .1U K X7R 0603
331 1552458000 CAP MC CP 25V .1U K X7R 0603
332 1552458000 CAP MC CP 25V .1U K X7R 0603
333 1552458000 CAP MC CP 25V .1U K X7R 0603
334 1552458000 CAP MC CP 25V .1U K X7R 0603
335 1552458000 CAP MC CP 25V .1U K X7R 0603
336 1552458000 CAP MC CP 25V .1U K X7R 0603
337 1552458000 CAP MC CP 25V .1U K X7R 0603
338 1552458000 CAP MC CP 25V .1U K X7R 0603
339 1552458000 CAP MC CP 25V .1U K X7R 0603
340 1552458000 CAP MC CP 25V .1U K X7R 0603
341 1552458000 CAP MC CP 25V .1U K X7R 0603
342 1552458000 CAP MC CP 25V .1U K X7R 0603
343 1552458000 CAP MC CP 25V .1U K X7R 0603
344 1552458000 CAP MC CP 25V .1U K X7R 0603
345 1552458000 CAP MC CP 25V .1U K X7R 0603
346 1552458000 CAP MC CP 25V .1U K X7R 0603
347 1552458000 CAP MC CP 25V .1U K X7R 0603
348 1552458000 CAP MC CP 25V .1U K X7R 0603
349 1552458000 CAP MC CP 25V .1U K X7R 0603
350 1552458000 CAP MC CP 25V .1U K X7R 0603
351 1552458000 CAP MC CP 25V .1U K X7R 0603
352 1552458000 CAP MC CP 25V .1U K X7R 0603
353 1552458000 CAP MC CP 25V .1U K X7R 0603
354 1552458000 CAP MC CP 25V .1U K X7R 0603
355 1552458000 CAP MC CP 25V .1U K X7R 0603
ViewSonic Corporation
84!
Confidential – Do Not Copy VX700-3
Page 86
356 1552458000 CAP MC CP 25V .1U K X7R 0603
357 1552458000 CAP MC CP 25V .1U K X7R 0603
358 1552458000 CAP MC CP 25V .1U K X7R 0603
359 1552458000 CAP MC CP 25V .1U K X7R 0603
360 1552458000 CAP MC CP 25V .1U K X7R 0603
361 1552458000 CAP MC CP 25V .1U K X7R 0603
362 1552458000 CAP MC CP 25V .1U K X7R 0603
363 1552458000 CAP MC CP 25V .1U K X7R 0603
364 1552458000 CAP MC CP 25V .1U K X7R 0603
365 1552458000 CAP MC CP 25V .1U K X7R 0603
366 1552458000 CAP MC CP 25V .1U K X7R 0603
367 1552458000 CAP MC CP 25V .1U K X7R 0603
368 1552458000 CAP MC CP 25V .1U K X7R 0603
369 1552458000 CAP MC CP 25V .1U K X7R 0603
370 1552458000 CAP MC CP 25V .1U K X7R 0603
371 1552458000 CAP MC CP 25V .1U K X7R 0603
372 1552458000 CAP MC CP 25V .1U K X7R 0603
373 1552458000 CAP MC CP 25V .1U K X7R 0603
374 1552458000 CAP MC CP 25V .1U K X7R 0603
375 1552458000 CAP MC CP 25V .1U K X7R 0603
376 1552458000 CAP MC CP 25V .1U K X7R 0603
377 1552458000 CAP MC CP 25V .1U K X7R 0603
378 1552458000 CAP MC CP 25V .1U K X7R 0603
379 1552458000 CAP MC CP 25V .1U K X7R 0603
380 1552458000 CAP MC CP 25V .1U K X7R 0603
381 1552458000 CAP MC CP 25V .1U K X7R 0603
382 1552458000 CAP MC CP 25V .1U K X7R 0603
383 202351080105 DIO SBD 3A 40V DO-201AD
384 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
385 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
386 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
387 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
388 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
389 E-D-0403-2053 203812540836 DIO ZEN 0.5W 5.45-5.73V LLDS(M
390 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
391 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
392 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
393 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
394 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
395 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
396 E-D-0403-2050 204520700205 DIO SW 0.215A 70V SOT-23 SE.
397 204520700207 DIO SW 0.215A 75V SOT-23 SE.
