CFD-V30L
SERVICE MANUAL
Ver 1.0 1998. 06
SUPPLEMENT - 1
Fill this Supplement with the Service manual.
Subject :
r
EAST EUROPEAN AND RUSSIAN MODEL HAS
BEEN ADDED
r
CHANGE OF BOARDS
r
ELECTRICAL PARTS LIST
r
CORRECTION
r
EXPLODED VIEWS
r
EAST EUROPEAN AND RUSSIAN MODEL HAS BEEN ADDED
The East European and Russian model is approximately the same as the AEP model.
Only difference between AEP model and East European and Russian model are listed.
Refer to original service manual (9-923-174-11) previously issued for the other information.
• DIFFERENCE PARTS LIST
ACCESSORIES & PACKING MATERIALS
Page
43
AEP Model
Part No. Description Part No. Description
3-859-117-31 MANUAL, INSTRUCTION (ENGLISH,GERMAN) 3-859-117-71 MANUAL, INSTRUCTION (POLISH, RUSSIAN)
3-859-117-41 MANUAL, INSTRUCTION (FRENCH,SPANISH) 3-859-118-11 MANUAL, INSTRUCTION (CZECH, HUNGARIAN)
3-859-117-51 MANUAL, INSTRUCTION
(DUTCH,SWEDISH,PORTUGUESE)
East European and Russian Model
(SPM-97033)
AEP Model
r
CHANGE OF BOARDS
The main board, power board, BATT board, M/B SW board, REC SW board, MONO/ST SW board, and mega bass
board have been changed.
Printed wiring boards and schematic diagram of new type, and changed parts list are described in this Supplement-1.
Refer to original service manual (9-923-174-11) previously issued for the other information.
NEW TYPE IDENTIFICATION
– MAIN BOARD (Component side) –
– M/B SW BOARD –
(Component side)
1-665-557-
22
1-665-035-
– MEGA BASS BOARD –
(Component side)
1-665-556-
22
22
– POWER BOARD –
(Component side)
1-665-036-
– REC SW BOARD –
(Component side)
1-665-037-
22
22
– BATT BOARD –
(Component side)
1-665-038-
– MONO/ST SW BOARD –
(Component side)
1-665-555-
22
11
r
ELECTRICAL PARTS LIST
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
AC INLET (Service Manual See page 39)
Before Change After Change
Ref.No. Parts No. Description Parts No. Description Remark
! J901 1-540-009-11 INLET, AC (⁄ AC IN) 1-526-838-11 INLET, AC (⁄AC IN) Changed
LCD SW (Service Manual See page 39)
Before Change After Change
Ref.No. Parts No. Description Parts No. Description Remark
S801 1-572-200-11 SWITCH, KEYBOARD (^) 1-762-798-11 SWITCH, KEYBOARD (^) Changed
S802 1-572-200-11 SWITCH, KEYBOARD (p) 1-762-798-11 SWITCH, KEYBOARD (p) Changed
S803 1-572-200-11 SWITCH, KEYBOARD (=) 1-762-798-11 SWITCH, KEYBOARD (=) Changed
S804 1-572-200-11 SWITCH, KEYBOARD (+) 1-762-798-11 SWITCH, KEYBOARD (+) Changed
S851 1-572-200-11 SWITCH, KEYBOARD (PLAY MODE) 1-762-798-11 SWITCH, KEYBOARD (PLAY MODE) Changed
S852 1-572-200-11 SWITCH, KEYBOARD (DISPLAY ENTER) 1-762-798-11 SWITCH, KEYBOARD (DISPLAY/ENTER) Changed
R821 –––––––––– 1-249-401-11 CARBON 47 5% 1/4W Added
MAIN (Service Manual See page 39 to 41)
Before Change After Change
Ref.No. Parts No. Description Parts No. Description Remark
*A-3306-539-A MAIN BOARD, COMPLETE *A-3306-928-A MAIN BOARD, COMPLETE Changed
C21 1-162-205-31 CERAMIC 18PF 5% 50V 1-162-203-31 CERAMIC 15PF 5% 50V Changed
C308 1-126-233-11 ELECT 22uF 20% 50V –––––––––– Deleted
C343 –––––––––– 1-162-294-31 CERAMIC 0.001uF 10% 50V Added
C392 1-124-903-11 ELECT 1uF 20% 50V 1-126-961-11 ELECT 2.2uF 20% 50V Changed
C652 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C716 1-136-169-00 FILM 0.22uF 5% 50V 1-136-153-00 FILM 0.01uF 5% 50V Changed
