Spalding M662034 User Manual
REQUIRED
MATERIALS:
•Two (2) Capable
Adults
•Wood Board
(scrap)
WARNING!
NOT SUITABLE FOR CHILDREN
UNDER THREE YEARS OF AGE
DUE TO SMALL
PARTS/CHOKING HAZARD.
•Sawhorse or
Support Table
•Garden Hose or Sand
SAND
SAND
(170 lb.)
(170 lb.)
(77 kg)
(77 kg)
• (2 each) Wrenches
and/or Socket
Wrenches and Sockets.
1/2" 9/16"
This manual, accompanied by sales receipt, should be saved and kept on hand as a
convenient reference, as it contains important information about your model.
Por table System
Owners Manual
Customer Service Center
• N53 W24700 South Corporate Circle • Sussex, WI 53089 • U.S.A.
AND/OR
1/2" 9/16"
OPTIONAL TOOLS
AND MA
• Large and Small
Adjustable W
© COPYRIGHT 2005 by SPALDING
TERIALS:
renches
WARNING!
READ AND UNDERSTAND
OPERATOR'S MANUAL
BEFORE USING THIS UNIT.
FAILURE TO FOLLOW
OPERATING INSTRUCTIONS
COULD RESULT IN INJURY
OR DAMAGE TO
PROPERTY.
Toll-Free Customer Service Number for U.S: 1-800-558-5234,
For Canada: 1-800-284-8339,
For Europe: 00 800 555 85234 (Sweden: 009 555 85234),
For Australia: 1-800-632 7921
Internet Address: http://www.huffysports.com
1
Write Model Number
From Box Here:
01/06 ID# M5800011
O
wner must ensure that all players know and follow these rules
for safe operation of the system.
WARNING
•
DO NOT HANG on the rim or any part of the system
including backboard, support braces or net.
•
During play, especially when performing dunk type
activities, keep player's face away from the
backboard, rim and net. Serious injury could occur if
teeth/face come in contact with backboard, rim or net.
•
Do not slide, climb, shake or play on base and/or
pole.
•
After assembly is complete, fill system completely
with water or sand. Never leave system in an upright
position without filling base with weight, as system
may tip over causing injuries.
•
When adjusting height or moving system, keep hands
and fingers away from moving parts.
•
Do not allow children to move or adjust system.
•
During play, do not wear jewelry (rings, watches,
necklaces, etc.). Objects may entangle in net.
•
Surface beneath the base must be smooth and free
of gravel or other sharp objects. Punctures cause
leakage and could cause system to tip over.
•
Keep organic material away from pole base. Grass,
litter, etc. could cause corrosion and/or deterioration.
•
Check pole system for signs of corrosion (rust,
pitting, chipping) and repaint with exterior enamel
paint. If rust has penetrated through the steel
anywhere, replace pole immediately.
•
Check system before each use for proper ballast,
loose hardware, excessive wear and signs of
corrosion and repair before use.
•
Check system before each use for instability.
•
Do not use system during windy and/or severe
weather conditions; system may tip over. Place
system in the storage position and/or in an area
protected from the wind and free from personal
property and/or overhead wires.
•
Never play on damaged equipment.
•
When moving system, use caution to keep
mechanism from shifting.
•
Keep pole top covered with cap at all times.
•
Do not allow water in tank to freeze. During subfreezing weather add 2 gallons of non-toxic
antifreeze, sand or empty tank completely and store.
(Do not use salt.)
•
While moving system, do not allow anyone to stand
or sit on base or have added ballasting on base.
•
Do not leave system unsupervised or play on system
when wheels are engaged for moving.
•
Use Caution when moving system across uneven
surfaces. System may tip over.
•
Use extreme caution if placing system on sloped
surface. System may tip over more easily.
•
See instruction manual for proper installation and
maintenance.
R
ead and understand warnings listed
below before using this product.
Failure to follow these warnings may
result in serious injury and/or property
damage.
ID#: 558200 05/05
MUNSELL NOTATION
Hue Value Chroma
5.0 YR 6.0/15
Equiv. CIE Data
(Y%) x y
30.05 0.5510 0.4214
Approx. PMS Color
13 parts yellow
3 parts Warm Red
1/4 part Black
Warning Area = Orange
Size = 4" x 6.5"
Corner Radius = 3/8"
Die Cut Label
3.25 Mil Vinyl
All Temp. Permanent Adhesive
1 Mil. Polypropolyne Overlaminate
Illustrator 8.0 = EPS
Backing + 1/16 Circumference
Rolls of 500
In the U.S.: 1-888-713-5488
In the U.S.: 1-800-558-5234
In Canada: 1-800-284-8339
In the U.S.: 1-800-334-9111
In the U.S.: 1-800-558-5234
In Canada: 1-800-284-8339
9-3/4" High
3" Wide
PMS 021 for Warning
558170 07/05
HEIGHT ADJUSTMENT
WARNING
Do not adjust height of system
in upright position. System must
be in down position to adjust
A
B
Rest unit on support table. Remove adjustment knobs (A)
and carriage bolts (B) to extend or retract backboard and rim.
Height adjustment from 4-1/2' - 6-1/2'.
WARNING
Backboard
may rotate during
height adjustment.
3-5/8" High
3" Wide
PMS 021 for Warning
ID# M5800011 01/06
23
2
SAFETY INSTRUCTIONS
FAILURE TO FOLLOW THESE SAFETY INSTRUCTIONS MAY RESULT IN SERIOUS INJURY OR
PROPERTY DAMAGE AND WILL VOID WARRANTY.
Owner must ensure that all players know and follow these rules for safe operation of the system.
o ensure safety, do not attempt to assemble this system without following the instructions carefully. Proper
T
and complete assembly, use, and supervision are essential for proper operation and to reduce the risk of
ccident or injury. A high probability of serious injury exists if this system is not installed, maintained, and
a
perated properly.
o
• If using a ladder during assembly, use extreme caution.
• Check base regularly for leakage. Slow leaks could cause the system to tip over
unexpectedly
• Seat the pole sections properly (if applicable). Failure to do so could allow the pole
sections to separate during play and/or during transport of the system.
• Climate, corrosion or misuse could result in system failure.
• If technical assistance is required, contact Customer Service.
• Minimum operational height is 4'-6" (1.37m) to the bottom of backboard.
Most injuries are caused by misuse and/or not following instructions.
Use caution when using this unit.
NOTICE TO ASSEMBLERS
Adult Assembly Required. Dispose of ALL packaging materials promptly. As with all children’s products,
periodically inspect for loose small parts.
Assembled unit MUST be filled with water at ALL times.
ALL basketball systems, including those used for DISPLAYS, MUST be assembled and ballasted with
sand or water according to instructions. Failure to follow instructions could result in SERIOUS INJUR
It is NOT acceptable to devise a makeshift weight system.
IMPORTANT!
Remove all contents from boxes.
Be sure to check inside pole sections;
hardware and additional parts are packed inside.
WARRANTY CARD:
Please remember to complete your product registration form either
on-line at:
www.huffysports.com/customer_support/product_registration
or mail-in the enclosed postcard.
Y.
3
01/06 ID# M5800011
Get to know the basic parts of your basketball system...
RIM
FRONT
TOP POLE
BACK
BACKBOARD
ELEVATOR
ASSEMBLY
MIDDLE POLE
BOTTOM POLE
BASE
STRUTS
ID# M5800011 01/06
4
Loading...