Thermador PRD48WDSGU, PRD606WCSG, PRD48WLSGU, PRD606WESG, PRD48WCSGU Maintance Manual
Use and care
GUIDE
Professional Series Pro Grand® Dual Fuel Steam and 60-Inch Pro Grand Ranges
THERMADOR.COM
Use and care
GUIDE
Professional Series Pro Grand® Dual Fuel Steam and 60-Inch Pro Grand Ranges
Table of contents............................................................................... 5
Models:
PRD48WCSGC
PRD48WCSGU
PRD48WDSGC
PRD48WDSGU
PRD48WISGC
PRD48WISGU
PRD48WLSGC
PRD48WLSGU
PRD606WCG
PRD606WCSG
PRD606WEG
PRD606WESG
THERMADOR.COM
Home ConnectTM user’s information
Wi-Fi® module
FCC/IC statements
Model: COM2
FCC ID: 2AHES-COM2
IC: 21152-COM2
The Home Connect module is a communication
device designed to provide communication between
appliances and smart devices.
This module is integrated at the factory, under direct control of BSH Home
Appliances Corporation, and is not user serviceable or upgradable.
At least 20 cm separation distance should be maintained from device to user.
FCC COMPLIANCE STATEMENT
CAUTION: Changes or modifications not expressly approved could void your authority to use
this equipment.
This device complies with Part 15 of the FCC Rules. Operation to the following two conditions:
(1) This device may not cause harmful interference, and (2) This device must accept any
interference received, including interference that may cause undesired operation.
INDUSTRY CANADA STATEMENT
This device complies with Industry Canada licence-exempt RSS standard(s). Operation is
subject to the following two conditions: (1) this device may not cause interference, and (2) this
device must accept any interference, including interference that may cause undesired
operation of the device.
Operation in the band 5150-5250 MHz is only for indoor use to reduce the potential for harmful
interference to co-channel mobile satellite systems.
Le présent appareil est conforme aux CNR d’Industrie Canada applicables aux appareils radio
exempts de licence. L’exploitation est autorisée aux deux conditions suivantes : (1) l’appareil
ne doit pas produire de brouillage, et (2) l’utilisateur de l’appareil doit accepter tout brouillage
radioélectrique subi, même si le brouillage est susceptible d’en compromettre le
fonctionnement.
Le fonctionnement dans la plage de 5150 à 5250 MHz est uniquement pour une utilisation intérieure afin
de réduire le potentiel d’interférences nuisibles aux systèmes de satellites mobiles sur les canaux.
Page. 3
Congratulations!
Congratulations on your recent Thermador purchase! Whether you are a dedicated chef or simply a connoisseur of the
art of cooking, owning a Thermador kitchen is the ultimate expression of personal style, good taste and an appreciation
for the complete culinary experience. Our award-winning products have been empowering culinary enthusiasts for more
than eleven decades.
Before you begin using your new Thermador product, please take a moment to review the Use and Care Guide. You will
find the answers to all of your questions as well as some very important safety information. Pay special attention to the
Important Safety Instructions located at the beginning of the manual. Your Thermador product is ready and waiting to be
used for your next gourmet creation!
Our products are handcrafted with the highest quality authentic materials to ensure years of reliable service. In the
unlikely event that you have a service question, please have your model and serial numbers of your product available (see
the “Before calling for service” section for location).
We realize that you have made a considerable investment in your kitchen. Please feel free to share your Thermador
kitchen photos and remodeling stories with us. Follow us on Twitter or post your kitchen photos on Facebook. We would
love to hear from you!
Thermador wishes you many years of creative cooking.
Page. 4
Tabl e o f
CONTENTS
Safety ...................................................................................... 7
Important safety instructions .......................................... 7
Description ............................................................................. 16
Appliance identification .................................................. 16
Before you begin ................................................................... 22
Getting started ............................................................... 22
Using the rangetop ................................................................26
Sealed STAR® burners .................................................... 26
ExtraLow® burners ......................................................... 27
PowerBoost®................................................................... 27
Electric griddle ................................................................ 33
Electric grill...................................................................... 36
Using the oven........................................................................ 41
Symbols and descriptions................................................41
Initial start-up................................................................... 43
Setting the oven(s)........................................................... 43
Timers
Panel lock ................................................................... 44
Multi-point meat probe ............................................. 45
Sabbath ..................................................................... 45
Remote start .............................................................. 47
Getting the most out of your appliance ................................. 48
Oven rack positions.........................................................48
Bake ........................................................................... 48
Broil ........................................................................... 49
Convection broil ........................................................ 50
Convection bake ........................................................ 50
True convection ......................................................... 51
Proof .......................................................................... 51
Roast .......................................................................... 52
Convection roast .......................................................52
Warm ......................................................................... 53
Fine tuning the oven........................................................ 53
..................................................... 44
Setting up Home Connect
Setup................................................................................54
Using the steam convection oven...........................................58
Description.......................................................................58
Before using.....................................................................60
Operating the steam oven...............................................61
Steam programs......................................................................72
Introduction to steam programs......................................72
Using the warming drawer ................................................78
Operating the warming drawer .......................................78
Care and maintenance ...........................................................82
Self-clean ....................................................................82
Steam-clean ...............................................................83
Descale .......................................................................84
Appliance cleaning tips ...................................................84
Do-it-yourself maintenance ....................................................89
Oven light bulb replacement ..........................................89
Before calling for service ........................................................91
Troubleshooting ..............................................................91
Data rating label .............................................................92
Service information .........................................................92
Remote costumer service connection ........................92
Product registration.........................................................92
Statement of limited product warranty ..................................93
Support, accessories, and parts.................................back page
TM
..................................................54
Page. 5
Safety
DEFINITIONS
9 WARNING
This indicates that death or serious injuries may occur as a
result of non-observance of this warning.