C737 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C754 1-162-207-31 CERAMIC 22PF 5% 50V –––––––––– Deleted
C772 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C786 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C787 1-162-294-31 CERAMIC 0.001uF 10% 50V 1-162-306-11 CERAMIC 0.01uF 30% 16V Changed
C788 –––––––––– 1-161-494-00 CERAMIC 0.022uF 25V Added
C804 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C805 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C807 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C808 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C809 –––––––––– 1-162-306-11 CERAMIC 0.01uF 30% 16V Added
C810 –––––––––– 1-162-282-31 CERAMIC 100PF 10% 50V Added
C954 –––––––––– 1-161-020-11 CERAMIC 0.039uF 10% 16V Added
CN803 –––––––––– 1-691-583-11 PIN, CONNECTOR (PC BOARD) 12P Added
CN804 *1-691-584-11 PIN, CONNECTOR (PC BOARD) 13P 1-691-586-11 PIN, CONNECTOR (PC BOARD) 15P Changed
MAIN (Service Manual See page 41 to 42)
Before Change After Change
Ref.No. Parts No. Description Parts No. Description Remark
CT3-1 1-141-559-11 CAP, VAR 1-141-561-11 CAP, VAR Changed
CT3-2 1-141-559-11 CAP, VAR 1-141-561-11 CAP, VAR Changed
CT3-3 1-141-559-11 CAP, VAR 1-141-561-11 CAP, VAR Changed
CT3-4 1-141-559-11 CAP, VAR 1-141-561-11 CAP, VAR Changed
CV3-1 1-141-559-11 CAP, VAR (TUNE) 1-141-561-11 CAP, VAR (TUNE) Changed
CV3-2 1-141-559-11 CAP, VAR (TUNE) 1-141-561-11 CAP, VAR (TUNE) Changed
CV3-3 1-141-559-11 CAP, VAR (TUNE) 1-141-561-11 CAP, VAR (TUNE) Changed
CV3-4 1-141-559-11 CAP, VAR (TUNE) 1-141-561-11 CAP, VAR (TUNE) Changed
L4 1-406-040-00 COIL (OSC) 1-416-087-11 COIL (OSC) Changed
R11 1-249-425-11 CARBON 4.7K 5% 1/4W 1-247-843-11 CARBON 3.3K 5% 1/4W Changed
R12 1-249-425-11 CARBON 4.7K 5% 1/4W 1-247-843-11 CARBON 3.3K 5% 1/4W Changed
R150 1-249-425-11 CARBON 4.7K 5% 1/4W –––––––––– Deleted
R250 1-249-425-11 CARBON 4.7K 5% 1/4W –––––––––– Deleted
R305 1-249-407-11 CARBON 150 5% 1/4W 1-249-406-11 CARBON 120 5% 1/4W Changed
R386 –––––––––– 1-249-417-11 CARBON 1K 5% 1/4W Added
R774 1-249-417-11 CARBON 1K 5% 1/4W –––––––––– Deleted
R780 1-249-417-11 CARBON 1K 5% 1/4W –––––––––– Deleted
R793 1-249-417-11 CARBON 1K 5% 1/4W –––––––––– Deleted
R799 –––––––––– 1-249-417-11 CARBON 1K 5% 1/4W Added
R820 –––––––––– 1-249-417-11 CARBON 1K 5% 1/4W Added
R954 –––––––––– 1-249-421-11 CARBON 2.2K 5% 1/4W Added
MONO/ST SW (Service Manual See page 43)
Before Change After Change
Ref.No. Parts No. Description Parts No. Description Remark
*1-665-042-11 MONO ST/SW BOARD * 1-665-555-11 MONO ST/SW BOARD Changed
r
CORRECTION
MISCELLANEOUS (Service Manual See page 43)
Incorrect
Ref.No. Parts No. Description Parts No. Description
! T901 1-426-632-11 TRANSFORMER, POWER 1-427-943-11 TRANSFORMER, POWER
ACCESSORIES & PACKING MATERIALS
Page
Part No. Description Part No. Description
43 4-911-047-XX LID, BATTERY CASE (FOR RMT-CV30) 4-991-047-01 LID, BATTERY CASE (FOR RMT-CV30)
Incorrect
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
Correct
Correct
– 2 – – 4 –– 3 –
r
SCHEMATIC DIAGRAM – MAIN SECTION –
CFD-V30L
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/
specified.
