Star TC2000 Parts Manual

TC2000 Parts
Electric (Domestic & Std. Export)

P/N 41587

Rev. B  V2  2/00

TC2000 Conveyor Toaster Oven

Models:

 TC200030
 TC200038

PARTS MANUAL

for domestic and standard export toaster ovens

TC2000

© 2000 Toastmaster, A Middleby Company.

is a registered trademark of Toastmaster, A Middleby Company. All rights reserved.

Middleby Cooking Systems Group  1400 Toastmaster Drive  Elgin, IL 60120  [phone]  FAX [phone]

1

TC2000

2

Body Panels and Legs - Parts Listing

ITEM P/N QTY. DESCRIPTION

1 36695 2 ADJUSTABLE HEAT CURTAIN

2 38251 2 EMITTER

3 38252 2 MICA INSULATION PANEL

4 36687 1 BOTTOM REFLECTOR PLATE (CENTER CRUMB TRAY)

5 7007413 3 SCREW, SHOULDER

6 3B20A8801 A/R SCREW, F HEX WSHR HD 8-32 X 3/8

7 21256-0008 4 SCREW, MS SLT TRS HD 10-32 X 3/8

8 2000096 4 SCREW, MS SLT TRS HD 8-32 X 1/4

9 B301A8803 6 SCREW, AB PHIL TRS HD 8-32 X 1/4

10 2000144 6 SCREW, MS PHIL PAN HD 8-32 X 3/4

11 2001347 6 NUT, KEPS 8-32

12 32123 4 ASSEMBLY, 4 (102mm) LEG

13 1523B8301 1 LEG, 4 (102mm)

14 31254 1 FOOT, RUBBER

TC2000

3

Components - Front

TC2000

Components - Rear

4

Components - Parts Listing

ITEM P/N QUANTITY DESCRIPTION

TC200030 TC200038

208V 240V

50/60 Hz, 1 Ph 50/60 Hz, 1 Ph

1 39403 2 -- HEATER ASSEMBLY, 208V/2500W

1 39459 -- 2 HEATER ASSEMBLY, 230V/2500W

2 30697 1 1 TRANSFORMER, 230V PRI/115V SEC

3 39358 2 2 TEMPERATURE CONTROLLER

4 3103116 A/R A/R NON-CONDUCTIVE SEALANT COMPOUND, 8 OZ.

5 3000639 1 1 CONTACTOR, 2-POLE 35A

6 2001371 A/R A/R NUT, KEPS 10-32

7 2000023 A/R A/R SCREW, MS SLT HEX WSHR HD 6-32 X 1/4

8 4111A8813 2 2 SCREW, SLT RND HD 10-32 X 1-1/4

9 39004 2 2 SCREW, T/S SHLDR THB 10-32 X 3/8

10 38079 1 1 TSTAT, SNAP DISC NO (CLOSE 120°F/49°C)

11 30519 1 1 TSTAT, SNAP DISC NC (OPEN 250°F/121°C)

12 27021-0013 1 1 FUSEBLOCK

13 28154-0009 2 2 FUSE, TYPE CC, 5A/600V

14 33406 1 1 TERMINAL BLOCK, 3-POLE

15 27276-0002 1 1 CABLE CLAMP, NYLON, 5/8

16 31791 1 1 CABLE CLAMP, 3/4

Not Shown:

-- 37350 1 1 CORD AND PLUG (NEMA 6-30P)

-- 39405 1 1 WIRESET, TC2000

TC2000

5

TC2000

6

Front Panel and Control Components - Parts Listing

ITEM P/N QTY. DESCRIPTION

1 3002808 1 CONVEYOR SPEED CONTROLLER

1a -- 1 GASKET (INC. WITH ITEM 1)

1b -- 1 WASHER (INC. WITH ITEM 1)

1c -- 1 HEX NUT (INC. WITH ITEM 1)

2 35824 1 POWER ON/OFF (I/O) SWITCH, DPST

3 39377 2 POTENTIOMETER, TEMPERATURE CONTROLLER

3a -- 1 WASHER (INC. WITH ITEM 3)

3b -- 1 HEX NUT (INC. WITH ITEM 3)

4 A5704 3 KNOB

5 38471 1 COOLING FAN

6 38276 1 COOLING FAN AIR DEFLECTOR

7 220282 4 SCREW, SLT TRS HD 10-32 X 1/2, BLACK

8 37647 1 COOLING FAN GRILL

9 2000096 2 SCREW, SLT TRS HD 10-32 X 3/8

10 39277 1 DECAL, CONTROL PANEL LEFT

11 39402 1 DECAL, CONTROL PANEL RIGHT

TC2000

7

TC2000

8

Conveyor System - Parts Listing

ITEM P/N QTY. DESCRIPTION

1 37309 1 CONVEYOR FRAME

2 36745 1 IDLER SHAFT

3 37314 1 DRIVE SHAFT

4 37950 8 SPROCKET W/SET SCREW

5 36729 2 IDLER BEARING BLOCK/TENSIONER

6 36733 2 DRIVE BEARING BLOCK

7 36742 4 BUSHING

8 3102930 1 RETAINING CLIP, E-RING, 5/16

9 38216 1 SPROCKET, DRIVE SHAFT, 10T W/SET SCREW

10 3002757 1 MOTOR, CONVEYOR DRIVE

11 31053 1 FUSE, 0.25A/125V

12 34129 1 SPROCKET, DRIVE MOTOR, 12T W/SET SCREW

13 39003 1 DRIVE CHAIN, #25, COMPLETE

14 3101212 1 MASTER LINK, #25

15 38247 1 CONVEYOR BELT, COMPLETE (7 FT./2.13m)

16 38246 3 MASTER LINK, CONVEYOR BELT

17 38257 2 END TRAY

18 36686 2 CRUMB TRAY

19 2000177 A/R SCREW, MS SLT HEX WSHR HD 10-32 X 1/4

20 35817 2 SCREW, TRS HD 10-32 X 5/8 SS

TC2000

9

Improper installation, adjustment, alteration, service or maintenance

can cause property damage, injury or death. Read the installation,

During the warranty period, ALL parts replacement and servicing should be performed by

TC2000

WARNING

operating and maintenance instructions thoroughly before

installing or servicing this equipment.

NOTICE

your Toastmaster Authorized Service Agent. Service that is performed by parties other

than your Toastmaster Authorized Service Agent may void your warranty.

NOTICE

Using any parts other than genuine Toastmaster factory manufactured parts relieves the

manufacturer of all warranty and liability.

NOTICE

Toastmaster reserves the right to change specifications at any time.

Middleby Cooking Systems Group  1400 Toastmaster Drive  Elgin, IL 60120  USA  [phone]  FAX [phone]

24-Hour Service Hotline: [phone]

www.middleby.com

10