Samsung SGH-F210 Service Manual

GSM TELEPHONE

SGH-F210

GSM TELEPHONE

CONTENTS

Safety Precautions

1.

Specification

2.

Product Function

3.

Array course control

4.

Exploded View and Parts list

5.

MAIN Electrical Parts List

6.

Block Diagrams

7.

PCB Diagrams

8.

Chart of Troubleshooting

9.

Reference data

10.

Disassembly and Assembly

11. Instructions

GSPN(Global Service Partner Network)

Country Web Site

North America service.samsungportal.com

Latin America latin.samsungportal.com

CIS cis.samsungportal.com

Europe europe.samsungportal.com

China china.samsungportal.com

Asia asia.samsungportal.com

Mideast

This Service Manual isaproperty of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable International and/or domestic law.

Africa mea.samsungportal.com

&

Samsung Electronics Co.,Ltd.

ⓒ

2007. 09.

Rev.1.0

Safety Precautions

1.

Repair Precaution

1-1.

Repair in Shield Box, during detailed tuning.

●

Take specially care of tuning or test,

because specipicty of cellular phone is sensitive for surrounding interference(RF noise).

Be careful to useakind of magnetic object or tool,

●

because performance of parts is damaged by the influence of manetic force.

Surely useastandard screwdriver when you disassemble this product,

●

otherwise screw will be worn away.

Useathicken twisted wire when you measure level.

●

thicken twisted wire has low resistance, therefore error of measurement is few.

A

Repair after separate Test Pack and Set because for short danger(for example an

●

overcurrent and furious flames of parts etc) when you repair board in condition of

connecting Test Pack and tuning on.

Take specially care of soldering, because Land of PCB is small and weak in heat.

●

Surely tune on/off while using AC power plug, becausearepair of battery charger is

●

dangerous when tuning ON/OFF PBA and Connector after disassembing charger.

Don't use as you pleases after change other material than replacement registered on SEC

●

System.

Otherwise engineer in charge isn't charged with problem that you don't keep this rules.

1-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Safety Precautions

ESD(Electrostatically Sensitive D evices) Precaution

1-2.

Several semiconductor may be damaged easilly by static electricity. Such parts are called by

ESD(Electrostatically Sensitive Devices), for example IC,BGA chip etc. Read Precaution below.

You can prevent from ESD damage by static electricity.

Remove static electricity remained your body before you touch semiconductor or parts with

●

semiconductor. There are ways that you touch an earthed place or wear static electricity

prevention string on wrist.

Use earthed soldering steel when you connect or disconnect ESD.

●

Use soldering removing tool to break static electricity.,otherwise ESD will be damaged by

●

static electricity.

Don't unpack until you set up ESD on product. Because most of ESD are packed by box

●

and aluminum plate to have conductive power,they are prevented from static electricity.

You must maintain electric contact between ESD and place due to be set up until ESD is

●

connected completely to the proper place oracircuit board.

1-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Specification

2.

GSM General Specification

2-1.

E-GSM DCS1800 PCS1900

Freq. Band[MHz]

Uplink/Downlink

ARFCN range

Tx/Rx spacing 45MHz 95MHz 80MHz

Mod. Bit

rate/

Bit Period

Time Slot Period/Frame

Period

Modulation

MS Power

GPRS

EDGE

GPRS 0.3GMSK 0.3GMSK 0.3GMSK

EDGE 8PSK 8PSK 8PSK

GPRS 33dBm~5dBm 30dBm~0dBm 30dBm~0dBm

EDGE 26dbm~0dBm 26dBm~0dBm 26dBm~0dBm

880~915 925~960

975~1023

0~124

270.833Kbps

3.692us

812.5Kbps

3.692us

576.9us

4.615ms

1710~1785 1805~1880

512~885 512~810

270.833Kbps

3.692us

812.5Kbps

3.692us

576.9us

4.615ms

1850~1910 1930~1990

270.833Kbps

3.692us

812.5Kbps

3.692us

576.9us

4.615ms

Power Level

Sensitivity -102dBm -100dBm -102dBm

TDMAMux888

Cell Radius 35Km 2Km 2Km

Operating Temperature

Supply Voltage

Size and Weight

GPRS 5~19(class4) 0~15(

EDGE 8~19(class E2) 2~15(

-20℃~45

3.7V 3.7V 3.7V

Dimention

Weight

℃

:87.7(H)× 30.9(

: 81.2g (

2-1

-20℃~45

with standard battery and IF cover

class1)

class E2)

℃

W)

× 20.4(

0~15(

2~15(

-20℃~45

D) mm

class1)

class E2)

℃

)

Speclflcation

GSM Tx Power Class

2-2.