9 CAUTION
This indicates that minor or moderate injuries may occur as a
result of non-observance of this warning.
NOTICE: This indicates that damage to the appliance or
property may occur as a result of non-compliance with this
advisory.
Note: This alerts you to important information and/or tips.
Page. 6
This THERMADOR® appliance is made by
BSH Home Appliances Corporation
1901 Main Street, Suite 600
Irvine, CA 92614
Questions?
1-800-735-4328
www.thermador.com
We look forward to hearing from you!
Safety
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
Please read carefully
Installer: Please leave this guide with this unit for the
owner.
Owner: Please retain this guide for future reference. Use
appliance only for its intended purpose as described in
this manual.
WARNING
When properly cared for, your new appliance has been
designed to be safe and reliable. Read all instructions
carefully before use. These precautions will reduce the
risk of burns, electric shock, fire, and injury to persons.
When using kitchen appliances, basic safety
precautions must be followed, including these in the
following pages.
WARNING
If the information in this manual is
not followed exactly, a fire or
explosion may result causing
property damage, personal injury or
death.
-- DO NOT store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
-- WHAT TO DO IF YOU SMELL GAS
• DO NOT try to light any appliance.
• DO NOT touch any electrical switch.
• DO NOT use any phone in your
building.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas supplier,
call the fire department.
-- Installation and service must be
performed by a qualified installer, service
agency or the gas supplier.
WARNING
DANGER OF TIPPING
All ranges can tip and injury can result. To
prevent accidental tipping of the range, attach
it to the floor, wall, or cabinet by installing the
anti-tip bracket supplied.
A child or adult can tip the range over and be
killed or seriously injured. Verify that the antitip bracket is securely installed. Ensure the antitip bracket is engaged when the range is
moved.
DO NOT operate the range
without the anti-tip bracket in
place. Failure to follow the
instructions in this manual can
result in death or serious burns to
children and adults.
If the range is pulled away from
the wall for cleaning, service, or
any other reason, ensure that the
anti-tip bracket is properly
reengaged when the range is pushed back against the
wall. In the event of abnormal usage (such as a person
standing, sitting, or leaning on an open door), failure
to take this precaution can result in tipping of the
range. Personal injury might result from spilled hot
liquids or from the range itself.
Check for proper installation and use of anti-tip
bracket. Carefully tip range forward pulling from the
back to ensure that the anti-tip bracket engages the
range and prevents tip-over. Range should not move
more than 1'' (2.5 cm).
WARNING
Improper installation, adjustment, alteration, service
or maintenance can cause injury or property damage.
Refer to this manual. For assistance or additional
information consult a qualified installer, service
agency, manufacturer or the gas supplier.
WARNING
To provide proper ventilation of the range DO NOT
remove range feet.
Page. 7
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
WARNING
Before servicing or cleaning the unit, switch power off
at service panel and lock service panel. This will
prevent power from being switched on accidentally.
When the service panel cannot be locked, securely
fasten a prominent warning device, such as a tag to
the service panel.
Gas type verification
Natural gas – 7 in. column water (17.4 mb) min., 14 in.
(34.9 mb) maximum
Propane gas – 11 in. water column (27.4 mb) min., 14 in.
(34.9 mb) maximum
Verify the type of gas supplied to the location. Ensure that
the appliance is connected to the type of gas for which it
is certified. Refer to the Data Rating Label.
WARNING
If a gas conversion kit is used, the kit shall be installed
by qualified technician in accordance with the
manufacturer’s instructions and all applicable codes
and requirements of the authority having jurisdiction.
If the information in the instructions is not followed
exactly, a fire, explosion or production of carbon
monoxide may result causing property damage,
personal injury or loss of life. The qualified technician
is responsible for the proper installation of the kit. The
installation is not proper and complete until the
operation of the converted appliance is checked as
specified in the manufacturer’s instructions supplied
with the kit.
CAUTION
When connecting the unit to propane gas, make
certain the propane gas tank is equipped with its own
high-pressure regulator in addition to the pressure
regulator supplied with the appliance. The maximum
gas pressure to this appliance must not exceed 14.0''
water column (34.9 mb) from the propane gas tank to
the pressure regulator.
For Massachusetts installations
1. Installation must be performed by a qualified or
licensed contractor, plumber or gas fitter qualified or
licensed by the state, province or region where this
appliance is being installed.
2. Shut-off valve must be a “T” handle gas cock.
3. Flexible gas connector must not be longer than 36''
(914 mm).
Ensure proper installation and servicing. Follow the
Installation Instructions provided with this product. Have
the appliance installed and electrically grounded by a
qualified technician.
In the event a burner goes out and gas escapes, open a
window or a door. DO NOT attempt to use the appliance
until the gas has had time to dissipate. Wait at least 5
minutes before using the appliance.
DO NOT repair or replace any part of the appliance unless
specifically recommended in this manual. All servicing
should be referred to an authorized servicer.
Electrical requirements
WARNING
IN CASE OF AN ELECTRICAL FAILURE
If for any reason a gas control knob is turned
ON and there is no electrical power to operate
the electronic igniters on the burners, turn OFF
the gas control knob and wait 5 minutes for the
gas to dissipate before lighting the burner
manually.