¢
•
: internal component.
4
W or less unless otherwise
• 1 : fusible resistor.
Note: The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
• U : B+ Line.
• H : adjustment for repair.
• Power voltage is dc 9V and fed with regulated dc power
supply from battery terminal.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
no mark : FM (Radio section), CD STOP (CD section)
PLAY (Tape section)
( ) : AM (Radio section), REC (Tape section)
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Signal path.
F : FM E : PB
a : REC J : CD
– 9 – – 10 – – 12 –– 11 –
CFD-V30L
p
p
r
WAVEFORMS
(PLAY MODE)
1
r
SCHEMATIC DIAGRAM – CD SECTION –
4
IC701 #¡
(RFO)
2
IC702 @∞
(XPCK)
3
140.5
IC702 @•
(RFCK)
242.0 µsec
µ
sec
1.0 – 1.4
Vp-p
VOLT/DIV : 0.2V AC
TIME/DIV : 0.5µsec
4.8Vp-
VOLT/DIV : 1V AC
TIME/DIV : 0.1msec
5.3 Vp-p
VOLT/DIV : 1V AC
TIME/DIV : 50µsec
140.5
IC702 #¡
(MNT3)
5
140.5
IC702 #™
(MNT1)
6
16.9344 MHz
IC702 #∞
(XTAO)
5.3Vp-p
µ
sec
VOLT/DIV : 1V AC
TIME/DIV : 50µsec
5.3 Vp-p
µ
sec
VOLT/DIV : 1V AC
TIME/DIV : 50µsec
0.8 Vp-
VOLT/DIV : 0.2V AC
TIME/DIV : 50nsec
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/
specified.
Note: The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
• U : B+ Line.
• H : adjustment for repair.
• Power voltage is dc 9V and fed with regulated dc power
supply from battery terminal.
• Voltages and waveforms are dc with respect to ground
under no-signal conditions.
no mark : FM (Radio section), CD STOP (CD section)
( ) : AM (Radio section), REC (Tape section)
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
• Circled numbers refer to waveforms.
• Signal path.
J : CD
PLAY (Tape section)
4
W or less unless otherwise
– 15 – – 16 –– 13 – – 14 –
r
EXPLODED WIEWS (Service Manual See page 33 to 38)
NOTE :
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Color indication of Appearance Parts
Example :
KNOB, BALANCE (WHITE) ••• (RED)
↑↑
Parts color Cabinet's color
8-1. FRONT CABINET SECTION
#1
SP901
12
• Items marked “ * ”are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering
these items.
• The mechanical parts with no reference
number in the exploded views are not
supplied.