398 204520700207 DIO SW 0.215A 75V SOT-23 SE.
399 204520700207 DIO SW 0.215A 75V SOT-23 SE.
400 204520700207 DIO SW 0.215A 75V SOT-23 SE.
401 204520700207 DIO SW 0.215A 75V SOT-23 SE.
402 204520700207 DIO SW 0.215A 75V SOT-23 SE.
403 204520700207 DIO SW 0.215A 75V SOT-23 SE.
404 204520700217 DIO SW 0.2A 70V SOT-23 SE.
405 204520700217 DIO SW 0.2A 70V SOT-23 SE.
406 204520700217 DIO SW 0.2A 70V SOT-23 SE.
ViewSonic Corporation
85!
Confidential – Do Not Copy VX700-3
Page 87
407 204520700217 DIO SW 0.2A 70V SOT-23 SE.
408 204520700217 DIO SW 0.2A 70V SOT-23 SE.
409 204520700217 DIO SW 0.2A 70V SOT-23 SE.
410 204520700217 DIO SW 0.2A 70V SOT-23 SE.
411 204520700305 DIO SW 0.2A 70V SOT-23 C.C.
412 204520700305 DIO SW 0.2A 70V SOT-23 C.C.
413 204520700307 DIO SW 0.215A 75V SOT-23
414 204520700307 DIO SW 0.215A 75V SOT-23
415 204520700317 DIO SW 0.2A 70V SOT-23 C.C.
416 204520700317 DIO SW 0.2A 70V SOT-23 C.C.
417 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
418 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
419 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
420 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
421 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
422 E-Q-0402-1087 210522000405 TR 40V 0.2A SOT-23 100-300
423 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
424 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
425 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
426 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
427 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
428 E-Q-0402-1180 210522000417 TR 40V 0.2A SOT-23 100-300
429 211522000205 TR -40V -0.2A SOT-23 100-300
430 211522000205 TR -40V -0.2A SOT-23 100-300
431 211522000217 TR -40V -0.2A SOT-23 100-300
432 211522000217 TR -40V -0.2A SOT-23 100-300
433 243600600031 FET -20V -3.4A 0.075ohm SO-8P
434 E-Q-0402-1551 243601100017 FET -30V -8.8A 0.02ohm SO-8
435 E-Q-0402-1552 243601100031 FET -30V -8.0A 0.02ohm SO-8
436 2500075813 IC VOLT/REG 5V 3A D2PAK-5P(TO437 2500080410 IC REGU LDO ADJ 3A DPAK
438 2500080541 IC REGU ADJ 3A TO-252
439 2500088136 IC VOL DETECTOR 4.4V SOT-23
440 2500092109 IC VOLT/REGU 5V 3A TO-263-5
441 2500223009 IC REGU 3.3V 1A SMD-8P
442 2500223009 IC REGU 3.3V 1A SMD-8P
443 2530192427 IC IMAGE PROCESSOR PQFP-208P
444 E-IC-0401-1931 2540005008 IC TRANSMITTER TSSOP-56P
445 E-IC-0401-1931 2540005008 IC TRANSMITTER TSSOP-56P
446 E-IC-0401-1932 2540170021 IC LVDS I/F TSSOP-56P
447 E-IC-0401-1932 2540170021 IC LVDS I/F TSSOP-56P
448 2540317134 IC LVDS X'CEVIER 28:4 85MHZ TS
449 2540317134 IC LVDS X'CEVIER 28:4 85MHZ TS
450 2600088009 IC HEX INVERTER SOIC-14
451 E-IC-0401-2704 2610049742 IC CMOS 2K EEPROM SO8
452 E-IC-0401-2687 2610099337 IC EEPROM 1K SO-8
453 E-IC-0401-2688 2610099942 IC EEPROM 1K*8 SO-8
454 E-IC-0401-2689 2610188212 IC E2PROM 16K 5V 8PIN
455 E-IC-0401-2690 2610188612 IC EEPROM 16K SOIC-8P
456 E-IC-0401-2691 2610380523 IC FLASH MEMORY 128K*8 70NS PL
457 E-IC-0401-2692 2610452084 IC F-EEPROM 128K*8 90NS PLCC32
ViewSonic Corporation
87!