To light the burners manually, carefully hold a
lighted match to the burner ports and turn the
gas control knob to HI
you can use the standard burners, but each
must be lit with a match.
DO NOT attempt to light the XLO® burners
manually. These burners are equipped with the
ExtraLow® feature and cannot be lit manually.
The appliance must be electrically grounded in
accordance with local codes or, in the absence of local
codes, with the National Electrical Code, NFPA 70 or the
Canadian Electric Code, CSA C22.1-02.
. During a power failure,
Page. 8
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
It is the personal responsibility and obligation of you, the
user, to have this appliance connected to the electrical
power supply by a qualified electrician, in accordance with
the National Electrical Code and/or applicable local codes
and ordinances.
Service should only be done by an authorized servicer.
Always disconnect the electrical plug from the wall
receptacle before servicing this unit.
See the Installation Instructions for electrical requirements
and grounding instructions.
Have the installer show you where the electric circuit
breaker and the gas supply shut off valve are located so
you know how and where to turn off the gas and electricity
to the appliance.
Installation and maintenance must be carried out correctly.
Follow the instructions in the Installation Manual supplied
with the product. Make sure that a qualified electrician
installs and performs grounding of the appliance.
This appliance complies with the following Safety
Codes and Standards:
• UL 858, The Standard for the Safety of Household
Electric Ranges
• ANSI Z21.1, The American National Standard for
Household Cooking Gas Appliances
• CAN1-1.1-M81, Domestic Gas Ranges
• CSA C22.2 No. 61, Household Cooking Ranges
Installation must conform with local codes or, in the
absence of local codes, with the National Fuel Gas Code,
ANSI Z223.1/NFPA 54 or, in Canada, the Natural Gas and
Propane Installation Code, CSA B149.1.
Installation of appliances designed for manufactured
(mobile) home installation must conform with the
Manufactured Home Construction and Safety Standard,
Title 24 CFR, Part 3280 [formerly the Federal Standard for
Mobile Home Construction and Safety, Title 24, HUD (Part
280)] or with local codes where applicable.
Installation of appliances designed for recreational park
trailers must conform with state or other codes or, in the
absence of such codes, with the Standard for Recreational
Park Trailers, ANSI A119.5.
Clearances from non-combustible materials are not part of
the ANSI Z21.1 scope and are not certified by
CSA. Clearances under 6 inches should be approved by
the local codes and/or by the local authority having
jurisdiction.
It is the responsibility of the owner and the installer to
determine if additional requirements and/or standards
apply to specific installations.
The maximum depth of cabinets installed above cooking
surface must be 13'' (330 mm).
Child safety
WARNING
DO NOT store items of interest to children above or
at the back of the appliance. If children should climb
onto the appliance to reach these items, they could be
seriously injured.
When children become old enough to use the appliance,
it is the responsibility of the parents or guardians to ensure
that they are instructed in safe operation of the appliance
by qualified persons.
DO NOT allow anyone to climb, stand, lean, sit, or hang
on any part of an appliance. This can damage the
appliance, and the unit may tip over, potentially causing
severe injury.
DO NOT allow children to use this appliance unless
closely supervised by an adult.
Children and pets should not be left alone or unattended
in the area where the appliance is in use. They should
never be allowed to play in its vicinity, whether or not the
appliance is in use.
General safety
State of California Proposition 65 Warning:
: WARNING
This product can expose you to chemicals including
vinyl chloride, which is known to the State of California
to cause cancer and birth defects or other
reproductive harm. For more information go to
www.P65Warnings.ca.gov.
Page. 9
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
WARNING
To reduce the risk of injury to persons, in the event
of a range top grease fire, observe the following:
• Smother flames with a close-fitting lid, cookie
sheet, or other metal tray, then turn off the gas
burner or the electric element. Be careful to
prevent burns. If the flames do not go out
immediately, evacuate and call the fire
department.
• Never pick up a flaming pan. You may be burned.
• DO NOT use water, including wet dish cloths or
towels, to extinguish flames – a violent steam
explosion will result.
• Use an extinguisher ONLY if:
• You know you have a class ABC extinguisher
and you already know how to operate it.
• The fire is small and contained in the area
where it started.
• The fire department is being called.
• You can fight the fire with your back to an exit.
WARNING
To eliminate risk of burns or fire caused by reaching
over heated surface units, cabinet storage located
above the surface units should be avoided.
WARNING
TO REDUCE THE RISK OF A GREASE FIRE:
• Never leave surface units unattended at high
settings. Boilovers cause smoking and greasy
spillovers that may ignite. Heat oils slowly on low
or medium settings.
• Always turn hood ON when cooking at high heat
or when flambéing food (i.e. Crepes Suzette,
Cherries Jubilee, Peppercorn Beef Flambé).
• Clean hood filters frequently. Grease should not
be allowed to accumulate on fan or filter.
• Use proper pan size. Always use cookware
appropriate for the size of the appliance burner.
If the appliance is near a window, be certain the curtains
do not blow over or near the appliance burners; they
could catch on fire.
ALWAYS have a working smoke detector near the kitchen.
In the event that personal clothing or hair catches fire,
drop and roll immediately to extinguish flames.
Have an appropriate fire extinguisher available nearby,
highly visible, and easily accessible near the cooking
appliance.
Smother flames from food fires, other than grease fires,
with baking soda. Never use water on cooking fires.
Whenever possible, do not operate the ventilation system
during a fire. However, DO NOT reach through fire to turn
it off.