11
8
9
10
#1
not
supplied
8
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
#6
#6
#6
#6
LCD801
4
7
6
#1
#1
#6
5
3
2
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
1 X-3373-942-1 CABINET (FRONT) SUB ASSY
2 3-009-193-01 KNOB (VOL)
3 3-012-690-61 WINDOW (V30), TU
4 3-009-191-01 POINTER
5 3-009-190-01 KNOB (TU)
* 6 3-009-189-01 CHASSIS, TU
* 7 1-665-554-11 SW BOARD
8 4-951-620-01 SCREW (2.6X8), +BVTP
1
9 3-009-216-01 KNOB (MEGA BASS)
* 10 1-665-557-21 M/B SW BOARD
11 3-703-397-01 STOPPER, WIRING
12 3-014-933-01 SHEET (B), ADHESIVE
LCD801 1-801-639-11 DISPLAY PANEL, LIQUID CRYSTAL
SP901 1-505-531-11 SPEAKER (10cm) (L-CH)
SP902 1-505-531-11 SPEAKER (10cm) (R-CH)
#1
SP902
– 17 –
8-2. UPPER CABINET SECTION
59
58
60
61
62
63
64
69
53
52
78
57
#1
#1
56
55
#2
51
54
#1
76
65
66
67
S871
#1
77
#1
68
#1
79
72
70
76
72
80
74
73
71
#1
75
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
51 3-009-208-01 SPRING, CASSETTE UP
52 3-922-112-11 DAMPER
53 3-009-186-01 CABINET (UPPER)
54 3-009-209-01 SPRING, CD UP
55 3-019-395-01 PLATE, CHUCKING
56 1-452-899-11 MAGNET
57 3-009-187-01 LID, CD
58 X-3373-389-1 HOLDER SUB ASSY, CASSETTE
59 3-009-196-01 BUTTON (REC)
60 3-009-199-01 BUTTON (PLAY)
61 3-009-198-01 BUTTON (REW)
62 3-009-197-01 BUTTON (FF)
63 3-009-200-01 BUTTON (STOP)
64 3-009-195-01 BUTTON (PAUSE)
* 65 3-009-206-01 SHAFT (MD)
66 3-009-214-01 SPRING, REC
67 4-951-620-01 SCREW (2.6X8), +BVTP
* 68 1-665-037-21 REC SW BOARD
69 3-009-201-01 HANDLE
70 3-923-736-01 COVER, CD
71 3-910-095-31 RUBBER, VIBRATION PROOF (RED)
72 3-910-095-21 RUBBER, VIBRATION PROOF (GREEN)
73 1-777-955-11 WIRE (FLAT TYPE) (16 CORE)
74 1-639-678-12 CD MOTOR BOARD
* 75 1-665-555-11 MONO ST SW BOARD
76 3-831-441-11 CUSHION (F)
77 3-015-646-01 CUSHION (CD)
78 3-923-151-01 CUSHION, RUBBER
79 7-623-957-11 SPACER (PICK)
80 3-831-441-99 CUSHION, SPEAKER
S871 1-692-960-11 SWITCH, PUSH (1 KEY) (OPEN CLOSE)
– 18 –
8-3. REAR CABINET SECTION
ANT1
F902
not
supplied
107
T901
108
#1
#1
115
#1
105
109
#4
114
#1
104
106
111
112
not
supplied
113
#3
110
103
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
* 101 3-009-215-01 TERMINAL (ANALOG), ANTENNA
* 102 A-3306-928-A MAIN BOARD, COMPLETE
103 3-009-194-01 KNOB (FUN)
* 104 1-665-556-21 MEGA BASS BOARD
105 3-009-192-01 GEAR, TUNING CAPACITOR
106 3-013-805-51 CABINET (REAR)
107 1-533-233-31 HOLDER, FUSE
* 108 1-665-036-21 POWER BOARD
* 109 1-665-043-11 AC INLET BOARD
110 3-009-210-01 SPRING (+/–)
102
101
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
111 3-009-211-01 SPRING (–)
* 112 1-665-038-21 BATT BOARD
113 3-009-202-01 LID, BATTERY CASE
* 114 3-846-312-01 SPACER
115 3-703-397-01 STOPPER, WIRING
ANT1 1-501-883-11 ANTENNA, TELESCOPIC
! F902 1-532-286-00 FUSE TIME, LAG (T2.5AL/250V)
! T901 1-427-943-11 TRANSFORMER, POWER
– 19 –
8-4. MECHANISM DECK SECTION (1)
(MF-V10-117)
HRP901
159
155
153
157