TX Power

control level

5 33±2

6 31±2

7 29±2

8 27±2

9 25±2

10 23±2

11 21±2

12 19±2

13 17±2

14 15±2

15 13±2

16 11±3

17 9±3

18 7±3

19 5±3

GSM900

dBm

TX Power

control level

0 30±3

1 28±3

2 26±3

3 24±3

4 22±3

5 20±3

6 18±3

7 16±3

8 14±3

9 12±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

DCS1800

dBm

TX Power

control level

0 30±3

1 28±3

2 26±3

3 24±3

4 22±3

5 20±3

6 18±3

7 16±3

8 14±3

9 12±4

10 10±4

11 8±4

12 6±4

13 4±4

14 2±5

P

CS1

900

dBm

15 0±5

2-2

dBm

15 0±5

dBm

Product Function

3.

Main Function

Camera and camcorder

-

Synchronisation with Windows Media Player

-

Music player

-

FM radio

-

Java

-

Offline mode

-

Bluetooth

-

Web browser

-

Multimedia Message Service(MMS)

-

3-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4.

Test Jig(GH80-03307A)

Test Cable(GH39-00501A)

RF Test Cable(GH39-00397A)

4-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Software Downloading

4-1.

•

4-2.

•

Downloading Binary Files

Three binary files for downloading F210

F210XXYY.s3:Main source code binary.

–

Pre-requsite for Downloading

Downloader Program(OptiFlash.exe

F210 Mobile Phone

Data Cable

Binary files

)

4-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

4-3.

1.

S/W Downloader Program

Load the binary download program by executing the“OptiFlash.exe

”

Select the“Options

2.

platform

”.

”->“

Choose hardware platform for the downloader file setting.

Settings

”->“

Generic

”->“

Specify hardware

Set the everything else as the default values which are shown b elow

4-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the COM port when the download cable is connected

3.

Up to twelve ports are supported. Additionally you can select the maximum transfer speed OptiFlash will use to communicate with the phone. However, OptiFlash will useaslower speed if either the PC’sor the phone’sserial hardware is incapable of handling the selected speed

4-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Select the“Flash&Verify

4.

”->“

Browse

”

Set the directory path and choose the latest s/w binary, for example

XC30XXYY.s3

“

for the downloader binary setting.

”,

Make sure that not to change the reserved memory regions.

In case of F200 the reserved regions are

x21fe0000

-0

:

x21ffffff

-0

4-5

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Array course control

Click“OK”button then press“Flash

5. Before pressing‘Flash’button, push the button

(

time.Then press‘Flash

Downloader will upload the binary file as below for the downloading.

’.)

”.

and‘END’at the same

‘*’

When downloading is finished successfully, there is

6.

message.

After finishing downloading, Certain memory resets should be done to

7.

guarantee the normal performance.

Confirm the downloaded version name and etc.

8.

Full Reset

*#1234#

:

*2767*3855#

:

All is well

a“

”

4-6

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5.

5-1.

QMW01

QFU01

QDC02

QME02

Cellular phone Exploded View

QVO01

QKP01

QME01

QCK01

QFR01



QMP01

QCH02

QCR10

QSH09

QME16

QLC02

QFL01

QCR05

QSC03

QSC02

QSC01

QCA01

QLC01

QAN02 QSP01

QMO01

QBL01

QCR05

QRF01

QCR05

QHI01



QIF01



QRE02

QCR08

QDC01

QBA00

5-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

5-2.