NEVER let clothing, potholders, or other flammable
materials come in contact with or too close to any burner
or burner grate until it has cooled. Fabric may ignite and
result in personal injury.
Use only dry potholders: moist or damp potholders on hot
surfaces may cause burns from steam. DO NOT use a
towel or other bulky cloth in place of potholders. DO NOT
let potholders touch hot burners or burner grates.
For personal safety, wear proper apparel. Loose fitting
garments or hanging sleeves should never be worn while
using this appliance. Some synthetic fabrics are highly
flammable and should not be worn while cooking.
DO NOT use aluminum foil to line any part of the
appliance. Use of a foil liner could result in a shock or fire
hazard, or the obstruction of the flow of combustion and
ventilation air. Foil is an excellent heat insulator and heat
will be trapped beneath it. This will upset the cooking
performance and can damage the finish of the appliance.
WARNING
The appliance is for cooking. Based on safety
considerations, never use the appliance to warm or
heat a room. Doing so may result in carbon monoxide
poisoning and overheating of the unit. Also, such use
can damage the appliance parts.
NEVER use any part of the appliance for storage.
Flammable materials can catch fire and plastic items may
melt or ignite. DO NOT hang articles from any part of the
appliance. Some fabrics are quite flammable and may
catch on fire.
Page. 10
When using the appliance: DO NOT TOUCH THE
BURNER GRATES OR THE IMMEDIATE SURROUNDING
AREA. Areas adjacent to the burners may become hot
enough to cause burns.
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
Never leave the appliance unattended when using high
flame settings. Boil overs cause smoking and greasy
spillovers that may ignite. Also, if the burner flames and
igniter are smothered with spillage, unburned gas will
escape into the room. See page 7 regarding gas leaks.
Only certain types of glass, heatproof glass-ceramic,
ceramic, earthenware, or other glazed cookware are
suitable for cooking on the burners. This type of cookware
may break with sudden temperature changes. Use only on
low or medium heat settings according to the utensil
manufacturer’s directions.
DO NOT heat or warm unopened food containers. Buildup of pressure may cause the container to burst and cause
injury.
WARNING
During cooking, set the burner control so that the
flame heats only the bottom of the pan and does not
extend beyond the bottom of the pan. This instruction
is based on safety considerations.
Use caution to ensure that drafts like those from forced air
vents or fans do not blow flammable material toward the
flames or push the flames so that they extend beyond the
edges of the pot.
GREASE IS FLAMMABLE. Let hot grease cool before
attempting to handle it. Avoid letting grease deposits
collect. Clean after each use.
For proper lighting and performance of the burners, keep
the igniter ports clean. It is necessary to clean the ports
when there is a boil over or when the burner does not light
even though the electronic igniters activate.
Clean the appliance with caution. Avoid steam burns; DO
NOT use a wet sponge or cloth to clean the appliance
while it is hot. Some cleaners produce noxious fumes if
applied to a hot surface. Follow directions provided by the
cleaner manufacturer.
WARNING
After a spill or boil over, turn off the burner and using
caution due to possible hot surfaces, clean around the
burner and burner ports. After cleaning, check for
proper operation.
Be sure all controls are turned off and the appliance is cool
before using any type of aerosol cleaner on or around the
appliance. The chemical that produces the spraying action
could, in the presence of heat, ignite or cause metal parts
to corrode.
Always use pots and pans that have flat bottoms large
enough to cover the burner. The use of undersized pots
and pans could expose a portion of the flame and may
result in ignition of clothing.
WARNING
Avoid using high flame setting with a pan larger than
the grate or with one that spans more than one
burner, such as a griddle, for prolonged periods of
time. This can result in poor combustion that
generates harmful by-products.
DO NOT use pots or pans on the grill plate accessory
(purchased separately). Bakeware, such as large casserole
pans, cookie sheets, etc., should never be used on the
accessory.
DO NOT use flammable cleaners to clean the appliance.
Remove the optional cutting board or griddle cover
accessory, which is stored on top of the griddle plate,
before operating the griddle or any adjacent burners.
WARNING
DO NOT block or obstruct the flow of air
through the ventilation openings. The vent is
located at the back of the appliance. The
vent needs to be unobstructed and open to
provide necessary airflow that is important
for proper performance.
DO NOT touch vent area while the appliance is on
and for several minutes after the appliance is off.
Some parts of the vent and surrounding areas become
hot enough to cause burns. Allow appliance sufficient
time to cool before touching or cleaning vent areas.
DO NOT position plastic or other heat-sensitive items
on or near the vent. These items could melt or ignite.
DO NOT obstruct the flow of combustion or ventilation
air.
DO NOT use the grill plate accessory for cooking
excessively fatty meats or products which promote flareups.
Page. 11
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
When cooking fatty or oily foods on burners, the grill, or
the griddle, adjacent gas burners can ignite airborne
fumes. Use caution to avoid burns.
To avoid a fire hazard, grease accumulation must be
prevented by frequently cleaning the ventilation hood and
filters.
In case of fire or when intentionally “flaming” liquor or
other spirits on the appliance, follow manufacturer’s
instructions. Use caution when cooking foods with high
alcohol content (e.g. rum, brandy, bourbon). Alcohol
evaporates at high temperatures. There is a risk of burning
as the alcohol vapors may catch fire. Use only small
quantities of alcohol in foods.
DO NOT store or use corrosive chemicals, vapors,
flammables, or nonfood products in or near this appliance.
It is specifically designed for use when heating or cooking
food. The use of corrosive chemicals while heating or
cleaning will damage the appliance and could result in
injury.