154
158
HE901
169
156
151
168
160
167
161
162
170
163
164
165
166
152
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
151 3-933-010-01 SPRING (S/P), TORSION
152 3-933-025-01 SPRING (P), TORSION
153 3-933-026-01 LEVER (P)
154 3-933-024-01 ROLLER, PINCH
155 3-933-019-01 SPRING (F/R), TORSION
156 3-933-028-01 SPRING (FWD), TORSION
157 3-933-016-01 GEAR (S REEL)
158 3-008-590-01 SLIDER (REC)
159 3-008-592-01 BASE (H), HEAD
* 160 3-008-588-01 SLIDER (REW)
* 161 3-008-589-13 SLIDER (FF)
* 162 3-008-587-01 SLIDER
* 163 3-008-591-01 SLIDER (PAUSE)
164 3-933-004-01 CLAW, REEL
* 165 3-933-021-01 SLIDER (FRP)
* 166 3-933-006-01 SLIDER (EJECT)
167 3-934-833-01 SPRING (FRP)
168 3-934-834-01 SPRING (BT)
* 169 3-933-007-01 PLATE, LOCK
* 170 3-012-114-01 LEVER (FR)
HE901 1-543-876-11 HEAD (ERASE)
HRP901 1-500-454-11 HEAD,MAGNETIC (RECORD/PLAYBACK)
– 20 –
8-5. MECHANISM DECK SECTION (2)
(MF-V10-117)
207
M901
204
S901
203
206
205
218
208
220
209
210
219
211
212
213
217
214
215
202
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
201 3-933-029-01 LEVER, ERASING PREVENTION
202 3-933-182-01 SPRING, CASSETTE
203 3-932-995-01 GEAR (MID)
204 X-3371-667-1 CLUTCH ASSY
205 3-932-997-01 GEAR (CAM)
* 206 3-932-999-01 SLIDER (SW)
207 3-932-998-01 SPRING (GROUND), TORSION
208 3-009-648-01 LEVER (S.OFF)
209 3-936-438-01 LEVER (K)
210 X-3373-572-1 REEL ASSY (N), T
211 3-933-020-01 BELT
201
#7
216
212 X-3372-924-1 FLYWHEEL ASSY
213 3-932-993-01 CHASSIS, OUTSERT
214 3-343-358-01 RING, RETAINING
215 3-933-005-01 SPRING (CAM), COMPRESSION
216 3-016-349-01 WASHER
217 3-937-760-01 SPRING (GROUND), COMPRESSION
218 3-934-336-01 BEARING
219 3-939-383-02 SPRING, COMPRESSION
220 3-009-650-02 SPRING (K), COMPRESSION
M901 A-3320-446-A MOTOR ASSY
S901 1-762-679-11 SWITCH, LEAF (MOTOR ON/OFF)
– 21 –
CFD-V30L
8-6. OPTICAL PICK-UP SECTION
(KSM-213CDM)
253
254
255
#5
not supplied
252
M702
M701
251
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part number specified.
Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark
251 2-626-908-01 SHAFT, SLED
252 2-627-003-02 GEAR(B)(RP)
253 2-626-907-01 GEAR (A) (S)
! 254 8-848-483-05 OPTICAL PICK-UP KSS-213C
9-923-174-81
Sony Corporation
Personal A&V Products Company
– 22 –
255 X-2626-202-1 CHASSIS ASSY (MB) (RP), MOTOR
(INCLUDING M702) (SPINDLE)
M701 X-2625-769-1 GEAR ASSY(MB)(RP), MOTOR (SLED)
98F0212-1
Printed in Japan © 1998.6
Published by Quality Engineering Dept.
(Shibaura)
CFD-V30L
SERVICE MANUAL
Ver 1.0 1999.05
CORRECTION - 3
File this Correction with the Service Manual.
!
: indicates corrected portion
INCORRECT CORRECT
Page Ref. No. Part No. Description Part No. Description
41 IC704 8-759-426-44 IC SM5877AM 8-759-364-34 IC SM5877AM
#
AEP Model
(SPM-99020)
9-923-174-93
Sony Corporation
Personal Audio Company
Printed in Japan © 1999.5
99E0244-1
Published by General Engineering Dept.
Loading...