Confidential – Do Not Copy VX700-3
Page 88
458 2817123010 CHOKE CR 100uH L
459 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
460 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
461 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
462 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
463 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
464 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
465 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
466 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
467 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
468 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
469 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
470 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
471 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
472 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
473 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
474 2921093612 CORE BEAD 100MHZ 120 OHM 0.2A
475 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
476 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
477 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
478 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
479 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
480 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
481 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
482 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
483 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
484 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
485 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
486 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
487 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
488 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
489 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
490 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
491 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
492 2921113212 CORE BEAD 100MHZ 120 OHM 4A 12
493 2970035401 PWB M0 L4 FR-4 140*117 (I/F BD
494 3020015200 SOCKET IC 32P P1.27 SMD
495 3070337934 WAFER 2.0mm 11P R-ANGLE
496 3075308757 CONN D-SUB 15P R/A PC99 W/O SC
497 3075316128 CONN DVI-D 94V0 24P R/A GOLD F
498 3076151434 PIN HEADER PBT 94V0 2*15P P2.0
499 3076265034 HEADER BOX PBT 94V0 2*5P P2.0
500 3202009100 LABEL REISTRATION 40*16
501 3202215900 LABEL MCU 11*11 POLYESTER 50#
502 3670470700 WIRE WITH HOUSING 1007 #24 L25
503 3670704600 WIRE WITH HOUSING 1007 #28 L20
504 B-KB-0207-0030 5600110075 LCD FUN KEY BD ASSY L17KMW 05A
505 M-MS-0808-8179 2301462531 LED HI-RED/GRN 3*4*2 C.C.
506 2970036001 PWB S1 FR-1 28.5*180 (KEY BD)
507 3000093900 SWITCH TACTILE DPST
508 3000093900 SWITCH TACTILE DPST
ViewSonic Corporation
87!
Confidential – Do Not Copy VX700-3
Page 89
509 3000093900 SWITCH TACTILE DPST
510 3000093900 SWITCH TACTILE DPST
511 3000093900 SWITCH TACTILE DPST
512 3000093900 SWITCH TACTILE DPST
513 3000093900 SWITCH TACTILE DPST
514 3000093900 SWITCH TACTILE DPST
515 3070337934 WAFER 2.0mm 11P R-ANGLE
516 3122009500 HOLDER FOR LED NY66 UL94V-2 6*
517 M-WR-0828-0224 3411000300 JUMP WIRE BRASS 0.6*7.5*4.0
518 M-WR-0828-0402 4010670000 WIRE CU 0.6 TNC
519 B-SB-0221-0450 5600200113 MICROPHONE BD ASSY
520 0990601015 MICROPHONE ASSY -46+-4dB L=150
521 2973007402 PWB D0 L2 FR-4 15.5*60 (MICROP
522 3072230200 CONN PHONE JACK OD3.5 7P VERTI
523 3072230300 CONN PHONE JACK OD3.5 7P VERTI
ViewSonic Corporation
88!
Confidential – Do Not Copy VX700-3
Page 90
*Readers Response*
Dear Readers:
Thank you in advance for your feedback on our Service Manual,which allows continuous improvement
of our products. We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic
corporation.
Assessment
A. What do you think about the content after reading VX700-3 series Service Manual?
tin U tn elle c x E d o o G ria F d a B
Engineering Specifications
Panel Control Description
Circuit Description
Troubleshooting Flow Chart
Adjust Procedure
Mechanical Assembly
Sechmatic Daigrams
PCB Layout
Recommended Spare Parts List
Complete Parts List
B. Are you satisfied with the VX700-3 service manual?
m etI tn ellec x E d o o G ria F d a B
tn etn o C la u n a M e civre S .1
tu o y a L lau n a M e civre S .2
g nitsil d n a m rof e h T .3
C. Do you have any other opinion or suggestion about this service manual?
Readers basic data:
:e m a N: eltiT
:y n a p m o C
:d d A
:le T: xa F
:lia m - E
After completing this form, please return it to ViewSonic Quality Assurance
1-909-839-7943.
(maupinm@viewsonic.com)
You may also e-mail any suggestions to the Director of Quality Assurance
in the USA at facsimile