WARNING
DO NOT leave food or cooking utensils, etc, in oven
during the self-cleaning mode of operation.
Before self-cleaning the oven (select models), remove
the broiler pan, oven racks, and any other utensils,
and excess spillage.
IMPORTANT: There is a possibility to discolor the back
wall under certain cooking conditions.
DO NOT clean, rub, damage, move or remove the door
gasket. It is essential for a good seal during baking. If the
gasket becomes worn or excessively soiled with food
particles, replace gasket to assure a tight seal.
Protect the self-cleaning feature. Clean only those parts
indicated in this booklet. DO NOT use commercial oven
cleaners or oven liner protective coatings of any kind in or
around the self-cleaning oven.
Place oven racks in desired position while oven is cool. If a
rack must be moved while the oven is hot, do not let the
potholders contact the broiler element.
DO NOT TOUCH HEATING ELEMENTS OR INTERIOR
SURFACES OF OVEN – Heating elements may be hot
even though they are dark in color. Interior surfaces of an
oven become hot enough to cause burns. During and
after use, do not touch, or let clothing or other flammable
materials contact heating elements or interior surfaces of
oven until they have had sufficient time to cool. Other
surfaces of the appliance may become hot enough to
cause burns - among these surfaces are oven vent
openings and surfaces near these openings, oven doors,
and windows of oven doors.
WARNING
WARNING
This appliance should not be installed with a
ventilation system that directs air in a downward
direction toward the appliance. This type of
ventilation system may cause ignition and combustion
problems with the appliance resulting in personal
injury, property damage, or unintended operation.
Ventilating systems that direct the air upwards do not
have any restriction.
An air curtain or other overhead range hood, which
operates by blowing a downward airflow onto a
range, shall not be used in conjunction with a gas
range unless the hood and range have been designed
and tested in accordance with the Standard for
Domestic Gas Ranges, ANSI Z21.1 • CSA 1.1, and
listed by an independent testing laboratory for
combination use.
NEVER cover any slots, holes or passages in the oven
bottom or cover an entire rack with materials such as
aluminum foil. Doing so blocks air flow through the
oven and may cause carbon monoxide poisoning.
Aluminum foil linings may also trap heat, causing a fire
hazard.
Use care when opening the oven door; let hot air or steam
escape before removing or replacing foods.
Please note that some pets or humans can be sensitive to
the odors created during the self-cleaning process
whether it is a manufacturing residue burn off or food. It is
recommended that those potentially affected be removed
from the kitchen area during the self-clean process.
Page. 12
9 IMPORTANT SAFETY INSTRUCTIONS
READ AND SAVE THESE INSTRUCTIONS
Steam oven safety practices
The steam oven bottom and the evaporator dish must
always remain clear. Always place ovenware on the rack or
in the provided cooking pans.
Ovenware must be heat and steam resistant. Silicone
baking pans are not suitable for steam mode.
DO NOT place anything on the open appliance door. This
could damage the appliance.
DO NOT use the grill plate accessory for cooking
excessively fatty meats or products which promote flareups.
When cooking fatty or oily foods on burners, the grill, or
the griddle, adjacent gas burners can ignite airborne
fumes. Use caution to avoid burns.
When using steam mode with a perforated cooking pan,
always slide the solid pan underneath it. The pan will catch
any drippings.
CAUTION
DO NOT overfill very juicy fruit tortes with fruit when
using the baking pan. The fruit juice that drips off the
baking pan leaves behind stains that cannot be removed.
When using aluminum foil in the steam oven, DO NOT
allow it to touch the glass on the door. This could cause
permanent staining of the door glass.
DO NOT place food directly on oven bottom. Follow the
manufacturer’s directions.
DO NOT clean the steam oven while it is still hot. Some
cleaners produce noxious fumes when applied to a hot
surface. Wet cloths or sponges can cause burns from
steam.
Risk of severe burns! DO NOT clean the steam oven
immediately after turning it off. The water in the
evaporator dish is still hot. Wait until the appliance has
cooled down.
The door will no longer close properly if the door gasket is
heavily soiled. The face of adjacent furnishings could
become damaged. Always keep the door gasket clean
and contact a Thermador Service Technician to replace if
necessary.
• Hot steam can escape when opening the oven
door. Hot water may drip from the door. Keep
children away.
• DO NOT touch the ventilation openings.
DO NOT store moist foods for an extended period of time
in the closed steam oven. The food could cause corrosion
of the oven interior.
The oven cavity is made of high quality stainless steel.
Improper care may result in corrosion of the oven cavity.
Follow the care and cleaning instructions provided in this
manual. Remove food residue and spills from the cavity
immediately after the steam oven has cooled down.
Remove all tape and packaging before using the
appliance. Destroy the packaging after install. Never allow
children to play with packaging material.
Page. 13
Getting started with
your range
Getting started with
your range
Description
1
2
3
4
6
5
9
10
7
11
8
Appliance identification
60'' double oven
Model shown is 60'' double oven with 6 burners and grill and griddle options (features will vary).
1 Island Trim included or Low Backguard ordered separately (See Warning concerning spacing behind the range
when using the range with the Island Trim.)
2 Oven vent – DO NOT obstruct!
3STAR
4 Grill option
5 Griddle option (options will vary)
6 Control panel
7 Leg covers (If additional leg covers are required, they may be ordered from the service center by calling
8 Main oven
9 Secondary oven
10 Range feet
11 Range casters (60'' models only)
Page. 16
®
burners and grates
1–800–735–4328 at no charge for up to one year after purchase date of the appliance.)