Cellular phone Parts list

Design LOC Discription SEC CODE

QAN02 INTENNA-SGH-F210 GH42-01304A

QBA00 BATTERY-750MAH,ME/BLU,ENG,M GH43-02922A

QBL01 PMO LOCKER-BATT GH72-39899D

QCA01 CAMERA MODULE GH59-04536A

QCH02 PMO-CAMERA HOUSING GH72-39898A

QCK01 PMO-KEY HOLD GH72-39902A

QCR05 SCREW-MACHINE

QCR08 SCREW-MACHINE

QCR10 SCREW-MACHINE

6001-001478

6001-001611

6001-001633

QDC02 ASSY DECO-WHEEL KEY GH98-05629A

QFR01 ASSY CASE-FRONT GH98-04982A

QFU01 ASSY CASE-SWING UPPER GH98-04981A

QKP01 ASSY KEYPAD-MAIN(XEN/RK) GH98-04985D

QLC01 LCD-MAIN GH07-00828A

QLC02 ELA UNIT-SGHF210 LCD MODULE,SV GH96-02842A

QME01 KEY FPCB-SGHF210 KEY FPCB GH59-04569A

QME02 KEY FPCB-WHEEL KEY,F210 GH59-04534A

QME16 FPC-CON TO CON,F210 GH41-01769A

QMO01 MOTOR DC-SGHF210 GH31-00355A

QMP01 PBA MAIN-SGHF210 GH92-03715A

QMW01 PMO COVER-MAINWINDOW GH72-42026A

QRE02 ASSY CASE-REAR GH98-04986D

QRF01 TAPE-SHEET RF GH74-32459D

QSC01 TAPE-SHEET SCREW CAP TOP GH74-32454A

QSC02 TAPE-SHEET SCREW CAP MID GH74-32455A

QSC03 TAPE-SHEET SCREW CAP BOT

L

GH74-32456A

QSH09 ASSY CASE-NAVIKEY SHIELD GH98-04983A

QSP01 SPEAKER

5-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

3001-002175

Exploded View and Parts List

QVO01 ASSY KEY-VOLUME GH98-06568A

QFL01 ASSY CASE-SWING LOWER GH98-04984A

QCR05 SCREW-MACHINE

6001-001478

QHI01 ASSY HINGE-FRONT GH98-05464A

QDC01 ASSY COVER-DECO GH98-06539A

QIF01 PMO COVER-IF GH72-42718D

5-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Exploded View and Parts List

Discription SEC CODE

BAG PE

6902-000297

CBF INTERFACE-MIC CABLE,BLK,S2 GH39-00727A

CBF INTERFACE-DATA LINK CABLE( GH39-00859B

ADAPTOR-ATADS10EBE,BLK,EU GH44-01702A

S/W CD-SAMSUNG PC STUDIO

3.1,F

GH46-00439A

EARPHONE-STEREO HEADSET,S20P,M GH59-02977A

LABEL(P)-UNIT SEAL GH68-00518B

LABEL(R)-WATER SOAK GH68-09361A

LABEL(R)-MAIN(EU) GH68-15849A

MANUAL USERS-EU GERMAN GH68-15984A

BOX(P)-UNIT MAIN(EU) GH69-05817A

CUSHION-CASE(EU) GH69-05819A

TAPE INSU GH74-18904A

MPR-TAPE LCD BTM MASKING GH74-22777A

MPR-TAPE MASKING LCD GH74-23786A

MPR-TAPE MASKING SM LCD GH74-24546A

SPONGE GH74-31970A

TAPE GASK GH74-33225A

VINYL-BOHO WINDOW GH74-33878A

5-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

MAIN Electrical Parts List

6.