Steam range
1
2
3
4
6
5
8
9
7
12
10
11
Model shown is 60'' steam oven with 6 burners and grill and griddle options (features will vary).
1 Island Trim included or Low Backguard ordered separately
(See Warning concerning spacing behind the range when using the range with the Island Trim.)
2 Oven vent – DO NOT obstruct!
3STAR® burners and grates
4 Grill option
5 Griddle option (options will vary)
6 Control panel
7 Leg covers (If additional leg covers are required, they may be ordered from the service center by calling
1–800–735–4328 at no charge for up to one year after purchase date of the appliance.)
8 Main oven
9Steam oven
10 Warming drawer
11 Range feet
12 Range casters (60'' models only)
Page. 17
Oven interiors and warming drawer
12 3 4
567
1
2
Oven interior
1 Broil element
2 Convection cover
3 Oven temperature sensor
4Rack guides
5 Oven interior light
6 Outlet for multi-point meat
probe
7Rack positions
8 Oven rack
9 Bake element (hidden)
Steam oven interior
1Rack guide
2 Oven light
3 Steam vent
4 Convection cover
5 Water tank
6 Evaporator dish
7Rack
12 3 546
895
7
Warming drawer
1 Warming platform
2 Heating element (hidden)
Page. 18
Control panel identification
OFF
OFF
TIMERS
SETTINGS ENTER
06:30
1
2 3 4 65
NOTE: Not all knobs, modes, and features are available to
all models.
ExtraLow
®
POWERBOOST
®
Standard Griddle Grill
Steam oven temp selector Induction Mode selector Oven temp
selector
Oven digital display
Oven temp gauge
350
300
250
200
100
400
CLEAN
450
500
BROIL
Light switch
1 Digital display screen
2 Left navigation buttons
3 Access multiple timers
4 Access user settings or the warming drawer on steam models
5 Confirm an entry
6 Right navigation buttons
Page. 19
Top surface identification
33
44
66
11
22
55
77
33
44
77
11
22
66
55
Model 486 with induction
Model 486 with griddle
1 ExtraLow® burner Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost
®
Natural 18000, LP 15000 BTU
3 Standard burner Natural 15000, LP 12000 BTU
4 Standard burner Natural 18000, LP 15000 BTU
5 ExtraLow burner Natural 15000, LP 12000 BTU
6 ExtraLow burner Natural 18000, LP 15000 BTU
7 Induction 3,600W
Model 486 with grill
11
22
33
55
44
66
77
1 ExtraLow burner Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost Natural 18000, LP 15000 BTU
3 Standard burner Natural 15000, LP 12000 BTU
4 Standard burner Natural 18000, LP 15000 BTU
5 Griddle 1,630W
6 ExtraLow burner Natural 15000, LP 12000 BTU
7 ExtraLow burner Natural 18000, LP 15000 BTU
Model 486 with grill and griddle
1 ExtraLow burner Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost Natural 18000, LP 15000 BTU
3 Standard burner Natural 15000, LP 12000 BTU
4 Standard burner Natural 18000, LP 15000 BTU
5 Grill 815W x 2
6 ExtraLow burner Natural 15000, LP 12000 BTU
7 ExtraLow burner Natural 18000, LP 15000 BTU
11
22
33
55
44
66
1 ExtraLow burner Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost Natural 18000, LP 15000 BTU
3 ExtraLow burner Natural 15000, LP 12000 BTU
4 ExtraLow burner Natural 18000, LP 15000 BTU
5 Grill 815W x 2
6 Griddle 1,630W
Page. 20
Model 606 with griddle and grill
33
44
77
88
11
22
55
66
Model 606 with double griddle
1 ExtraLow burner
®
Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost
®
Natural 18000, LP 15000 BTU
3 Standard burner Natural 15000, LP 12000 BTU
4 Standard burner Natural 18000, LP 15000 BTU
5 Grill 815W x 2
6 Griddle 1,630W
7 ExtraLow burner Natural 18000, LP 15000 BTU
8 ExtraLow burner Natural 15000, LP 12000 BTU
11
22
33
55
44
66
77
1 ExtraLow burner Natural 15000, LP 12000 BTU
2 ExtraLow burner and
PowerBoost Natural 18000, LP 15000 BTU
3 Standard burner Natural 15000, LP 12000 BTU
4 Standard burner Natural 18000, LP 15000 BTU
5 Griddle 1,630W x 2
6 ExtraLow burner Natural 15000, LP 12000 BTU
7 ExtraLow burner Natural 18000, LP 15000 BTU
Page. 21
Before you begin
Getting started
Data rating label
• Record the model and serial number on page 92.
• The model and serial number must be provided when
calling customer support for assistance.
• Register your BSH product to ensure timely service
and access to your product related information. For
product registration information see page 92.
Surface burners
1. Ensure that the burner caps are correctly seated on
the burner bases of the range's cooktop (see
page 26).
2. Turn on each burner to check for proper flame color
(see “Flame description” on page 28 for details).
Oven racks
To install rack guides
To install Full Access
1. Hold the rack on a slight angle and place the safety
hooks under the front of the rack guides.
2. Push the rack into the oven, lifting the rack stops
over the front of the rack guides.
3. Hold the rack straight.
®
racks:
1. Push the two rails in the holes in the back of the oven
cavity.
2. Slide the guide's key slots over the shoulder bolts.
3. At the front of the oven cavity press down on the front
of rack guide to clear the heads of the two shoulder
bolts.
4. Push the rack in completely.
5. Engage the rack’s front hooks on the rack guides.
IMPORTANT: When placing the gliding rack in the oven,
make sure the front supports on the rack guides rest in
the large slots at the front corners of the rack. This is
necessary to keep the rack in the correct position while
fully inserted into the oven.
Page. 22
To install flat racks
1. Grasp rack firmly on both sides and insert rack.
2. Tilt rack up to allow stop into rack guide.
Oven operation
Positioning the oven racks
9 WARNING
To help prevent burns, never remove or reposition the
oven racks while the oven is ON or while the oven is
cooling.
• The correct rack position depends on the recipe and
the cooking mode.
• The rack positions are numbered from the bottom of
the oven, like an elevator.
• Rack position 3 is the most frequently used position.
• Place rack(s) in the proper position before turning on
the oven.
The range occasionally has an odor or smoke when first
used. These odors or smoke comes from the burning off of
manufacturing residues and is typical of any new oven
regardless of manufacturer.
IMPORTANT: ALWAYS remove the oven racks before selfcleaning the oven. If the gliding racks remain in the oven
during self-clean, lubricants in the glide mechanisms of
each rack will be lost and the finish will discolor.
Automatic operation of the cooling fan
The cooling fan runs during all cooking modes. The fan
can be heard when it is running, and warm air may be felt
as it is released from the oven vent. The fan may also run
after the oven is off.
Oven vent
The oven vent is located at the back of the unit. Warm air
may be released from the vent before, during and after
cooking. It is normal to see steam escaping from the vent,
and condensation may collect in this area. This area may
be warm when the oven is in use. Do not block the vent,
since it is important for air circulation.
Convection fan
The convection fan operates during all convection modes.
When the oven is operating in a convection mode, the fan
turns off automatically when the door is opened. The
convection fan may also run during self-clean.
Initial start-up
Before baking or broiling, the oven and broiler should be
turned on to burn off the manufacturing oils using one of
the two following methods:
1. Turn on kitchen ventilation (or if vent hood is a
recirculation type open a window).
2. Turn the oven on to 450ºF (230ºC) for 20 to 30
minutes; then turn the broiler to broil for the same
length of time.
or
1. Turn on kitchen ventilation (or if vent hood is a
recirculation type open a window).
2. Remove oven racks.
3. Set oven to self-clean (select models).
Page. 23
Using the rangetop
Using the rangetop
Using the rangetop
Sealed STAR® burners
9 WARNING
To prevent flare-ups and avoid the creation of harmful
by-products, do not use the cooktop without all
burner caps and all burner grates properly positioned.
9 WARNING
To prevent burns, do not touch burner caps or grates
while hot. Turn the cooktop off and allow the burners
to cool.
The burner caps must be properly placed on the burner
bases for the cooktop to function properly. If the burner
cap is not properly placed, one or more of the following
problems may occur:
• Burner flames are too high.
• Flames shoot out of burners.
• Burners do not ignite.
• Burner flames light unevenly.
• Burner emits gas odor.
Burner cap placement
Each cap has a letter (B, D, or F) cast in the underside of
the cap that corresponds to a letter (B, D, or F) cast in the
burner base that is attached to the appliance.
Checking the burner cap placement
• Check each burner to make sure there is no gap
between the burner cap and burner base.
• You may gently try to move the burner caps from side
to side to check if the caps are properly placed on the
burner bases.
• When properly placed, each burner cap will rest flat
on top of its burner base, and completely cover the
star-shape of the burner base when viewed from the
top as shown below.
Burner grate placement
To install the burner grates
1. Place grates flat-side down and align into the
rangetop recess.
2. Grates should rest flush against each other and
against the sides of the recess.
To place the burner caps
1. Place each burner cap on its correct burner base per
its corresponding letter designation.
2. Place burner cap gently on top of base so that the
prongs of the burner base fit snugly into the groove of
the burner cap.
Page. 26
Control knobs
Operation of the ExtraLow
®
burners
The control knobs for two sealed gas burners, one in front
and one in the rear, are located directly in front of and
below the pair of burners on the control panel.
Operation of the burners
To turn on the burners
1. Press in on the knob and turn it counter-clockwise HI.
– The igniter for the selected burner clicks and
sparks.
– After burner ignition, the igniter stops clicking.
2. Rotate the knob to any flame setting between HI and
LO.
LED panel light (select models)
Positioned below the bullnose, the LED panel light
provides task lighting with a theatrical ambiance.
The panel light toggle switch on the control panel turns
the light ON and OFF.
• XLO, the very lowest setting, is achieved by cycling
the flame on for approximately 10 seconds and off for
50 seconds of each minute.
• When the knob is set just below the XLO setting, the
flame will cycle on for approximately 50 seconds and
off for 10 seconds of each minute.
• To vary the amount of low heat to suit the food and
quantity, the control can be set anywhere within the
XLO range marked on the knob.
ExtraLow
• To maintain a low or simmer heat, bring food to a
• If a large pan is used, the simmer action may occur
• It is normal to stir food occasionally while simmering.
®
techniques
rolling boil. Stir well, then cover the pan and lower the
heat to a setting just below XLO.
mainly in the center of the pan. To equalize the
temperature throughout the food, stir the food
around the outer edges of the pan into the food in the
center.
This is especially important when simmering for
several hours, such as for a homemade spaghetti
sauce or beans.