SEC CODE Design LOC Discription STATUS

0403-001547

0404-001172

0406-001150

0406-001201

0406-001208

0406-001241

0406-001254

0406-001267

0801-002995

0801-003121

1001-001401

1001-001428

1009-001035

1107-001703

1108-000046

1201-002457

1203-003563

1203-004119

1203-004135

1203-004164

1203-004172

1203-004291

1203-004377

D507 DIODE-ZENER SA

D601 DIODE-ZENER SA

D701 DIODE-SCHOTTKY SA

V601 DIODE-TVS SA

VR604 DIODE-TVS SA

VR605 DIODE-TVS SA

VR607 DIODE-TVS SA

ZD604 DIODE-TVS SA

ZD603 DIODE-TVS SA

ZD605 DIODE-TVS SA

D505 DIODE-TVS SA

C610 DIODE-TVS SA

D503 DIODE-TVS SA

D504 DIODE-TVS SA

V402 DIODE-TVS SA

V403 DIODE-TVS SA

ZD401 DIODE-TVS SA

ZD501 DIODE-TVS SA

ZD502 DIODE-TVS SA

U302 IC-CMOS LOGIC SA

U706 IC-CMOS LOGIC SA

U202 IC-ANALOG SWITCH SA

U401 IC-ANALOG MULTIPLEX SA

U402 IC-ANALOG MULTIPLEX SA

U601 IC-HALL EFFECT S/W SA

UME202 IC-FLASH MEMORY SA

UME201 IC-MCP SA

U101 IC-POWER AMP SA

U712 IC-POSI.FIXED REG. SA

CPU301 IC-POWER SUPERVISOR SA

U707 IC-POSI.FIXED REG. SA

U701 IC-DC/DC CONVERTER SA

U705 IC-DC/DC CONVERTER SA

U708 IC-MULTI REG. SA

U702 IC-MULTI REG. SA

U704 IC-MULTI REG. SA

6-1

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription STATUS

1203-004416

1203-004518

1204-002746

1205-002272

1205-002942

1205-003093

1205-003227

1404-001165

1405-001082

1405-001108

2007-000138

2007-000139

2007-000148

2007-000157

2007-000161

2007-000162

2007-000170

2007-000171

U709 IC-DC/DC CONVERTER SA

U301 IC-BATTERY SA

U403 IC-TUNER SA

U203 IC-TRANSCEIVER SA

U103 IC-TRANSCEIVER SA

U102 IC-TRANSCEIVER SA

UCD401 IC-CODEC SA

TH301 THERMISTOR-NTC SA

V401 VARISTOR SA

V501 VARISTOR SA

VR608 VARISTOR SA

ZD601 VARISTOR SA

ZD602 VARISTOR SA

R534 R-CHIP SA

R224 R-CHIP SA

R225 R-CHIP SA

R201 R-CHIP SA

R202 R-CHIP SA

R214 R-CHIP SA

R231 R-CHIP SA

R714 R-CHIP SA

R716 R-CHIP SA

R222 R-CHIP SA

R423 R-CHIP SA

R624 R-CHIP SA

U711 R-CHIP SA

R322 R-CHIP SA

R315 R-CHIP SA

R320 R-CHIP SA

R321 R-CHIP SA

R119 R-CHIP SA

R514 R-CHIP SA

F601 R-CHIP SA

L105 R-CHIP SA

L402 R-CHIP SA

R101 R-CHIP SA

6-2

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription STATUS

2007-000171

2007-000172

2007-001290

2007-001313

2007-007132

2007-007136

2007-007142

2007-007308

2007-007313

2007-007314

2007-007528

2007-007588

2007-007590

2007-007698

2007-007798

2007-008044

R305 R-CHIP SA

R426 R-CHIP SA

R427 R-CHIP SA

R701 R-CHIP SA

R706 R-CHIP SA

R713 R-CHIP SA

R720 R-CHIP SA

R708 R-CHIP SA

R226 R-CHIP SA

R227 R-CHIP SA

R515 R-CHIP SA

R410 R-CHIP SA

R304 R-CHIP SA

R309 R-CHIP SA

R404 R-CHIP SA

R406 R-CHIP SA

R414 R-CHIP SA

R416 R-CHIP SA

R308 R-CHIP SA

R303 R-CHIP SA

R310 R-CHIP SA

R223 R-CHIP SA

R409 R-CHIP SA

R412 R-CHIP SA

R413 R-CHIP SA

R408 R-CHIP SA

R401 R-CHIP SA

R407 R-CHIP SA

R415 R-CHIP SA

R417 R-CHIP SA

R707 R-CHIP SA

R418 R-CHIP SA

R419 R-CHIP SA

R606 R-CHIP SA

R614 R-CHIP SA

R615 R-CHIP SA

6-3

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization

Main Electrical Parts List

SEC CODE Design LOC Discription STATUS

2007-008044

2007-008045

2007-008048

2007-008049

2007-008052

2007-008054

2007-008055

2007-008056

2007-008419

R616 R-CHIP SA

R617 R-CHIP SA

R618 R-CHIP SA

R633 R-CHIP SA

R634 R-CHIP SA

R635 R-CHIP SA

R636 R-CHIP SA

R637 R-CHIP SA

R638 R-CHIP SA

R639 R-CHIP SA

R640 R-CHIP SA

R641 R-CHIP SA

R217 R-CHIP SA

R111 R-CHIP SA

R613 R-CHIP SA

R607 R-CHIP SA

R608 R-CHIP SA

R609 R-CHIP SA

R611 R-CHIP SA

R612 R-CHIP SA

R411 R-CHIP SA

R216 R-CHIP SA

R220 R-CHIP SA

R312 R-CHIP SA

R313 R-CHIP SA

R502 R-CHIP SA

R503 R-CHIP SA

R504 R-CHIP SA

R516 R-CHIP SA

R702 R-CHIP SA

R709 R-CHIP SA

R712 R-CHIP SA

R104 R-CHIP SA

R507 R-CHIP SA

R508 R-CHIP SA

R509 R-CHIP SA

6-4

SAMSUNG Proprietary-Contents may change without notice

This Document can not be used without Samsung's authorization