ExtraLow® burners
The controls for the
ExtraLow burners have flame
settings even lower than the
standard low settings.
The drawing shows that the control knob has an additional
range after the XLO setting. When the knob is set within
this range, the flame cycles off and on.
By varying the length of time the flame is off and on, the
heat is reduced even further to cook delicate foods. For
example, these very low settings are suitable for
simmering and poaching, melting chocolate and butter,
holding cooked foods at temperatures without scorching
or burning, etc.
• If the setting is too low to hold a simmer, bring the
food back to a boil before re-setting to a higher heat.
• There may be bubbling when the flame cycles on and
no bubbles when the flame is off. Even when the flame
is off, there will be steam and a slight quiver on the
liquid’s surface.
®
POWERBOOST
(select
models)
The POWERBOOST, or XHI, offers
the convenience to quickly boil
water, sear steaks, stir-fry
vegetables, etc. Use of the SIM
and XLO remains the same as the
other XLO knobs.
Page. 27
Automatic re-ignition
Flame height
Each burner has its own electronic igniter that sparks
when the burner is turned on. Each burner should light in
4 seconds or less. If a burner does not light, check to see
that the cap is positioned correctly on the base.
If any one or more burners blow out, the electronic igniter
automatically activates to re-light the flame. Do not touch
the burners when the igniters are active.
9 CAUTION
DO NOT touch the burners when the igniters are
sparking.
IMPORTANT
• For proper combustion do not use the rangetop
without the burner grates in place.
• There is a slight sound associated with gas
combustion and ignition. This is a normal condition.
• On rangetops using propane gas (LP), a slight “pop”
sound may be heard at the burner ports a few seconds
after the burner has been turned off.
• The correct flame height depends on 1) size and
material of pan being used; 2) food being cooked; and
3) amount of liquid in the pan.
• Never extend the flame beyond the base of the pan.
• Use a low or medium flame for pan materials that
conduct the heat slowly, such as porcelain coated
steel or glass-ceramic.
Flame description
Flame characteristics
Yellow flames:
Further adjustment is
required.
Yellow tips on outer cones:
Normal for LP Gas
Soft blue flames:
Normal for natural gas
Power failure
9 WARNING
In the event of a power failure, turn all knobs to the
OFF position. Only the standard burners can be lit
manually.
• In the event of a power failure, only the standard
burners can be manually lit. It is necessary to light
each one individually.
• If the rangetop is being used when the power failure
occurs, turn all knobs to the OFF position.
• The standard burners can be lit by holding a match at
the ports and turning the control knob to the HI
position. Wait until the flame is burning all around the
burner cap before adjusting the flame to the desired
height.
• The burners with the ExtraLow
used during a power failure. Be sure to turn them off.
• If a burner with ExtraLow is on when a power failure
occurs, it cannot be turned back on until the knob is
first turned off.
®
feature cannot be
• If the flame is completely or mostly yellow, verify that
the regulator is set for the correct fuel. After
adjustment, retest.
• Some orange-colored streaking is normal during the
initial start-up.
• Allow unit to operate 4-5 minutes and re-evaluate
before making adjustments.
• The burner flame color should be blue with no yellow
on the tips. It is not uncommon to see orange in the
flame color; this indicates the burning of airborne
impurities in the gas and will disappear with use.
• With propane (LP) gas, slight yellow tips on the
primary cone are normal.
• The flame should burn completely around the burner
cap. If it doesn’t, check that the cap is positioned
correctly on the base and that the ports are not
blocked.
• The flame should be stable with no excessive noise or
fluttering.
• If you smell gas, refer to safety precautions listed in
the Safety chapter.
Page. 28
Cookware recommendations
9 WARNING
To avoid risk of serious injury, damage to appliance or
cookware, please observe the following:
• Bakeware, such as large casserole pans, cookie sheets,
etc. should never be used on the rangetop.
• Placement of large stock pots should be staggered
when used on the rangetop.
• Food packaged in aluminum foil should not be placed
directly on the burner grate. Aluminum foil can melt
during cooking.
• DO NOT let plastic, paper, or cloth come in contact
with a hot burner grate. They may melt or catch fire.
• Professional quality pans with metal handles are
recommended because plastic handles can melt or
blister if the flame extends up the side of the pan.
• All cookware should have these characteristics: good
heat conductivity, good balance, correctly sized base
diameter, a heavy, flat base, and a proper fitting lid.
• For best cooking results, the flame should be
contained under the bottom of the pan.
• Aluminum and copper are pan materials that conduct
the heat quickly and evenly. These metals are
sometimes attached to the base or in the core
between stainless steel.
• A heavy, flat base is more apt to remain flat when
heated. Pan bases that are warped, dented, ridged or
too lightweight will heat unevenly. Heat and cool pans
gradually to avoid sudden temperature changes which
tend to distort cookware. DO NOT add cold water to
a hot pan.
• Select the base diameter to match the diameter of the
flame. The diameter of the flame should be the same
size as the pan base or slightly smaller. Oversize or
under size pans sacrifice cooking performance. A 5½''
(140 mm) base size is generally the smallest
recommended.
• Avoid using high flame setting with a pan larger than
the grate or with one that spans more than one
burner, such as a griddle, for prolonged periods of
time. This can result in poor combustion that
generates harmful by-products.
• Balance is important for stability and even cooking.
The handle must not be heavier than the pan and tilt it
unevenly. A pan must sit level on the grate without
rocking or wobbling.
• A properly fitting lid will shorten cooking time and
make it possible to use lower heat settings.
Page. 29
Loading...